AIR CONDITIONING – Toyota RAV4 EV 2014 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Automatic A/C Wiring Diagram, EV (1 of 5) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, EV (1 of 5) for Toyota RAV4 EV 2014:

• (behind left side of front grille) cooler (ambient temperature sensor) thermistor
• (right end of dash) j/c a65
• (right rear of motor compt) a/c pressure sensor (suction pipe sub-assembly)
• A/c amplifier (lower center of dash)
• A/c blower assembly
• A/c evaporator temperature sensor
• Ae6
• Ae7
• B bus
• Blw
• Bus
• Bus g
• Canh
• Canl
• Computer data lines system
• Connector housing color (black)
• Connector housing color (green)
• Connector housing color (red)
• Damper servo motor (air inlet)
• Damper servo motor (air vent mode)
• Damper servo motor (driver side air mix)
• Damper servo motor (front passenger's side air mix)
• Defogger system
• E36
• Gnd
• Ig+
• Lin1
• Pnk
• Pre
• Ptc1
• Ptc2
• Ptc3
• Rdfg
• Red
• S5-1
• S5-3
• S5-4
• Sg-1
• Sg-2
• Sg-4
• Sga
• Tam
• Tea
• Tsd
• Tsp
• Z10

Automatic A/C Wiring Diagram, EV (2 of 5) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, EV (2 of 5) for Toyota RAV4 EV 2014:

• A/c-b fuse 7.5a
• A54
• A70
• B31
• B66
• Blower motor w/ fan sub-assembly (bottom of blower housing)
• Cooler (room temperature sensor) thermistor (lower left center of dash)
• Cooler (solar sensor) thermistor (top left center of dash)
• E1 (left kick panel)
• E17
• E4 (right kick panel)
• E5 (right side of dash)
• Ef1
• Gnd
• Hot at all times
• Htr fuse 50a
• Humidity sensor (air conditioning thermistor assembly) (center front of roof)
• Instrument panel j/b (left end of dash)
• J/b 6 (right center of dash)
• Motor compartment r/b 2 (right side of motor compt)
• Pe1
• Pnk
• Red
• S5v
• Seg3
• Short pin
• Tfg
• Tng

Automatic A/C Wiring Diagram, EV (3 of 5) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, EV (3 of 5) for Toyota RAV4 EV 2014:

• 5v ic
• 5v+b
• A4 (right front of motor compt)
• A45
• A53
• A54
• A6 (right end of dash)
• Can controller
• Can i/f
• Canh
• Canl
• Combination meter assembly
• Computer data lines system
• Cpu
• E5 (right side of dash)
• Eco ind
• Hot at all times
• Ig+
• Led driver
• Motor compartment r/b 2 (right side of motor compt)
• Ptc htr 1 fuse 50a
• Ptc htr 2 fuse 50a
• Ptc htr 3 fuse 50a
• Ptc relay 1
• Ptc relay 2
• Ptc relay 3
• Quick heater assembly
• Red

Automatic A/C Wiring Diagram, EV (4 of 5) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, EV (4 of 5) for Toyota RAV4 EV 2014:

• A/c amplifier (lower center of dash)
• A/c control assembly
• A/c-igct fuse 10a
• A1 (left front of motor compt)
• A3 (right front of motor compt)
• A62
• Acc
• Acc-b fuse 7.5a
• Ad1
• Ae10
• Ae7
• Air bag on/off ind
• B39
• B40
• Battery coolant heater (rear of motor compt)
• Battery coolant temperature sensor (left side of traction motor assembly)
• Bct
• Bctg
• Circulation heater assembly
• Clk
• Compressor w/ bracket assembly (front of traction motor assembly)
• Computer data lines system
• D15
• Da1
• Dc/dc converter (right side of traction motor assembly)
• Din
• Door locks system
• Dout
• E116
• E4 (right kick panel)
• Ecu ig1 1 fuse 10a
• El2
• Gauge fuse 7.5a
• Gnd
• Gnd 1
• Heater bracket sub- assembly
• Hot w/ acc relay energized
• Hot w/ ig1 relay energized
• Hot w/ ig2 relay energized
• Hot w/ igct 3 relay energized
• Ig+
• Ig1
• Ill+
• Ill-
• Instrument panel j/b (left end of dash)
• Interior lights system
• J/b 6 (right center of dash)
• J/c e131 (right end of dash)
• J/c e133 (center of dash)
• L30
• L32
• Lin1
• Motor compartment r/b & motor compartment junction block (left side of motor compt)
• Navigation & sound systems
• P-ab
• Paon
• Pnk
• Pwr
• Rear window defogger switch
• Red
• Rmi
• Seat heater switch
• Seats system
• Security ind
• Sg-5
• Sg-6
• Shd+
• Shield
• Shp+
• Stbi
• Sync
• Tfg
• Thermal control ecu (behind right quarterpanel)
• Thw
• Tng
• Tsch
• Tscl
• Tsl
• Tsr
• Z11

Automatic A/C Wiring Diagram, EV (5 of 5) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, EV (5 of 5) for Toyota RAV4 EV 2014:

• +b1
• +b2
• A3 (right front of motor compt)
• A31
• A32
• A56
• Ad2
• Ae1
• Ca2h
• Ca2l
• Clk
• Computer data lines system
• Cooler expansion valve (center rear of motor compt)
• D2 (left rear of traction motor assembly)
• Da2
• E02
• E117
• E118
• E3 (left center of dash)
• Ethb
• Eti
• Fan 1 fuse 50a
• Fan 2 fuse 50a
• Fan relay 1
• Fan relay 2
• Fctl
• Hot at all times
• Hot w/ igct 3 relay energized
• Hpmv
• Igct fan fuse 7.5a
• Ite
• J/c a39 (right side of motor compt)
• Left cooling fan ecu (behind left side of battery coolant cooling radiator)
• Left cooling fan motor (behind left side of battery coolant cooling radiator)
• Lpmv
• Motor compartment r/b & motor compartment junction block (left side of motor compt)
• Motor compartment r/b 2 (right side of motor compt)
• Opm2
• Power management control ecu (right side of dash)
• Red
• Right cooling fan ecu (behind right side of battery coolant cooling radiator)
• Right cooling fan motor (behind right side of battery coolant cooling radiator)
• Service valve 2 (right rear of motor compt)
• Si2
• Sio
• Stb
• Thb
• Thermistor assembly (left front of motor compt)
• Vlo

Automatic A/C Wiring Diagram, Except EV (1 of 3) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, Except EV (1 of 3) for Toyota RAV4 EV 2014:

• (right rear of engine compt) a/c pressure sensor (liquid pipe sub-assembly)
• 2wd
• 4wd
• A/c amplifier assembly (lower center of dash)
• A/c blower assembly (a/c harness assembly)
• A/c evaporator temperature sensor
• Ag1
• Ag4
• B bus
• Blw
• Bus
• Bus g
• Canh
• Canl
• Cds fan fuse 30a
• Combination switch assembly
• Computer data lines system
• Connector housing color (black)
• Connector housing color (green)
• Connector housing color (red)
• Damper servo motor (air inlet)
• Damper servo motor (air mix driver side)
• Damper servo motor (air mix front passenger's side)
• Damper servo motor (air vent mode)
• Defogger system
• Eco mode switch (if equipped)
• Ecos
• Ecu-b1 fuse 10a
• Ecu-b2 fuse 10a
• Engine room r/b (left side of engine compt)
• G81
• Gd (center of dash)
• Gnd
• Hot at all times
• Htr fuse 50a
• Ig+
• J/c 5 (center of dash)
• J/c 7 (center of dash)
• J/c 9 (center of dash)
• Lin1
• Lock
• Mgc
• Pnk
• Pre
• Ptc htr 1 fuse 30a
• Ptc htr 2 fuse 30a
• Ptc1
• Ptc2
• Rdfg
• Rdi fan fuse 30a
• Red
• S5-3
• Sg-2
• Sg-i
• Sga
• Short pin
• Sol+
• Tea
• Tsd
• Tsp

Automatic A/C Wiring Diagram, Except EV (2 of 3) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, Except EV (2 of 3) for Toyota RAV4 EV 2014:

• (2wd) mg/clt relay
• 2wd
• A31
• A32
• A44
• Ae (right end of dash)
• Ag4
• Ag8
• Automatic light control sensor (top left of dash)
• B30
• B68
• Ba1
• Ba3
• Bb (left rear of engine)
• Blower assembly
• Cltb
• Clte
• Clts
• Compressor w/ pulley assembly (lower left front of engine)
• Cooler thermistor (room temperature sensor) (lower left center of dash)
• Engine room r/b 2 (right side of engine compt)
• Fan relay 1
• Fan relay 2
• Fan relay 3
• Gd (center of dash)
• Gnd
• Mg+
• Pnk
• Ptc htr relay 1
• Ptc htr relay 2
• Quick heater assembly (lower front of hvac unit)
• Red
• Sol+
• Sol-
• Solar sensor
• Ssr+
• Ssr-
• Tsl
• Tsr

Automatic A/C Wiring Diagram, Except EV (3 of 3) for Toyota RAV4 EV 2014

List of elements for Automatic A/C Wiring Diagram, Except EV (3 of 3) for Toyota RAV4 EV 2014:

• (if equipped) eco mode ind
• (left side of engine compt) ecm (engine control module)
• 5v ic
• 5v+b
• A/c control assembly
• A62
• Ac (right front of engine compt)
• Acc
• Acc fuse 7.5a
• Ag1
• Ag4
• B16
• B19
• B25
• B77
• Becu
• C15
• Can controller
• Can i/f
• Canh
• Canl
• Cltb
• Clte
• Clts
• Combination meter assembly
• Computer data lines system
• Cooler thermistor (ambient temperature sensor) (behind left side of front grille)
• Cooling fan motor (behind left side of radiator)
• Cooling fan motor 2 (behind right side of radiator)
• Cpu
• D15
• D36
• D40
• Driver
• Ecu ig 2 fuse 7.5a
• Ecu ig 3 fuse 7.5a
• Efi engine coolant temperature sensor (left rear of engine)
• Ethw
• Fanh
• Fanl
• G16
• G78
• Ga (left kick panel)
• Gnd
• Gnd1
• Hot in on or start
• Hot w/ accessory relay energized
• Hot w/ ig1 relay 1 energized
• Hot w/ ig2 relay energized
• Htr ig fuse 7.5a
• I/f
• Ig+
• Ill+
• Ill-
• Instrument panel j/b (left end of dash)
• Interior lights system
• J/c 6 (center of dash)
• J/c 8 (center of dash)
• Led
• Lin1
• Main body ecu (left end of dash)
• Meter fuse 5a
• Rear window defogger switch
• Red
• Thw
• Tx1+
• Tx1-

Manual A/C Wiring Diagram (1 of 4) for Toyota RAV4 EV 2014

List of elements for Manual A/C Wiring Diagram (1 of 4) for Toyota RAV4 EV 2014:

• 2wd
• 4wd
• A/c
• A/c amplifier assembly (lower center of dash)
• A/c pressure sensor (liquid pipe sub-assembly) (right rear of engine compt)
• Ag4
• Blower resistor (near blower motor)
• Blower switch
• Canh
• Canl
• Cds fan fuse 30a
• Combination switch assembly
• Computer data lines system
• Cooler thermistor 1 (evaporator temperature sensor) (lower left side of hvac evaporator assembly)
• Defogger system
• Eco mode switch (if equipped)
• Ecos
• Engine room r/b (left side of engine compt)
• Gd (center of dash)
• Gnd
• Heat
• Heater control sub- assembly
• Hot at all times
• Htr fuse 50a
• Ig+
• Ill+
• Ill-
• Interior lights system
• J/c 10 (usa 4wd 4 speaker w/o parking assist) j/c 9 (except usa 4wd 4 speaker w/o parking assist) (center of dash)
• J/c 5 (center of dash)
• Led
• Lock
• Mgc
• Pre
• Ptc htr 1 fuse 30a
• Ptc htr 2 fuse 30a
• Ptc1
• Ptc2
• Rdef
• Rdi fan fuse 30a
• Rear window defogger switch
• Red
• S5-3
• Sblw
• Sg-1
• Sg-2
• Sol+
• Timer circuit

Manual A/C Wiring Diagram (2 of 4) for Toyota RAV4 EV 2014

List of elements for Manual A/C Wiring Diagram (2 of 4) for Toyota RAV4 EV 2014:

• (2wd) mg/clt relay
• 2wd
• Ac (right front of engine compt)
• Ag4
• B30
• B68
• Ba1
• Ba3
• Bb (left rear of engine)
• Blower damper servo sub assembly 1
• Compressor w/ pulley assembly (lower left front of engine)
• Cooling fan motor (behind left side of radiator)
• Cooling fan motor 2 (behind right side of radiator)
• Engine room r/b 2 (right side of engine compt)
• Fan relay 1
• Fan relay 2
• Fan relay 3
• Frs
• Ig+
• Mg+
• Pnk
• Ptc htr relay 1
• Ptc htr relay 2
• Rec
• Red
• Sol+
• Sol-
• Ssr+
• Ssr-

Manual A/C Wiring Diagram (3 of 4) for Toyota RAV4 EV 2014

List of elements for Manual A/C Wiring Diagram (3 of 4) for Toyota RAV4 EV 2014:

• (center of dash) j/c 8
• (right front of engine compt) ac
• A/c
• A/c switch
• A31
• A32
• Ae (right end of dash)
• Ag4
• Ag8
• Aind
• B19
• B25
• Blower motor (right side of dash)
• D15
• D36
• Ecu ig 3 fuse 7.5a
• Engine room r/b (left side of engine compt)
• Except usa 4wd 4 speaker w/o parking assist
• Heater control sub-assembly 3
• Heater relay
• Hot in on or start
• Hot w/ ig1 relay 1 energized
• Hot w/ ig2 relay energized
• Htr ig fuse 7.5a
• Ill+
• Ill-
• Instrument panel j/b (left end of dash)
• Interior lights system
• J/c 10 (center of dash)
• J/c 11 (center of dash)
• Max hot switch
• Meter fuse 5a
• Pnk
• Quick heater assembly (lower front of hvac unit)
• Red
• Usa 4wd 4 speaker w/o parking assist

Manual A/C Wiring Diagram (4 of 4) for Toyota RAV4 EV 2014

List of elements for Manual A/C Wiring Diagram (4 of 4) for Toyota RAV4 EV 2014:

• (if equipped) eco mode ind
• 5v ic
• 5v+b
• A/c+
• A62
• Acid
• Ag1
• Air inlet control switch
• B77
• Can controller
• Can i/f
• Canh
• Canl
• Combination meter assembly
• Computer data lines system
• Cooler thermister (ambient temperature sensor) (behind left side of front grille)
• Cpu
• Def
• Driver
• Ecm (engine control module) (left side of engine compt)
• Efi engine coolant temperature sensor (left rear of engine)
• Ethw
• Fanh
• Fanl
• Free
• Frs
• G16
• Ga (left kick panel)
• Heater control sub assembly 1
• I/f
• Ig+
• Ill+
• Ill-
• Interior lights system
• Led
• Led+
• Lock
• Mode control switch
• Pnk
• Rec
• Red
• Thw
• Tx1+
• Tx1-