VW GOLF PLUS 2008 — Engine preheating . Wiring diagrams, Pin Connector, Location

Wiring Diagram VW GOLF PLUS 2008 - Engine preheating element

J519	Onboard supply control unit
T1u	2-pin connector, in front engine compartment
T2ap	2-pin connector, on front of engine
U8	External socket, 230 V, 110 V, on front right bumper
Z97	Engine preheating element
209	Earth connection 6, in engine compartment wiring harness
640	Earth point, left in engine compartment
655	Earth point, on left headlight
*	Only on vehicles with retrofitted item
**	Only engine code CCSA

VW GOLF PLUS 2008

VW GOLF PLUS 2008 Overview of control units

Overview of control units

   

1 -	Power steering control unit -J500-

q	Fitting location → Page 804/3

q	Connector assignment → Page 804/4

2 -	Auxiliary heater control unit -J364-

q	Fitting location → Page 804/5

3 -	ABS with EDL control unit -J104-

q	Fitting location → Page 804/6

q	Connector assignment with ESP → Page 804/7

q	Connector assignment with no ESP → Page 804/8

4 -	Airbag control unit -J234-

q	Fitting location → Page 804/9

q	50-pin connector assignment → Page 804/10

q	75-pin connector assignment → Page 804/11

5 -	Convenience system central control unit -J393-

q	Fitting location → Page 804/12

q	Connector assignment → Page 804/13

Golf Plus	Fitting Locations	No.  804 / 2

6 -	Steering column electronics control unit -J527-

q	Fitting location → Page 804/14

q	Connector assignment → Page 804/15

7 -	Dash panel insert -K-

q	Connector assignment → Page 804/21

8 -	Onboard supply control unit -J519-

q	Fitting location → Page 804/24

q	Connector assignment → Page 804/25

9 -	Vehicle inclination sender -G384-

q	Fitting location → Page 804/33

10 -	Data bus diagnostic interface -J533-

q	Fitting location → Page 804/34

q	Connector assignment → Page 804/35

11 -	Automatic gearbox control unit -J217-

q	Fitting location → Page 804/36

q	Connector assignment → Page 804/37

12 -	Engine control unit -J623-

q	Fitting location → Page 804/38

q	80-pin connector assignment → Page 804/39

q	154-pin connector assignment → Page 804/40

Golf Plus	Fitting Locations	No.  804 / 3

Power steering control unit -J500-

Fitting location: Central on steering assembly carrier -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 4

Connector assignment:

A -	Power steering control unit -J500-

Connector:

B -	5-pin connector -T5g-, on wiring harness

C -	5-pin connector -T5h-, on wiring harness

D -	2-pin connector -T2a-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 5

Auxiliary heater control unit -J364-

Fitting location: Front right in engine compartment -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 6

ABS control unit -J104-

Fitting location: On right of bulkhead in engine compartment -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 7

Connector assignment:

A -	ABS control unit -J104-

q	Only with ESP

Connector:

B -	47-pin connector -T47-/ -T47a-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 8

Connector assignment:

A -	ABS control unit -J104-

Connector:

B -	26-pin connector -T26a-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 9

Airbag control unit -J234-

Fitting location: Under centre console -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 10

Connector assignment:

A -	Airbag control unit -J234-

Connector:

B -	50-pin connector -T50-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 11

Connector assignment:

A -	Airbag control unit -J234-

Connector:

B -	75-pin connector -T75-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 12

Convenience system central control unit -J393-

Fitting location: Behind glove compartment on right below dash panel -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 13

Connector assignment:

A -	Convenience system central control unit -J393-

Connector:

B -	6-pin connector -T6-, on wiring harness

C -	18-pin connector -T18-, on wiring harness

D -	8-pin connector -T8n-, on wiring harness

E -	6-pin connector -T6m-, on wiring harness

F -	18-pin connector -T18a-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 14

Steering column electronics control unit -J527-

Fitting location: Under steering column, near steering column switch -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 15

Connector assignment:

A -	Steering column electronics control unit -J527-

Connector:

B = Connector for airbag control unit:

1 -	Airbag 1 -

2 -	Airbag 1 +

3 -	Airbag 2 +

3 -	Airbag 2 -

C = Cruise control system (CCS) and turn signal connector:

1 -	Cruise control system terminal 15 voltage supply

2 -

CCS off

3 -	Res (+), Set (-)

4 -	CCS on/off

5 -	Cruise control system earth

6 -	Cruise control system illumination terminal 58

7 -	Headlight flasher

Golf Plus	Fitting Locations	No.  804 / 16

8 -

Main beam

9 -	Turn signal

10 -	Turn signal earth

D= 20-pin connector:

2 -	Not assigned

3 -	Not assigned

4 -	Not assigned

5 -	Not assigned

6 -	Not assigned

7 -	Not assigned

8 -	Not assigned

9 -	Not assigned

10 -	Not assigned

11 -	Diagnostic interface for powertrain CAN data bus, low

12 -	Diagnostic interface for powertrain CAN data bus, high

13 -	Cruise control system, output

Golf Plus	Fitting Locations	No.  804 / 17

14 -	Diagnostic interface for convenience CAN data bus, low

15 -	Diagnostic interface for convenience CAN data bus, high

16 -	Multifunction switch

q	Only automatic or dual clutch gearbox

17 -	Terminal 15

18 -	Terminal 50

19 -	Terminal 30

20 -	Terminal 31

E= 4-pin connector:

1 -	Airbag 1 -

2 -	Airbag 1 +

3 -	Airbag 2 +

4 -	Airbag 2 -

Golf Plus	Fitting Locations	No.  804 / 18

F = Connector for ignition/starter switch and ignition key withdrawal lock:

1 -	Not assigned

2 -	Not assigned

3 -	Ignition key withdrawal lock on, terminal 30

4 -	Ignition key withdrawal lock earth

5 -	Not assigned

6 -	Not assigned

7 -	Ignition/starter switch output terminal 50

8 -	Ignition/starter switch, terminal 30

9 -	Ignition/starter switch output terminal S

10 -	Ignition/starter switch output terminal X

11 -	Ignition/starter switch output terminal P

12 -	Ignition/starter switch output terminal 15

Golf Plus	Fitting Locations	No.  804 / 19

G = Connector for wiper, interval potentiometer and multifunction system:

1 -	Wiper switch signal

2 -	Wiper earth

3 -	Rear wash/wipe signal

4 -	Not assigned

5 -	MFI signal

6 -	MFI interval potentiometer earth

7 -	Intermittent speeds signal

8 -	Not assigned

H = Connector for steering angle sensor:

1 -	Photoelectric beam 5

2 -	Photoelectric beam 3

3 -	Photoelectric beam 1

4 -	12 volt voltage supply

5 -	5 volt voltage supply

6 -	Photoelectric beam 6

Golf Plus	Fitting Locations	No.  804 / 20

7 -	Photoelectric beam 4

8 -	Photoelectric beam 2

9 -

Earth

10 -	Photoelectric beam 7

I = Connector for coil spring:

1 -	Not assigned

2 -	Not assigned

3 -	Airbag 1 +

4 -	Airbag 1 -

5 -	Airbag 2 +

6 -	Airbag 2 -

7 -	Earth for coil connector, multifunction steering wheel and horn

8 -	CCS in detent "off", horn

9 -	LIN bus, heated steering wheel temperature sensor

10 -	Multifunction steering wheel voltage supply terminal 15

Golf Plus	Fitting Locations	No.  804 / 21

Dash panel insert -K- Connector assignment:

Connector:

1 -	Terminal 15

2 -	Terminal 30

3 -	Not assigned

4 -	Not assigned

5 -	Brake fluid level warning lamp

6 -	Handbrake warning lamp

7 -	Immobilizer reader coil

8 -	Immobilizer reader coil

9 -	Not assigned

10 -	Not assigned

11 -	Not assigned

12 -	Diagnostic interface for dash panel CAN data bus, low

13 -	Diagnostic interface for dash panel CAN data bus, high

Golf Plus	Fitting Locations	No.  804 / 22

14 -	Not assigned

15 -	Data bus diagnostic interface for dash panel CAN wake-up wire

16 -	Not assigned

17 -	Fuel gauge sender

18 -	Fuel gauge sender

19 -	Terminal 31

20 -	Not assigned

21 -	Not assigned

22 -	Front left brake pad wear sender

23 -	Not assigned

24 -	Not assigned

25 -	Oil pressure warning lamp

26 -	Oil level and oil temperature sender

27 -	Not assigned

28 -	Speed signal, sliding sunroof control unit output, control unit with display for radio and navigation system

Golf Plus	Fitting Locations	No.  804 / 23

29 -	Speed signal input

30 -	Not assigned

31 -	Not assigned

32 -	Not assigned

33 -	Terminal 31, sensor earth

34 -	Washer fluid level warning lamp

35 -	Coolant temperature and coolant shortage warning lamp

36 -	Ambient temperature sensor

Golf Plus	Fitting Locations	No.  804 / 24

Onboard supply control unit -J519-

Fitting location: On left under dash panel, below relay carrier -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 25

Connector assignment:

A = 11-pin connector:

1 -	Terminal 30

2 -	Right dipped beam bulb

3 -	Right main beam bulb

4 -	Right fog light bulb

5 -	Right gas discharge (xenon) bulb

6 -	Front right turn signal bulb

7 -	Left side light bulb

8 -	Not assigned

9 -

Earth

10 -	Electric fuel pump 2 relay

11 -	Terminal 50 voltage supply relay

B = 12-pin connector:

1 -	Right reversing light bulb

Golf Plus	Fitting Locations	No.  804 / 26

1 -	Not assigned

2 -	Not assigned

3 -	Rear left fog light bulb

4 -	Right brake and tail light bulb

5 -	Not assigned

6 -	Footwell lighting bulb front left, footwell lighting bulb front right

7 -	Not assigned

8 -	Right tail light bulb

9 -	Rear right turn signal bulb

10 -	Front interior light

11 -	Terminal 58d

C = 12-pin connector:

1 -	Heated driver seat control unit, heated front passenger seat control unit

2 -	Rear left turn signal bulb

3 -	Not assigned

Golf Plus	Fitting Locations	No.  804 / 27

1 -	Not assigned

2 -	Not assigned

3 -	Not assigned

4 -	Not assigned

5 -	Number plate light

6 -	High level brake light bulb

7 -	Left tail light bulb

8 -	Rear left turn signal bulb

9 -	Not assigned

D = 11-pin connector:

1 -	Terminal 30

2 -	Left fog light bulb

3 -	Left main beam bulb

4 -	Left dipped beam bulb

5 -

Earth

6 -	Left gas discharge (xenon) bulb

7 -	Terminal 15 voltage supply relay

8 -	Headlight washer system relay

Golf Plus	Fitting Locations	No.  804 / 28

9 -	Not assigned

10 -	Right side light bulb

11 -	Front left turn signal bulb

E = 16-pin connector:

1 -	Light switch, terminal 58

2 -	Brake light switch

3 -	Not assigned

4 -	Not assigned

5 -	Not assigned

6 -	Fog light switch

7 -	Earth (only for manual gearbox), mechatronics for dual clutch gearbox (only for dual clutch gearbox), multifunction switch (only for automatic gearbox)

8 -	Light switch, terminal 56

9 -	Not assigned

10 -	Not assigned

11 -	Not assigned

12 -	Not assigned

Golf Plus	Fitting Locations	No.  804 / 29

13 -	Light switch RFL

14 -	Light switch auto

15 -	Not assigned

16 -	Light switch day driving light

F = 8-pin connector:

1 -	Terminal 50 voltage supply relay

2 -	Terminal 15 voltage supply relay

3 -	Rain and light detector sensor (LIN bus)

4 -	Alternator

5 -	Bonnet contact switch

6 -	Reversing light switch

7 -	Terminal 30

8 -	Terminal 31

G = 12-pin connector:

1 -	Steering column electronics control unit terminal 50

Golf Plus	Fitting Locations	No.  804 / 30

2 -	Hazard warning light system warning lamp

3 -	Heated rear window

4 -	Switch and instrument illumination regulator

5 -	Not assigned

6 -	Heated rear window button

7 -	Convenience CAN bus, low

8 -	Convenience CAN bus, high

9 -	Hazard warning light switch

10 -	Switch and instrument illumination regulator

11 -	Steering column electronics control unit, terminal 15

12 -	Illumination regulators, switches, instruments

H = 12-pin connector:

Only models with no central locking.

1 -	Not assigned

2 -	Rear lid lock

3 -	Not assigned

4 -	Not assigned

Golf Plus	Fitting Locations	No.  804 / 31

5 -	Rear right door lock

6 -	Not assigned

7 -	Not assigned

8 -	Not assigned

9 -	Not assigned

10 -	Front left door lock

11 -	Front right door lock

12 -	Rear left door lock

I = 2-pin connector:

1 -	Fuse terminal 75

1 -	Terminal 75x

J = 6-pin connector:

1 -	Windscreen and rear window washer pump fuse

2 -	Rear window wiper motor and rear window washer pump

3 -

Horn fuse

Golf Plus	Fitting Locations	No.  804 / 32

4 -	Windscreen washer pump motor

5 -

Earth

6 -	Treble tone horn, bass tone horn

K = 10-pin connector:

1 -	Heated rear window

2 -	Not assigned

3 -	Not assigned

4 -	Not assigned

5 -	Terminal 30g fuse

6 -	Heated rear window fuse

7 -	Not assigned

8 -	Not assigned

9 -	Not assigned

10 -	Terminal 30g

L = 2-pin connector:

1 -	Interior terminal 15 fuse

2 -	Interior terminal 15

Golf Plus	Fitting Locations	No.  804 / 33

Vehicle inclination sender -G384-

Fitting location: On left under left dash panel -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 34

Data bus diagnostic interface -J533-

Fitting location: In left footwell near centre console -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 35

Connector assignment:

A -	Data bus diagnostic interface -J533-

Connector:

B -	20-pin connector -T20-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 36

Automatic gearbox control unit -J217-

Fitting location: In front left wheel housing -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 37

Connector assignment:

A -	Automatic gearbox control unit -J217-

Connector:

B -	52-pin connector -T52-, on wiring harness

Golf Plus	Fitting Locations	No.  804 / 38

Engine control unit -J623-

Fitting location: Central under plenum chamber cover -arrow-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  804 / 39

80-pin connector assignment:

A -	Engine control unit -J623-

Connector:

B -	28-pin connector -T80-, on wiring harness

C -	52-pin connector -T80-, on wiring harness

-T80- is comprised of items B and C.

Golf Plus	Fitting Locations	No.  804 / 40

154-pin connector assignment:

A -	Engine control unit -J623-

Connector:

B -	94-pin connector -T94-, on wiring harness

C -	60-pin connector -T60-, on wiring harness

-T154- is comprised of items B and C.

VW GOLF PLUS 2008

VW GOLF PLUS 2008 Overview of earth points in engine compartment

Overview of earth points in engine compartment

   

1 -	Earth point, on right headlight -656-

q	Fitting location → Page 801/4

2 -	Earth point 3, on bulkhead -647-

q	Fitting location → Page 801/3

3 -	Earth strap, battery - body -1-

q	Fitting location → Page 801/2

4 -	Earth point 2, on left in engine compartment -640-

q	Fitting location → Page 801/2

5 -	Earth point, on left headlight -655-

q	Fitting location → Page 801/3

6 -	Earth point for electronically controlled fan -642-

q	Fitting location → Page 801/2

7 -	Earth point, engine and gearbox earth -652-

q	Fitting location → Page 801/3

Golf Plus	Fitting Locations	No.  801 / 2

Battery negative pole -arrow A-    1 Earth strap, battery - body -arrow B-

Get access to all wiring diagrams of the car

640 Earth point, on left in engine compartment -arrow A-    642 Earth point, electronically controlled fan -arrow C-

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 3

647 Earth point 3, on bulkhead -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

652 Earth point, engine and gearbox earth -arrow D-  -  Torque setting: M8 20+/-1 Nm t  From May 2006, additionally with earth point for electromechanical power steering    655 Earth point, on left headlight -arrow B-  -  Torque setting: M6 9+/-1 Nm t  Up to April 2006

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 4

656 Earth point, on right headlight -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 5

Overview of earth points in vehicle interior

1 -	Earth point, in front right footwell -47-

q	Fitting location → Page 801/6

2 -	Earth point, lower part of right A-pillar -43-

q	Fitting location → Page 801/6

3 -	Earth point, on right A-pillar -638-

q	Fitting location → Page 801/6

4 -	Earth point, centre behind dash panel -45-

q	Fitting location → Page 801/7

5 -	Earth point, lower part of right B-pillar -78-

q	Fitting location → Page 801/8

6 -	Earth point, lower part of left B-pillar -77-

q	Fitting location → Page 801/8

7 -	Earth point, on top end of steering column -605-

q	Fitting location → Page 801/7

8 -	Earth point, lower part of left A-pillar -44-

q	Fitting location → Page 801/6

9 -	Earth point, in front left footwell -602-

q	Fitting location → Page 801/6

Golf Plus	Fitting Locations	No.  801 / 6

43 Earth point, lower part of right A-pillar -arrow A-  -  Torque setting: M6 9+/-1 Nm    47 Earth point, in front right footwell -arrow B-  -  Torque setting: M6 9+/-1 Nm t  Up to April 2006    638 Earth point, on right A-pillar -arrow C-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

44 Earth point, lower part of left A-pillar -arrow A-  -  Torque setting: M6 9+/-1 Nm    602 Earth point, in front left footwell -arrow B-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 7

45 Earth point, centre behind dash panel -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

605 Earth point, on top end of steering column -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 8

77 Earth point, on lower part of left B-pillar -arrow-  -  Torque setting: M6 9+/-1 Nm t  Up to April 2006

Get access to all wiring diagrams of the car

78 Earth point, lower part of right B-pillar -arrow-  -  Torque setting: M6 9+/-1 Nm t  Up to April 2006

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 9

Overview of earth points in luggage compartment

1 -	Earth point, on rear right of roof -666-

q	Fitting location → Page 801/10

2 -	Earth point 2, in rear right side panel -682-

q	Fitting location → Page 801/10

3 -	Earth point, on right in rear lid -53-

q	Fitting location → Page 801/11

4 -	Earth point, in rear left side panel -662-

q	Fitting location → Page 801/11

Golf Plus	Fitting Locations	No.  801 / 10

666 Earth point, on rear right of roof -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

682 Earth point 2, in rear right side panel -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

Golf Plus	Fitting Locations	No.  801 / 11

53 Earth point, on right in rear lid -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car

662 Earth point, in rear left side panel -arrow-  -  Torque setting: M6 9+/-1 Nm

Get access to all wiring diagrams of the car