Čeština
Dansk
Deutsch
Ελληνικά
English
English
Español
Suomi
Français
Français
עברית
Hrvatski
Magyar
Italiano
日本語
한국어
Polski
Português
Português
Română
Русский
Slovenčina
Slovenščina
Svenska
Türkçe
中文 (中国)
Wiring Diagram VW TRANSPORTER 2005 - Onboard supply control unit - multifunction steering wheel control unit
| J285 | Control unit in dash panel insert |
| J453 | Multifunction steering wheel control unit |
| J519 | Onboard supply control unit |
| SA2 | Fuse 2 on fuse holder A |
| SC9 | Fuse 9 on fuse holder C |
| T6c | 6-pin connector, black |
| T16 | 16-pin connector, diagnostic connector |
| T18 | 18-pin connector, black |
| T18b | 18-pin connector, black |
| T32a | 32-pin connector, green |
| 366 | Earth connection 1, in main wiring harness |
| 370 | Earth connection 5, in main wiring harness |
| 371 | Earth connection 6, in main wiring harness |
| B298 | Positive connection 2 (30), in main wiring harness |
| B301 | Positive connection 5 (30), in main wiring harness |
| B305 | Positive connection 9 (30), in main wiring harness |
| B397 | Connection 1 (convenience CAN bus, high), in main wiring harness |
| B406 | Connection 1 (convenience CAN bus, low), in main wiring harness |
| B444 | Connection 1 (diagnosis), in main wiring harness |
| * | applicable up to May 2003 |
| ** | applicable from June 2003 |
Wiring Diagram VW TRANSPORTER 2005 - Onboard supply control unit - multifunction steering wheel control unit - operating unit in steering wheel
| E45 | Cruise control system switch |
| E221 | Operating unit in steering wheel |
| E440 | Multifunction buttons on left in steering wheel |
| E441 | Multifunction buttons on right in steering wheel |
| F138 | Airbag coil connector and return spring with slip ring |
| H | Horn plate |
| J234 | Airbag control unit |
| J453 | Multifunction steering wheel control unit |
| J519 | Onboard supply control unit |
| J623 | Engine control unit |
| N95 | Driver side airbag igniter |
| SC13 | Fuse 13 on fuse holder C |
| T6c | 6-pin connector, black |
| T8z | 8-connector, yellow, in steering wheel |
| T10 | 10-pin connector, black, coupling station on electronics box, in engine compartment |
| T18b | 18-pin connector, black |
| T41 | 41-pin connector |
| T75 | 75-pin connector |
| 371 | Earth connection 6, in main wiring harness |
| B279 | Positive connection 3 (15a), in main wiring harness |
| B441 | Connection (CCS), in main wiring harness |
| * | for models with operating unit in steering wheel for radio and CCS only |
| ** | for models with operating unit in steering wheel for radio CCS and telephone only |
VW TRANSPORTER 2005
VW TRANSPORTER 2005 Engine compartment
Engine compartment
| 1 - | Electronics box, in engine compartment |
| 2 - | Fuse holder D -SD- , in engine compartment |
| 3 - | Fuse holder A -SA- , in electronics box |
| 4 - | Upper housing half for fuse holder, in engine compartment |
| 5 - | Pin connectors on engine control unit, in electronics box |
| Connector assigment: |
| C - | 60-pin connector -T60- , on wiring harnessConnector assigment: |
| C - | 40-pin connector -T40- or 121-pin connector -T121- , on wiring harness |
Note
| Designation as Motronic control unit -J220- possible |
VW TRANSPORTER 2005 ABS control unit J104
| ABS control unit -J104- |
| Connector assigment: |
VW TRANSPORTER 2005 Automatic gearbox control unit J217
| Automatic gearbox control unit -J217- |
| Connector assigment: |
VW TRANSPORTER 2005 Radiator fan control unit J293
|
|
Note
|
|
Note
|
VW TRANSPORTER 2005 Control unit in dash panel insert J285
Note
|
|
Note
VW TRANSPORTER 2005 Driver door control unit J386
|
VW TRANSPORTER 2005 Airbag control unit J234
|
|
| Connector assigment: |
| A - | Airbag control unit -J234- |
| Pin connector: |
| B - | 75-pin connector -T75- , on wiring harness |
|
VW TRANSPORTER 2005 Interior monitor send and receive module 2 G305
|
|
Note
VW TRANSPORTER 2005 Sliding sunroof adjustment control unit J245
|
|
VW TRANSPORTER 2005 Mobile telephone operating electronics control unit J412
|
Note
|
| Connector assigment: |
| A - | Mobile telephone operating electronics control unit -J412- |
| Pin connector: |
| B - | 54-pin connector -T54- |
VW TRANSPORTER 2005 Traffic information control unit J559 Note
VW TRANSPORTER 2005 Traffic information control unit J559
|
| Note
VW TRANSPORTER 2005 Front passenger door control unit J387
|
VW TRANSPORTER 2005 Gearshift indicator control unit J98
|
|
|
Note
VW TRANSPORTER 2005
|
|
|
Note
VW TRANSPORTER 2005
|
|
|
| Connector assigment: |
| A - | Convenience system central control unit -J393- |
| Pin connector: |
| B - | 12-pin connector -T12b- , on wiring harness |
| D - | 12-pin connector -T12c- , on wiring harnessVW TRANSPORTER 2005 | CD changer -R41- ,amplifier -R12- and voice amplification control unit -J656- |
| A - | CD changer -R41- , under the seat on front right |
| B - | Amplifier -R12- , under the seat on front right |
| C - | Voice amplification control unit -J656- , under the seat on front right |
VW TRANSPORTER 2005 Four-wheel drive control unit J492
|
VW TRANSPORTER 2005
VW TRANSPORTER 2005 Overview:
| Overview: |
| 1 - | Relay carrier electronics box |
| 2 - | Relay carrier 1, cockpit |
| 3 - | Relay carrier 2, cockpit |
| 4 - | Relay carrier on left of seat box |
Note
| The chamber marked as “vacant” can be fitted with a relay or a pin connector. See Fitting Locations "interior single fuses" and "coupling station"! |
| No. | Function/component | Location | Figure on page | |||
| 1 | - | Battery isolation relay -J7- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 2 | - | Auxiliary heater relay -J8- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 3 | - | Fuel pump relay -J17- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 4 | - | Headlight washer system relay -J39- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 5 | - | Electric fuel pump 2 relay -J49- | - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 |
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 6 | - | Glow plug relay -J52- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 7 | - | X-contact relief relay -J59- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 8 | - | Automatic gearbox relay -J60- | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | - | from March 2003 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 9 | - | Alarm system control unit -J85- from June 2004 from August 2006 from June 2007 | ||||
| 10 | - | Magnetic clutch control unit -J153- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 11 | - | Rear fresh air blower relay -J163- from February 2004 from June 2004 | ||||
| 12 | - | Automatic glow period control unit -J179- | - | Relay carrier electronics box (1.9 l - diesel engine) | ---- | from June 2004 from August 2006 from June 2007 from November 2007 |
| - | Relay carrier electronics box (2,5 l - diesel engine) | ---- | from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 13 | - | Switch-over relay 1 for roof ventilator -J180- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 14 | - | Switch-over relay 2 for roof ventilator -J181- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 15 | - | Differential lock control unit -J187- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 16 | - | Starter inhibitor relay -J207- | - | Relay carrier electronics box (1.9 l - diesel engine) | ---- | from June 2004 from August 2006 from June 2007 from November 2007 |
| - | Relay carrier electronics box (2.0 l - petrol engine) | ---- | from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 17 | - | Cut-out relay for air conditioning system magnetic coupling -J246- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 18 | - | Secondary air pump relay -J299- | - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 |
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 19 | - | Terminal 30 voltage supply relay -J317- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 20 | - | Rotating light relay -J326- | ||||
| - | Relay carrier (2), cockpit | -- | from February 2004 from June 2004 | |||
| - | Relay carrier on left of seat box | -- | from August 2006 from June 2007 | |||
| 21 | - | Folding exterior mirror control unit -J351- | - | Relay carrier (2), cockpit | -- | from August 2006 from June 2007 |
| 22 | - | Brake light additional relay -J419- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 23 | - | Taxi alarm system 2 control unit -J430- | - | Relay carrier (2), cockpit | ---- | from February 2004 from June 2004 from August 2006 from June 2007 |
| 24 | - | Multifunction steering wheel control unit -J453- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 25 | - | Alarm system relay 1 -J460- | - | Relay carrier (2), cockpit | -- | from February 2004 from June 2004 |
| - | Relay carrier on left of seat box | -- | from August 2006 from June 2007 | |||
| 26 | - | Fresh air blower isolation relay -J487- from February 2004 from June 2004 | ||||
| - | Relay carrier (2), cockpit | --- | from January 2006 from August 2006 from June 2007 | |||
| 27 | - | Auxiliary coolant heater relay -J493- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 28 | - | Additional coolant pump relay -J496- from June 2004 from August 2006 from June 2007 from November 2007 | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | ----- | from March 2003 from June 2004 from August 2006 from June 2007 from November 2007 | |||
| 29 | - | Power steering control unit -J500- | ||||
| - | Relay carrier electronics box (2.0 l - petrol engine) | - | from March 2003 | |||
| - | Relay carrier electronics box (2,5 l - diesel engine) | - | from March 2003 | |||
| - | Relay carrier electronics box (3,2 l - petrol engine) | - | from March 2003 | |||
| 30 | - | Taxi alarm remote control, control unit -J601- | - | Relay carrier on left of seat box | ---- | from February 2004 from June 2004 from August 2006 from June 2007 |
| 31 | - | Residual heat relay -J708- from February 2004 from June 2004 from August 2006 from June 2007 | ||||
| 32 | - | Dual signal inverter relay -J741- | ||||
| - | Relay carrier (2), cockpit | - | from June 2003 | |||
| - | Relay carrier (1), cockpit | ---- | from February 2004 from June 2004 from August 2006 from June 2007 |
|
Note
|
Note
|
Note
|
Note
|
|
|
|
|
|
|
Note
|
Note
|
Note
|
Note
|
|
Note
|
|
|
|
Note
|
Note
|
Note
|
Note
|
Note
|
Note
|
|
Note
|
|
|
Note
|
Note
|
Note
|
Note
|
Note
|
VW TRANSPORTER 2005 Overview of fuse carrier
Overview of fuse carrier
| 1 - | Fuses (SB) on fuse holder B, in centre of dash panel |
| q | Position of fuses, from March 2003 |
| q | Position of fuses, from June 2004 |
| q | Position of fuses, from August 2006 |
| q | Position of fuses, from November 2007 |
| 2 - | Fuses (SC) on fuse holder C, in centre of dash panel |
| q | Position of fuses, from March 2003 |
| q | Position of fuses, from June 2004 |
| q | Position of fuses, from August 2006 |
| q | Position of fuses, from November 2007 |
VW TRANSPORTER 2005 Fuse (SB) on fuse holder B
| Fuse (SB) on fuse holder B |
| Location: |
| t | In the upper fuse box on centre of dash panel |
| Fuse colours |
| 40 A - blue |
| 30 A - green |
| 25 A - white |
| 20 A - yellow |
| 15 A - blue |
| 10 A - red |
| 7.5 A - brown |
| 5 A - beige |
|
| Position of fuses, from March 2003 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SB1 - Fuse 1 on fuse holder B | 30 A | - - - | J18 - X-contact relay J487 - Fresh air blower isolation relay V306-Rear blower Bitron regulation motor3) | 30 |
| 25 A | - | J487 - Fresh air blower isolation relay5) | 30 | |||
| 2 | - | SB2 - Fuse 2 on fuse holder B | 5 A | - | G85 - steering angle sender | 30 |
| 3 | - | SB3 - Fuse 3 on fuse holder B | 10 A | - | J519 - Onboard power supply control unit | 30 |
| 4 | - | SB4 - Fuse 4 on fuse holder B | 10 A | - - - | E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor | 56b |
| 5 | - | SB5 - Fuse 5 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32) | 56b |
| 6 | - | SB6 - Fuse 6 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62) | 56a |
| 7 | - | SB7 - Fuse 7 on fuse holder B | 15 A | - | J519 - Onboard power supply control unit (interior light) | 30 |
| 8 | - | SB8 - Fuse 8 on fuse holder B | 5 A | - | T16 - 16-pin connector, diagnostic connector | 30 |
| 9 | - | SB9 - Fuse 9 on fuse holder B | 15 A | - | F - Brake light switch1) | 30 |
| 10 A | - | F - Brake light switch2) | 30 | |||
| 10 | - | SB10 - Fuse 10 on fuse holder B | 5 A | - - | E22 - Intermittent wiper switch E34 - Rear wiper switch | 15 |
| 11 | - | SB11 - Fuse 11 on fuse holder B | 5 A | - - | E20 - Switches and instruments illumination regulator X - number plate light | 58 |
| 12 | - | SB12 - Fuse 12 on fuse holder B | 15 A | - | U1 - Cigarette lighter | 30 |
| 13 | - | SB13 - Fuse 13 on fuse holder B | 5 A | - - | J419-Brake light additional relay4) J234 - Airbag control unit5) | 15 |
| 14 | - | SB14 - Fuse 14 on fuse holder B | 30 A | - - - - | E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor | 30 or 75x |
| 15 | - | SB15 - Fuse 15 on fuse holder B | 7,5 A | - - - | E30 - Air conditioning system switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve | 15 |
| 16 | - | SB16 - Fuse 16 on fuse holder B | 5 A | - | J519 - Onboard power supply control unit | 15 |
| 17 | - | SB17 - Fuse 17 on fuse holder B | 5 A | - - - - | F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket | RFL |
| 18 | - | SB18 - Fuse 18 on fuse holder B | 5 A | - | J285 - Control unit in dash panel insert | 30 |
| 19 | - | SB19 - Fuse 19 on fuse holder B | 5 A | - - - - - - | E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio | 86s |
| 20 | - | SB20 - Fuse 20 on fuse holder B | 5 A | - - - - - | M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple6) U10 -Trailer socket | LPL |
| 21 | - | SB21 - Fuse 21 on fuse holder B | 5 A | - - - - | M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket | RPL |
| 22 | - | SB22 - Fuse 22 on fuse holder B | 10 A | - - - | J285 - Control unit in dash panel insert K45 - Front differential lock warning lamp T16 - 16-pin connector, diagnostic connector | 15 |
| 23 | - | SB23 - Fuse 23 on fuse holder B | 25 A | - | U10 -Trailer socket4) | 30 |
| 25 A | - | B-Starter8) | 50 | |||
| 5 A | - | J207 - Starter inhibitor relay7) | 50 | |||
| 24 | - | SB24 - Fuse 24 on fuse holder B | 5 A | - | G85 - steering angle sender | 15 |
| 25 | - | SB25 - Fuse 25 on fuse holder B | 5 A | - - | E30 - Air conditioning system switch J255 - Climatronic control unit | 30 |
| 26 | - | SB26 - Fuse 26 on fuse holder B | 30 A | - | E1 - Lighting switch5) | 75x |
| 27 | - | SB27 - Fuse 27 on fuse holder B | 15 A | - - - | L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 46) | 56b |
| 28 | - | SB28 - Fuse 28 on fuse holder B | 15 A | - - - - | K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 76) | 56a |
| 29 | - | SB29 - Fuse 29 on fuse holder B | - | Vacant | - | |
| 30 | - | SB30 - Fuse 30 on fuse holder B | 10 A | - - - - - | V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element | 75x |
| 31 | - | SB31 - Fuse 31 on fuse holder B | 30 A | - | J519-Onboard power supply control unit (signal horn) | 30 |
| 32 | - | SB32 - Fuse 32 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (windscreen wiper motor) | 30 |
| 33 | - | SB33 - Fuse 33 on fuse holder B | 15 A | - - - | J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio | 30 |
| 34 | - | SB34 - Fuse 34 on fuse holder B | 25 A | - - - - | G22-Speedometer sender G70 - Air mass meter J60 - Automatic gearbox relay J623 - Engine control unit | 15 |
| 35 | - | SB35 - Fuse 35 on fuse holder B | 5 A | - | Instruments illumination | 58d |
| 36 | - | SB36 - Fuse 36 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (turn signal) | 30 |
| Note
|
| Position of fuses, from June 2004 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SB1 - Fuse 1 on fuse holder B | 25 A | - | J487 - Fresh air blower isolation relay | 30 |
| 30 A | - | V306-Rear blower Bitron regulation motor | 30 | |||
| 2 | - | SB2 - Fuse 2 on fuse holder B | 5 A | - | G85 - steering angle sender | 30 |
| 3 | - | SB3 - Fuse 3 on fuse holder B | 10 A | - | J519 - Onboard power supply control unit | 30 |
| 4 | - | SB4 - Fuse 4 on fuse holder B | 10 A | - - - | E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor | 56b |
| 5 | - | SB5 - Fuse 5 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32) | 56b |
| 6 | - | SB6 - Fuse 6 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62) | 56a |
| 7 | - | SB7 - Fuse 7 on fuse holder B | 15 A | - | J519 - Onboard power supply control unit (interior light)1) | 30 |
| 8 | - | SB8 - Fuse 8 on fuse holder B | 5 A | - | T16 - 16-pin connector, diagnostic connector | 30 |
| 9 | - | SB9 - Fuse 9 on fuse holder B | 10 A | - | F - Brake light switch | 30 |
| 10 | - | SB10 - Fuse 10 on fuse holder B | 10 A | - - | E22 - Intermittent wiper switch E34 - Rear wiper switch | 15 |
| 11 | - | SB11 - Fuse 11 on fuse holder B | 5 A | - | X - number plate light | 58 |
| 12 | - | SB12 - Fuse 12 on fuse holder B | 15 A | - | U1 - Cigarette lighter | 30 |
| 13 | - | SB13 - Fuse 13 on fuse holder B | 5 A | - | J234 - Airbag control unit | 15 |
| 14 | - | SB14 - Fuse 14 on fuse holder B | 30 A | - - - - | E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor | 30 or 75x |
| 15 | - | SB15 - Fuse 15 on fuse holder B | 7,5 A | - - - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve | 153) 154) 75x5) |
| 16 | - | SB16 - Fuse 16 on fuse holder B | 5 A | - | J519 - Onboard power supply control unit | 15 |
| 17 | - | SB17 - Fuse 17 on fuse holder B | 5 A | - - - - | F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket | RFL |
| 18 | - | SB18 - Fuse 18 on fuse holder B | 5 A | - | J285 - Control unit in dash panel insert | 30 |
| 19 | - | SB19 - Fuse 19 on fuse holder B | 5 A | - - - - - - - | E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12) | 86s |
| 20 | - | SB20 - Fuse 20 on fuse holder B | 5 A | - - - - - | M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket | LPL |
| 21 | - | SB21 - Fuse 21 on fuse holder B | 5 A | - - - - | M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket | RPL |
| 22 | - | SB22 - Fuse 22 on fuse holder B | 10 A | - - - | J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector | 15 |
| 23 | - | SB23 - Fuse 23 on fuse holder B | 40 A | - | B-Starter6) | 50 |
| 25 A | - | B-Starter7) | 50 | |||
| 30 A | - | B-Starter8) | 50 | |||
| 5 A | - | J207 - Starter inhibitor relay9) | 50 | |||
| 24 | - | SB24 - Fuse 24 on fuse holder B | 5 A | - | G85 - steering angle sender | 15 |
| 25 | - | SB25 - Fuse 25 on fuse holder B | 5 A | - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit | 30 |
| 26 | - | SB26 - Fuse 26 on fuse holder B | 30 A | - | E1 - Lighting switch | 75x |
| 27 | - | SB27 - Fuse 27 on fuse holder B | 15 A | - - - | L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42) | 56b |
| 28 | - | SB28 - Fuse 28 on fuse holder B | 15 A | - - - - | K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72) | 56a |
| 29 | - | SB29 - Fuse 29 on fuse holder B | 10 A | - | J741-Dual signal inverter relay | 30 |
| 30 | - | SB30 - Fuse 30 on fuse holder B | 10 A | - - - - - | V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element | 75x |
| 31 | - | SB31 - Fuse 31 on fuse holder B | 30 A | - | J519-Onboard power supply control unit (signal horn) | 30 |
| 32 | - | SB32 - Fuse 32 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (windscreen wiper motor) | 30 |
| 33 | - | SB33 - Fuse 33 on fuse holder B | 15 A | - - - | J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio | 30 |
| 34 | - | SB34 - Fuse 34 on fuse holder B | 25 A | - - - - - - - - - - - | J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness | 15 |
| 35 | - | SB35 - Fuse 35 on fuse holder B | 5 A | - | Instruments illumination | 58d |
| 36 | - | SB36 - Fuse 36 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (turn signal) | 30 |
| Note
|
| Fuse location from August 2006 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SB1 - Fuse 1 on fuse holder B | 25 A | - | J487 - Fresh air blower isolation relay | 30 |
| 30 A | - | V306-Rear blower Bitron regulation motor | 30 | |||
| 2 | - | SB2 - Fuse 2 on fuse holder B | 5 A | - | G85 - steering angle sender | 30 |
| 3 | - | SB3 - Fuse 3 on fuse holder B | 10 A | - | J519 - Onboard power supply control unit | 30 |
| 4 | - | SB4 - Fuse 4 on fuse holder B | 10 A | - - - | E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor | 56b |
| 5 | - | SB5 - Fuse 5 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32) | 56b |
| 6 | - | SB6 - Fuse 6 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62) | 56a |
| 7 | - | SB7 - Fuse 7 on fuse holder B | 15 A | - | J519 - Onboard power supply control unit (interior light)1) | 30 |
| 8 | - | SB8 - Fuse 8 on fuse holder B | 5 A | - | T16 - 16-pin connector, diagnostic connector | 30 |
| 9 | - | SB9 - Fuse 9 on fuse holder B | 10 A | - | F - Brake light switch | 30 |
| 10 | - | SB10 - Fuse 10 on fuse holder B | 10 A | - - | E22 - Intermittent wiper switch E34 - Rear wiper switch | 15 |
| 11 | - | SB11 - Fuse 11 on fuse holder B | 5 A | - | X - number plate light | 58 |
| 12 | - | SB12 - Fuse 12 on fuse holder B | 15 A | - | U1 - Cigarette lighter | 30 |
| 13 | - | SB13 - Fuse 13 on fuse holder B | 5 A | - | J234 - Airbag control unit | 15 |
| 14 | - | SB14 - Fuse 14 on fuse holder B | 30 A | - - - - | E9 - Fresh air blower switch E30 - Air conditioning system switch J493-Auxiliary coolant heater relay V305 - Front blower Bitron regulation motor | 30 or 75x |
| 15 | - | SB15 - Fuse 15 on fuse holder B | 7,5 A | - - - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve | 153) 75x4) |
| 16 | - | SB16 - Fuse 16 on fuse holder B | 5 A | - | J519 - Onboard power supply control unit | 15 |
| 17 | - | SB17 - Fuse 17 on fuse holder B | 5 A | - - - - | F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket | RFL |
| 18 | - | SB18 - Fuse 18 on fuse holder B | 5 A | - | J285 - Control unit in dash panel insert | 30 |
| 19 | - | SB19 - Fuse 19 on fuse holder B | 5 A | - - - - - - - | E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12) | 86s |
| 20 | - | SB20 - Fuse 20 on fuse holder B | 5 A | - - - - - | M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket | LPL |
| 21 | - | SB21 - Fuse 21 on fuse holder B | 5 A | - - - - | M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket | RPL |
| 22 | - | SB22 - Fuse 22 on fuse holder B | 10 A | - - - - | J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 25) | 15 |
| 23 | - | SB23 - Fuse 23 on fuse holder B | 30 A | - | B-Starter6) | 50 |
| 5 A | - | J207 - Starter inhibitor relay7) | 50 | |||
| 24 | - | SB24 - Fuse 24 on fuse holder B | 5 A | - | G85 - steering angle sender | 15 |
| 25 | - | SB25 - Fuse 25 on fuse holder B | 5 A | - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit | 30 |
| 26 | - | SB26 - Fuse 26 on fuse holder B | 30 A | - | E1 - Lighting switch | 75x |
| 27 | - | SB27 - Fuse 27 on fuse holder B | 15 A | - - - | L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42) | 56b |
| 28 | - | SB28 - Fuse 28 on fuse holder B | 15 A | - - - - | K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72) | 56a |
| 29 | - | SB29 - Fuse 29 on fuse holder B | 10 A | - | J741-Dual signal inverter relay | 30 |
| 30 | - | SB30 - Fuse 30 on fuse holder B | 10 A | - - - - - | V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element | 75x |
| 31 | - | SB31 - Fuse 31 on fuse holder B | 30 A | - | J519-Onboard power supply control unit (signal horn) | 30 |
| 32 | - | SB32 - Fuse 32 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (windscreen wiper motor) | 30 |
| 33 | - | SB33 - Fuse 33 on fuse holder B | 15 A | - - - | J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio | 30 |
| 34 | - | SB34 - Fuse 34 on fuse holder B | 25 A | - - - - - - - - - - - | J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness | 15 |
| 35 | - | SB35 - Fuse 35 on fuse holder B | 5 A | - | Instruments illumination | 58d |
| 36 | - | SB36 - Fuse 36 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (turn signal) | 30 |
| Note
|
| Position of fuses, from November 2007 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SB1 - Fuse 1 on fuse holder B | 25 A | - | J487 - Fresh air blower isolation relay | 30 |
| 30 A | - | V306-Rear blower Bitron regulation motor | 30 | |||
| 2 | - | SB2 - Fuse 2 on fuse holder B | 5 A | - | G85 - steering angle sender | 30 |
| 3 | - | SB3 - Fuse 3 on fuse holder B | 10 A | - | J519 - Onboard power supply control unit | 30 |
| 4 | - | SB4 - Fuse 4 on fuse holder B | 10 A | - - - | E102 - Headlight range control regulator V48 - Left headlight range control motor V49 - Right headlight range control motor | 56b |
| 5 | - | SB5 - Fuse 5 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M29 - Left headlight dipped beam bulb S293-Special vehicle fuse 32) | 56b |
| 6 | - | SB6 - Fuse 6 on fuse holder B | 15 A | - - - | L1 - Left headlight twin filament bulb M30 - Left main beam bulb S296-Special vehicle fuse 62) | 56a |
| 7 | - | SB7 - Fuse 7 on fuse holder B | 15 A | - | J519 - Onboard power supply control unit (interior light)1) | 30 |
| 8 | - | SB8 - Fuse 8 on fuse holder B | 5 A | - | T16 - 16-pin connector, diagnostic connector | 30 |
| 9 | - | SB9 - Fuse 9 on fuse holder B | 10 A | - | F - Brake light switch | 30 |
| 10 | - | SB10 - Fuse 10 on fuse holder B | 10 A | - - | E22 - Intermittent wiper switch E34 - Rear wiper switch | 15 |
| 11 | - | SB11 - Fuse 11 on fuse holder B | 5 A | - | X - number plate light | 58 |
| 12 | - | SB12 - Fuse 12 on fuse holder B | 15 A | - | U1 - Cigarette lighter | 30 |
| 13 | - | SB13 - Fuse 13 on fuse holder B | 5 A | - | J234 - Airbag control unit | 15 |
| 14 | - | SB14 - Fuse 14 on fuse holder B | - | - | Vacant | - |
| 30 A | - | E4 - Headlight dipper/flasher switch5) | 30 | |||
| 15 | - | SB15 - Fuse 15 on fuse holder B | 7,5 A | - - - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch E179 - Rear fresh air blower switch J255 - Climatronic control unit N280 - Air conditioning system compressor regulating valve | 153) 75x4) |
| 16 | - | SB16 - Fuse 16 on fuse holder B | 5 A | - | J519 - Onboard power supply control unit | 15 |
| 17 | - | SB17 - Fuse 17 on fuse holder B | 5 A | - - - - | F216 - Rear fog light cut-out contact switch K13 - Rear fog light warning lamp L46 - Rear left fog light bulb U10 -Trailer socket | RFL |
| 18 | - | SB18 - Fuse 18 on fuse holder B | 5 A | - | J285 - Control unit in dash panel insert | 30 |
| 19 | - | SB19 - Fuse 19 on fuse holder B | 5 A | - - - - - - - | E153 - Operating and display unit for camping equipment J285 - Control unit in dash panel insert J503 - Control unit with display for radio and navigation system J519 - Onboard power supply control unit J768 - Roof hydraulics control unit R - Radio S291-Special vehicle fuse 12) | 86s |
| 20 | - | SB20 - Fuse 20 on fuse holder B | 5 A | - - - - - | M1 - Left side light bulb M4 - Left tail light bulb M21 - Left brake and tail light bulb T10bh-10-pin connector, purple2) U10 -Trailer socket | LPL |
| 21 | - | SB21 - Fuse 21 on fuse holder B | 5 A | - - - - | M2 - Right tail light bulb M3 - Right side light bulb M22 - Right brake and tail light bulb U10 -Trailer socket | RPL |
| 22 | - | SB22 - Fuse 22 on fuse holder B | 7,5 A | - - - - | J285 - Control unit in dash panel insert K145 - Front passenger side airbag deactivated warning lamp T16 - 16-pin connector, diagnostic connector T16j - 16-pin connector, diagnostic connector 2 | 15 |
| 23 | - | SB23 - Fuse 23 on fuse holder B | 30 A | - | B-Starter6) | 50 |
| 5 A | - - | J207 - Starter inhibitor relay7) T10bj-10-pin connector, yellow7) | 50 | |||
| 24 | - | SB24 - Fuse 24 on fuse holder B | 5 A | - | G85 - steering angle sender | 15 |
| 25 | - | SB25 - Fuse 25 on fuse holder B | 5 A | - - - | E30 - Air conditioning system switch E159 - Fresh air/air recirculation flap switch J255 - Climatronic control unit | 30 |
| 26 | - | SB26 - Fuse 26 on fuse holder B | 30 A | - | E1 - Lighting switch | 75x |
| 27 | - | SB27 - Fuse 27 on fuse holder B | 15 A | - - - | L2 - Right headlight twin filament bulb M31 - Right headlight dipped beam bulb S294-Special vehicle fuse 42) | 56b |
| 28 | - | SB28 - Fuse 28 on fuse holder B | 15 A | - - - - | K1 - Main beam warning lamp L2 - Right headlight twin filament bulb M32 - Right main beam bulb S297-Special vehicle fuse 72) | 56a |
| 29 | - | SB29 - Fuse 29 on fuse holder B | 10 A | - | J741-Dual signal inverter relay | 30 |
| 30 | - | SB30 - Fuse 30 on fuse holder B | 10 A | - - - - - | V12 - Rear window wiper motor V92 - Rear left wing door window wiper motor V93 - Rear right wing door window wiper motor Z20 - Left washer jet heater element Z21 - Right washer jet heater element | 75x |
| 31 | - | SB31 - Fuse 31 on fuse holder B | 30 A | - | J519-Onboard power supply control unit (signal horn) | 30 |
| 32 | - | SB32 - Fuse 32 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (windscreen wiper motor) | 30 |
| 33 | - | SB33 - Fuse 33 on fuse holder B | 15 A | - - - | J503 - Control unit with display for radio and navigation system J559-Traffic information control unit R - Radio | 30 |
| 34 | - | SB34 - Fuse 34 on fuse holder B | 25 A | - - - - - - - - - - - | J60 - Automatic gearbox relay SD3 - Fuse 3 on fuse holder D SD12-Fuse 12 on fuse holder D SD14 - Fuse 14 on fuse holder D SD15 - Fuse 15 on fuse holder D SD16 - Fuse 16 on fuse holder D SD17 - Fuse 17 on fuse holder D SD19 - Fuse 19 on fuse holder D SD20 - Fuse 20 on fuse holder D SD24 - Fuse 24 on fuse holder D D17 - Positive connection 1 (15), in engine harness | 15 |
| 35 | - | SB35 - Fuse 35 on fuse holder B | 5 A | - | Instruments illumination | 58d |
| 36 | - | SB36 - Fuse 36 on fuse holder B | 25 A | - | J519-Onboard power supply control unit (turn signal) | 30 |
| Note
|
| Fuses (SC) on fuse holder C |
| Location: |
| t | In the lower fuse box on centre of dash panel |
| Fuse colours |
| 30 A - blue |
| 30 A - green |
| 25 A - white |
| 20 A - yellow |
| 15 A - blue |
| 10 A - red |
| 7.5 A - brown |
| 5 A - beige |
|
| Position of fuses, from March 2003 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SC1 - Fuse 1 on fuse holder C | 15 A | - | U18 - 12 V socket -2- | 30 |
| 2 | - | SC2 - Fuse 2 on fuse holder C | 5 A | - - | G303 - Interior monitor send and receive module 1 G305 - Interior monitor send and receive module 2 | 30 |
| 3 | - | SC3 - Fuse 3 on fuse holder C | 5 A | - - | V320 - Right auxiliary blower V321 - Left auxiliary blower | 75x |
| 4 | - | SC4 - Fuse 4 on fuse holder C | 15 A | - | U19 - 12 V socket 3 | 30 |
| 5 | - | SC5-Fuse 5 on fuse holder C | 15 A | - | J698-Refrigerator box | 30 |
| 6 | - | SC6 - Fuse 6 on fuse holder C | 5 A | - | G226 - Oil level and oil temperature sender | 15 |
| 7 | - | SC7 - Fuse 7 on fuse holder C | 10 A | - | J180 - Switch-over relay 1 for roof ventilator | 30 |
| 8 | - | SC8 - Fuse 8 on fuse holder C | 5 A | - | J446 - Parking aid control unit | 15 |
| 9 | - | SC9 - Fuse 9 on fuse holder C | 5 A | - | J453-Multifunction steering wheel control unit | 30 |
| 10 | - | SC10 - Fuse 10 on fuse holder C | 30 A | - | R12 - Amplifier | 30 |
| 11 | - | SC11 - Fuse 11 on fuse holder C | 20 A | - - - - | J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit | 30 |
| 12 | - | SC12 - Fuse 12 on fuse holder C | 5 A | - | J493-Auxiliary coolant heater relay1) | 75x |
| 5 A | - | J419-Brake light additional relay2) | 15 | |||
| 13 | - | SC13 - Fuse 13 on fuse holder C | 5 A | - - - | E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring | 15 |
| 14 | - | SC14 - Fuse 14 on fuse holder C | 5 A | - | J412 - Mobile telephone operating electronics control unit | 30 |
| 15 | - | SC15 - Fuse 15 on fuse holder C | 5 A | - | J98-Gearshift indicator control unit | 15 |
| 16 | - | SC16 - Fuse 16 on fuse holder C | 5 A | - | J503 - Control unit with display for radio and navigation system | 15 |
| 17 | - | SC17 - Fuse 17 on fuse holder C | 5 A 7,5 A | - - | E265 - Rear Climatronic operating and display unit1) J519 - Onboard power supply control unit (interior light)2) | 30 |
| 18 | - | SC18 - Fuse 18 on fuse holder C | 5 A | - - | E179 - Rear fresh air blower switch E265 - Rear Climatronic operating and display unit2) | 15 30 |
| 19 | - | SC19 - Fuse 19 on fuse holder C | 5 A | - | Y7 - Automatic anti-dazzle interior mirror | 15 |
| 20 | - | SC20 - Fuse 20 on fuse holder C | 10 A | - | J519-Onboard power supply control unit (heated exterior mirror) | 30 |
| 21 | - | SC21 - Fuse 21 on fuse holder C | 5 A | - | G303 - Interior monitor send and receive module 1 | 15 |
| 22 | - | SC22 - Fuse 22 on fuse holder C | 5 A | - - | G65 - High-pressure sender G238 - Air quality sensor | 15 |
| 23 | - | SC23 - Fuse 23 on fuse holder C | 5 A3) 10 A4) | - - - - | E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater | 30 |
| 24 | - | SC24 - Fuse 24 on fuse holder C | 5 A | - | E153 - Operating and display unit for camping equipment1) | 15 |
| 25 | - | SC25 - Fuse 25 on fuse holder C | 15 A | - - - - | E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator G59 - Driver seat temperature sensor G60 - Front passenger seat temperature sensor | 75x |
| 26 | - | SC26 - Fuse 26 on fuse holder C | 10 A | - | G24 - Tachograph | 30 |
| 27 | - | SC27 - Fuse 27 on fuse holder C | 15 A | - - - | L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86), 7) | FL |
| 28 | - | SC28 - Fuse 28 on fuse holder C | 5 A | - | E43 - Mirror adjustment switch | 15 |
| 29 | - | SC29 - Fuse 29 on fuse holder C | 25 A | - | J364 - Auxiliary heater control unit | 30 |
| 30 | - | SC30 - Fuse 30 on fuse holder C | 5 A | - | E153 - Operating and display unit for camping equipment | 15 |
| 5 A | - | J493-Auxiliary coolant heater relay1) | 75x | |||
| 31 | - | SC31 - Fuse 31 on fuse holder C | 25 A | - | J245 - Sliding sunroof adjustment control unit | 30 |
| 32 | - | SC32 - Fuse 32 on fuse holder C | 20 A | - | J39 - Headlight washer system relay | 30 |
| 33 | - | SC33-Fuse 33 on fuse holder C | 5 A | - | G24 - Tachograph | 15 |
| 34 | - | SC34 - Fuse 34 on fuse holder C | 20 A | - | V192 - Vacuum pump for brakes1) | 75x |
| 25 A | - | U10 -Trailer socket2) | 30 | |||
| 35 | - | SC35 - Fuse 35 on fuse holder C | 10 A | - | J519 - Onboard power supply control unit | 30 |
| 36 | - | SC36 - Fuse 36 on fuse holder C | 15 A | - | U20 - 12 V socket -4-5) | 30 |
| 5 A | - - | E153 - Operating and display unit for camping equipment6) Special vehicles6), 7) | 15 | |||
| Note
|
| Position of fuses, from June 2004 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SC1 - Fuse 1 on fuse holder C | 25 A | - | U10 -Trailer socket | 30 |
| 2 | - | SC2 - Fuse 2 on fuse holder C | 5 A | - - | G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit | 30 |
| 3 | - | SC3 - Fuse 3 on fuse holder C | 5 A | - - | V320 - Right auxiliary blower V321 - Left auxiliary blower | 75x |
| 4 | - | SC4 - Fuse 4 on fuse holder C | 10 A | - | J492 - Four-wheel drive control unit | 15 |
| 5 | - | SC5-Fuse 5 on fuse holder C | 10 A | - | T6bn-6-pin connector, grey | 75x |
| 6 | - | SC6 - Fuse 6 on fuse holder C | 5 A | - | G226 - Oil level and oil temperature sender | 15 |
| 7 | - | SC7 - Fuse 7 on fuse holder C | 10 A | - | B320 - Positive connection -6- (30), in main wiring harrness1) | 30 |
| 15 A | - | U20 - 12 V socket -4-2) | 30 | |||
| 8 | - | SC8 - Fuse 8 on fuse holder C | 5 A | - | J446 - Parking aid control unit | 15 |
| 9 | - | SC9 - Fuse 9 on fuse holder C | 5 A | - | J453-Multifunction steering wheel control unit | 30 |
| 10 | - | SC10 - Fuse 10 on fuse holder C | 30 A | - | R12 - Amplifier | 30 |
| 11 | - | SC11 - Fuse 11 on fuse holder C | 15 A | - | J605 - Rear lid control unit | 30 |
| 20 A | - - - - - | H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit | 30 | |||
| 12 | - | SC12 - Fuse 12 on fuse holder C | 5 A | - | J419-Brake light additional relay | 15 |
| 10 A | - | J419-Brake light additional relay3), 7) | 15 | |||
| 13 | - | SC13 - Fuse 13 on fuse holder C | 5 A | - - - | E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring | 15 |
| 14 | - | SC14 - Fuse 14 on fuse holder C | 5 A | - | J412 - Mobile telephone operating electronics control unit | 30 |
| 15 | - | SC15 - Fuse 15 on fuse holder C | 5 A | - | J98-Gearshift indicator control unit | 15 |
| 16 | - | SC16 - Fuse 16 on fuse holder C | 5 A | - - | J503 - Control unit with display for radio and navigation system J412 - Mobile telephone operating electronics control unit | 15 |
| 17 | - | SC17 - Fuse 17 on fuse holder C | 7,5 A | - - | J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness | 30 |
| 18 | - | SC18 - Fuse 18 on fuse holder C | 5 A | - | E179 - Rear fresh air blower switch | 15 |
| 5 A | - | E265 - Rear Climatronic operating and display unit | 30 | |||
| 19 | - | SC19 - Fuse 19 on fuse holder C | 5 A | - | Y7 - Automatic anti-dazzle interior mirror | 15 |
| 20 | - | SC20 - Fuse 20 on fuse holder C | 10 A | - | J519-Onboard power supply control unit (heated exterior mirror) | 30 |
| 21 | - | SC21 - Fuse 21 on fuse holder C | 5 A | - | J529-Anti-theft and tilt system control unit | 15 |
| 22 | - | SC22 - Fuse 22 on fuse holder C | 5 A | - - | G65 - High-pressure sender G238 - Air quality sensor | 15 |
| 23 | - | SC23 - Fuse 23 on fuse holder C | 10 A | - - - - | E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater | 30 |
| 24 | - | SC24 - Fuse 24 on fuse holder C | 7,5 A | - | B250-Positive connection in roof wiring harness (interior lighting) | 30g |
| 25 | - | SC25 - Fuse 25 on fuse holder C | 15 A | - - - - | E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J131 - Heated driver seat control unit J132 - Heated front passenger seat control unit | 75x |
| 25 A | - | J774 -Heated front seats control unit7) | 75x | |||
| 26 | - | SC26 - Fuse 26 on fuse holder C | 10 A | - | G24 - Tachograph4) | 30 |
| 15 A | - | U18 - 12 V socket -2-5) | 30 | |||
| 27 | - | SC27 - Fuse 27 on fuse holder C | 15 A | - - - | L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86) | FL |
| 28 | - | SC28 - Fuse 28 on fuse holder C | 5 A | - | E43 - Mirror adjustment switch | 15 |
| 29 | - | SC29 - Fuse 29 on fuse holder C | 25 A | - | J364 - Auxiliary heater control unit | 30 |
| 30 | - | SC30 - Fuse 30 on fuse holder C | 5 A | - | E153 - Operating and display unit for camping equipment | 15 |
| 5 A | - | J493-Auxiliary coolant heater relay | 75x | |||
| 31 | - | SC31 - Fuse 31 on fuse holder C | 25 A | - | J245 - Sliding sunroof adjustment control unit | 30 |
| 32 | - | SC32 - Fuse 32 on fuse holder C | 20 A | - | J39 - Headlight washer system relay | 30 |
| 33 | - | SC33-Fuse 33 on fuse holder C | 5 A | - | G24 - Tachograph | 15 |
| 34 | - | SC34 - Fuse 34 on fuse holder C | 15 A | - | U19 - 12 V socket 3 | 30 |
| 35 | - | SC35 - Fuse 35 on fuse holder C | 10 A | - | J519 - Onboard supply control unit (reversing light models with automatic gearbox) | 30 |
| 36 | - | SC36 - Fuse 36 on fuse holder C | 5 A | - - | E153 - Operating and display unit for camping equipment Special vehicles6) | 15 |
| Note
|
| Fuse location from August 2006 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SC1 - Fuse 1 on fuse holder C | 25 A | - | U10 -Trailer socket | 30 |
| 2 | - | SC2 - Fuse 2 on fuse holder C | 5 A | - - | G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit | 30 |
| 3 | - | SC3 - Fuse 3 on fuse holder C | 5 A | - - | V320 - Right auxiliary blower V321 - Left auxiliary blower | 75x |
| 4 | - | SC4 - Fuse 4 on fuse holder C | 10 A | - | J492 - Four-wheel drive control unit | 15 |
| 5 | - | SC5-Fuse 5 on fuse holder C | 10 A | - | T6bn-6-pin connector, grey | 75x |
| 6 | - | SC6 - Fuse 6 on fuse holder C | 5 A | - | G226 - Oil level and oil temperature sender | 15 |
| 7 | - | SC7 - Fuse 7 on fuse holder C | 10 A | - | B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator) | 30 |
| 15 A | - | U20 - 12 V socket -4- | 30 | |||
| 8 | - | SC8 - Fuse 8 on fuse holder C | 5 A | - | J446 - Parking aid control unit | 15 |
| 9 | - | SC9 - Fuse 9 on fuse holder C | 5 A | - | J453-Multifunction steering wheel control unit | 30 |
| 10 | - | SC10 - Fuse 10 on fuse holder C | 30 A | - | R12 - Amplifier | 30 |
| 11 | - | SC11 - Fuse 11 on fuse holder C | 15 A | - | J605 - Rear lid control unit | 30 |
| 20 A | - - - - - | H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit | 30 | |||
| 12 | - | SC12 - Fuse 12 on fuse holder C | 5 A | - | J419-Brake light additional relay | 15 |
| 10 A | - | J419-Brake light additional relay1) | 15 | |||
| 13 | - | SC13 - Fuse 13 on fuse holder C | 5 A | - - - | E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring | 15 |
| 14 | - | SC14 - Fuse 14 on fuse holder C | 5 A | - | J412 - Mobile telephone operating electronics control unit | 30 |
| 15 | - | SC15 - Fuse 15 on fuse holder C | 5 A | - | J98-Gearshift indicator control unit | 15 |
| 16 | - | SC16 - Fuse 16 on fuse holder C | 5 A | - - | J412 - Mobile telephone operating electronics control unit J503 - Control unit with display for radio and navigation system | 15 |
| 17 | - | SC17 - Fuse 17 on fuse holder C | 7,5 A | - - | J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness | 30 |
| 18 | - | SC18 - Fuse 18 on fuse holder C | 5 A | - | E179 - Rear fresh air blower switch | 15 |
| 5 A | - | E265 - Rear Climatronic operating and display unit | 30 | |||
| 19 | - | SC19 - Fuse 19 on fuse holder C | 5 A | - | Y7 - Automatic anti-dazzle interior mirror | 15 |
| 20 | - | SC20 - Fuse 20 on fuse holder C | 10 A | - | J519-Onboard power supply control unit (heated exterior mirror) | 30 |
| 21 | - | SC21 - Fuse 21 on fuse holder C | 5 A | - | J529-Anti-theft and tilt system control unit | 15 |
| 22 | - | SC22 - Fuse 22 on fuse holder C | 5 A | - - | G65 - High-pressure sender G238 - Air quality sensor | 15 |
| 23 | - | SC23 - Fuse 23 on fuse holder C | 10 A | - - - - | E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater | 30 |
| 24 | - | SC24 - Fuse 24 on fuse holder C | 7,5 A | - | B250-Positive connection in roof wiring harness (interior lighting) | 30g |
| 25 | - | SC25 - Fuse 25 on fuse holder C | 25 A | - - - | E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit | 75x |
| 26 | - | SC26 - Fuse 26 on fuse holder C | 10 A | - | G24 - Tachograph2) | 30 |
| 15 A | - | U18 - 12 V socket -2-3) | 30 | |||
| 27 | - | SC27 - Fuse 27 on fuse holder C | 15 A | - - - | L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 84) | FL |
| 28 | - | SC28 - Fuse 28 on fuse holder C | 5 A | - - | E43 - Mirror adjustment switch J386 - Driver door control unit | 15 |
| 29 | - | SC29 - Fuse 29 on fuse holder C | 25 A | - | J364 - Auxiliary heater control unit | 30 |
| 30 | - | SC30 - Fuse 30 on fuse holder C | 5 A | - | E153 - Operating and display unit for camping equipment | 15 |
| 5 A | - | J493-Auxiliary coolant heater relay | 75x | |||
| 31 | - | SC31 - Fuse 31 on fuse holder C | 25 A | - | J245 - Sliding sunroof adjustment control unit | 30 |
| 5 A | - | A11 - Onboard supply charger unit5) | 30 | |||
| 32 | - | SC32 - Fuse 32 on fuse holder C | 20 A | - | J39 - Headlight washer system relay | 30 |
| 33 | - | SC33-Fuse 33 on fuse holder C | 5 A | - | G24 - Tachograph2) | 15 |
| 15 A | - - | G24 - Tachograph6) J351 - Folding exterior mirror control unit6) | 15 | |||
| 15 A | - | J351 - Folding exterior mirror control unit7) | 15 | |||
| 34 | - | SC34 - Fuse 34 on fuse holder C | 15 A | - | U19 - 12 V socket 3 | 30 |
| 35 | - | SC35 - Fuse 35 on fuse holder C | 10 A | - | J519 - Onboard supply control unit (reversing light models with automatic gearbox) | 30 |
| 36 | - | SC36 - Fuse 36 on fuse holder C | 5 A | - - | E153 - Operating and display unit for camping equipment Special vehicles4) | 15 |
| Note
|
| Position of fuses, from November 2007 |
| No. | Current Flow Diagram designation | Nominal value | Function/component | Terminal | ||
| 1 | - | SC1 - Fuse 1 on fuse holder C | 25 A | - | U10 -Trailer socket | 30 |
| 2 | - | SC2 - Fuse 2 on fuse holder C | 5 A | - - | G305 - Interior monitor send and receive module 2 J529-Anti-theft and tilt system control unit | 30 |
| 3 | - | SC3 - Fuse 3 on fuse holder C | 5 A | - - | V320 - Right auxiliary blower1) V321 - Left auxiliary blower1) | 75x |
| - | - | Vacant2), 10) | - | |||
| 30 A | - | J519 - Onboard power supply control unit (heated rear window)11) | 30 | |||
| 4 | - | SC4 - Fuse 4 on fuse holder C | 10 A | - - - | E121 - Rear differential lock switch J187-Differential lock control unit J492 - Four-wheel drive control unit | 15 |
| 5 | - | SC5-Fuse 5 on fuse holder C | 10 A | - | T6bn-6-pin connector, grey | 75x |
| 6 | - | SC6 - Fuse 6 on fuse holder C | 5 A | - | G226 - Oil level and oil temperature sender | 15 |
| 7 | - | SC7 - Fuse 7 on fuse holder C | 10 A | - | B320 - Positive connection -6- (30), in main wiring harrness (roof ventilator) | 30 |
| 15 A | - | U20 - 12 V socket -4- | 30 | |||
| 8 | - | SC8 - Fuse 8 on fuse holder C | 5 A | - | J446 - Parking aid control unit | 15 |
| 9 | - | SC9 - Fuse 9 on fuse holder C | 5 A | - | J453-Multifunction steering wheel control unit | 30 |
| 10 | - | SC10 - Fuse 10 on fuse holder C | 30 A | - | R12 - Amplifier | 30 |
| 11 | - | SC11 - Fuse 11 on fuse holder C | 15 A | - | J605 - Rear lid control unit | 30 |
| 20 A | - - - - - | H12 - Alarm horn J393 - Convenience system central control unit J558 - Left sliding door control unit J605 - Rear lid control unit J731-Right sliding door control unit | 30 | |||
| 12 | - | SC12 - Fuse 12 on fuse holder C | 5 A | - | J419-Brake light additional relay | 15 |
| 10 A | - | J419-Brake light additional relay3) | 15 | |||
| 13 | - | SC13 - Fuse 13 on fuse holder C | 5 A | - - - | E45-Cruise control system switch E221 - Operating unit in steering wheel F138 - Airbag coil connector and return spring with slip ring | 15 |
| 14 | - | SC14 - Fuse 14 on fuse holder C | 5 A | - | J412 - Mobile telephone operating electronics control unit | 30 |
| 15 | - | SC15 - Fuse 15 on fuse holder C | 5 A | - | J98-Gearshift indicator control unit | 15 |
| 16 | - | SC16 - Fuse 16 on fuse holder C | 5 A | - | J503 - Control unit with display for radio and navigation system | 15 |
| 17 | - | SC17 - Fuse 17 on fuse holder C | 7,5 A | - - | J519 - Onboard power supply control unit (interior light) B315 - Positive connection -1- (30), in main wiring harrness | 30 |
| 18 | - | SC18 - Fuse 18 on fuse holder C | 5 A | - | E179 - Rear fresh air blower switch | 15 |
| 5 A | - | E265 - Rear Climatronic operating and display unit | 30 | |||
| 19 | - | SC19 - Fuse 19 on fuse holder C | 5 A | - | Y7 - Automatic anti-dazzle interior mirror | 15 |
| 20 | - | SC20 - Fuse 20 on fuse holder C | 10 A | - | J519-Onboard power supply control unit (heated exterior mirror) | 30 |
| 21 | - | SC21 - Fuse 21 on fuse holder C | 5 A | - | J529-Anti-theft and tilt system control unit | 15 |
| 22 | - | SC22 - Fuse 22 on fuse holder C | 5 A | - - | G65 - High-pressure sender G238 - Air quality sensor | 15 |
| 23 | - | SC23 - Fuse 23 on fuse holder C | 10 A | - - - - | E153 - Operating and display unit for camping equipment E407-Auxiliary heater operating and display unit J708 - Residual heat relay R149-Remote control receiver for auxiliary coolant heater | 30 |
| 24 | - | SC24 - Fuse 24 on fuse holder C | 7,5 A | - | B250-Positive connection in roof wiring harness (interior lighting) | 30g |
| 25 | - | SC25 - Fuse 25 on fuse holder C | 25 A | - - - | E94 - Heated driver seat regulator E95 - Heated front passenger seat regulator J774 -Heated front seats control unit | 75x |
| 26 | - | SC26 - Fuse 26 on fuse holder C | 10 A | - | G24 - Tachograph7) | 30 |
| 15 A | - | U18 - 12 V socket -2-5) | 30 | |||
| 27 | - | SC27 - Fuse 27 on fuse holder C | 15 A | - - - | L22 - Left fog light bulb L23 - Right fog light bulb S298-Special vehicle fuse 86) | FL |
| 28 | - | SC28 - Fuse 28 on fuse holder C | 5 A | - - | E43 - Mirror adjustment switch J386 - Driver door control unit | 15 |
| 29 | - | SC29 - Fuse 29 on fuse holder C | 25 A | - | J364 - Auxiliary heater control unit | 30 |
| 30 | - | SC30 - Fuse 30 on fuse holder C | 5 A | - | E153 - Operating and display unit for camping equipment | 15 |
| 5 A | - | J493-Auxiliary coolant heater relay | 75x | |||
| 31 | - | SC31 - Fuse 31 on fuse holder C | 25 A | - | J245 - Sliding sunroof adjustment control unit | 30 |
| 5 A | - | A11 - Onboard supply charger unit4) | 30 | |||
| 32 | - | SC32 - Fuse 32 on fuse holder C | 20 A | - | J39 - Headlight washer system relay | 30 |
| 33 | - | SC33-Fuse 33 on fuse holder C | 5 A | - | G24 - Tachograph7) | 15 |
| 15 A | - - | G24 - Tachograph8) J351 - Folding exterior mirror control unit8) | 15 | |||
| 15 A | - | J351 - Folding exterior mirror control unit9) | 15 | |||
| 34 | - | SC34 - Fuse 34 on fuse holder C | 15 A | - | U19 - 12 V socket 3 | 30 |
| 35 | - | SC35 - Fuse 35 on fuse holder C | 10 A | - | J519 - Onboard supply control unit (reversing light models with automatic gearbox) | 30 |
| 36 | - | SC36 - Fuse 36 on fuse holder C | 5 A | - - | E153 - Operating and display unit for camping equipment T10bh-10-pin connector, purple6) | 15 |
| Note
|
VW TRANSPORTER 2005 Overview:
Overview:
| 1 - | Ignition/starter switch -D- |
| q | On steering column |
| q | Connector assigment |
| 2 - | Onboard power supply control unit -J519- |
| q | Below the dash panel |
| q | Connector assigment |
| 3 - | Steering column switch -T41- |
| q | On steering column |
| q | Connector assigment |
| 4 - | Diagnosis connection -T16- |
| q | Left under dash panel |
| q | Connector assigment |
| 5 - | Control unit in dash panel insert -J285- |
| q | Pin connector -T32- |
| q | Pin connector -T32a- |
|
VW TRANSPORTER 2005 Onboard power supply control unit -J519-
| Onboard power supply control unit -J519- |
| Connector assigment: |
| A - | Pin connector, T6, black |
| B - | Pin connector, T6a, brown |
| C - | Pin connector, T6b, red |
| D - | Pin connector, T5, black |
| E - | Pin connector, T5a, brown |
| F - | Pin connector, T6c, black |
| G - | Pin connector, T18, black |
| H - | Pin connector, T6d, brown |
| I - | Pin connector, T18a, brown |
| J - | Pin connector, T6e, red |
| K - | Vacant |
VW TRANSPORTER 2005 Contact assignment of pin connector -T6-, on onboard supply control unit (Item A)
| Contact assignment of pin connector -T6-, on onboard supply control unit (Item A) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | 636 - Earth point onboard supply control unit | 31 | |
| 2 | - | Vacant | ||
| 3 | - | B129 - Connection (interior light, 31l), in interior wiring harness | TK | |
| 4 | - | B153 - Connection (RTS), in interior wiring harness (output right turn signal) | BLR | |
| 5 | - | SB36 - Fuse 36 on fuse holder B (turn signal input) | 30a | |
| 6 | - | B152 - Connection (LTS), in interior wiring harness (output left turn signal) | BLL |
VW TRANSPORTER 2005 Contact assignment of pin connector -T6a-, on onboard supply control unit (Item A)
| Contact assignment of pin connector -T6a-, on onboard supply control unit (Item A) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | Z5 - Front passenger side heated exterior mirror (output) | ||
| 2 | - | Z4 - Driver side heated exterior mirror (output) | ||
| 3 | - | SB16 - Fuse 16 on fuse holder B (input) | 15 | |
| 4 | - | SB20 - Fuse 20 on fuse holder C (input heated exterior mirror) | 30a | |
| 5 | - | SB17 - Fuse 17 on fuse holder C (interior light output) SC24 - Fuse 24 on fuse holder C (interior light output) | ¹) ¹) | 30g 30g |
| 5 | - | B315 - Positive connection 1 (30a), in main wiring harrness (interior light output) | ²) | 30g |
| 6 | - | SB7 - Fuse 7 on fuse holder C (interior light input) | ¹) | 30a |
| 6 | - | SB17 - Fuse 17 on fuse holder C (interior light input) | ²) | 30a |
| Note
|
VW TRANSPORTER 2005 Contact assignment of pin connector -T6b-, on onboard supply control unit (Item C)
| Contact assignment of pin connector -T6b-, on onboard supply control unit (Item C) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | Vacant | ||
| 2 | - | SC35 - Fuse 35 on fuse holder C | RFL | |
| 3 | - | Vacant | ||
| 4 | - | Vacant | ||
| 5 | - | Vacant | ||
| 6 | - | B520-Connection (RL), in main wiring harness | RFL |
VW TRANSPORTER 2005 Contact assignment of pin connector -T5-, on onboard supply control unit (Item D)
| Contact assignment of pin connector -T5-, on onboard supply control unit (Item D) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | J49-Electric fuel pump 2 relay | 85 | |
| 2 | - | V - Windscreen wiper motor, Pin 1 (speed 2) | 53b | |
| 3 | - | V - Windscreen wiper motor, Pin 2 (speed 1) | 53 | |
| 4 | - | 370 - Earth connection 5, in main wiring harness | 31 | |
| 5 | - | SB32 - Fuse 32 on fuse holder (windscreen wiper motor input) | 30a |
VW TRANSPORTER 2005 Contact assignment of pin connector -T5a-, on onboard supply control unit (Item E)
| Contact assignment of pin connector -T5a-, on onboard supply control unit (Item E) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | SB3 - Fuse 3 on fuse holder B (input) | 30a | |
| 2 | - | H1 - Horn or dual tone horn (output) C13 - Positive connection in dual tone horn wiring harness (output) | ||
| 3 | - | SB13 - Fuse 13 on fuse holder B (horn or dual tone horn input) | 30a | |
| 4 | - | Z1-Heated rear window (output) | ||
| 5 | - | S41-Heated rear window fuse (input) | 30a |
VW TRANSPORTER 2005 Contact assignment of pin connector -T6c-, on onboard supply control unit (Item F)
| Contact assignment of pin connector -T6c-, on onboard supply control unit (Item F) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | Vacant | ||
| 2 | - | Vacant | ||
| 3 | - | B441-Connection (CCS), in main wiring harness, GND on/off | ||
| 4 | - | E45-Cruise control system switch, T41 Pin 31, GND R | ||
| 5 | - | E45-Cruise control system switch, T41 Pin 27, GND memory | ||
| 6 | - | E45-Cruise control system switch, T41 Pin 30, GND memory |
VW TRANSPORTER 2005 Contact assignment of pin connector -T18-, on onboard supply control unit (Item G)
| Contact assignment of pin connector -T18-, on onboard supply control unit (Item G) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | B406-Connection 1 (convenience CAN bus, low), in main wiring harness | CAN-L | |
| 2 | - | B397-Connection 1 (convenience CAN bus, high), in main wiring harness | CAN-H | |
| 3 | - | Vacant | ||
| 4 | - | E2-Turn signal switch, T41 Pin 32 (right turn signal input) | BLR | |
| 5 | - | SD18 - Fuse 18 on fuse holder D (input battery voltage measurement, positive) | 30A | |
| 6 | - | A - Battery (input battery voltage measurement, negative) | 31 | |
| 7 | - | F2 - Driver door contact switch (input) | ||
| 8 | - | Vacant | ||
| 9 | - | O4 - Positive connection (30as), in seat heating wiring harness (deactivate - output J131, J132) | ||
| 10 | - | E3 - Hazard warning light switch (input) | ||
| 11 | - | F11 - Rear right door contact switch (J741 Pin 7), (input) | ||
| 12 | - | E2-Turn signal switch, T41 Pin 34 (left turn signal input) | BLL | |
| 13 | - | F10 - Rear left door contact switch (J741 Pin 8), (input) | ||
| 14 | - | E15 - Heated rear window switch (input) | ||
| 15 | - | H-Horn plate, T41 Pin 10 (input) | ||
| 16 | - | F266 - Bonnet contact switch (input) | ||
| 17 | - | F3 - Front passenger door contact switch (input) | ||
| 18 | - | E231 - Exterior mirror heater button (input) |
VW TRANSPORTER 2005 Contact assignment of pin connector -T6d-, on onboard supply control unit (Item H)
| Contact assignment of pin connector -T6d-, on onboard supply control unit (Item H) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | J245 - Sliding sunroof adjustment control unit (output) | ||
| 2 | - | E180 - Heated windscreen switch (input) | ¹) | |
| 3 | - | G213 - Rain sensor, (signal - input) | ||
| 4 | - | J39 - Headlight washer system relay (output) | 85 | |
| 5 | - | K122-Heated windscreen warning lamp | ¹) | |
| 6 | - | G213 - Rain sensor (GND) | 31 |
VW TRANSPORTER 2005 Contact assignment of pin connector -T18a-, on onboard supply control unit (Item I)
| Contact assignment of pin connector -T18a-, on onboard supply control unit (Item I) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | Vacant | ||
| 2 | - | K10 - Heated rear window warning lamp (output) | ||
| 3 | - | Vacant | ||
| 4 | - | F5 - Luggage compartment light switch (input via B475) | ||
| 5 | - | F111 - Rear lid contact switch (input via B534) | ||
| 6 | - | SB35 - Fuse 35 on fuse holder B (input via B340) | 58d | |
| 7 | - | V - Windscreen wiper motor (input) | ||
| 8 | - | D - Ignition/starter switch, Pin 8 (input - S-contact via SB19 and B518) | 86s | |
| 9 | - | E34 - Rear wiper switch, T41 Pin 20 (input - windscreen and rear window washer pump) | ||
| 10 | - | F4 - Reversing light switch (input - reversing lights via B520) | RFL | |
| 11 | - | E38-Intermittent wipe regulator, T41 Pin 17 (input - intermittent) | INT | |
| 12 | - | D-Ignition/starter switch, Pin 8 (input) | 50b | |
| 13 | - | C - Alternator (input - battery charge) | 61 | |
| 14 | - | E22-Intermittent wiper switch, T41 Pin 16 (input - windscreen wiper speed 2) | 53b | |
| 15 | - | D-Ignition/starter switch, Pin 2 (input - X-contact via B173) | X | |
| 16 | - | K6-Hazard warning light system warning lamp | ||
| 17 | - | Vacant | ||
| 18 | - | E22-Intermittent wiper switch, T41 Pin 16 (input - windscreen wiper speed 1) | 53 |
VW TRANSPORTER 2005 Contact assignment of pin connector -T6e-, on onboard supply control unit (Item J)
| Contact assignment of pin connector -T6e-, on onboard supply control unit (Item J) |
| Pin | Assignment/Component | Terminal | ||
| 1 | - | A18 - Windscreen heater voltage transformer (output) | ¹) | |
| 2 | - - | J7 - Battery isolation relay (output) J713 - Second battery charging circuit relay (output) | 85 85 | |
| 3 | - | J207 - Starter inhibitor relay (output) | 50a | |
| 4 | - | J98 - Gearshift indicator control unit (output) | ||
| 5 | - | G213 - Rain sensor (voltage supply - output) | 15 | |
| 6 | - | F125 - Multifunction switch (input - release AG) |
| Note
|
VW TRANSPORTER 2005 Contact assignment of pin connector -T41-, on steering column switch
|
VW TRANSPORTER 2005 Contact assignment of pin connector -T16-, on diagnosis pin connector
VW TRANSPORTER 2005 Control unit in dash panel insert -J285-
Note
|
|
|
VW TRANSPORTER 2005
VW TRANSPORTER 2005 Overview of earth points in engine compartment
| Overview of earth points in engine compartment |
Note:
| ♦ Earth points for camper ⇒ Fitting Locations for camper |
| 12 | Earth point, on left in engine compartment ⇒ -arrow A- |
| TV7 - | Terminal 31 wiring junction |
| Earth point 1 ⇒ -arrow a- |
| Earth point 2 ⇒ -arrow b- |
| Earth point 3 ⇒ -arrow c- |
Note:
| ♦ near headlight |
Note:
|
| 14 | Earth point, on gearbox ⇒ -arrow- |
Note:
| ♦ near starter |
Note:
|
| 607 | Earth point, on left in plenum chamber ⇒ -arrow- |
Note:
| ♦ near windscreen wiper motor |
|
| 18 | Earth point on engine block ⇒ -arrow A- |
| Transporter | Fitting Locations | No. 801 / 7 |
| 34 | Earth point under driver seat ⇒ -arrow- |
|
| 49 | Earth point, near bulkhead ⇒ -arrow D- |
| 636 | Earth point, onboard supply control unit ⇒ -arrow C- |
| 637 | Earth point, airbag control unit ⇒ -arrow A- |
| 605 | Earth point, on top end of steering column ⇒ -arrow- |
|
| 639 | Earth point, left A-pillar ⇒ -arrow A- |
| 670 | Earth point 2, left A-pillar ⇒ -arrow B- |
Note:
| ♦ Earth points for camper ⇒ Fitting Locations for camper |
| 653 | Earth point, left D-pillar ⇒ -arrow A- |
| 668 | Earth point 2, left D-pillar ⇒ -arrow B- |
Note:
| ♦ for models with short wheel base only |
| 653 | Earth point, left D-pillar ⇒ -arrow B- |
| 668 | Earth point 2, left D-pillar ⇒ -arrow A- |
Note:
| ♦ for models with long wheel base only |
Note:
|
| Transporter | Fitting Locations | No. 801 / 15 |
Note:
|
| 68 | Earth point, on left of rear cross member ⇒ -arrow A- |
