All Wiring Diagrams for Dodge Cab & Chassis R2002 2500 model

AIR CONDITIONING

Heater Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Heater Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (dash panel right center support) g201
• (left fender side shield) g102
• Bi-level
• Blower motor (behind right side of dash)
• Blower motor relay
• Blower motor resistor block (behind right side of dash, on a/c-heater housing)
• Blower motor speed switch
• Defrost
• Floor
• Floor/defrost
• Fuse 10a
• Fuse 40a
• Heater control
• High
• Hot at all times
• Hot in run
• Illum
• Interior lights system
• J/c 1
• J/c 8 (behind center of dash)
• Junction block (left end of dash)
• Low
• Med 1
• Med 2
• Mode select switch
• Off
• Panel
• Power distribution center (in engine compartment, on left inner fender panel, near battery)
• S207 (dash harness, near blower motor)
• Tan

Manual A/C Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Manual A/C Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (dash harness, near blower motor) s207
• (dash panel right center support) g201
• (engine harn., near break- out to fuel injectors) (8 cyl)
• (engine harness, near fuel transfer pump) s164
• (engine harness, top of transmission) (8 cyl) s122 (1o cyl) (engine harness, in breakout to transmission)
• (front of engine) g105
• (headlamp & dash harness, in power distribution center) s105
• (left fender side shield) g102
• (left rear of engine) g107
• A/c compressor clutch
• A/c compressor clutch relay
• A/c heater control
• A/c heater temperature select
• A/c high pressure switch (on discharge line, near a/c compressor)
• A/c low pressure switch (on top of a/c accumulator)
• A/c select input
• A/c switch sense
• A/c-high
• A/c-low
• A/c-med 1
• A/c-med 2
• Bi- level
• Blend door actuator
• Blower motor (behind right side of dash)
• Blower motor relay
• Blower motor resistor block (behind right side of dash, on a/c-heater housing)
• Blower motor speed switch
• C13
• C20
• C90
• Defrost
• Diesel
• Floor
• Floor/defrost
• Fuse 10a
• Fuse 40a
• Fuse j 10a
• Gasoline
• Ground
• Heater-high
• Heater-low
• Heater-med 1
• Heater-med 2
• High
• Hot at all times
• Hot in run
• Hot in run or start
• Ignition
• Illum
• Interior lights system
• J/c 1
• J/c 8 (behind center of dash)
• Junction block (left end of dash)
• Low
• Med 1
• Med 2
• Mode select switch
• Off
• Panel
• Power distribution center (in engine compartment, on left inner fender panel, near battery)
• Powertrain control module (pcm) (in engine compartment, on right side of firewall)
• Recirc
• Relay ctrl
• S120 (10 cyl (1), diesel (2)) ((1) engine harness, rear of engine) ((2) transmission harness, near breakout to a/c low pressure switch)
• Tan
• Temp select

ANTI-LOCK BRAKES

Anti-lock Brake Wiring Diagrams for Dodge Cab & Chassis R2002 2500

List of elements for Anti-lock Brake Wiring Diagrams for Dodge Cab & Chassis R2002 2500:

• (left bottom of dash)
• 4wd ind
• 4wd sensor
• 4wd switch (on front axle)
• A10
• A20
• B113
• B114
• Brake lamp switch (on brake pedal bracket)
• Brake pressure switch (on combination valve)
• Brake sw sense
• Ccd bus (+)
• Ccd bus (-)
• Controller anti-lock brake (left fender side shield)
• Data link connector
• Diesel
• Engine controls system
• Fuse 10a
• Fuse 40a
• Fuse b (+)
• Fuse ign sw (run)
• G100 (left fender side shield)
• G101 (left fender side shield)
• G107
• G200 (left kick panel)
• Ground
• Hot at all times
• Hot in run
• Instrument cluster
• J/c 1 (in pdc)
• Joint connector 7 (left side of dash)
• Junction block (left end of dash)
• Left front wheel speed sensor (w/ all wheel abs) (on left front steering knuckle)
• Lf whl spd sensor (+)
• Lf whl spd sensor (-)
• Power distribution center (in engine compt, on left inner fender panel, near battery)
• Powertrain control module (right rear of eng compt)
• Rear wheel speed sensor (in differential housing)
• Rear whl spd sensor (+)
• Rear whl spd sensor (-)
• Red
• Red brake ind driver
• Rf whl spd sensor (+)
• Rf whl spd sensor (-)
• Right front wheel speed sensor (w/ all wheel abs) (on right front steering knuckle)
• S112
• S113
• S151
• S152 (near left front wheel speed sensor)
• S174 (transmission harness, in breakout to power distribution center)
• V40
• Vehicle speed sen sig
• Vss

ANTI-THEFT

Anti-theft Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Anti-theft Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (at upper left kick panel) s308
• (left fender side shield) g102
• (left side of dash) j/c 5
• (right center of dash) g201
• Ccd bus (+)
• Ccd bus (-)
• Central timer module (on left side of dash, inboard of steering column opening)
• Clockspring
• Ctm
• Data link connector (left bottom of dash)
• Disarm sense
• Door ajar sense
• Driver cylinder lock switch
• Driver door ajar switch
• F12
• Fuse 10a
• Fuse g 15a
• Fuse h 20a
• Fused b(+)
• Fused ign
• G100 (left fender side shield)
• G16
• G200 (left kick panel)
• G300 (lower left rear of cab)
• G50
• G69
• G73
• G75
• Ground
• Headlights system
• High note horn
• Horn relay
• Horn relay ctrl
• Horn switch
• Hot at all times
• Hot in run or start
• J/c 1 (in pdc)
• J/c 6 (left side of dash)
• J/c 7 (left side of dash)
• J/c 8 (left side of dash)
• Junction block (on left end of dash)
• Low note horn
• Nca
• Other
• Overhead console
• Passenger cylinder lock switch
• Passenger door ajar switch
• Power distribution center (on left inner fender panel, near battery)
• Red
• S143 (w/ drl)
• S150
• S305
• S329
• S330
• Security relay
• Tan
• Vtss lamp
• Vtss lamp driver

BODY COMPUTER

Body Computer Wiring Diagrams for Dodge Cab & Chassis R2002 2500

List of elements for Body Computer Wiring Diagrams for Dodge Cab & Chassis R2002 2500:

• Anti-theft system
• Base/ midline
• Battery
• Ccd bus (+)
• Ccd bus (-)
• Central timer module (left side of dash)
• Ctsy lp sw out
• Cyl lk sw mux
• Data link connector (left bottom of dash)
• Door locks system
• Dr lk driver
• Dr unlk drv
• F12
• F35
• Fuse 10a
• Fuse 25a
• G13
• G16
• G200 (left kick panel)
• G201 (right center dash support)
• G26
• G50
• G69
• G73
• G75
• Ground
• Heated seat sw
• Highline
• Horn rly ctrl
• Horns system
• Hot at all times
• Hot in acc or run
• Hot in run or start
• Ign run/accy
• Ign run/start
• Illum entry sw
• Interior lights system
• J/c 5 (left side of dash)
• J/c 7 (left kick panel)
• Junction block (left end of dash)
• Key-in ign sw
• Lt dr ajar sw
• M11
• M22
• P132
• P30
• P31
• P33
• P34
• Pass dr lk mtr
• Radio ctrl mux
• Red
• Rt dr ajar sw
• Seats system
• Secty rly ctrl
• Sound system
• Tan
• Tone reqst sig
• V10
• V18
• Vtss ind driver
• Warning systems
• Wiper/ washer system
• Wiper/washer system
• Wpr motor rly
• Wpr park sw
• Wpr sw mode
• Wpr sw sig
• Wshr sw sense
• X20

COMPUTER DATA LINES

Computer Data Lines for Dodge Cab & Chassis R2002 2500

List of elements for Computer Data Lines for Dodge Cab & Chassis R2002 2500:

• (behind left side of dash) j/c 7
• (diesel)
• (drain wire)
• (gas)
• (in breakout to engine control module) (diesel) s184
• (unterminated)
• A cummins bus (+)
• Air bag control module (behind lower center of dash)
• B cummins bus (-)
• Ccd bus (+)
• Ccd bus (-)
• Central timer module (on left side of dash)
• Controller anti-lock brake (rwal: left front inner fender) (4wabs: mounted on hydraulic control unit)
• Cummins bus (+)
• Cummins bus (-)
• Cummins bus (diesel) (left front of engine)
• Cummins bus shield
• D20
• D21
• D220
• Data link connector (dlc) (on left bottom of dash)
• Diesel
• Engine control module (on left side of engine, behind fuel filter)
• Fuse 12 10a
• G105 (front of engine)
• G107 (left rear of engine)
• G113 (primary battery engine ground)
• G200 (on left end of dash)
• Gas
• Ground
• Hot at all times
• Instrument cluster
• J/c 5 (behind left side of dash)
• Junction block (on left end of dash)
• K244
• K246
• K247
• Nca
• Overhead console (highline)
• Pnk
• Powertrain control module (on right side of firewall)
• Radio
• S109
• S126
• S164
• S172 (diesel) (top of a/c accumulator)
• S173 (diesel) (top of a/c accumulator)
• S175 (diesel) (in breakout to pdc)
• Sci receive
• Sci transmit
• Z11
• Z12

CRUISE CONTROL

Cruise Control Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Cruise Control Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (8.0l: near fuel injector 7) (5.9l: near fuel injector 5)
• (8.0l: rear of engine) (5.9l: near fuel injectors)
• (in breakout to power dist center)
• (in engine compartment, below battery) vehicle speed control servo
• 5.9l a/t diesel
• 5.9l m/t diesel
• 5.9l, 8.0l
• C3 a
• Cancel
• Clock- spring
• Coast
• Diesel
• Dump
• Engine control module (left side of engine)
• Engine controls system
• G100 (left fender side shield)
• Gas
• J/c 1 (in power dist center)
• Left speed control switch
• Nca
• On/ off
• Powertrain control module (right side of firewall)
• Resume/ accel
• Right speed control switch
• S118
• S121
• S151
• S179
• Sensor ground
• Set
• Speed ctrl in
• Stoplight switch (on brake pedal bracket)
• Tan/red
• Vacuum
• Vacuum ctrl
• Vent
• Vent ctrl
• Vsc sw signal

DEFOGGERS

Heated Mirrors Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Heated Mirrors Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• Fuse 10a
• G201 (dash right center support)
• G300 (left lower cowl)
• Heated mirror relay
• Heated mirror switch
• Hot in run
• J/c 5 (lower left side of dash)
• J/c 8 (center of dash)
• Junction block (left end of dash)
• Left power mirror
• Nca
• Off
• Right power mirror
• S305
• S307 (body harn, left cowl)
• S329
• S330 (slt only)
• Solid state

ENGINE PERFORMANCE

5.9L

5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R2002 2500:

• (pins 12-20 not used)
• (pins 16-21 not used)
• (pins 2-7 not used)
• (pins 22-24 not used)
• (pins 24-30 not used)
• (pins 7-10 not used)
• (pins 9-21 not used)
• (trans harn, in breakout pdc) s116
• (trans harn, in breakout to pdc)
• (transmission harn, near breakout to a/c low pressure switch)
• A/c clutch rly
• A/c request
• A/c select in
• A/t
• A14
• A142
• Acc pedal pos
• Air condi- tioning system
• Asd relay sens
• Auto sht rly
• Automatic shutdown relay
• Batt temp sens
• Battery temper- ature sensor (below battery tray)
• Brake lamp switch (on brake pedal bracket)
• Brake sw
• C13
• C20
• C90
• Ccd bus (+)
• Ccd bus (-)
• Ckp eng sig
• Controller anti-lock brake (4wabs: in eng compt, mounted on hydraulic control unit; rwabs: in eng compt, on left front inner fender)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D21
• D220
• F18
• Fuel lev sens
• Fuel tank module (top of fuel tank)
• Fuse 30a
• Fuse i 20a
• Fused b(+)
• G115 (primary battery body ground)
• G200 (left kick panel)
• Gen field drv
• Gen field out
• Generator
• Gov press sig
• Ground
• Hot at all times
• Ign power
• Joint connector (in pcd)
• Joint connector 1 (in pdc)
• K118
• K20
• K22
• K226
• K24
• K30
• K51
• K54
• K88
• M/t
• Output sens
• Output speed sensor (on left side of transmission)
• Overdrive switch
• Overdrv sol
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Prk/neutral
• Red
• S111
• S126
• S127 (trans harn, near breakout to park/neutral position switch)
• S171
• S174
• S179
• Sci receive
• Sci transmit
• Sensor grd
• Starting/ charging system
• T125
• T13
• T14
• T16
• T25
• T41
• T54
• T60
• Tan/red
• Tcc drvr
• Tcc sol ctrl
• Trans overdrv
• Trans relay
• Trans rly out
• Trans temp in
• Trans temp sns
• Trans- mission relay
• Transmission solenoid assembly (on left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol
• Var frce sol
• Vss in
• Z12

5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near break- out to ecm)
• (eng harn, near breakout for a/c low pressure switch)
• (in pdc) fuel heater relay
• (trans harn, in breakout pdc)
• Accelerator pedal position sensor (at left front side of eng, below cable/lever/ linkage cover)
• Camshaft position sensor
• Ccd (+)
• Ccd (-)
• Cummins bus
• Data link connector (left bottom of dash)
• Fuel heater (in top of fuel filter housing)
• Fuel transfer pump (on lower left side of eng, below rearward of fuel filter)
• Fuse 10a
• Fuse 40a
• G102 (left fender side shield)
• G107 (left rear of eng)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector 7 (left side of instrument panel)
• Joint connector no1 (in pdc)
• Junction block (left end of dash)
• Nca
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Pto switch
• Red/tan
• S105
• S164
• S172
• S173
• S175
• S184
• Wait to start ind

5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout to ecm)
• (eng harn, near fuel transfer pump)
• (near fuel transfer pump)
• A14
• Acc pedal pos sens
• Air heater rly no1
• Air heater rly no2
• App sens gnd
• Battery
• Brake sw sens
• Ccd bus(-)
• Ccd buss (+)
• Ckp sens sig
• Cmp sig
• Cmpsens sig
• Cruise control system
• Cummin bus (-)
• Cummins bus (+)
• Cummins bus shield
• D20
• D21
• Data link shd inj
• Data lk (-) fuel inj
• Dl (+) fuel inj pmp
• Ect sens sig
• Engine control module (on left side of eng, behind fuel filter)
• Engine coolant temperature sensor (on front of cylinder head, near thermostat housing)
• Engine oil pressure sensor (on left side of eng, near near ecm)
• Eop sw sens
• F18
• Fault sig
• Fuel inj pmp rly ctrl
• Fuel injection pump (on left side of eng, on rear of timing gear housing)
• Fuel pump relay (in pdc)
• Fuse 20a
• Fuse b(+)
• Fused b(+)
• G10
• G102 (left fender side shield)
• G113
• G115 (primary battery body ground)
• G12
• G85
• Gnd
• H101
• H102
• H103
• H104
• H105
• Hot at all times
• Iat sig
• Idle val sw no2
• Idle val sw sens
• Intake air heater
• Intake air heater relay 1 (on left inner fender, below left battery)
• Intake air heater relay 2 (on left inner fender, below left battery)
• Intake air temperature sensor (in left rear side of intake manifold)
• Joint connector 1 (in pdc)
• Joint connector 2 (in pdc)
• K104
• K124
• K131
• K135
• K14
• K21
• K22
• K24
• K240
• K242
• K243
• K244
• K246
• K247
• K44
• K45
• K48
• Knock sensor rtn
• Manifold air pressure sensor (left rear side of intake manifold)
• Map sens sig
• Nca
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Pto sw sens
• S160
• S161
• S165
• S166
• S167
• S168
• S170
• S21
• S22
• Sci receive
• Sci transmit
• Sensor gnd
• Speed ctrl sw
• St-run
• Trans pmp pwr
• Transfer pmp pwr
• V32
• V37
• Vss signal
• Wait to start warn
• Water in-fuel sensor (at bottom of fuel filter/ water separator canister)
• Water-in-fuel
• Z12

5.9L, Engine Performance Wiring Diagrams, California (1 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, California (1 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 3 )
• (eng harn, near breakout for fuel injs)
• (front of
• (front of right cylinder head) ignition coil
• (lt) down ho2s
• (lt) up ho2s
• A14
• Automatic shutdown relay
• Cam pos sns
• Coil driver
• Controller anti-lock brake (4wabs: in eng compt, mounted on hydraulic control unit; rwabs: in eng compt, on left front of inner fender)
• Crnk pos sns
• Distributor
• Ect sens in
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 10a
• Fused b(+)
• G105
• G113
• G60
• Gen field drv
• Gov press sig
• Ground
• Hot in run or start
• Iat sens in
• Idle air 1
• Idle air 2
• Idle air 3
• Idle air 4
• Ign power
• Inj 1 driver
• Inj 2 driver
• Inj 3 driver
• Inj 4 driver
• Inj 5 driver
• Inj 6 driver
• Inj 7 driver
• Inj 8 driver
• Junction block (on left end of dash)
• K11
• K12
• K13
• K14
• K141
• K19
• K20
• K21
• K22
• K24
• K241
• K26
• K28
• K30
• K341
• K38
• K39
• K40
• K44
• K441
• K54
• K58
• K59
• K60
• K88
• Map sens in
• Nca
• Oil press sig
• Output sens
• Output speed sensor (on left side of transmission)
• Overdrv sol
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Power take off switch
• Powertrain control module (in eng compt, on right side of firewall)
• Prk/neutral
• Pto sw sens
• Rt dn ho2s
• Rt up ho2s
• S107
• S117
• S123
• S126
• S127 (eng harn, near breakout for transmission)
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• Tps sens in
• Trans relay
• Trans temp in
• Var frce sol
• Vss in
• Z12

5.9L, Engine Performance Wiring Diagrams, California (2 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, California (2 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 5)
• (eng harn, near breakout for fuel injs)
• (headlamp & dash harn, in pdc)
• (in pdc) joint connector 2
• Crankshaft position sensor (right rear of eng block)
• Engine coolant temperature sensor (in water jacket, at front of intake manifold)
• Engine oil pressure sensor (near distributor)
• Fuse 20a
• Fuse 30a
• Fuse k 15a
• Hot at all times
• Iac mtr 1
• Iac mtr 2
• Iac mtr 3
• Iac mtr 4
• Idle air control motor (on throttle body)
• Manifold absolute pressure sensor (on throttle body)
• Oxygen sensor downstream relay
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• S119
• S121
• S176

5.9L, Engine Performance Wiring Diagrams, California (3 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, California (3 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for oil pressure sensor)
• (on right exhaust downpipe, before mini- catalytic converter)
• A61
• Camshaft position sensor (in distributor)
• Fuel pump module (top of fuel tank)
• Fuel pump rly out (b+)
• G100 (left fender side shield)
• G105 (front of eng)
• Gov press sig
• Ground
• Heated oxygen sensor 1/1 (left bank up) (on left exhaust downpipe, before catalytic converter)
• Heated oxygen sensor 1/2 (left bank down) (on outlet end of left mini- catalytic converter)
• Heated oxygen sensor 2/1 (right bank up)
• Heated oxygen sensor 2/2 (right bank down) (on outlet end of right mini- catalytic converter)
• Intake air temperature sensor (in right front side of intake manifold)
• K226
• K54
• K88
• Nca
• Overdrv sol
• Pnk
• Red
• S100 (eng harn, near oil pressure sensor)
• S118 (eng harn, near breakout for fuel injs)
• S122
• S130
• S331
• Sensor grd
• Sensor return
• Sensor sig
• T16
• T25
• T54
• T60
• Tcc sol ctrl
• Throttle position sensor (on throttle body)
• Trans rly out
• Trans temp sns
• Transmission solenoid assembly (at left side of transmission)
• Var force sol
• Z13

5.9L, Engine Performance Wiring Diagrams, California (4 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, California (4 of 4) for Dodge Cab & Chassis R2002 2500:

• A/c comp rly
• A/c request
• A/c select in
• A142
• Air condi- tioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery tray)
• Brake sw in
• C13
• C20
• C90
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Dash harn, rear of front bumper)
• Data link connector (left bottom of dash)
• Evap purge solenoid (on bracket, mounted on right inner fender)
• Evap sol drvr
• Fuel pmp rly
• Fuse 10a
• Fuse i 20a
• G200 (left kick panel)
• Gen field out
• Generator
• Ho2s 1/1 htr
• Ho2s 1/2 htr
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector no 1 (in pdc)
• Joint connector no1 (in pdc)
• Joint connector no7 (left side of instrument panel)
• Junction block (on left end of dash)
• K106
• K107
• K118
• K125
• K145
• K199
• K226
• K299
• K31
• K51
• K52
• Leak detec pmp
• Leak detection pump (on right front inner fender)
• Low fuel sens
• Overdrive switch
• Oxy dn rly ctrl
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S105
• S116 (eng harn, near breakout for fuel inj)
• Sci receive
• Sci transmit
• Stoplight switch (on brake pedal bracket)
• Tan/red
• Trans overdrv
• Transmission relay
• V32
• V35
• V36
• V37
• V40

5.9L, Engine Performance Wiring Diagrams, Federal (1 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, Federal (1 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 3 )
• (eng harn, near breakout for fuel injs)
• (front of
• (front of right cylinder head) ignition coil
• (lt) down ho2s
• (lt) up ho2s
• A14
• Automatic shutdown relay
• Cam pos sns
• Coil driver
• Controller anti-lock brake (4wabs: in eng compt, mounted on hydraulic control unit; rwabs: in eng compt, on left front of inner fender)
• Crnk pos sns
• Distributor
• Ect sens in
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 10a
• Fused b(+)
• G105
• G113
• G60
• Gen field drv
• Gov press sig
• Ground
• Hot in run or start
• Iat sens in
• Idle air 1
• Idle air 2
• Idle air 3
• Idle air 4
• Ign power
• Inj 1 driver
• Inj 2 driver
• Inj 3 driver
• Inj 4 driver
• Inj 5 driver
• Inj 6 driver
• Inj 7 driver
• Inj 8 driver
• Junction block (on left eng of dash)
• K11
• K12
• K13
• K14
• K141
• K19
• K20
• K21
• K22
• K24
• K26
• K28
• K30
• K341
• K38
• K39
• K40
• K44
• K54
• K58
• K59
• K60
• K88
• Map sens in
• Nca
• Oil press sig
• Output sens
• Output speed sensor (on left side of transmission)
• Overdrv sol
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Power take off switch
• Powertrain control module (in eng compt, on right side of firewall)
• Prk/neutral
• Pto sw sens
• Rt dn ho2s
• Rt up ho2s
• S107
• S117
• S123
• S126
• S127 (eng harn, near breakout for transmission)
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• Tps sens in
• Trans relay
• Trans temp in
• Var frce sol
• Vss in
• Z12

5.9L, Engine Performance Wiring Diagrams, Federal (2 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, Federal (2 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 5)
• (eng harn, near breakout for fuel injs)
• (eng harn, top of transmission)
• (in pdc) joint connector 2
• Crankshaft position sensor (right rear of eng block)
• Engine coolant temperature sensor (in water jacket, at front of intake manifold)
• Engine oil pressure sensor (near distributor)
• Fuse 20a
• Fuse 30a
• Fuse k 15a
• Hot at all times
• Iac mtr 1
• Iac mtr 2
• Iac mtr 3
• Iac mtr 4
• Idle air control motor (on throttle body)
• Manifold absolute pressure sensor (on throttle body)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• S119
• S121
• S124

5.9L, Engine Performance Wiring Diagrams, Federal (3 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, Federal (3 of 4) for Dodge Cab & Chassis R2002 2500:

• of catalytic
• A61
• Camshaft position sensor (in distributor)
• Converter)
• Fuel pump module (top of fuel tank)
• Fuel pump rly out (b+)
• G100 (left fender side shield)
• Gov press sig
• Ground
• Heated oxygen sensor 1/1 (upstream) (on inlet of catalytic converter)
• Heated oxygen sensor 1/2 (downstream) (near outlet end
• Intake air temperature sensor (in right front side of intake manifold)
• K226
• K54
• K88
• Nca
• Overdrv sol
• Pnk
• Red
• S118 (eng harn, near breakout for fuel injs)
• S331
• Sensor grd
• Sensor return
• Sensor sig
• T16
• T25
• T54
• T60
• Tcc sol ctrl
• Throttle position sensor (on throttle body)
• Trans rly out
• Trans temp sns
• Transmission solenoid assembly (at left side of transmission)
• Var force sol
• Z13

5.9L, Engine Performance Wiring Diagrams, Federal (4 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, Federal (4 of 4) for Dodge Cab & Chassis R2002 2500:

• A/c comp rly
• A/c request
• A/c select in
• A142
• Air condi- tioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery tray)
• Brake sw in
• C13
• C20
• C90
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Dash harn, rear of front bumper)
• Data link connector (left bottom of dash)
• Evap purge solenoid (on bracket, mounted on right inner fender)
• Evap sol drvr
• Fuel pmp rly
• Fuse 10a
• Fuse i 20a
• G200 (left kick panel)
• Gen field out
• Generator
• Ho2s 1/1 htr
• Ho2s 1/2 htr
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector no 1 (in pdc)
• Joint connector no1 (in pdc)
• Joint connector no7 (left side of instrument panel)
• Junction block (on left end of dash)
• K106
• K107
• K118
• K125
• K199
• K226
• K299
• K31
• K51
• K52
• Leak detec pmp
• Leak detection pump (on right front inner fender)
• Low fuel sens
• Overdrive switch
• Oxy dn rly ctrl
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S105
• S116 (eng harn, near breakout for fuel inj)
• Sci receive
• Sci transmit
• Stoplight switch (on brake pedal bracket)
• Tan/red
• Trans overdrv
• Transmission relay
• V32
• V35
• V36
• V37
• V40

5.9L, Engine Performance Wiring Diagrams, HD (1 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, HD (1 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 3 )
• (eng harn, near breakout for fuel injs)
• (front of
• (front of right cylinder head) ignition coil
• (lt) up ho2s
• A14
• Automatic shutdown relay
• Cam pos sns
• Coil driver
• Controller anti-lock brake (4wabs: in eng compt, mounted on hydraulic control unit; rwabs: in eng compt, on left front of inner fender)
• Crnk pos sns
• Distributor
• Ect sens in
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 10a
• Fused b(+)
• G105
• G113
• G60
• Gen field drv
• Gov press sig
• Ground
• Hot in run or start
• Iat sens in
• Idle air 1
• Idle air 2
• Idle air 3
• Idle air 4
• Ign power
• Inj 1 driver
• Inj 2 driver
• Inj 3 driver
• Inj 4 driver
• Inj 5 driver
• Inj 6 driver
• Inj 7 driver
• Inj 8 driver
• Junction block (on left eng of dash)
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K241
• K26
• K28
• K30
• K38
• K39
• K40
• K41
• K44
• K54
• K58
• K59
• K60
• K88
• Map sens in
• Nca
• Oil press sig
• Output sens
• Output speed sensor (on left side of transmission)
• Overdrv sol
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Power take off switch
• Powertrain control module (in eng compt, on right side of firewall)
• Prk/neutral
• Pto sw sens
• Rt up ho2s
• S107
• S117
• S123
• S126
• S127 (eng harn, near breakout for transmission)
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• Tps sens in
• Trans relay
• Trans temp in
• Var frce sol
• Vss in
• Z12

5.9L, Engine Performance Wiring Diagrams, HD (2 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, HD (2 of 4) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout for fuel inj 5)
• (eng harn, near breakout for fuel injs)
• (eng harn, top of transmission)
• (in pdc) joint connector 2
• Crankshaft position sensor (right rear of eng block)
• Engine coolant temperature sensor (in water jacket, at front of intake manifold)
• Engine oil pressure sensor (near distributor)
• Fuse 20a
• Fuse 30a
• Fuse k 15a
• Hot at all times
• Iac mtr 1
• Iac mtr 2
• Iac mtr 3
• Iac mtr 4
• Idle air control motor (on throttle body)
• Manifold absolute pressure sensor (on throttle body)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• S119
• S121
• S124

5.9L, Engine Performance Wiring Diagrams, HD (3 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, HD (3 of 4) for Dodge Cab & Chassis R2002 2500:

• (on left exhaust downpipe, before catalytic converter)
• A61
• Camshaft position sensor (in distributor)
• Fuel pump module (top of fuel tank)
• Fuel pump rly out (b+)
• G100 (left fender side shield)
• G105 (front of eng)
• Gov press sig
• Ground
• Heated oxygen sensor 1/1 (left bank up)
• Heated oxygen sensor 2/1 (right bank up) (on right downpipe, before exhaust catalytic converter)
• Intake air temperature sensor (in right front side of intake manifold)
• K226
• K54
• K88
• Nca
• Overdrv sol
• Pnk
• Red
• S118 (eng harn, near breakout for fuel injs)
• S122
• S331
• Sensor grd
• Sensor return
• Sensor sig
• T16
• T25
• T54
• T60
• Tcc sol ctrl
• Throttle position sensor (on throttle body)
• Trans rly out
• Trans temp sns
• Transmission solenoid assembly (at left side of transmission)
• Var force sol
• Z13

5.9L, Engine Performance Wiring Diagrams, HD (4 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Engine Performance Wiring Diagrams, HD (4 of 4) for Dodge Cab & Chassis R2002 2500:

• A/c comp rly
• A/c request
• A/c select in
• A142
• Air condi- tioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Battery temper- ature sensor (below battery tray)
• Brake sw in
• C13
• C20
• C90
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Dash harn, rear of front bumper)
• Data link connector (left bottom of dash)
• Evap purge solenoid (on bracket, mounted on right inner fender)
• Evap sol drvr
• Fuel pmp rly
• Fuse 10a
• Fuse i 20a
• G200 (left kick panel)
• Gen field out
• Generator
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector no 1 (in pdc)
• Joint connector no1 (in pdc)
• Joint connector no7 (left side of instrument panel)
• Junction block (on left end of dash)
• K106
• K107
• K118
• K125
• K226
• K31
• K51
• K52
• Leak detec pmp
• Leak detection pump (on right front inner fender)
• Low fuel sens
• Overdrive switch
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S105
• S116 (eng harn, near breakout for fuel inj)
• Sci receive
• Sci transmit
• Stoplight switch (on brake pedal bracket)
• Tan/red
• Trans overdrv
• Transmission relay
• V32
• V35
• V36
• V37
• V40

8.0L

8.0L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, Engine Performance Wiring Diagrams (1 of 3) for Dodge Cab & Chassis R2002 2500:

• (calif)
• (eng harn, near break- out for fuel inj 1)
• (eng harn, rear of eng)
• (front of
• (in pdc) joint connector no2
• A14
• Automatic shutdown relay
• Cam pos sns
• Capacitor
• Controller anti-lock brake (4wabs: in eng compt, mounted on hydraulic control unit; rwabs: in eng compt, on left front inner fender panel)
• Crnk pos sns
• Ect sens in
• Engine)
• F18
• Fuel injectors
• Fuel pump relay
• Fuse 20a
• Fuse 30a
• Fused b(+)
• G105
• G60
• Gen field drv
• Gov press sig
• Ground
• Ho2s 1/1 sig
• Ho2s 1/2 sig
• Ho2s 1/3 sig
• Ho2s 2/1 sig
• Hot at all times
• Iat sens in
• Idle air 1
• Idle air 2
• Idle air 3
• Idle air 4
• Ign coil dvr 1
• Ign coil dvr 2
• Ign coil dvr 3
• Ign coil dvr 4
• Ign coil dvr 5
• Ign power
• Ignition coil 4-pack
• Ignition coil 6-pack
• Inj 1 driver
• Inj 10 driver
• Inj 2 driver
• Inj 3 driver
• Inj 4 driver
• Inj 5 driver
• Inj 6 driver
• Inj 7 driver
• Inj 8 driver
• Inj 9 driver
• K11
• K115
• K116
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K241
• K26
• K28
• K30
• K32
• K341
• K38
• K39
• K40
• K41
• K43
• K44
• K54
• K58
• K59
• K60
• K88
• Map sens in
• Nca
• Oil press sig
• Output sens
• Output speed sensor (on left side of transmission)
• Overdrv sol
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Prk/neutral
• S107
• S117
• S123
• S126
• S127 (eng harn, at transmission)
• S131
• Sensor grd
• Starting/ charging system
• T13
• T14
• T25
• T41
• T54
• T60
• Tan
• Tcc drvr
• To spark plugs
• Tps sens in
• Trans relay
• Trans temp in
• Var frce sol
• Vss in
• Z12

8.0L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, Engine Performance Wiring Diagrams (2 of 3) for Dodge Cab & Chassis R2002 2500:

• (calif)
• (eng harn, in breakout for transmission)
• (eng harn, near breakout for fuel inj 5) s121
• (eng harn, rear of eng)
• (in pdc) joint connector no 1
• (left fender side shield)
• (near oil filter) engine oil pressure sensor
• (on right lower side of cylinder block, above oil pan rail)
• (on throttle body) idle air control motor
• (pre- catalyst) (on inlet of catalytic converter)
• A61
• Battery temper- ature sensor (below battery tray)
• Camshaft position sensor (in timing chain case/cover on left front side of eng)
• Crankshaft position sensor
• Engine coolant temperature sensor (on thermostat housing)
• Evap purge solenoid (on bracket, mounted on right inner fender)
• Fuel pump
• Fuel pump module (on top of fuel tank)
• Fuse 10a
• G100
• G105 (front of engine)
• Ground
• Heated oxygen sensor 1/1 (left bank up) (on left exhaust downpipe)
• Heated oxygen sensor 1/2
• Heated oxygen sensor 2/1 (right bank up) (on right exhaust downpipe)
• Heated oxygen sensor 2/2 (post- catalyst) (on outlet end of catalytic converter)
• Hot in run or start
• Iac mtr 1
• Iac mtr 2
• Iac mtr 3
• Iac mtr 4
• Junction block (on left end of dash)
• K226
• Manifold absolute pressure sensor (on right upper side of intake manifold)
• Nca
• Pnk
• S105
• S118 (eng harn, rear of eng)
• S119
• S122
• S124
• S130
• S331
• Sensor return
• Sensor sig rly out (b+)
• Z13

8.0L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, Engine Performance Wiring Diagrams (3 of 3) for Dodge Cab & Chassis R2002 2500:

• (headlamp & dash harn, in pdc)
• (headlamp & dash harn, rear of front bumper)
• (m/t only)
• A/c comp rly
• A/c request
• A/c select in
• A142
• Air condi- tioning system
• Air conditioning system
• Asd relay sens
• Auto sht rly
• Batt temp sens
• Brake sw in
• C13
• C20
• C90
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Cruise control system
• Cruise feed
• Cruise sw in
• Cruise vac sol
• Cruise vnt sol
• D20
• D21
• Data link connector (left bottom of dash)
• Downstream oxygen sensor relay
• Evap sol drvr
• Fuel pmp rly
• Fuse i 20a
• Fuse k 15a
• G200 (left kick panel)
• Gen field out
• Generator
• Gov press sig
• Ho2s 1/1 htr ctrl
• Ho2s 2/1 htr ctrl
• Ho2s dn rly ctrl
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (in left front side of intake manifold)
• Joint connector 1 (in pdc)
• Joint connector no7 (left side of instrument panel)
• K106
• K107
• K118
• K125
• K145
• K199
• K226
• K299
• K31
• K51
• K52
• K54
• K88
• Leak detec pmp
• Leak detection pump (on right front of inner fender)
• Low fuel sens
• Overdrive switch
• Overdrv sol
• Pnk
• Power distribution center (in eng compt, on left inner fender panel, near battery)
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S116 (eng harn, rear of eng)
• S176
• S180
• Sci receive
• Sci transmit
• Sensor grd
• Stop lamp switch (on brake pedal bracket)
• T16
• T25
• T54
• T60
• Tan/red
• Tcc sol ctrl
• Throttle position sensor (on throttle body)
• Trans overdrive
• Trans rly out
• Trans temp sns
• Transmission relay
• Transmission solenoid assembly (on left side of transmission)
• V32
• V35
• V36
• V37
• V40
• Var force sol

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Back-up Lamps Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (left rear frame rail) s316
• (near daytime running lamps module)
• (w/ trailer package)
• A/t
• Automatic day/night mirror (highline)
• Back- up lamp switch (on left side of trans)
• Daytime running lamp module
• Fuse 10a
• G100 (left fender side shield)
• Hot in run
• J/c 1 (in pdc)
• Junction block
• Left back-up lamp
• M/t
• Park/ neutral position switch (left side of trans)
• Right back-up lamp
• S108
• S315
• S401
• S402
• Trailer tow connector or aftermarket trailer tow connector
• W/ aftermarket w/o aftermarket
• W/ drl
• W/o drl

Exterior Lamps & Trailer connector Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for Exterior Lamps & Trailer connector Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500:

• (left fender side shield) g100
• (left frame rail)
• (left frame rail) s313
• (left front fender area) s104
• (left s314
• (near left front park/ turn signal lamp)
• (near right front park/ turn signal lamp)
• (right of radiator) s141
• Center high mounted stop lamp 1
• Center high mounted stop lamp 2
• Combination flasher
• Frame rail)
• Fuse 10 10a
• Fuse 4 20a
• Fuse 5 20a
• Fuse f 20a
• G100 (left fender side shield)
• G201 (right dash center support)
• G301 (below left rear speaker)
• Hazard
• Head
• Headlamp switch
• Hot at all times
• Hot in acc or run
• Instrument cluster
• J/c 6 (left side of dash)
• Junction block
• Left
• Left front park/turn signal lamp
• Left license lamp
• Left tail/ stop/turn signal lamp
• Left turn ind
• Normal
• Off
• Park
• Pnk
• Pnk/red
• Power distribution center
• Right
• Right front park/turn signal lamp
• Right license lamp
• Right tail/ stop/turn signal lamp
• Right turn ind
• S102
• S103
• S150
• S151
• S311
• S315
• S317
• S401
• S402
• Stop lamp switch (on brake pedal bracket)
• Tan
• Timing control
• Turn signal/ hazard switch (part of multi- function switch)
• W/ dual rear wheels
• W/ trailer tow
• W/o dual rear wheels
• W/o trailer tow

Exterior Lamps & Trailer connector Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for Exterior Lamps & Trailer connector Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500:

• (w/ aftermarket)
• (w/o aftermarket)
• Aftermarket center high mounted stop lamp
• Back-up lamps circuit
• Battery (+)
• Brake (+)
• Center identification lamp
• Electric brake (highline)
• Fuse 8 40a
• G100 (left fender side shield)
• G102 (left fender side shield)
• G201 (right center dash support)
• G302 (at overhead console)
• Ground
• Hot at all times
• J/c 1 (in power distribution center)
• J/c 2 (in power distribution center)
• Left front fender lamp
• Left license lamp
• Left outboard clearance lamp
• Left outboard identification lamp
• Left rear fender lamp
• Power distribution center
• Rear wheels
• Right front fender lamp
• Right outboard clearance lamp
• Right outboard identification lamp
• Right rear fender lamp
• Right tailgate lamp
• S114 (in breakout to chassis harness)
• S315
• S318 (w/o aftermarket trailer tow)
• S319 (w/o aftermarket trailer tow)
• S320 (w/o aftermarket trailer tow) (in trailer tow breakout)
• S321
• S322 (at roof lamps)
• S325
• S404
• S406 (near breakout to tailgate lamp)
• Stoplight sw
• Trailer tow connector or aftermarket trailer tow connector (if equipped)
• Trailer tow relay (w/ trailer package) (in power distribution center)
• W/ dual
• W/ highline only
• W/0 aftermarket trailer tow

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Dodge Cab & Chassis R2002 2500:

• (8.0l) oxygen sensor 1/2 pre- catalyst
• (8.0l) oxygen sensor 1/3 post catalyst
• (california) oxygen sensor 1/2 left bank down
• (california) oxygen sensor 2/2 right bank down
• (diesel) auxiliary battery
• (diesel) battery
• (gasoline) battery
• (not used)
• A/c compressor clutch
• A/t
• Cummins bus
• Data link connector (dlc)
• Diesel
• Engine control module
• Engine starter motor relay
• Fuel heater
• Fuel injection pump
• Fuel transfer pump
• G105 (front of engine) (engine ground)
• G107 (left rear of engine)
• G113 (primary battery engine ground)
• G114 (battery engine ground)
• G115
• G115 (primary battery body ground)
• G116 (battery frame ground)
• G117 (auxiliary battery engine ground)
• G118 (primary frame ground)
• G120 (auxiliary battery body ground)
• Gas
• Intake air heater relay
• J/c 2 (in power distribution center)
• M/t
• Power distribution center
• Powertrain control module (pcm)
• S109 (battery harness, in break out for engine & transmission ground)
• S122 (8 cyl) (engine harness, top of transmission) (10 cyl) (engine harness, in break out to transmission)
• S126 (8 cyl) (engine harness, near breakout to fuel injector 1) (10 cyl) (engine harness, near break out to engine ground)
• S128 (transmission harness, near break out to power distribution center)
• S164 (engine harness, near fuel transfer pump)
• S168 (engine harness, near break out to engine coolant temperature sensor)
• Z12

Ground Distribution Wiring Diagram (2 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Dodge Cab & Chassis R2002 2500:

• (chassis harness, near break out to fuel pump module) s331
• (left fender side shield) (rwal ground) g102
• 4wd switch
• After- market
• After- market trailer tow connector
• Air bag control module
• Blower motor relay
• Brake controller) s112
• Brake pressure switch
• Clock spring
• Controller anti-lock brake (4wabs)
• Daytime running lamp (drl) module
• Diesel
• Dual rear wheels
• Fuel heater relay
• Fuel pump module
• Fuel pump relay
• G100 (left fender side shield)
• G101 (left fender side shield)
• High note horn
• J/c 1 (in power distribution center)
• J/c 6 (left side of dash)
• J/c 8 (center of dash)
• Left back-up lamp
• Left front door speaker
• Left left front front fender fender lamp lamp
• Left left license license lamp lamp
• Left left rear rear fender fender lamp lamp
• Left license lamp
• Left park/turn signal lamp
• Left remote radio switch
• Left tail/ stop/turn signal lamp
• Low note horn
• Nca
• Other
• Passenger air bag on/off switch
• Power distribution center
• Premium
• Quad high beam relay
• Radio
• Radio choke relay
• Right back-up lamp
• Right front door speaker
• Right license lamp
• Right park/turn signal lamp
• Right remote radio switch
• Right right front front fender fender lamp lamp
• Right right rear rear fender fender lamp lamp
• Right tail/ stop/turn signal lamp
• S150 (front bumper right support)
• S151 (left front engine compartment)
• S209 (steering wheel harness, near remote radio switch)
• S302 (body harness, left side of dash)
• S315 (left rear frame rail)
• S321 (in break out to left rear lamps)
• S401 (tail/stop/turn & back-up lamp harness, near break out to left back-up lamp)
• S402 (tail/stop/turn & back-up lamp harness, near break out to right back-up lamp)
• S404 (fender lamp harness, near break out to tailgate lamp)
• Security relay
• Tailgate tailgate lamp lamp
• To g200 (diagram 3 of 4)
• Trailer tow connector
• Trailer tow relay
• Underhood lamp
• Vehicle speed control servo
• Washer fluid level switch
• Windshield washer pump
• Windshield wiper motor

Ground Distribution Wiring Diagram (3 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Dodge Cab & Chassis R2002 2500:

• (part of multi-function switch) headlamp beam select switch
• A/c heater control
• A/c heater temperature select
• Ash receiver lamp
• Automatic day/night mirror
• Base
• Blend door actuator
• Brake lamp switch
• Central timer module
• Cigar lighter
• Combination flasher
• Cup holder lamp
• Data link connector (dlc)
• Driver heated seat switch
• Electric brake provision
• From g100 (diagram 2 of 4)
• G200 (on left end of dash)
• G201 (dash panel right center support)
• Glove box lamp & switch
• Headlamp switch
• Heated mirror switch
• Highline
• Ignition switch
• Instru- ment cluster
• Instrument cluster
• J/c 5 (left side of dash)
• J/c 8 (center of dash)
• Junction block (on left end of dash)
• Left visor/ vanity lamp
• Midline/ base
• Other
• Overdrive switch
• Overhead console
• Passenger heated seat switch
• Power outlet
• Right visor/ vanity lamp
• S323 (overhead console harness, at roof lamps)
• S340 (overhead console harness, at roof lamps)
• Tan

Ground Distribution Wiring Diagram (4 of 4) for Dodge Cab & Chassis R2002 2500

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Dodge Cab & Chassis R2002 2500:

• (at overhead console) g302
• (below left rear speaker) g301
• (club cab) seat belt switch
• (heated seats) seat heat interface module (shim)
• (standard cab) driver power seat switch
• (standard cab) seat belt switch
• Center high mounted stop lamp
• Center identi- fication lamp
• Driver cylinder lock switch
• Driver door ajar switch
• Driver door window/ lock switch
• Driver door window/ lock switch (iem)
• Driver heated seat cushion
• Driver power seat switch
• G300 (left lower kick panel)
• Heated seat/ power seat
• Left outboard clearance lamp
• Left outboard identification lamp
• Left power mirror
• Manual seat/ other
• Midline
• Passenger cylinder lock switch
• Passenger door ajar switch
• Passenger door window/lock switch
• Passenger heated seat cushion
• Passenger power seat switch
• Power mirror switch
• Right outboard clearance lamp
• Right outboard identification lamp
• Right power mirror
• S305 (body harness, right side of dash)
• S311 (at left body ground)
• S325 (overhead console harness at roof lamps)
• S328 (power seat harness, near break out to body wiring)
• S329 (except base) (door harness, near left door near grommet)
• S336 (power seat harness, under passenger seat)
• Slt

HEADLIGHTS

Headlight Wiring Diagram, with DRL & with Quad Headlights for Dodge Cab & Chassis R2002 2500

List of elements for Headlight Wiring Diagram, with DRL & with Quad Headlights for Dodge Cab & Chassis R2002 2500:

• (above steering column) j/c 5
• (fog lamp harness, in breakout to right fog lamp) s136
• (headlamp & dash harness, in breakout to daytime running lamps module)
• (headlamp & dash harness, near breakout to power distribution center) s143
• (headlamp & dash harness, near intake air heater relay) s181
• (instrument panel right center support) g201
• (left fender side shield) (rwal ground) g102
• (not used)
• 87a
• Daytime running lamp (drl) module (in engine compartment, on left inner fender panel)
• Exterior lights system
• Flash
• Fog lamp ctrl
• Fog lamp indicator
• Fog lamp relay (on power distribution center)
• Fog lamp switch
• Fuse 10a
• Fuse b 15a
• Fuse c 15a
• Fuse e 15a
• Fuse f 20a
• Fuse g 15a
• Fused b (+)
• G100 (left fender side shield)
• G11
• G34
• Ground
• Head
• Headlamp beam select switch (part of multi-function switch)
• Headlight switch
• High
• High beam ind
• High beam indicator
• High beam out
• High low
• Hot at all times
• Hot in run
• Ignition
• Instrument cluster
• J/c 1 (in power distribution center)
• Junction block (on left end of dash)
• L10
• L139
• L34
• Left fog lamp
• Left headlamp
• Left outboard headlamp
• Low
• Low beam out
• Off
• Park
• Park brake indicator
• Park brake sen
• Park brake switch (on park brake mechanism)
• Pnk/ red
• Pnk/red
• Power distribution center (in engine compartment, on left inner fender panel, near battery)
• Quad high beam relay (in power distribution center)
• Right fog lamp
• Right headlamp
• Right outboard headlamp
• S106 (headlamp & dash harness, in power distribution center)
• S110 (headlamp & dash harness, near left wheel speed sensor)
• S134 (fog lamp harness, in breakout to right fog lamp)
• S144 (headlamp & dash harness, near breakout to j/c 3)
• S151 (left front of engine compartment)
• S177 (headlamp & dash harness, in breakout to daytime running lamps (drl) module)
• S182
• Security relay

Headlight Wiring Diagram, with DRL & without Quad Headlights for Dodge Cab & Chassis R2002 2500

List of elements for Headlight Wiring Diagram, with DRL & without Quad Headlights for Dodge Cab & Chassis R2002 2500:

• (above steering column) j/c 5
• (fog lamp harness, in breakout to right fog lamp) s136
• (headlamp & dash harness, near breakout to power distribution center) s143
• (headlamp & dash harness, near daytime running lamp module) s108
• (instrument panel right center support) g201
• (not used)
• 87a
• Daytime running lamp (drl) module (in engine compartment, on left inner fender panel)
• Exterior lights system
• Flash
• Fog lamp ctrl
• Fog lamp indicator
• Fog lamp relay (in power distribution center)
• Fog lamp switch
• Fuse 10a
• Fuse b 15a
• Fuse c 15a
• Fuse f 20a
• Fuse g 15a (or 20a)
• Fused b (+)
• Fused ignition
• G100 (left fender side shield)
• G102 (left fender side shield) (rwal ground)
• G11
• G34
• Ground
• Head
• Headlamp beam select switch (part of multi-function switch)
• Headlamp switch
• High
• High beam ind
• High beam indicator
• High beam out
• Hot at all times
• Hot in run
• Hot in run & start
• Instrument cluster
• J/c 1 (in power distribution center)
• Junction block (on left end of dash)
• L10
• L139
• L34
• Left fog lamp
• Left outboard headlamp
• Low
• Low beam out
• Off
• Park
• Park brake indicator
• Park brake sen
• Park brake switch (on park brake mechanism)
• Pnk/ red
• Pnk/red
• Power distribution center (in engine compartment, on left inner fender panel, near battery)
• Right fog lamp
• Right outboard headlamp
• S106 (headlamp & dash harness, in power distribution center)
• S110 (headlamp & dash harness, near left wheel speed sensor)
• S134 (fog lamp harness, in breakout to right fog lamp)
• S151 (left front of engine compartment)
• S177 (headlamp & dash harness, in breakout to daytime running lamps module)
• Security relay

Headlight Wiring Diagram, without DRL & with Quad Headlights for Dodge Cab & Chassis R2002 2500

List of elements for Headlight Wiring Diagram, without DRL & with Quad Headlights for Dodge Cab & Chassis R2002 2500:

• (above steering column) j/c 5
• (fog lamp harness, in breakout to right fog light) s136
• (headlamp & dash harness, near breakout to power distribution center) s143
• (headlamp & dash harness, near intake air heater relay) s181
• (instrument panel right center support) g201
• (left fender side shield) (rwal ground) g102
• (not used)
• 87a
• Exterior lights system
• Flash
• Fog lamp indicator
• Fog lamp relay (on power distribution center)
• Fog lamp switch
• Fog lamp)
• Fuse 10a
• Fuse b 15a
• Fuse c 15a
• Fuse e 15a
• Fuse f 20a
• Fuse g 15a (or 20a)
• Head
• Headlamp beam select switch (part of multi-function switch)
• Headlamp switch
• High
• High beam indicator
• Hot at all times
• Instrument cluster
• J/c 1 (in power distribution center)
• Junction block (on left end of dash)
• Left fog lamp
• Left headlamp
• Left outboard headlamp c
• Low
• Off
• Park
• Pnk/ red
• Pnk/red
• Power distribution center (in engine compartment, on left inner fender panel)
• Quad high beam relay (on power distribution center)
• Right fog lamp
• Right headlamp
• Right outboard headlamp c
• S106 (headlamp & dash harness, in power distribution center)
• S110 (headlamp & dash harness, near left wheel speed sensor)
• S144 (headlamp & dash harness, near breakout to j/c 3)
• S183 (headlamp & dash harness, in power distribution center)

Headlight Wiring Diagram, without DRL & without Quad Headlights for Dodge Cab & Chassis R2002 2500

List of elements for Headlight Wiring Diagram, without DRL & without Quad Headlights for Dodge Cab & Chassis R2002 2500:

• (above steering column) j/c 5
• (fog lamp harness, in breakout to right fog lamp) s136
• (headlamp & dash harness, near breakout to power distribution center) s143
• (instrument panel right center support) g201
• (not used)
• 87a
• Exterior lights system
• Flash
• Fog lamp indicator
• Fog lamp relay (in power distribution center)
• Foglamp switch
• Fuse 10a
• Fuse b 15a
• Fuse c 15a
• Fuse f 20a
• Fuse g 15a (or 20a)
• Head
• Headlamp beam select switch (part of multi-function switch)
• Headlamp switch
• High
• High beam indicator
• Hot at all times
• Instrument cluster
• J/c 1 (in power distribution center)
• Junction block (on left end of dash)
• Left fog lamp
• Left outboard headlamp
• Low
• Off
• Park
• Pnk/ red
• Power distribution center (in engine compartment, on left inner fender panel, near battery)
• Right fog lamp
• Right outboard headlamp
• S106 (headlamp & dash harness, in power distribution center)
• S110 (headlamp & dash harness, near left wheel speed sensor)
• S134 (fog lamp harness, in breakout to right fog lamp)
• S183 (headlamp & dash harness, in power distribution center)

HORN

Horn Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Horn Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (left side dash, under inst panel)
• (right front of engine compartment)
• Central timer module (left side dash, under inst panel)
• Clock- spring
• Fuse h 20a
• G100 (left fender side shield)
• High note horn
• Horn relay
• Hot at all times
• Joint connector 1 (in pdc)
• Joint connector 6
• Left horn switch
• Low note horn
• Nca
• Other
• Power distribution center (on left inner fender panel, near battery)
• Right horn switch
• S150
• Vehicle speed control/ horn switch
• W/ central timer module (highline)

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500:

• (diesel)
• (engine harn, near fuel injector breakout) s117
• 025.6
• 4wd
• 4wd ind
• 4wd switch (on transmission)
• A10
• Abs ind
• Air bag ind
• B10
• Bright sen
• C1 (conn a)
• C2 (conn b)
• Ccd (+)
• Ccd (-)
• Check engine ind
• Check gauges ind
• Club cab
• Controller anti-lock brake (in engine compt, on hydraulic control unit)
• Coolant temp gauge
• Cruise on ind
• Daytime running lamp module (left front inner fender panel)
• Exterior lights system
• Fuel gauge
• Fuse 10a
• Fuse 5a
• G100 (left fender side shield)
• G200 (left kick panel)
• G201 (right center of dash)
• G300 (left kick panel)
• G301 (below left rear speaker)
• Gnd
• Headlights system
• Hi beam ind
• Hot at all times
• Hot in park or head
• Hot in run or start
• Illlumination (7 bulbs)
• Instrument cluster
• Joint connector 5 (left side of dash)
• Junction block (left end of dash)
• Left turn ind
• Low fuel warn ind
• Low washer ind
• Odometer
• Oil pressure gauge
• Overdrive ind
• Park brake ind
• Park brake switch (on park brake mechanism)
• Right turn ind
• S151
• S152
• S311
• S328
• Seat belt
• Seat belt switch (above left rear speaker)
• Seat belt warn ind
• Service reminder lamp
• Solid state gauge and indicator driver module
• Speedometer
• Standard cab
• Tachometer
• Tan
• Tone req
• Tone request
• Trans temp warn ind
• Trip odometer
• Upshift ind
• Voltmeter
• W/ drl only
• W/ power seat only
• Wait-to-start ind
• Wash fluid
• Washer fluid level switch (washer fluid reservoir)
• Water-in fuel ind

Instrument Cluster Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500:

• (diesel only)
• (diesel)
• (engine harn, center of firewall) s172
• (engine harn, center of firewall) s173
• (engine harn, near engine control module)
• (engine harn, near fuel injector 5) s121
• (gas)
• (left rear of engine compartment) s174
• 5v ref
• Air bag control module (behind lower center of dash)
• Ccd (+)
• Ccd (-)
• Central timer module/ integrated electronic module (under left side of dash)
• Controller anti-lock brake (left front inner fender panel)
• Cruise control
• Ect
• Engine control module (diesel) (left side of engine, behind fuel filter)
• Engine controls
• Engine coolant temperature sensor (5.9l: in water jacket, at intake manifold) (8.0l: on thermostat housing)
• Engine coolant temperature sensor (diesel: front of cylinder head, near thermostat housing)
• Engine oil pressure sensor (5.9l: near distributor) (8.0l: near oil filter)
• Engine oil pressure sensor (diesel: left side of engine, near ecm)
• Eop
• Fuel lvl
• Fuel pump module (top of fuel tank)
• G13
• G200 (left kick panel)
• G60
• G85
• Joint connector 7 (left side of dash)
• K104
• K226
• O/d sense
• Overdrive switch (on steering column)
• Powertrain control module (right side of firewall)
• S118
• S165
• S166
• Sens rtn
• Spd ctrl
• T54
• Tone req
• Trans temp
• Transmission solenoid assembly (left side of transmission)
• V37
• Vss out
• Wait ind
• Water in fuel sensor (diesel: bottom of fuel filter/ water seperator canister)
• Wif

Overhead Console Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Overhead Console Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (behind left side
• Ambient air temperature sensor (underside of hood panel, near latch striker)
• Ccd bus (+)
• Ccd bus (-)
• Central timer module
• Computer data lines
• Courtesy lmps
• F12
• Fuse 10a
• Fused b+
• G200 (left kick panel)
• G31
• G32
• G69
• Ground
• Hot at all times
• Hot in run or start
• Ign (st/run)
• Interior lights
• Junction block (left end of dash)
• Of dash)
• Overhead console
• Pnk
• S324
• S326
• S340
• Sensor ground
• Temp sensor
• Vtss

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Courtesy Lamps Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (at roof lamps) s323
• (at roof lamps) s326
• Base
• Cargo lamp 1
• Cargo lamp 2
• Central timer module (left side of dash)
• Data link connector (left bottom of dash)
• Dome lamp
• Driver door jamb switch
• Except base
• Fuse 10a
• G100 (left fender side shield)
• G200 (left end of dash)
• G201 (dash panel right center support)
• G300 (left lower kick panel)
• Glove box lamp & switch
• Headlamp switch
• High-line
• Highline
• Hot at all times
• Ignition switch
• Illumination parade dome cargo off park head
• J/c 5 (behind left side of dash)
• J/c 6 (near left kick panel)
• J/c 8 (near left kick panel)
• Junction block (left end of dash)
• Left visor/ vanity lamp
• Nca
• Overhead console
• Passenger door jamb switch
• Pnk
• Power mirrors switch
• Radio
• Right visor/ vanity lamp
• S151
• S305
• S310 (at left body ground)
• S332 (body harn, left side of dash)
• S340 (at roof lamps) (high-line only)
• Tan
• Underhood lamp

Instrument Illumination Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Instrument Illumination Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• A/c heater control
• Ash receiver lamp
• Cup holder lamp
• Exterior lights system
• Fuse 5 5a
• G201 (dash panel right center support)
• Head
• Headlamp switch
• Hot at all times
• Illumination parade dome cargo
• Instrument cluster
• J/c 5 (near left kick panel)
• J/c 8 (near left kick panel)
• Junction block (left end of dash)
• Off
• Park
• Radio
• Tan
• Variable dimming
• W/ heated seats
• W/o heated seats

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for Power Distribution Wiring Diagram (1 of 3) for Dodge Cab & Chassis R2002 2500:

• (left rear of engine compt, in breakout to controller anti-lock brake) s113
• (left side of dash) s304
• (near engine control module) s167
• (not used)
• A/c heater temp- erature select
• A/t
• A14
• Acc
• After- market
• Aftermarket trailer tow connector
• Air bag control module
• Automatic shut down relay
• Auxiliary battery (diesel)
• Battery
• Blend door act- uator
• Blower motor relay
• Brake light switch
• Breakout)
• Bypass jumper
• Central timer module
• Cigar lighter
• Circuit breaker 1 20a
• Clutch pedal position switch
• Combi- nation flasher
• Combin- ation flasher
• Con- troller anti-lock brake
• Controller anti-lock brake
• Driver door window/ lock switch
• Driver heated seat switch
• Electric brake provision
• Engine starter motor relay
• Engine control module (diesel)
• Engine starter motor
• Engine starter motor relay
• Except after- market
• Fuel heater relay
• Fuel pump relay
• Fuse 10a
• Fuse 20a
• Fuse 25a
• Fuse 30a
• Fuse 40a
• Fuse 40a (diesel)
• Fuse 50a
• Fuse spare
• G201 (right center of dash)
• Heated mirror switch
• Ignition switch
• Intake air heater relay 1 (diesel)
• Intake air heater relay 2 (diesel)
• Inter- mittent wiper switch
• J/c (in pdc)
• J/c 8 (near junction block)
• Junction block
• M/t
• Nca
• Off
• Passenger door window/ lock switch
• Passenger heated seat switch
• Power distrib- ution center
• Power distribuiton center
• Power distribution center
• Power- train control module (diesel)
• Power- train control module (gas)
• Power- train control module) s161
• Radio
• Red
• Red/
• Run
• Start
• Tan
• To circuit breaker 2 (j/b) (diagram 2 of 3)
• To fuse 11 (j/b) (diagram 3 of 3)
• To fuse b (diagram 2 of 3)
• To generator fuse (diagram 2 of 3)
• To splice s108 (diagram 3 of 3)
• Trailer tow connector
• Trailer tow relay
• Wiper motor
• Wiper motor relay

Power Distribution Wiring Diagram (2 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for Power Distribution Wiring Diagram (2 of 3) for Dodge Cab & Chassis R2002 2500:

• (center of roof pnk at lamps) s326
• (left side of dash) s306
• (near left power seat switch) s327
• (near left rear speaker) s310
• (rear of front bumper) s181
• A (w/0 quad) (w/ quad)
• A/c comp- pressor clutch relay
• Base
• Cargo lamp
• Central timing module
• Circuit breaker 2 20a
• Club cab
• Data link connector
• Daytime running lamp module
• Dome lamp
• Driver door window/ lock switch
• Driver power seat switch
• Engine starter motor relay
• F35
• Fog lamp relay
• From battery (diagram 1 of 3)
• From fuse 1 (pdc) (diagram 1 of 3)
• Fuse 10a
• Fuse 15a
• Fuse b 15a
• Fuse c 15a
• Fuse d 20a
• Fuse e 15a
• Fuse f 20a
• Fuse g 15a
• Fuse gen 140a
• Fuse h 20a
• Fuse i 20a
• Fuse j 10a
• Fuse l 20a
• Gen- erator
• Glove box lamp
• Headlamp switch
• Heated seat relay
• Highline
• Horn relay
• Instrument cluster
• J/c 5 (behind left side of dash)
• Junction block
• Left fog lamp
• Left headlalmp
• Left outboard headlamp
• Left visor/ vanity lamp
• Nca
• Overhead console
• Passenger door window/ lock switch
• Passenger power seat switch
• Pnk
• Pnk/ red
• Pnk/red
• Power distribution center
• Power mirror switch
• Power outlet
• Quad high beam relay
• Radio
• Radio choke relay
• Red
• Red/
• Red/tan
• Right fog lamp
• Right headlalmp
• Right outboard headlamp
• Right visor/ vanity lamp
• S136 (near fog lamp breakout)
• S143 (in fog lamp harness)
• Seat) s337
• Security relay
• Standard cab
• Trans- mission control relay
• Underhood lamp
• W/ drl
• W/o drl

Power Distribution Wiring Diagram (3 of 3) for Dodge Cab & Chassis R2002 2500

List of elements for Power Distribution Wiring Diagram (3 of 3) for Dodge Cab & Chassis R2002 2500:

• (headlamp and dash harn, near left wheel speed sensor) s105
• (headlamp and dash harn, near left wheel speed sensor) s107
• (left front of roof at lamps) s324
• (left rear of engine compt) s171
• A/c compressor clutch relay
• A/t
• Air bag control module
• Automatic day/night mirror
• Back-up lamp switch
• Base/ midline
• Central timer module
• Daytime running lamp module
• Diesel only
• Engine control module
• Evap/purge solenoid
• F12
• F14
• F18
• From fuse 7 (j/b) (diagram 1 of 3)
• From ignition switch (start/run) (diagram 1 of 3)
• Fuel heater relay
• Fuel pump relay (gas)
• Fuse 10a
• Instrument cluster
• J/c 8 (near junction block)
• Junction block
• L10
• M/t
• Other
• Overhead console (highline)
• Park/ neutral position switch
• Passenger air bag on/off switch
• Power distribution center
• Powertrain control module
• S108 (left rear of engine compt)
• W/ drl only

POWER DOOR LOCKS

Power Door Lock Wiring Diagram, with Keyless Entry for Dodge Cab & Chassis R2002 2500

List of elements for Power Door Lock Wiring Diagram, with Keyless Entry for Dodge Cab & Chassis R2002 2500:

• (behind left side of dash)
• Anti-theft system
• Central timer module (left side of dash)
• Courtesy lps
• Door lock
• Door unlock
• Fuse 10a
• G201 (center of dash, on right support)
• G50
• Ground
• Horn relay
• Hot at all times
• Interior lights system
• J/c 5 (left side of dash)
• Junction block (on left end of dash)
• Left door lock motor
• Left door window/ lock switch
• Lock
• Lock sw
• M11
• P30
• P31
• P33
• P34
• Red
• Right door lock motor
• Right door window/ lock switch
• S300
• S301 (behind left side of dash)
• S306
• Sec rly cntrl
• Unlock
• Unlock sw

Power Door Lock Wiring Diagram, without Keyless Entry for Dodge Cab & Chassis R2002 2500

List of elements for Power Door Lock Wiring Diagram, without Keyless Entry for Dodge Cab & Chassis R2002 2500:

• Fuse 10a
• G301 (below left rear speaker)
• Hot at all times
• Junction block (on left end of dash)
• Left door lock motor
• Left door window/ lock switch
• Lock
• Red
• Red s306
• Right door lock motor
• Right door window/ lock switch
• S300 (behind left side of dash)
• S311
• Side of dash) s301
• Unlock

POWER MIRRORS

Power Mirror Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Power Mirror Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• Defogger system
• Down
• Fuse 12 10a
• G300 (left lower kick panel)
• Hot at all times
• J/c 5 (behind (left side of dash)
• Junction block (on left end of dash)
• Left
• Left mirror
• Left power mirror
• Pnk
• Power mirror switch
• Right
• Right mirror
• Right power mirror
• S310
• S329

POWER SEATS

Heated Seats Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Heated Seats Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (near passenger seat jumper breakout) s333
• B+ to module
• Central timer module (left side of dash)
• Driver heated seat cushion (under seat)
• Driver heated seat switch
• F235
• Fuse 10a
• Fuse 15a
• Fused ign sw
• G201 (dash panel right center support)
• G300 (left kick panel)
• Ground
• Heated seat relay
• Hot at all times
• Hot in run
• Htd st rly ctrl c2
• Interior lights system
• Joint connector 5 (left side of dash)
• Joint connector 8 (center of dash)
• Junction block (left end of dash)
• Lt heater b+
• Lt high led
• Lt htd seat sw
• Lt low led
• Lt temp sens
• Lt temp sensor
• P130
• P132
• P137
• P138
• P139
• P140
• P141
• P142
• P144
• Panel lmp feed
• Passenger heated seat cushion (under seat)
• Passenger heated seat switch
• Red
• Rt heater b+
• Rt high led
• Rt htd seat sw
• Rt low led
• Rt temp sens
• Rt temp sensor
• S204 (near cup holder lamp breakout)
• S328
• S335
• S336
• Seat heat interface module (under front seat center cushion)
• Tan
• Temp sens 5v
• Temp sensor 5v

Power Seats Wiring Diagram, Crew Cab for Dodge Cab & Chassis R2002 2500

List of elements for Power Seats Wiring Diagram, Crew Cab for Dodge Cab & Chassis R2002 2500:

• Back
• Circuit breaker 2 20a
• Deflate
• Driver power seat switch
• Driver seat lumbar motor
• F dn
• F up
• Forward/backward seat motor
• Front vertical seat motor
• Fwd
• G300 (left kick panel)
• Hot at all times
• Inflate
• Junction block (left end of dash)
• Passenger power seat switch
• Passenger seat lumbar motor
• R dn
• R up
• Rear vertical seat motor
• S327
• S328
• S336
• S337

Power Seats Wiring Diagram, Standard for Dodge Cab & Chassis R2002 2500

List of elements for Power Seats Wiring Diagram, Standard for Dodge Cab & Chassis R2002 2500:

• Back
• Circuit breaker 2 20a
• Driver power seat switch
• F dn
• F up
• Forward/backward seat motor
• Front vertical seat motor
• Fwd
• G301 (below left rear speaker)
• Hot at all times
• Junction block (left end of dash)
• R dn
• R up
• Rear vertical seat motor
• S311

POWER WINDOWS

Power Window Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Power Window Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (left kick panel) g300
• Circuit breaker 1 20a
• G300 (left kick panel)
• Hot in run
• Junction block (left end of dash)
• Left door window/ lock switch
• Left power window motor
• Right door window/ lock switch
• Right power window motor
• S304 tan
• S329
• S330
• Tan

RADIO

Radio Wiring Diagrams, Base Radio for Dodge Cab & Chassis R2002 2500

List of elements for Radio Wiring Diagrams, Base Radio for Dodge Cab & Chassis R2002 2500:

• Antenna
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Central timer module (left side of dash, inboard of steering column opening)
• Clock- spring 1
• Day sense
• E17
• Fuse 12 10a
• Fuse 8 10a
• Fused b(+)
• Fused ign
• G100 (left fender side shield)
• Hot at all times
• Hot in run or acc
• Illumination
• Interior lights system
• Joint connector (left side of dash)
• Joint connector 7 (behind left side of dash)
• Junction block (left end of dash)
• Left front door speaker
• Left rear speaker
• Left remote radio switch
• Lf spkr (+)
• Lf spkr (-)
• Lr spkr (+)
• Lr spkr (-)
• Mux ctrl
• Nca
• Pnk
• Preset
• Radio
• Rf spkr (+)
• Rf spkr (-)
• Right front door speaker
• Right rear speaker
• Right remote radio switch
• Rr spkr (+)
• Rr spkr (-)
• S209 (steering wheel jumper harn)
• S210 (steering wheel jumper harn)
• Seek dn
• Seek up
• Vol dn
• Vol up
• X12
• X51
• X52
• X53
• X54
• X55
• X56
• X57
• X58

Radio Wiring Diagrams, Premium Radio for Dodge Cab & Chassis R2002 2500

List of elements for Radio Wiring Diagrams, Premium Radio for Dodge Cab & Chassis R2002 2500:

• Amp l rear spkr (+)
• Amp l rear spkr (-)
• Amp r rear spkr (+)
• Amp r rear spkr (-)
• Amp tweeter spkr (+)
• Amp tweeter spkr (-)
• Antenna
• Ccd (+)
• Ccd (-)
• Ccd bus (+)
• Ccd bus (-)
• Central timer module (left side of dash, inboard of steering column opening)
• Choke relay
• Clock- spring 1
• Day sense
• E17
• Fuse 12 10a
• Fuse 4 10a
• Fuse 8 10a
• Fused b(+)
• Fused ign
• G100 (left fender side shield)
• Ground
• Hot at all times
• Hot in run or acc
• Illumination
• Interior lights system
• Joint connector (left side of dash)
• Joint connector 7 (behind left side of dash)
• Junction block (left end of dash)
• L front spkr (+)
• L front spkr (-)
• L rear spkr (+)
• L rear spkr (-)
• Left front door speaker
• Left rear speaker
• Left remote radio switch
• Left tweeter speaker
• Lf spkr (+)
• Lf spkr (-)
• Lr spkr (+)
• Lr spkr (-)
• Mux ctrl
• Nca
• Pnk
• Preset
• R front spkr (+)
• R front spkr (-)
• R rear spkr (+)
• R rear spkr (-)
• Radio
• Radio choke
• Radio choke relay (behind center of dash)
• Rf spkr (+)
• Rf spkr (-)
• Right front door speaker
• Right rear speaker
• Right remote radio switch
• Right tweeter speaker
• Rr spkr (+)
• Rr spkr (-)
• S209
• S210 (steering wheel jumper harn)
• S302
• S303 (dash harn, left side of dash)
• Seek dn
• Seek up
• Vol dn
• Vol up
• X12
• X16
• X51
• X52
• X53
• X54
• X55
• X56
• X57
• X58

STARTING/CHARGING

5.9L

5.9L 24-Valve Diesel, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• A14
• Auxiliary battery
• Battery
• Battery temperature sensor (below battery tray)
• Engine control system
• Fuse 20a
• Fused b+
• G113 (primary battery engine ground)
• G115 (primary battery body ground)
• G117 (auxiliary battery engine ground)
• G118 (primary frame ground)
• G120 (auxiliary battery body ground)
• Gen field
• Gen fuse 140a
• Gen source
• Generator
• Hot at all times
• Joint connector 1 (in pdc)
• Leak detection pump (on right front inner fender)
• Power distribution center (on left fender, near battery)
• Power distribution system
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S116 (transmssion harness, near breakout to pdc)
• S161 (transmssion harness, near breakout to pdc)
• S180 (headlamp & dash harness, near to fuel injectors
• Sensor ground
• Sensor signal
• T125
• Transmission control relay

5.9L 24-Valve Diesel, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• A/t
• Acc
• Auxiliary battery
• Battery
• Bypass jumper (top of clutch pedal)
• Clutch pedal position switch (on cutch master cylinder pushrod)
• Engine control system
• Engine starter motor
• Engine starter motor relay (in pdc)
• Fuse 30a
• Fuse 50a
• G113 (primary battery engine ground)
• G115 (primary battery body ground)
• G117 (auxiliary battery engine ground)
• G118 (primary frame ground)
• G120 (auxiliary battery body ground)
• Hd in
• Ignition switch
• Lock
• M/t
• Off
• Park/ neutral position switch (left side of trans)
• Park/ neutral switch sense
• Pl in
• Power distri- bution center (on left inner fender panel near battery)
• Power- train control module (in engine compt, on right side of firewall)
• Red
• Run
• S127 (transmission harness, near breakout to a/c low pressure switch)
• S128
• Start
• T41

5.9L, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• A14
• Battery
• Battery temperature sensor (below battery tray)
• Except 8.0l m/t
• Fuse 20a
• Fused b+
• G114 (battery engine ground)
• G115
• G116 (battery frame ground)
• Gen field
• Gen fuse 140a
• Gen source
• Generator
• Hot at all times
• Joint connector 1 (in pdc)
• Joint connector 2 (in pdc)
• K20
• Leak detection pump (on right front inner fender)
• Power distribution center (on left fender, near battery)
• Power distribution system
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S116 (engine harness, near breakout to fuel injectors)
• S180 (headlamp & dash harness, near intake heater relay)
• Sensor ground
• Sensor signal
• T125
• Transmission control relay

5.9L, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (except 8.0l) (8.0l)
• A/t
• Acc
• Battery
• Bypass jumper (top of clutch pedal)
• Clutch pedal position switch (on cutch master cylinder pushrod)
• Engine starter motor
• Engine starter motor relay (in pdc)
• Fuse 30a
• Fuse 50a
• G105 (front of engine)
• G114 (battery engine ground)
• G115
• G116 (battery frame ground)
• Hd in
• Ignition switch
• Lock
• M/t
• Off
• Park/ neutral position switch (left side of trans)
• Park/ neutral switch sense
• Pl in
• Power distribution center (on left fender, near battery)
• Power- train control module (in engine compt, on right side of firewall)
• Red
• Run
• S122
• S127 (6 cyl & 8 cyl: engine harness, top of transmission, 10 cyl: trans harn. near breakout to transmission)
• Start
• T41

8.0L

8.0L, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, Charging Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• A14
• Battery
• Battery temperature sensor (below battery tray)
• Except 8.0l m/t
• Fuse 20a
• Fused b+
• G114 (battery engine ground)
• G115
• G116 (battery frame ground)
• Gen field
• Gen fuse 140a
• Gen source
• Generator
• Hot at all times
• Joint connector 1 (in pdc)
• Joint connector 2 (in pdc)
• K20
• Leak detection pump (on right front inner fender)
• Power distribution center (on left fender, near battery)
• Power distribution system
• Powertrain control module (in eng compt, on right side of firewall)
• Red
• S116 (engine harness, near breakout to fuel injectors)
• S180 (headlamp & dash harness, near intake heater relay)
• Sensor ground
• Sensor signal
• T125
• Transmission control relay

8.0L, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, Starting Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (except 8.0l) (8.0l)
• A/t
• Acc
• Battery
• Bypass jumper (top of clutch pedal)
• Clutch pedal position switch (on cutch master cylinder pushrod)
• Engine starter motor
• Engine starter motor relay (in pdc)
• Fuse 30a
• Fuse 50a
• G105 (front of engine)
• G114 (battery engine ground)
• G115
• G116 (battery frame ground)
• Hd in
• Ignition switch
• Lock
• M/t
• Off
• Park/ neutral position switch (left side of trans)
• Park/ neutral switch sense
• Pl in
• Power distribution center (on left fender, near battery)
• Power- train control module (in engine compt, on right side of firewall)
• Red
• Run
• S122
• S127 (6 cyl & 8 cyl: engine harness, top of transmission, 10 cyl: trans harn. near breakout to transmission)
• Start
• T41

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Supplemental Restraint Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (center of dash) j/c 8
• (left fender side shield) g100
• Air bag control module (behind lower center of dash)
• Air bag warning indicator
• Bus (+)
• Bus (-)
• Ccd (+)
• Ccd (-)
• Clockspring
• Data link connector (dlc) (partial) (on left bottom of dash)
• Driver air bag
• F14
• F23
• Fuse 18 10a
• Fuse 19 10a
• Ground
• Hot in run
• Hot in run or start
• Ignition
• Indicator driver
• Instrument cluster
• J/c 7 (left side of dash)
• J/c 8 (center of dash)
• Junction block (on left end of dash)
• Line
• Line 1
• Line 2
• Nca
• Off indicator
• Passenger air bag
• Passenger air bag on/off switch
• R142
• R144
• R43
• R45
• Resistor fused

TRANSMISSION

5.9L

5.9L 24-Valve Diesel, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500:

• (eng harn, near breakout to a/c low pressure switch)
• (primary battery body ground) g115
• (trans harn, in breakout to pdc)
• (trans harn, in breakout to pdc)
• 4wd switch
• 4x4 ind
• A14
• Acc pdl pos sens
• Brake lamp switch (on brake pedal bracket)
• Brake sw sens
• Ccd (+)
• Ccd (-)
• Ckp sens sig
• D20
• D21
• D220
• Data link connector (partial) (on left bottom of dash)
• Ect sens sig
• Engine control module (on left side of engine, behind fuel filter)
• F18
• Fuse 10a
• Fused (b+)
• Fused b(+)
• Fused ign (st/run)
• G100 (left fender side shield)
• G200 (on left end of dash)
• Generator output
• Gnd
• Gov pres sol ctrl
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector 1 (in pdc)
• Joint connector 7
• Junction block (on left end of dash)
• K104
• K22
• K24
• K30
• K54
• K88
• Od ind
• Output speed sensor (on left side of transmission)
• Output ss gnd
• Output ss sig
• Overdrive switch
• Pnk
• Pnp sw sens
• Powertrain control module (in engine compt, on right side of firewall)
• S107
• S111 (trans harn, near breakout to a/c low pressure switch)
• S126
• S151
• S152 (near left front wheel speed sensor)
• S161
• S167
• S171
• S172
• S173
• S174
• S175
• Sci receive
• Sci transit
• Sci transmit
• Sensor gnd
• Sensor ground
• Shift sol ctrl
• T125
• T13
• T14
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Trans od sw sens
• Trans rly ctrl
• Trans temp sens
• V40
• Vss signal
• Z12

5.9L 24-Valve Diesel, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L 24-Valve Diesel, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500:

• Controller anti-lock brake (rwabs: on left front inner fender, 4wabs: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (on front of cyl head, near thermostat housing)
• Engine starter motor relay
• Fuse 20a
• Fuse i 20a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Overdrive solenoid
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center (in engine compt, on left inner fender panel, near battery)
• Red
• S116 (trans harn, in breakout to pdc)
• S127 (trans harn, near breakout to a/c low pressure switch)
• S165 (engine harn, near ecm)
• S179 (trans harn, in breakout to pdc)
• Sensor ground
• Torque converter clutch solenoid
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (on left side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid

5.9L, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500:

• (on left bottom of dash)
• 4wd switch
• 4x4 ind
• A14
• Brake lamp switch (on brake pedal bracket)
• Brake sw sens
• Ccd (+)
• Ccd (-)
• D20
• D21
• Data link connector (partial)
• Ect sens sig
• F18
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G100 (left fender side shield)
• G105 (front of engine)
• G200 (on left end of dash)
• Generator output
• Gnd
• Gov pres sol ctrl
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector
• Joint connector 1 (in pdc)
• Junction block (on left end of dash)
• K22
• K30
• K54
• K88
• Od ind
• Output speed sensor (on left side of transmission)
• Output ss gnd
• Output ss sig
• Overdrive switch
• Pnk
• Pnp sw sens
• Powertrain control module (in engine compt, on right side of firewall)
• S107
• S126
• S151
• S152 (near left front wheel speed sensor)
• Sci receive
• Sci transmit
• Sensor gnd
• Shift sol ctrl
• T125
• T13
• T14
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sens
• Trans rly ctrl
• Trans temp sens
• V40
• Vss signal
• Z12

5.9L, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 5.9L, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500:

• (engine harn, 5.9l: near nreakout to fuel injectors; 8.0l: rear of engine)
• Controller anti- lock brake (rwabs: on left front inner fender; 4wabs: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (5.9l: in water jacket, at front of intake manifold; 8.0l: on thermostat housing)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse i 20a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Leak detection pump (on right front inner fender)
• Overdrive solenoid
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center (in engine compt, on left inner fender panel, near battery)
• Red
• S116 (engine harn, 5.9l: near breakout to fuel injectors; 8.0l: rear of engine)
• S118
• S119 (engine harn, 5.9l: near breakout to fuel injectors; 8.0l: rear of engine)
• S127 (engine harn, 5.9l: on top of transmission; 8.0l: near breakout to transmission)
• Sensor ground
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (on left side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid

8.0L

8.0L, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, A/T Wiring Diagram (1 of 2) for Dodge Cab & Chassis R2002 2500:

• (on left bottom of dash)
• 4wd switch
• 4x4 ind
• A14
• Brake lamp switch (on brake pedal bracket)
• Brake sw sens
• Ccd (+)
• Ccd (-)
• D20
• D21
• Data link connector (partial)
• Ect sens sig
• F18
• Fuse 10a
• Fused b(+)
• Fused ign (st/run)
• G100 (left fender side shield)
• G105 (front of engine)
• G200 (on left end of dash)
• Generator output
• Gnd
• Gov pres sol ctrl
• Gov press sig
• Hot at all times
• Hot in run or start
• Instrument cluster
• Joint connector
• Joint connector 1 (in pdc)
• Junction block (on left end of dash)
• K22
• K30
• K54
• K88
• Od ind
• Output speed sensor (on left side of transmission)
• Output ss gnd
• Output ss sig
• Overdrive switch
• Pnk
• Pnp sw sens
• Powertrain control module (in engine compt, on right side of firewall)
• S107
• S126
• S151
• S152 (near left front wheel speed sensor)
• Sci receive
• Sci transmit
• Sensor gnd
• Shift sol ctrl
• T125
• T13
• T14
• T25
• T41
• T54
• T60
• Tcc sol ctrl
• Tp sens sig
• Trans od sw sens
• Trans rly ctrl
• Trans temp sens
• V40
• Vss signal
• Z12

8.0L, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500

List of elements for 8.0L, A/T Wiring Diagram (2 of 2) for Dodge Cab & Chassis R2002 2500:

• (engine harn, 5.9l: near nreakout to fuel injectors; 8.0l: rear of engine)
• Controller anti- lock brake (rwabs: on left front inner fender; 4wabs: mounted on top of hydraulic control unit)
• Engine controls system
• Engine coolant temperature sensor (5.9l: in water jacket, at front of intake manifold; 8.0l: on thermostat housing)
• Engine starter motor relay
• Fuel pump relay
• Fuse 20a
• Fuse i 20a
• Generator
• Governor pressure signal
• Hot at all times
• Joint connector
• Leak detection pump (on right front inner fender)
• Overdrive solenoid
• Park/neutral position switch (on left side of transmission)
• Pnk
• Power distribution center
• Power distribution center (in engine compt, on left inner fender panel, near battery)
• Red
• S116 (engine harn, 5.9l: near breakout to fuel injectors; 8.0l: rear of engine)
• S118
• S119 (engine harn, 5.9l: near breakout to fuel injectors; 8.0l: rear of engine)
• S127 (engine harn, 5.9l: on top of transmission; 8.0l: near breakout to transmission)
• Sensor ground
• Throttle position sensor (on throttle body)
• Torque converter clutch solenoid
• Trans ctrl rly output
• Transmission control relay
• Transmission solenoid assembly (on left side of transmission)
• Transmission temperature sensor signal
• Variable force solenoid

WARNING SYSTEMS

Warning System Wiring Diagrams for Dodge Cab & Chassis R2002 2500

List of elements for Warning System Wiring Diagrams for Dodge Cab & Chassis R2002 2500:

• (club cab)
• (standard cab)
• Base/midline
• Central timer module (left side of dash)
• Driver door ajar switch
• F12
• F35
• Fuse 10a
• Fuse 25a
• Fused b(+)
• Fused ign
• G13
• G200 (left end of dash)
• G26
• G300 (left kick panel)
• G301 (below left rear speaker)
• G75
• Ground
• Headlamp switch
• Highline
• Hot at all times
• Hot in run or acc
• Hot in run or start
• Ignition switch
• Instrument cluster
• J/c 6 (behind left side of dash)
• J/c 8 (center of dash)
• Junction block (left end of dash)
• Key-in switch
• Key-in/ lf dr ajar switch sense
• Key-in/lights on warning
• Off
• Red
• S311
• S328 (power seat only)
• Seat belt ind
• Seat- belt sw sense
• Seat- belt switch
• Tan
• Tone request

WIPER/WASHER

Wiper/Washer Wiring Diagram for Dodge Cab & Chassis R2002 2500

List of elements for Wiper/Washer Wiring Diagram for Dodge Cab & Chassis R2002 2500:

• (instrument panel harness, near overdrive switch)
• (left front of engine compartment) s151
• (part of multi-function switch) intermittent wiper switch
• 87a
• Central timer module (on left side of dash, inboard of steering column opening)
• Fuse 6 25a
• G100 (left fender side shield)
• High
• Hot in run or acc
• Indicator driver
• Instrument cluster
• Int
• J/c 2 (in power distribution center)
• J/c 6 (left side of dash)
• Junction block (on left end of dash)
• L0w
• Low
• Low washer indicator
• Nca
• Off
• Park switch
• Ptc
• S202
• S203
• V10
• V18
• Washer fluid level switch (on side of washer fluid reservoir)
• Washer switch
• Washer switch sense
• Windshield washer pump (in bottom of windshield washer reservoir)
• Windshield wiper motor (in engine compartment, on center of firewall)
• Wiper motor relay (on power distribution center)
• Wiper motor relay ctrl
• Wiper park switch sense
• Wiper switch mode sense
• Wiper switch mode signal