VW PASSAT 2015

Wiring Diagram VW PASSAT 2015 - Starter - Control unit for vehicle location system - Vehicle location system aerial 1 - Vehicle location system aerial 2 - Diagnostic connection

B	Starter
J519	Onboard supply control unit
J623	Engine control unit
J682	Terminal 50 voltage supply relay
J710	Voltage supply relay 2
J895	Control unit for vehicle location system
R259	Vehicle location system aerial 1
R260	Vehicle location system aerial 2
SC10	Fuse 10 on fuse holder C
SC25	Fuse 25 on fuse holder C
T1v	Single connector
T5	5-pin connector
T16d	16-pin connector
T16fo	16-pin connector
T52c	52-pin connector
T94	94-pin connector
U31	Diagnostic connection
50	Earth point, on left in luggage compartment
A76	Connection (K-diagnosis wire), in dash panel wiring harness
B290	Positive connection 14 (15a) in main wiring harness
B509	Connection 3 (diagnosis), in main wiring harness
B571	Connection 38, in main wiring harness
*	see applicable current flow diagram for engine

VW PASSAT 2015 Overview of control units

Overview of control units

Получить доступ ко всем электросхемам автомобиля

1 -	Airbag control unit -J234-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

2 -	Control unit for terminal control and engine start -J942-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

3 -	Convenience system central control unit -J393-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

4 -	Air conditioning system control unit -J301- / Climatronic control unit -J255-

q	Air conditioning system control unit -J301- → Chapter

q	Connector assignment: → Chapter

q	Climatronic control unit -J255- → Chapter

q	Connector assignment: → Chapter

4 -	Control unit with display for radio and navigation -J503-

q	Connector assignment → Chapter

5 -	Control unit for cornering light and headlight range control -J745-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

6 -	Mobile telephone operating electronics control unit -J412-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

7 -	Heated rear seats control unit -J786-

q	Fitting location: → Chapter

8 -	Front passenger door control unit -J387-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

9 -	Control unit for electromechanical parking brake -J540-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

10 -	Rear passenger side door control unit -J927-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

11 -	Fuel pump control unit -J538-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

12 -	Rear driver side door control unit -J926-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

13 -	Heated front seats control unit -J774-

q	Fitting location: → Chapter

14 -	Control unit for seat adjustment and steering column adjustment with memory function -J136-

q	Fitting location: → Chapter

15 -	Driver door control unit -J386-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

16 -	Special purpose vehicle control unit -J608-

q	Fitting location: → Chapter

16 -	Amplifier -R12-

q	Fitting location: → Chapter

16 -	Digital sound package amplifier -R184-

q	Fitting location: → Chapter

17 -	Steering column electronics control unit -J527-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

18 -	Dash panel insert -K- / control unit in dash panel insert -J285-

q	Connector assignment: → Chapter

19 -	Electronic steering column lock control unit -J764-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

20 -	Park assist steering control unit -J791- / parking aid control unit -J446-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

21 -	Data bus diagnostic interface -J533-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

21 -	Onboard supply control unit -J519-

q	Fitting location: → Chapter

q	Connector assignment: → Chapter

22 -	Taxi alarm remote control, control unit -J601-

q	Fitting location: → Chapter

Airbag control unit -J234-

Fitting location:

under centre console, front

Connector assignment:

-	100-pin connector -T100-

Получить доступ ко всем электросхемам автомобиля

Control unit for terminal control and engine start -J942-

Fitting location:

Under the left side of the instrument panel above the pedals.

Connector assignment:

-	32-pin connector -T32g-

Получить доступ ко всем электросхемам автомобиля

Convenience system central control unit -J393-

Fitting location:

Below the dash panel, behind the glove compartment

Connector assignment:

A -	18-pin connector -T18d-

B -	6-pin connector -T6ao-

C -	8-pin connector -T8r-

D -	18-pin connector -T18a-

F -	6-pin connector -T6an-

G -	18-pin connector -T18c-

Получить доступ ко всем электросхемам автомобиля

Air conditioning system control unit -J301-

Connector assignment:

Получить доступ ко всем электросхемам автомобиля

A -	5-pin connector -T5r-

B -	16-pin connector -T16j-

D -	20-pin connector -T20b-

VW PASSAT 2015 Climatronic control unit J255

Climatronic control unit -J255-

Connector assignment:

Получить доступ ко всем электросхемам автомобиля

A -	16-pin connector -T16h-

B -	16-pin connector -T16i-

C -	20-pin connector -T20c-

VW PASSAT 2015 Control unit for cornering light and headlight range control J745

Control unit for cornering light and headlight range control -J745-

Fitting location:

Behind the glove compartment, left

Connector assignment:

-	26-pin connector -T26-

VW PASSAT 2015 Control unit for cornering light and headlight range control J745

Получить доступ ко всем электросхемам автомобиля

Mobile telephone operating electronics control unit -J412- / telephone controls control unit -J738-

Fitting location:

under seat on front right

Connector assignment:

-	54-pin connector -T54-

Получить доступ ко всем электросхемам автомобиля

Heated rear seats control unit -J786-

Fitting location:

Under seat on front right -arrow-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Front passenger door control unit J387

Front passenger door control unit -J387-

Fitting location:

On inside of front passenger door -arrow-

VW PASSAT 2015 Driver door control unit J386

Driver door control unit -J386-

Fitting location:

On inside of driver door -arrow-

Note:

The illustration shows the driver side. The front passenger side is similar.

VW PASSAT 2015 Driver door control unit J386

Получить доступ ко всем электросхемам автомобиля

Connector assignment:

Получить доступ ко всем электросхемам автомобиля

-	Front passenger door control unit -J387- , driver door control unit -J386-

Connector:

A -	32-pin connector -T32a- , -32-pin connector -T32b-

B -	16-pin connector -T16k- -, -16-pin connector -T16l-

C -	20-pin connector -T20g- , -20-pin connector -T20h-

VW PASSAT 2015 Control unit for electromechanical parking brake J540

Control unit for electromechanical parking brake -J540-

Fitting location:

On rear of centre tunnel -arrow-

Connector assignment:

-	30-pin connector -T30-

VW PASSAT 2015 Control unit for electromechanical parking brake J540

Получить доступ ко всем электросхемам автомобиля

Rear passenger side door control unit -J927-

Fitting location:

On inside of rear door on front passenger side -arrow-

Rear driver side door control unit -J926-

Fitting location:

On inside of rear door on driver's side -arrow-

Note:

The illustration shows the driver side. The front passenger side is similar.

Получить доступ ко всем электросхемам автомобиля

Connector assignment:

Получить доступ ко всем электросхемам автомобиля

-	Rear driver side door control unit -J926- / rear passenger side door control unit -J927-

Connector:

-	20-pin connector -T20k- / 20-pin connector -T20l-

Fuel pump control unit -J538-

Fitting location:

under rear right seat, on fuel delivery unit -arrow-

Fitting location in natural gas vehicles: on left in luggage compartment

Connector assignment:

-	10-pin connector -T10p-

Получить доступ ко всем электросхемам автомобиля

Heated front seats control unit -J774-

Fitting location:

On driver's seat frame -arrow-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Control unit for seat adjustment and steering column adjustment with memory function J136

Control unit for seat adjustment and steering column adjustment with memory function -J136-

Fitting location:

Under the front driver side seat

VW PASSAT 2015 Control unit for seat adjustment and steering column adjustment with memory function J136

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Special purpose vehicle control unit J608

Special purpose vehicle control unit -J608-

Fitting location:

Under driver seat -arrow-

VW PASSAT 2015 Special purpose vehicle control unit J608

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Amplifier R12

Amplifier -R12-

Fitting location:

under driver seat

Получить доступ ко всем электросхемам автомобиля

Digital sound package amplifier -R184-

Fitting location:

under driver seat

Получить доступ ко всем электросхемам автомобиля

Steering column electronics control unit -J527-

Fitting location:

under steering column, near steering column switch -arrow-

Connector assignment:

A -	16-pin connector -T16o-

B -	4-pin connector -T4ae-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015

Dash panel insert -K- / control unit in dash panel insert -J285-

Note:

The illustration does not correspond with the selected vehicle, but the fitting location is the same.

Connector assignment:

1 -	Fuel gauge sender (full)

2 -	Fuel gauge sender (empty)

3 -	Fuel level sensor (full), only for all-wheel drive

4 -	Fuel level sensor (empty), only for all-wheel drive

5 -	Not assigned

6 -	Not assigned

7 -	Not assigned

8 -	Not assigned

9 -	Speed signal, sliding sunroof control unit output , control unit with display for radio and navigation system

10 -	Not assigned

11 -	Oil level and oil temperature sender

12 -	Not assigned

13 -	Not assigned

14 -	Not assigned

15 -	Front left brake pad wear sender

16 -	Terminal 31

17 -	Washer fluid level warning lamp

18 -	Coolant temperature and coolant shortage warning lamp

19 -	Ambient temperature sensor

20 -	Terminal 31, sensor earth

21 -	Not assigned

22 -	Not assigned

23 -	Not assigned

24 -	Not assigned

25 -	Electric park/handbrake warning lamp

26 -	Brake fluid level warning lamp

27 -	Oil pressure warning lamp

28 -	Diagnostic interface for dash panel insert CAN data bus, high

29 -	Diagnostic interface for dash panel insert CAN data bus, low

30 -	Not assigned

31 -	Voltage supply, terminal 15

32 -	Voltage supply, terminal 30

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Electronic steering column lock control unit J764

Electronic steering column lock control unit -J764-

Fitting location:

On steering column -arrow-

Connector assignment:

-	10-pin connector -T10k-

VW PASSAT 2015 Electronic steering column lock control unit J764

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015

Park assist steering control unit -J791- / parking aid control unit -J446-

Fitting location:

Under dash panel on left, behind relay carrier above onboard supply control unit -arrow-

Connector assignment:

A -	12-pin connector -T12-

B -	12-pin connector -T12a-

C -	16-pin connector -T16-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Data bus diagnostic interface J533

Data bus diagnostic interface -J533-

Fitting location:

In driver's footwell near the pedal assembly

Connector assignment:

-	20-pin connector -T20-

VW PASSAT 2015 Data bus diagnostic interface J533

Получить доступ ко всем электросхемам автомобиля

Onboard supply control unit -J519-

Fitting location:

Under dash panel on driver's side, below relay carrier.

Connector assignment:

A -	52-pin connector -T52c- , brown

B -	52-pin connector -T52b- , white

C -	52-pin connector -T52a- , black

Получить доступ ко всем электросхемам автомобиля

Taxi alarm remote control, control unit -J601-

Fitting location:

In driver footwell, behind relay carrier -arrow- .

Получить доступ ко всем электросхемам автомобиля

Control unit with display for radio and navigation -J503-

Получить доступ ко всем электросхемам автомобиля

1 -	Control unit with display for radio and navigation -J503-

A -

DAB input

q	Only for Europe

A -	SDRS input

q	Only for American markets

A -

GPS input

q	Only for Japan

B -	FM/AM input

C -

FM input

D -

GPS input

E -	26-pin connector -T26g-

F -	Multi-pin connector

G -	16-pin connector -T16c-

H -	12-pin connector -T12j-

I -	12-pin connector -T12l-

Connector assignment

-T26g- (E)	Designation	-T16c- (G)	Designation
1	Not assigned	1	Amplifier -R12- (sound system) rear right bass loudspeaker -R17- +
2	Not assigned	2	Amplifier -R12- (sound system) front right bass loudspeaker -R23-
3	Not assigned	3	Amplifier -R12- (sound system) front left bass loudspeaker -R21-
4	Not assigned	4	Amplifier -R12- (sound system) rear left bass loudspeaker -R15-
5	Not assigned	5	Amplifier -R12- (sound system) rear right bass loudspeaker -R17-
6	Telephone bracket -R126-	6	Amplifier -R12- (sound system) front right bass loudspeaker -R23-
7	Telephone bracket -R126-	7	Amplifier -R12- (sound system) front left bass loudspeaker -R21-
8	Telephone bracket -R126-	8	Amplifier -R12- (sound system) rear left bass loudspeaker -R15-
9	Not assigned	9	Data bus diagnostic interface -J533- (CAN bus, high)
10	TV tuner -R78-	10	Data bus diagnostic interface -J533- (CAN bus, low)
11	TV tuner -R78-	11	Not assigned
12	TV tuner -R78-	12	Terminal 31
13	TV tuner -R78-	13	Not assigned
14	Not assigned	14	Not assigned
15	Not assigned	15	Terminal 30
16	Not assigned	16	Terminal 30
17	Not assigned
18	Not assigned
19	Not assigned
20	Telephone bracket -R126-
21	Not assigned
22	TV tuner -R78-
23	TV tuner -R78-
24	TV tuner -R78-
25	TV tuner -R78-
26	TV tuner -R78-

-T12j- (H)	Designation	-T12l- (I)	Designation
1	Connection for external audio sources -R199- (Aux-In)	1	Voice command microphone -R206- (mic in -)
2	Connection for external audio sources -R199- (Aux-In earth)	2	Not assigned
3	CD changer -R41-	3	Not assigned
4	CD changer -R41- (terminal 30)	4	Not assigned
5	Not assigned	5	Mobile telephone operating electronics control unit -J412-
6	CD changer -R41- (CD bus radio DATA)	6	Mobile telephone operating electronics control unit -J412-
7	Interface for external multimedia units -R215- (Aux-in audio)	7	Voice command microphone -R206- (mic in +)
8	CD changer -R41- (CD-X audio left)	8	Not assigned
9	CD changer -R41- (CD-X audio right)	9	Not assigned
10	CD changer -R41- (terminal 15)	10	Not assigned
11	CD changer -R41- (CD bus)	11	Mobile telephone operating electronics control unit -J412-
12	CD changer -R41-	12	Mobile telephone operating electronics control unit -J412-

VW PASSAT 2015 Overview of control units

Overview of control units

Получить доступ ко всем электросхемам автомобиля

1 -	Auxiliary heater control unit -J364-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

2 -	Power steering control unit -J500-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

3 -	ABS control unit -J104-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

4 -	Automatic gearbox control unit -J217-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

4 -	Voltage stabiliser -J532-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

5 -	Engine control unit -J623-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

6 -	Adaptive cruise control unit -J428-

q	Fittings location: → Chapter

q	Pin assignment: → Chapter

Auxiliary heater control unit -J364-

Fitting location:

Behind the right front wheel housing liner

Connector assignment:

-	Auxiliary heater control unit -J364-

-	2-pin connector -T2- -T2cn-

-	8-pin connector -T8- -T8ai-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Power steering control unit J500

Power steering control unit -J500-

Fitting location:

At the steering on the subframe

Connector assignment:

A -	5-pin connector -T5- -T5z-

B -	2-pin connector -T2- -T2fn

VW PASSAT 2015 Power steering control unit J500

Получить доступ ко всем электросхемам автомобиля

ABS control unit -J104-

Fitting location:

On bulkhead, on right in engine compartment -arrow-

Connector assignment:

-	38-pin connector -T38- -T38-

Получить доступ ко всем электросхемам автомобиля

Automatic gearbox control unit -J217-

Fitting location:

In front left wheel housing -arrow-

Connector assignment:

-	52-pin connector -T52- -T52-

Получить доступ ко всем электросхемам автомобиля

Voltage stabiliser -J532-

Fitting location:

In front left wheel housing -arrow-

Connector assignment:

-	12-pin connector -T12- -T12ad-

Получить доступ ко всем электросхемам автомобиля

Engine control unit -J623-

Fitting location:

Under the plenum chamber cover, centre -arrow-

Connector assignment:

A -	94-pin connector -T94- -T94-

B -	60-pin connector -T60- -T60-

Получить доступ ко всем электросхемам автомобиля

Adaptive cruise control unit -J428-

Fitting location:

Behind radiator in centre -arrow-

Connector assignment:

-	10-pin connector -T10- -T10y-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Overview of relay carriers

Overview of relay carriers

Получить доступ ко всем электросхемам автомобиля

1 -	Heated windscreen relay -J47-

q	Fitting location: → Chapter

2 -	Relay carrier 1

q	Fitting location: → Chapter

q	Relay assignment: → Chapter

3 -	Relay carrier 2

q	Fitting location: → Chapter

q	Relay assignment: → Chapter

4 -	Relay carrier 3

q	Fitting location: → Chapter

q	Relay assignment: → Chapter

5 -	Additional relay carrier

q	Fitting location: → Chapter

q	Relay assignment: → Chapter

6 -	Relay carrier on E-box

q	Fitting location: → Chapter

q	Relay assignment for E-box low → Chapter

q	Relay assignment for E-box high → Chapter

Heated windscreen relay -J47-

Fitting location:

In plenum chamber next to engine control unit -arrow-

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Relay carrier 1

Relay carrier 1

Fitting location:

On left under dash panel

Relay assignment:

1 -	Fresh air blower relay -J13- (Climatic with auxiliary heater)

2 -	Auxiliary heater operation relay -J485- (Climatic with auxiliary heater)

3 -	Auxiliary heater operation relay -J485- (Diesel engine with auxiliary heater)

4 -

Vacant

5 -	Continued coolant circulation relay -J151- (only 1.8l / 2.0l TFSI)

5 -	Current supply relay -J17-

6 -	Terminal 50 voltage supply relay -J682- (not for models with start/stop system)

7/8 -

Voltage supply relay 2 -J710- (not for models with start/stop system)

Получить доступ ко всем электросхемам автомобиля

Relay carrier 2

Fitting location:

On left under dash panel

Relay positions:

1 -

Vacant

2 -

Vacant

3 -

Vacant

4 -

Vacant

5 -

Vacant

6 -

Vacant

7 -	Second battery charging circuit relay -J713- (100)

8 -

Vacant

Получить доступ ко всем электросхемам автомобиля

Relay carrier 3

Fitting location:

On left under dash panel

Relay assignment:

1 -	Heated rear window relay -J9- (645)

2 -	Terminal 15 voltage supply relay -J329- (645)

3 -	Dual tone horn relay -J4- (646)

3 -	Headlight washer system relay -J39- (646)

4 -	Trailer voltage supply relay -J941- (from May 2012)

4 -

Vacant

5 -	X-contact relief relay -J59- (644)

Получить доступ ко всем электросхемам автомобиля

Additional relay carrier

Fitting location:

Under electronics box in engine compartment, left

Relay assignment:

1 -	Starter relay 1 -J906- (643) - For models with start/stop system only

2 -	Automatic glow period control unit -J179- (457)

3 -

Vacant

4 -	Low heat output relay -J359- (53)

5 -	High heat output relay -J360- (100)

6 -	Starter relay 2 -J907- (489) - For models with start/stop system only

Получить доступ ко всем электросхемам автомобиля

Relay carrier on E-box low

Fitting location:

On left in engine compartment

Relay assignment:

A1 -	Engine component current supply relay -J757-

A2 -	Terminal 30 voltage supply relay -J317- (Diesel engine)

A2 -	Motronic current supply relay -J271- (Petrol engine)

Получить доступ ко всем электросхемам автомобиля

Relay carrier on E-box high

Fitting location:

On left in engine compartment

Relay assignment:

A1 -	Current bridge

A1 -	Relay for gas shut-off valves -J908-

A2 -	Continued coolant circulation relay -J151- (100)

A3 -

Vacant

A4 -	Main relay -J271- (100)

Получить доступ ко всем электросхемам автомобиля

VW PASSAT 2015 Overview of fuses

Overview of fuses

Получить доступ ко всем электросхемам автомобиля

1 -	Fuse holder D -SD-

q	Fitting location: → Chapter

q	Fuse assignment, left-hand drive models: → Chapter

q	Fuse assignment, right-hand drive models: → Chapter

2 -	Fuse holder F -SF-

q	Fitting location: → Chapter

q	Fuse assignment: → Chapter

3 -	Fuse 2 (30) -S205- (60 A)

q	behind left side trim in luggage compartment

4 -	Fuse holder C -SC-

q	Fitting location: → Chapter

q	Fuse assignment, from November 2011: → Chapter

q	Fuse assignment, from May 2012: → Chapter

5 -	Safety cutout under dash panel, driver side

q	Fuse assignment: → Chapter

6 -	Fuse holder B -SB-

q	Fuse assignment for E-box low from November 2011 → Chapter

q	Fuse assignment for E-box low from May 2012 → Chapter

q	Fuse assignment for E-box high from November 2011 → Chapter

7 -	Fuse holder A -SA-

q	Fuse assignment for E-box low → Chapter

q	Fuse assignment for E-box high → Chapter

Fuse holder D -SD- on right in dash panel

Fitting location

Fitting location: on right of dash panel, near A-pillar

Получить доступ ко всем электросхемам автомобиля

30 A - green

25 A - clear

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

3 A - purple

Note:

Fuses SD13-SD24 are reserved for special purpose vehicles.

Fuse assignment on fuse holder D -SD- , left-hand drive models

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	Fuse 1 on fuse holder D -SD1-	30 A	-	Rear lid control unit -J605-¹⁾	30
2	-	Fuse 2 on fuse holder D -SD2-	30 A	-	Rear lid control unit 2 -J756-¹⁾	30
3	-	Fuse 3 on fuse holder D -SD3-	30 A	-	Sunroof roller blind control unit -J394-¹⁾	30
4	-	Fuse 4 on fuse holder D -SD4-	15 A	-	Electronically controlled damping control unit -J250-	75
5	-	Not assigned		-
6	-	Not assigned		-
7	-	Not assigned		-
8	-	Not assigned		-
9	-	Not assigned		-
10	-	Not assigned		-
11	-	Not assigned		-
12	-	Not assigned		-
13	-	Fuse 13 on fuse holder D -SD13-		-	-Special vehicles
14	-	Fuse 14 on fuse holder D -SD14-		-	-Special vehicles
15	-	Fuse 15 on fuse holder D -SD15-		-	-Special vehicles
16	-	Fuse 16 on fuse holder D -SD16-		-	Charging station for hand-held 2-way radio -U24- Charging station 2 for hand-held 2-way radio -U28- Charging station 2 for torch -U29-
17	-	Fuse 17 on fuse holder D -SD17-		-	-Special vehicles
18	-	Fuse 18 on fuse holder D -SD18-		-	-Special vehicles
19	-	Fuse 19 on fuse holder D -SD19-		-	-Special vehicles
20	-	Fuse 20 on fuse holder D -SD20-		-	-Special vehicles
21	-	Fuse 21 on fuse holder D -SD21-		-	-Special vehicles
22	-	Fuse 22 on fuse holder D -SD22-		-	-Special vehicles
23	-	Fuse 23 on fuse holder D -SD23-		-	-Special vehicles
24	-	Fuse 24 on fuse holder D -SD24-		-	-Special vehicles

¹⁾ Only estate

Fuse assignment on fuse holder D -SD- , right-hand drive models

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	Fuse 1 on fuse holder D -SD1-	15 A	-	Trailer detector control unit -J345-	30
2	-	Fuse 2 on fuse holder D -SD2-	20 A	-	Trailer detector control unit -J345-	30
3	-	Fuse 3 on fuse holder D -SD3-	15 A	-	Trailer detector control unit -J345-	30
4	-	Not assigned		-
5	-	Not assigned		-
6	-	Not assigned		-
7	-	Not assigned		-
8	-	Not assigned		-
9	-	Not assigned		-
10	-	Not assigned		-
11	-	Not assigned		-
12	-	Not assigned		-
13	-	Fuse 13 on fuse holder D -SD13-		-	-Special vehicles
14	-	Fuse 14 on fuse holder D -SD14-		-	-Special vehicles
15	-	Fuse 15 on fuse holder D -SD15-		-	-Special vehicles
16	-	Fuse 16 on fuse holder D -SD16-		-	Charging station for hand-held 2-way radio -U24- Charging station 2 for hand-held 2-way radio -U28- Charging station 2 for torch -U29-
17	-	Fuse 17 on fuse holder D -SD17-		-	-Special vehicles
18	-	Fuse 18 on fuse holder D -SD18-		-	-Special vehicles
19	-	Fuse 19 on fuse holder D -SD19-		-	-Special vehicles
20	-	Fuse 20 on fuse holder D -SD20-		-	-Special vehicles
21	-	Fuse 21 on fuse holder D -SD21-		-	-Special vehicles
22	-	Fuse 22 on fuse holder D -SD22-		-	-Special vehicles
23	-	Fuse 23 on fuse holder D -SD23-		-	-Special vehicles
24	-	Fuse 24 on fuse holder D -SD24-		-	-Special vehicles

VW PASSAT 2015

Fuse holder F -SF- , luggage compartment, left rear (BWS)

Specified torque settings

Получить доступ ко всем электросхемам автомобиля

⇒ Electrical system, Repair Group 97, Removing and installing fuse holders

Fuse colours

30 A - green

25 A - clear

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

3 A - purple

VW PASSAT 2015

Fuse assignment on fuse holder F -SF- , luggage compartment, left rear (BWS)

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	Fuse 1 on fuse holder F -SF1-	30 A	-	-Left fuse holder (SC12 - SC17, SC27, SC29 - SC31, SC44)	30
2	-	Fuse 2 on fuse holder F -SF2-	80 A	-	-Fuses in E-box (SB16 - SB26, SB49, SB50)	30
3	-	Fuse 3 on fuse holder F -SF3-	125 A	-	-Power supply E-box	30
4	-	Fuse 4 on fuse holder F -SF4-	5 A	-	Onboard supply control unit -J519- Battery monitor control unit -J367-	30

VW PASSAT 2015

Fuse holder C -SC- , on left of dash panel

Fitting location of fuse holder C -SC-

Fitting location: on left of dash panel, near A-pillar

Получить доступ ко всем электросхемам автомобиля

30 A - green

25 A - clear

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

3 A - purple

Fuse assignment on fuse holder C -SC- , from November 2011

Slot		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	Fuse 1 on fuse holder C -SC1-	10 A	-	High-pressure sender -G65- Air quality sensor -G238- Oil level and oil temperature sender -G266- Fresh air blower relay -J13- DC/AC converter with socket, 12 V - 230 V -U13- Automatic anti-dazzle interior mirror -Y7- Heated rear left seat switch with regulator -E128- Heated rear right seat switch with regulator -E129-	15
2	-	Fuse 2 on fuse holder C -SC2-	5 A	-	Light switch -E1- TCS and ESP button -E256- Auto-hold button -E540- ABS control unit -J104- Power steering control unit -J500- Control unit for electromechanical parking brake -J540-	15
3	-	Fuse 3 on fuse holder C -SC3-	10 A	-	Current supply relay -J16- Heater element for crankcase breather -N79- Gas injection valve 1 -N366- Gas injection valve 2 -N367- Gas injection valve 3 -N368- Gas injection valve 4 -N369-	15
4	-	Fuse 4 on fuse holder C -SC4-	10 A	-	Rear roller blind switch -E149- Start/Stop operation button -E693- Electronically controlled damping control unit -J250- Adaptive cruise control unit -J428- Parking aid control unit -J446- Trailer detector control unit -J345- Park assist steering control unit -J791- Front camera for driver assist systems -R242- Diagnostic connection -U31-	15
5	-	Fuse 5 on fuse holder C -SC5-	10 A	-	Headlight range control regulator -E102- Left headlight range control motor -V48- Right headlight range control motor -V49- Front left headlight -MX1-⁴⁾	15
6	-	Fuse 6 on fuse holder C -SC6-	10 A	-	All-wheel drive control unit -J492-	15
7	-	Fuse 7 on fuse holder C -SC7-	5 A	-	Control unit in dash panel insert -J285- Data bus diagnostic interface -J533-	15
8	-	Fuse 8 on fuse holder C -SC8-	10 A	-	Front right headlight -MX2-⁴⁾	15
9	-	Fuse 9 on fuse holder C -SC9-	10 A	-	Airbag control unit -J234- Front passenger side airbag deactivated warning lamp -K145-	15
10	-	Fuse 10 on fuse holder C -SC10-	10 A	-	Air mass meter -G70- Voltage stabiliser -J532- Fuel pump control unit -J538-Engine control unit -J623- Terminal 50 voltage supply relay -J682- Voltage supply relay 2 -J710- Starter relay 1 -J906- Starter relay 2 -J907-	15
11	-	Fuse 11 on fuse holder C -SC11-	5 A ⁶⁾	-	Warning buzzer pedal switch on front passenger side -F349-⁶⁾	15
12	-	Fuse 12 on fuse holder C -SC12-	20 A	-	Convenience system central control unit -J393- Front passenger door control unit -J387-¹⁷⁾ Rear passenger side door control unit -J927-¹⁷⁾	30
13	-	Fuse 13 on fuse holder C -SC13-	10 A	-	Light switch -E1- Selector lever -E313- ABS control unit -J104- Handbrake warning lamp -K139- Diagnostic connection -U31- ABS control unit -J104- T38/15	30
14	-	Fuse 14 on fuse holder C -SC14-	10 A	-	Interior monitor send and receive module 1 -G303- Alarm horn -H12-	30
15	-	Fuse 15 on fuse holder C -SC15-	10 A	-	Rain and light sensor -G397- Heated rear window relay -J9- Heated windscreen relay -J47- Climatronic control unit -J255- Air conditioning system control unit -J301- Reversing camera system control unit -J772- Control unit for terminal control and engine start -J942- Remote control receiver for auxiliary coolant heater -R149- Tyre Pressure Monitoring System control unit -J502-	30
16	-	Fuse 16 on fuse holder C -SC16-	10 A	-	Electronic ignition lock -D9- Electronic steering column lock control unit -J764- Control unit for terminal control and engine start -J942-	30
17	-	Fuse 17 on fuse holder C -SC17-	15 A	-	Driver door control unit -J386-¹⁷⁾ Rear driver side door control unit -J926-¹⁷⁾	30
18	-	Fuse 18 on fuse holder C -SC18-	A 3	-	Onboard supply control unit -J519- Voltage stabiliser -J532- Engine control unit -J623- Voltage supply relay 2 -J710-	15
19	-	Not assigned		-
20	-	Not assigned		-
21	-	Fuse 21 on fuse holder C -SC21-	10 A	-	Rear roller blind control unit -J262-	15
22	-	Fuse 22 on fuse holder C -SC22-	20 A	-	Control unit for electromechanical parking brake -J540-	30
23	-	Fuse 23 on fuse holder C -SC23-	15 A	-	Trailer detector control unit -J345- Electronically controlled damping control unit -J250-⁴⁾	30
24	-	Fuse 24 on fuse holder C -SC24-	20 A	-	Control unit for electromechanical parking brake -J540-	30
25	-	Fuse 25 on fuse holder C -SC25-	5 A ⁸⁾ 15 A ⁷⁾ 30 A ⁴⁾	-	Emergency assistance call button -E276- Trailer detector control unit -J345- Sunroof roller blind control unit -J394-⁴⁾	30
26	-	Fuse 26 on fuse holder C -SC26-	20 A	-	Onboard supply control unit -J519-	30
27	-	Fuse 27 on fuse holder C -SC27-	15 A¹⁾ 20 A²⁾	-	Fuel pump control unit -J538-¹⁾ Fuel pump relay -J17-²⁾ Electric fuel pump 2 relay -J49-²⁾	15¹⁾ 30²⁾
28	-	Fuse 28 on fuse holder C -SC28-	30 A	-	Driver door control unit -J386-⁹⁾ Rear driver side door control unit -J926-⁹⁾ Front passenger door control unit -J387-⁴⁾ Rear passenger side door control unit -J927-⁴⁾	30
29	-	Fuse 29 on fuse holder C -SC29-	20 A	-	Heated rear seats control unit -J786-	30
30	-	Fuse 30 on fuse holder C -SC30-	20 A ¹⁰⁾ 30 A ¹¹⁾	-	Sliding sunroof adjustment control unit -J245-	30
31	-	Fuse 31 on fuse holder C -SC31-	30 A	-	DC/AC converter with socket, 12 V-230 V -U13-	30
32	-	Fuse 32 on fuse holder C -SC32-	30 A	-	Heated rear window relay -J9-	30
33	-	Fuse 33 on fuse holder C -SC33-	30 A	-	Headlight washer system relay -J39-	30
34	-	Fuse 34 on fuse holder C -SC34-	25 A	-	Heated front seats control unit -J774-	30
35	-	Fuse 35 on fuse holder C -SC35-	15 A ⁴⁾	-	Rear lid control unit -J605-⁴⁾	30
36	-	Fuse 36 on fuse holder C -SC36-	15 A	-	Driver seat lumbar support adjustment switch -E176-	30
37	-	Fuse 37 on fuse holder C -SC37-	20 A ⁹⁾ 30 A ⁴⁾	-	Trailer detector control unit -J345-⁹⁾ Rear lid control unit 2 -J756-⁴⁾	30
38	-	Fuse 38 on fuse holder C -SC38-	40 A ¹²⁾	-	Fresh air blower relay -J13-¹⁴⁾ Fresh air blower control unit -J126-¹³⁾	75
39	-	Fuse 39 on fuse holder C -SC39-	5 A	-	Selector lever -E313- Reversing light switch -F4- Mechatronic unit for dual clutch gearbox -J743-	15
40	-	Fuse 40 on fuse holder C -SC40-	20 A	-	Onboard supply control unit -J519- Rear window wiper motor -V12- Windscreen and rear window washer pump -V59-	75
41	-	Fuse 41 on fuse holder C -SC41-	20 A	-	Onboard supply control unit -J519- Cigarette lighter -U1- Rear cigarette lighter -U9-	75
42	-	Fuse 42 on fuse holder C -SC42-	15 A	-	12 V socket -U5-	75
43	-	Fuse 43 on fuse holder C -SC43-	20 A ¹⁵⁾	-	Auxiliary heater control unit -J364-¹⁵⁾	30
44	-	Fuse 44 on fuse holder C -SC44-	30 A	-	Driver door control unit -J386-⁴⁾ Rear driver side door control unit -J926-⁴⁾ Front passenger door control unit -J387-⁹⁾ Rear passenger side door control unit -J927-⁹⁾	30
45	-	Fuse 45 on fuse holder C -SC45-	20 A ¹⁵⁾	-	Auxiliary heater operation relay -J485-¹⁵⁾	30
46	-	Not assigned		-
47	-	Fuse 47 on fuse holder C -SC47-	5 A ³⁾	-	Analogue clock -Y-³⁾ TV tuner -R78-³⁾ Mobile telephone operating electronics control unit -J412-³⁾ Control unit for navigation system -J856-^3.16)	30
48	-	Fuse 48 on fuse holder C -SC48-	5 A ³⁾	-	Control unit in dash panel insert -J285-³⁾	30
49	-	Fuse 49 on fuse holder C -SC49-		-	-Vacant

¹⁾ Only models with a petrol engine

²⁾ Only models with a diesel engine

³⁾ Only models with start/stop system

⁴⁾ Only right-hand drive models

⁵⁾ Only models with xenon headlights

⁶⁾ Only applicable to special vehicles

⁷⁾ Only models with trailer socket

⁸⁾ Only models with emergency call module

⁹⁾ Only left-hand drive models

¹⁰⁾ Only saloon

¹¹⁾ Only estate

¹²⁾ Only models with auxiliary heating

¹³⁾ Only models with Climatronic

¹⁴⁾ Only models with Climatic

¹⁵⁾ Only models with second battery

¹⁶⁾ Only models with equipment for Korea

¹⁷⁾ Only CC

Fuse assignment on fuse holder C -SC- , from May 2012

Slot		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	Fuse 1 on fuse holder C -SC1-	10 A	-	High-pressure sender -G65- Air quality sensor -G238- Oil level and oil temperature sender -G266- Fresh air blower relay -J13- DC/AC converter with socket, 12 V - 230 V -U13- Automatic anti-dazzle interior mirror -Y7- Heated rear left seat switch with regulator -E128- Heated rear right seat switch with regulator -E129-	15
2	-	Fuse 2 on fuse holder C -SC2-	5 A	-	Light switch -E1- TCS and ESP button -E256- Auto-hold button -E540- ABS control unit -J104- Power steering control unit -J500- Control unit for electromechanical parking brake -J540-	15
3	-	Fuse 3 on fuse holder C -SC3-	10 A	-	Current supply relay -J16- Heater element for crankcase breather -N79- Gas injection valve 1 -N366- Gas injection valve 2 -N367- Gas injection valve 3 -N368- Gas injection valve 4 -N369-	15
4	-	Fuse 4 on fuse holder C -SC4-	10 A	-	Rear roller blind switch -E149- Start/Stop operation button -E693- Electronically controlled damping control unit -J250- Adaptive cruise control unit -J428- Parking aid control unit -J446- Trailer detector control unit -J345- Park assist steering control unit -J791- Front camera for driver assist systems -R242- Diagnostic connection -U31-	15
5	-	Fuse 5 on fuse holder C -SC5-	10 A	-	Headlight range control regulator -E102- Left headlight range control motor -V48- Right headlight range control motor -V49- Front left headlight -MX1-⁴⁾	15
6	-	Fuse 6 on fuse holder C -SC6-	10 A	-	All-wheel drive control unit -J492-	15
7	-	Fuse 7 on fuse holder C -SC7-	5 A	-	Control unit in dash panel insert -J285- Data bus diagnostic interface -J533-	15
8	-	Fuse 8 on fuse holder C -SC8-	10 A	-	Front right headlight -MX2-⁴⁾	15
9	-	Fuse 9 on fuse holder C -SC9-	10 A	-	Airbag control unit -J234- Front passenger side airbag deactivated warning lamp -K145-	15
10	-	Fuse 10 on fuse holder C -SC10-	10 A	-	Air mass meter -G70- Voltage stabiliser -J532- Fuel pump control unit -J538-Engine control unit -J623- Terminal 50 voltage supply relay -J682- Voltage supply relay 2 -J710- Starter relay 1 -J906- Starter relay 2 -J907-	15
11	-	Fuse 11 on fuse holder C -SC11-	5 A ⁶⁾	-	Warning buzzer pedal switch on front passenger side -F349-⁶⁾	15
12	-	Fuse 12 on fuse holder C -SC12-	20 A	-	Convenience system central control unit -J393-	30
13	-	Fuse 13 on fuse holder C -SC13-	10 A	-	Light switch -E1- Selector lever -E313- ABS control unit -J104- Handbrake warning lamp -K139- Diagnostic connection -U31- ABS control unit -J104- T38/15	30
14	-	Fuse 14 on fuse holder C -SC14-	10 A	-	Interior monitor send and receive module 1 -G303- Alarm horn -H12-	30
15	-	Fuse 15 on fuse holder C -SC15-	10 A	-	Rain and light sensor -G397- Heated rear window relay -J9- Heated windscreen relay -J47- Climatronic control unit -J255- Air conditioning system control unit -J301- Reversing camera system control unit -J772- Control unit for terminal control and engine start -J942- Remote control receiver for auxiliary coolant heater -R149- Tyre Pressure Monitoring System control unit -J502-	30
16	-	Fuse 16 on fuse holder C -SC16-	10 A	-	Electronic ignition lock -D9- Electronic steering column lock control unit -J764- Control unit for terminal control and engine start -J942-	30
17	-	Fuse 17 on fuse holder C -SC17-		-	-Vacant
18	-	Fuse 18 on fuse holder C -SC18-	A 3	-	Onboard supply control unit -J519- Voltage stabiliser -J532- Engine control unit -J623- Voltage supply relay 2 -J710-	15
19	-	Not assigned		-
20	-	Not assigned		-
21	-	Fuse 21 on fuse holder C -SC21-	10 A	-	Rear roller blind control unit -J262-	15
22	-	Fuse 22 on fuse holder C -SC22-	20 A	-	Control unit for electromechanical parking brake -J540-	30
23	-	Fuse 23 on fuse holder C -SC23-	15 A	-	Trailer detector control unit -J345- Electronically controlled damping control unit -J250-⁴⁾	30
24	-	Fuse 24 on fuse holder C -SC24-	20 A	-	Control unit for electromechanical parking brake -J540-	30
25	-	Fuse 25 on fuse holder C -SC25-	5 A ⁸⁾ 15 A ⁷⁾ 30 A ⁴⁾	-	Emergency assistance call button -E276- Trailer detector control unit -J345- Sunroof roller blind control unit -J394-⁴⁾	30
26	-	Fuse 26 on fuse holder C -SC26-	20 A	-	Onboard supply control unit -J519-	30
27	-	Fuse 27 on fuse holder C -SC27-	15 A¹⁾ 20 A²⁾	-	Fuel pump control unit -J538-¹⁾ Fuel pump relay -J17-²⁾ Electric fuel pump 2 relay -J49-²⁾	15¹⁾ 30²⁾
28	-	Fuse 28 on fuse holder C -SC28-	30 A	-	Driver door control unit -J386-⁹⁾ Rear driver side door control unit -J926-⁹⁾ Front passenger door control unit -J387-⁴⁾ Rear passenger side door control unit -J927-⁴⁾	30
29	-	Fuse 29 on fuse holder C -SC29-	20 A	-	Heated rear seats control unit -J786-	30
30	-	Fuse 30 on fuse holder C -SC30-	20 A ¹⁰⁾ 30 A ¹¹⁾	-	Sliding sunroof adjustment control unit -J245-	30
31	-	Fuse 31 on fuse holder C -SC31-	30 A	-	DC/AC converter with socket, 12 V-230 V -U13-	30
32	-	Fuse 32 on fuse holder C -SC32-	30 A	-	Heated rear window relay -J9-	30
33	-	Fuse 33 on fuse holder C -SC33-	30 A	-	Headlight washer system relay -J39-	30
34	-	Fuse 34 on fuse holder C -SC34-	25 A	-	Heated front seats control unit -J774-	30
35	-	Fuse 35 on fuse holder C -SC35-	15 A ⁴⁾	-	Rear lid control unit -J605-⁴⁾ Driver seat lumbar support adjustment switch -E176-⁹⁾	30
36	-	Fuse 36 on fuse holder C -SC36-	15 A	-	Driver seat lumbar support adjustment switch -E176-⁴⁾ Trailer voltage supply relay -J941-	30
37	-	Fuse 37 on fuse holder C -SC37-	20 A ⁹⁾ 30 A ⁴⁾	-	Trailer detector control unit -J345-⁹⁾ Rear lid control unit 2 -J756-⁴⁾	30
38	-	Fuse 38 on fuse holder C -SC38-	40 A ¹²⁾	-	Fresh air blower relay -J13-¹⁴⁾ Fresh air blower control unit -J126-¹³⁾	75
39	-	Fuse 39 on fuse holder C -SC39-	5 A	-	Selector lever -E313- Reversing light switch -F4- Mechatronic unit for dual clutch gearbox -J743-	15
40	-	Fuse 40 on fuse holder C -SC40-	20 A	-	Onboard supply control unit -J519- Rear window wiper motor -V12- Windscreen and rear window washer pump -V59-	75
41	-	Fuse 41 on fuse holder C -SC41-	20 A	-	Onboard supply control unit -J519- Cigarette lighter -U1- Rear cigarette lighter -U9-	75
42	-	Fuse 42 on fuse holder C -SC42-	15 A	-	12 V socket -U5-	75
43	-	Fuse 43 on fuse holder C -SC43-	20 A ¹⁵⁾	-	Auxiliary heater control unit -J364-¹⁵⁾	30
44	-	Fuse 44 on fuse holder C -SC44-	30 A	-	Driver door control unit -J386-⁴⁾ Rear driver side door control unit -J926-⁴⁾ Front passenger door control unit -J387-⁹⁾ Rear passenger side door control unit -J927-⁹⁾	30
45	-	Fuse 45 on fuse holder C -SC45-	20 A ¹⁵⁾	-	Auxiliary heater operation relay -J485-¹⁵⁾	30
46	-	Not assigned		-
47	-	Fuse 47 on fuse holder C -SC47-	5 A ³⁾	-	Analogue clock -Y-³⁾ TV tuner -R78-³⁾ Mobile telephone operating electronics control unit -J412-³⁾ Control unit for navigation system -J856-^3.16)	30
48	-	Fuse 48 on fuse holder C -SC48-	5 A ³⁾	-	Control unit in dash panel insert -J285-³⁾	30
49	-	Fuse 49 on fuse holder C -SC49-		-	-Vacant

¹⁾ Only models with a petrol engine

²⁾ Only models with a diesel engine

³⁾ Only models with start/stop system

⁴⁾ Only right-hand drive models

⁵⁾ Only models with xenon headlights

⁶⁾ Only applicable to special vehicles

⁷⁾ Only models with trailer socket

⁸⁾ Only models with emergency call module

⁹⁾ Only left-hand drive models

¹⁰⁾ Only saloon

¹¹⁾ Only estate

¹²⁾ Only models with auxiliary heating

¹³⁾ Only models with Climatronic

¹⁴⁾ Only models with Climatic

¹⁵⁾ Only models with second battery

¹⁶⁾ Only models with equipment for Korea

VW PASSAT 2015 Safety cutout under dash panel, driver side

Safety cutout under dash panel, driver side

Получить доступ ко всем электросхемам автомобиля

A -	Not assigned

B -	Driver seat adjustment thermal fuse 1 -S44-

VW PASSAT 2015

Fuse holder B -SB- on E-box low

Fitting location

on E-box low, on left in engine compartment

Получить доступ ко всем электросхемам автомобиля

Fuse colours:

50 A - red

40 A - orange

30 A - green

25 A - clear

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

3 A - purple

Fuse assignment on fuse holder B -SB- on E-box low, from November 2011

Slot		Current Flow Diagram designation	Nominal value		Function/component	Terminal
SB1	-	Not assigned		-
SB2	-	Fuse 2 on fuse holder B -SB2-	30 A	-	ABS control unit -J104-	30
SB3	-	Fuse 3 on fuse holder B -SB3-	20 A	-	Treble horn -H2- Bass horn -H7- Dual tone horn relay -J4-	30
SB4	-	Fuse 4 on fuse holder B -SB4-	20 A	-	Trailer detector control unit -J345-	30
SB5	-	Fuse 5 on fuse holder B -SB5-	5 A	-	Battery monitoring control unit -J367- Onboard supply control unit -J519-	30
SB6	-	Fuse 6 on fuse holder B -SB6-	15 A	-	Mechatronic unit for dual clutch gearbox -J743-	30
SB7	-	Fuse 7 on fuse holder B -SB7-	15 A ^6,7) 20 A ^5,7) 30 A ¹⁾	-	Radio -R- Control unit with display for radio and navigation -J503- Voltage stabiliser -J532-⁽¹	30
SB8	-	Fuse 8 on fuse holder B -SB8-	30 A	-	Mechatronic unit for dual clutch gearbox -J743-	30
SB9	-	Fuse 9 on fuse holder B -SB9-	5 A	-	Steering column electronics control unit -J527-	30
SB10	-	Fuse 10 on fuse holder B -SB10-	20 A	-	Ignition coil 1 with output stage -N70- Ignition coil 2 with output stage -N127- Ignition coil 3 with output stage -N291- Ignition coil 4 with output stage -N292- Fuel pressure regulating valve -N276- Fuel metering valve -N290-	87
SB11	-	Fuse 11 on fuse holder B -SB11-	5 A	-	Control unit in dash panel insert -J285-	30
SB12	-	Fuse 12 on fuse holder B -SB12-	5 A	-	TV tuner -R78- Mobile telephone operating electronics control unit -J412- Analogue clock -Y- Control unit for navigation system -J856-¹⁴⁾	30
SB13	-	Fuse 13 on fuse holder B -SB13-	10 A	-	Motronic current supply relay -J271- Terminal 30 voltage supply relay -J317- Engine control unit -J623-	30
SB14	-	Fuse 14 on fuse holder B -SB14-	25 A ³⁾ 30 A ²⁾	-	Engine control unit -J623- Engine control unit -J623-	87
SB15	-	Fuse 15 on fuse holder B -SB15-	5 A	-	Data bus diagnostic interface -J533-	30
SB16	-	Fuse 16 on fuse holder B -SB16-	10 A ⁹⁾ 15 A ⁸⁾	-	Charge pressure control solenoid valve -N75-²⁾ Exhaust gas recirculation cooler changeover valve -N345- Magnetic clutch for supercharger -N421-³⁾ Continued coolant circulation relay -J151-³⁾ Continued coolant circulation pump -V51-³⁾ Coolant circulation pump 2 -V178-	87
SB17	-	Fuse 17 on fuse holder B -SB17-	10 A 40 A ¹⁰⁾	-	Fuel pressure regulating valve -N276- Fuel tank shut-off valve 1 -N361- Fuel tank shut-off valve 2 -N362- Fuel tank shut-off valve 3 -N363- Coolant circulation pump -V50- Low heat output relay -J359-¹⁰⁾	87
SB18	-	Fuse 18 on fuse holder B -SB18-	10 A ⁹⁾ 30 A ⁸⁾	-	Fuel quality sender -G446- High-pressure valve for gas mode -N372-	87
SB19	-	Fuse 19 on fuse holder B -SB19-	30 A	-	Amplifier -R12- Special vehicle control unit -J608-¹¹⁾	30
SB20	-	Fuse 20 on fuse holder B -SB20-	5 A 15 A ^{12), 15)}	-	Brake light switch -F- Clutch position sender -G476- Low heat output relay -J359- High heat output relay -J360- Engine component current supply relay -J757- Fuel pressure regulating valve -N276-	87
SB21	-	Fuse 21 on fuse holder B -SB21-	20 A	-	Auxiliary heater control unit -J364-	30
SB22	-	Fuse 22 on fuse holder B -SB22-	30 A	-	Wiper motor control unit -J400-	30
SB23	-	Fuse 23 on fuse holder B -SB23-	10 A	-	Brake light switch -F- Air mass meter -G70- Clutch position sender -G476- Fuel pump relay -J17- Automatic glow period control unit -J179- Radiator fan control unit -J293- Additional coolant pump relay -J496- Charge pressure control solenoid valve -N75- Activated charcoal filter solenoid valve 1 -N80- Camshaft control valve 1 -N205- Turbocharger air recirculation valve -N249- Intake manifold flap valve -N316- Valve for oil pressure control -N428-	87
SB24	-	Fuse 24 on fuse holder B -SB24-	10 A^2.9 15 A	-	Lambda probe heater -Z19- Lambda probe 1 heater after catalytic converter -Z29- NOx sender 2 control unit -J881-⁸⁾	87
SB25	-	Fuse 25 on fuse holder B -SB25-	40 A	-	Onboard supply control unit -J519-	30
SB26	-	Fuse 26 on fuse holder B -SB26-	40 A	-	Onboard supply control unit -J519-	30
SB27	-	Fuse 27 on fuse holder B -SB27-	60 A	-	Heated windscreen relay -J47-	30
SB28	-	Fuse 28 on fuse holder B -SB28-	50 A	-	Automatic glow period control unit -J179-²⁾	30
SB29	-	Fuse 29 on fuse holder B -SB29-	50 A	-	Fuse 38 on fuse holder C -SC38-¹³⁾ Fuse 40 on fuse holder C -SC40- to fuse 42 on fuse holder C -SC42- X-contact relief relay -J59-	30
SB30	-	Fuse 30 on fuse holder B -SB30-	40 A	-	Terminal 15 voltage supply relay -J329- Fuse 1 on fuse holder C -SC1- to fuse 11 on fuse holder C -SC11- Fuse 20 on fuse holder C -SC20- Fuse 21 on fuse holder C -SC21- Fuse 39 on fuse holder C -SC39- Fuse 18 on fuse holder C -SC18-¹⁾	30

¹⁾ Only models with start/stop system

²⁾ Only models with diesel engines

³⁾ Only models with a petrol engine

⁴⁾ Depends on equipment

⁵⁾ Only models with navigation system

⁶⁾ Only models with radio

⁷⁾ Only models with start/stop system

⁸⁾ Only models with reducing agent metering system

⁹⁾ Only models without reducing agent metering system

¹⁰⁾ Only models with auxiliary air heater

¹¹⁾ Only applicable to special vehicles

¹²⁾ for CNG models only

¹³⁾ Only models with air conditioning system/Climatronic

¹⁴⁾ Only models with equipment for Korea

¹⁵⁾ Only ethanol vehicles

Fuse assignment on fuse holder B -SB- on E-box low, from May 2012

Slot		Current Flow Diagram designation	Nominal value		Function/component	Terminal
SB1	-	Fuse 1 on fuse holder B -SB1-	15 A ^{12), 15)}	-	Mechatronic unit for dual clutch gearbox -J743-^{12), 15)}	30
SB2	-	Fuse 2 on fuse holder B -SB2-	30 A	-	ABS control unit -J104-	30
SB3	-	Fuse 3 on fuse holder B -SB3-	20 A	-	Treble horn -H2- Bass horn -H7- Dual tone horn relay -J4-	30
SB4	-	Fuse 4 on fuse holder B -SB4-	15 A	-	Trailer detector control unit -J345-	30
SB5	-	Fuse 5 on fuse holder B -SB5-	5 A	-	Battery monitoring control unit -J367- Onboard supply control unit -J519-	30
SB6	-	Fuse 6 on fuse holder B -SB6-	15 A ^{2), 16)} 40 A ^{12), 17)}	-	Mechatronic unit for dual clutch gearbox -J743-^{2) 16)} Low heat output relay -J359-^{12), 17)}	30
SB7	-	Fuse 7 on fuse holder B -SB7-	15 A ^6,7) 20 A ^5,7) 30 A ¹⁾	-	Radio -R- Control unit with display for radio and navigation -J503- Voltage stabiliser -J532-⁽¹	30
SB8	-	Fuse 8 on fuse holder B -SB8-	30 A	-	Mechatronic unit for dual clutch gearbox -J743-	30
SB9	-	Fuse 9 on fuse holder B -SB9-	5 A	-	Steering column electronics control unit -J527-	30
SB10	-	Fuse 10 on fuse holder B -SB10-	20 A	-	Ignition coil 1 with output stage -N70- Ignition coil 2 with output stage -N127- Ignition coil 3 with output stage -N291- Ignition coil 4 with output stage -N292- Fuel pressure regulating valve -N276- Fuel metering valve -N290-	87
SB11	-	Fuse 11 on fuse holder B -SB11-	5 A	-	Control unit in dash panel insert -J285-	30
SB12	-	Fuse 12 on fuse holder B -SB12-	5 A	-	TV tuner -R78- Mobile telephone operating electronics control unit -J412- Analogue clock -Y- Control unit for navigation system -J856-¹⁴⁾	30
SB13	-	Fuse 13 on fuse holder B -SB13-	10 A	-	Motronic current supply relay -J271- Terminal 30 voltage supply relay -J317- Engine control unit -J623-	30
SB14	-	Fuse 14 on fuse holder B -SB14-	25 A ³⁾ 30 A ²⁾	-	Engine control unit -J623- Engine control unit -J623-	87
SB15	-	Fuse 15 on fuse holder B -SB15-	5 A	-	Data bus diagnostic interface -J533-	30
SB16	-	Fuse 16 on fuse holder B -SB16-	10 A ⁹⁾ 15 A ⁸⁾	-	Charge pressure control solenoid valve -N75-²⁾ Exhaust gas recirculation cooler changeover valve -N345- Magnetic clutch for supercharger -N421-³⁾ Continued coolant circulation relay -J151-³⁾ Continued coolant circulation pump -V51-³⁾ Coolant circulation pump 2 -V178-	87
SB17	-	Fuse 17 on fuse holder B -SB17-	10 A 40 A ¹⁰⁾	-	Fuel pressure regulating valve -N276- Fuel tank shut-off valve 1 -N361- Fuel tank shut-off valve 2 -N362- Fuel tank shut-off valve 3 -N363- Coolant circulation pump -V50- Low heat output relay -J359-¹⁰⁾	87
SB18	-	Fuse 18 on fuse holder B -SB18-	10 A ⁹⁾ 15A^{12) 15)} 30 A⁸⁾	-	Fuel quality sender -G446- High-pressure valve for gas mode -N372-	87
SB19	-	Fuse 19 on fuse holder B -SB19-	30 A	-	Amplifier -R12- Special vehicle control unit -J608-¹¹⁾	30
SB20	-	Fuse 20 on fuse holder B -SB20-	5 A	-	Brake light switch -F- Clutch position sender -G476- Low heat output relay -J359- High heat output relay -J360- Engine component current supply relay -J757- Fuel pressure regulating valve -N276-	87
SB21	-	Fuse 21 on fuse holder B -SB21-	20 A	-	Auxiliary heater control unit -J364-	30
SB22	-	Fuse 22 on fuse holder B -SB22-	30 A	-	Wiper motor control unit -J400-	30
SB23	-	Fuse 23 on fuse holder B -SB23-	10 A	-	Brake light switch -F- Air mass meter -G70- Clutch position sender -G476- Fuel pump relay -J17- Automatic glow period control unit -J179- Radiator fan control unit -J293- Additional coolant pump relay -J496- Charge pressure control solenoid valve -N75- Activated charcoal filter solenoid valve 1 -N80- Camshaft control valve 1 -N205- Turbocharger air recirculation valve -N249- Intake manifold flap valve -N316- Valve for oil pressure control -N428-	87
SB24	-	Fuse 24 on fuse holder B -SB24-	10 A^2.9 15 A	-	Lambda probe heater -Z19- Lambda probe 1 heater after catalytic converter -Z29- NOx sender 2 control unit -J881-⁸⁾	87
SB25	-	Fuse 25 on fuse holder B -SB25-	40 A	-	Onboard supply control unit -J519-	30
SB26	-	Fuse 26 on fuse holder B -SB26-	40 A	-	Onboard supply control unit -J519-	30
SB27	-	Fuse 27 on fuse holder B -SB27-	60 A	-	Heated windscreen relay -J47-	30
SB28	-	Fuse 28 on fuse holder B -SB28-	50 A	-	Automatic glow period control unit -J179-²⁾	30
SB29	-	Fuse 29 on fuse holder B -SB29-	50 A	-	Fuse 38 on fuse holder C -SC38-¹³⁾ Fuse 40 on fuse holder C -SC40- to fuse 42 on fuse holder C -SC42- X-contact relief relay -J59-	30
SB30	-	Fuse 30 on fuse holder B -SB30-	40 A	-	Terminal 15 voltage supply relay -J329- Fuse 1 on fuse holder C -SC1- to fuse 11 on fuse holder C -SC11- Fuse 20 on fuse holder C -SC20- Fuse 21 on fuse holder C -SC21- Fuse 39 on fuse holder C -SC39- Fuse 18 on fuse holder C -SC18-¹⁾	30

¹⁾ Only models with start/stop system

²⁾ Only models with diesel engines

³⁾ Only models with a petrol engine

⁴⁾ Depends on equipment

⁵⁾ Only models with navigation system

⁶⁾ Only models with radio

⁷⁾ Only models with start/stop system

⁸⁾ Only models with reducing agent metering system

⁹⁾ Only models without reducing agent metering system

¹⁰⁾ Only models with auxiliary air heater

¹¹⁾ Only applicable to special vehicles

¹²⁾ for CNG models only

¹³⁾ Only models with air conditioning system/Climatronic

¹⁴⁾ Only models with equipment for Korea

¹⁵⁾ Only ethanol vehicles

¹⁶⁾ Only for petrol engine with forced induction

¹⁷⁾ Only for petrol engine without forced induction

VW PASSAT 2015

Fuse holder B -SB- on E-box high

Fitting location

on E-box high, on left in engine compartment

Получить доступ ко всем электросхемам автомобиля

Fuse colours:

50 A - red

40 A - orange

30 A - green

25 A - clear

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

3 A - purple

Fuse assignment on fuse holder B -SB- on E-box high, from November 2011

Slot		Current Flow Diagram designation	Nominal value		Function/component	Terminal
SB1	-	Fuse 1 on fuse holder B -SB1-	5 A ¹⁾ 10 A ²⁾	-	Automatic gearbox control unit -J217- Mechatronic unit for dual clutch gearbox -J743-	30
SB2	-	Fuse 2 on fuse holder B -SB2-	30 A	-	ABS control unit -J104-	30
SB3	-	Fuse 3 on fuse holder B -SB3-	15 A	-	Trailer detector control unit -J345-	30
SB4	-	Fuse 4 on fuse holder B -SB4-		-	-Vacant
SB5	-	Fuse 5 on fuse holder B -SB5-	20 A	-	Treble horn -H2- Bass horn -H7- Dual tone horn relay -J4-	30
SB6	-	Fuse 6 on fuse holder B -SB6-	20 A	-	Ignition coil 1 with output stage -N70- Ignition coil 2 with output stage -N127- Ignition coil 3 with output stage -N291- Ignition coil 4 with output stage -N292- Ignition coil 5 with output stage -N323- Ignition coil 6 with output stage -N324-	87
SB7	-	Fuse 7 on fuse holder B -SB7-	15 A	-	Fuel pressure regulating valve -N276-	87
SB8	-	Fuse 8 on fuse holder B -SB8-	5 A ³⁾ 10 A	-	Brake light switch -F- Continued coolant circulation relay -J151- Radiator fan control unit -J293- Activated charcoal filter solenoid valve 1 -N80- Camshaft control valve 1 -N205- Exhaust camshaft control valve 1 -N318-	87
SB9	-	Fuse 9 on fuse holder B -SB9-	5 A	-	Circulation pump relay -J160-	87
SB10	-	Fuse 10 on fuse holder B -SB10-	10 A	-	Lambda probe 1 heater after catalytic converter -Z29- Lambda probe 2 heater after catalytic converter -Z30-	87
SB11	-	Fuse 11 on fuse holder B -SB11-	25 A 30 A ³⁾	-	Engine control unit -J623-	87
SB12	-	Fuse 12 on fuse holder B -SB12-	10 A ³⁾ 20A	-	Lambda probe heater -Z19- Lambda probe 2 heater -Z28-	87
SB13	-	Not assigned		-
SB14	-	Not assigned		-
SB15	-	Fuse 15 on fuse holder B -SB15-	10 A	-	Continued coolant circulation pump -V51-	87
SB16	-	Fuse 16 on fuse holder B -SB16-	5 A	-	Steering column electronics control unit -J527-	30
SB17	-	Fuse 17 on fuse holder B -SB17-	5 A	-	Control unit in dash panel insert -J285-	30
SB18	-	Fuse 18 on fuse holder B -SB18-	30 A	-	Amplifier -R12-
SB19	-	Fuse 19 on fuse holder B -SB19-	15 A ^6.7) 20 A ^5.7) 30 A ⁴⁾	-	Radio -R- Control unit with display for radio and navigation -J503- Voltage stabiliser -J532-⁽⁴	30
SB20	-	Fuse 20 on fuse holder B -SB20-	5 A	-	Analogue clock -Y- TV tuner -R78- Mobile telephone operating electronics control unit -J412- Control unit for navigation system -J856-⁸⁾	30
SB21	-	Not assigned		-
SB22	-	Not assigned		-
SB23	-	Not assigned		-
SB24	-	Fuse 24 on fuse holder B -SB24-	5 A	-	Data bus diagnostic interface -J533-	30
SB25	-	Not assigned		-
SB26	-	Fuse 26 on fuse holder B -SB26-	10 A	-	Motronic current supply relay -J271- Engine control unit -J623-	30
SB27	-	Not assigned		-
SB28	-	Not assigned		-
SB29	-	Not assigned		-
SB30	-	Fuse 30 on fuse holder B -SB30-	20 A	-	Auxiliary heater control unit -J364-	30
SB31	-	Fuse 31 on fuse holder B -SB31-	30 A	-	Wiper motor control unit -J400-	30
SB32	-	Not assigned		-
SB33	-	Not assigned		-
SB34	-	Not assigned		-
SB35	-	Fuse 35 on fuse holder B -SB35-	20 A 40 A ³⁾	-	Auxiliary heater operation relay -J485- Low heat output relay -J359-³⁾	30
SB36	-	Not assigned		-
SB37	-	Not assigned		-
SB38	-	Not assigned		-
SB39	-	Not assigned		-
SB40	-	Not assigned		-
SB41	-	Not assigned		-
SB42	-	Not assigned		-
SB43	-	Not assigned		-
SB44	-	Not assigned		-
SB45	-	Not assigned		-
SB46	-	Not assigned		-
SB47	-	Fuse 47 on fuse holder B -SB47-	40 A	-	Onboard supply control unit -J519-	30
SB48	-	Fuse 48 on fuse holder B -SB48-	40 A	-	Onboard supply control unit -J519-	30
SB49	-	Fuse 49 on fuse holder B -SB49-	50 A	-	Terminal 15 voltage supply relay -J329- Fuse 6 on fuse holder C -SC6- to fuse 11 on fuse holder C -SC11- Fuse 20 on fuse holder C -SC20- Fuse 21 on fuse holder C -SC21- Fuse 39 on fuse holder C -SC39- Fuse 18 on fuse holder C -SC18-⁴⁾	30
SB50	-	Not assigned		-
SB51	-	Fuse 51 on fuse holder B -SB51-	60 ³⁾	-	High heat output relay -J360-³⁾	30
SB52	-	Fuse 52 on fuse holder B -SB52-	60 A	-	Heated windscreen relay -J47-	30
SB53	-	Fuse 53 on fuse holder B -SB53-	50 A	-	X-contact relief relay -J59-	30
SB54	-	Fuse 54 on fuse holder B -SB54-	50	-	Automatic glow period control unit -J179-³⁾	30

¹⁾ Only models with automatic gearbox

²⁾ Only models with dual clutch gearbox

³⁾ Only for countries with hot climate

⁴⁾ Only models with start/stop system

⁵⁾ Only models with navigation system

⁶⁾ Only models with radio

⁷⁾ Only models with start/stop system

⁸⁾ Only models with equipment for Korea

VW PASSAT 2015 Fuse holder A SA

Fuse holder A -SA-

Fuse holder A -SA- , on E-box low

Получить доступ ко всем электросхемам автомобиля

Multifuse strip fuse

→ Repair Group 97

Note:

The fuse strip (multifuse) must be replaced as a complete unit.

Fuse assignment on fuse holder A -SA- , on E-box low

Screw location		Current Flow Diagram designation	Nominal value		Function/component	Terminal
SA1	-	Fuse 1 on fuse holder A -SA1-	150 A 180 A¹⁾	-	Alternator -C-	30
SA2	-	Fuse 2 on fuse holder A -SA2-	80 A	-	Electromechanical power steering motor -V187-	30
SA3	-	Fuse 3 on fuse holder A -SA3-	50 A	-	Radiator fan control unit -J293-	30
SA4	-	Fuse 4 on fuse holder A -SA4-	60 A	-	Fuse 12 on fuse holder C -SC12- to fuse 17 on fuse holder C -SC17- , Fuse 22 on fuse holder C -SC22- to fuse 27 on fuse holder C -SC27- , Fuse 28 on fuse holder C -SC28- , Fuse 44 on fuse holder C -SC44- , Fuse 46 on fuse holder C -SC46-	30
SA5	-	Fuse 5 on fuse holder A -SA5-	80 A	-	Fuse 29 on fuse holder C -SC29- to fuse 31 on fuse holder C -SC31-	30
SA6	-	Fuse 6 on fuse holder A -SA6-	70 A	-	Fuse 32 on fuse holder C -SC32- to fuse 37 on fuse holder C -SC37-	30
SA7	-	Fuse 7 on fuse holder A -SA7-	60 A	-	Second battery charging circuit relay -J713- High heat output relay -J360- Fuse 38 on fuse holder C -SC38- Fuse 43 on fuse holder C -SC43- Fuse 45 on fuse holder C -SC45-	30
SA8	-	Fuse 8 on fuse holder A -SA8-	40 A	-	ABS control unit -J104-	30

¹⁾ Only vehicles with 180 A alternator, fitted in alternator wire

Fuse holder A -SA- , on E-box high

Получить доступ ко всем электросхемам автомобиля

Fuse colours for MIDI fuse:

t	30 A - orange

t	40 A - green

t	50 A - red

t	60 A - yellow

t	70 A - brown

t	80 A - white

t	100 A - blue

t	125 A - pink

t	150 A - grey

t	200A - purple

Note:

Torque settings ⇒ Electrical system, Repair Group 97, Removing and installing fuse holders

Fuse assignment on fuse holder A -SA- , on E-box high

Screw location		Current Flow Diagram designation	Nominal value		Function/component	Terminal
SA1	-	Fuse 1 on fuse holder A -SA1-	150 A /180 A¹⁾	-	Alternator -C-	30
SA2	-	Fuse 2 on fuse holder A -SA2-	80 A	-	Electromechanical power steering motor -V187-	30
SA3	-	Fuse 3 on fuse holder A -SA3-	60 A	-	Fuse 32 on fuse holder C -SC32- to fuse 37 on fuse holder C -SC37-	30
SA4	-	Fuse 4 on fuse holder A -SA4-	50 A	-	Radiator fan control unit -J293-	30
SA5	-	Not assigned	-	-
SA6	-	Fuse 6 on fuse holder A -SA6-	80 A	-	Fuse 29 on fuse holder C -SC29- to fuse 31 on fuse holder C -SC31-	30
SA7	-	Fuse 7 on fuse holder A -SA7-	40 A	-	ABS control unit -J104-	30

¹⁾ Only vehicles with 180 A alternator, fitted in alternator wire

VW PASSAT 2015 — Vehicle location system . Wiring diagrams, Pin Connector, Location

Wiring Diagram VW PASSAT 2015 - Starter - Control unit for vehicle location system - Vehicle location system aerial 1 - Vehicle location system aerial 2 - Diagnostic connection

VW PASSAT 2015 Overview of control units

VW PASSAT 2015 Climatronic control unit J255

VW PASSAT 2015 Control unit for cornering light and headlight range control J745

VW PASSAT 2015

VW PASSAT 2015 Front passenger door control unit J387

VW PASSAT 2015 Driver door control unit J386

VW PASSAT 2015 Control unit for electromechanical parking brake J540

VW PASSAT 2015 Control unit for seat adjustment and steering column adjustment with memory function J136

VW PASSAT 2015 Special purpose vehicle control unit J608

VW PASSAT 2015 Amplifier R12

VW PASSAT 2015

VW PASSAT 2015 Electronic steering column lock control unit J764

VW PASSAT 2015

VW PASSAT 2015 Data bus diagnostic interface J533

VW PASSAT 2015 Overview of control units

VW PASSAT 2015 Power steering control unit J500

VW PASSAT 2015 Overview of relay carriers

VW PASSAT 2015 Relay carrier 1

VW PASSAT 2015 Overview of fuses

VW PASSAT 2015

VW PASSAT 2015

VW PASSAT 2015

VW PASSAT 2015 Safety cutout under dash panel, driver side

VW PASSAT 2015

VW PASSAT 2015

VW PASSAT 2015 Fuse holder A SA

Войти

Регистрация

Получить новый пароль