AIR CONDITIONING – Mitsubishi Lancer Ralliart 2004 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Manual A/C Wiring Diagram, Evolution (1 of 2) for Mitsubishi Lancer Ralliart 2004

List of elements for Manual A/C Wiring Diagram, Evolution (1 of 2) for Mitsubishi Lancer Ralliart 2004:

• (behind instrument cluster)
• A/c ecu
• A/c switch, outside/inside air selection damper control & illumination
• A17
• A17-1
• Air thermo sensor (behind right center of of dash, on hvac unit)
• Blower motor (behind right end of dash)
• Blower relay
• Blower switch
• C210
• C211
• C214
• Cooling fan motor
• Defogger system
• Fan control module (on fan shroud, at left front of engine compt)
• Fuse 30a
• Fuse 7.5a
• G13 (at left front corner of engine compartment)
• G3 (at right side of front deck crossmember)
• G6 (behind center of dash, near left center reinforcement)
• G7 (at top left side of dash)
• Hot at all times
• Hot in on
• Inlet side
• Interior lights system
• Joint connector 2
• Joint connector 3 (behind right side of dash)
• Junction block (behind left end of dash)
• Nca
• Off
• Outlet side
• Outside/inside air selection damper control motor (behind upper right end of dash)
• Pnk
• Resistor (behind right side of dash, on hvac unit)

Manual A/C Wiring Diagram, Evolution (2 of 2) for Mitsubishi Lancer Ralliart 2004

List of elements for Manual A/C Wiring Diagram, Evolution (2 of 2) for Mitsubishi Lancer Ralliart 2004:

• (on engine compt relay box)
• (on left side of engine compt) engine compartment relay box
• A/c compressor
• A/c compressor clutch
• A/c compressor control relay
• A/c refrigerant temperature switch
• A34
• A35
• C115
• C119
• C121
• Condenser fan control relay (high) (on engine compt relay box)
• Condenser fan control relay (low)
• Condenser fan motor (mounted on rear of radiator)
• Dual pressure switch (on right side of engine compartment)
• Engine compartment relay box (on left side of engine compt)
• Engine control module (behind glove box)
• Engine controls system
• Engine coolant temperature sensor (on rear of cylinder head)
• Fan control relay
• Fuse 10a
• Fuse 20a
• Fuse 30a
• Fuse 7.5a
• Fusible link 2 50a
• G13 (at left front corner of engine compartment)
• G13 (at left front corner of engine compt)
• Headlights, exterior lights & wiper/washer systems
• High pressure side on-off: 2940 kpa off-on: 2350 kpa
• Hot at all times
• Hot w/ taillight relay energized
• Joint connector 1 (behind center of dash)
• Joint connector 6 (behind lower center of dash)
• Low pressure side on-off: 196 kpa off-on: 221 kpa
• Mfi relay
• Nca
• Off
• Pnk
• Red

Manual A/C Wiring Diagram, Except Evolution (1 of 2) for Mitsubishi Lancer Ralliart 2004

List of elements for Manual A/C Wiring Diagram, Except Evolution (1 of 2) for Mitsubishi Lancer Ralliart 2004:

• (behind instrument cluster)
• A/c ecu (behind center of dash, below radio)
• A17
• A17-1
• A17-2
• A18
• A18-1
• A18-2
• Air thermo sensor (behind right center of of dash, on hvac unit)
• Blower motor (behind right end of dash)
• Blower relay
• Blower switch
• C210 c211
• C211 c212
• C214 c215
• Condenser fan motor (mounted on rear of radiator)
• Defogger system
• Fan control module (on fan shroud, at left front of engine compartment)
• Fuse 30a
• Fuse 7.5a
• G12 (sportback) (at left front of engine compartment, left of battery)
• G13 (lancer) (at left front corner of engine compartment)
• G3 (under right front kick panel)
• G5 (sportback) (on center tunnel, right of accelerator pedal)
• G6 (lancer) (behind center of dash, near left center reinforcement)
• Heater control panel & illumination
• Hot at all times
• Hot in on
• Inlet side
• Interior lights system
• Joint connector 2
• Joint connector 3 (behind right side of dash)
• Junction block (behind left end of dash)
• Lancer
• Lancer sportback
• Nca
• Off
• Outlet side
• Outside/inside air selection damper control motor (behind upper right end of dash)
• Radiator fan motor
• Resistor (behind right side of dash, on hvac unit)
• Sportback

Manual A/C Wiring Diagram, Except Evolution (2 of 2) for Mitsubishi Lancer Ralliart 2004

List of elements for Manual A/C Wiring Diagram, Except Evolution (2 of 2) for Mitsubishi Lancer Ralliart 2004:

• 2.0l a/t
• 2.0l m/t
• 2.4l
• 2.4l a/t
• 2.4l m/t
• A/c compressor assembly
• A/c compressor clutch
• A/c compressor clutch relay
• A/c refrigerant temperature switch (on-off: 150 degrees centigrade) (off-on: 120 degrees centigrade)
• C111
• C112
• C113
• C114
• C115
• C116
• C118
• C119
• C120
• C121
• C133
• C134
• C135
• C136
• C137
• C138
• C139
• C140
• Dual pressure switch (on right front of engine compt)
• Engine compartment relay box (on left side of engine compartment)
• Engine compartment relay box (on left side of engine compt)
• Engine controls system
• Engine coolant temperature sensor (on rear of cylinder head)
• Exterior lights system
• Fan control relay
• Fuse 10a
• Fuse 20a
• Fuse 7.5a
• Fusible link 2 50a
• G12 (sportback) (at left front of engine compt, left of battery)
• G13 (lancer) (at left front corner of engine compt)
• High pressure side on-off: 3138 kpa off-on: 2550 kpa
• Hot at all times
• Hot w/ taillight relay energized
• Joint connector 1 (behind center of dash)
• Joint connector 6 (behind lower center of dash)
• Lancer
• Low pressure side on-off: 196 kpa off-on: 221 kpa
• Mfi relay
• Nca
• Off
• Pnk
• Powertrain control module (a/t) engine control module (m/t) (behind glove box)
• Red
• Sportback