2000-01 HONDA Insight

Honda Insight 2000 - BUZZERS, RELAYS & TIMERS

Honda Insight 2000 BUZZERS, RELAYS & TIMERS LOCATION

Component	Component Location
Blower Motor High Relay	Behind glove box. See Fig. 7 .
Daytime Running Lights Relay	Under left side of dash. See Fig. 8 .
EPS Motor Relay	Under right side of dash. See Fig. 6 .
Fan Control Relay	In multi-relay box.
Fuel Cut Relay	In multi-relay box.
Hatch Opener Relay	Below left taillight.
High Speed Battery Module Fan Control Relay	On junction board. See Fig. 5 .
High Speed Motor Power Inverter Module Fan Control Relay	Left side of intelligent power unit compartment. See Fig. 3 .
High Voltage Contactor Control Relay	Left side of intelligent power unit compartment. See Fig. 3 .
Ignition Hold Relay	Left side of intelligent power unit compartment. See Fig. 3 .
Low Beam Cut Relay	Under left side of dash. See Fig. 8 .
Low Speed Battery Module Fan Control Relay	On junction board. See Fig. 5 .
Low Speed Motor Power Inverter Module Fan Control Relay	Left side of intelligent power unit compartment. See Fig. 3 .
PGM-FI Main Relay	Under left side of dash.
Power Window Relay	In underdash fuse/relay box. See Fig. 8 .
Rear Window Defogger Relay	In multi-relay box.
Starter Cut Relay	In underdash fuse/relay box. See Fig. 8 .
Taillight Relay	In underdash fuse/relay box. See Fig. 8 .
Turn Signal/Hazard Relay	In underdash fuse/relay box. See Fig. 8 .
Windshield Wiper Intermittent Relay	In multi-relay box.

Honda Insight 2000 - CIRCUIT PROTECTION DEVICES

Honda Insight 2000 CIRCUIT PROTECTION DEVICES LOCATION

Component	Component Location
Battery Module Fuse	On junction board. See Fig. 5 .
Multi-Relay Box	Left side of engine compartment.
Underdash Fuse/Relay Box	At left end of dash. See Fig. 8 .
Underhood Fuse/Relay Box	Left side of engine compartment.

Honda Insight 2000 - CONTROL UNITS

Honda Insight 2000 CONTROL UNITS LOCATION

Component	Component Location
Audio Unit	Behind radio. See Fig. 7 .
Battery Condition Monitor (BCM) Module	In middle of intelligent power unit compartment. See Fig. 3 .
Battery Module	Right side of intelligent power unit compartment. See Fig. 3 .
Daytime Running Lights Control Unit	Under left side of dash. See Fig. 8 .
ECM	On right side of floor. See Fig. 1 .
ELD Unit	In underhood fuse/relay box.
EPS Control Unit	Under right side of dash. See Fig. 6 .
Immobilizer Receiver Unit	In steering column. See Fig. 8 .
Intelligent Power Unit (IPU)	Rear of vehicle, under mid-frame cover.
Keyless Door Lock Control Unit	Under left side of dash. See Fig. 8 .
Motor Control Module (MCM)	Right side of intelligent power unit compartment. See Fig. 3 .
Motor Drive Module (MDM)	In power control unit. See Fig. 4 .
Motor Power Inverter (MPI) Module	In power control unit. See Fig. 4 .
Power Control Unit (PCU)	Left front side of intelligent power unit compartment. See Fig. 3 .
SRS Unit	Under middle of dash.
Voltage Converter Module	In power control unit. See Fig. 4 .

Honda Insight 2000 - SENDING UNITS & SENSORS

Honda Insight 2000 SENDING UNITS & SENSORS LOCATION

Component	Component Location
ABS Wheel Speed Sensor (Left Front)	At left front wheel.
ABS Wheel Speed Sensor (Left Rear)	At left rear wheel.
ABS Wheel Speed Sensor (Right Front)	At right front wheel.
ABS Wheel Speed Sensor (Right Rear)	At right rear wheel.
Ambient Temperature Sensor	Front center of vehicle.
Battery Current Sensor	On junction board. See Fig. 5 .
Brake Vacuum Sensor	On left rear of engine compartment. See Fig. 6 .
CKP Sensor	On lower right front of engine. See Fig. 1 .
Engine Coolant Temperature (ECT) Sensor	On rear of engine. See Fig. 1 .
EPS Torque Sensor	Left side of engine compartment. See Fig. 6 .
Evaporator Temperature Sensor	Behind glove box. See Fig. 7 .
Fuel Pump/Sending Unit	Left side of fuel tank.
Fuel Tank Pressure Sensor	Right side of fuel tank.
Heater Core Temperature Sensor	Behind center lower cover.
In-Car Temperature Sensor	Under center of dash.
Intake Air Temperature (IAT) Sensor	On air intake hose. See Fig. 1 .
Knock Sensor	On left side of engine. See Fig. 1 .
MAP Sensor	On left rear of engine. See Fig. 1 .
Motor Communication Sensor	On lower right rear of engine. See Fig. 2 .
Motor Power Inverter (MPI) Module Current Sensor	On junction board. See Fig. 5 .
Neutral Position Switch	On transaxle housing. See Fig. 1 .
Outside Air Temperature Sensor	Behind center of bumper.
Primary Heated Oxygen Sensor	In exhaust, before catalytic converter. See Fig. 1 .
Secondary Heated Oxygen Sensor	In exhaust, after catalytic converter. See Fig. 1 .
Sunlight Sensor	On top center of dash.
TDC Sensor 1	On left rear of engine. See Fig. 1 .
TDC Sensor 2	On right rear of engine. See Fig. 1 .
Throttle Position (TP) Sensor	On throttle body. See Fig. 1 .
U Phase Motor Current Sensor	In power control unit. See Fig. 4 .
Vehicle Speed Sensor (VSS)	On left side of engine compartment. See Fig. 1 .
V Phase Motor Current Sensor	In power control unit. See Fig. 4 .
W Phase Motor Current Sensor	In power control unit. See Fig. 4 .

Honda Insight 2000 - MOTORS

Honda Insight 2000 MOTORS LOCATION

Component	Component Location
Air Mix Control Motor	Behind glove box. See Fig. 7 .
Battery Module Fan	Right side of intelligent power unit compartment. See Fig. 3 .
Blower Motor	Behind glove box. See Fig. 7 .
EPS Motor	Left side of engine compartment. See Fig. 6 .
Fuel Pump/Sending Unit	Left side of fuel tank.
Mode Control Motor	Under center of dash.
Motor Power Inverter Module Fan	Left side of intelligent power unit compartment. See Fig. 3 .
Radiator Fan Motor	Front center of engine compartment.
Rear Window Washer Motor	Right front of engine compartment.
Rear Window Wiper Motor	Right side of hatch.
Recirculation Control Motor	Behind glove box. See Fig. 7 .
Windshield Washer Motor	Right front of engine compartment.
Windshield Wiper Motor	Right side of engine compartment. See Fig. 6 .

Honda Insight 2000 - SOLENOIDS & SOLENOID VALVES

Honda Insight 2000 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Component Location
ABS Modulator Assembly	On right front of engine compartment.
EVAP Emission By-Pass Solenoid Valve	Right side of fuel tank.
EVAP Emission Control Canister Vent Shutoff Valve	Right side of fuel tank.
EVAP Purge Control Solenoid Valve	On left rear of engine. See Fig. 1 .
Exhaust Gas Recirculation (EGR) Valve	On left rear of engine. See Fig. 1 .
Fuel Injector No. 1	On left side of engine. See Fig. 1 .
Fuel Injector No. 2	On left side of engine. See Fig. 1 .
Fuel Injector No. 3	On left side of engine. See Fig. 1 .
Idle Air Control (IAC) Valve	On left side of engine. See Fig. 1 .
Starter Solenoid	On starter motor. See Fig. 1 .
VTEC Solenoid Valve	On left side of engine. See Fig. 1 .

Honda Insight 2000 - SWITCHES

Honda Insight 2000 SWITCHES LOCATION

Component	Component Location
A/C Pressure Switch	Right rear of engine compartment.
Back-Up Lights Switch	On transaxle housing. See Fig. 1 .
Battery Module Switch	Under small cover, on intelligent power unit lid. See Fig. 5 .
Brake Fluid Level Switch	On master cylinder reservoir. See Fig. 6 .
Brake Switch	Under left side of dash. See Fig. 8 .
Clutch Switch	Under left side of dash. See Fig. 8 .
Driver's Seat Belt Switch	Under driver's seat.
Engine Oil Pressure Switch	On lower left side of engine. See Fig. 1 .
Parking Brake Switch	At base of parking brake lever.
Radiator Fan Switch	On front of engine compartment. See Fig. 1 .
VTEC Pressure Switch	On left side of engine. See Fig. 1 .

Honda Insight 2000 - MISCELLANEOUS

Honda Insight 2000 MISCELLANEOUS LOCATION

Component	Component Location
A/C Diode	Under left side of dash.
Battery Module Fan Resistor	On junction board. See Fig. 5 .
By-Pass Contactor	On junction board. See Fig. 5 .
Data Link Connector (DLC)	Behind center of dash. See Fig. 8 .
DC-DC Converter	In power control unit. See Fig. 4 .
High Voltage Contactor	On junction board. See Fig. 5 .
Ignition Coil No. 1	On top center of engine. See Fig. 1 .
Ignition Coil No. 2	On top center of engine. See Fig. 1 .
Ignition Coil No. 3	On top center of engine. See Fig. 1 .
Intelligent Power Unit (IPU) Compartment	Rear of vehicle, under mid-frame cover. See Fig. 3 .
Junction Board	Center of intelligent power unit compartment. See Fig. 3 .
Junction Connector C104	At top rear of engine. See Fig. 1 .
Junction Connector C105	At right side of floor. See Fig. 1 .
Junction Connector C107	Under middle of dash.
Junction Connector C108	Under middle of dash.
Junction Connector C507	Behind rear seats, at middle of floor.
Junction Connector C508	Behind rear seats, at middle of floor.
Junction Connector C571	Under left side of dash.
Memory Erase Signal (MES) Connector	In underdash fuse/relay box.
Motor Power Inverter Module Fan Control Resistors	Left side of intelligent power unit compartment. See Fig. 3 .
Motor Rotor	On rear of engine, in bellhousing. See Fig. 2 .
Motor Stator	On rear of engine, in bellhousing. See Fig. 2 .
Power Transistor	Behind glove box. See Fig. 7 .
Seat Belt Tensioner (Left)	At base of left "B" pillar.
Seat Belt Tensioner (Right)	At base of right "B" pillar.
Test Tachometer Connector	Left side of engine compartment. See Fig. 6 .
Y Condenser	On junction board. See Fig. 5 .

Honda Insight 2000 - CONNECTORS

Honda Insight 2000 CONNECTORS LOCATION

Component	Component Location
C101 (M/T) (Gray, 4-Pin)	Under middle of dash.
C101 (CVT) (Gray, 8-Pin)	Under middle of dash.
C102 (Light Blue, 16-Pin)	Under middle of dash. See Fig. 1 .
C103 (Light Blue, 24-Pin)	Under middle of dash. See Fig. 1 .
C106 (Light Blue, 6-Pin)	Behind center lower cover. See Fig. 1 .
C109 (CVT) (Gray, 8-Pin)	On transaxle housing.
C401 (Brown, 3-Pin)	Under left side of dash. See Fig. 8 .
C402 (Gray, 14-Pin)	Under left side of dash. See Fig. 8 .
C403 (Light Blue, 16-Pin)	Under left side of dash. See Fig. 8 .
C404 (Light Blue, 24-Pin)	Under left side of dash. See Fig. 8 .
C405 (Gray, 14-Pin)	Under left side of dash. See Fig. 8 .
C406 (Gray, 4-Pin)	Under left side of dash. See Fig. 8 .
C407 (Gray, 16-Pin)	Behind top of left kick panel.
C408 (Light Blue, 16-Pin)	Behind center lower cover. See Fig. 7 .
C409 (Gray, 12-Pin)	Behind right side of dash. See Fig. 7 .
C410 (Gray, 10-Pin)	Behind center lower cover.
C451 (Brown, 1-Pin)	Under left side of dash.
C452 (Gray, 16-Pin)	Under left side of dash. See Fig. 8 .
C501 (Light Blue, 16-Pin)	Under middle of dash.
C502 (Blue, 24-Pin)	Behind center lower cover. See Fig. 8 .
C503 (Blue, 2-Pin)	Behind center lower cover.
C504 (Blue, 16-Pin)	Behind center lower cover.
C505 (Light Blue, 24-Pin)	Behind rear seats, at middle of floor.
C506 (Gray, 12-Pin)	Behind rear seats, at middle of floor.
C531 (Light Blue, 16-Pin)	Under left side of dash.
C551 (Gray, 10-Pin)	At right front side of power control unit.
C552 (Light Blue, 24-Pin)	At right front side of power control unit.
C601 (Gray, 14-Pin)	At left "B" pillar.
C602 (Gray, 2-Pin)	At middle rear of cargo area.
C701 (Light Blue, 6-Pin)	At right "B" pillar.
C702 (Brown, 1-Pin)	At right "B" pillar.
C703 (White, 2-Pin)	At left side of hatch.

Honda Insight 2000 - GROUNDS

Honda Insight 2000 GROUNDS LOCATION

Component	Component Location
G1	At middle rear of engine compartment. See Fig. 1 .
G2	At left side of engine compartment. See Fig. 1 .
G3	At left side of engine compartment. See Fig. 1 .
G4	At left side of engine compartment. See Fig. 1 .
G101	At top rear of engine. See Fig. 1 .
G102	At top rear of engine.
G201	Above left front wheelwell. See Fig. 1 .
G301	Above right front wheelwell. See Fig. 1 .
G401	Behind top of left kick panel. See Fig. 8 .
G402	Behind left side of dash. See Fig. 8 .
G403	Behind middle of dash. See Fig. 8 .
G404	Behind right side of dash. See Fig. 7 .
G451	Behind right kick panel. See Fig. 6 .
G501	Under SRS unit, at front of center console.
G502	Behind rear seats, at middle of floor.
G601	At middle rear of cargo area.
G651	At left rear side of floor.
G701	At middle rear of roof. See Fig. 6 .