2001 DAIMLERCHRYSLER PT Cruiser

Chrysler PT Cruiser 2001 - BUZZERS, RELAYS & TIMERS

Chrysler PT Cruiser 2001 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
A/C Compressor Clutch Relay	In power distribution center.
Automatic Shut Down Relay	In power distribution center.
Engine Starter Motor Relay	In power distribution center.
Fuel Pump Relay	In power distribution center.
Headlight Relay	On fuse block.
High Speed Radiator Fan Relay	In power distribution center.
Horn Relay	In power distribution center.
Low Speed Radiator Fan Relay	In power distribution center.
Transmission Control Relay	In power distribution center.

Chrysler PT Cruiser 2001 - CIRCUIT PROTECTION DEVICES

Chrysler PT Cruiser 2001 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Fuse Block	At lower left front of dash. See Fig. 4 .
Power Distribution Center	On left side of engine compartment. See Fig. 3 .

Chrysler PT Cruiser 2001 - CONTROL UNITS

Chrysler PT Cruiser 2001 CONTROL UNITS LOCATION

Component	Location
Controller Anti-Lock Brake	At left side of engine compartment, on bottom of hydraulic control unit. See Fig. 3 .
Left Side Impact Air Bag Control Module	At base of left "B" pillar.
Occupant Restraint Controller	On tunnel floor pan, between shifter & parking brake.
Powertrain Control Module	On firewall, behind power distribution center. See Fig. 3 .
Remote Keyless Entry Module	Behind upper center of dash.
Right Side Impact Air Bag Control Module	At base of right "B" pillar.
Sentry Key Immobilizer Module	On steering column, near ignition lock cylinder. See Fig. 4 .
Sunroof Control Module	On right side of sunroof assembly.
Transmission Control Module	At left front of engine compartment.

Chrysler PT Cruiser 2001 - MOTORS

Chrysler PT Cruiser 2001 MOTORS LOCATION

Component	Location
Blower Motor	On bottom right side of heater-A/C unit housing.
Front Washer Pump Motor	On washer reservoir.
Front Wiper Motor	On center of firewall.
Fuel Pump Module	On fuel tank.
Idle Air Control Motor	On side of throttle body. See Fig. 1 .
Power Sunroof Module	At rear of sun roof frame.
Radiator Fan Motor	At front of engine compartment. See Fig. 3 .
Rear Wiper Motor	On center of liftgate.

Chrysler PT Cruiser 2001 - SENDING UNITS & SENSORS

Chrysler PT Cruiser 2001 SENDING UNITS & SENSORS LOCATION

Component	Location
Ambient Temperature Sensor	In front of A/C condenser, behind radiator grille. See Fig. 3 .
Camshaft Position Sensor	On rear of cylinder head. See Fig. 1 .
Crankshaft Position Sensor	On engine block, near oil filter. See Fig. 1 .
Engine Coolant Temperature Sensor	At front of cylinder head.
Front Wheel Speed Sensor (2) (Left/Right)	On respective steering knuckle boss.
Inlet Air Temperature Sensor	In air inlet tube. See Fig. 1 .
Input Speed Sensor (A/T)	On left side of transaxle. See Fig. 2 .
Knock Sensor	On left side of cylinder block. See Fig. 2 .
Manifold Absolute Pressure Sensor	On front of intake manifold. See Fig. 1 .
Output Speed Sensor (A/T)	On left side of transaxle. See Fig. 2 .
Oxygen Sensor 1/1 (Upstream)	In exhaust manifold. See Fig. 1 .
Oxygen Sensor 1/2 (Downstream)	In exhaust pipe, behind catalytic converter. See Fig. 1 .
Rear Wheel Speed Sensor (2) (Left/Right)	On respective rear disc brake adapter.
Throttle Position Sensor	On throttle body. See Fig. 1 .
Transmission Range Sensor (A/T)	In transaxle, on top of valve body. See Fig. 2 .
Vehicle Speed Sensor (M/T)	On right rear side of transaxle.

Chrysler PT Cruiser 2001 - SOLENOIDS & SOLENOID VALVES

Chrysler PT Cruiser 2001 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
A/C Compressor Clutch	On A/C compressor. See Fig. 2 .
Brake Transmission Shift Interlock Solenoid	Below steering column. See Fig. 4 .
EGR Solenoid	On top right rear of cylinder head. See Fig. 1 .
EVAP Purge Solenoid	At lower right rear of engine compartment. See Fig. 3 .
Leak Detection Pump	Under rear of vehicle, near EVAP canister.
Speed Control Servo	At right rear corner of engine compartment. See Fig. 3 .
Transmission Solenoid/Pressure Switch Assembly (A/T)	On lower left side of transaxle. See Fig. 2 .

Chrysler PT Cruiser 2001 - SWITCHES

Chrysler PT Cruiser 2001 SWITCHES LOCATION

Component	Location
A/C Low Pressure Switch	At right rear corner of engine compartment, on A/C accumulator. See Fig. 3 .
A/C Pressure Transducer	On back cover of A/C compressor. See Fig. 2 .
Back-Up Light Switch (M/T)	On left side of transaxle.
Brake Warning Indicator Switch	At left rear of engine compartment. See Fig. 3 .
Clutch Pedal Position Switch (Up)	On clutch/brake pedal bracket.
Engine Oil Pressure Switch	On right rear side of engine block. See Fig. 1 .
Hood Ajar Switch	At left rear side of engine compartment. See Fig. 3 .
Multi-Function Switch	At top of steering column. See Fig. 4 .
Parking Brake Switch	At base of park brake lever.
Power Steering Pressure Switch	On power steering gear. See Fig. 3 .
Stoplight Switch	On brake pedal bracket.
Transmission Solenoid/Pressure Switch Assembly (A/T)	On lower left side of transaxle. See Fig. 2 .

Chrysler PT Cruiser 2001 - MISCELLANEOUS

Chrysler PT Cruiser 2001 MISCELLANEOUS LOCATION

Component	Location
Blower Motor Resistor Block	On right side of firewall, below base of windshield.
Data Link Connector (DLC)	Under left side of dash, near kick panel.
Ignition Coil	On valve cover. See Fig. 1 .
Noise Suppressor	On top right rear of engine. See Fig. 1 .

Chrysler PT Cruiser 2001 - CONNECTORS

Chrysler PT Cruiser 2001 CONNECTORS LOCATION

Component	Location
C101 (Black, 14 Pin)	At left front side of engine compartment. See Fig. 3 .
C102 (Light Gray, 14 Pin)	At left front side of engine compartment. See Fig. 3 .
C103 (Dark Gray, 8 Pin)	On left side of engine. See Fig. 2 .
C104 (Dark Gray, 14 Pin)	At left front side of engine compartment.
C105 (White, 26 Pin)	Behind left side of dash.
C106 (Gray, 26 Pin)	Behind left side of dash.
C107 (Black, 4 Pin)	At left front of vehicle.
C108 (Black, 4 Pin)	At right front of vehicle.
C109 (Black, 4 Pin)	At lower right front of engine compartment.
C110 (Black, 10 Pin)	At lower right front of engine compartment.
C111 (Light Gray, 14 Pin)	On right side of engine.
C112 (Black, 14 Pin)	On right side of engine.
C114 (Dark Gray, 14 Pin)	On right side of engine.
C200 (Black, 8 Pin)	Behind left side of dash.
C201 (Black, 8 Pin)	Behind right side of dash.
C202 (White, 26 Pin)	At left kick panel.
C203 (Green, 20 Pin)	At lower right kick panel.
C204 (White, 16 Pin)	Behind left side of dash.
C205 (White, 16 Pin)	At upper right kick panel.
C206 (Black, 3 Pin)	Below driver's seat.
C207 (Red, 6 Pin)	Behind right side of dash.
C208 (Red, 6 Pin)	Behind left side of dash.
C209 (Black, 2 Pin)	Behind right side of dash.
C210 (Black, 3 Pin)	Below driver's seat.
C211 (White, 6 Pin)	Below driver's seat.
C212 (Black, 16 Pin)	Near fuse block.
C213 (Black, 16 Pin)	At front of right front door.
C300 (Black, 4 Pin)	At left "B" pillar.
C301 (Black, 4 Pin)	At right "B" pillar.
C302 (White, 12 Pin)	At top left of liftgate.
C303 (Dark Gray, 4 Pin)	At left rear quarter panel.
C304 (Black, 10 Pin)	At fuel tank.
C305 (Yellow, 2 Pin) (Driver's Side)	At left rear of console.
C305 (Yellow, 4 Pin) (Passenger's Side)	At left rear of console.
C306 (Yellow, 2 Pin) (Driver's Side)	At left rear of console.
C306 (Yellow, 4 Pin) (Passenger's Side)	At left rear of console.

Chrysler PT Cruiser 2001 - GROUNDS

Chrysler PT Cruiser 2001 GROUNDS LOCATION

Component	Location
G100	At left side of engine compartment.
G101	At battery tray.
G102	At left front strut tower. See Fig. 3 .
G103	At left front strut tower. See Fig. 3 .
G104	At front of right front fender.
G105	At left front inner fender.
G106	In breakout for powertrain control module.
G200	Behind center of dash.
G201	Behind center of dash.
G202	At left kick panel, near breakout for air bag control module.
G203	Behind center of dash.
G204	At left kick panel.
G300	At left rear quarter panel.
G301	At right rear quarter panel.
G302	At upper left rear of cargo area.
G303	On left "B" pillar.
G304	On lower right "B" pillar.

Chrysler PT Cruiser 2001 - SPLICES

Chrysler PT Cruiser 2001 SPLICES LOCATION

Component	Location
S100	Near breakout for fuel injectors.
S101	Near engine starter eyelet.
S102	Near breakout for in-line connector, on left side of engine. See Fig. 2 .
S103	Near breakout for powertrain control module. See Fig. 1 .
S104	Near breakout for engine starter. See Fig. 2 .
S105	Near breakout for powertrain control module. See Fig. 1 .
S106	Near breakout for camshaft position sensor. See Fig. 1 .
S107	Near breakout for in-line connector, at left side of engine. See Fig. 2 .
S108	Near breakout for EGR solenoid. See Fig. 1 .
S109	Near breakout for engine oil switch. See Fig. 1 .
S110	Near breakout for inlet air temperature sensor. See Fig. 1 .
S111 (A/T)	Near breakout for input speed sensor. See Fig. 2 .
S111 (M/T)	Near breakout for back-up light switch.
S112	Near breakout for powertrain control module. See Fig. 1 .
S113	Near breakout at left front strut tower. See Fig. 3 .
S114	At breakout on left side of engine compartment. See Fig. 2 .
S115	Near breakout at left front strut tower. See Fig. 3 .
S116	Near breakout at left front strut tower. See Fig. 3 .
S117	Near breakout for radiator fan motor.
S118	Near breakout for transmission control module.
S119	Near breakout for controller anti-lock brake.
S120	Near breakout for right headlight assembly. See Fig. 3 .
S121	Near breakout for speed control servo.
S123	Inside power distribution center.
S124	Inside power distribution center.
S125	Inside power distribution center.
S126	Near data link connector.
S127	Near brakelight switch.
S128	Near breakout for powertrain control module. See Fig. 3 .
S129	Near breakout for powertrain control module. See Fig. 3 .
S130	Near breakout for powertrain control module. See Fig. 3 .
S131	Near breakout for powertrain control module. See Fig. 3 .
S132	Near breakout for right front foglight. See Fig. 3 .
S133	Inside power distribution center.
S134	Near breakout for left foglight.
S135	At left front side of engine compartment. See Fig. 3 .
S136	Near breakout for transmission control module. See Fig. 3 .
S137	Near breakout for transmission control module.
S138	Near breakout for siren.
S139	Near breakout for left foglight.
S140	Near breakout at left front strut tower. See Fig. 3 .
S141	Near breakout for EVAP purge solenoid. See Fig. 3 .
S142	Near breakout for radiator fan motor.
S144	Near breakout for low beam headlight.
S145	Near breakout for powertrain control module. See Fig. 3 .
S146	Near breakout for left headlight assembly. See Fig. 3 .
S200	Near breakout for A/C-heater control switch.
S201	Near breakout for brake transmission shift interlock solenoid. See Fig. 4 .
S202	Near breakout for brake transmission shift interlock solenoid. See Fig. 4 .
S203	Near right turn signal indicator.
S204	Near breakout for A/C-heater control module.
S205	Near breakout for rear window defogger switch.
S206	Near breakout for instrument cluster. See Fig. 4 .
S207	Between breakout for cigar lighter & parking brake switch.
S208	Near breakout for passenger's air bag.
S209	Near breakout for rear window defogger & rear wiper switches.
S210	Near breakout for in-line connector for right front door.
S211	Near breakout for front wiper/washer switch.
S212	Near breakout for instrument cluster. See Fig. 4 .
S213	Near breakout for rear window defogger & rear wiper switches.
S214	Near breakout for instrument cluster. See Fig. 4 .
S216	In breakout for radio.
S217	In breakout, behind left side of dash.
S220	Near breakout for brake transmission shift interlock solenoid.
S221	Near breakout for passenger's air bag. See Fig. 4 .
S222	Near breakout for sentry key immobilizer module. See Fig. 4 .
S224	Behind left side of dash.
S225	Between breakout for brake transmission shift interlock solenoid & ignition switch. See Fig. 4 .
S226	Between breakout for brake transmission shift interlock solenoid & ignition switch. See Fig. 4 .
S227	In breakout for in-line connector, at lower right kick panel.
S228	Near breakout for power mirror switch.
S229	Near breakout for ground, behind center of dash.
S231	Near breakout for instrument cluster.
S232	In breakout for ground, behind center of dash.
S233	Near breakout for turn signal indicators.
S234	Near breakout for brake transmission shift interlock solenoid.
S236	Near breakout for remote keyless entry module.
S237	Near breakout for instrument cluster. See Fig. 4 .
S239	Near breakout for ground, behind center of dash.
S240	Near breakout for ground, behind center of dash.
S241	Near breakout for ground, behind center of dash.
S244	Near breakout for visor/vanity light.
S245	At breakout for ignition switch. See Fig. 4 .
S246	Near breakout for visor/vanity light.
S247	Near breakout for brake transmission shift interlock solenoid.
S248	Near breakout for overhead console.
S249	In breakout for overhead console.
S250	In breakout for power mirror switch.
S254	Near breakout for instrument cluster.
S260	Near breakout for radio.
S261	Behind center of dash.
S301	Forward of left rear wheelwell.
S302	In trough near left rear door.
S303	At base of right rear wheelwell.
S304	At top of left rear wheelwell.
S305	Near breakout for left rear door ajar switch.
S306	Near breakout for license light.
S307	Near breakout for left rear door ajar switch.
S308	Near breakout for license light.
S309	Near breakout for left front door lock switch.
S310	Near breakout for rear window defogger ground.
S311	Near breakout for right front door lock switch.
S312	Near breakout for license light.
S313	Near breakout for passenger's heated seat module.
S314	Near breakout for passenger's heated seat module.
S315	Near breakout for passenger's heated seat module.
S316	Near breakout for passenger's heated seat module.