VW TRANSPORTER 2009 — Roof ventilator . Wiring diagrams, Pin Connector, Location

Wiring Diagram VW TRANSPORTER 2009 - Roof ventilator - switch-over relay for roof ventilator - change-over switch warning lamp for roof ventilator - roof ventilator switch

E534	Switch for roof ventilator to ventilate load area
E535	Switch for roof ventilator to extract air from load area
J180	Switch-over relay 1 for roof ventilator
J181	Switch-over relay 2 for roof ventilator
K99	Change-over switch warning lamp for roof ventilator
L81	Roof ventilator switch illumination
SB35	Fuse -35- on fuse holder
SC7	Fuse -7- on fuse holder
T6m	6-pin connector, red, coupling station on left of A-pillar
T6as	6-pin connector, yellow, coupling station on left of A-pillar
V3	Roof ventilator
368	Earth connection -3-, in main wiring harness
369	Earth connection 4, in main wiring harness
375	Earth connection -10-, in main wiring harness
637	Earth point, airbag control unit
B320	Positive connection -6- (30a), in main wiring harness
B340	Connection -1- (58d), in main wiring harness
B479	Connection -15- in main wiring harness
B480	Connection -16- in main wiring harness
*	On relay carrier (2) cockpit, ⇒ Fitting locations
**	Applicable up to April 2004
***	Applicable from May 2004

VW TRANSPORTER 2009

VW TRANSPORTER 2009 Overview:

Overview:

   

1 -	Relay carrier electronics box

2 -	Relay carrier 1, cockpit

3 -	Relay carrier 2, cockpit

4 -	Relay carrier on left of seat box

The chamber marked as “vacant” can be fitted with a relay or a pin connector. See Fitting Locations "interior single fuses" and "coupling station"!

No.		Function/component		Location		Figure on page
1	-	Battery isolation relay -J7-	-	Relay carrier on left of seat box	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
2	-	Auxiliary heater relay -J8-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
3	-	Fuel pump relay -J17-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
4	-	Headlight washer system relay -J39-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
5	-	Electric fuel pump 2 relay -J49-	-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
6	-	Glow plug relay -J52-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
7	-	X-contact relief relay -J59-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
8	-	Automatic gearbox relay -J60-	-	Relay carrier electronics box (1.9 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
9	-	Alarm system control unit -J85-	-	Relay carrier (2), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
10	-	Magnetic clutch control unit -J153-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
11	-	Rear fresh air blower relay -J163-	-	Relay carrier (2), cockpit	---	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter
12	-	Automatic glow period control unit -J179-	-	Relay carrier electronics box (1.9 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
13	-	Switch-over relay 1 for roof ventilator -J180-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
14	-	Switch-over relay 2 for roof ventilator -J181-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
15	-	Differential lock control unit -J187-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
16	-	Starter inhibitor relay -J207-	-	Relay carrier electronics box (1.9 l - diesel engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	----	from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
17	-	Cut-out relay for air conditioning system magnetic coupling -J246-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
18	-	Secondary air pump relay -J299-	-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
19	-	Terminal 30 voltage supply relay -J317-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
20	-	Rotating light relay -J326-	-	Relay carrier (1), cockpit	-	from June 2003 → chapter
			-	Relay carrier (2), cockpit	--	from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier on left of seat box	--	from August 2006 → chapter from June 2007 → chapter
21	-	Folding exterior mirror control unit -J351-	-	Relay carrier (2), cockpit	--	from August 2006 → chapter from June 2007 → chapter
22	-	Brake light additional relay -J419-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
23	-	Taxi alarm system 2 control unit -J430-	-	Relay carrier (2), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
24	-	Multifunction steering wheel control unit -J453-	-	Relay carrier (2), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
25	-	Alarm system relay 1 -J460-	-	Relay carrier (2), cockpit	--	from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier on left of seat box	--	from August 2006 → chapter from June 2007 → chapter
26	-	Fresh air blower isolation relay -J487-	-	Relay carrier (1), cockpit	---	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter
			-	Relay carrier (2), cockpit	---	from January 2006 → chapter from August 2006 → chapter from June 2007 → chapter
27	-	Auxiliary coolant heater relay -J493-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
28	-	Additional coolant pump relay -J496-	-	Relay carrier electronics box (1.9 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-----	from March 2003 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter from November 2007 → chapter
29	-	Power steering control unit -J500-	-	Relay carrier electronics box (1.9 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2.0 l - petrol engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (2,5 l - diesel engine)	-	from March 2003 → chapter
			-	Relay carrier electronics box (3,2 l - petrol engine)	-	from March 2003 → chapter
30	-	Taxi alarm remote control, control unit -J601-	-	Relay carrier on left of seat box	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
31	-	Residual heat relay -J708-	-	Relay carrier (1), cockpit	-----	from March 2003 → chapter from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter
32	-	Dual signal inverter relay -J741-	-	Relay carrier on left of seat box	-	from March 2003 → chapter
			-	Relay carrier (2), cockpit	-	from June 2003 → chapter
			-	Relay carrier (1), cockpit	----	from February 2004 → chapter from June 2004 → chapter from August 2006 → chapter from June 2007 → chapter

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from March 2003 t  In electronics box in engine compartment For engine codes AXB and AXC Pos. -  Connector/designation 1 -  Glow plug relay -J52- 2 -  Fuel pump relay -J17- 3 -  Magnetic clutch control unit -J153- 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- 5 -  Vacant 6 -  Terminal 30 voltage supply relay -J317- 7 -  Additional coolant pump relay -J496- 8 -  Power steering control unit -J500- 2B -  Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from June 2004 t  In electronics box in engine compartment for engine codes AXB, AXC, BRR and BRS Pos. -  Connector/designation 1 -  Glow plug relay -J52- (103) 2)  -  Glow plug relay -J52- (100) 3)  -  Automatic glow period control unit -J179- (457) 4) 2 -  Fuel pump relay -J17- (53)  -  vacant1) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Fuel pump relay -J17- (53) 1) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)   Note t  1) applicable from January 2006 t  2) for engine codes AXB and AXC only t  3) applicable from June 2006 and engine codes AXB and AXC t  4) for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from August 2006 t  In electronics box in engine compartment for engine codes AXB, AXC, BRR and BRS Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (457) 2) 2 -  Vacant 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Fuel pump relay -J17- (53) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)   Note t  1) for engine codes AXB and AXC only t  2) for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from June 2007 t  In electronics box in engine compartment for engine codes AXB, AXC, BRR and BRS Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (457) 2) 2 -  Vacant 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Fuel pump relay -J17- (53) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)   Note t  1) for engine codes AXB and AXC only t  2) for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 1.9 l diesel engine, from November 2007 t  In electronics box in engine compartment for engine codes AXB, AXC, BRR and BRS Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (457) 2) 2 -  Vacant 3 -  Magnetic clutch control unit -J153- (454) 4 -  Vacant 5 -  Vacant  -  Starter inhibitor relay -J207- (449) 6 -  Terminal 30 voltage supply relay -J317- (643) 7 -  Fuel pump relay -J17- (449)  -  Additional coolant pump relay -J496- (449) 8 -  Vacant  -  Cut-out relay for air conditioning system magnetic coupling -J246- (449)   Note t  1) for engine codes AXB and AXC only t  2) for engine codes BRR and BRS only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from March 2003 t  In electronics box in engine compartment For engine code AXA Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- 2 -  Fuel pump relay -J17- 3 -  Magnetic clutch control unit -J153- 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- 5 -  Electric fuel pump 2 relay -J49- 6 -  Terminal 30 voltage supply relay -J317- 7 -  Additional coolant pump relay -J496- 8 -  Power steering control unit -J500- 2B -  Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from June 2004 t  In electronics box in engine compartment For engine code AXA Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Fuel pump relay -J17- (167) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from August 2006 t  In electronics box in engine compartment For engine code AXA Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Fuel pump relay -J17- (167) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from June 2007 t  In electronics box in engine compartment For engine code AXA Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Fuel pump relay -J17- (167) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 3C -  Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2.0 l petrol engine, from November 2007 t  In electronics box in engine compartment For engine code AXA Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Vacant  -  Electric fuel pump 2 relay -J49- (449) 3 -  Magnetic clutch control unit -J153- (454) 4 -  Fuel pump relay -J17- (643) 5 -  Vacant  -  Starter inhibitor relay -J207- (449) 6 -  Terminal 30 voltage supply relay -J317- (643) 7 -  Vacant  -  Additional coolant pump relay -J496- (449) 8 -  Vacant  -  Cut-out relay for air conditioning system magnetic coupling -J246- (449)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from March 2003 t  In electronics box in engine compartment For engine codes AXD and AXE Pos. -  Connector/designation 1 -  Glow plug relay -J52- 2 -  Fuel pump relay -J17- 3 -  Vacant 4 -  Starter inhibitor relay -J207- 5 -  Vacant 6 -  Terminal 30 voltage supply relay -J317- 7 -  Additional coolant pump relay -J496- 8 -  Power steering control unit -J500- 2B -  Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from June 2004 t  In electronics box in engine compartment for engine codes AXD, AXE, BLJ, BNZ and BPC Pos. -  Connector/designation 1 -  Glow plug relay -J52- (103) 2)  -  Glow plug relay -J52- (100) 3)  -  Automatic glow period control unit -J179- (475) 4) 2 -  Fuel pump relay -J17- (53) 3 -  Vacant 4 -  Vacant 5 -  Fuel pump relay -J17- (53) 1) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)   Note t  1) applicable from January 2006 t  2) for engine codes AXD, AXE and BLJ only t  3) applicable from June 2006 and engine codes AXD, AXE, BLJ t  4) for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from August 2006 t  In electronics box in engine compartment for engine codes AXD, AXE, BLJ, BNZ and BPC Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (475) 2) 2 -  Vacant 3 -  Vacant 4 -  Vacant 5 -  Fuel pump relay -J17- (53) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)   Note t  1) for engine codes AXD, AXE and BJL only t  2) for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from June 2007 t  In electronics box in engine compartment for engine codes AXD, AXE, BLJ, BNZ and BPC Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (475) 2) 2 -  Vacant 3 -  Vacant 4 -  Vacant 5 -  Fuel pump relay -J17- (53) 6 -  Terminal 30 voltage supply relay -J317- (109) 7 -  Additional coolant pump relay -J496- (53) 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)   Note t  1) for engine codes AXD, AXE and BLJ only t  2) for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 2,5 l diesel engine, from November 2007 t  In electronics box in engine compartment for engine codes AXD, AXE, BLJ, BNZ and BPC Pos. -  Connector/designation 1 -  Glow plug relay -J52- (100) 1)  -  Automatic glow period control unit -J179- (475) 2) 2 -  Vacant 3 -  Vacant 4 -  Vacant 5 -  Automatic gearbox relay -J60- (449)  -  Starter inhibitor relay -J207- (449) 6 -  Terminal 30 voltage supply relay -J317- (643) 7 -  Fuel pump relay -J17- (449)  -  Additional coolant pump relay -J496- (449) 8 -  Vacant   Note t  1) for engine codes AXD, AXE and BLJ only t  2) for engine codes BNZ and BPC only

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from March 2003 t  In electronics box in engine compartment For engine codes BDL and BDM Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- 2 -  Terminal 30 voltage supply relay -J317- 3 -  Magnetic clutch control unit -J153- 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- 5 -  Electric fuel pump 2 relay -J49-  -  Additional coolant pump relay -J496- 6 -  Fuel pump relay -J17- 7 -  Starter inhibitor relay -J207- 8 -  Power steering control unit -J500- 2B -  Automatic gearbox relay -J60-

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from June 2004 t  In electronics box in engine compartment For engine codes BDL, BDM and BKK Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Terminal 30 voltage supply relay -J317- (428)  -  Terminal 30 voltage supply relay -J317- (614) 1) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404)  -  Additional coolant pump relay -J496- (404) 6 -  Fuel pump relay -J17- (167) 7 -  Vacant 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)   Note 1) applicable from June 2006

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from August 2006 t  In electronics box in engine compartment For engine codes BDL, BDM and BKK Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Terminal 30 voltage supply relay -J317- (614) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404)  -  Additional coolant pump relay -J496- (404) 6 -  Fuel pump relay -J17- (167) 7 -  Vacant 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from June 2007 t  In electronics box in engine compartment For engine codes BDL, BDM and BKK Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Terminal 30 voltage supply relay -J317- (614) 3 -  Magnetic clutch control unit -J153- (KL2) 4 -  Cut-out relay for air conditioning system magnetic coupling -J246- (53) 5 -  Electric fuel pump 2 relay -J49- (404)  -  Additional coolant pump relay -J496- (404) 6 -  Fuel pump relay -J17- (167) 7 -  Vacant 8 -  Vacant 2B -  Automatic gearbox relay -J60- (53) 3C -  Starter inhibitor relay -J207- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier electronics box (8-pin), for 3,2 l petrol engine, from November 2007 t  In electronics box in engine compartment For engine codes BDL, BDM and BKK Pos. -  Connector/designation 1 -  Secondary air pump relay -J299- (100) 2 -  Additional coolant pump relay -J496- (449)  -  Electric fuel pump 2 relay -J49- (449) 3 -  Magnetic clutch control unit -J153- (454) 4 -  Vacant 5 -  Automatic gearbox relay -J60- (449)  -  Starter inhibitor relay -J207- (449) 6 -  Terminal 30 voltage supply relay -J317- (100) 7 -  Fuel pump relay -J17- (643) 8 -  Vacant  -  Cut-out relay for air conditioning system magnetic coupling -J246- (449)

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from March 2003 t  On left in seat box Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Vacant 4 -  Vacant 5 -  Vacant 6 -  vacant1)  -  Battery isolation relay -J7-2) 7 -  Vacant 8 -  Battery isolation relay -J7-1)  -  vacant2) 3) -  Dual signal inverter relay -J741-1)   Note t  1) applicable up to May 2003 t  2) applicable from June 2003 t  3) position is depends on equipment

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from February 2004 t  On left in seat box Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Vacant 4 -  Taxi alarm remote control, control unit -J601-1) 5 -  Vacant 6 -  Battery isolation relay -J7- 7 -  Vacant 8 -  Vacant   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from June 2004 t  On left in seat box Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Vacant 4 -  Taxi alarm remote control, control unit -J601-1) 5 -  Vacant 6 -  Battery isolation relay -J7- (100) 7 -  Vacant 8 -  Vacant   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from August 2006 t  On left in seat box Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Vacant 4 -  Taxi alarm remote control, control unit -J601-1) 5 -  Vacant 6 -  Battery isolation relay -J7- (100) 7 -  Vacant 8 -  Rotating light relay -J326- (406)  -  Alarm system relay 1 -J460-1)   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier, left in seat box (8-pin), from June 2007 t  On left in seat box Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Vacant 4 -  Taxi alarm remote control, control unit -J601-1) 5 -  Vacant 6 -  Battery isolation relay -J7- (100) 7 -  Vacant 8 -  Rotating light relay -J326- (486)  -  Alarm system relay 1 -J460- (53) 1)   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from March 2003 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Auxiliary heater relay -J8-  -  Residual heat relay -J708- 2 -  Headlight washer system relay -J39- 3 -  Brake light additional relay -J419- 4 -  Rotating light relay -J326-1) 5 -  X-contact relief relay -J59- 6 -  Fresh air blower isolation relay -J487- 7 -  Auxiliary coolant heater relay -J493- 8 -  Vacant   Note 1) applicable from June 2003

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from February 2004 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Auxiliary heater relay -J8-  -  Residual heat relay -J708- 2 -  Headlight washer system relay -J39- 3 -  Brake light additional relay -J419- 4 -  Dual signal inverter relay -J741- 5 -  X-contact relief relay -J59- 6 -  Fresh air blower isolation relay -J487- 7 -  Auxiliary coolant heater relay -J493- 8 -  Vacant

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), June 2004 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Auxiliary heater relay -J8- (404)  -  Residual heat relay -J708- (404) 2 -  Headlight washer system relay -J39- (53) 3 -  Brake light additional relay -J419- (404/480) 4 -  Dual signal inverter relay -J741- (472) 3)  -  vacant1) 5 -  X-contact relief relay -J59- (100) 6 -  Fresh air blower isolation relay -J487- (53) 2) 7 -  Auxiliary coolant heater relay -J493- (53) 8 -  vacant3)  -  Dual signal inverter relay -J741- (472) 1)   Note t  1) applicable from January 2006 t  2) is dropped from September 2004 t  3) up to December 2005

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from August 2006 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Auxiliary heater relay -J8- (404)  -  Residual heat relay -J708- (404) 2 -  Headlight washer system relay -J39- (53) 3 -  Brake light additional relay -J419- (404/480) 4 -  Vacant 5 -  X-contact relief relay -J59- (100) 6 -  Dual signal inverter relay -J741- (472) 7 -  Auxiliary coolant heater relay -J493- (53) 8 -  Vacant

Получить доступ ко всем электросхемам автомобиля

Relay carrier (1) cockpit (8-pin), from June 2007 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Auxiliary heater relay -J8- (404)  -  Residual heat relay -J708- (404) 2 -  Headlight washer system relay -J39- (53) 3 -  Brake light additional relay -J419- (404/480) 4 -  Vacant 5 -  X-contact relief relay -J59- (100) 6 -  Vacant 7 -  Dual signal inverter relay -J741- (472) 8 -  Auxiliary coolant heater relay -J493- (53)

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from March 2003 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Dual signal inverter relay -J741-1) 4 -  Differential lock control unit -J187- 5 -  Switch-over relay 1 for roof ventilator -J180-  -  Switch-over relay 2 for roof ventilator -J181- 6 -  Multifunction steering wheel control unit -J453- 7 -  Multifunction steering wheel control unit -J453- 8 -  Rear fresh air blower relay -J163-   Note 1) applicable from June 2003

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from February 2004 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Rotating light relay -J326-  -  Alarm system relay 1 -J460-1) 4 -  Differential lock control unit -J187- 5 -  Switch-over relay 1 for roof ventilator -J180-  -  Switch-over relay 2 for roof ventilator -J181-  -  Taxi alarm system 2 control unit -J430-1) 6 -  Multifunction steering wheel control unit -J453-  -  Alarm system control unit -J85-1) 7 -  Multifunction steering wheel control unit -J453-  -  Alarm system control unit -J85-1) 8 -  Rear fresh air blower relay -J163-   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from June 2004 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Vacant 2 -  Vacant 3 -  Rotating light relay -J326- (406)  -  Alarm system relay 1 -J460-3) 4 -  Differential lock control unit -J187- (468) 5 -  Switch-over relay 1 for roof ventilator -J180- (404)  -  Switch-over relay 2 for roof ventilator -J181- (404)  -  Taxi alarm system 2 control unit -J430-3) 6 -  Alarm system control unit -J85-3)  -  Multifunction steering wheel control unit -J453- (451) 7 -  Alarm system control unit -J85-3)  -  Multifunction steering wheel control unit -J453- (451) 8 -  Rear fresh air blower relay -J163-1)  -  Fresh air blower isolation relay -J487- (53) 2)   Note t  1) applicable up to December 2005 t  2) applicable from January 2006 t  3) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from August 2006 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Folding exterior mirror control unit -J351- (361) 2 -  Folding exterior mirror control unit -J351- (361) 3 -  Vacant 4 -  Differential lock control unit -J187- (468) 5 -  Alarm system control unit -J85-1)  -  Multifunction steering wheel control unit -J453- (451) 6 -  Alarm system control unit -J85-1)  -  Multifunction steering wheel control unit -J453- (451) 7 -  Switch-over relay 1 for roof ventilator -J180- (404)  -  Switch-over relay 2 for roof ventilator -J181- (404)  -  Taxi alarm system 2 control unit -J430-1) 8 -  Fresh air blower isolation relay -J487- (53)   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

Relay carrier (2) cockpit (8-pin), from June 2007 t  Under dash panel (centre, under the fuses) Pos. -  Connector/designation 1 -  Vacant 2 -  Folding exterior mirror control unit -J351- (361) 3 -  Folding exterior mirror control unit -J351- (361) 4 -  Differential lock control unit -J187- (468) 5 -  Alarm system control unit -J85- (73) 1)  -  Multifunction steering wheel control unit -J453- (451) 6 -  Alarm system control unit -J85- (73) 1)  -  Multifunction steering wheel control unit -J453- (451) 7 -  Switch-over relay 1 for roof ventilator -J180- (404)  -  Switch-over relay 2 for roof ventilator -J181- (404)  -  Taxi alarm system 2 control unit -J430- (53) 1) 8 -  Fresh air blower isolation relay -J487- (53)   Note 1) for models with taxi equipment only

Получить доступ ко всем электросхемам автомобиля

VW TRANSPORTER 2009 Overview of fuse carrier

Overview of fuse carrier

1 -	Fuses (SB) on fuse holder B, in centre of dash panel

q	Location: → Chapter

q	Position of fuses, from March 2003 → chapter

q	Position of fuses, from June 2004 → chapter

q	Position of fuses, from August 2006 → chapter

q	Position of fuses, from November 2007 → chapter

2 -	Fuses (SC) on fuse holder C, in centre of dash panel

q	Location: → Chapter

q	Position of fuses, from March 2003 → chapter

q	Position of fuses, from June 2004 → chapter

q	Position of fuses, from August 2006 → chapter

q	Position of fuses, from November 2007 → chapter

VW TRANSPORTER 2009 Fuse (SB) on fuse holder B

Fuse (SB) on fuse holder B

Location:

t	In the upper fuse box on centre of dash panel

Fuse colours

40 A - blue

30 A - green

25 A - white

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

–  Back to overview → chapter

Position of fuses, from March 2003

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	30 A	- - -	J18 - X-contact relay J487 - Fresh air blower isolation relay V306-Rear blower Bitron regulation motor3)	30
			25 A	-	J487 - Fresh air blower isolation relay5)	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32)	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62)	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	15 A	-	F - Brake light switch1)	30
			10 A	-	F - Brake light switch2)	30
10	-	SB10 - Fuse 10 on fuse holder B	5 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	- -	E20 - Switches and instruments illumination regulator X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	- -	J419-Brake light additional relay4) J234 - Airbag control unit5)	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - -	E30 - Air conditioning system switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	15
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple6) U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - -	J285 - Control unit in dash panel insert K45 - Front differential lock warning lamp T16 - 16-pin connector, diagnostic connector	15
23	-	SB23 - Fuse 23 on fuse holder B	25 A	-	U10 -Trailer socket4)	30
			25 A	-	B-Starter8)	50
			5 A	-	J207 - Starter inhibitor relay7)	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- -	E30 - Air conditioning system switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch5)	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 46)	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 76)	56a
29	-	SB29 - Fuse 29 on fuse holder B		-	Vacant	-
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - -	G22-Speedometer sender G70 - Air mass meter J60 - Automatic gearbox relay J623 - Engine control unit	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note t  1) applicable up to August 2003 t  2) applicable from September 2003 t  3) applicable from June 2003 t  4) applicable up to January 2004 t  5) applicable from February 2004 t  6) for models with electric interface only (UF1) t  7) applicable from February 2004, manual gearbox with electric interface t  8) applicable from February 2004, for manual gearbox without electric interface only –  Back to overview → chapter

Position of fuses, from June 2004

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
			30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32)	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62)	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)1)	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	153) 154) 75x5)
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12)	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector	15
23	-	SB23 - Fuse 23 on fuse holder B	40 A	-	B-Starter6)	50
			25 A	-	B-Starter7)	50
			30 A	-	B-Starter8)	50
			5 A	-	J207 - Starter inhibitor relay9)	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42)	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72)	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note t  1) for models with roof console only t  2) for models with electric interface only (UF1) t  3) for models with Climatronic only t  4) for models without Climatronic only, applicable up to December 2005 t  5) for models without Climatronic only, applicable from January 2006 t  6) for models with manual gearbox and without electric interface only, applicable up to December 2004 t  7) for models with manual gearbox and without electric interface only, applicable from January 2005 up to December 2005 t  8) for models with manual gearbox and without electric interface only, applicable from January 2006 t  9) for models with manual gearbox and electric interface only –  Back to overview → chapter

Fuse location from August 2006

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
			30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32)	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62)	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)1)	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	30 A	- - - -	E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor	30 or 75x
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	153) 75x4)
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12)	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	10 A	- - - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 25)	15
23	-	SB23 - Fuse 23 on fuse holder B	30 A	-	B-Starter6)	50
			5 A	-	J207 - Starter inhibitor relay7)	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42)	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72)	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note t  1) for models with roof console only t  2) for models with electric interface only (UF1) t  3) for models with Climatronic only t  4) for models without Climatronic only t  5) applicable from June 2007 t  6) for models with manual gearbox and without electric interface only t  7) for models with manual gearbox and electric interface only –  Back to overview → chapter

Position of fuses, from November 2007

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SB1 - Fuse 1 on fuse holder B	25 A	-	J487 - Fresh air blower isolation relay	30
			30 A	-	V306-Rear blower Bitron regulation motor	30
2	-	SB2 - Fuse 2 on fuse holder B	5 A	-	G85 - steering angle sender	30
3	-	SB3 - Fuse 3 on fuse holder B	10 A	-	J519 - Onboard power supply control unit	30
4	-	SB4 - Fuse 4 on fuse holder B	10 A	- - -	E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor	56b
5	-	SB5 - Fuse 5 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32)	56b
6	-	SB6 - Fuse 6 on fuse holder B	15 A	- - -	L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62)	56a
7	-	SB7 - Fuse 7 on fuse holder B	15 A	-	J519 - Onboard power supply control unit (interior light)1)	30
8	-	SB8 - Fuse 8 on fuse holder B	5 A	-	T16 - 16-pin connector, diagnostic connector	30
9	-	SB9 - Fuse 9 on fuse holder B	10 A	-	F - Brake light switch	30
10	-	SB10 - Fuse 10 on fuse holder B	10 A	- -	E22 - Intermittent wiper switch E34 - Rear wiper switch	15
11	-	SB11 - Fuse 11 on fuse holder B	5 A	-	X - number plate light	58
12	-	SB12 - Fuse 12 on fuse holder B	15 A	-	U1 - Cigarette lighter	30
13	-	SB13 - Fuse 13 on fuse holder B	5 A	-	J234 - Airbag control unit	15
14	-	SB14 - Fuse 14 on fuse holder B	-	-	Vacant	-
			30 A	-	E4 - Headlight dipper/flasher switch5)	30
15	-	SB15 - Fuse 15 on fuse holder B	7,5 A	- - - - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve	153) 75x4)
16	-	SB16 - Fuse 16 on fuse holder B	5 A	-	J519 - Onboard power supply control unit	15
17	-	SB17 - Fuse 17 on fuse holder B	5 A	- - - -	F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket	RFL
18	-	SB18 - Fuse 18 on fuse holder B	5 A	-	J285 - Control unit in dash panel insert	30
19	-	SB19 - Fuse 19 on fuse holder B	5 A	- - - - - - -	E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12)	86s
20	-	SB20 - Fuse 20 on fuse holder B	5 A	- - - - -	M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket	LPL
21	-	SB21 - Fuse 21 on fuse holder B	5 A	- - - -	M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket	RPL
22	-	SB22 - Fuse 22 on fuse holder B	7,5 A	- - - -	J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 2	15
23	-	SB23 - Fuse 23 on fuse holder B	30 A	-	B-Starter6)	50
			5 A	- -	J207 - Starter inhibitor relay7) T10bj-10-pin connector, yellow7)	50
24	-	SB24 - Fuse 24 on fuse holder B	5 A	-	G85 - steering angle sender	15
25	-	SB25 - Fuse 25 on fuse holder B	5 A	- - -	E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit	30
26	-	SB26 - Fuse 26 on fuse holder B	30 A	-	E1 - Lighting switch	75x
27	-	SB27 - Fuse 27 on fuse holder B	15 A	- - -	L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42)	56b
28	-	SB28 - Fuse 28 on fuse holder B	15 A	- - - -	K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72)	56a
29	-	SB29 - Fuse 29 on fuse holder B	10 A	-	J741-Dual signal inverter relay	30
30	-	SB30 - Fuse 30 on fuse holder B	10 A	- - - - -	V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element	75x
31	-	SB31 - Fuse 31 on fuse holder B	30 A	-	J519-Onboard power supply control unit (signal horn)	30
32	-	SB32 - Fuse 32 on fuse holder B	25 A	-	J519-Onboard power supply control unit (windscreen wiper motor)	30
33	-	SB33 - Fuse 33 on fuse holder B	15 A	- - -	J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio	30
34	-	SB34 - Fuse 34 on fuse holder B	25 A	- - - - - - - - - - -	J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness	15
35	-	SB35 - Fuse 35 on fuse holder B	5 A	-	Instruments illumination	58d
36	-	SB36 - Fuse 36 on fuse holder B	25 A	-	J519-Onboard power supply control unit (turn signal)	30

Note t  1) for models with roof console only t  2) for models with electric interface only (UF1) t  3) for models with Climatronic only t  4) for models without Climatronic only t  5) applicable from June 2008 t  6) for models with manual gearbox and without electric interface only t  7) for models with manual gearbox and electric interface only –  Back to overview → chapter

Fuses (SC) on fuse holder C

Location:

t	In the lower fuse box on centre of dash panel

Fuse colours

30 A - blue

30 A - green

25 A - white

20 A - yellow

15 A - blue

10 A - red

7.5 A - brown

5 A - beige

–  Back to overview → chapter

Position of fuses, from March 2003

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	15 A	-	U18 - 12 V socket -2-	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G303 - Interior monitor send and receive module 1 G305 - Interior monitor send and receive module 2	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
5	-	SC5-Fuse 5 on fuse holder C	15 A	-	J698-Refrigerator box	30
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	J180 - Switch-over relay 1 for roof ventilator	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	20 A	- - - -	J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J493-Auxiliary coolant heater relay1)	75x
			5 A	-	J419-Brake light additional relay2)	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	-	J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	5 A 7,5 A	- -	E265 - Rear Climatronic operating and display unit1) J519 - Onboard power supply control unit (interior light)2)	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	- -	E179 - Rear fresh air blower switch E265 - Rear Climatronic operating and display unit2)	15 30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	G303 - Interior monitor send and receive module 1	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	5 A3) 10 A4)	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment1)	15
25	-	SC25 - Fuse 25 on fuse holder C	15 A	- - - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator G59 - Driver seat temperature sensor G60 - Front passenger seat temperature sensor	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86), 7)	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	-	E43 - Mirror adjustment switch	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
			5 A	-	J493-Auxiliary coolant heater relay1)	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph	15
34	-	SC34 - Fuse 34 on fuse holder C	20 A	-	V192 - Vacuum pump for brakes1)	75x
			25 A	-	U10 -Trailer socket2)	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard power supply control unit	30
36	-	SC36 - Fuse 36 on fuse holder C	15 A	-	U20 - 12 V socket -4-5)	30
			5 A	- -	E153 - Operating and display unit for camping equipment6) Special vehicles6), 7)	15

Note t  1) applicable up to January 2004 t  2) applicable from February 2004 t  3) applicable up to May 2003 t  4) applicable from June 2003 t  5) applicable up to May 2004 t  6) applicable from March 2004 t  7) for models with electric interface only (UF1) –  Back to overview → chapter

Position of fuses, from June 2004

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	10 A	-	J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness1)	30
			15 A	-	U20 - 12 V socket -4-2)	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
			20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
			10 A	-	J419-Brake light additional relay3), 7)	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	- -	J503 - Control unit with display for radio and navigation system J412 - Mobile telephone operating electronics control unit	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
			5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	15 A	- - - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J131 - Heated driver seat control unit J132 - Heated front passenger seat control unit	75x
			25 A	-	J774 -Heated front seats control unit7)	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph4)	30
			15 A	-	U18 - 12 V socket -2-5)	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86)	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	-	E43 - Mirror adjustment switch	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
			5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment Special vehicles6)	15

Note t  1) applicable up to December 2004 t  2) applicable from January 2005 t  3) for models with TSP only t  4) for models with tachograph only t  5) Multivan without tachograph and second battery only t  6) for models with electric interface only (UF1) t  7) applicable from January 2006 –  Back to overview → chapter

Fuse location from August 2006

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower V321 - Left auxiliary blower	75x
4	-	SC4 - Fuse 4 on fuse holder C	10 A	-	J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator)	30
			15 A	-	U20 - 12 V socket -4-	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
			20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
			10 A	-	J419-Brake light additional relay1)	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	- -	J412 - Mobile telephone operating electronics control unit J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
			5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	25 A	- - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph2)	30
			15 A	-	U18 - 12 V socket -2-3)	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 84)	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	- -	E43 - Mirror adjustment switch J386 - Driver door control unit	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
			5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
			5 A	-	A11 - Onboard supply charger unit5)	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph2)	15
			15 A	- -	G24 - Tachograph6) J351 - Folding exterior mirror control unit6)	15
			15 A	-	J351 - Folding exterior mirror control unit7)	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment Special vehicles4)	15

Note t  1) for models with TSP only t  2) for models with tachograph only t  3) Multivan without tachograph and second battery only t  4) for models with electric interface only (UF1) t  5) for camper only, applicable from November 2006 t  6) for models with tachograph and electric folding exterior mirror only t  7) for models with electric folding exterior mirror only –  Back to overview → chapter

Position of fuses, from November 2007

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	SC1 - Fuse 1 on fuse holder C	25 A	-	U10 -Trailer socket	30
2	-	SC2 - Fuse 2 on fuse holder C	5 A	- -	G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit	30
3	-	SC3 - Fuse 3 on fuse holder C	5 A	- -	V320 - Right auxiliary blower1) V321 - Left auxiliary blower1)	75x
			-	-	Vacant2), 10)	-
			30 A	-	J519 - Onboard power supply control unit (heated rear window)11)	30
4	-	SC4 - Fuse 4 on fuse holder C	10 A	- - -	E121 - Rear differential lock switch J187-Differential lock control unit J492 - Four-wheel drive control unit	15
5	-	SC5-Fuse 5 on fuse holder C	10 A	-	T6bn-6-pin connector, grey	75x
6	-	SC6 - Fuse 6 on fuse holder C	5 A	-	G226 - Oil level and oil temperature sender	15
7	-	SC7 - Fuse 7 on fuse holder C	10 A	-	B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator)	30
			15 A	-	U20 - 12 V socket -4-	30
8	-	SC8 - Fuse 8 on fuse holder C	5 A	-	J446 - Parking aid control unit	15
9	-	SC9 - Fuse 9 on fuse holder C	5 A	-	J453-Multifunction steering wheel control unit	30
10	-	SC10 - Fuse 10 on fuse holder C	30 A	-	R12 - Amplifier	30
11	-	SC11 - Fuse 11 on fuse holder C	15 A	-	J605 - Rear lid control unit	30
			20 A	- - - - -	H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit	30
12	-	SC12 - Fuse 12 on fuse holder C	5 A	-	J419-Brake light additional relay	15
			10 A	-	J419-Brake light additional relay3)	15
13	-	SC13 - Fuse 13 on fuse holder C	5 A	- - -	E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring	15
14	-	SC14 - Fuse 14 on fuse holder C	5 A	-	J412 - Mobile telephone operating electronics control unit	30
15	-	SC15 - Fuse 15 on fuse holder C	5 A	-	J98-Gearshift indicator control unit	15
16	-	SC16 - Fuse 16 on fuse holder C	5 A	-	J503 - Control unit with display for radio and navigation system	15
17	-	SC17 - Fuse 17 on fuse holder C	7,5 A	- -	J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness	30
18	-	SC18 - Fuse 18 on fuse holder C	5 A	-	E179 - Rear fresh air blower switch	15
			5 A	-	E265 - Rear Climatronic operating and display unit	30
19	-	SC19 - Fuse 19 on fuse holder C	5 A	-	Y7 - Automatic anti-dazzle interior mirror	15
20	-	SC20 - Fuse 20 on fuse holder C	10 A	-	J519-Onboard power supply control unit (heated exterior mirror)	30
21	-	SC21 - Fuse 21 on fuse holder C	5 A	-	J529-Anti-theft and tilt system control unit	15
22	-	SC22 - Fuse 22 on fuse holder C	5 A	- -	G65 - High-pressure sender G238 - Air quality sensor	15
23	-	SC23 - Fuse 23 on fuse holder C	10 A	- - - -	E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater	30
24	-	SC24 - Fuse 24 on fuse holder C	7,5 A	-	B250-Positive connection in roof wiring harness (interior lighting)	30g
25	-	SC25 - Fuse 25 on fuse holder C	25 A	- - -	E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit	75x
26	-	SC26 - Fuse 26 on fuse holder C	10 A	-	G24 - Tachograph7)	30
			15 A	-	U18 - 12 V socket -2-5)	30
27	-	SC27 - Fuse 27 on fuse holder C	15 A	- - -	L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86)	FL
28	-	SC28 - Fuse 28 on fuse holder C	5 A	- -	E43 - Mirror adjustment switch J386 - Driver door control unit	15
29	-	SC29 - Fuse 29 on fuse holder C	25 A	-	J364 - Auxiliary heater control unit	30
30	-	SC30 - Fuse 30 on fuse holder C	5 A	-	E153 - Operating and display unit for camping equipment	15
			5 A	-	J493-Auxiliary coolant heater relay	75x
31	-	SC31 - Fuse 31 on fuse holder C	25 A	-	J245 - Sliding sunroof adjustment control unit	30
			5 A	-	A11 - Onboard supply charger unit4)	30
32	-	SC32 - Fuse 32 on fuse holder C	20 A	-	J39 - Headlight washer system relay	30
33	-	SC33-Fuse 33 on fuse holder C	5 A	-	G24 - Tachograph7)	15
			15 A	- -	G24 - Tachograph8) J351 - Folding exterior mirror control unit8)	15
			15 A	-	J351 - Folding exterior mirror control unit9)	15
34	-	SC34 - Fuse 34 on fuse holder C	15 A	-	U19 - 12 V socket 3	30
35	-	SC35 - Fuse 35 on fuse holder C	10 A	-	J519 - Onboard supply control unit (reversing light models with automatic gearbox)	30
36	-	SC36 - Fuse 36 on fuse holder C	5 A	- -	E153 - Operating and display unit for camping equipment T10bh-10-pin connector, purple6)	15

Note t  1) applicable up to May 2008 t  2) applicable from June 2008 t  3) for models with TSP only t  4) for camper only t  5) Multivan without tachograph and second battery only t  6) for models with electric interface only (UF1) t  7) for models with tachograph only t  8) for models with tachograph and electric folding exterior mirror only t  9) for models with electric folding exterior mirror only t  10) applicable up to October 2008 t  11) applicable from November 2008 –  Back to overview → chapter

VW TRANSPORTER 2009

VW TRANSPORTER 2009 Overview of earth points in engine compartment

Overview of earth points in engine compartment

   

1 -	Earth point, on left in engine compartment -12-

q	Location → page 801/2

2 -	Earth point, on right in engine compartment -13-

q	Location → page 801/2

3 -	Earth point, on gearbox -14-

q	Location → page 801/3

4 -	Earth point, on engine block -18-

q	Location → page 801/5

5 -	Earth point, near radiator fan control unit -29-

q	Location → page 801/3

6 -	Earth point, on left in plenum chamber -607-

q	Location → page 801/4

7 -	Earth point, starter battery -624-

q	Location → page 801/4

8 -	Earth point 2, on left in engine compartment -640-

q	Location → page 801/3

♦ Earth points for camper ⇒ Fitting Locations for camper

Transporter	Fitting Locations	No.  801 / 2

12 Earth point, on left in engine compartment ⇒ -arrow A- TV7 -  Terminal 31 wiring junction Earth point 1 ⇒ -arrow a- Earth point 2 ⇒ -arrow b- Earth point 3 ⇒ -arrow c-   Note: ♦ near headlight

Получить доступ ко всем электросхемам автомобиля

13 Earth point, in engine compartment, right ⇒ -arrow-   Note: ♦ near horn or dual tone horn

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 3

14 Earth point, on gearbox ⇒ -arrow-   Note: ♦ near starter

Получить доступ ко всем электросхемам автомобиля

29 Earth point, near radiator fan control unit ⇒ -arrow A-   640 Earth point 2, on left in engine compartment ⇒ -arrow B-   Note: ♦ on longitudinal member

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 4

607 Earth point, on left in plenum chamber ⇒ -arrow-   Note: ♦ near windscreen wiper motor

Получить доступ ко всем электросхемам автомобиля

624 Earth point, starter battery ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 5

18 Earth point on engine block ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 6

Overview of earth points in passenger compartment

1 -	Earth point, under driver seat -34-

q	Location → page 801/8

2 -	Earth point, under front passenger seat -35-

q	Location → page 801/8

3 -	Earth point, near bulkhead -49-

q	Location → page 801/9

4 -	Earth point, on top end of steering column -605-

q	Location → page 801/10

5 -	Earth point (audio), under centre console, front -610-

q	Location → page 801/9

6 -	Earth point, onboard supply control unit -636-

q	Location → page 801/9

7 -	Earth point, airbag control unit -637-

q	Location → page 801/9

Transporter	Fitting Locations	No.  801 / 7

8 -	Earth point, right A-pillar -638-

q	Location → page 801/10

9 -	Earth point, left A-pillar -639-

q	Location → page 801/11

10 -	Earth point 2, left A-pillar -670-

q	Location → page 801/11

Transporter	Fitting Locations	No.  801 / 8

34 Earth point under driver seat ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

35 Earth point under front passenger seat ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 9

49 Earth point, near bulkhead ⇒ -arrow D-   610 Earth point (audio), under centre console, front ⇒ -arrow B-   636 Earth point, onboard supply control unit ⇒ -arrow C-   637 Earth point, airbag control unit ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 10

605 Earth point, on top end of steering column ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

638 Earth point, right A-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 11

639 Earth point, left A-pillar ⇒ -arrow A-   670 Earth point 2, left A-pillar ⇒ -arrow B-

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 12

Earth point, in luggage compartment

1 -	Earth point, left D-pillar -653-

q	Location ⇒ from page → 801/13

2 -	Earth point, right D-pillar -654-

q	Location ⇒ from page → 801/14

3 -	Earth point 2, left D-pillar -668-

q	Location ⇒ from page → 801/13

4 -	Earth point 2, right D-pillar -669-

q	Location ⇒ from page → 801/14

♦ Earth points for camper ⇒ Fitting Locations for camper

Transporter	Fitting Locations	No.  801 / 13

653 Earth point, left D-pillar ⇒ -arrow A-   668 Earth point 2, left D-pillar ⇒ -arrow B-   Note: ♦ for models with short wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 14

653 Earth point, left D-pillar ⇒ -arrow B-   668 Earth point 2, left D-pillar ⇒ -arrow A-   Note: ♦ for models with long wheel base only

Получить доступ ко всем электросхемам автомобиля

654 Earth point, right D-pillar ⇒ -arrow A-   669 Earth point 2, right D-pillar ⇒ -arrow B-   Note: ♦ for models with long wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 15

654 Earth point, right D-pillar ⇒ -arrow A-   669 Earth point 2, right D-pillar ⇒ -arrow B-   Note: ♦ for models with short wheel base only

Получить доступ ко всем электросхемам автомобиля

Transporter	Fitting Locations	No.  801 / 16

Earth points platform/double cab

1 -	Earth point, on left of rear cross member -68-

q	Location → page 801/17

Transporter	Fitting Locations	No.  801 / 17

68 Earth point, on left of rear cross member ⇒ -arrow A-

Получить доступ ко всем электросхемам автомобиля