2002 ISUZU Passport, Rodeo & Rodeo Sport

Isuzu Rodeo LS 2002 - BUZZERS, RELAYS & TIMERS

Isuzu Rodeo LS 2002 BUZZERS, RELAYS & TIMERS LOCATION

Component	Component Location
Accessory Power Socket Relay	On dash fuse box.
A/C Compressor Relay	In fuse/relay box.
Condenser Fan Hi Relay (2.2L)	In option fuse box.
Condenser Fan Hi Relay 2 (2.2L)	In option fuse box.
Condenser Fan Lo Relay (2.2L)	In fuse/relay box.
Condenser Fan Relay (3.2L)	In fuse/relay box.
ECM Main Relay (M/T)	In fuse/relay box.
Flasher Unit	Above left kick panel.
Foglight Relay	In fuse/relay box.
Fuel Pump Relay	In fuse/relay box.
Headlight Relay	In fuse/relay box.
Heater-A/C Relay	In fuse/relay box.
Horn Relay	Integral to alarm & relay control unit.
Intake Actuator Relay	Behind glove box.
PCM Main Relay (A/T)	In fuse/relay box.
Power Window Relay	On dash fuse box.
Rear Window Defogger Relay	On dash fuse box.
Shift Lock Relay	Below shift lever.
Starter Relay	In fuse/relay box.
Taillight Relay	On dash fuse box.
Thermo Switch Relay	In fuse/relay box.

Isuzu Rodeo LS 2002 - CIRCUIT PROTECTION DEVICES

Isuzu Rodeo LS 2002 CIRCUIT PROTECTION DEVICES LOCATION

Component	Component Location
Dash Fuse Box	Behind dash, left of steering column.
Diode Box "B"	In fuse/relay box.
Diode Box No. 5	In dash fuse box.
Diode Box No. 6	In dash fuse box.
Fuse/Relay Box (2.2L)	On right side of engine compartment. See Fig. 1 .
Fuse/Relay Box (3.2L)	On right side of engine compartment. See Fig. 4 .
Option Fuse Box	At right rear of engine compartment.

Isuzu Rodeo LS 2002 - CONTROL UNITS

Isuzu Rodeo LS 2002 CONTROL UNITS LOCATION

Component	Component Location
Alarm & Relay Control Unit	Above right kick panel.
Cruise Control Unit	Under rear of center console.
Electronic Brake Control Module (EBCM)	On right rear corner of engine compartment.
Engine Control Module (ECM) (M/T) (2.2L)	Below center of dash. See Fig. 8 .
Engine Control Module (ECM) (M/T) (3.2L)	Left rear of engine compartment.
Ignition Control Module (ICM) (2.2L)	On right rear of engine.
Intelligent Suspension Control Unit	Below center of dash.
Ion Sensing Module (3.2L)	On top of intake manifold.
Keyless Entry & Security Control Unit	Above right kick panel.
Multi-Plexed Indicator Control Unit	Under rear of center console.
Powertrain Control Module (PCM) (A/T) (2.2L)	Below center of dash. See Fig. 8 .
Powertrain Control Module (PCM) (A/T) (3.2L)	Left rear of engine compartment.
Sensing & Diagnostic Module (2.2L)	Below center of dash. See Fig. 8 .
Sensing & Diagnostic Module (3.2L)	Below center of dash.
Shift-On-The-Fly Controller	On lower left center of dash.
Sun Roof Control Unit	Center front of roof.
4WD Control Unit	Under center console.

Isuzu Rodeo LS 2002 - MOTORS

Isuzu Rodeo LS 2002 MOTORS LOCATION

Component	Component Location
Blower Motor	Below right side of dash.
Condenser Fan	Behind right side of radiator grille.
Cruise Control Actuator	On right side of engine compartment, on inner fender panel.
Fuel Pump	Beneath rear of vehicle, in top of fuel tank.
Intake Actuator	On heater case.
Rear Washer Motor	On right front of engine compartment, in washer fluid reservoir.
Rear Wiper Motor	Inside right side of tailgate, behind trim panel.
Sun Roof Motor	Center front of roof.
Windshield Washer Motor	On right front of engine compartment, in washer fluid reservoir.
Windshield Wiper Motor	On right rear corner of engine compartment, on firewall.
4WD Transfer Motor Actuator	On rear of transfer case.

Isuzu Rodeo LS 2002 - SENDING UNITS & SENSORS

Isuzu Rodeo LS 2002 SENDING UNITS & SENSORS LOCATION

Component	Component Location
Acceleration Position Sensor	Above accelerator pedal.
Camshaft Position (CMP) Sensor (2.2L)	On top center front of cylinder head. See Fig. 1 .
Camshaft Position (CMP) Sensor (3.2L)	On top rear of left cylinder head. See Fig. 5 .
Crankshaft Position (CKP) Sensor (2.2L)	On lower left front of engine.
Crankshaft Position (CKP) Sensor (3.2L)	On lower right side of engine. See Fig. 7 .
Engine Coolant Temperature (ECT) Gauge Sender (2.2L)	On right rear of engine, below intake manifold.
Engine Coolant Temperature (ECT) Gauge Sender (3.2L)	On left front of engine. See Fig. 6 .
Engine Coolant Temperature (ECT) Sensor (2.2L)	On rear of engine, in coolant manifold. See Fig. 3 .
Engine Coolant Temperature (ECT) Sensor (3.2L)	On right front of engine. See Fig. 4 .
Front Speed Sensors (ABS)	On inside of front wheels.
Fuel Vapor Pressure Sensor	On top of fuel tank.
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 1) (3.2L)	On right exhaust downpipe.
Heated Oxygen Sensor (HO2S) (Bank 1 Sensor 2) (3.2L)	On underside of vehicle, rear of right TWC converter.
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 1) (3.2L)	On left exhaust downpipe.
Heated Oxygen Sensor (HO2S) (Bank 2 Sensor 2) (3.2L)	On underside of vehicle, rear of left TWC converter.
Heated Oxygen Sensor (HO2S-POST) (2.2L)	Beneath center of vehicle, rear of TWC converter.
Heated Oxygen Sensor (HO2S-PRE) (2.2L)	On lower left side of engine, in exhaust downpipe.
Intake Air Temperature (IAT) Sensor (2.2L)	On left front of engine, on air duct assembly. See Fig. 1 .
Intake Air Temperature (IAT) Sensor (3.2L)	In air duct assembly. See Fig. 4 .
Knock Sensor (KS) (2.2L)	On lower right side of engine. See Fig. 2 .
Knock Sensor (KS) (3.2L)	Below upper intake manifold. See Fig. 5 .
Manifold Absolute Pressure (MAP) Sensor (2.2L)	On right side of engine, on intake manifold. See Fig. 1 .
Manifold Absolute Pressure (MAP) Sensor (3.2L)	On top rear of intake manifold. See Fig. 4 .
Mass Airflow (MAF) Sensor (3.2L)	In air duct assembly. See Fig. 4 .
Rear Speed Sensor (ABS)	Beneath rear of vehicle, on top of differential.
Throttle Position (TP) Sensor (2.2L)	On right side of engine, on throttle body. See Fig. 1 .
Throttle Position (TP) Sensor (3.2L)	On throttle body assembly. See Fig. 6 .
Transmission Speed Sensor (A/T)	Beneath center of vehicle, on top of transmission.
Vehicle Speed Sensor (VSS) (2.2L)	On right side of transmission.
Vehicle Speed Sensor (VSS) (3.2L)	Beneath center of vehicle, rear of transmission.

Isuzu Rodeo LS 2002 - SOLENOIDS & SOLENOID VALVES

Isuzu Rodeo LS 2002 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Component Location
Evaporative Emission (EVAP) Canister Cut Valve	On underside of vehicle, above right side of rear axle.
Evaporative Emission (EVAP) Canister Purge Valve (2.2L)	On right rear of engine.
Evaporative Emission (EVAP) Canister Purge Valve (3.2L)	On front of engine. See Fig. 6 .
Exhaust Gas Recirculation (EGR) Solenoid Valve (2.2L)	On top center rear of engine. See Fig. 3 .
Exhaust Gas Recirculation (EGR) Solenoid Valve (3.2L)	On top right rear of engine. See Fig. 4 .
Front Actuator (Left)	On top of left front shock.
Front Actuator (Right)	On top of right front shock.
Front Axle Vacuum Solenoid Valve (Blue)	In left rear corner of engine compartment.
Front Axle Vacuum Solenoid Valve (Gray)	In left rear corner of engine compartment.
Idle Air Control (IAC) Valve (2.2L)	On throttle body. See Fig. 1 .
Idle Air Control (IAC) Valve (3.2L)	On top of throttle body. See Fig. 4 .
Rear Actuator (Left)	On top of left rear shock.
Rear Actuator (Right)	On top of right rear shock.
Shift Lock Solenoid	Below shift lever cover.
Variable Intake Manifold Vacuum Switching Valve (3.2L)	On left rear of engine.

Isuzu Rodeo LS 2002 - SWITCHES

Isuzu Rodeo LS 2002 SWITCHES LOCATION

Component	Component Location
A/C Dual Pressure Switch (M/T) (3.2L)	Behind left side of radiator grille.
A/C Pressure Switch (2.2L)	Behind left side of radiator grille.
A/C Thermo Switch	On A/C compressor.
A/C Triple Pressure Switch (A/T) (3.2L)	Behind left side of radiator grille.
A/T Gear Position Switch	Beneath center of vehicle, on left side of transmission.
A/T Mode Switch	Beneath center of vehicle, on left side of transmission.
Back-Up Light Switch (M/T) (2.2L)	Beneath vehicle, on left side of transmission.
Back-Up Light Switch (M/T) (3.2L)	Beneath vehicle, on top of transmission.
Brake Fluid Level Switch	On left rear of engine compartment, in brake fluid reservoir.
Brake Switch	Behind dash, on brake pedal support.
Clutch Start Switch	Behind dash, on clutch pedal support.
Clutch Switch	Behind dash, on clutch pedal support.
Driver's Seat Belt Switch	In driver's seat belt buckle.
Engine Hood Switch	At right rear corner of engine compartment.
Front Axle Switch	On center of front axle.
Hatch Gate Open Switch	Inside top center of tailgate, on latch assembly.
Kickdown Switch	Behind left side of dash, on accelerator pedal bracket.
Oil Pressure Switch (2.2L)	On lower right side of engine, near oil filter. See Fig. 2 .
Oil Pressure Switch (3.2L)	On lower front of engine, near oil filter.
Parking Brake Switch	Beneath center console, on parking brake lever.
Park Position Detect Switch	Below shift lever cover.
Power Steering Pressure (PSP) Switch	On power steering pump.
Tailgate Open Switch	On tailgate.
Transmission Switch No. 1 & No. 2 (M/T)	On left front of transmission.
Transmission Switch No. 3 & No. 4 (M/T)	On right front of transmission.
4WD Transfer Switch	Beneath vehicle, on right side of transfer case.

Isuzu Rodeo LS 2002 - MISCELLANEOUS

Isuzu Rodeo LS 2002 MISCELLANEOUS LOCATION

Component	Component Location
Anti-Theft Horn	On right side of engine compartment.
Blower Resistor	Behind glove box, on plenum.
Condenser (Ignition)	On right front of engine.
Data Link Connector (DLC)	On lower left side of dash, near engine hood release lever.
Electronic Thermostat	Behind glove box, on plenum.
Fuel Tank Unit	Beneath rear of vehicle, in top of fuel tank.
High Note Horn	Behind right side of radiator grille.
Ignition Coils (2) (2.2L)	On right rear of engine.
Ignition Coils (6) (3.2L)	On both valve covers, at top of respective cylinder. See Fig. 7 .
Inverter	Underside of vehicle, behind left rear wheel.
J/C "A"	In fuse/relay box.
J/C "B"	In fuse/relay box.
Low Note Horn	Behind right side of radiator grille.
Trailer Lighting Connector	In left rear cargo compartment, taped to harness.

Isuzu Rodeo LS 2002 - CONNECTORS

Isuzu Rodeo LS 2002 CONNECTORS LOCATION

Component	Component Location
A (White, 18 Pin)	Below left side of dash, on amplifier.
B (Gray, 16 Pin)	Below left side of dash, on amplifier.
B9 (Black, 6 Pin)	In right taillight assembly.
B13 (Black, 6 Pin)	In left taillight assembly.
B22 (White, 2 Pin)	Under left front seat.
B38 (White/Gray, 2 Pin)	Under driver's seat.
B39 (White/Gray, 2 Pin)	Under passenger's seat.
C17 (Gray, 2 Pin)	Behind left side of front bumper.
C22 (Gray, 2 Pin)	Behind right side of front bumper.
C24 (Gray, 2 Pin)	At left front of engine compartment, behind grille.
C27 (White, 6 Pin)	At right rear of engine compartment, on wiper motor assembly.
C35 (Gray, 4 Pin)	On left side of fan shroud.
C37 (White, 22 Pin)	Below center of dash, below engine control module.
C39 (White, 6 Pin)	Behind glove box.
C43 (Gray, 6 Pin)	At right side of engine compartment.
C44 (Black, 4 Pin)	At right side of engine compartment.
C45 (Black, 4 Pin)	At left side of engine compartment.
C46 (Gray, 6 Pin)	At left side of engine compartment.
C47 (Gray, 4 Pin)	At lower left side of engine.
C71 (2.2L)	At center front of engine compartment.
C72 (2.2L)	At center front of engine compartment.
D2 (White, 2 Pin)	Behind trim, inside front of left front door.
D3 (White, 8 Pin)	At top front of left front door.
D9 (White, 3 Pin)	Inside rear of left front door.
D11 (White, 2 Pin)	Inside front of right front door.
D12 (White, 8 Pin)	Top front of right front door.
D15 (White, 3 Pin)	Inside rear of right front door.
D20 (White, 2 Pin)	Inside front of left rear door.
D25 (White, 2 Pin)	Inside front of right rear door.
E4 (Gray, 1 Pin)	At left side of engine compartment.
E9 (Gray, 5 Pin)	At left side of engine compartment, near air cleaner.
E14 (Black, 2 Pin)	At right side of engine compartment, near generator.
E27 (Gray, 3 Pin)	At right front of engine, beside generator.
E45 (Black, 1 Pin)	At front of engine, near throttle body.
E50 (3.2L) (Black, 4 Pin)	At left front of transmission.
E51 (3.2L) (Black, 4 Pin)	At right front of transmission.
E52 (Gray, 4 Pin)	At left side of transmission.
E53 (3.2L) (Black, 8 Pin)	At left side of transmission.
E54 (Gray, 7 Pin)	At left side of transmission.
E56 (White, 1 Pin)	On right side of transfer case.
E57 (White, 1 Pin)	On right side of transfer case.
E58 (3.2L) (Black, 4 Pin)	At left rear of transmission.
E59 (3.2L) (Black, 4 Pin)	At right rear of transmission.
E60 (Gray, 6 Pin)	Underneath center of vehicle, rear of transfer case.
E62 (3.2L) (1 Pin)	On top of transmission.
E63 (1 Pin)	On top of transmission.
F1 (Black, 4 Pin)	Under vehicle, on top of fuel tank.
F5 (Black, 4 Pin)	Underneath vehicle, near left rear shock absorber.
F6 (Gray, 8 Pin)	Underneath vehicle, near right rear shock absorber.
F7 (Gray, 8 Pin)	Underneath vehicle, near right rear shock absorber.
G1 (White, 2 Pin)	Behind trim, on tailgate.
G4 (Black, 2 Pin)	At rear of hardtop.
G5 (Black, 3 Pin)	Behind trim, on tailgate.
G6 (White, 6 Pin)	Behind trim, on tailgate.
G8 (Gray, 2 Pin)	Under right side of rear bumper.
H1 (White, 1 Pin)	In fuse/relay box, at right side of engine compartment.
H2 (Gray, 2 Pin)	At right side of engine compartment, on fuse/relay box.
H4 (Black, 16 Pin)	At left side of engine compartment, below brake fluid reservoir.
H5 (2.2L) (Green, 16 Pin)	At left side of engine compartment, below brake fluid reservoir.
H5 (3.2L) (Green, 16 Pin)	At left side of engine compartment.
H6 (Blue, 16 Pin)	At left side of engine compartment, below brake fluid reservoir.
H7 (White, 16 Pin)	At left side of engine compartment.
H8 (Blue, 16 Pin)	At lower right rear of engine compartment.
H11 (Gray, 6 Pin)	Behind right kick panel.
H12 (Blue, 20 Pin)	Below right side of dash, behind kick panel.
H13 (White, 19 Pin)	Below right side of dash, behind kick panel.
H14 (Black, 19 Pin)	Below right side of dash, behind kick panel.
H15 (Blue, 20 Pin)	Behind left kick panel.
H16 (Black, 22 Pin)	Behind left kick panel.
H17 (Black, 19 Pin)	Behind left kick panel.
H18 (White, 22 Pin)	Behind right kick panel.
H19 (White, 22 Pin)	Below right side of dash, behind kick panel.
H20 (White, 1 Pin)	Behind trim, at right side of rear roof panel.
H21 (Rodeo) (White, 2 Pin)	Behind trim, at left side of rear roof panel.
H21 (Rodeo Sport) (White, 4 Pin)	At left rear of cargo compartment.
H22 (White, 8 Pin)	Behind trim, at lower left "D" pillar.
H24 (White, 10 Pin)	At left "B" pillar, behind trim.
H25 (W/ Intelligent Suspension System) (White, 10 Pin)	Below carpet, under driver's seat.
H25 (W/O Intelligent Suspension System) (White, 13 Pin)	Below carpet, under driver's seat.
H27 (Gray, 2 Pin)	Underneath left rear of vehicle.
H28 (W/ Keyless Security & Anti-Theft) (White, 22 Pin)	Above left kick panel, in door grommet.
H28 (W/O Keyless Security & Anti-Theft) (White, 4 Pin)	Above left kick panel, in door grommet.
H29 (White, 10 Pin)	Behind trim, on right "B" pillar.
H30 (Rodeo) (White, 6 Pin)	Behind left side of dash, above kick panel.
H31 (White, 22 Pin)	Behind left kick panel.
H32 (White, 16 Pin)	Behind left kick panel.
H33 (W/ Keyless Security & Anti-Theft) (White, 22 Pin)	Above right kick panel, in door grommet.
H33 (W/O Keyless Security & Anti-Theft) (4 Pin)	Above right kick panel, in door grommet.
H34 (Rodeo Sport W/ Hardtop) (White, 8 Pin)	Behind trim panel, at left rear of luggage compartment.
H34 (Rodeo) (White, 8 Pin)	Behind trim, on lower left "D" pillar.
H35 (White, 22 Pin)	Below carpet, under driver's seat.
H37 (White, 4 Pin)	Behind trim, on upper left "D" pillar.
H44 (Green, 16 Pin)	At lower right rear of engine.
I1 (Green, 30 Pin)	Behind left side of dash, on top of instrument cluster.
I2 (Green, 16 Pin)	Behind left side of dash, on top of instrument cluster.
I3 (White, 6 Pin)	Behind left side of dash, behind instrument cluster.
I9 (Green, 14 Pin)	Behind left side of dash, on top of instrument cluster.
I13 (Yellow, 2 Pin)	On connector bracket, behind left side of dash.
I25 (Yellow, 2 Pin)	Behind glove box.
I31 (White, 13 Pin)	Behind left side of dash, on connector bracket.
I32 (Black, 13 Pin)	Behind left side of dash, on connector bracket.
I33 (White, 8 Pin)	Behind center side of dash.
I40 (White, 6 Pin)	Below front of center console.
I46 (White, 8 Pin)	Behind left side of dash, on connector bracket.
J3 (White, 2 Pin)	Behind headliner, at center front of roof.
L1 (White, 2 Pin)	Behind headliner, at center front of roof.
L4 (Black, 2 Pin)	In headliner, behind fastener for left vanity mirror.
L6 (Black, 2 Pin)	In headliner, behind fastener for right vanity mirror.
M8 (1 Pin)	On top of transmission.
M9 (1 Pin)	On top of transmission.
M13 (Black, 4 Pin)	On transmission, at lower left rear of engine.
M14 (Black, 4 Pin)	On bracket, at left underside of vehicle.
P2	Right side of engine compartment, on fuse/relay box.
P11	Right side of engine compartment, on fuse/relay box.
SB1 (White, 1 Pin)	At left rear of cargo area.
SB2 (Clear, 2 Pin)	At left rear of cargo area.
T10	At right side of passenger's seat.

Isuzu Rodeo LS 2002 - GROUNDS

Isuzu Rodeo LS 2002 GROUNDS LOCATION

Component	Component Location
B6	Below center console.
B8	Below center console.
B99	At right rear floor of cargo area.
C16	On inner fender panel, at left rear corner of engine compartment.
C36	At right side of engine compartment, behind battery.
E28 (2.2L)	At right rear of engine.
E28 (3.2L)	At left side of intake manifold.
E29 (2.2L)	At left side of intake manifold.
E29 (3.2L)	At top left of engine.
E30	At right side of intake manifold.
I43	Above kick panel, below left side of dash.
P6	At right side of engine compartment, behind battery.
P10	At lower right front of engine.