2002 HONDA Insight

Honda Insight 2002 - BUZZERS, RELAYS & TIMERS

Honda Insight 2002 BUZZERS, RELAYS & TIMERS LOCATION

Component	Component Location
A/F Sensor Relay	Behind upper left kick panel.
A/T Reverse Relay	Under left side of dash.
Blower Motor High Relay	Behind glove box. See Fig. 5 .
DRL Relay	Under left side of dash. See Fig. 6 .
EPS Motor Relay	Under right kick panel. See Fig. 4 .
Fuel Cut Relay	At left front of engine compartment. See Fig. 3 .
Hatch Opener Relay	Below left taillight.
High Speed MPI Module Fan Control Relay	Left rear of power control unit. See Fig. 9 .
High Voltage Contactor Relay	Left rear of power control unit. See Fig. 9 .
Ignition Hold Relay	Left rear of power control unit. See Fig. 9 .
Intermittent Wiper Relay	At left front of engine compartment. See Fig. 3 .
Low Beam Cut Relay	Under left side of dash. See Fig. 6 .
Low Speed MPI Module Fan Control Relay	Left rear of power control unit. See Fig. 9 .
PGM-FI Main Relay	Under left side of dash.
Power Window Relay	In underdash fuse/relay box. See Fig. 6 .
Radiator Fan Main Relay	At left front of engine compartment. See Fig. 3 .
Rear Window Defogger Relay	At left front of engine compartment. See Fig. 3 .
Starter Cut Relay	In underdash fuse/relay box. See Fig. 6 .
Taillight Relay	In underdash fuse/relay box. See Fig. 6 .
Turn Signal/Hazard Relay	In underdash fuse/relay box. See Fig. 6 .

Honda Insight 2002 - CIRCUIT PROTECTION DEVICES

Honda Insight 2002 CIRCUIT PROTECTION DEVICES LOCATION

Component	Component Location
Underdash Fuse/Relay Box	Behind left end of dash. See Fig. 6 .
Underhood Fuse/Relay Box	At left side of engine compartment.

Honda Insight 2002 - CONTROL UNITS

Honda Insight 2002 CONTROL UNITS LOCATION

Component	Component Location
ABS Modulator/Control Unit	At right front of engine compartment.
Audio Unit	Behind radio. See Fig. 5 .
BCM Module	On top front of battery module. See Fig. 8 .
DRL Control Unit	Under left side of dash. See Fig. 6 .
ECM (CVT)	On right side of front floor. See Fig. 2 .
ECM (M/T)	On right side of front floor. See Fig. 1 .
ELD Unit	In underhood fuse/relay box. See Fig. 3 .
EPS Control Unit	Under right side kick panel. See Fig. 4 .
Immobilizer Receiver Unit	Under left side of dash, right of steering column. See Fig. 6 .
Keyless Door Lock Control Unit	Under left side of dash. See Fig. 6 .
MCM	On top front of battery module. See Fig. 8 .
MPI Module Fan	On left side of DC-DC converter in rear compartment. See Fig. 9 .
Power Control Unit (PCU)	In rear compartment.
SRS Unit	Under middle of dash.
Voltage Converter Module	In power control unit. See Fig. 9 .

Honda Insight 2002 - MOTORS

Honda Insight 2002 MOTORS LOCATION

Component	Component Location
Air Mix Control Motor	Behind glove box. See Fig. 5 .
Battery Module Fan Motor	At top front of battery module. See Fig. 8 .
Blower Motor	Behind glove box. See Fig. 5 .
EPS Motor	At left rear of engine compartment. See Fig. 4 .
Fuel Pump/Sending Unit	On top left side of fuel tank.
Mode Control Motor	Under center of dash.
Radiator Fan Motor	At front left of engine compartment. See Fig. 3 .
Rear Window Washer Motor	At right front of engine compartment.
Rear Window Wiper Motor	In right side of hatch.
Recirculation Control Motor	Behind glove box. See Fig. 5 .
Windshield Washer Motor	At right front of engine compartment.
Windshield Wiper Motor	At right rear of engine compartment. See Fig. 4 .

Honda Insight 2002 - SENDING UNITS & SENSORS

Honda Insight 2002 SENDING UNITS & SENSORS LOCATION

Component	Component Location
ABS Wheel Speed Sensor (Left Front)	At left front wheel hub assembly.
ABS Wheel Speed Sensor (Left Rear)	At left rear wheel hub assembly.
ABS Wheel Speed Sensor (Right Front)	At right front wheel hub assembly.
ABS Wheel Speed Sensor (Right Rear)	At right rear wheel hub assembly.
A/F Sensor (CVT)	On top center of engine. See Fig. 2 .
Battery Current Sensor	On top front of battery module. See Fig. 8 .
Brake Booster Vacuum Sensor	On left rear of engine compartment. See Fig. 4 .
CKP Sensor (CVT)	On lower right front of engine. See Fig. 2 .
CKP Sensor (M/T)	On lower right front of engine. See Fig. 1 .
CVT Drive Pulley Speed Sensor	On transaxle housing. See Fig. 2 .
CVT Driven Pulley Speed Sensor	On transaxle housing. See Fig. 2 .
ECT Sensor (CVT)	On rear of engine. See Fig. 2 .
ECT Sensor (M/T)	On rear of engine. See Fig. 1 .
EPS Torque Sensor	At left rear of engine compartment. See Fig. 4 .
Evaporator Temperature Sensor	Behind glove box. See Fig. 5 .
Fuel Tank Pressure Sensor	On top right side of fuel tank. See Fig. 7 .
Fuel Tank Unit	On top left side of fuel tank.
Heater Core Temperature Sensor	Behind center lower dash cover.
In-Car Temperature Sensor	Under center of dash.
IAT Sensor (CVT)	On air intake hose. See Fig. 2 .
IAT Sensor (M/T)	On air intake hose. See Fig. 1 .
Knock Sensor (CVT)	On left side of engine. See Fig. 2 .
Knock Sensor (M/T)	On left side of engine. See Fig. 1 .
MAP Sensor (CVT)	On left rear of engine. See Fig. 2 .
MAP Sensor (M/T)	On right rear of engine. See Fig. 1 .
Motor Communication Sensor	On lower right rear of engine.
MPI Module Current Sensor	On left side of battery module.
Neutral Position Switch (MT)	On transaxle housing. See Fig. 1 .
Outside Air Temperature Sensor	Behind center of bumper. See Fig. 3 .
Primary HO2S (MT)	In exhaust, before catalytic converter. See Fig. 1 .
Secondary HO2S (CVT)	In exhaust, after catalytic converter. See Fig. 2 .
Secondary HO2S (M/T)	In exhaust, after catalytic converter. See Fig. 1 .
Sunlight Sensor	On top center of dash.
TDC Sensor 1 (CVT)	On right rear of engine. See Fig. 2 .
TDC Sensor 1 (M/T)	On left rear of engine. See Fig. 1 .
TDC Sensor 2 (CVT)	On left rear of engine. See Fig. 2 .
TDC Sensor 2 (M/T)	On right rear of engine. See Fig. 1 .
Third HO2S	In exhaust, under middle of floor pan. See Fig. 7 .
TP Sensor (CVT)	On throttle body. See Fig. 2 .
TP Sensor (M/T)	On throttle body. See Fig. 1 .
U Phase Motor Current Sensor	In power control unit. See Fig. 9 .
V Phase Motor Current Sensor	In power control unit. See Fig. 9 .
VSS (CVT)	On rear of transaxle. See Fig. 2 .
VSS (M/T)	On rear of transaxle. See Fig. 1 .
W Phase Motor Current Sensor	In power control unit. See Fig. 9 .

Honda Insight 2002 - SOLENOIDS & SOLENOID VALVES

Honda Insight 2002 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Component Location
ABS Modulator/Control Unit	At right front of engine compartment.
CAS Solenoid Valves (CVT)	At right side of engine compartment.
EGR Valve & EGR Valve Position Sensor (CVT)	On left rear of engine. See Fig. 2 .
EGR Valve & EGR Valve Position Sensor (M/T)	On left rear of engine. See Fig. 1 .
EVAP By-Pass Solenoid Valve	Under rear of vehicle, near right side of fuel tank. See Fig. 7 .
EVAP Canister Purge Valve (CVT)	On left rear of engine. See Fig. 2 .
EVAP Canister Purge Valve (M/T)	On left rear of engine. See Fig. 1 .
EVAP Canister Vent Shut Valve	Under rear of vehicle, near right side of fuel tank. See Fig. 7 .
Fuel Injector No. 1 (CVT)	On left side of engine. See Fig. 2 .
Fuel Injector No. 1 (M/T)	On left side of engine. See Fig. 1 .
Fuel Injector No. 2 (CVT)	On left side of engine. See Fig. 2 .
Fuel Injector No. 2 (M/T)	On left side of engine. See Fig. 1 .
Fuel Injector No. 3 (CVT)	On left side of engine. See Fig. 2 .
Fuel Injector No. 3 (M/T)	On left side of engine. See Fig. 1 .
IAC Valve (CVT)	On left side of engine. See Fig. 2 .
IAC Valve (M/T)	On left side of engine. See Fig. 1 .
Shift Lock Solenoid	Under center console. See Fig. 7 .
Starter Solenoid (CVT)	On starter motor. See Fig. 2 .
Starter Solenoid (M/T)	On starter motor. See Fig. 1 .
VTEC Solenoid Valve (CVT)	On left side of engine. See Fig. 2 .
VTEC Solenoid Valve (M/T)	On left side of engine. See Fig. 1 .

Honda Insight 2002 - SWITCHES

Honda Insight 2002 SWITCHES LOCATION

Component	Component Location
A/C Pressure Switch	At right rear of engine compartment.
Back-Up Light Switch (MT)	On transaxle housing. See Fig. 1 .
Battery Module Switch	Under small cover, on intelligent power unit lid.
Brake Fluid Level Switch	On master cylinder reservoir. See Fig. 4 .
Brake Pedal Position Switch	Under left side of dash. See Fig. 6 .
Clutch Pedal Position Switch	Under left side of dash. See Fig. 6 .
Driver's Seat Belt Switch	Under driver's seat. See Fig. 7 .
Idle Stop Switch	Under left side of dash.
IMA Diode	On top front of battery module.
Neutral Position Switch (M/T)	On transaxle housing. See Fig. 1 .
Oil Pressure Switch (CVT)	On lower left side of engine. See Fig. 2 .
Oil Pressure Switch (M/T)	On lower left side of engine. See Fig. 1 .
Parking Brake Switch	At base of parking brake lever. See Fig. 7 .
Park Pin Switch	Under center console. See Fig. 7 .
Radiator Fan Switch (CVT)	At front of engine compartment. See Fig. 2 .
Radiator Fan Switch (M/T)	At front of engine compartment. See Fig. 1 .
Transmission Range Switch (CVT)	On transaxle housing. See Fig. 2 .
VTEC Oil Pressure Switch (CVT)	On left side of engine. See Fig. 2 .
VTEC Oil Pressure Switch (M/T)	On left side of engine. See Fig. 1 .

Honda Insight 2002 - MISCELLANEOUS

Honda Insight 2002 MISCELLANEOUS LOCATION

Component	Component Location
A/C Diode	Under left side of dash.
Battery Module Fan Resistor	Left front of battery module.
Blower Power Transistor	Behind glove box. See Fig. 5 .
By-Pass Contactor	Left front of battery module.
Data Link Connector (DLC)	Behind center of dash. See Fig. 6 .
DC-DC Converter	Right front of power control unit. See Fig. 8 .
Driver's Seat Belt Tensioner	At left "B" pillar. See Fig. 7 .
High Voltage Contactor	In left front of battery module. See Fig. 8 .
Ignition Coil No. 1 (CVT)	On top center of engine. See Fig. 2 .
Ignition Coil No. 1 (M/T)	On top center of engine. See Fig. 1 .
Ignition Coil No. 2 (CVT)	On top center of engine. See Fig. 2 .
Ignition Coil No. 2 (M/T)	On top center of engine. See Fig. 1 .
Ignition Coil No. 3 (CVT)	On top center of engine. See Fig. 2 .
Ignition Coil No. 3 (M/T)	On top center of engine. See Fig. 1 .
Intelligent Power Unit (IPU) Compartment	At rear of vehicle, under mid-frame cover.
Junction Board	At left front of battery module. See Fig. 8 .
Junction Connector C104	At top rear of engine. See Fig. 2 .
Junction Connector C105	At right side of floor. See Fig. 2 .
Junction Connector C107	Under middle of dash. See Fig. 2 .
Junction Connector C108	Under middle of dash. See Fig. 2 .
Junction Connector C507	Behind rear seats, at middle of floor. See Fig. 8 .
Junction Connector C508	Behind rear seats, at middle of floor. See Fig. 8 .
Junction Connector C571	Under left side of dash.
MES Connector	Behind upper left kick panel.
MPI Module Fan Control Resistor	On left side of intelligent power unit compartment. See Fig. 9 .
Passenger's Seat Belt Tensioner	At right "B" pillar. See Fig. 7 .
Test Tachometer Connector	Left rear of engine compartment. See Fig. 4 .

Honda Insight 2002 - CONNECTORS

Honda Insight 2002 CONNECTORS LOCATION

Component	Component Location
C101 (M/T) (Gray, 4-Pin)	Under middle of dash. See Fig. 2 .
C101 (CVT) (Gray, 8-Pin)	Under middle of dash. See Fig. 2 .
C102 (Light Blue, 16-Pin)	Under middle of dash. See Fig. 2 .
C103 (Light Blue, 24-Pin)	Under middle of dash. See Fig. 2 .
C106 (Light Blue, 6-Pin)	Behind center lower cover. See Fig. 2 .
C109 (CVT) (Gray, 8-Pin)	On transaxle housing. See Fig. 2 .
C401 (Brown, 3-Pin)	Under left side of dash. See Fig. 6 .
C402 (Gray, 14-Pin)	Under left side of dash. See Fig. 6 .
C403 (Light Blue, 16-Pin)	Under left side of dash. See Fig. 6 .
C404 (Light Blue, 24-Pin)	Under left side of dash. See Fig. 6 .
C405 (Gray, 14-Pin)	Under left side of dash. See Fig. 6 .
C406 (Gray, 4-Pin)	Under left side of dash. See Fig. 6 .
C407 (Gray, 16-Pin)	Behind top of left kick panel.
C408 (Light Blue, 16-Pin)	Behind center lower cover. See Fig. 5 .
C409 (Gray, 12-Pin)	Behind right side of dash. See Fig. 5 .
C410 (Gray, 10-Pin)	Behind center lower cover.
C451 (Brown, 1-Pin)	Under left side of dash.
C452 (Gray, 16-Pin)	Under left side of dash. See Fig. 6 .
C501 (Light Blue, 16-Pin)	Under middle of dash. See Fig. 7 .
C502 (Blue, 24-Pin)	Behind center lower cover. See Fig. 6 .
C503 (Blue, 2-Pin)	Behind center lower cover. See Fig. 7 .
C504 (Blue, 16-Pin)	Behind center lower cover. See Fig. 7 .
C505 (Light Blue, 24-Pin)	Behind rear seats, at middle of floor. See Fig. 7 .
C506 (Gray, 12-Pin)	Behind rear seats, at middle of floor. See Fig. 7 .
C531 (Light Blue, 16-Pin)	Under left side of dash.
C551 (Gray, 10-Pin)	At right front side of power control unit. See Fig. 8 .
C552 (Light Blue, 24-Pin)	At right front side of power control unit. See Fig. 8 .
C601 (Gray, 14-Pin)	At left "B" pillar. See Fig. 7 .
C602 (Gray, 2-Pin)	At middle rear of cargo area.
C701 (Light Blue, 6-Pin)	At right "B" pillar. See Fig. 7 .
C702 (Brown, 1-Pin)	At right "B" pillar. See Fig. 7 .
C703 (White, 2-Pin)	At left side of hatch.

Honda Insight 2002 - GROUNDS

Honda Insight 2002 GROUNDS LOCATION

Component	Component Location
G1	At middle rear of engine compartment. See Fig. 3 .
G2	At left side of engine compartment. See Fig. 3 .
G3	At left side of engine compartment. See Fig. 3 .
G4	At left side of engine compartment. See Fig. 3 .
G101	At top rear of engine. See Fig. 2 .
G102	At top rear of engine. See Fig. 2 .
G201	Above left front wheelwell. See Fig. 2 .
G301	Above right front wheelwell. See Fig. 3 .
G401	Behind top of left kick panel. See Fig. 6 .
G402	Behind left side of dash. See Fig. 6 .
G403	Behind middle of dash. See Fig. 6 .
G404	Behind right side of dash. See Fig. 5 .
G451	Behind right kick panel. See Fig. 4 .
G501	Under SRS unit, at front of center console. See Fig. 7 .
G502	Behind rear seats, at middle of floor. See Fig. 7 .
G601	At middle rear of cargo area.
G651	At left rear side of floor.
G701	At middle rear of roof. See Fig. 4 .