AIR CONDITIONING – Chrysler Aspen Limited 2008 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Automatic A/C Wiring Diagram (1 of 2) for Chrysler Aspen Limited 2008

List of elements for Automatic A/C Wiring Diagram (1 of 2) for Chrysler Aspen Limited 2008:

• (on hvac unit, near breakout for c202) s188
• (rear hvac) s342
• (right end of hvac) front blower power module
• (right kick panel) g207
• 87a
• A/c heater control
• A/c select
• A925
• Auto hdlp sig
• C121
• C151
• C152
• C153
• C154
• C21
• C22
• C29
• C32
• C34
• C53
• C54
• C56
• C61
• C800
• C801
• C802
• C803
• C804
• C805
• C806
• C807
• C808
• Can b bus (+)
• Can b bus (-)
• Common door driver 2
• Common door driver 3
• Computer data lines system
• D54
• D55
• E12
• Ebl select
• Evap sens sig
• Fr blower motor relay out
• Fr common door drv
• Front blend door actuator (middle of hvac)
• Front blend door driver
• Front blower control
• Front blower motor (right end of hvac)
• Front blower motor relay
• Front blower switch
• Front mode door actuator (floor to defrost) (left end of hvac)
• Front mode door actuator (floor to panel) (left end of hvac)
• Front recirculation door actuator (right side of hvac)
• Fuse 13 15a
• Fuse 24 10a
• Fuse 7 40a
• Fused b (+)
• G114 (left front of engine compt)
• G139
• G39
• Ground
• High
• Hot at all times
• Hot w/ run remote relay energized
• Hvac micro controller
• Illumination
• Ilt- dimming hvac
• Interior lights system
• Junction block (left kick panel)
• L24
• Low
• Manual a/c circuit
• Med 1
• Med 2
• Medium
• Mode door 1 driver
• Mode door 2 driver
• Nca
• Off
• Power distribution center (left side of engine compt)
• Rear
• Rear blend door actuator (left side of rear hvac)
• Rear blend door driver
• Rear blend sense
• Rear blower motor (rear hvac)
• Rear blower motor relay
• Rear blower motor resistor block (rear hvac)
• Rear blower switch
• Rear blower- medium
• Rear blower-high
• Rear blower-low
• Rear common door drv
• Rear mode door actuator (middle of rear hvac)
• Rear mode door driver
• Rear wash/ wipe
• Recirc door driver
• S131
• S343 (rear hvac)
• Sensor ground
• Sun sens 2 sig
• Sun sens sig
• Z24
• Z928
• Z961

Automatic A/C Wiring Diagram (2 of 2) for Chrysler Aspen Limited 2008

List of elements for Automatic A/C Wiring Diagram (2 of 2) for Chrysler Aspen Limited 2008:

• (3.7l & 4.7l)
• (4.7l/3.7l: top right front of engine) (5.7l: lower left front of engine) a/c compressor clutch
• (5.7l)
• (center front of engine compt) ambient air temperature sensor
• (top rear of radiator fan shroud) a/c pressure transducer
• 4wd
• 87a
• A/c clutch relay (power distribution center)
• A/c clutch relay control
• A/c pressure sig
• A/c pressure sig c1
• Aat sig
• Auto head sig
• C13
• C18
• C83
• Can b (+)
• Can b (-)
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Condenser cooling fan module (behind radiator)
• D54
• D55
• D64
• D65
• Ect signal
• Electronic overhead module (front center of headliner)
• Engine controls system
• Engine coolant temperature sensor (4.7l: right front of engine) (3.7l: top right front of engine)
• Evaporator temperature sensor (right end of hvac)
• Fan rly ctrl
• Fcm sens return
• Fcm sens return ipm
• Front control module
• Front/rear washer fluid level sensor (left front of engine compt)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 40a
• Fused b(+)
• G100 (4.7l/3.7l: right side of engine compt) (5.7l: rear of right cylinder head)
• G112 (right front of engine compt)
• G180
• G306 (center of vehicle floor)
• G31
• G931
• Ground infrared sensor signal
• High
• Hot at all times
• Hot in run or start
• Ign (run-start)
• Infrared sens sig
• Infrared sensor (front of headliner)
• Integrated power module (left side of engine compt)
• Interior lights system
• Ipm
• Junction block (left kick panel)
• K900
• Low
• Medium
• Off
• Power distribution center (left side of engine compt)
• Powertrain control module (right side of engine compt)
• Radiator fan high relay
• Radiator fan low relay
• Radiator fan resistor (front center of engine compt)
• Rear a/c-heater control
• Rear blend sense
• Rear hvac controller
• S105 (3.7l: near breakout for map sensor) (4.7l: top front of engine)
• S117 (near breakout for left front impact sensor)
• S118 (near breakout for left front impact sensor)
• S119
• S219 (center of dash)
• S351
• Sens gnd
• Sensor ground
• Shift motor/mode sensor assembly (4.7l & 5.7l: left side of transmission)
• Sun sens 2 sig
• Sun sens sig
• Sun sensor (top right side of dash)
• T103

Manual A/C Wiring Diagram (1 of 2) for Chrysler Aspen Limited 2008

List of elements for Manual A/C Wiring Diagram (1 of 2) for Chrysler Aspen Limited 2008:

• (left kick panel) junction block
• (near breakout for g306)
• (near breakout for g306) s314
• (on hvac unit, near breakout for c202)
• (right end of hvac) front blower motor
• (right kick panel) g207
• 87a
• A/c select
• A/c-heater control
• Auto head sig
• C121
• C151
• C152
• C153
• C154
• C21
• C22
• C29
• C32
• C34
• C50
• C53
• C54
• C61
• C71
• C72
• C73
• C75
• C800
• C801
• C931
• Can b bus (+)
• Can b bus (-)
• Cluster
• Common door driver 1
• Computer data lines system
• D54
• D55
• E12
• Ebl select
• Evap temp sens sig
• F504
• Fr blend door driver
• Front blend door actuator (middle of hvac)
• Front blower motor relay
• Front blower motor resistor block (right end of hvac)
• Front blower switch
• Front control module
• Front mode door actuator (floor to defrost) (left end of hvac)
• Front mode door actuator (floor to panel) (left end of hvac)
• Front recirculation door actuator (right side of hvac)
• Frt blwr ctrl
• Fuse 24 10a
• Fuse 7 40a
• G114 (left front of engine compt)
• G207 (right kick panel)
• Ground
• High
• Hot at all times
• Hot w/ run remote relay energized
• Hvac micro controller
• Ign sw out (run)
• Illumination
• Integrated power module (left side of engine compt)
• Interior lights system
• Ipm
• Junction block (left kick panel)
• Low
• Med
• Med 1
• Med 2
• Mode door 1 driver
• Mode door 2 driver
• Nca
• Off
• Power distribution center (left side of engine compt)
• Rear
• Rear blend door actuator (left side of rear hvac)
• Rear blend door driver
• Rear blend sense
• Rear blend sense rtn
• Rear blower ctrl feed
• Rear blower motor (rear hvac)
• Rear blower motor relay
• Rear blower motor resistor block (rear hvac)
• Rear blower switch
• Rear common door driver
• Rear mode door actuator (middle of rear hvac)
• Rear mode door driver
• Rear wash/ wipe
• Recirc door driver
• Run remote relay
• S111
• S131
• S188
• S313
• S342 (rear hvac)
• S343 (rear hvac)
• S359
• Sensor ground
• Sun sens rtn
• Sun sensor (top right side of dash)
• W/ remote start
• Z24
• Z928
• Z961

Manual A/C Wiring Diagram (2 of 2) for Chrysler Aspen Limited 2008

List of elements for Manual A/C Wiring Diagram (2 of 2) for Chrysler Aspen Limited 2008:

• (3.7l & 4.7l)
• (4.7l/3.7l: top right front of engine) (5.7l: lower left front of engine) a/c compressor clutch
• (5.7l)
• (center front of engine compt) ambient air temperature sensor
• 4wd
• 87a
• A/c clutch relay (power distribution center)
• A/c clutch relay control
• A/c pressure sig
• A/c pressure sig c1
• A/c pressure transducer (top rear of radiator fan shroud)
• Aat sig
• C13
• C18
• C83
• Can b (+)
• Can b (-)
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Condenser cooling fan module (behind radiator)
• D54
• D55
• D64
• D65
• Ect signal
• Electronic overhead module (front center of headliner)
• Engine controls system
• Engine coolant temperature sensor (4.7l: right front of engine) (3.7l: top right front of engine)
• Evaporator temperature sensor (right end of hvac)
• Fan rly ctrl
• Fcm sens return
• Fcm sens return ipm
• Front control module
• Front/rear washer fluid level sensor (left front of engine compt)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 40a
• Fused b(+)
• G100 (4.7l/3.7l: right side of engine compt) (5.7l: rear of right cylinder head)
• G112 (right front of engine compt)
• G180
• G306 (center of vehicle floor)
• G31
• G931
• Ground
• High
• Hot at all times
• Hot in run or start
• Ign (run-start)
• Infrared sens sig
• Infrared sensor (front of headliner)
• Integrated power module (left side of engine compt)
• Interior lights system
• Ipm
• Junction block (left kick panel)
• K900
• Low
• Medium
• Off
• Power distribution center (left side of engine compt)
• Powertrain control module (right side of engine compt)
• Radiator fan high relay
• Radiator fan low relay
• Radiator fan resistor (front center of engine compt)
• Rear a/c-heater control
• Rear blend sense
• Rear blend sense return
• Rear hvac controller
• S117 (near breakout for left front impact sensor)
• S118 (near breakout for left front impact sensor)
• S119
• S351
• Sens gnd
• Sensor ground
• Sensor signal
• Shift motor/mode sensor assembly (4.7l & 5.7l: left side of transmission)
• T103