| A | Battery |
| B | Starter |
| C | Alternator |
| C1 | Voltage regulator |
| D | Ignition/starter switch |
| J4 | Dual tone horn relay |
| J59 | X-contact relief relay |
| J226 | Starter inhibitor and reversing light relay, on the 13 position additional relay carrier |
| S162 | Fuse -1- (30), in fuse holder on battery |
| S163 | Fuse -2- (30), in fuse holder on battery |
| S176 | Fuse -4- (30), in fuse holder on battery |
| S177 | Fuse -5- (30), in fuse holder on battery |
| T2e | 2-pin connector, near starter (in models without air conditioning system) |
| T4 | 4-pin connector, near starter (in models with air conditioning system) |
| T6 | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| 500 | Screw connection 1 (30), on relay plate |
| 502 | Screw connection (30a), on relay plate |
| * | only models with manual gearbox |
| -••- | from September 2000 |
| ** | up August 2000 |
| --- | models with automatic gearbox only |
| D | Ignition/starter switch |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| Q6 | Glow plugs, engine |
| S10 | Fuse 10 in fuse holder |
| S229 | Fuse 29 in fuse holder |
| S237 | Fuse 37 in fuse holder |
| T2 | 2-pin connector, in cable channel left in engine compartment |
| T6 | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T14a | 14-pin connector, near battery |
| T121 | 121-pin connector |
| 501 | Screw connection 2 (30), on relay plate |
| 504 | Screw connection (87F), on relay plate |
| A2 | Positive connection (15), in dash panel wiring harness |
| A32 | Positive connection (30), in dash panel wiring harness |
| A80 | Connection 1 (X), in dash panel wiring harness |
| A98 | Positive connection 4 (30), in dash panel wiring harness |
| A104 | Positive connection 2 (15), in dash panel wiring harness |
| ** | from September 2000 |
| *** | from November 2001 |
| -••- | up to October 2001 |
| F8 | Kick-down switch |
| F60 | Idling speed switch |
| G28 | Engine speed sender |
| G79 | Accelerator position sender |
| J52 | Glow plug relay |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| J317 | Terminal 30 voltage supply relay, above the central electrics |
| T3 | 3-pin connector, on front of engine |
| T6 | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T6a | 6-pin connector |
| T10h | 10-pin connector, blue, in connector protective housing, on left in plenum chamber |
| T121 | 121-pin connector |
| 200 | Earth connection (screening) in engine compartment wiring harness |
| A98 | Positive connection 4 (30), in dash panel wiring harness |
| D74 | Connection (86), in engine compartment wiring harness |
| G2 | Coolant temperature sender |
| G62 | Coolant temperature sender |
| G71 | Intake manifold pressure sender |
| G72 | Intake manifold temperature sender |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| N79 | Heater element for crankcase breather |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10f | 10-pin connector, in front engine compartment |
| T14a | 14-pin connector, near battery |
| T10w | 10-pin connector, white, in connector protective housing, on left in plenum chamber |
| T121 | 121-pin connector |
| 131 | Earth connection -2-, in engine compartment wiring harness |
| 608 | Earth point, in centre of plenum chamber |
| * | connection for radiator fan control unit/ radiator fan relay |
| ** | connection air conditioning |
| J104 | ABS/ABS control unit with EDL |
| J217 | Automatic gearbox control unit |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10w | 10-pin connector, white, in connector protective housing, on left in plenum chamber |
| T25 | 25-pin connector, on ABS/ABS control unit with EDL |
| T47 | 47-pin connector, on ABS with EDL control unit /TCS/ESP (up to July 2000) |
| T47a | 47-pin connector, on ABS/ ABS with EDL control unit /TCS/ESP (up to August 2000) |
| T68a | 68-pin connector, models with 5-speed automatic gearbox (AG5) |
| T121 | 121-pin connector |
| A121 | Connection (high bus), in dash panel wiring harness |
| A122 | Connection (low bus), in dash panel wiring harness |
| --- | models with automatic gearbox only |
| G40 | Hall sender (for camshaft position) |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| N240 | Unit injector valve, No. 1 cyl. |
| N241 | Unit injector valve, No. 2 cyl. |
| N242 | Unit injector valve, No. 3 cyl. |
| N243 | Unit injector valve, No. 4 cyl. |
| T3a | 3-pin connector, on front of engine |
| T8 | 8-pin connector, in left engine compartment |
| T121 | 121-pin connector |
| D101 | Connection -1-, in engine compartment wiring harness |
| G70 | Air mass meter |
| G81 | Fuel temperature sender |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| N18 | Exhaust gas recirculation valve |
| N75 | Charge pressure control solenoid valve |
| N239 | Variable intake manifold flap change-over valve |
| T5 | 5-pin connector |
| T10f | 10-pin connector, in front engine compartment |
| T10w | 10-pin connector, white, in connector protective housing, on left in plenum chamber |
| T121 | 121-pin connector |
| E29 | Connection, in engine compartment wiring harness |
| E45 | Cruise control system switch** |
| E227 | Cruise control system (CCS) SET button** |
| F36 | Clutch pedal switch |
| J217 | Automatic gearbox control unit |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| T10 | 10-pin connector, orange, in connector protective housing, on left in plenum chamber |
| T10e | 10-pin connector, black, in connector protective housing, on left in plenum chamber |
| T10s | 10-pin connector, next to steering column |
| T10w | 10-pin connector, white, in connector protective housing, on left in plenum chamber |
| T68a | 68-pin connector, models with 5-speed automatic gearbox (AG5) |
| T121 | 121-pin connector |
| A27 | Connection (speed signal), in dash panel wiring harness |
| A155 | Connection 2 (86), in dash panel wiring harness |
| * | only models with manual gearbox |
| ** | only models with GND |
| --- | models with automatic gearbox only |
| F | Brake light switch |
| F47 | Cruise control system brake pedal switch/diesel direct injection system |
| J248 | Diesel direct injection system control unit, in centre plenum chamber |
| J359 | Low heat output relay*, in protective housing on left in engine compartment (53) |
| J360 | High heat output relay*, in protective housing on left in engine compartment (100) |
| Q7 | Glow plugs, coolant* |
| S13 | Fuse 13 in fuse holder |
| T6 | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T10e | 10-pin connector, black, in connector protective housing, on left in plenum chamber |
| T10w | 10-pin connector, white, in connector protective housing, on left in plenum chamber |
| T121 | 121-pin connector |
| A18 | Connection (54), in dash panel wiring harness |
| A155 | Connection 2 (86), in dash panel wiring harness |
| D50 | Positive connection (30), in engine compartment wiring harness |
| D98 | Connection (glow plugs), in engine compartment wiring harness |
| * | only models with manual gearbox |
| ** | from September 2000 |
| G | Fuel gauge sender*** |
| G6 | Fuel pump (pre-supply pump) |
| J17 | Fuel pump relay, on additional relay carrier above the relay plate |
| S228 | Fuse 28 in fuse holder |
| S232 | Fuse 32 in fuse holder |
| S234 | Fuse 34 in fuse holder |
| S243 | Fuse 43 in fuse holder |
| T6 | 6-pin connector, brown, in connector protective housing, on left in plenum chamber |
| T14a | 14-pin connector, near battery |
| 42 | Earth point, next to steering column |
| 81 | Earth connection 1, in dash panel wiring harness |
| 269 | Earth connection (sender earth) 1, in engine compartment wiring harness |
| A71 | Connection (86), in dash panel wiring harness |
| A100 | Connection 2 (87), in dash panel wiring harness |
| B168 | Connection (86), in interior wiring harness |
| * | from May 2000 |
| ** | from September 2000 |
| -•-- | up to April 2000 |
| -••- | up August 2000 |
| *** | models with four-wheel drive ⇒ four-wheel drive Current Flow Diagram |
| F1 | Oil pressure switch |
| G22 | Speedometer sender (Hall sender, on gearbox) |
| G32 | Coolant shortage indicator sender |
| G266 | Oil level and oil temperature sender*** |
| J217 | Automatic gearbox control unit |
| S5 | Fuse 5 in fuse holder |
| S7 | Fuse 7 in fuse holder |
| T10h | 10-pin connector, blue, in connector protective housing, on left in plenum chamber |
| T14a | 14-pin connector, near battery |
| T68a | 68-pin connector, models with 5-speed automatic gearbox (AG5) |
| 85 | Earth connection 1, in engine compartment wiring harness |
| 269 | Earth connection (sender earth) 1, in engine compartment wiring harness |
| 608 | Earth point, in centre of plenum chamber |
| A20 | Connection (15a), in dash panel wiring harness |
| B163 | Positive connection 1 (15), in interior wiring harness |
| * | only models with manual gearbox |
| *** | only flexible service interval display |
| --- | models with automatic gearbox only |
| G1 | Fuel gauge |
| G3 | Coolant temperature gauge |
| G5 | Rev. counter |
| J285 | Control unit with display in dash panel insert |
| K3 | Oil pressure warning lamp |
| K28 | Coolant temperature/coolant shortage warning lamp |
| K38 | Oil level warning lamp*** |
| K105 | Reserve fuel warning lamp |
| T12a | 12-pin connector, Climatronic connection only |
| T32 | 32-pin connector, blue |
| T32a | 32-pin connector, green |
| * | only models with manual gearbox |
| ** | from September 2000 |
| -••- | up August 2000 |
| *** | only flexible service interval display |
| --- | models with automatic gearbox only |
| E86 | Multifunction display call-up button |
| E109 | Multifunction display memory switch |
| G17 | Ambient temperature sensor |
| G21 | Speedometer |
| H3 | Warning buzzer |
| J119 | Multifunction display |
| J285 | Control unit with display in dash panel insert |
| J533 | Data bus diagnostic interface, in dash panel insert |
| K2 | Alternator warning lamp |
| K29 | Glow period warning lamp |
| K31 | Cruise control system warning lamp |
| T6e | 6-pin connector |
| T16 | 16-pin connector, in centre dash panel, self-diagnosis connection |
| T32 | 32-pin connector, blue |
| T32a | 32-pin connector, green |
| 42 | Earth point, next to steering column |
| 49 | Earth point, on top end of steering column |
| 135 | Earth connection 2, in dash panel wiring harness |
| A27 | Connection (speed signal), in dash panel wiring harness |
| A76 | Connection (diagnosis wire K), in dash panel wiring harness |
| * | from May 2000 |
| ** | from September 2000 |
Čeština
Dansk
Deutsch
English
English
Español
Suomi
Français
Français
עברית
Hrvatski
Magyar
Italiano
日本語
한국어
Nederlands
Polski
Português
Português
Română
Русский
Slovenčina
Slovenščina
Svenska
Türkçe
中文 (中国)
