Wiring Diagram VW TOURAN 2005 - Battery - starter - alternator - fuses SA1 - SA2 - SA3
A | Battery |
B | Starter |
C | Alternator |
J293 | Radiator fan control unit |
J500 | Power steering control unit |
J519 | Onboard supply control unit |
SA1 | Fuse 1 on fuse holder A |
SA2 | Fuse 2 on fuse holder A |
SA3 | Fuse 3 on fuse holder A |
T2ab | 2-pin connector |
T4x | 4-pin connector, on lower left of radiator fan |
V187 | Electromechanical power steering motor |
1 | Earth strap, battery - body |
12 | Earth point, on left in engine compartment |
508 | Screw connection (30), on electronics box |
652 | Earth point for engine and gearbox earth |
D50 | Positive connection (30), in engine compartment wiring harness |
* | only models with 90 A/ 110 A alternator |
** | only models with 140 A alternator |
*** | ⇒ Engine Current Flow Diagram |
-•- | only for models with increased blower output |
Wiring Diagram VW TOURAN 2005 - Fuses SA4 - SA5 - SA6 - SA7
J519 | Onboard supply control unit |
SA4 | Fuse 4 on fuse holder A |
SA5 | Fuse 5 on fuse holder A |
SA6 | Fuse 6 on fuse holder A |
SA7 | Fuse 7 on fuse holder A |
T2af | 2-pin connector, pre-installation for two-way radio voltage supply, in spare wheel well in luggage compartment |
* | Models with optional equipment only |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Terminal 15 voltage supply relay - fuses SB27 - SB39 - SB40 - SB41
G266 | Oil level and oil temperature sender |
J285 | Control unit in dash panel insert |
J329 | Terminal 15 voltage supply relay, on electronics box, on left in engine compartment (433) |
J519 | Onboard supply control unit |
N79 | Heater element for crankcase breather |
SB27 | Fuse 27 on fuse holder B |
SB39 | Fuse 39 on fuse holder B |
SB40 | Fuse 40 on fuse holder B |
SB41 | Fuse 41 on fuse holder B |
T6z | 6-pin connector, near left headlight |
T14a | 14-pin connector, near battery |
T26 | 26-pin connector |
T36 | 36-pin connector |
T40 | 40-pin connector |
376 | Earth connection 11, in main wiring harness |
381 | Earth connection 16, in main wiring harness |
655 | Earth point, on left headlight |
B163 | Positive connection 1 (15), in interior wiring harness |
B277 | Positive connection 1 (15a), in main wiring harness |
* | not for all engine variants |
-•- | only models without oil level and oil temperature sender |
Wiring Diagram VW TOURAN 2005 - Fuses SB28 - SB29 - SB43
F125 | Multifunction switch |
J217 | Automatic gearbox control unit |
J519 | Onboard supply control unit |
N70 | Ignition coil 1 with output stage |
N127 | Ignition coil 2 with output stage |
N291 | Ignition coil 3 with output stage |
N292 | Ignition coil 4 with output stage |
SB28 | Fuse 28 on fuse holder B |
SB29 | Fuse 29 on fuse holder B |
SB43 | Fuse 43 on fuse holder B |
T6ab | 6-pin connector |
T10s | 10-pin connector, on gearbox |
T10t | 10-pin connector, in left engine compartment |
T14a | 14-pin connector, near battery |
T26 | 26-pin connector |
T40 | 40-pin connector |
T52 | 52-pin connector |
V192 | Vacuum pump for brakes |
D52 | Positive connection (15a), in engine compartment wiring harness |
D136 | Positive connection 2 (15a), in engine compartment wiring harness |
* | engine codes BLP, BAG only |
** | not for models with hydraulic brake servo (HBV) |
--- | models with 6-speed automatic gearbox 09G only |
-•- | engine codes BLX, BLY, BJB only |
Wiring Diagram VW TOURAN 2005 - Terminal 50 voltage supply relay - fuses SB15 - SB38 - SB42
E102 | Headlight range control regulator |
G70 | Air mass meter |
J248 | Diesel direct injection system control unit |
J361 | Simos control unit, in centre plenum chamber |
J519 | Onboard supply control unit |
J682 | Terminal 50 voltage supply relay, on electronics box, in left engine compartment (433) |
SB15 | Fuse 15 on fuse holder B |
SB38 | Fuse 38 on fuse holder B |
SB42 | Fuse 42 on fuse holder B |
T5d | 5-pin connector |
T8e | 8-pin connector |
T10i | 10-pin connector, on left of headlight |
T10j | 10-pin connector, on right of headlight |
T12b | 12-pin connector, in connector protective housing, on left in plenum chamber |
T14b | 14-pin connector, near left headlight |
T26 | 26-pin connector |
T40 | 40-pin connector |
T60 | 60-pin connector |
T121 | 121-pin connector |
V48 | Left headlight range control motor |
V49 | Right headlight range control motor |
A41 | Positive connection (50), in dash panel wiring harness |
B455 | Connection (HRC), in main wiring harness |
* | only models with diesel engine |
*** | ⇒ Engine Current Flow Diagram |
-••- | models without automatic headlight range control only |
Wiring Diagram VW TOURAN 2005 - Fuel pump relay - fuses SB32 - SB42 - SB44 - SB45
G39 | Lambda probe |
G130 | Lambda probe after catalytic converter |
J361 | Simos control unit, in centre plenum chamber |
J519 | Onboard supply control unit |
J757 | Engine component current supply relay |
N30 | Injector, cylinder 1 |
N31 | Injector, cylinder 2 |
N32 | Injector, cylinder 3 |
N33 | Injector, cylinder 4 |
SB32 | Fuse 32 on fuse holder B |
SB42 | Fuse 42 on fuse holder B |
SB44 | Fuse 44 on fuse holder B |
SB45 | Fuse 45 on fuse holder B |
T4v | 4-pin connector, near lambda probe |
T6w | 6-pin connector, near lambda probe |
T14a | 14-pin connector, near battery |
T26 | 26-pin connector |
T40 | 40-pin connector |
T121 | 121-pin connector |
D95 | Connection (injectors), in engine compartment wiring harness |
E30 | Connection (87a), in engine wiring harness |
* | engine code BGU only |
Wiring Diagram VW TOURAN 2005 - Fuses SB33 - SB46 - SB47 - SB48 - SB50 - SB51
G6 | Fuel system pressurisation pump |
J17 | Fuel pump relay |
J179 | Automatic glow period control unit, under electronics box, in left engine compartment (461) |
J299 | Secondary air pump relay |
J519 | Onboard supply control unit |
Q10 | Glow plug 1 |
Q11 | Glow plug 2 |
Q12 | Glow plug 3 |
Q13 | Glow plug 4 |
SB33 | Fuse 33 on fuse holder B |
SB46 | Fuse 46 on fuse holder B |
SB47 | Fuse 47 on fuse holder B |
SB48 | Fuse 48 on fuse holder B |
SB50 | Fuse 50 on fuse holder B |
SB51 | Fuse 51 on fuse holder B |
T5a | 5-pin connector |
T10r | 10-pin connector, on left of cylinder head |
T14b | 14-pin connector, near left headlight |
T26 | 26-pin connector |
T40 | 40-pin connector |
V101 | Secondary air pump motor |
A193 | Connection (87a), in dash panel wiring harness |
* | engine codes BKD, AZV only |
** | engine code BGU only |
Wiring Diagram VW TOURAN 2005 - Terminal 30 voltage supply relay - fuses SB7 - SB26
F47 | Brake pedal switch |
G476 | Clutch position sender |
J220 | Motronic control unit |
J248 | Diesel direct injection system control unit |
J317 | Terminal 30 voltage supply relay, on electronics box, on left in engine compartment (458) |
J361 | Simos control unit |
J519 | Onboard supply control unit |
SB7 | Fuse 7 on fuse holder B |
SB26 | Fuse 26 on fuse holder B |
T5m | 5-pin connector |
T26 | 26-pin connector |
T40 | 40-pin connector |
T94 | 94-pin connector |
T121 | 121-pin connector |
131 | Earth connection 2, in engine compartment wiring harness |
607 | Earth point, on left in plenum chamber |
A38 | Positive connection 2 (15a), in dash panel wiring harness |
D52 | Positive connection (15a), in engine compartment wiring harness |
D78 | Positive connection 1 (30a), in engine compartment wiring harness |
* | only models with diesel engine |
** | engine code BGU only |
--- | models with 6-speed automatic gearbox 09G/ direct shift gearbox 02E only |
-•- | models with petrol engine only (not for engine codes BGU) |
Wiring Diagram VW TOURAN 2005 - Fuses SB6 - SB8
F265 | Map-controlled engine cooling system thermostat |
J293 | Radiator fan control unit |
J519 | Onboard supply control unit |
N18 | Exhaust gas recirculation valve |
N80 | Activated charcoal filter system solenoid valve 1 |
N152 | Ignition transformer |
N156 | Variable intake manifold change-over valve |
N205 | Inlet camshaft control valve 1 |
N276 | Fuel pressure regulating valve |
N316 | Intake manifold flap valve |
SB6 | Fuse 6 on fuse holder B |
SB8 | Fuse 8 on fuse holder B |
T4aa | 4-pin connector |
T4x | 4-pin connector, on lower left of radiator fan |
T6y | 6-pin connector |
T14a | 14-pin connector, near battery |
T40 | 40-pin connector |
V157 | Intake manifold flap motor |
D180 | Connection (87a), in engine compartment wiring harness |
D181 | Connection 2 (87a), in engine compartment wiring harness |
* | engine codes BAG, BLP, BLX, BLY, BJB only |
** | only models with petrol engine ⇒ Engine Current Flow Diagram |
*** | only models with diesel engine |
-•- | engine code BGU only |
Wiring Diagram VW TOURAN 2005 - Fuses SB9 - SB10
G130 | Lambda probe after catalytic converter |
G131 | Lambda probe 2 after catalytic converter |
G287 | Lambda probe 3 after catalytic converter |
J17 | Fuel pump relay |
J299 | Secondary air pump relay |
J519 | Onboard supply control unit |
J583 | NOx sensor control unit |
N18 | Exhaust gas recirculation valve |
N75 | Charge pressure control solenoid valve |
N345 | Exhaust gas recirculation cooler change-over valve |
SB9 | Fuse 9 on fuse holder B |
SB10 | Fuse 10 on fuse holder B |
T4an | 4-pin connector, near lambda probe |
T4ao | 4-pin connector, near lambda probe |
T4v | 4-pin connector, near lambda probe |
T5e | 5-pin connector |
T6ac | 6-pin connector |
T6ae | 6-pin connector |
T11 | 11-pin connector, in connector protective housing, on left in plenum chamber |
T26 | 26-pin connector |
D102 | Connection 2, in engine compartment wiring harness |
D183 | Connection 4 (87a), in engine compartment wiring harness |
E7 | Connection (87a), in Motronic wiring harness |
* | engine code BLY only |
*** | only models with diesel engine |
--- | engine codes BLX, BJB only |
-•- | engine code BGU only |
-••- | engine code BJB only |
Wiring Diagram VW TOURAN 2005 - Fuses SB11 - SB12
G39 | Lambda probe |
G108 | Lambda probe 2 |
J220 | Motronic control unit |
J248 | Diesel direct injection system control unit |
J361 | Simos control unit |
J519 | Onboard supply control unit |
J583 | NOx sensor control unit |
SB11 | Fuse 11 on fuse holder B |
SB12 | Fuse 12 on fuse holder B |
T6af | 6-pin connector, near lambda probe |
T6w | 6-pin connector, near lambda probe |
T10m | 10-pin connector |
T26 | 26-pin connector |
T94 | 94-pin connector |
T121 | 121-pin connector |
D182 | Connection 3 (87a), in engine compartment wiring harness |
E30 | Connection (87a), in engine wiring harness |
* | engine codes BAG, BLP, BLX, BJB only ⇒ Engine Current Flow Diagram |
** | only models with petrol engine BGU |
*** | only models with diesel engine |
--- | engine code BLY only |
Wiring Diagram VW TOURAN 2005 - Fuses SB1 - SB2 - SB3 - SB13 - SB14 - SB16 - SB17
J104 | ABS control unit |
J285 | Control unit in dash panel insert |
J519 | Onboard supply control unit |
J527 | Steering column electronics control unit |
J743 | Mechatronics for direct shift gearbox |
SB1 | Fuse 1 on fuse holder B |
SB2 | Fuse 2 on fuse holder B |
SB3 | Fuse 3 on fuse holder B |
SB13 | Fuse 13 on fuse holder B |
SB14 | Fuse 14 on fuse holder B |
SB16 | Fuse 16 on fuse holder B |
SB17 | Fuse 17 on fuse holder B |
T4q | 4-pin connector |
T20d | 20-pin connector |
T20e | 20-pin connector |
T26 | 26-pin connector |
T26a | 26-pin connector, on ABS control unit with TCS |
T36 | 36-pin connector |
T40 | 40-pin connector |
T47 | 47-pin connector, on ABS control unit with EDL/ESP |
T47a | 47-pin connector, on ABS control unit with TCS HBV |
V217 | Front passenger side windscreen wiper motor |
D104 | Positive connection 2 (30a), in engine compartment wiring harness |
* | only models with ESP |
** | models with ESP and 6-speed automatic gearbox only |
Wiring Diagram VW TOURAN 2005 - Dual tone horn relay - fuses SB4 - SB5 - SB19 - SB20 - SB21 - SB22 - SB23
H2 | Treble tone horn |
H7 | Bass tone horn |
J4 | Dual tone horn relay (449) |
J412 | Mobile telephone operating electronics control unit |
J503 | Control unit with display for radio and navigation system |
J519 | Onboard supply control unit |
R | Radio |
SB4 | Fuse 4 on fuse holder B |
SB5 | Fuse 5 on fuse holder B |
SB19 | Fuse 19 on fuse holder B |
SB20 | Fuse 20 on fuse holder B |
SB21 | Fuse 21 on fuse holder B |
SB22 | Fuse 22 on fuse holder B |
SB23 | Fuse 23 on fuse holder B |
T8j | 8-pin connector |
T16b | 16-pin connector |
T18d | 18-pin connector |
T40 | 40-pin connector |
A90 | Connection (dual tone horn), in dash panel wiring harness |
B224 | Connection 1 (radio), in interior wiring harness |
* | only models with dual tone horn |
** | Radio and navigation system only (commercial equipment) |
--- | only models with treble tone horn |
Wiring Diagram VW TOURAN 2005 - Fuses SB18 - SB24 - SB25 - SB30 - SB31
J364 | Auxiliary heater control unit |
J519 | Onboard supply control unit |
J533 | Data bus diagnostic interface |
J608 | Special vehicle control unit |
R12 | Amplifier |
SB18 | Fuse 18 on fuse holder B |
SB24 | Fuse 24 on fuse holder B |
SB25 | Fuse 25 on fuse holder B |
SB30 | Fuse 30 on fuse holder B |
SB31 | Fuse 31 on fuse holder B |
T2g | 2-pin connector |
T4q | 4-pin connector |
T20 | 20-pin connector |
T23 | 23-pin connector |
T26 | 26-pin connector |
T40 | 40-pin connector |
T88 | 88-pin connector |
V216 | Driver side windscreen wiper motor |
A164 | Positive connection 2 (30a), in dash panel wiring harness |
V21 | Positive connection (30), in radio - amplifier wiring harness |
X61 | Positive connection (30), in optional equipment wiring harness |
* | only optimal equipment, driving school vehicle |
** | only optimal equipment, taxi |
-•- | only optimal equipment police and german special police |
Wiring Diagram VW TOURAN 2005 - Fuses S34 - SB35 - SB36 - SB37 - SB53 - SB54
J293 | Radiator fan control unit |
J519 | Onboard supply control unit |
SB34 | Fuse 34 on fuse holder B |
SB35 | Fuse 35 on fuse holder B |
SB36 | Fuse 36 on fuse holder B |
SB37 | Fuse 37 on fuse holder B |
SB53 | Fuse 53 on fuse holder B |
SB54 | Fuse 54 on fuse holder B |
T4x | 4-pin connector, radiator fan connection |
T26 | 26-pin connector |
T40 | 40-pin connector |
* | only for vehicles with front and rear window regulator |
--- | only for models with low blower output |
Wiring Diagram VW TOURAN 2005 - X-contact relief relay - fuses SB49 - SB52
J59 | X-contact relief relay (460) |
J519 | Onboard supply control unit |
SB49 | Fuse 49 on fuse holder B |
SB52 | Fuse 52 on fuse holder B |
T40 | 40-pin connector |
B546 | Positive connection (30a), in driving school vehicle wiring harness |
* | only optimal equipment, driving school vehicle |
** | only optimal equipment, taxi |
*** | only optimal equipment, german special police |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC1 - SC2 - SC3 - SC4 - SC5
E16 | Heater/heat output switch |
G65 | High pressure sender |
J131 | Heated driver seat control unit |
J132 | Heated front passenger seat control unit |
J255 | Climatronic control unit |
J345 | Trailer detector control unit |
J519 | Onboard supply control unit |
J538 | Fuel pump control unit |
SC1 | Fuse 1 on fuse holder C |
SC2 | Fuse 2 on fuse holder C |
SC3 | Fuse 3 on fuse holder C |
SC4 | Fuse 4 on fuse holder C |
SC5 | Fuse 5 on fuse holder C |
T3c | 3-pin connector |
T6c | 6-pin connector, under driver seat |
T6d | 6-pin connector |
T6e | 6-pin connector, under front passenger seat |
T6f | 6-pin connector |
T8c | 8-pin connector |
T10q | 10-pin connector |
T12m | 12-pin connector |
T20c | 20-pin connector |
Y7 | Automatic anti-dazzle interior mirror |
A20 | Positive connection (15a), in dash panel wiring harness |
O5 | Connection 1 (15a), in seat heating wiring harness |
* | only models with Climatic and without auxiliary coolant heater |
** | only models with auxiliary coolant heater |
*** | only models with Climatronic |
--- | only models without air conditioning system |
Wiring Diagram VW TOURAN 2005 - Fuses SC6 - SC9 - SC10 - SC11 - SC12
E313 | Selector lever |
F189 | Tiptronic switch |
J234 | Airbag control unit |
J412 | Mobile telephone operating electronics control unit |
J500 | Power steering control unit |
J519 | Onboard supply control unit |
J587 | Selector lever sensors control unit |
J743 | Mechatronics for direct shift gearbox |
K145 | Front passenger side airbag deactivated warning lamp |
SC6 | Fuse 6 on fuse holder C |
SC9 | Fuse 9 on fuse holder C |
SC10 | Fuse 10 on fuse holder C |
SC11 | Fuse 11 on fuse holder C |
SC12 | Fuse 12 on fuse holder C |
T4al | 4-pin connector |
T5b | 5-pin connector |
T6z | 6-pin connector, left headlight |
T10u | 10-pin connector, under selector lever cover |
T11 | 11-pin connector, in connector protective housing, on left in plenum chamber |
T18d | 18-pin connector |
T20e | 20-pin connector |
T75 | 75-pin connector |
A200 | Positive connection 5 (15a), in dash panel wiring harness |
A203 | Positive connection 7 (15a), in dash panel wiring harness |
* | models without front passenger airbag deactivation only |
-••- | models with 6-speed automatic gearbox 09G only |
Wiring Diagram VW TOURAN 2005 - Fuses SC13 - SC14 - SC15 - SC16
E132 | Traction control system switch |
E256 | TCS and ESP button |
E492 | Tyre pressure monitor display button |
F4 | Reversing light switch |
J104 | ABS control unit |
J431 | Headlight range control, control unit |
J503 | Control unit with display for radio and navigation system (commercial equipment) |
J519 | Onboard supply control unit |
J533 | Data bus diagnostic interface |
SC13 | Fuse 13 on fuse holder C |
SC14 | Fuse 14 on fuse holder C |
SC15 | Fuse 15 on fuse holder C |
SC16 | Fuse 16 on fuse holder C |
T6ap | 6-pin connector |
T8j | 8-pin connector |
T12b | 12-pin connector, in connector protective housing, on left in plenum chamber |
T16 | 16-pin connector, under dash panel left behind storage compartment, diagnosis connection |
T20 | 20-pin connector |
T26a | 26-pin connector, on ABS control unit with TCS |
T26b | 26-pin connector |
T47 | 47-pin connector, on ABS control unit with EDL/ESP |
T47a | 47-pin connector, on ABS control unit with TCS HBV |
A192 | Positive connection 3 (15a), in dash panel wiring harness |
A199 | Positive connection 4 (15a), in dash panel wiring harness |
* | only models with tyre pressure monitor display |
--- | only models with auxiliary coolant heater |
Wiring Diagram VW TOURAN 2005 - Fuses SC17 - SC25 - SC26 - SC27
E72 | 2-way radio switch |
E247 | Switch to trip alarm |
E487 | Hands-free system button |
E501 | Hands-free system button 1 |
E502 | 2-way radio loudspeaker volume control 1 |
E503 | 2-way radio loudspeaker volume control 2 |
E505 | Special signal system change-over button |
E523 | Menu selection button, forwards |
G41 | Taxi meter |
G511 | Mirror taxi meter |
J220 | Motronic control unit |
J248 | Diesel direct injection system control unit |
J519 | Onboard supply control unit |
J753 | Data transmission control unit |
SC17 | Fuse 17 on fuse holder C |
SC25 | Fuse 25 on fuse holder C |
SC26 | Fuse 26 on fuse holder C |
SC27 | Fuse 27 on fuse holder C |
T6ak | 6-pin connector |
T6al | 6-pin connector |
T6an | 6-pin connector |
T12b | 12-pin connector, in connector protective housing, on left in plenum chamber |
T94 | 94-pin connector |
A192 | Positive connection 3 (15a), in dash panel wiring harness |
X55 | Positive connection (15), in optional equipment wiring harness |
X129 | Positive connection 1 (15), in taxi wiring harness |
* | only optimal equipment, german special police |
** | only optimal equipment, taxi |
*** | engine code BGU only |
Wiring Diagram VW TOURAN 2005 - Fuses SC18 - SC19
G41 | Taxi meter |
G511 | Mirror taxi meter |
E502 | 2-way radio loudspeaker volume control 1 |
E503 | 2-way radio loudspeaker volume control 2 |
J519 | Onboard supply control unit |
J601 | Taxi alarm remote control, control unit |
J753 | Data transmission control unit |
R8 | Two-way radio |
SC18 | Fuse 18 on fuse holder C |
SC19 | Fuse 19 on fuse holder C |
T6ak | 6-pin connector |
T6al | 6-pin connector |
T6an | 6-pin connector |
T6w | 6-pin connector, optimal equipment connection |
T8k | 8-pin connector, coupling point tachograph, near ashtray |
T10aa | 10-pin connector, special signal system, in radio shaft |
T10v | 10-pin connector |
A192 | Positive connection 3 (15a), in dash panel wiring harness |
X60 | Positive connection 2 (15a), in optional equipment wiring harness |
X61 | Positive connection (30), in optional equipment wiring harness |
X82 | Positive connection 1 (30a), in taxi wiring harness |
* | only optimal equipment, driving school vehicle |
** | only optimal equipment, taxi |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC18 - SC19 - SC36 - SC37 - SC38
J519 | Onboard supply control unit |
SC18 | Fuse 18 on fuse holder C |
SC19 | Fuse 19 on fuse holder C |
SC36 | Fuse 36 on fuse holder C |
SC37 | Fuse 37 on fuse holder C |
SC38 | Fuse 38 on fuse holder C |
T2y | 2-pin connector, coupling point voltage supply special signal system, in front right engine compartment |
T8k | 8-pin connector, coupling point tachograph, near ashtray |
T10aa | 10-pin connector, special signal system, in radio shaft |
T33 | 33-pin connector, coupling point special vehicle control unit, under the seat on front left |
W18 | Luggage compartment light on left |
X61 | Positive connection (30), in optional equipment wiring harness |
X116 | Positive connection 2 (30), in optional equipment wiring harness |
X141 | Positive connection 4 (30a), in siren wiring harness |
X147 | Positive connection 6 (30), in optional equipment wiring harness |
X148 | Positive connection 7 (30), in optional equipment wiring harness |
*** | only optimal equipment, german special police |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC7 - SC8 - SC28 - SC29 - SC30 - SC31 - SC34
E1 | Light switch |
E16 | Heater/heat output switch |
E295 | Footwell light switch |
E296 | Warning buzzer switch |
J255 | Climatronic control unit |
J301 | Air conditioning system control unit |
J519 | Onboard supply control unit |
J746 | Driving school mode relay |
SC7 | Fuse 7 on fuse holder C |
SC8 | Fuse 8 on fuse holder C |
SC28 | Fuse 28 on fuse holder C |
SC29 | Fuse 29 on fuse holder C |
SC30 | Fuse 30 on fuse holder C |
SC31 | Fuse 31 on fuse holder C |
SC34 | Fuse 34 on fuse holder C |
T4u | 4-pin connector |
T6y | 6-pin connector |
T6z | 6-pin connector |
T10d | 10-pin connector, coupling point on right roof of rear lid |
T10f | 10-pin connector, coupling point, on right in rear lid |
T10h | 10-pin connector |
T20c | 20-pin connector |
V12 | Rear window wiper motor |
B545 | Positive connection (15a), in driving school vehicle wiring harness |
* | only optimal equipment, driving school vehicle |
Wiring Diagram VW TOURAN 2005 - Fuses SC32 - SC33 - SC35
E16 | Heater/heat output switch |
J301 | Air conditioning system control unit |
J485 | Auxiliary heater operation relay (53) |
J519 | Onboard supply control unit |
SC32 | Fuse 32 on fuse holder C |
SC33 | Fuse 33 on fuse holder C |
SC35 | Fuse 35 on fuse holder C |
T2al | 2-pin connector, coupling point loading device, under the seat on front right |
T2ar | 2-pin connector, coupling point loading device, under the seat on front right |
T2t | 2-pin connector |
T2u | 2-pin connector |
T5 | 5-pin connector |
T10k | 10-pin connector, on heater |
Z20 | Left washer jet heater element |
Z21 | Right washer jet heater element |
44 | Earth point, lower part of left A-pillar |
238 | Earth connection 1, in interior wiring harness |
366 | Earth connection 1, in main wiring harness |
C14 | Positive connection (15), in heated washer jet wiring harness |
* | only optimal equipment, german special police |
--- | only models with auxiliary coolant heater with can operated independently |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC20 - SC21 - SC24
E1 | Light switch |
E16 | Heater/heat output switch |
E313 | Selector lever |
F189 | Tiptronic switch |
J104 | ABS control unit |
J217 | Automatic gearbox control unit |
J255 | Climatronic control unit |
J301 | Air conditioning system control unit |
J519 | Onboard supply control unit |
J587 | Selector lever sensors control unit |
SC20 | Fuse 20 on fuse holder C |
SC21 | Fuse 21 on fuse holder C |
SC24 | Fuse 24 on fuse holder C |
T10h | 10-pin connector |
T10t | 10-pin connector, in left engine compartment |
T10u | 10-pin connector, under selector lever cover |
T16 | 16-pin connector, under dash panel left behind storage compartment, diagnosis connection |
T20c | 20-pin connector |
T47a | 47-pin connector |
T52 | 52-pin connector |
A167 | Positive connection 3 (30a), in dash panel wiring harness |
B231 | Positive connection 5 (30a), in interior wiring harness |
* | Models with optional equipment only |
--- | models with 6-speed automatic gearbox 09G only |
Wiring Diagram VW TOURAN 2005 - Fuses SC22 - SC23 - SC43 - SC45 - SC48
F | Brake light switch |
J131 | Heated driver seat control unit |
J132 | Heated front passenger seat control unit |
J515 | Aerial selection control unit |
J519 | Onboard supply control unit |
J538 | Fuel pump control unit |
J757 | Engine component current supply relay |
R149 | Remote control receiver for auxiliary coolant heater |
SC22 | Fuse 22 on fuse holder C |
SC23 | Fuse 23 on fuse holder C |
SC43 | Fuse 43 on fuse holder C |
SC45 | Fuse 45 on fuse holder C |
SC48 | Fuse 48 on fuse holder C |
T3q | 3-pin connector |
T4y | 4-pin connector |
T6c | 6-pin connector, under driver seat |
T6d | 6-pin connector |
T6e | 6-pin connector, under front passenger seat |
T6f | 6-pin connector |
T6j | 6-pin connector |
T10q | 10-pin connector |
B156 | Positive connection (30a), in interior wiring harness |
O10 | Positive connection 2 (30as), in seat heating wiring harness |
* | models with petrol engine only (not for engine codes BGU) |
** | engine code BGU only |
*** | only models with diesel engine |
Wiring Diagram VW TOURAN 2005 - Fuses SC42 - SC44 - SC46 - SC47
G273 | Interior monitoring sensor |
G384 | Vehicle inclination sender |
H12 | Alarm horn |
J519 | Onboard supply control unit |
SC42 | Fuse 42 on fuse holder C |
SC44 | Fuse 44 on fuse holder C |
SC46 | Fuse 46 on fuse holder C |
SC47 | Fuse 47 on fuse holder C |
T3 | 3-pin connector |
T3g | 3-pin connector |
T3h | 3-pin connector |
T3i | 3-pin connector |
T4j | 4-pin connector |
T4k | 4-pin connector |
U1 | Cigarette lighter |
U5 | 12 V socket |
U9 | Rear cigarette lighter |
A168 | Positive connection 4 (30a), in dash panel wiring harness |
B161 | Connection (ATA), in interior wiring harness |
-•- | only optimal equipment, police |
-••- | only models without interior monitor |
Wiring Diagram VW TOURAN 2005 - Fuses SC49 - SC50
E72 | 2-way radio switch |
E115 | Interior light switch (taxi) |
E138 | Taxi sign switch |
E485 | Taxi alarm active button |
E489 | Engine continues to run without key button |
E505 | Special signal system change-over button |
J386 | Driver side door control unit |
J387 | Front passenger side door control unit |
J393 | Convenience system central control unit |
J519 | Onboard supply control unit |
SC49 | Fuse 49 on fuse holder C |
SC50 | Fuse 50 on fuse holder C |
T18 | 18-pin connector |
T20a | 20-pin connector |
T20b | 20-pin connector |
T28 | 28-pin connector, coupling point, front left A-pillar |
T28a | 28-pin connector, coupling point, front right A-pillar |
A1 | Positive connection (30a), in dash panel wiring harness |
X61 | Positive connection (30), in optional equipment wiring harness |
X127 | Positive connection 3 (30a), in taxi wiring harness |
X136 | Positive connection 1 (30a), in siren wiring harness |
* | only optimal equipment, taxi |
** | only optimal equipment, german special police |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC51 - SC52 - SC53 - SC54 - SC56
J8 | Auxiliary heater relay |
J39 | Headlight washer system relay |
J245 | Sliding sunroof adjustment control unit |
">J446 | ">Parking aid control unit |
J519 | Onboard supply control unit |
SC51 | Fuse 51 on fuse holder C |
SC52 | Fuse 52 on fuse holder C |
SC53 | Fuse 53 on fuse holder C |
SC54 | Fuse 54 on fuse holder C |
SC56 | Fuse 56 on fuse holder C |
T2y | 2-pin connector, coupling point voltage supply special signal system, in front right engine compartment |
T6c | 6-pin connector |
T6t | 6-pin connector |
T10k | 10-pin connector, on heater |
T16c | 16-pin connector |
V2 | Fresh air blower |
V11 | Headlight washer system pump |
A189 | Positive connection 5 (30a), in dash panel wiring harness |
L59 | Positive connection (30), in heater unit wiring harness |
* | only models with auxiliary coolant heater |
-•- | only optimal equipment, police |
Wiring Diagram VW TOURAN 2005 - Fuses SC39 - SC40 - SC41 - SC55
J345 | Trailer detector control unit |
J519 | Onboard supply control unit |
J754 | Accident data memory |
SC39 | Fuse 39 on fuse holder C |
SC40 | Fuse 40 on fuse holder C |
SC41 | Fuse 41 on fuse holder C |
SC55 | Fuse 55 on fuse holder C |
T12m | 12-pin connector |
T26c | 26-pin connector |
X126 | Positive connection 2 (30a), in taxi wiring harness |
X137 | Positive connection 2 (30a), in siren wiring harness |
* | only optimal equipment, taxi |
-•- | only optimal equipment police and german special police |
Wiring Diagram VW TOURAN 2005 - Fuses SC57 - SC58
J386 | Driver side door control unit |
J387 | Front passenger side door control unit |
J388 | Rear left door control unit |
J389 | Rear right door control unit |
J519 | Onboard supply control unit |
SC57 | Fuse 57 on fuse holder C |
SC58 | Fuse 58 on fuse holder C |
T18b | 18-pin connector |
T18c | 18-pin connector |
T20a | 20-pin connector |
T20b | 20-pin connector |
T28 | 28-pin connector, coupling point, left A-pillar |
T28a | 28-pin connector, coupling point, right A-pillar |
T28b | 28-pin connector, coupling point, left B-pillar |
T28c | 28-pin connector, coupling point, right B-pillar |
B266 | Positive connection 1 (30a, door control unit), in interior wiring harness |
B267 | Positive connection 2 (30a, door control unit), in interior wiring harness |
B553 | Positive connection 3 (30a, door control unit), in interior wiring harness |
* | only for vehicles with front and rear window regulator |
VW TOURAN 2005 Overview of control units
1 - | ABS control unit -J104- |
q | 26-pin connector assignment |
q | 47-pin connector assignment |
2 - | Engine control unit -J623- |
q | 121-pin connector assignment |
q | 154-pin connector assignment |
3 - | Aerial selection control unit -J515- |
4 - | Vehicle inclination sender -G384- |
5 - | Convenience system central control unit -J393- |
q | Connector assignment |
6 - | Traffic information control unit -J559- /Chip card reader control unit -J676- |
q | Fitting location |
7 - | Climatronic control unit -J255- |
7 - | Air conditioning system control unit -J301- |
8 - | Control unit in dash panel insert -J285- |
q | Connector assignment 32-pin connector -T32- |
8 - | Traffic data aerial -R173- |
9 - | Steering column electronics control unit -J527- |
q | Fitting location from May 2010 |
q | Connector assignment to May 2010 |
q | Connector assignment from May 2010 |
q | Connector assignment |
11 - | Park assist steering control unit -J791- / Parking aid control unit -J446- |
q | Fitting location |
q | Connector assignment |
12 - | Onboard supply control unit -J519- |
q | Connector assignment to May 2010 |
q | Fitting location from May 2010 |
q | Connector assignment from May 2010 52-pin connector -T52 A--black- |
q | Connector assignment from May 2010 52-pin connector -T52 B--white- |
q | Connector assignment from May 2010 52-pin connector -T52 C--brown- |
q | Connector assignment |
13 - | Mechatronic unit for dual clutch gearbox -J743- |
q | 20-pin connector assignment |
Dual clutch gearbox 0AM: |
q | Fitting location |
q | 25-pin connector assignment |
14 - | Voltage stabiliser -J532- |
15 - | Headlight range control unit -J431- |
q | Connector assignment |
15 - | Control unit for cornering light and headlight range control -J745- |
q | Connector assignment |
q | Connector assignment 75-pin connector -T75- |
q | Connector assignment 50-pin connector -T50- |
17 - | Power steering control unit -J500- |
q | Connector assignment |
q | Fitting location from May 2010 |
|
26-pin connector assignment: |
A - | ABS control unit -J104- |
Connector: |
B - | 26-pin connector -T26a- on wiring harness |
Back to overview |
47-pin connector assignment: |
A - | ABS control unit -J104- |
Connector: |
B - | 47-pin connector -T47- /-T47a- on wiring harness |
Back to overview |
|
121-pin connector assignment: |
A - | Engine control unit -J623- |
Connector: |
B - | 81-pin connector -T81- on wiring harness |
C - | 40-pin connector -T40- on wiring harness |
Note
-T121- is comprised of items B and C. |
Back to overview |
154-pin connector: |
A - | Engine control unit -J623- |
Connector: |
B - | 94-pin connector -T94- on wiring harness |
C - | 60-pin connector -T60- on wiring harness |
Note
-T154- is comprised of items B and C. |
Back to overview |
|
|
Connector assignment: |
A - | Convenience system central control unit -J393- |
Connector: |
B - | 6-pin connector -T6- on wiring harness |
C - | 18-pin connector -T18- on wiring harness |
D - | 8-pin connector -T8- on wiring harness |
E - | 6-pin connector -T6- on wiring harness |
F - | 18-pin connector -T18a- on wiring harness |
Back to overview |
|
|
|
36-pin connector -T36- on wiring harness: |
1 - | Voltage supply positive, terminal 15 |
2 - | Voltage supply positive, terminal 30 |
3 - | Vacant |
4 - | Vacant |
5 - | Brake fluid level warning lamp -K33- |
6 - | Handbrake warning switch -F9- |
7 - | Immobiliser reader coil -D2- |
8 - | Immobiliser reader coil -D2- |
9 - | Speedometer -G21- Output signal on instrument cluster, not assigned in current flow diagram |
10 - | Vacant |
11 - | Vacant |
12 - | Data bus diagnostic interface -J533- Dash panel CAN, low |
13 - | Data bus diagnostic interface -J533- Dash panel CAN, high |
14 - | Vacant |
15 - | Data bus diagnostic interface -J533- Dash panel CAN wake-up wire |
16 - | Vacant |
17 - | Fuel gauge -G1- (full) |
18 - | Fuel gauge -G1- (empty) |
19 - | Earth connection 2, in main wiring harness -367- Terminal 31 |
20 - | Vacant |
21 - | Vacant |
22 - | Front left brake pad wear sender -G34- |
23 - | Vacant |
24 - | Fuel tank flap lock warning lamp |
25 - | Oil pressure switch -F1- |
26 - | Oil level and oil temperature sender -G266- |
27 - | Vacant |
28 - | Sliding sunroof adjustment control unit -J245- ,Control unit with display for radio and navigation -J503- Speedometer signal, output |
29 - | Vacant |
30 - | Vacant |
31 - | Vacant |
32 - | Vacant |
33 - | Earth connection (sender earth) in interior wiring harness -401- |
34 - | Windscreen washer fluid level sender -G33- |
35 - | Coolant shortage indicator sender -G32- |
36 - | Ambient temperature sensor -G17- |
Back to overview |
32-pin connector -T32- on wiring harness: |
1 - | Fuel gauge sender -G- (full) |
2 - | Fuel gauge sender -G- (empty) |
3 - | Vacant |
4 - | Vacant |
5 - | Vacant |
6 - | Vacant |
7 - | Immobiliser reader coil -D2- |
8 - | Immobilizer reader coil 2 -D3- |
9 - | Vacant |
10 - | Vacant |
11 - | Oil level and oil temperature sender -G266- |
12 - | Vacant |
13 - | Vacant |
14 - | Vacant |
15 - | Front left brake pad wear sender -G34- |
16 - | Earth connection 22, in main wiring harness -367- |
17 - | Washer fluid level warning lamp -K37- |
18 - | Coolant temperature and coolant shortage warning lamp -K28- |
19 - | Ambient temperature sensor -G17- |
20 - | Earth connection 1 (sender earth) in main wiring harness -410- |
21 - | Vacant |
22 - | Vacant |
23 - | Vacant |
24 - | Vacant |
25 - | Handbrake warning lamp -K139- |
26 - | Brake fluid level warning lamp -K33- |
27 - | Oil pressure warning lamp -K3- |
28 - | Data bus diagnostic interface -J533- Dash panel CAN, high |
29 - | Data bus diagnostic interface -J533- Dash panel CAN, low |
30 - | Vacant |
31 - | Voltage supply positive, terminal 15 |
32 - | Voltage supply positive, terminal 30a |
Back to overview |
|
|
Connector assignment: |
A - | Steering column electronics control unit -J527- |
B - | Airbag connector: |
1 - | Airbag 1 - |
2 - | Airbag 1+ |
3 - | Airbag 2+ |
4 - | Airbag 2 - |
C - | Connector for turn signal switch -E2- / Headlight dipper and flasher switch -E4- / Cruise control system switch -E45- : |
1 - | Cruise control system terminal 15 voltage supply |
2 - | CCS off |
3 - | Cruise control system (CCS) SET button -E227- Res (+), Set (-) |
4 - | CCS on/off |
5 - | Earth CCS |
6 - | Cruise control system terminal 58 illumination |
7 - | Headlight flasher |
8 - | Main beam |
9 - | Turn signal |
10 - | Turn signal earth |
D - | 20-pin connector -T20d- on wiring harness |
1 - | Taxi two-way radio 2 |
2 - | Taxi two-way radio 1 |
3 - | Taxi alarm 2 |
4 - | Taxi alarm 1 |
5 - | Vacant |
6 - | Vacant |
7 - | Vacant |
8 - | Vacant |
9 - | Vacant |
10 - | Powertrain CAN shielding |
11 - | Data bus diagnostic interface -J533- / Connection 1 (powertrain CAN bus, low), in main wiring harness -B390- |
12 - | Data bus diagnostic interface -J533- / Connection 1 (powertrain CAN bus, high), in main wiring harness -B383- |
13 - | Cruise control system, output |
14 - | Data bus diagnostic interface -J533- / Connection 1 (convenience CAN bus, high), in main wiring harness -B397- |
15 - | Data bus diagnostic interface -J533- / Connection 1 (convenience CAN bus, low), in main wiring harness -B406- |
16 - | Selector lever locked in position P switch -F319- |
17 - | Terminal 15 |
18 - | Terminal 50 |
19 - | Terminal 30 |
20 - | Terminal 31 |
E - | 4-pin connector -T4ak- on wiring harness |
1 - | Airbag 1 - |
2 - | Airbag 1+ |
3 - | Airbag 2+ |
4 - | Airbag 2 - |
F - | 12-pin connector -T12j- / ignition/starter switch -D- / ignition key withdrawal lock solenoid -N376- : |
1 - | Vacant |
2 - | Vacant |
3 - | 2-pin connector -T2dy- / ignition key withdrawal lock solenoid -N376- Terminal 30 |
4 - | 2-pin connector -T2dy- / ignition key withdrawal lock solenoid -N376- Earth |
5 - | Vacant |
6 - | Vacant |
7 - | Ignition/starter switch -D- Terminal 50, output |
8 - | Ignition/starter switch -D- Terminal 30 |
9 - | Ignition/starter switch -D- Terminal S, output |
10 - | Ignition/starter switch -D- Terminal X, output |
11 - | Ignition/starter switch -D- Terminal P, output |
12 - | Ignition/starter switch -D- Terminal 15, output |
G - | Connector for intermittent wiper switch -E22- / sliding sunroof adjustment regulator -E38- / washer pump switch (automatic wash/wipe and headlight washer system) -E44- / multifunction display call-up button -E86- / reset button -E92- : |
1 - | Wiper switch signal |
2 - | Earth wiper |
3 - | Rear lid wash/wipe signal |
4 - | Vacant |
5 - | MFD signal |
6 - | Earth MFD, interval potentiometer |
7 - | Intermittent operation speeds signal |
8 - | Vacant |
H - | Connector for steering angle sender -G85- : |
1 - | Photoelectric beam 5 |
2 - | Photoelectric beam 3 |
3 - | Photoelectric beam 1 |
4 - | 12 Volt voltage supply, steering angle sender |
5 - | 5 Volt voltage supply, steering angle sender |
6 - | Photoelectric beam 6 |
7 - | Photoelectric beam 4 |
8 - | Photoelectric beam 2 |
9 - | Earth |
10 - | Photoelectric beam 7 |
I - | 10-pin connector -T10x- / coil connector -F350- / airbag coil connector and return ring with slip ring -F138- : |
1 - | Vacant |
2 - | Vacant |
3 - | Airbag 1 + |
4 - | Airbag 1 - |
5 - | Airbag 2 + |
6 - | Airbag 2 - |
7 - | Earth for coil connector, multifunction steering wheel and signal horn |
8 - | CCS in detent -Off-, signal horn |
9 - | LIN bus, heated steering wheel temperature sensor |
10 - | Multifunction steering wheel voltage supply terminal 15 |
Back to overview |
Steering column electronics control unit -J527- , from May 2010 |
Fitting location: |
1 - | Steering column electronics control unit -J527- |
Near steering column switch |
Connectors: |
q | -A-16-pin connector -T16k- |
q | -B-4-pin connector -T4k- |
Back to overview |
|
1 - | Fuse 6 on fuse holder B -SB6- via B504 Positive connection 8 (30a) in interior wiring harness |
q | Only models with no start/stop system |
- Fuse 57 on fuse holder C -SC57- via B321 Positive connection 7 (30a) in main wiring harness |
q | Only models with start/stop system |
2 - | 382 Earth connection 17 in main wiring harness |
3 - | B406 Connection 1 (convenience CAN bus, low), in main wiring harness |
4 - | B397 Connection 1 (convenience CAN bus, high), in main wiring harness |
5 - | Engine control unit -J623- , GRA E_A) |
6 - | Onboard supply control unit -J519- , (T52c/14), (terminal 50) |
7 - | Terminal S, vacant |
8 - | Vacant |
9 - | Vacant |
10 - | Vacant |
11 - | Selector lever locked in position P switch -F319- , P locked |
12 - | B390 Connection 1 (powertrain CAN bus, low), in main wiring harness |
13 - | B383 Connection 1 (powertrain CAN bus, high), in main wiring harness |
14 - | Onboard supply control unit -J519- , (T52c/13, T52c/31) |
15 - | Vacant |
16 - | Vacant |
|
1 - | Airbag control unit -J234- , (T50/21), (airbag 1+) |
2 - | Airbag control unit -J234- , (T50/20), (airbag 1–) |
3 - | Vacant |
4 - | Vacant |
Back to overview |
|
|
Connector assignment: |
A - | Data bus diagnostic interface -J533- |
Connector: |
B - | 20-pin connector -T20- on wiring harness |
Back to overview |
|
A - | Park assist steering control unit -J791- / Parking aid control unit -J446- |
B - | Front parking aid warning buzzer -H22- |
Back to overview |
Connector assignment: |
A - | Parking aid control unit -J446- / park assist steering control unit -J791- |
B - | 16-pin connector -T16j- |
Connector assignment: |
1 - | Fuse 11 on fuse holder B -SB11- Terminal 15 |
2 - | Rear parking aid warning buzzer -H15- Pin 1 - |
3 - | Vacant |
4 - | Parking aid button -E266- Pin 4 |
5 - | Vacant |
6 - | Data bus diagnostic interface -J533- , Powertrain CAN bus high |
7 - | Vacant |
8 - | Earth connection |
9 - | Warning light for park assist steering -K241- Pin 2 |
10 - | Rear parking aid warning buzzer -H15- Pin 1 + |
11 - | Vacant |
12 - | Vacant |
13 - | Parking aid warning lamp -K136- Pin 2 |
14 - | Vacant |
15 - | Data bus diagnostic interface -J533- Powertrain CAN bus low |
16 - | Park assist steering button -E581- Pin 5 |
C - | 12-pin connector -T12t- |
Connector assignment: |
1 - | Front sender, pin 3 - |
2 - | Front sender, pin 1 + |
3 - | Front parking aid warning buzzer -H22- Pin 2 - |
4 - | Front parking aid warning buzzer -H22- Pin 1 + |
5 - | Front left parking aid sender -G255- Pin 2 signal |
6 - | Front centre left parking aid sender -G254- Pin 2 signal |
7 - | Front centre right parking aid sender -G253- Pin 2 signal |
8 - | Front right parking aid sender -G252- Pin 2 signal |
9 - | Front left sender for park assist steering on left side of vehicle -G568- Pin 2 signal |
10 - | Front right sender for park assist steering on right side of vehicle -G569- Pin 2 signal |
11 - | Vacant |
12 - | Vacant |
D - | 12-pin connector -T12n- |
Connector assignment: |
1 - | Vacant |
2 - | Rear centre right parking aid sender -G205- Pin 2 signal |
3 - | Rear centre left parking aid sender -G204- Pin 2 signal |
4 - | Rear right parking aid sender -G206- Pin 2 signal |
5 - | Rear left parking aid sender -G203- Pin 2 signal |
6 - | Vacant |
7 - | Vacant |
8 - | Rear sender Pin 3 - |
9 - | Vacant |
10 - | Vacant |
11 - | Rear sender, pin 1 + |
12 - | Vacant |
Back to overview |
|
Connector assignment: |
A = 11-pin connector -T11b- on wiring harness |
1 - | Terminal 30 |
2 - | Right dipped beam bulb/ right gas discharge light control unit |
3 - | Right main beam bulb (not for xenon) |
4 - | Right fog light bulb |
5 - | Right dipped beam screen motor (xenon) |
6 - | Front right turn signal bulb |
7 - | Left side light bulb |
8 - | Vacant |
9 - | Earth |
10 - | Fuel pump control unit |
11 - | Terminal 50 voltage supply relay |
B = 12-pin connector -T12a- on wiring harness: |
1 - | Right reversing light bulb, automatic anti-dazzle interior mirror |
2 - | Vacant |
3 - | Vacant |
4 - | Rear left fog light bulb |
5 - | Right brake light bulb |
6 - | Vacant |
7 - | Footwell lighting bulb front left, footwell lighting bulb front right |
8 - | Vacant |
9 - | Right tail light bulb |
10 - | Rear right turn signal bulb |
11 - | Left interior light, right interior light, button illumination bulb |
12 - | Terminal 58d |
Back to overview |
C = 12-pin connector -T12m- on wiring harness: |
1 - | Heated driver seat control unit, heated front passenger seat control unit |
2 - | Left brake light bulb |
3 - | Vacant |
4 - | Vacant |
5 - | Vacant |
6 - | Vacant |
7 - | Vacant |
8 - | Number plate light |
9 - | Additional brake light bulb |
10 - | Left tail light bulb |
11 - | Rear left turn signal bulb |
12 - | Left reversing light bulb (only models without rear left fog light bulb) |
D = 11-pin connector -T11c- on wiring harness: |
1 - | Terminal 30 |
2 - | Left fog light bulb |
3 - | Left headlight main beam bulb |
4 - | Left headlight dipped beam bulb |
5 - | Earth |
6 - | Left dipped beam screen motor |
7 - | Bridge to T8a/2- |
8 - | Headlight washer system relay |
9 - | Vacant |
10 - | Right side light bulb |
11 - | Front left turn signal bulb |
E = 16-pin connector -T16k- on wiring harness: |
1 - | Lighting switch terminal 58 |
2 - | Brake light switch |
3 - | Vacant |
4 - | Vacant |
5 - | Vacant |
6 - | Fog light switch |
7 - | Earth (only models with manual gearbox not for American markets) |
7 - | Clutch position sender (only models with manual gearbox for American markets) |
8 - | Lighting switch terminal 56 |
9 - | Vacant |
10 - | Vacant |
11 - | Vacant |
12 - | Vacant |
13 - | Rear fog light switch |
14 - | Light switch, driving light assist |
15 - | Vacant |
16 - | Light switch (daytime running lights) |
Back to overview |
F = 8-pin connector -T8a- on wiring harness: |
1 - | Terminal 50 voltage supply relay |
2 - | Bridge to Connector -T11c/7- |
3 - | Windscreen wiper motor, rain and light sensor (LIN bus) |
4 - | Alternator -C- |
5 - | Bonnet contact switch |
6 - | Vacant |
7 - | Terminal 30 |
8 - | Terminal 31 |
G = 12-pin connector -T12n- on wiring harness: |
1 - | Steering column electronics control unit terminal 50 |
2 - | Indicator lamp for hazard warning light |
3 - | Vacant |
4 - | Switch and instrument illumination regulator |
5 - | Vacant |
6 - | Vacant |
7 - | Convenience CAN bus low |
8 - | Convenience CAN bus high |
9 - | Hazard warning light switch |
10 - | Switch and instrument illumination regulator |
11 - | Steering column electronics control unit terminal 15 |
12 - | Switch and instrument illumination regulator |
H = 12-pin connector : |
- | Pin connector H is vacant. |
Back to overview |
I = 2-pin connector -T2z- on wiring harness: |
1 - | Fuses terminal 30 |
2 - | Terminal 75a |
J = 6-pin connector -T6l- on wiring harness: |
1 - | Washer pump fuse |
2 - | Washer pump |
3 - | Horn fuse |
4 - | Washer pump |
5 - | Earth |
6 - | Treble tone horn, bass tone horn |
K = 10-pin connector -T10- on wiring harness: |
1 - | Heated rear window |
2 - | Vacant |
3 - | Vacant |
4 - | Vacant |
5 - | Fuse terminal 30 |
6 - | Heated rear window fuse |
7 - | Vacant |
8 - | Vacant |
9 - | Vacant |
10 - | Terminal 30g |
L = 2-pin connector -T2- - on wiring harness: |
1 - | Fuse terminal 30 |
2 - | Interior terminal 15 |
Back to overview |
|