VW PASSAT 1983 – Climatronic, (9AK) . Wiring diagrams, Pin Connector, Location

Wiring Diagram VW PASSAT 1983 - Terminal 15 power supply relay 2 - Fuse 4 (on fuse panel C) - Fuse 4 (on fuse panel A) - Fuse 23 (on fuse panel B) - Fuse 25 (on fuse panel C) - Fuse 32 (on fuse panel C)

J681	Terminal 15 power supply relay 2
SC	Fuse panel C
SC4	Fuse 4 (on fuse panel C)
SA4	Fuse 4 (on fuse panel A)
SB23	Fuse 23 (on fuse panel B)
SC25	Fuse 25 (on fuse panel C)
SC32	Fuse 32 (on fuse panel C)
B163	Positive connection 1 (15) (in interior wiring harness)
B169	Positive connection 1 (30) (in interior wiring harness)
B170	Positive connection 2 (30) (in interior wiring harness)
B492	Positive connection 3 (15) (in interior wiring harness)
*	Refer to applicable standard equipment wiring diagram

Wiring Diagram VW PASSAT 1983 - High pressure sensor - Climatronic control module

">G65	"> High pressure sensor
">J255	"> Climatronic control module
">J774	"> Front seat heating control module
T3c	3-pin connector
T8z	8-pin connector
T10c	10-pin connector
T20c	20-pin connector
366	Ground connection 1 (in main wiring harness)
388	Ground connection 23 (in main wiring harness)
A189	Positive connection 5 (30a) (in instrument panel wiring harness)
A217	Positive connection 8 (15a) (in instrument panel wiring harness)
B431	Seat heating connection (in main wiring harness)
M45	Connection 5 (in driver seat wiring harness)

Wiring Diagram VW PASSAT 1983 - Sunlight photo sensor - Left vent temperature sensor - Right vent temperature sensor - Air quality sensor - Left footwell vent temperature sensor - Evaporator temperature sensor - Light recognition sensor - Climatronic control module - Vehicle electrical system control module

">G107	"> Sunlight photo sensor
G134	Sunlight photo sensor 2
">G150	"> Left vent temperature sensor
">G151	"> Right vent temperature sensor
">G238	"> Air quality sensor
">G261	"> Left footwell vent temperature sensor
">G308	"> Evaporator temperature sensor
G399	Light recognition sensor
">J255	"> Climatronic control module
J519	Vehicle electrical system control module
J533	Data bus on board diagnostic interface
T2bh	Double connector
T2bq	Double connector
T2da	Double connector
T2j	Double connector
T3aw	3-pin connector
T4n	4-pin connector
T6ap	6-pin connector
T16g	16-pin connector
T20	20-pin connector
T20c	20-pin connector
T52a	52-pin connector
T52c	52-pin connector
370	Ground connection 5 (in main wiring harness)
B397	Comfort system CAN bus high connection 1 (in main wiring harness)
B406	Comfort system CAN bus low connection 1 (in main wiring harness)
L7	Connection 3 (in A/C unit wiring harness)
L9	Connection 1 (in A/C system wiring harness)
*	Only for vehicles with Korea equipment
*2	Only for vehicles with US equipment
*3	Only for vehicles without rain/light recognition sensor

Wiring Diagram VW PASSAT 1983 - Defroster door motor position sensor - Left temperature door potentiometer/actuator - Right footwell vent temperature sensor - Climatronic control module - Defroster door motor - Left temperature door motor

">G135	"> Defroster door motor position sensor
">G220	"> Left temperature door potentiometer/actuator
">G262	"> Right footwell vent temperature sensor
">J255	"> Climatronic control module
T2db	Double connector
T6p	6-pin connector
T6q	6-pin connector
T16e	16-pin connector
T16g	16-pin connector
">V107	"> Defroster door motor
">V158	"> Left temperature door motor
L7	Connection 3 (in A/C unit wiring harness)
L8	Connection 4 (in A/C unit wiring harness)

Wiring Diagram VW PASSAT 1983 - Right temperature door potentiometer/actuator - Front air distribution door motor position sensor - Fresh air/recirculating air/back pressure door motor position sensor - Climatronic control module - Right temperature door motor - Fresh air/recirculating air/back pressure door motor - Front air distribution door motor

G221	Right temperature door potentiometer/actuator
G642	Front air distribution door motor position sensor
">G644	"> Fresh air/recirculating air/back pressure door motor position sensor
">J255	"> Climatronic control module
T6n	6-pin connector
T6r	6-pin connector
T6t	6-pin connector
T16e	16-pin connector
T16g	16-pin connector
">V159	"> Right temperature door motor
">V425	"> Fresh air/recirculating air/back pressure door motor
V426	Front air distribution door motor
L7	Connection 3 (in A/C unit wiring harness)
L8	Connection 4 (in A/C unit wiring harness)

Wiring Diagram VW PASSAT 1983 - Fresh air blower control module - Climatronic control module - A/C compressor regulator valve - Fresh air blower

">J126	"> Fresh air blower control module
">J255	"> Climatronic control module
">N280	"> A/C compressor regulator valve
T2gt	Double connector
T4t	4-pin connector
T6t	6-pin connector
T10a	10-pin connector
T16e	16-pin connector
T20c	20-pin connector
">V2	"> Fresh air blower
132	Ground connection 3 (in engine compartment wiring harness)
376	Ground connection 11 (in main wiring harness)

VW PASSAT 1983 Overview of Relay Carrier

Overview of Relay Carrier

2 -	Relay and fuse carrier 3 -SR3- , on the lower vehicle electrical system control module

t	Starter relay 2 -J907-

t	Heating, ventilation and air conditioning relay via remote start -J951-

q	Component location and relay assignment, from January 2011

t	Recirculation pump relay -J160-

t	Motronic engine control module power supply relay -J271-

t	Secondary air injection pump relay -J299-

t	Terminal 30 power supply relay -J317-

t	Low heat output relay -J359-

t	High heat output relay -J360-

t	Wiper motor change-over relay -J368-

t	Wiper motor change-over relay 2 -J369-

q	Component location and relay assignment, from January 2011

VW PASSAT 1983 Component location and relay assignment Relay and fuse carrier 1 SR1

Component location and relay assignment Relay and fuse carrier 1 -SR1-

1 -	Wiper motor change-over relay 2 -J369-

q	Relay location R1

2 -	Wiper motor change-over relay -J368-

q	Relay location R2

3 -	Motronic engine control module power supply relay -J271-

q	Relay location R3

q	Only for vehicles with gasoline engine

Terminal 30 power supply relay -J317-

q	Relay location R3

q	Only vehicles with a diesel engine

4 -	Low heat output relay -J359-

q	Relay location R4

q	Only vehicles with a diesel engine

Recirculation pump relay -J160-

q	Relay location R4

q	Only on vehicles with a 6-cylinder engine

Secondary air injection pump relay -J299-

q	Relay location R4

q	Only for vehicles with gasoline engine

5 -	High heat output relay -J360-

q	Relay location R5

q	Only vehicles with a diesel engine

6 -	Automatic glow time control module -J179-

q	Relay location R6

q	Only vehicles with a diesel engine

Back to overview

VW PASSAT 1983

Relay and fuse carrier 2 -SR2- , on upper vehicle electrical system control module

1 -	Terminal 15 power supply relay 2 -J681-

q	Fuse location 1

2 -	Terminal​ 75​ power​ supply​ relay 1 -J680-

q	Fuse location 2

3 -	Dual tone horn relay -J4-

q	Connection 3/1

Rear window defogger relay -J9-

q	Connection 3/2

4 -	Starter relay 1 -J906-

q	Fuse location 4

q	Depending on equipment

Terminal 50 power supply relay -J682-

q	Fuse location 4

q	Depending on equipment

5 -	Fuel pump relay -J17-

q	Fuse location 5

Back to overview

VW PASSAT 1983

Relay and fuse carrier 3 -SR3- , on the lower vehicle electrical system control module

1 -

Not used

2 -	Heating, ventilation and air conditioning relay via remote start -J951-

3 -	Starter relay 2 -J907-

4 -

Not used

5 -

Not used

Back to overview

VW PASSAT 1983 Overview of fuse holder

Overview of fuse holder    

q	Fuse assignment, from January 2011

q	Fuse assignment, from January 2011

q	Fuse assignment, from December 2011

q	Fuse assignment, from January 2011

q	Fuse assignment, from December 2011

q	Fuse assignment, from January 2011

VW PASSAT 1983 Component location fuse panel A SA

Component location fuse panel A -SA-

1 -	Fuse panel A -SA-

Multi-fuse fuse strip

The fuse strip (multi-fuse) must be replaced as a complete unit.

Back to overview

VW PASSAT 1983

Fuse assignment fuse panel A -SA- , from January 2011

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
508	A	508 - Threaded Connection - terminal 30 (on electronics box)		-		30
SA1	B	Fuse 1 on fuse panel A -SA1-	200A 1) 250A 2)	-	Generator -C-	30a
SA2	C	Fuse 2 on fuse panel A -SA2-	80A 2) 3)	-	Fuse panel F -SF-	30a
SA3	D	Fuse 3 on fuse panel A -SA3-	80A	-	Power steering control module -J500-	30a
SA4	E	Fuse 4 on fuse panel A -SA4-	80A		Fuse panel C -SC-	30a

1) Only for vehicles with gasoline engine

2) only for vehicles with a diesel engine

3) only on vehicles with a 6-cylinder engine

Back to overview

VW PASSAT 1983 Component location fuse panel B SB

Component location fuse panel B -SB-

1 -	Fuse panel B -SB-

Fuse colors, SB1 through SB20

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Fuse colors, SB21 through SB32

t	50 A - red

t	40 A - green

t	30 A - pink

Back to overview

VW PASSAT 1983

Fuse assignment fuse panel B -SB- , from January 2011

1 -	Fuse panel B -SB-

Fuse colors, SB1 through SB20

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Fuse colors, SB21 through SB32

t	50 A - red

t	40 A - green

t	30 A - pink

Passat	Fitting Locations	No.  802 / 6

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
F1	-	Fuse 1 on fuse panel B -SB1-	-	-	Not used	-
F2	-	Fuse 2 on fuse panel B -SB2-	15A 30A 1) 2)	-	Engine control module -J623-	87a
F3	-	Fuse 3 on fuse panel B -SB3-	30A	-	Coolant fan control module -J293- Reducing agent reservoir sensor -G697-(2 Reducing​ agent​ reservoir​ processing​ unit​ -G698-(2 Wastegate bypass regulator valve -N75-(2 Positive crankcase ventilation heating element -N79- Reversing valve for reducing agent -N473-2)oil pressure regulating valve -N428-(3 EVAP canister purge regulator valve 1 -N80-(3 Camshaft​ adjustment​ valve​ 1 -N205-(3	87a
F4	-	Fuse 4 on fuse holder B -SB4-	15A 20A 1) 2)	-	NOx sensor -G295-(2 NOx sensor control module -J583-(2 Oxygen sensor heater -Z19- Oxygen​ sensor​ 1 before​ catalytic​ converter​ -GX10- Oxygen sensor 2 heater -Z28-(1	87a
F5	-	Fuse 5 on fuse holder B -SB5-	5A (2 10A (3 (4 15A (3 (4 20A (1	-	Mass air flow sensor -G70-(2 Heater for oxygen sensor 1 after catalytic converter -Z29- Heater for oxygen sensor 2 after catalytic converter -Z30-(1	87a
F6	-	Fuse 6 on fuse panel B -SB6-	10A 20A (1	-	Fuel pressure regulator valve -N276-(1 Low heat output relay -J359-(2 High heat output relay -J360-(2 Secondary​ air​ pump​ relay -J299-(3 Fuel pump relay -J17-(3 Secondary​ air​ injection​ solenoid​ valve -N112-(3 Leak detection pump -V144-(3	87a
F7	-	Fuse 7 on the fuse panel B -SB7-	20A (2 30A	-	Fuel pressure regulator valve -N276-(2 Fuel metering valve -N290-(2 Charge air cooling pump -V188-(2 Ignition coil 1 with power output stage -N70- Ignition coil 2 with power output stage -N127- Ignition coil 3 with power output stage -N291- Ignition coil 4 with power output stage -N292- Ignition coil 5 with power output stage -N323- Ignition coil 6 with power output stage -N324-(1	87a
F8	-	Fuse 8 on fuse panel B -SB8-	10A (1 30A (2	-	Auxiliary coolant pump relay -J496-(1 EVAP canister purge regulator valve 1 -N80-(1 Camshaft​ adjustment​ valve​ 1 -N205-(1 Exhaust​​ camshaft​​ adjustment​​ valve​​ 1 -N318-(1 Leak detection pump -V144-(1Reducing agent heater control module -J891-(2	87a
F9	-	Fuse 9 on fuse panel B -SB9-	5A	-	Brake lamp switch -F- Brake pedal switch -F47- Clutch position sensor -G476-	87a
F10	-	Fuse 10 on fuse holder B --SB10--	5A	-	Mass air flow sensor -G70-(1 Fuel pump relay -J17-(2 Automatic glow time control module -J179-(2	87a
F11	-	Fuse 11 on fuse panel B --SB11--	30A (1	-	DSG​ transmission​ Mechatronic -J743-(1	30a
F12	-	Fuse 12 on fuse panel B -SB12-	15A (1	-	Coolant pump -VX20-1	87a
F13	-	Fuse 13 on fuse panel B -SB13-	30A	-	Radio -R- Radio/navigation display unit control module -J503-	30a
F14	-	Fuse 14 on fuse panel B -SB14-	5A	-	Motronic engine control module power supply relay -J271-(1 (3 Engine control module -J623- Terminal 30 power supply relay -J317-(2	30a
F15	-	Fuse 15 (on fuse panel B) -SB15-	20A	-	High tone horn -H2- Low tone horn -H7- Dual tone horn relay -J4-	30a
F16	-	Fuse 16 on fuse panel B -SB16-	40A	-	Amplifier -R12-	30a
F17	-	Fuse 17 on fuse panel B -SB17-	30A(2	-	DSG​ transmission​ Mechatronic -J743-(2	30a
F18	-	Fuse 18 on fuse holder B -SB18--	5A	-	Telephone transceiver -R36-	30a
F19	-	Fuse 19 on fuse panel B -SB19-	5A	-	Vehicle electrical system control module -J519-	30 Ref.
F20	-	Fuse 20 on fuse panel B -SB20-	40A		Wiper motor change-over relay -J368- Wiper motor change-over relay 2 -J369-	30a
F21	-	Fuse 21 (on fuse panel B) -SB21-	40A	-	Secondary​ air​ injection​ pump​ motor -V101-(3 Auxiliary heater heating element -Z35-(2	30a
F22	-	Fuse 22 on fuse panel B -SB22-	40A 2)	-	Auxiliary heater heating element -Z35-(2	30a
F23	-	Fuse 23 on fuse holder B -SB23-	50A	-	Fuse 32 on fuse panel C -SC32- Fuse 33 on fuse panel C -SC33- Fuse 34 on fuse panel C -SC34- Fuse 35 on fuse panel C -SC35- Fuse 36 on fuse panel C -SC36- Fuse 37 on fuse panel C -SC37- Driver and front passenger seat circuit breaker -S346-	30a
F24	-	Fuse 24 (on fuse panel B) -SB24-	50A	-	Terminal​ 75​ power​ supply​ relay 1 -J680-	30a
F25	-	Fuse 25 on fuse panel B -SB25-	40A	-	Terminal 15 power supply relay 2 -J681-	30a
F26	-	Fuse 26 on fuse panel B -SB26-	50A (2	-	Automatic glow time control module -J179- (2	30a
F27	-	Fuse 27 on fuse panel B -SB27-	50A	-	Coolant fan control module -J293-	30a
F28	-	Fuse 28 on fuse panel B -SB28-	40A	-	Vehicle electrical system control module -J519-	30a
F29	-	Fuse 29 (on fuse panel B) -SB29-	40A	-	Vehicle electrical system control module -J519-	30a
F30	-	Fuse 30 on fuse panel B -SB30-	40A	-	ABS control module -J104-	30a
F31	-	Fuse 31 on the fuse panel B -SB31-	30A	-	ABS control module -J104-	30a
F32	-	Fuse 32 on fuse panel B -SB32-	40A (2	-	Auxiliary heater heating element -Z35-(2	30a

1) only on vehicles with a 6-cylinder engine

2) only for vehicles with a diesel engine

3) Only for vehicles with gasoline engine

4) Depending on equipment

Back to overview

VW PASSAT 1983

Fuse assignment, fuse panel B -SB- , from December 2011

1 -	Fuse panel B -SB-

Fuse colors, SB1 through SB20

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Fuse colors, SB21 through SB32

t	50 A - red

t	40 A - green

t	30 A - pink

Passat	Fitting Locations	No.  802 / 8

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
F1	-	Fuse 1 on fuse panel B -SB1-	-	-	Not used	-
F2	-	Fuse 2 on fuse panel B -SB2-	15A 30A 1) 2)	-	Engine control module -J623-	87a
F3	-	Fuse 3 on fuse panel B -SB3-	5A 1) 2) 7.5A 2) 4) 15A 3)	-	Coolant fan control module -J293- Reducing agent reservoir sensor -G697-(2 Reducing​ agent​ reservoir​ processing​ unit​ -G698-(2 Wastegate bypass regulator valve -N75-(2 Positive crankcase ventilation heating element -N79- Reversing valve for reducing agent -N473-2)oil pressure regulating valve -N428-(3 EVAP canister purge regulator valve 1 -N80-(3 Camshaft​ adjustment​ valve​ 1 -N205-(3	87a
F4	-	Fuse 4 on fuse holder B -SB4-	15A 2) 3) 4) 20A 1) 2)	-	NOx sensor -G295-(2 NOx sensor control module -J583-(2 Oxygen sensor heater -Z19- Oxygen​ sensor​ 1 before​ catalytic​ converter​ -GX10- Oxygen sensor 2 heater -Z28-(1	87a
F5	-	Fuse 5 on fuse holder B -SB5-	5A (2 10A 1) 3)	-	Mass air flow sensor -G70-(2 Heater for oxygen sensor 1 after catalytic converter -Z29- Heater for oxygen sensor 2 after catalytic converter -Z30-(1	87a
F6	-	Fuse 6 on fuse panel B -SB6-	5A 3) 4) 7.5A 3) 4) 10A 20A (1	-	Fuel pressure regulator valve -N276-(1 Low heat output relay -J359-(2 High heat output relay -J360-(2 Secondary​ air​ pump​ relay -J299-(3 Fuel pump relay -J17-(3 Secondary​ air​ injection​ solenoid​ valve -N112-(3 Leak detection pump -V144-(3	87a
F7	-	Fuse 7 on the fuse panel B -SB7-	7.5A (2 30A	-	Fuel pressure regulator valve -N276-(2 Fuel metering valve -N290-(2 Charge air cooling pump -V188-(2 Ignition coil 1 with power output stage -N70- Ignition coil 2 with power output stage -N127- Ignition coil 3 with power output stage -N291- Ignition coil 4 with power output stage -N292- Ignition coil 5 with power output stage -N323- Ignition coil 6 with power output stage -N324-(1	87a
F8	-	Fuse 8 on fuse panel B -SB8-	5A (1 30A (2	-	Auxiliary coolant pump relay -J496-(1 EVAP canister purge regulator valve 1 -N80-(1 Camshaft​ adjustment​ valve​ 1 -N205-(1 Exhaust​​ camshaft​​ adjustment​​ valve​​ 1 -N318-(1 Leak detection pump -V144-(1Reducing agent heater control module -J891-(2	87a
F9	-	Fuse 9 on fuse panel B -SB9-	5A 1) 2)	-	Mass air flow sensor -G70-(1 Automatic glow time control module -J179-(2 Fuel pump relay -J17-(2	87a
F10	-	Fuse 10 on fuse holder B --SB10--	5A	-	Brake lamp switch -F- Brake pedal switch -F47- Clutch position sensor -G476-	87a
F11	-	Fuse 11 on fuse panel B --SB11--	15A (1	-	DSG​ transmission​ Mechatronic -J743-(1	30a
F12	-	Fuse 12 on fuse panel B -SB12-	15A (1	-	Coolant pump -VX20-1	87a
F13	-	Fuse 13 on fuse panel B -SB13-	30A	-	Radio -R- Radio/navigation display unit control module -J503-	30a
F14	-	Fuse 14 on fuse panel B -SB14-	5A	-	Motronic engine control module power supply relay -J271-(1 (3 Engine control module -J623- Terminal 30 power supply relay -J317-(2	30a
F15	-	Fuse 15 (on fuse panel B) -SB15-	20A	-	High tone horn -H2- Low tone horn -H7- Dual tone horn relay -J4-	30a
F16	-	Fuse 16 on fuse panel B -SB16-	40A	-	Amplifier -R12-	30a
F17	-	Fuse 17 on fuse panel B -SB17-	15A (1 (2	-	DSG​ transmission​ Mechatronic -J743-(2	30a
F18	-	Fuse 18 on fuse holder B -SB18--	5A	-	Telephone transceiver -R36-	30a
F19	-	Fuse 19 on fuse panel B -SB19-	5A	-	Vehicle electrical system control module -J519-	30 Ref.
F20	-	Fuse 20 on fuse panel B -SB20-	40A		Wiper motor change-over relay -J368- Wiper motor change-over relay 2 -J369-	30a
F21	-	Fuse 21 (on fuse panel B) -SB21-	40A 50A 2)	-	Secondary​ air​ injection​ pump​ motor -V101-(3 Auxiliary heater heating element -Z35-(2	30a
F22	-	Fuse 22 on fuse panel B -SB22-	50A 2)	-	Auxiliary heater heating element -Z35-(2	30a
F23	-	Fuse 23 on fuse holder B -SB23-	50A	-	Fuse 32 on fuse panel C -SC32- Fuse 33 on fuse panel C -SC33- Fuse 34 on fuse panel C -SC34- Fuse 35 on fuse panel C -SC35- Fuse 36 on fuse panel C -SC36- Fuse 37 on fuse panel C -SC37- Driver and front passenger seat circuit breaker -S346-	30a
F24	-	Fuse 24 (on fuse panel B) -SB24-	50A	-	Terminal​ 75​ power​ supply​ relay 1 -J680-	30a
F25	-	Fuse 25 on fuse panel B -SB25-	40A	-	Terminal 15 power supply relay 2 -J681-	30a
F26	-	Fuse 26 on fuse panel B -SB26-	50A (2	-	Automatic glow time control module -J179- (2	30a
F27	-	Fuse 27 on fuse panel B -SB27-	50A	-	Coolant fan control module -J293-	30a
F28	-	Fuse 28 on fuse panel B -SB28-	40A	-	Vehicle electrical system control module -J519-	30a
F29	-	Fuse 29 (on fuse panel B) -SB29-	40A	-	Vehicle electrical system control module -J519-	30a
F30	-	Fuse 30 on fuse panel B -SB30-	40A	-	ABS control module -J104-	30a
F31	-	Fuse 31 on the fuse panel B -SB31-	30A	-	ABS control module -J104-	30a
F32	-	Fuse 32 on fuse panel B -SB32-	40A (2	-	Auxiliary heater heating element -Z35-(2	30a

1) only on vehicles with a 6-cylinder engine

2) only for vehicles with a diesel engine

3) Only for vehicles with gasoline engine

4) Depending on equipment

Back to overview

VW PASSAT 1983 Component location fuse holder C SC

Component location fuse holder C -SC-

1 -	Fuse panel C -SC-

Fuse colors, SC22 through SC45

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

Fuse colors, SC1 through SC21, SC46 through SC49

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Back to overview

VW PASSAT 1983

Fuse assignment fuse panel C -SC- , from January 2011

1 -	Fuse panel C -SC-

Fuse colors, SC22 through SC45

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

Fuse colors, SC1 through SC21, SC46 through SC49

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Passat	Fitting Locations	No.  802 / 11

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
F1	-	Fuse 1 on fuse panel C -SC1-	7.5A (2	-	Fuel pump control module -J538-(2	15a
F2	-	Fuse 2 on fuse panel C -SC2-	15A	-	Airbag control module -J234- Front passenger airbag -disabled- indicator lamp -K145-	15a
F3	-	Fuse3 on fuse panel C -SC3-	7.5A	-	Instrument cluster -K- Instrument cluster control module -J285- Data​ bus​ on​ board​ diagnostic​ interface -J533- ABS control module -J104- Light switch -E1- Oil level thermal sensor -G266- Power steering control module -J500- Selector lever sensor system control module -J587- Engine control module -J623- DSG transmission Mechatronic -J743- Starter relay 1 -J906- Starter relay 2 -J907-	15a
F4	-	Fuse 4 (on fuse panel C) -SC4-	7.5A	-	Back-up lamp switch -F4- High pressure sensor -G65- Air quality sensor -G238- Garage door opener control module -J530- Parallel​ parking​ assistance​ control​ module​ -J791- 16-pin connector -T16- (diagnostic​ connector)​ Automatic dimming interior rearview mirror -Y7- Left washer nozzle heater -Z20- Right washer nozzle heater -Z21-	15a
F5	-	Fuse 5 on fuse panel C -SC5-	-	-	Not used	-
F6	-	Fuse 6 on fuse panel C -SC6-	-	-	Not used	-
F7	-	Fuse 7 (on fuse panel C) -SC7-	-	-	Not used	-
F8	-	Fuse 8 on fuse panel C -SC8-	-	-	Not used	-
F9	-	Fuse 9 on fuse panel C -SC9-	-	-	Not used	-
F10	-	Fuse10 on fuse panel C -SC10-	-	-	Not used	-
F11	-	Fuse11 on fuse panel C -SC11-	-	-	Not used	-
F12	-	Fuse 12 (on fuse panel C) -SC12-	10A	-	Light switch -E1- 16-pin connector -T16- (diagnostic​ connector)​ Selector lever sensor system control module -J587- Vehicle electrical system control module -J519- Access/start authorization control module -J518-	30a
F13	-	Fuse13 on fuse panel C -SC13-	10A	-	Instrument cluster control module -J285-	30a
F14	-	Fuse14 on fuse panel C -SC14-	-	-	Not used	-
F15	-	Fuse 15 on use panel C -SC15-	5A	-	Electronic steering column lock control module -J764-	30a
F16	-	Fuse16 on fuse panel C -SC16-	5A	-	Data​ bus​ on​ board​ diagnostic​ interface -J533-	30a
F17	-	Fuse17 on fuse panel C -SC17-	10A	-	Steering column electronics control module -J527-	30a
F18	-	Fuse18 on fuse panel C -SC18-	-	-	Not used	-
F19	-	Fuse19 on fuse panel C -SC19-	-	-	Not used	-
F20	-	Fuse 20 on fuse panel C -SC20-	-	-	Not used	-
F21	-	Fuse 21on fuse panel C -SC21-	-	-	Not used	-
F22	-	Fuse 22 on fuse panel C -SC22-	30A	-	28-pin connector -T28a/22- (right A-pillar) 28-pin connector -T28c/22- (right B-pillar)	30a
F23	-	Fuse 23 on fuse panel C -SC23-	30A	-	Rear window defogger relay -J9- Rear window defogger -Z1-	30a
F24	-	Fuse 24 on fuse panel C -SC24-	20A 30A (1	-	Fuel pump relay -J17- Fuel pump control module -J538- Transfer fuel pump -G6-	30a
F25	-	Fuse 25 on fuse panel C -SC25-	20A	-	Climatronic control unit -J255- A/C control module -J301- Transmission control module -J217-(3	30a
F26	-	Fuse 26 on fuse panel C -SC26-	15A	-	Rear​ lid​ remote​ lock​ key​ switch​ -E232- Compass magnetic field sensor -G197- Rain/light recognition sensor -G397- Remote start system relay -J471- Analog clock -Y-	30a
F27	-	Fuse 27 on fuse panel C -SC27-	-	-	Not used	-
F28	-	Fuse 28 on ofuse panel C -SC28-	30A (3	-	Automatic transmission control module -J217-	15a
F29	-	Fuse 29 on fuse panel C -SC29-	20A	-	Vehicle electrical system control module -J519-	30A
F30	-	Fuse 30 on fuse panel C -SC30-	20A	-	Vehicle electrical system control module -J519-	30A
F31	-	Fuse 31 on fuse panel C -SC31-	30A	-	28-pin connector -T28/22- (left A-pillar) 28-pin connector -T28b/22- (left B-pillar)	30a
F32	-	Fuse32 on fuse panel C -SC32 -SC32-	40A	-	Fresh air blower control module -J126- Fresh air blower -V2-	30a
F33	-	Fuse 33 on fuse panel C -SC33-	30A	-	Front seat heating control module -J774-	30a
F34	-	Fuse 34 on fuse panel C -SC34-	20A	-	Power sunroof control module -J245- Sunroof motor -V1-	30a
F35	-	Fuse 35 on fuse panel C -SC35-	30A	-	Driver​ seat​ lumbar​ support​ adjustment​ switch -E176- Front​ passenger​ seat​ lumbar​ support​ adjustment​ switch -E177- Driver​ seat​ lumbar​ support​ curvature​ adjustment​ motor -V125- Front​ passenger​ seat​ lumbar​ support​ curvature​ adjustment​ motor -V126-	30a
F36	-	Fuse 36 on fuse panel C -SC36-	-	-	Not used	-
F37	-	Fuse 37 on fuse panel C -SC37-	-	-	Not used	-
F38	-	Fuse 38 on fuse panel C -SC38-	-	-	Not used	-
F39	-	Fuse 39 on fuse panel C -SC39-	-	-	Not used	-
F40	-	Fuse 40 on fuse panel C -SC40-	40A	-	A/C control module -J301- Fresh air blower -V2-	75a
F41	-	Fuse 41 on fuse panel C -SC41-	-	-	Not used	-
F42	-	Fuse 42 on fuse panel C -SC42-	30A	-	Cigarette lighter -U1- 12 V socket 2 -U18-	75a
F43	-	Fuse 43 on the fuse panel C -SC43-	-	-	Not used	-
F44	-	Fuse 44 on fuse panel C -SC44-	-	-	Not used	-
F45	-	Fuse 45 on fuse panel C -SC45-	-	-	Not used	-
F46	-	Fuse 46 on fuse panel C -SC46-	-	-	Not used	-
F47	-	Fuse 47 on fuse panel C -SC47-	-	-	Not used	-
F48	-	Fuse 48 on fuse panel C -SC48-	-	-	Not used	-
F49	-	Fuse 49 on fuse panel C -SC49-	-	-	Not used	-

1) only on vehicles with a 6-cylinder engine

2) only for vehicles with a diesel engine

3) Only for vehicles with gasoline engine

4) Depending on equipment

Back to overview

VW PASSAT 1983

Fuse assignment, fuse panel C -SC- , from December 2011

1 -	Fuse panel C -SC-

Fuse colors, SC22 through SC45

t	40 A - orange

t	30 A - bright green

t	25 A - natural (white)

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

Fuse colors, SC1 through SC21, SC46 through SC49

t	20 A - yellow

t	15 A - light blue

t	10 A - red

t	7.5 A - brown

t	5 A - light brown

t	3 A - purple

Passat	Fitting Locations	No.  802 / 13

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
F1	-	Fuse 1 on fuse panel C -SC1-	7.5A (2	-	Fuel pump control module -J538-(2	15a
F2	-	Fuse 2 on fuse panel C -SC2-	5A	-	Airbag control module -J234- Front passenger airbag -disabled- indicator lamp -K145-	15a
F3	-	Fuse3 on fuse panel C -SC3-	7.5A	-	Instrument cluster -K- Instrument cluster control module -J285- Data​ bus​ on​ board​ diagnostic​ interface -J533- ABS control module -J104- Light switch -E1- Oil level thermal sensor -G266- Power steering control module -J500- Selector lever sensor system control module -J587- Engine control module -J623- DSG transmission Mechatronic -J743- Starter relay 1 -J906- Starter relay 2 -J907-	15a
F4	-	Fuse 4 (on fuse panel C) -SC4-	7.5A	-	Back-up lamp switch -F4- High pressure sensor -G65- Air quality sensor -G238- Garage door opener control module -J530- Parallel​ parking​ assistance​ control​ module​ -J791- 16-pin connector -T16- (diagnostic​ connector)​ Automatic dimming interior rearview mirror -Y7-	15a
F5	-	Fuse 5 on fuse panel C -SC5-	-	-	Not used	-
F6	-	Fuse 6 on fuse panel C -SC6-	5A	-	Left washer nozzle heater -Z20- Right washer nozzle heater -Z21-	15a
F7	-	Fuse 7 (on fuse panel C) -SC7-	-	-	Not used	-
F8	-	Fuse 8 on fuse panel C -SC8-	-	-	Not used	-
F9	-	Fuse 9 on fuse panel C -SC9-	-	-	Not used	-
F10	-	Fuse10 on fuse panel C -SC10-	-	-	Not used	-
F11	-	Fuse11 on fuse panel C -SC11-	-	-	Not used	-
F12	-	Fuse 12 (on fuse panel C) -SC12-	10A	-	Light switch -E1- 16-pin connector -T16- (diagnostic​ connector)​ Selector lever sensor system control module -J587- Vehicle electrical system control module -J519-	30a
F13	-	Fuse13 on fuse panel C -SC13-	10A	-	Instrument cluster control module -J285-	30a
F14	-	Fuse14 on fuse panel C -SC14-	10A	-	Rearview camera -R189-	30a
F15	-	Fuse 15 on use panel C -SC15-	7.5A (5	-	Electronic steering column lock control module -J764-	30a
F16	-	Fuse16 on fuse panel C -SC16-	10A	-	Data​ bus​ on​ board​ diagnostic​ interface -J533-	30a
F17	-	Fuse17 on fuse panel C -SC17-	10A	-	Steering column electronics control module -J527-	30a
F18	-	Fuse18 on fuse panel C -SC18-	-	-	Not used	-
F19	-	Fuse19 on fuse panel C -SC19-	-	-	Not used	-
F20	-	Fuse 20 on fuse panel C -SC20-	-	-	Not used	-
F21	-	Fuse 21on fuse panel C -SC21-	-	-	Not used	-
F22	-	Fuse 22 on fuse panel C -SC22-	30A	-	28-pin connector -T28a/22- (right A-pillar) 28-pin connector -T28c/22- (right B-pillar)	30a
F23	-	Fuse 23 on fuse panel C -SC23-	30A	-	Rear window defogger relay -J9- Rear window defogger -Z1-	30a
F24	-	Fuse 24 on fuse panel C -SC24-	15A (6 20A	-	Fuel pump relay -J17- Fuel pump control module -J538- Transfer fuel pump -G6-	30a
F25	-	Fuse 25 on fuse panel C -SC25-	15A	-	Climatronic control unit -J255- A/C control module -J301- Transmission control module -J217-(3	30a
F26	-	Fuse 26 on fuse panel C -SC26-	5A	-	Rear​ lid​ remote​ lock​ key​ switch​ -E232- Compass magnetic field sensor -G197- Remote start system relay -J471- Analog clock -Y-	30a
F27	-	Fuse 27 on fuse panel C -SC27-	40A	-	A/C control module -J301- Fresh air blower -V2-	75a
F28	-	Fuse 28 on ofuse panel C -SC28-	30A (3	-	Automatic transmission control module -J217-	15a
F29	-	Fuse 29 on fuse panel C -SC29-	20A	-	Vehicle electrical system control module -J519-	30A
F30	-	Fuse 30 on fuse panel C -SC30-	20A	-	Vehicle electrical system control module -J519-	30A
F31	-	Fuse 31 on fuse panel C -SC31-	30A	-	28-pin connector -T28/22- (left A-pillar) 28-pin connector -T28b/22- (left B-pillar)	30a
F32	-	Fuse32 on fuse panel C -SC32 -SC32-	40A	-	Access/start authorization control module -J518-	30a
F33	-	Fuse 33 on fuse panel C -SC33-	30A	-	Front seat heating control module -J774-	30a
F34	-	Fuse 34 on fuse panel C -SC34-	20A	-	Power sunroof control module -J245- Sunroof motor -V1-	30a
F35	-	Fuse 35 on fuse panel C -SC35-	30A	-	Driver​ seat​ lumbar​ support​ adjustment​ switch -E176- Front​ passenger​ seat​ lumbar​ support​ adjustment​ switch -E177- Driver​ seat​ lumbar​ support​ curvature​ adjustment​ motor -V125- Front​ passenger​ seat​ lumbar​ support​ curvature​ adjustment​ motor -V126-	30a
F36	-	Fuse 36 on fuse panel C -SC36-	-	-	Not used	-
F37	-	Fuse 37 on fuse panel C -SC37-	-	-	Not used	-
F38	-	Fuse 38 on fuse panel C -SC38-	-	-	Not used	-
F39	-	Fuse 39 on fuse panel C -SC39-	-	-	Not used	-
F40	-	Fuse 40 on fuse panel C -SC40-	-	-	Not used	-
F41	-	Fuse 41 on fuse panel C -SC41-	-	-	Not used	-
F42	-	Fuse 42 on fuse panel C -SC42-	30A	-	Cigarette lighter -U1- 12 V socket 2 -U18-	75a
F43	-	Fuse 43 on the fuse panel C -SC43-	-	-	Not used	-
F44	-	Fuse 44 on fuse panel C -SC44-	-	-	Not used	-
F45	-	Fuse 45 on fuse panel C -SC45-	-	-	Not used	-
F46	-	Fuse 46 on fuse panel C -SC46-	-	-	Not used	-
F47	-	Fuse 47 on fuse panel C -SC47-	-	-	Not used	-
F48	-	Fuse 48 on fuse panel C -SC48-	-	-	Not used	-
F49	-	Fuse 49 on fuse panel C -SC49-	-	-	Not used	-

1) only on vehicles with a 6-cylinder engine

2) only for vehicles with a diesel engine

3) Only for vehicles with gasoline engine

4) Depending on equipment

5) only for vehicles with access/start authorization system

6) only for vehicles with Korea equipment

Back to overview

VW PASSAT 1983 Component location fuse panel F SF

Component location fuse panel F -SF-

1 -	Fuse panel F -SF-

Fuse Colors

t	200 A - purple

t	150 A - gray

t	125 A - pink

t	100 A - blue

t	80 A - natural (white)

t	70 A - brown

t	60 A - yellow

t	50 A - red

t	40 A - green

t	30 A - orange

Tightening specifications ⇒ Electrical Equipment; Repair Group 97; Fuse Panel, Removing and Installing

Back to overview

VW PASSAT 1983

Fuse assignment fuse panel F -SF- , from January 2011

No.		Designation in Wiring Diagram	Nominal Value		Function/Component	Terminal
1		Fuse 1 on fuse panel F -SF1-	125A	-	Threaded connection (30) on the E-box -508-	30
2		Fuse 2 on fuse panel F -SF2-	80A	-	Fuse 12 on fuse panel C -SC12- Fuse13 on fuse panel C -SC13- Fuse14 on fuse panel C -SC14- Fuse 15 on fuse panel C -SC15- Fuse16 on fuse panel C -SC16- Fuse17 on fuse panel C -SC17- Fuse 29 on fuse panel C -SC29- Fuse 30 on fuse panel C -SC30- Fuse 31 on fuse panel C -SC31-	30
3		Fuse 3 on fuse panel F -SF3-	80A	-	Motronic engine control module power supply relay -J271- (1 Fuse 2 on fuse panel B -SB2- Fuse 3 on fuse panel B -SB3- Fuse 4 on fuse holder B -SB4- Fuse 5 on fuse holder B -SB5- Fuse 6 on fuse panel B -SB6- Fuse 7 on the fuse panel B -SB7- Fuse 8 on fuse panel B -SB8- Fuse 9 on fuse panel B -SB9- Fuse 10 on fuse holder B --SB10--	30
4		Fuse 4 on fuse panel F -SF4-	5A		Vehicle electrical system control module -J519-	30

1) only on vehicles with a 6-cylinder engine

Back to overview

VW PASSAT 1983

Component location and fuse assignment driver and front passenger seat circuit breaker -S346-

1 -	Relay and fuse carrier 2 -SR2- , on upper vehicle electrical system control module

A -

Not used

B -	Driver and front passenger seat circuit breaker -S346-

Back to overview

VW PASSAT 1983

VW PASSAT 1983 Climatronic Overview

Climatronic Overview

4 -	Climatronic control module -J255-

5 -	Right vent temperature sensor -G151-

7 -	Fresh air blower -V2-

8 -	Fresh air blower control module -J126-

q	Includes Fresh air blower series resistor with fuse -N24-

11 -	Auxiliary heater heating element -Z35-

q	Only installed on vehicles with Diesel engine without auxiliary heater.

13 -	Left temperature door motor -V158- with Left temperature door potentiometer/actuator -G220-

15 -	Defroster door motor -V107- with Defroster door motor position sensor -G135-

16 -	Left footwell vent temperature sensor -G261-

17 -	Front air distribution door motor -V426- with Front air distribution door motor position sensor -G642-

18 -	Right temperature door motor -V159- with Right temperature door potentiometer/actuator -G221-

19 -	Right footwell vent temperature sensor -G262-

20 -	Evaporator temperature sensor -G308-

21 -	Fresh air/recirculating air/back pressure door motor -V425- with Fresh air/recirculating air/back pressure door motor position sensor -G644-

22 -	Sunlight photo sensor -G107-

23 -	Left vent temperature sensor -G150-

Control Motors On Heating and A/C Unit Climatronic

t	View -A- shows the arrangement of the control motors on the left side of the heating and A/C unit.

t	View -B- shows the arrangement of the control motors on the right side of the heating and A/C unit.

t	View -C- shows the arrangement of the control motors on the air intake grille for the heater and A/C unit.

1 -	Defroster door motor -V107- with Defroster door motor position sensor -G135-

2 -	Front air distribution door motor -V426- with Front air distribution door motor position sensor -G642-

3 -	Fresh air/recirculating air/back pressure door motor -V425- with Fresh air/recirculating air/back pressure door motor position sensor -G644-

4 -	Right temperature door motor -V159- with Right temperature door potentiometer/actuator -G221-

5 -	Left temperature door motor -V158- with Left temperature door potentiometer/actuator -G220-

  Auxiliary heater heating element -Z35-

1 -	Auxiliary heater heating element -Z35-

  Left footwell vent temperature sensor -G261-

1 -	Left footwell vent temperature sensor -G261-

  Right footwell vent temperature sensor -G262-

1 -	Right footwell vent temperature sensor -G262-

  Evaporator temperature sensor -G308-

1 -	Evaporator temperature sensor -G308-

  Left vent temperature sensor -G150-

2 -	Left vent temperature sensor -G150-

 

High pressure sensor -1- may also be installed on a different side in the vicinity of the condenser, depending on the engine version.

1 -	High pressure sensor -G65-

A/C compressor regulator valve -N280- is located in the A/C compressor and cannot be serviced. It is part of the compressor.

 

The air quality sensor is installed at the right front on the intake air grille in the plenum chamber.

 

VW PASSAT 1983 Manual Climate Control

Manual Climate Control    

Control Motors On Heating and A/C Unit Manual Air Conditioning 1 -  Recirculation door motor -V113- 2 -  Air distribution door motor -V428- . Includes Air distribution door motor position sensor -G645- . 3 -  Temperature regulator door motor -V68- . With Temperature regulator door motor position sensor -G92- .

https://portal-diagnostov.com/license.html https://portal-diagnostov.com/license.html Automotive Electricians Portal FZCO Automotive Electricians Portal FZCO Obtenga acceso a todos los diagramas de cableado del coche

VW PASSAT 1983 Overview of Control Modules

Overview of Control Modules    

Steuergerät für ABS -J104-

q	Component location

q	Pin arrangements47-pin connector -T47-

Airbag control module -J234-

q	Component location

q	Pin arrangements75-pin connector -T75-

3 -

Not used

Fresh air blower control module -J126-

q	Installed location / connector assignment

Radio -R- / Radio/navigation display unit control module -J503-

q	Component location: instrument panel, center

Climatronic control module -J255- / A/C control module -J301-

q	Component location: instrument panel, center

Front passenger door control module -J387-

q	Component location: in front passenger door

q	Pin arrangement

Telephone transceiver -R36-

q	Component location

Front​ passenger​ side​ rear​ door​ control​ module​ -J927-

q	Component location: in right rear door

q	Pin arrangement

Fuel pump control module -J538-

q	Component location

q	Pin arrangement

11 -

Not used

Driver side rear door control module -J926-

q	Component location: in left rear door

q	Pin arrangement

Amplifier -R12-

q	Installed location / connector assignment

Driver door control module -J386-

q	Component location: in driver door

q	Pin arrangement

Driver seat adjustment control module -J810-

q	Installed location / connector assignment

q	Front seat heating control module -J774-

q	Installed location / connector assignment

Electronic​ steering​ column​ lock​ control​ module -J764-

q	Installed location / connector assignment

19 -

Not used

Instrument cluster -K- / instrument​ cluster​ control​ module -J285- / anti-theft​ immobilizer​ control​ module -J362-

q	Pin arrangement

Access/start​ authorization​ control​ module -J518-

q	Installed location / connector assignment

Data​ bus​ on​ board​ diagnostic​ interface -J533-

q	Installed location / connector assignment

DSG​ transmission​ Mechatronic -J743-

q	Installed location / connector assignment

Coolant fan control module -J293-

q	Installed location / connector assignment

Power steering control module -J500-

q	Component location

q	Pin arrangement

ABS control module -J104-

-	Component location: on bulkhead in engine compartment, front passenger side

1 -	ABS control module -J104-

2 -	47-pin connector -T47- on wiring harness

  Pin Arrangements:

A -	ABS control module -J104-

Connector:

B -	47-pin connector -T47- on wiring harness

VW PASSAT 1983 Airbag control module J234

Airbag control module -J234-

-	Component location: under front center console -arrow-

  Pin Arrangements:

A -	Airbag control module -J234-

Connector:

B -	75-pin connector -T75- on wiring harness

VW PASSAT 1983 Fresh air blower control module J126

Fresh air blower control module -J126-

1 -	Fresh air blower control module -J126-

Component Location:

q	on the heating and A/C unit, front passenger footwell

Pin Connectors:

q	-A-2-pin connector -T2- on wiring harness

q	-B-6-pin connector -T6t- on wiring harness

VW PASSAT 1983 Front passenger door control module J387

Front passenger door control module -J387-

A -	Front passenger door control module -J387-

Pin Connectors:

B -	32-pin connector -T32b- on the wiring harness

C -	16-pin connector -T16b- on wiring harness

D -	20-pin connector -T20b- on wiring harness

VW PASSAT 1983 Telephone transceiver R36

Telephone transceiver -R36-

1 -	Telephone transceiver -R36-

Component Location:

q	under the front passenger seat

Connector:

2 -	54-pin connector -T54- on wiring harness

VW PASSAT 1983 Front​ passenger​ side​ rear​ door​ control​ module​ J927

Front​ passenger​ side​ rear​ door​ control​ module​ -J927-

A -	Right rear door control module -J389-

Connector:

B -	16-pin connector -T16i- on wiring harness

VW PASSAT 1983 Fuel pump control module J538

Fuel pump control module -J538-

-	Component location: under right rear seat, on fuel delivery unit -arrow-

  Pin Arrangements:

A -	Fuel pump control module -J538-

Connector:

B -	10-pin connector -T10n- on wiring harness

VW PASSAT 1983 Driver​ side​ rear​ door​ control​ module​ J926

Driver​ side​ rear​ door​ control​ module​ -J926-

A -	Left rear door control module -J388-

Connector:

B -	16-pin connector -T16h- on wiring harness

VW PASSAT 1983 Amplifier R12

Amplifier -R12-

1 -	Amplifier -R12-

Component Location:

q	under the driver seat

Connector:

q	-A-38-pin connector -T38- on wiring harenss

VW PASSAT 1983 Driver door control module J386

Driver door control module -J386-

A -	Driver door control module -J386-

Connector:

B -	32-pin connector -T32a- on wiring harness

C -	16-pin connector -T16a- on wiring harness

D -	20-pin connector -T20a- on wiring harness

VW PASSAT 1983 Driver seat adjustment control module J810

Driver seat adjustment control module -J810-

1 -	Driver seat adjustment control module -J810-

Component Location:

q	in the driver seat pan

Pin Connectors:

q	-A-12-pin connector -T12fv-

q	-B-32-pin connector -T32bv-

q	-C-16-pin connector -T16fv-

q	-D-10-pin connector -T10sv-

VW PASSAT 1983 Front seat heating control module J774

Front seat heating control module -J774-

1 -	Front seat heating control module -J774-

Component Location:

q	in the driver seat pan

Connector:

q	-A-8-pin connector -T8z- on wiring harness

VW PASSAT 1983 Steering column electronics control module J527

Steering column electronics control module -J527-

1 -	Steering column electronics control module -J527-

Component Location:

q	near the steering column switch

Pin Connectors:

q	-A-16-pin connector -T16l- on wiring harness

q	-B-4-pin connector -T4k- on wiring harness

VW PASSAT 1983 Electronic steering column lock control module J764

Electronic steering column lock control module -J764-

1 -	Electronic steering column lock control module -J764-

Component Location:

q	behind the steering column trim

Connector:

q	-A-16-pin connector -T16v- on the wiring harness

VW PASSAT 1983 Vehicle electrical system control module J519

Vehicle electrical system control module -J519-

A -	52-pin connector -T52a- black

B -	52-pin connector -T52b- white

C -	52-pin connector -T52c- brown

VW PASSAT 1983

Instrument cluster -K- / instrument cluster control module -J285- / anti-theft immobilizer control module -J362-

1 -	Instrument cluster -K- / instrument cluster control module -J285- / anti-theft immobilizer control module -J362-

Connector:

q	-A-32-pin connector -T32- on wiring harness

VW PASSAT 1983 Access/start authorization control module J518

Access/start authorization control module -J518-

1 -	Access/start authorization control module -J518-

Component Location:

q	next to steering column, near center console

Connector:

q	-A-32-pin connector -T32e- on wiring harness

VW PASSAT 1983 Data​ bus​ on​ board​ diagnostic​ interface J533

Data​ bus​ on​ board​ diagnostic​ interface -J533-

1 -	Data​ bus​ on​ board​ diagnostic​ interface -J533-

Component Location:

q	next to steering column, near center console

Connector:

q	-A-20-pin connector -T20- on wiring harness

VW PASSAT 1983 Automatic transmission control module J217

Automatic transmission control module -J217-

A -	Automatic transmission control module -J217-

Connector:

B -	52-pin connector -T52- on wiring harness

VW PASSAT 1983 DSG transmission Mechatronic J743

DSG transmission Mechatronic -J743-

1 -	DSG transmission Mechatronic -J743-

Connection on transmission:

q	-A-20-pin connector -T20e- on the wiring harness

q	Illustration be valid for Direct Shift Gearbox 02E

VW PASSAT 1983 Coolant fan control module J293

Coolant fan control module -J293-

1 -	Coolant fan control module -J293-

Connector:

q	-A/B-4-pin connector -T4x- on wiring harness

VW PASSAT 1983 Engine control module J623

Engine control module -J623-

154-pin, Pin Arrangements:

   

A -	Engine control module -J623-

Connector:

B -	94-pin connector -T94- on wiring harness

C -	60-pin connector -T60- on wiring harness

154-pin connector -T154- consists of connectors B and C

VW PASSAT 1983 Power steering control module J500

Power steering control module -J500-

Component Location:

At steering on subframe, center -arrow-

  Pin Arrangements:

A -	Power steering control module -J500-

Pin Connectors:

B -	2-pin connector -T2a- on wiring harness

C -	3-pin connector -T3- on wiring harness

D -	5-pin connector -T5g- on wiring harness

VW PASSAT 1983

VW PASSAT 1983 Overview of Ground Connections

Overview of Ground Connections

   

13	Ground point inside the engine compartment on the right side

q	Tightening specification: 9 Nm

q	Component location

638	Ground point on the right A-pillar

q	Tightening specification: 9 Nm

q	Component location

43	Ground connection on A-pillar, lower right

q	Tightening specification: 9 Nm

q	Component location

610	Audio ground connection under front center console

q	Tightening specification: 9 Nm

q	Component location

51	Ground connection inside the luggage compartment on the right side

q	Tightening specification: 9 Nm

q	Component location

605	Ground connection on upper steering column

q	Tightening specification: 9 Nm

q	Component location

50	Ground connection inside the luggage compartment on the left side

q	Tightening specification: 9 Nm

q	Component location

662	Ground connection inside the left rear side panel

q	Tightening specification: 9 Nm

q	Component location

624	Ground connection next to the battery

q	Tightening specification: 20 Nm

q	Component location

602	Ground connection inside the left front footwell

q	Tightening specification: 9 Nm

q	Component location

639	Ground connection on the left A-pillar

q	Tightening specification: 9 Nm

q	Component location

1	Ground strap, battery to body

q	Tightening specification: 20 Nm

q	Component location

640	Ground Connection 2 (in engine compartment, left)

q	Tightening specification: 9 Nm

q	Component location

655	Ground connection on the left headlamp

q	Tightening specification: 9 Nm

q	Component location

12	Ground connection inside the engine compartment on the left side

q	Tightening specification: 20 Nm

q	Component location

13	Ground point inside the engine compartment on the right side

 

638	Ground connection on the right A-pillar -A-

 

43	Ground connection on A-pillar, lower right -B-

 

610	Audio ground connection under front center console

 

51	Ground connection inside the luggage compartment on the right side

 

605	Ground connection on upper steering column

 

50	Ground connection inside the luggage compartment on the left side

 

662	Ground connection inside the left rear side panel

 

624	Ground connection next to the battery -arrow-

 

44	Ground connection left lower A-pillar -A-

 

639	Ground connection on the left A-pillar -B-

 

1	Ground strap, battery to body

 

640	Ground Connection 2 (in engine compartment, left)

 

655	Ground connection on the left headlamp

 

12	Ground connection inside the engine compartment on the left side

 

VW PASSAT 1983 Fresh air blower V2

Fresh air blower -V2-    

Passat Fitting Locations No.  880 / 2 High pressure sensor -G65-   Cavity Function 1 Ground, sensor 2 PWM signal, sensor 3 Power, sensor A/C compressor regulator valve -N280- Passat Fitting Locations No.  880 / 4 A/C control module -J301-     Climatic - 20 Pins   Cavity Function Cavity Function 1 . . . 11 . . . 2 . . . 12 Front seat heating control module, right 3 Center vent temperature sensor, signal 13 Front seat heating control module, left 4 . . . 14 . . . 5 High pressure sensor 15 . . . 6 . . . 16 A/C compressor regulator valve 7 CAN Low 17 . . . 8 CAN High 18 Center vent temperature sensor, ground 9 . . . 19 Battery power, module 10 . . . 20 Ground, module Passat Fitting Locations No.  880 / 6 Climatic - 5 Pins   Cavity Function Cavity Function 1 Fresh air blower resistor, step 3 4 Fresh air blower resistor, step 4 2 Fresh air blower resistor, step 2 5 Power, fresh air blower 3 Fresh air blower resistor, step 1     Air distribution door motor -V428- and Air distribution door motor position sensor -G645-

Climatic

Cavity	Function	Cavity	Function
1	Ground, sensor	4	. . .
2	Signal, sensor	5	Motor, mode 1
3	5 volt, sensor	6	Motor, mode 2

Recirculation door motor -V113-

Passat	Fitting Locations	No.  880 / 9

Temperature regulator door motor -V68- and Left temperature door potentiometer/actuator -G220- Passat Fitting Locations No.  880 / 10 VW PASSAT 1983 Evaporator vent temperature sensor G263 Evaporator vent temperature sensor -G263- Passat Fitting Locations No.  880 / 11 Footwell vent temperature sensor -G192-     Climatic   Cavity Function 1 Ground, sensor 2 Signal, sensor Center vent temperature sensor -G191- Passat Fitting Locations No.  880 / 13 Fresh air blower series resistor with fuse -N24-     Climatic   Cavity Function Cavity Function 1 Fresh air blower resistor, step 4 3 Fresh air blower resistor, step 1 2 Fresh air blower resistor, step 2 4 Fresh air blower resistor, step 3 Fresh air blower control module -J126- Passat Fitting Locations No.  880 / 15 Air quality sensor -G238-     Climatronic   Cavity Function 1 Switched battery, sensor 2 Ground, sensor 3 PWM signal, output Climatronic control module -J255- Passat Fitting Locations No.  880 / 17 Climatronic - 16 Pins (g)   Cavity Function Cavity Function 1 5 volt sensor, output 9 Right footwell vent temperature sensor, input 2 Left temperature door potentiometer/actuator, sensor input (5v = warm) 10 . . . 3 Right temperature door potentiometer/actuator, sensor input (5v = warm) 11 Evaporator temperature sensor, input 4 Defroster door motor position sensor, sensor input (5v = defrost) 12 . . . 5 Central door motor position sensor, sensor input (5v = instrument panel) 13 . . . 6 . . . 14 Signal ground 7 Fresh air/recirculating air/back pressure door motor position sensor, input 15 . . . 8 Left footwell vent temperature sensor, input 16 . . . Passat Fitting Locations No.  880 / 19 Sunlight photo sensor -G107- and Sunlight photo sensor 2 -G134- Passat Fitting Locations No.  880 / 20 Left temperature door motor -V158- and Left temperature door potentiometer/actuator -G220-     Climatronic   Cavity Function Cavity Function 1 Ground, sensor 4 . . . 2 Signal, sensor 5 Motor, hot 3 5 volt, sensor 6 Motor, cold Right temperature door motor -V159- and Right temperature door potentiometer/actuator -G221-     Climatronic   Cavity Function Cavity Function 1 5 volt, sensor 4 . . . 2 Signal, sensor 5 Motor, cold 3 Ground, sensor 6 Motor, hot Defroster door motor -V107- and Defroster door motor position sensor -G135-     Climatronic   Cavity Function Cavity Function 1 5 volt, sensor 4 . . . 2 Signal, sensor 5 Motor, no defrost 3 Ground, sensor 6 Motor, full defrost Fresh air/recirculating air/back pressure door motor -V425- and Fresh air/recirculating air/back pressure door motor position sensor -G644-

Climatronic

Cavity	Function	Cavity	Function
1	Ground, sensor	4	. . .
2	Signal, sensor	5	Motor, recirculation
3	5 volt, sensor	6	Motor, fresh air

Central air door motor -V70- and Central door motor position sensor -G112-    

Climatronic

Cavity	Function	Cavity	Function
1	Ground, sensor	4	. . .
2	Signal, sensor	5	Motor, vent
3	5 volt, sensor	6	Motor, foot

Left footwell vent temperature sensor -G261-

Passat	Fitting Locations	No.  880 / 26

Right footwell vent temperature sensor -G262-

Climatronic

Cavity	Function
1	Ground, sensor
2	Signal, sensor

Left vent temperature sensor -G150-

Passat	Fitting Locations	No.  880 / 28

Right vent temperature sensor -G151-

Climatronic

Cavity	Function
1	Ground, sensor
2	Signal, sensor

Evaporator temperature sensor -G308-    

Climatronic

Cavity	Function
1	Ground, sensor
2	Signal, sensor