AIR CONDITIONING – Ford Freestar SEL 2007 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Automatic A/C Wiring Diagram (1 of 2) for Ford Freestar SEL 2007

List of elements for Automatic A/C Wiring Diagram (1 of 2) for Ford Freestar SEL 2007:

• (in heater blower motor harness, near breakout to c212) s234
• (in main harness, near breakout to joint connector 1) s202
• (right kick panel) g201
• A/c clutch req
• Ambient air temperature sensor (at right front side of engine compt)
• Ambient temp rtn(-)
• Ambient temp sns(+)
• Autolamp/ sunload sensor (near top center of dash)
• Blend dr close
• Blend dr feed
• Blend dr open
• Blower req
• Breakout for c214)
• Bussed electrical center (bec) (at left side of engine compt)
• C1035d a5
• C2280a
• C2280b
• C2280c
• C2280h
• C228a
• C228b
• Climate illum
• Computer data lines system
• Defrost feed
• Driver temperature blend door actuator (behind left side of dash)
• Electronic automatic temperature control (eatc) module (behind center of dash)
• Fresh/recirculation door actuator (behind center of dash)
• Front blower motor (behind right side of dash)
• Front blower motor relay (left kick panel)
• Front blower motor speed controller (behind right side of dash)
• Front blower out
• Frt hvac blwr
• Fuse 10a
• Fuse 30a
• Fuse 5a
• G301 (left kick panel)
• Ground
• Headlights system
• Heat/cool seat
• Hi htd seat
• Hot at all times
• Hot in run
• Htd seat req
• In-vehicle temperature sensor (behind left side of dash)
• Instrument cluster system
• L sunload sens
• Lo htd seat
• Low current board
• Mode actuator
• Mode door actuator (behind center of dash)
• P/fl/def close
• P/fl/def open
• Passenger temperature blend door actuator (behind right side of dash)
• Pnk
• R sunload sens
• Rear def req
• Rear defog ind
• Rear defog sw
• Recirc dr close
• Recirc dr open
• Rr def status
• S201 (in main harness, in breakout to c214)
• S203 (in main harn, near breakout to passenger airbag module)
• S228 (in main harness, near breakout to joint connector 1)
• S229 (in main harness, near breakout to front blower motor resistor assembly)
• S235 (in heater blower motor harness, near breakout to c212)
• Scp sig a (-)
• Scp sig b (+)
• Seat lo status
• Seats systems
• Shift interlock system
• Sjb-illum
• Smart junction box (sjb) (behind left side of dash)
• Sound systems
• Temp sens
• Temp sens gnd
• V-ign
• Vbatt
• Vbc output
• Vref actuator
• Vref mode rtn
• Vref rtn (gnd)

Automatic A/C Wiring Diagram (2 of 2) for Ford Freestar SEL 2007

List of elements for Automatic A/C Wiring Diagram (2 of 2) for Ford Freestar SEL 2007:

• (in dash to headlight junction harness, near breakout to c1024) s113
• (left front side of engine compt) g101
• 87a
• A/c cl cycl & hi press cutout input
• A/c clutch cycling pressure switch (at right side of engine compt, on a/c accumulator)
• A/c clutch field coil (on a/c compressor)
• A/c clutch relay
• A/c compressor clutch diode
• A/c cutout relay
• A/c hi press cutout input
• A/c pressure transducer sensor
• A10
• A11
• Auxiliary relay box 1 (right front of engine compt)
• Bussed electrical center (bec) (at left side of engine compt)
• C1035a
• C1035b
• C1035c
• C1035c f7
• C11 c1035b
• Chts
• Cool fan ctrl
• Cylinder head temperature sensor (rear of left cylinder head)
• D11
• Dropping resistor (left front of engine compt)
• E11
• Engine controls system
• Engine cooling fan circuit breaker
• Engine cooling fan motor 1 (behind left side of radiator)
• Engine cooling fan motor 2 (behind right side of radiator)
• Engine cooling fan relay 1
• Engine cooling fan relay 2
• Engine cooling fan relay 3
• Engine cooling fan relay 4
• Engine cooling fan relay 5
• F11
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 40a
• G107 (right front of engine compt)
• Ground distribution system
• Hot at all times
• Hot in start or run
• Powertrain control module (pcm) (right rear of engine compt)
• Red
• Ref volt
• S102 (in engine control sensor & fuel charge harness, near breakout for g104)
• S106 (in engine control sensor & fuel charge harness, near breakout for g104)
• Sig rtn
• Tan/red
• W/ trailer tow
• W/o trailer tow

Manual A/C Wiring Diagram (1 of 2) for Ford Freestar SEL 2007

List of elements for Manual A/C Wiring Diagram (1 of 2) for Ford Freestar SEL 2007:

• (at left side of engine compt)
• (behind center of dash)
• (in heater blower motor harness, near breakout to c212) s235
• (in main harness, near breakout for joint connector 1) s202
• (left front side of engine compt) g101
• A/c clutch cycling pressure switch (at right side of engine compt, on a/c accumulator)
• A/c clutch field coil (on a/c compressor)
• A/c clutch relay
• A/c clutch req
• A/c compressor clutch diode
• A/c pressure transducer sensor
• A10
• Blend dr close
• Blend dr feed
• Blend dr open
• Bussed electrical center (bec)
• C1035a
• C1035b
• C1035c
• C2280a
• C2280b
• C2280c
• C2280h
• C294a
• C294b
• C294c
• Computer data lines system
• D11
• Driver temperature blend door actuator (behind left side of dash)
• Drv htd seat
• Drv htd seat hi
• Drv htd seat lo
• Electronic manual temperature control (emtc) module
• Fr bl rly out
• Fr blower req
• Fr hvac bl sw
• Fresh/ recirculation door actuator (behind center of dash)
• Front blower motor (behind right side of dash)
• Front blower motor relay (left kick panel)
• Front blower motor resistor assembly (behind right side of dash)
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G201 (right kick panel)
• G301 (left kick panel)
• Ground
• Ground distribution system
• High
• Hot at all times
• Hot in run
• Hot in start or run
• Illum
• Instrument cluster system
• Low
• Low current board
• Mode door actuator (behind center of dash)
• P/fl/def close
• P/fl/def feed
• P/fl/def open
• Pas htd seat
• Pas htd seat hi
• Pas htd seat lo
• Passenger temperature blend door actuator (behind right side of dash)
• Pnk
• Rear def req
• Rear def status
• Recirc dr close
• Recirc dr open
• Rr def ind
• Rr wdo def sw
• S200 (in main harness, near breakout to c214)
• S201 (near main harness, in breakout to c214)
• S229 (in main harness, near breakout to front blower motor resistor assembly)
• Scp+
• Scp-
• Seats systems
• Shift interlock system
• Smart junction box (sjb) (behind left side of dash)
• Sound systems
• Tan/red
• V-batt
• V-ign
• Vref
• Vref mode act
• Vref mode rtn
• Vref rtn

Manual A/C Wiring Diagram (2 of 2) for Ford Freestar SEL 2007

List of elements for Manual A/C Wiring Diagram (2 of 2) for Ford Freestar SEL 2007:

• (in dash to headlight junction harness, near breakout to c1024) s113
• (in engine control sensor & fuel charge harness, near breakout to g104)
• (left front side of engine compt) g101
• (right front of engine compt) g107
• 87a
• A/c cl cyc & hi press cutout in
• A/c cutout relay
• A/c hi pres cutout in
• A11
• Auxiliary relay box 1 (right front of engine compartment)
• Bussed electrical center (bec) (at left side of engine compartment)
• C1035b c11
• Chts
• Cylinder head temperature sensor (rear of left cylinder head)
• Dropping resistor (left front of engine compt)
• E11
• Engine cooling fan circuit breaker
• Engine cooling fan motor 1 (behind left side of radiator)
• Engine cooling fan motor 2 (behind right side of radiator)
• Engine cooling fan relay 1
• Engine cooling fan relay 2
• Engine cooling fan relay 3
• Engine cooling fan relay 4
• Engine cooling fan relay 5
• F11
• F7 c1035c
• Fan ctrl
• Fuse 15a
• Fuse 30a
• Fuse 40a
• G107 (right front of engine compt)
• Hot at all times
• Hot in start or run
• Powertrain control module (pcm) (right rear of engine compartment)
• Red
• Ref volt
• S102
• S106 (in engine control sensor & fuel charge harness, near breakout to g104)
• Sig rtn
• Tan/red
• W/ trailer tow
• W/o trailer tow

Rear A/C Wiring Diagram for Ford Freestar SEL 2007

List of elements for Rear A/C Wiring Diagram for Ford Freestar SEL 2007:

• (behind panel, left of rear seat) auxiliary blower motor resistor assembly
• (in a/c blower motor harness, near breakout to c315) s345
• (in interior lamps harness, near breakout to rear integrated control panel) s901
• (in interior lamps harness, near breakout to rear integrated control panel) s902
• (n body main harness, near breakout to left side power sliding door module) s310
• Aux air blend mtr close
• Aux air blend mtr open
• Aux air blend pos
• Aux air blend ref
• Aux air blend rtn
• Aux blwr rly out
• Aux blwr speed rly 1
• Aux blwr speed rly 2
• Aux blwr speed set
• Aux head vref
• Aux mode mtr close
• Aux mode mtr open
• Aux mode pos
• Aux mode trn
• Aux vref (pos)
• Auxiliary blower motor (behind panel, left of rear seat)
• Auxiliary blower motor relay
• Auxiliary blower relay module (left rear of vehicle, behind trim panel)
• Auxiliary blower speed relay 1
• Auxiliary blower speed relay 2
• Blower
• Bussed electrical center (bec) (at left side of engine compt)
• C2280c
• C2280d
• C2280f
• C2280h
• Dvd/ohc/rr hvac
• F4 c1035a
• Fuse 30a
• Fuse 5a
• G201 (right kick panel)
• G400 (at left ``d" pillar)
• Hot at all times
• Ill gnd
• Ill+
• Rear aux rtn
• Rear blend door actuator (above left rear wheelwell)
• Rear integrated control panel (ricp)
• Rear mode door actuator (above left rear wheelwell)
• Return
• Rr temp mode set
• S344 (in a/c blower motor harness, in breakout to c3172)
• S346 (in a/c blower motor harness, near breakout to c3121)
• Smart junction box (sjb) (behind left side of dash)
• Temp
• Trunk, tailgate, fuel doors system
• V-ref