SEAT LEON 2004 — Anti-dazzle mirror, rain sensor . Wiring diagrams, Pin Connector, Location

Wiring Diagram SEAT LEON 2004 - Windscreen wiper motor - automatic intermittent wash/wipe relay - intermittent wiper control - rain sensor - automatic anti-dazzle interior mirror

D	Ignition/starter switch
E38	Intermittent wiper control
F4	Reversing light switch
G213	Rain sensor
J31	Automatic intermittent wash/wipe relay
S5	Fuse in fuse box/relay plate
Y7	Automatic anti-dazzle interior mirror
T4	4-pin connector, behind dash panel, right
T6	6-pin connector, in centre console
T6a	6-pin connector, green, under driver's seat
T10	10-pin connector, orange, in protective housing for connectors, in plenum chamber, left
33	Earth point, behind dash panel, right
81	Earth connection -1-, in dash panel wiring harness
135	Earth connection -2-, in dash panel wiring harness
A2	Positive (+) connection (15), in dash panel wiring harness
A20	Connection (15a), in dash panel wiring harness
A87	Connection (RL), in dash panel wiring harness

Wiring Diagram SEAT LEON 2004 - Automatic intermittent wash/wipe relay - intermittent wiper switch - windscreen wiper motor - windscreen washer pump

E22	Intermittent wiper switch
J...	Engine control units
J31	Automatic intermittent wash/wipe relay
S224	Fuse in fuse box
V	Windscreen wiper motor
V5	Windscreen washer pump
T10	10-pin connector, orange, in protective housing for connectors, in plenum chamber, left
179	Earth connection, in left headlight wiring harness
503	Screw connection -2- (75x), on relay plate
A27	Connection (speed signal), in dash panel wiring harness
A96	Connection (53a), in dash panel wiring harness
A97	Connection (53), in dash panel wiring harness
A102	Connection (windscreen wiper), in dash panel wiring harness

SEAT LEON 2004 Overview of relay

Overview of relay    

1 -	Relay in left engine compartment

q	Position of relays → page 804/2

2 -	Relay on relay plate

q	Position of relays → page 804/3

2 -	Relay on the 13 position additional relay carrier above the relay plate

q	Position of relays → page 804/4

Toledo/León	Fitting Locations	No.  804 / 2

Relay in left engine compartment: A -  Secondary air pump relay -J299- (100)  -  High heat output relay -J360- (100) (only models with auxiliary heater) B -  Terminal 30 voltage supply relay -J689- (428)  -  Current supply relay for Simos control unit -J363- (429) (for models with engine code BFQ only)  -  Low heat output relay -J359- (53) (only models with auxiliary heater) C -  Vacant

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  804 / 3

SEAT LEON 2004 Relay on relay plate Relay on relay plate 1 -  Dual tone horn relay -J4- (53) 2 -  X-contact relief relay -J59- (100) 3 -  Vacant 4 -  Fuel pump relay -J17- (409)  -  Glow plug relay -J52- (103) V y Vl -  Automatic intermittent wash and wipe relay -J31-  -  with rain sensor, with/without headlight washer system (192)  -  without rain sensor, with headlight washer system (389)  -  without rain sensor, without headlight washer system (377)

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  804 / 4

SEAT LEON 2004 Relay on the 13 position additional relay carrier above the relay plate Relay on the 13 position additional relay carrier above the relay plate Left-handdrive vehicles: 1 -  Telephone relay 2....9 -  Vacant 10 -  Fuel pump relay (turbo diesel engine unit injectors) (167) -J17- (up to October 2002)  -  Fuel pump relay (TDI-PD) (53) (from November 2002) 11 -  Automatic gearbox relay AG4 -J60- (175) 12 -  Terminal 30 voltage supply relay -J317- (109) 13 -  Radiator fan relay (53)

Получить доступ ко всем электросхемам автомобиля

Right-handdrive vehicles: 1....5 -  Vacant 6 -  Telephone switch-over relay 7 -  Radiator fan relay -J26- (53) 8 -  Terminal 30 voltage supply relay (109) 9 -  Automatic gearbox relay AG4 -J60- (175) 10 -  Fuel pump relay (turbo diesel engine unit injectors)-J17- (167) (up to October 2002)  -  Fuel pump relay (TDI-PD) (53) (from November 2002) 11 -  Vacant 12 -  Cigarette lighter relay Australia -J193- (53) 13 -  Vacant

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  804 / 5

SEAT LEON 2004 Glow plug activation control unit: Glow plug activation control unit: A -  Glow plug activation control unit -J370- (with engine code ARL only)

Получить доступ ко всем электросхемам автомобиля

SEAT LEON 2004 Overview of coupling station and connections for wiring harness

Overview of coupling station and connections for wiring harness    

1 -	Coupling station in protective housing, in plenum chamber

q	With connectors -T10g-, -T10d-, -T10e-, -T10-, -T6l-, -T10h-, -T10v-

q	Location → page 803/2

2 -	Coupling station, right B-pillar

q	With connector -T10m-

q	Location → page 803/4

3 -	Coupling station on left of C-pillar

q	Location → page 803/4

4 -	Coupling station on left of A-pillar

q	With connector -T10i-

q	Location → page 803/5

5 -	Coupling station in engine compartment, in left wiring harness

q	Location → page 803/5

Toledo/León	Fitting Locations	No.  803 / 2

Coupling station in protective housing, in plenum chamber

1 -	10-pin connector -T10g-, grey, automatic gearbox

2 -	10-pin connector, -T10d-, white, data bus wire, engine control unit, automatic gearbox, Motronic control unit, ABS control unit

3 -	10-pin connector -T10e-, black, cruise control system, Motronic control unit, engine control unit

4 -	10-pin connector -T10-, orange, reversing lights, engine control unit, starter, Climatronic control unit, Motronic control unit

5 -	6-pin connector -T6l-, brown, starter, fuel pump relay, engine control unit

Toledo/León	Fitting Locations	No.  803 / 3

6 -	10-pin connector -T10h-, blue, accelerator position sender, Motronic control unit, engine control unit

7 -	10-pin connector, -T10v-, green, radiator outlet coolant temperature sender, radiator fan control unit, potentiometer for temperature selection rotary knob

Toledo/León	Fitting Locations	No.  803 / 4

SEAT LEON 2004 Coupling station, right B-pillar Coupling station, right B-pillar 1 -  10-pin connector -T10m-, black, signal loudspeakers, central locking, rear electric window regulator, rear door warning lamp The wiring on the B-pillar, left, is installed vice versa.

Получить доступ ко всем электросхемам автомобиля

SEAT LEON 2004 Coupling station on left of C-pillar Coupling station on left of C-pillar See connectors in fitting locations: Multi-pin connections. 1 -  Earth connection 2 -  Rear fog light, number plate light, reversing lights black 3 -  Rear window wiper and washer system (only for Leon) pink 4 -  Central locking brown

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  803 / 5

SEAT LEON 2004 Coupling station on left of A-pillar Coupling station on left of A-pillar 1 -  10-pin connector -T10i-, black, central locking, electric mirror adjustment, radio with muting / electric windows The wiring on the A-pillar, right, is installed vice versa.

Получить доступ ко всем электросхемам автомобиля

SEAT LEON 2004 Coupling station in engine compartment, in left wiring harness Coupling station in engine compartment, in left wiring harness See connectors in fitting locations: Multi-pin connections.

Получить доступ ко всем электросхемам автомобиля

SEAT LEON 2004 Overview of earth points in engine compartment

Overview of earth points in engine compartment    

1 -	Earth point, in centre of plenum chamber -608-

q	Location → page 801/2

2 -	Earth point, in plenum chamber -10-

q	Location → page 801/2

3 -	Earth point, on right in plenum chamber -609-

q	Location → page 801/3

4 -	Earth strap, battery - body -1-

q	Location → page 801/3

5 -	Earth points, in left engine compartment -12-

q	Location → page 801/4

6 -	Earth strap, gearbox - body -2-

q	Location → page 801/4

Toledo/León	Fitting Locations	No.  801 / 2

608 Earth point, in centre of plenum chamber ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

10 Earth point, in plenum chamber ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 3

609 Earth point, on right in plenum chamber ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

1 Earth strap, battery - body ⇒ Arrow A

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 4

12 Earth points, on left in engine compartment ⇒ -arrow B-

Получить доступ ко всем электросхемам автомобиля

2 Earth strap, gearbox - body ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 5

Overview of earth points in vehicle interior

1 -	Earth point, lower part of right A-pillar -43-

q	Location → page 801/7

2 -	Earth point, right B-pillar -78-

q	Location → page 801/7

3 -	Earth point, left B-pillar -77-

q	Location → page 801/8

4 -	Earth point, lower part of left A-pillar -44-

q	Location → page 801/8

5 -	Earth point, on right behind dash panel -42-

q	Location → page 801/9

6 -	Earth point, on right behind dash panel -33-

q	Location → page 801/9

Toledo/León	Fitting Locations	No.  801 / 6

7 -	Earth point, on left behind dash panel insert -32-

q	Location → page 801/10

8 -	Earth point, behind dash panel -45-

q	Location → page 801/10

Toledo/León	Fitting Locations	No.  801 / 7

43 Earth point, lower part of right A-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

78 Earth point on right B-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 8

77 Earth point on left B-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

44 Earth point, lower part of left A-pillar ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 9

33 Earth point behind dash panel on right ⇒ -arrow-   42 Same earth point as ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 10

32 Earth point behind dash panel on left ⇒ -arrow-

Получить доступ ко всем электросхемам автомобиля

45 Earth point, behind dash panel

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 11

SEAT LEON 2004 Overview of earth points in luggage compartment (Toledo)

Overview of earth points in luggage compartment (Toledo)

1 -	Earth point, on left in luggage compartment -50-

q	Location → page 801/12

Toledo/León	Fitting Locations	No.  801 / 12

50 Earth point, on left in luggage compartment

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  801 / 13

SEAT LEON 2004 Overview of earth points in luggage compartment (León)

Overview of earth points in luggage compartment (León)

1 -	Earth point, left rear pillar -57-

q	Location → page 801/14

Toledo/León	Fitting Locations	No.  801 / 14

57 Earth point, left rear pillar

Получить доступ ко всем электросхемам автомобиля

SEAT LEON 2004 Overview of fuses

Overview of fuses    

1 -	Fuse in fuse holder left dash panel

q	Location → page 802/2

q	Position of fuses → page 802/3

2 -	Auxiliary fuse above additional relay carrier -S37-, -S45-, -S323-, -S111-, -S144-

q	Location → page 802/7

3 -	Fuse on fuse holder -S162-, -S163-, -S164-, -S176-, -S177-, -S178-, -S179-, -S180-, next to battery

q	Location, up to August 2000: → Page 802/8

q	Location, from September 2000: → Page 802/9

Toledo/León	Fitting Locations	No.  802 / 2

Fuse in fuse holder, dash panel Fuse colours 30 A -  green 25 A -  white 20 A -  yellow 15 A -  blue 10 A -  red 7,5 A -  brown 5 A -  beige 3 A -  purple The fuse electrical connections are shown in the respective current flow diagrams. The fuses for options not mentioned are also shown in the respective Current flow diagrams. Fuses from S 24 are designated with an additional characteristic o. distinctive feature "2" in the Current Flow Diagram, for example: S 40 is designated as S 240.

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  802 / 3

SEAT LEON 2004 Position of fuses in fuse holder, left dash panel

Position of fuses in fuse holder, left dash panel

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
1	-	-S1-	10A	-	Glove compartment light, heated washer jets
2	-	-S2-	10A	-	Turn signals
3	-	-S3-	5A	-	Side light warning lamp
4	-	-S4-	5A	-	Number plate light
5	-	-S5-	7.5A	-	Number plate light
6	-	-S6-	5A	-	Electric folding exterior mirror and window regulator (applicable up to October 2001) Convenience system central control unit (applicable from November 2001)
7	-	-S7-	10A	-	Reversing light
8	-	-S8-	5A	-	Telephone
9	-	-S9-	5A	-	ABS/ESP/HALDEX
10	-	-S10-	10A	-	Petrol engine control unit (applicable up to October 2001) Diesel engine control unit (applicable up to October 2001) - S-contact (applicable from November 2001)
11	-	-S11-	5A	-	Dash panel insert
12	-	-S12-	7.5A	-	Diagnosis voltage
13	-	-S13-	10A	-	Brake lights
14	-	-S14-	10A	-	Interior light
15	-	-S15-	5A	-	Dash panel insert, steering angle sender
16	-	-S16-	10A	-	Compressor

Toledo/León	Fitting Locations	No.  802 / 4

SEAT LEON 2004 Position of fuses in fuse holder, left dash panel

Position of fuses in fuse holder, left dash panel

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
17	-	-S17-	10A	-	Vacant (applicable up to October 2001) Taxi (applicable from November 2001)
18	-	-S18-	10A	-	Right headlight main beam
19	-	-S19-	10A	-	Left main beam
20	-	-S20-	15A	-	Right dipped beam
21	-	-S21-	15A	-	Left dipped beam
22	-	-S22-	5A	-	Side light right
23	-	-S23-	5A	-	Side light left
24	-	-S224-	20A	-	Windscreen wiper, washer pump
25	-	-S225-	25A	-	Heater blower
26	-	-S226-	25A	-	Heated rear window
27	-	-S227-	15A	-	Rear window wiper
28	-	-S228-	15A	-	Fuel pump
29	-	-S229-	10A	-	Diesel engine control unit
			15A	-	applicable up to October 2001: Petrol engine control unit
			15A	-	applicable from November 2001: Petrol engine control unit, not for AQN, AUE and BDE
			20A	-	applicable from November 2001: Engine control units AQN, AUE and BDE

Toledo/León	Fitting Locations	No.  802 / 5

Position of fuses in fuse holder, left dash panel

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
30	-	-S230-	20A	-	Electrical sunroof
31	-	-S231-	20A	-	Automatic gearbox - AG4
			5A	-	Haldex
32	-	-S232-	10A	-	Injectors (petrol)
			30A	-	Diesel engine control unit
33	-	-S233-	20A	-	Headlight washer system (HWS)
34	-	-S234-	10A	-	Diesel engine control unit
			10A	-	Petrol engine control unit
35	-	-S235-	30A	-	Caravan tow coupling delay, luggage compartment power socket
36	-	-S236-	15A	-	Rear fog lights
37	-	-S237-	10A	-	applicable up to October 2001: Signal S (ignition key)
			5A	-	applicable from November 2001: Diesel engine control unit
			20A	-	applicable from November 2001: Petrol engine control unit, not for AUE and BDE
			30A	-	applicable from November 2001: Engine control units AUE and BDE
38	-	-S238-	10A	-	Luggage compartment light, central locking
39	-	-S239-	15A	-	Hazard warning lights system

Toledo/León	Fitting Locations	No.  802 / 6

Position of fuses in fuse holder, left dash panel

No.		Current Flow Diagram designation	Nominal value		Function/component	Terminal
40	-	-S240-	20A	-	Horns
41	-	-S241-	15A	-	Cigarette lighter
42	-	-S242-	15A	-	Radio
43	-	-S243-	10A	-	Petrol engine control unit
			10A	-	Diesel engine control unit
44	-	-S244-	15A	-	Seat heater

Toledo/León	Fitting Locations	No.  802 / 7

Auxiliary fuse above additional relay carrier Right-handdrive vehicles A -  Seat adjustment fuse -S45- (30 A) B -  Vacuum pump fuse (20 A) C -  Window regulator fuse -S37- (30 A) D -  Fuel charging hole fuse -S323- (10 A) E -  Alarm horn fuse -S111- (15 A)  -  Turn signal fuse -S144- (15 A) F -  Taxi fuse (15 A) G -  Vacant H -  Vacant

Получить доступ ко всем электросхемам автомобиля

Left-handdrive vehicles: A -  Seat adjustment fuse -S45- (30 A) B -  Vacuum pump fuse (20 A) C -  Window regulator fuse -S37- (30 A) D -  Vacant E -  Taxi fuse (15 A) F -  Alarm horn fuse 1 -S111- (15 A)  -  Turn signal fuse -S144- (15 A) G -  Fuel charging hole fuse -S323- (10 A) H -  Vacant

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  802 / 8

SEAT LEON 2004 Fuse on fuse holder, next to battery (up to August 2000): Fuse on fuse holder, next to battery (up to August 2000): Fuses: S162 -  Glow plug heater 50 A S163 -  Engine control unit 50 A S164 -  Radiator fan 40 A S176 -  Passenger compartment, 110A S177 -  Alternator (90 A), 110 A  -  Alternator (120 A), 150 A S178 -  ABS (pump), 30 A S179 -  ABS, 30 A S180 -  Radiator fan 30 A

Получить доступ ко всем электросхемам автомобиля

Toledo/León	Fitting Locations	No.  802 / 9

SEAT LEON 2004 Fuse on fuse holder, next to battery (from September 2000): Fuse on fuse holder, next to battery (from September 2000): A -  Red wire, 16mm²

Fuses: S162 -  Glow plug heater 50 A S163 -  Engine control unit 50 A S164 -  Radiator fan 40 A S176 -  Passenger compartment, 110A S177 -  Alternator (90 A), 110 A  -  Alternator (120 A), 150 A S178 -  ABS (pump), 30 A S179 -  ABS, 30 A S180 -  Radiator fan 30 A

Получить доступ ко всем электросхемам автомобиля