All Wiring Diagrams for Dodge Sprinter 2004 2500

AIR CONDITIONING

Automatic A/C Wiring Diagram (1 of 2) for Dodge Sprinter 2004 2500

List of elements for Automatic A/C Wiring Diagram (1 of 2) for Dodge Sprinter 2004 2500:

• (behind center of dash) s218
• (behind left side of dash) g203
• (left rear of engine compt) g200
• (rest system)
• 0 off 1 low 2 med-low 3 med-high 4 high
• 5v ref
• A/c aux fan rly ctrl
• A/c auxiliary fan relay (in relay block)
• A/c comp clutch (+)
• A/c compressor clutch
• Air outlet temperature sensor (right rear of engine compt)
• Aot sens sig
• Automatic temperature control module
• Auxiliary heater timer
• Blower motor resistor block (right rear of engine compt)
• C2 c2
• Cabin heater assembly
• Can c bus (+)
• Can c bus (-)
• Circ pmp mtr (+)
• Circ pmp mtr req
• Circulation pump (front of engine compt)
• Computer data lines system
• D+ rly 1 output
• Evap temp sen sig
• Evaporator temperature sensor (under right side of dash)
• Fuse 15a
• Fuse 30a
• Fuse block 1 (under steering column)
• Fuse/ relay block
• G202 (under driver's seat)
• Gnd
• Hot at all times
• Htr booster mode
• Htr booster mode ctrl
• Ic 18-c2 to atcm 8-c1
• Interior lights system
• K-ic/atc/hbm/chm
• Lamp driver
• Nca
• Recirc air sol vlv (+)
• Red
• Refrig press sen sig
• Refrigerant pressure sensor (left front of engine compt)
• S201 (behind center of dash)
• S201 com cir
• S209
• S223
• Sens gnd
• Sig
• W/ program timer
• W/o program timer
• Wtr cycl vlv (duty cycl)

Automatic A/C Wiring Diagram (2 of 2) for Dodge Sprinter 2004 2500

List of elements for Automatic A/C Wiring Diagram (2 of 2) for Dodge Sprinter 2004 2500:

• (in engine compt) a/c auxiliary fan
• (in engine compt) water cycle valve
• (left rear of engine compt) g200
• 87a
• Amb temp sens rtn
• Amb temp sens sig (+)
• Ambient temperature sensor (under left side of dash)
• Cabin heater assembly
• Computer data lines system
• D+ relay 1 (in relay block
• D+ rly 1 ctrl
• Fan stage 1 relay (relay block)
• Fan stg 1 rly
• Front blower motor (right side of engine compt)
• Fuse 10a
• Fuse 125a
• Fuse 15a
• Fuse block 2 (under steering column)
• Fuse block 3
• G102 (right front of engine compt)
• G200 (left rear of engine compt)
• G202 (under driver's seat)
• Hot at all times
• Ic 18-c2 to atcm 8-c1
• Instrument cluster
• Nca
• Power distribution center (left side of engine compt)
• Recirculated air solenoid valve (right side of engine compt)
• Red
• S100
• S231
• S232
• S310 (behind center of dash)
• S350 (near trailer tow connector)

Auxiliary Blower Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Auxiliary Blower Wiring Diagram for Dodge Sprinter 2004 2500:

• (behind left side of dash) g203
• (not used)
• (top right rear of vehicle) g301
• 12v a/c fan high
• 12v a/c fan low
• Fuse 10a
• Fuse 15a
• Fuse block 2 (under driver's seat)
• Fuse block 3
• Fuse/ relay block (under driver's seat)
• Ground
• Hot at all times
• Hot w/ d+ relay 1 energized
• Hot w/ optional equipment relay energized
• Interior lights system
• Nca
• Red
• Roof a/c control module (in dash)
• Roof a/c switch
• Roof a/c temperature setting control
• Roof fan motor (in headliner)
• Roof fan switch
• S256 (behind center of dash)
• S310
• S365 (behind center of dash)
• Temp sw sens
• Temp sw sig

Auxiliary Heater Wiring Diagram (1 of 3) for Dodge Sprinter 2004 2500

List of elements for Auxiliary Heater Wiring Diagram (1 of 3) for Dodge Sprinter 2004 2500:

• (under dash) metering pump
• A rest system
• Aux htr sw (+)
• Auxiliary heater timer
• B cabin heater module
• C w/ program timer
• Cabin heater assembly
• Cabin htr ctrl
• Circ pmp mtr req
• Circ pmp mtr rly hi ctrl
• Computer data lines system
• D w/o program timer
• Dosing pump ctrl
• Fan stage 1 rly hi ctrl
• Fuse 25a
• Fuse 7.5a
• Fuse block 3
• G100 (right front of engine compt)
• G202 (under driver's seat)
• G203 (behind left side of dash)
• Gnd
• Ground
• Heater timer control module
• Hot at all times
• Htr booster mode ctrl
• Htr timer
• Htr timer (cut-in sig)
• Interior lights system
• K-ctm/ssm
• K-ic/atc/hbm/chm
• Metering pump
• Nca
• Otp equip rly out
• Red
• S201 com circt
• S211
• Security system module
• Warm air aux htr ctrl
• Warm air auxiliary heater assembly

Auxiliary Heater Wiring Diagram (2 of 3) for Dodge Sprinter 2004 2500

List of elements for Auxiliary Heater Wiring Diagram (2 of 3) for Dodge Sprinter 2004 2500:

• (not used)
• Additional heat exchanger
• Additional heat exchanger relay (relay block)
• Additional heat exchanger switch
• Controller anti-lock brake (left side of engine compt)
• Fuse 25a
• Fuse block 3
• G202 (under driver's seat)
• G203 (behind left side of dash)
• Hot at all times
• Interior lights system
• S201 (behind center of dash)
• Tcs sw (asr) sens
• Tcs switch (asr)

Auxiliary Heater Wiring Diagram (3 of 3) for Dodge Sprinter 2004 2500

List of elements for Auxiliary Heater Wiring Diagram (3 of 3) for Dodge Sprinter 2004 2500:

• (not used)
• 87a
• Automatic temperature control module
• Auxiliary heater switch
• B cabin heater module
• Blwr mtr sel 1
• Circ pmp mtr req
• Circulation pump (cabin heater module) (front of engine compt)
• Circulation pump diode
• Circulation pump relay (relay block)
• D w/o program timer
• Dosing pump
• Fan stage 1 relay (relay block)
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 70a
• Fuse block 1 (under steering column)
• Fuse block 3
• G100 (right front of engine compt)
• G200 (left rear of engine compt)
• G202 (under driver's
• G202 (under driver's seat)
• G203 (behind left side of dash)
• Hot at all times
• Hot in run and start
• Htr bstr mode ctrl
• Interior lights system
• Optional equipment relay (in relay) block
• Power distribution center (left side of engine compt)
• Red
• S201 com circt
• S206
• S223
• S252
• S311 (under driver's seat)
• S327 (near security system module)
• S362

ANTI-LOCK BRAKES

Anti-lock Brakes Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Anti-lock Brakes Wiring Diagram for Dodge Sprinter 2004 2500:

• (left front of eng compt)
• (not used)
• Additional heat exchanger switch
• Automatic temperature control module
• Auxiliary heater timer (under driver's seat)
• Brake lamp sw out
• Brake lamp switch (on brake pedal support)
• Brake sw out
• Can c bus (+)
• Can c bus (-)
• Common circuit
• Computer data lines system
• Controller anti-lock brake (left side of eng compt)
• Data link connector (under dash)
• Fuse 10a
• Fuse 25a
• Fuse 40a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse/relay block (under driver's seat)
• Fused b (+)
• Fused relay out
• G100
• G302
• Grd
• Hot at all times
• Hot in run or start
• Instrument cluster
• Interior lights system
• K-abs/shifter assembly
• Left front wheel speed sensor
• Left rear wheel speed sensor
• Lf whl spd sens (+)
• Lf whl spd sens (-)
• Lr whl spd sens (+)
• Lr whl spd sens (-)
• Red
• Rf whl spd sens (+)
• Rf whl spd sens (-)
• Right front wheel speed sensor
• Right rear wheel speed sensor
• Rr whl spd sens (+)
• Rr whl spd sens (-)
• S201
• S201 (behind center of dash)
• S204
• S229 (left side of eng compt)
• S251 (left side of eng compt)
• S307
• S312
• S313
• S314
• S315
• Tcs sw (asr) sens
• Tcs switch (asr)

ANTI-THEFT

Anti-theft Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Anti-theft Wiring Diagram for Dodge Sprinter 2004 2500:

• (left front of roof panel)
• (left front of roof panel) s212
• (left rear of engine compt)
• (near center of right roof rail) s354
• Aux htr ctrl
• Central timer module (behind dash)
• Data link connector (under dash)
• Defog rly lt
• Defogger system
• Defor rly rt
• Door ajar sw sens
• Dr cyl lock
• Dr cyl unlock
• Driver cylinder lock switch
• Exterior lights system
• Frt ctsy lps ctrl
• Fuse 15a
• Fuse 7.5a
• Fuse block 3
• Fused b+
• G101 (right front of engine compt)
• G200
• G200 (left rear of engine compt)
• G202 (under driver's seat)
• G203 (behind left side of dash)
• Ground
• Hood ajar sw sens
• Hood ajar switch
• Hot at all times
• Hot in run
• Int sens 1 sig
• Int sens 2 sig
• Int sens 3 sig
• Int sens ind ctrl
• Int sns sw
• Interior lights system
• Intrusion sens int
• Intrusion sensor 1
• Intrusion sensor 2
• Intrusion sensor 3
• Intrusion sensor sw
• K-ctm/ssm
• Lamp drv
• Left sliding door jamb switch
• Lt turn sig
• Nca
• Opt equip rly out
• Panic alarm switch
• Panic sw sens
• Rear door jamb switch
• Red
• Right interior lamp
• Right sliding door jamb switch
• Rke interface
• Rt turn sig
• S213
• S214
• S222
• S309
• Sec sys int
• Sec sys intr
• Security system module (behind dash)
• Sens 1 sig
• Sens 2 sig
• Sens 3 sig
• Sens int
• Sentry key remote entry module (skreem) (behind dash)
• Siren (left rear of engine compt)
• Siren sig ctrl
• Tow int drv
• Tow sens sw
• Towing sensor sw
• Towing/intrusion sensor on/off switch
• Warm air auxiliary heater assembly

BODY CONTROL MODULES

Body Control Modules Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Body Control Modules Wiring Diagram for Dodge Sprinter 2004 2500:

• (under driver's seat)
• Acc-run-start
• Anti-theft system
• Central timer module (behind dash)
• Computer data lines system
• Door locks system
• Driver dr ajar ind driver
• Driver dr lock driver
• Driver dr lock sens
• Driver dr unlock driver
• Driver dr unlock sense
• Enhanced accident report driver
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fused b (+)
• Fused d (+) rly output
• G202
• Grd
• Hot at all times
• Hot in acc, run or start
• Hot w/ d+ relay 1 energized
• K-ctm/ssm
• Lft sliding dr lock sens
• Lft sliding dr unlock sens
• Master dr lock sw sens
• Master dr lock sw-pass drs
• Pass dr ajar ind driver
• Pass drs lock driver (+)
• Pass drs unlock driver (+)
• Pass front dr lock sens
• Pass front dr unlock sens
• Rear dr lock sens
• Rear dr unlock sens
• Rht sliding dr lock sens
• Rht sliding dr unlock sens
• Rke interface
• S255
• S310

COMPUTER DATA LINES

Computer Data Lines Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Computer Data Lines Wiring Diagram for Dodge Sprinter 2004 2500:

• Airbag control module (under driver's seat)
• Automatic temperature control module
• Cabin heater assembly
• Can c bus (+)
• Can c bus (-)
• Central timer module (behind dash)
• Controller anti-lock brake (left side of engine compt)
• Data link connector (under dash)
• Engine control module (left end of dash)
• Fuse 10a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• G200 (left rear of engine compt)
• Hot at all times
• Hot in run or start
• Instrument cluster
• K-abs/shftr assembly
• K-acm
• K-ctm/ssm
• K-ecm
• K-ic/atc/ hbm/chm
• K-skreem
• K-tcm/radio
• Nca
• Radio
• S204
• S221 (near data link connector)
• S222 (near security system module)
• S229 (left side of engine compt)
• S231
• S232
• S257
• S259
• S260
• S261
• Security system module
• Sentry key remote entry module (behind of dash)
• Shifter assembly
• Transmission control module
• Twisted pair
• Warm air auxiliary heater module

CRUISE CONTROL

Cruise Control Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Cruise Control Wiring Diagram for Dodge Sprinter 2004 2500:

• 87a
• Accel/ set
• Accel/set sig
• Anti-lock brake controller (left side of engine compt)
• Brake lamp switch (on brake pedal support)
• Brake sw out
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Decel/ set
• Decel/set sig
• Eng ctrl rly ctrl
• Eng ctrl rly sig
• Engine control module (left end of dash)
• Engine control relay
• Fuse 10a
• Fuse 15a
• Fuse block 1 (under steering column)
• Fused eng ctrl rly output
• G200 (left rear of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Hot in start
• Ign sw (run/start)
• Ign sw (start)
• Nca
• Off sig
• Off/on
• Red
• Resume
• Resume sig
• S200
• S204
• S217
• S219
• S251
• Speed control switch
• Verification sig
• Verification switch
• Wiper/turn signal/ engine start control module

DEFOGGERS

Heated Mirrors Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Heated Mirrors Wiring Diagram for Dodge Sprinter 2004 2500:

• (behind left side of dash)
• Driver power mirror motor
• Fuse 10a
• Fuse block 2 (under driver's seat)
• G203
• Hot in run or start
• Nca
• Passenger power mirror motor
• S304
• S305

Rear Defogger Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Rear Defogger Wiring Diagram for Dodge Sprinter 2004 2500:

• (under driver's seat)
• D(+) rly 1 out
• Defog sw-rear out
• Fuse 15a
• Fuse 30a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fuse/relay block (under driver's seat)
• Fused b(+)
• G202
• G202 (under driver's seat)
• G203 (behind left side of dash)
• G300 (rear of vehicle)
• Grd
• Hot at all times
• Hot in run or start
• Hot w/ d+ relay energized
• Interior lights system
• Lamp driver
• Left rear window defogger
• Left rear window defogger relay
• Rear window defogger module
• Rear window defogger switch
• Relay block (under driver's seat)
• Right rear window defogger
• Right rear window defogger relay
• Rr wdo defog sig
• S206
• S310
• S330 (near security system module)
• S355
• Security system module
• Wdo defog-lr sig

Rear Defogger Wiring Diagram, without Defogger Relays for Dodge Sprinter 2004 2500

List of elements for Rear Defogger Wiring Diagram, without Defogger Relays for Dodge Sprinter 2004 2500:

• (under driver's seat)
• D(+) rly 1 out
• Defog sw-rear out
• Fuse 15a
• Fuse 30a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fuse/relay block (under driver's seat)
• Fused b(+)
• G202
• G203 (behind left side of dash)
• G300 (rear of vehicle)
• Grd
• Hot at all times
• Hot in run or start
• Hot w/ d+ relay energized
• Interior lights system
• Lamp driver
• Left rear window defogger
• Rear window defogger module
• Rear window defogger switch
• Right rear window defogger
• Rr wdo defog sig
• S206
• S310
• S330 (near security system module)
• S355
• Security system module
• Wdo defog-lr sig

ENGINE PERFORMANCE

2.7L

2.7L, Engine Performance Wiring Diagram (1 of 5) for Dodge Sprinter 2004 2500

List of elements for 2.7L, Engine Performance Wiring Diagram (1 of 5) for Dodge Sprinter 2004 2500:

• (16-19 not used)
• (41-48 not used)
• (63-71 not used)
• (in air intake duct) intake air pressure sensor
• (in engine compt) fuel temperature sensor
• (left side of engine compt)
• (on engine)
• 5 volt
• Boost press servo ctrl
• Boost pressure servomotor
• Cps ground
• Cps sig
• Cps sig 1
• Cps sig 2
• Crankcase heater (in engine compt)
• Crankshaft position sensor
• Crnkcase htr ground
• Crnkcase htr sig
• Ctrl
• Ecm c1 cav 15/62 o2 sen 1/5
• Ecm c1 cav 39 o2 sen cav 6
• Ecm c1 cav 40 o2 sen cav 2
• Ecm c1 cav 72 os sen cav 3
• Ect sens ground
• Ect sens sig
• Egr valve (on engine)
• Egr vlv ctrl
• Engine control module (left end of dash)
• Fps ground
• Fps sig
• Fuel inj 1 high side ctrl
• Fuel inj 1 low side ctrl
• Fuel inj 2 high side ctrl
• Fuel inj 2 low side ctrl
• Fuel inj 3 high side ctrl
• Fuel inj 3 low side ctrl
• Fuel inj 4 high side ctrl
• Fuel inj 4 low side ctrl
• Fuel inj 5 high side ctrl
• Fuel inj 5 low side ctrl
• Fuel qlty ctrl vlv ctrl
• Fuel shutdwn sol ctrl
• Fuel temp sens ground
• Fuel temp sens sig
• Gnd
• Ign
• Intake press sens ground
• Intake press sens signal
• Maf sens ground
• Maf sens sig
• Mass air flow sensor (in air intake duct)
• S106
• S107
• S175
• Sig
• Sig 1
• Sig 2
• Water in fuel sen gnd
• Water in fuel sen sig

2.7L, Engine Performance Wiring Diagram (2 of 5) for Dodge Sprinter 2004 2500

List of elements for 2.7L, Engine Performance Wiring Diagram (2 of 5) for Dodge Sprinter 2004 2500:

• (in engine compt) fuel pressure sensor
• (in engine compt) water in fuel sensor
• (rear of engine compt) fuel quality control valve
• 12 volt
• 5 volt
• 87a
• Camshaft position sensor (on front left side of engine)
• Ecm c1 cav 15/62 o2 sen cav 1/5
• Ecm c1 cav o2 sen cav
• Engine control relay
• Engine coolant temperature sensor (on front of engine)
• Fuel injectors
• Fuel shutdown solenoid
• Fuse 15a
• Fuse block 1 (under steering column)
• Gnd
• Hot at all times
• Hot in run or start
• Nca
• Not used
• Oxygen sensor
• S107 common circuit
• S206
• S217
• Sig
• To wiper/turn signal engine start control module (diagram 5 of 5)

2.7L, Engine Performance Wiring Diagram (3 of 5) for Dodge Sprinter 2004 2500

List of elements for 2.7L, Engine Performance Wiring Diagram (3 of 5) for Dodge Sprinter 2004 2500:

• (top of accelerator pedal) accelerator pedal position sensor
• 87a
• Fuel pump
• Fuel pump relay
• Fuse 125a
• Fuse 15a
• Fuse block 1 (under steering column
• G100 (left front of engine compt)
• G202 (under driver's seat)
• Glow plug control module (left front of engine compt)
• Glow plug module control
• Glow plugs
• Gnd
• Gnd 1
• Hot at all times
• Nca
• Power distribution center (left side of engine compt)
• Red
• S108
• Sig 1
• Sig 2
• Starter motor relay

2.7L, Engine Performance Wiring Diagram (4 of 5) for Dodge Sprinter 2004 2500

List of elements for 2.7L, Engine Performance Wiring Diagram (4 of 5) for Dodge Sprinter 2004 2500:

• (front of engine compt) engine coolant level switch
• (in air intake duct) intake air temperature sensor
• (top of fuel tank) fuel level sensor
• (under dash) kickdown switch
• Can c bus (+)
• Can c bus (-)
• Daytime running lights relay (in relay block)
• Eng coolant level sw sig
• Fuel lev sens sig (+)
• Fuel lev sens sig rtn
• Fuse 15a
• Fuse block 3
• G100 (left front of engine compt)
• G200 (left rear of engine compt)
• G203 (behind left side of dash)
• High idle switch
• Hot in run and start
• Instrument cluster
• Nca
• S107
• S306

2.7L, Engine Performance Wiring Diagram (5 of 5) for Dodge Sprinter 2004 2500

List of elements for 2.7L, Engine Performance Wiring Diagram (5 of 5) for Dodge Sprinter 2004 2500:

• (in air intake duct) boost pressure sensor
• 5 volt
• Accel/set sig
• Apps ground 1
• Apps ground 2
• Apps sig 1
• Apps sig 2
• Boost press sen sig
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Cruise control system
• Data link connector (under dash)
• Decel/set sig
• Driver enhncd accdnt report
• Eng ctrl rly ctrl
• Eng ctrl rly sig
• Engine control module (left end of dash)
• Engine rpm
• From engine control relay (diagram 2 of 5)
• Fuel pump rly ctrl
• Fuse 15a
• Fuse block 1 (under steering column)
• Fused eng ctrl rly output
• Fused ign sw output (run/start)
• G200 (left rear of engine compt)
• Glw plug mod ctrl
• Gnd
• Ground
• High idle on sig
• Hot in run and start
• Hot in start
• Iat sens ground
• Iat sens sig
• Ign sw output (start)
• K-ecm
• Kickdwn sw sig
• Off sig
• Red
• Resume sig
• S200
• S219
• S231
• S232
• S259
• S260
• Sensor ground
• Sig
• Starter mtr rly ctrl
• Starting/charging system
• Transmission control module (under driver's seat)
• Verification sig
• Wiper/turn signal/ engine start control module

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Back-up Lamps Wiring Diagram for Dodge Sprinter 2004 2500:

• Back- up lamp
• Back-up lamp
• Fuse 10a
• Fuse block 1 (under steering column)
• Fused ignition
• G203 (behind left side of dash)
• G300 (rear of vehicle)
• Ground
• Hot in run or start
• Left tail lamp assembly
• Right tail lamp assembly
• S320 (under rear center of vehicle)
• Shifter assembly
• Trailer tow connector

Exterior Lamps Wiring Diagram (1 of 3) for Dodge Sprinter 2004 2500

List of elements for Exterior Lamps Wiring Diagram (1 of 3) for Dodge Sprinter 2004 2500:

• (under driver seat)
• Acc
• Brake lamp
• Connector
• Ctrl
• Elec brakes
• Feed
• Fuse 15a
• Fuse 20a
• Fuse block 1 (under steering column)
• Fuse block 3 (under driver seat)
• Fused b+
• G100 (left front of engine compt)
• G102 (right front of engine compt)
• G200 (left rear of engine compt)
• G202
• G300 (rear of vehicle)
• Ground
• Hazard warning switch
• Hazard warning switch sense
• Headlamp switch
• Hot at all times
• Hot in run or start
• Ignition switch
• L stop/turn
• L turn
• Lamp driver
• Left front turn signal 1 lamp
• Left front turn signal 2 lamp
• Left headlamp assembly
• Multi- function switch
• Nca
• Off
• Out
• R stop/turn
• R turn
• Red
• Right front turn signal 1 lamp
• Right front turn signal 2 lamp
• Run
• S333
• S351
• S352
• S358
• Side lamp
• Sig
• Start
• Trailer tow
• Trailer tow control module (rear of vehicle)
• Turn lamp
• Turn signal relay
• Turn signal relay controls
• Turn signal switch
• Wiper/ turn signal/ engine start control module

Exterior Lamps Wiring Diagram (2 of 3) for Dodge Sprinter 2004 2500

List of elements for Exterior Lamps Wiring Diagram (2 of 3) for Dodge Sprinter 2004 2500:

• (behind dash) (if equipped) security system module
• (behind dash) sentry key remote entry module
• (under rear center of vehicle) s320
• Back- up lamp
• Back-up lamps circuit
• Brake lamp
• Brake lamp switch (on brake pedal support)
• Center high mount stop lamp
• Controller anti-lock brake (left side of engine compt)
• Fuse 10a
• Fuse 20a
• Fuse block 1 (under steering column)
• Fuse/ relay block (under driver seat)
• G200 (left rear of engine compt)
• G300 (rear of vehicle)
• Hot at all times
• Hot in run or start
• L turn
• Left tail lamp assembly
• Left turn signal/ anti-theft alarm relay
• Park lamp
• R turn
• Relay block (under driver seat)
• Right tail lamp assembly
• Right turn signal/ anti-theft alarm relay
• S204
• S226
• S227
• S250
• S251 (left side of engine compt)
• S309
• S319 (near left taillamp assembly)
• S351
• S352
• S356
• Turn lamp
• Turn/ theft relay ctrl

Exterior Lamps Wiring Diagram (3 of 3) for Dodge Sprinter 2004 2500

List of elements for Exterior Lamps Wiring Diagram (3 of 3) for Dodge Sprinter 2004 2500:

• 87a
• Daytime running lamps relay
• Fuse 10a
• Fuse 15a
• Fuse 7.5a
• Fuse block 2 (under driver seat)
• G202 (under driver seat)
• G300 (rear of vehicle)
• Hot at all times
• Hot w/ d+ relay 1 energized
• Instrument cluster
• Interior lights system
• L turn
• Lamp driver
• Left center marker lamp
• Left front marker lamp 1
• Left front marker lamp 2
• Left lamp relay
• Left rear marker lamp
• License plate lamp 1
• License plate lamp 2
• Marker lamp connector
• R turn
• Relay block (under the driver seat)
• Right front marker lamp 1
• Right front marker lamp 2
• Right rear marker lamp
• S203 (under driver seat)
• S216
• S310
• S316
• S317
• S318 (near left rear marker lamp)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Dodge Sprinter 2004 2500

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Dodge Sprinter 2004 2500:

• Battery
• Brake fluid level switch
• Center high mounted stop lamp
• Circulation pump
• Clock spring
• Data link connector
• Dome lamp
• Driver cylinder lock switch
• Engine control module
• Front blower motor
• Front wiper motor
• Fuse block 1 (under steering column)
• G200 (left rear of engine compt)
• Hazard warning switch
• Horn switch
• Ignition lock switch
• Instrument cluster
• Interior lamp 1
• Interior lamp 2
• Interior lamp 3
• Interior lamp 4
• Interior lamp 5
• Interior lighting connector
• Intrusion sensor
• Kickdown switch
• Left front brake wear sensor
• Left interior lamp
• Middle front interior lamp
• Middle rear interior lamp
• Multi- function switch
• Nca
• Reading lamp connector
• Rear interior lamp 2
• Recirculated air solenoid valve
• Right front brake wear sensor
• Right interior lamp
• S308 (near interior lamp 3)
• S309
• Sentry key remote entry module
• Siren
• Water cycle valve
• Wiper/ turn signal/ engine start control module

Ground Distribution Wiring Diagram (2 of 4) for Dodge Sprinter 2004 2500

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Dodge Sprinter 2004 2500:

• A/c auxiliary fan
• Cabin heater assembly
• Controller anti-lock brake
• Differential lock solenoid valve
• Dosing pump
• Engine coolant level switch
• Front washer pump motor
• G100 (left front of engine compt)
• G101 (right front of engine compt)
• G102 (right front of engine compt)
• G300 (rear of vehicle)
• Glow plug control module
• Hood ajar switch
• Left front turn signal 1
• Left front turn signal 2
• Left headlamp assembly
• Left rear brake wear sensor
• Left rear marker lamp
• Left rear window defogger
• Left tail lamp assembly
• License plate lamp 1
• License plate lamp 2
• Nca
• Right front turn signal 1
• Right front turn signal 2
• Right headlamp assembly
• Right rear brake wear sensor
• Right rear marker lamp
• Right rear window defogger
• Right tail lamp assembly
• S332 (near left rear brake wear sensor)
• Trailer tow connector

Ground Distribution Wiring Diagram (3 of 4) for Dodge Sprinter 2004 2500

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Dodge Sprinter 2004 2500:

• 87a
• A/c auxiliary fan relay
• Additional heat exchanger
• Additional heat exchanger relay
• Airbag control module
• Auxiliary battery
• Auxiliary battery relay
• Central timer module
• Circulation pump relay
• D + relay 2
• D+ relay 1
• Daytime running lamps relay
• Driver heated seat module
• Fan stage 1 relay
• Fog lamp relay
• Fuel pump
• Fused ignition switch run/start relay
• G202 (under driver's seat)
• Horn relay
• Left center marker lamp
• Left front marker lamp 1
• Left front marker lamp 2
• Left lamp relay
• Left rear window defogger relay
• Left side daytime running lamps relay
• Marker lamp connector
• Nca
• Optional equipment relay
• Parking brake switch
• Passenger heated seat module
• Rear window defogger module
• Right center marker lamp
• Right front marker lamp 1
• Right front marker lamp 2
• Right lamp relay
• Right rear window defogger relay
• Right side daytime running lamps relay
• Seat belt switch
• Security system module
• Time delay relay
• Trailer tow control module
• Trans- mission control module
• Trans- mission relay
• Warm air auxiliary heater assembly

Ground Distribution Wiring Diagram (4 of 4) for Dodge Sprinter 2004 2500

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Dodge Sprinter 2004 2500:

• A/c roof switch
• Additional heat exchanger switch
• Ash receiver lamp
• Automatic temperature control module
• Auxiliary heater switch
• Auxiliary heater timer
• Cigar lighter
• Cigar lighter lamp
• Controller anti-lock brake
• Ctel connector
• Driver heated seat switch
• Driver power mirror motor
• Driver power window switch
• Fog lamp switch
• G203 (behind left side of dash)
• G301 (top right rear of vehicle)
• G302 (left front of engine compt)
• Headlamp adjust switch
• High idle switch
• Instrument panel socket
• Interior light switch
• Locker switch 1
• Map/ reading lamp switch
• Master door lock switch
• Nca
• Panic alarm switch
• Passenger heated seat switch
• Passenger power mirror motor
• Passenger power window switch
• Power mirror switch
• Radio
• Rear window defogger switch
• Roof a/c control module
• Roof fan switch
• S211 (near auxiliary heater timer)
• Shifter assembly
• Tcs switch (asr)
• Towing/ intrusion sensor on/ off switch

HEADLIGHTS

Headlights Wiring Diagram, with DRL for Dodge Sprinter 2004 2500

List of elements for Headlights Wiring Diagram, with DRL for Dodge Sprinter 2004 2500:

• 87a
• Beam select switch
• Fog lamp
• Fog lamp relay
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fuse block 3
• G100 (left front of engine compartment)
• G102 (right front of engine compartment)
• G202 (under driver's seat)
• Headlamp switch
• High beam
• Hot at all times
• Hot with d+ relay 1 energized
• Interior lights system
• Left headlamp assembly
• Left side daytime running lamp relay
• Low beam
• Multi- function switch
• Nca
• Red
• Relay block (under driver's seat)
• Right headlamp assembly
• Right side daytime running lamp relay
• S104 (near left headlamp assembly)
• S205 (under driver's seat)
• S225 (behind dash)

Headlights Wiring Diagram, without DRL for Dodge Sprinter 2004 2500

List of elements for Headlights Wiring Diagram, without DRL for Dodge Sprinter 2004 2500:

• Beam select switch
• Fog lamp
• Fog lamp relay
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse block 3
• G100 (left front of engine compartment)
• G102 (right front of engine compartment)
• G202 (under driver's seat)
• Headlamp switch
• High beam
• Hot at all times
• Interior lights system
• Left headlamp assembly
• Low beam
• Multi- function switch
• Nca
• Red
• Relay block (under driver's seat)
• Right headlamp assembly
• S104 (near left headlamp assembly)
• S225 (behind dash)

HORN

Horn Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Horn Wiring Diagram for Dodge Sprinter 2004 2500:

• Clock- spring
• Fuse 15a
• Fuse block no. 1 (under steering column)
• G200 (left rear of eng compt)
• G202 (under driver's seat)
• Horn (vtss)
• Horn relay (in relay block)
• Horn switch
• Hot in run or start
• Nca
• S206

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram (1 of 2) for Dodge Sprinter 2004 2500

List of elements for Courtesy Lamps Wiring Diagram (1 of 2) for Dodge Sprinter 2004 2500:

• Dome lamp
• Driver door courtesy lamp
• Driver door jamb switch (left front door)
• Fuse 20a
• Fuse block 1 (under steering column)
• G200 (left rear of engine compt)
• Hot at all times
• Left interior lamp
• Left sliding door courtesy lamp
• Left sliding door jamb switch (in sliding door)
• Middle front interior lamp
• Middle rear interior lamp
• Passenger door courtesy lamp
• Passenger door jamb switch (right front door)
• Rear door jamb switch (in rear door)
• Rear interior lamp 1
• Rear interior lamp 2
• Right interior lamp
• Right sliding door courtesy lamp
• Right sliding door jamb switch (in sliding door)
• S250
• S308
• S309
• S326 (near front center of roof)
• S353
• S354 (near center of right roof rail)

Courtesy Lamps Wiring Diagram (2 of 2) for Dodge Sprinter 2004 2500

List of elements for Courtesy Lamps Wiring Diagram (2 of 2) for Dodge Sprinter 2004 2500:

• (behind center of dash) s253
• (if equipped)
• (near map/reading lamp switch)
• 87a
• Ash receiver lamp
• Cigar lighter
• Cigar lighter lamp
• Daytime running lamps relay
• Driver interior light switch
• Fuse 10a
• Fuse 15a
• Fuse block 2 (under driver's seat)
• Fuse block 3
• Fused b (+)
• G200 (left rear of engine compt)
• G202 (under driver's seat)
• G203 (behind left side of dash)
• Ground
• Hot at all times
• Hot with d+ relay 1 energized
• Int lps drvr
• Int lt sw out
• Interior lamp 1
• Interior lamp 2
• Interior lamp 3
• Interior lamp 4
• Interior lamp 5
• Interior light switch
• Interior lighting connector (if equipped)
• Map/ reading lamp switch
• Passenger interior light switch
• Reading lamp connector
• Rear interior light switch
• Relay block (under driver's seat)
• S207
• S208
• S254 (top of right "b" pillar)
• S309
• S310
• S316
• S324
• S325
• S359 (top of right "b" pillar)
• S360 (top of right "b" pillar)
• S361
• Seat)
• Time delay relay

Instrument Illumination Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Instrument Illumination Wiring Diagram for Dodge Sprinter 2004 2500:

• (behind center of dash)
• 87a
• Additional heat exchanger switch
• Ash receiver lamp
• Automatic temperature control module
• Auxiliary heater switch
• Auxiliary heater timer
• Cigar lighter
• Cigar lighter lamp
• Daytime running lamps relay
• Driver heated seat switch
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse block 2 (under driver's seat)
• G202 (under driver's seat)
• G203 (behind left side of dash)
• High idle switch
• Hot at all times
• Hot with d+ relay 1 energized
• Interior light switch
• Locker switch 1
• Map/ reading lamp switch
• Master door lock switch
• Panic alarm switch
• Passenger heated seat switch
• Radio
• Rear window defogger switch
• Red
• Relay block (under driver's seat)
• Roof a/c switch
• Roof a/c temperature setting control
• Roof fan switch
• S211
• S253
• S310
• S316
• Seat)
• Shifter assembly
• Tcs switch (asr)
• Towing/intrusion sensor on/off switch

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (1 of 7) for Dodge Sprinter 2004 2500:

• (instrument panel) s216
• (not used)
• (under driver's seat) s100
• (under driver's seat) s102
• Auxiliary battery relay
• Battery
• Body plug connector
• Central timer module
• D+ relay
• Data link connector
• Except heavy duty
• Fuse 100a
• Fuse 10a
• Fuse 125a
• Fuse 15a
• Fuse 200a
• Fuse 25a
• Fuse 7.5a
• Fuse 70a
• Fuse 80a
• Fuse block 2 (under driver's seat)
• Fused ignition switch run/start relay
• Generator
• Glow plug control module
• Heavy duty
• Instrument cluster
• Left lamp relay
• Nca
• Power distribution center (left side of engine compt)
• Red
• Relay block (under driver's seat)
• Right lamp relay
• S261
• Starter motor
• To fuse/relay block, fuse 9 (diagram 2 of 7)
• To optional equipment relay (diagram 6 of 7)
• To splice 101 (diagram 3 of 7)
• Trans- mission relay

Power Distribution Wiring Diagram (2 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (2 of 7) for Dodge Sprinter 2004 2500:

• (top of right "b" pillar) s360
• A/c auxiliary fan relay
• Auxiliary heater timer
• Cabin heater assembly
• Controller anti-lock brake
• Ctel connector
• Driver interior light switch
• Fog lamp switch
• From splice 100 (diagram 1 of 7)
• From splice 100 (diagram 2 of 7)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 30a
• Fuse 40a
• Fuse 7.5a
• Fuse block 3 (under driver's seat)
• Fuse/ relay block (under driver's seat)
• Interior lamp switch
• Interior lighting connector
• Left rear window defogger relay
• Left turn signal/ anti-theft alarm relay
• Map/ reading lamp switch
• Nca
• Passenger interior light switch
• Rear interior light switch
• Rear window defogger module
• Red
• Relay block (under driver's seat)
• Right rear window defogger relay
• Right turn signal/ anti-theft alarm relay
• Roof a/c control module
• S226
• S355
• S361
• Sentry key remote entry module
• Time delay relay
• To fuse block 3, fuse 11 (diagram 2 of 7)
• To fuse block 3, fuse 6 (diagram 3 of 7)
• Warm air auxiliary heater assembly

Power Distribution Wiring Diagram (3 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (3 of 7) for Dodge Sprinter 2004 2500:

• (under driver's seat)
• Additional heat exchanger relay
• Blower motor resistor block
• Daytime running lamps relay
• Engine control relay
• Fan stage 1 relay
• From power distribution center, fuse 6 (diagram 1 of 7)
• From splice 100 (diagram 2 of 7)
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 30a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fuse block 3
• Hazard warning switch
• Instrument panel socket
• Intrusion sensor 1
• Intrusion sensor 2
• Intrusion sensor 3
• Multifunction switch
• Nca
• Red
• Relay block
• S101
• S103 (left side of engine compt) red
• S358
• Security system module
• Siren
• To d+ relay 1 (diagram 7 of 7)
• To fuse block 1, fuse 8 (diagram 4 of 7)
• Trailer tow connector
• Trailer tow control module

Power Distribution Wiring Diagram (4 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (4 of 7) for Dodge Sprinter 2004 2500:

• Automatic temperature control module
• Auxiliary heater switch
• Cigar lighter
• Circulation pump relay
• Dome lamp
• Driver door courtesy lamp
• From fuse block 1, g fuse 21 (diagram 3 of 7)
• From fuse block 1, h fuse 8 (diagram 4 of 7)
• Fuse 15a
• Fuse 20a
• Fuse block 1 (under steering column)
• G203 (behind left side of dash)
• Left interior lamp
• Left sliding door courtesy lamp
• Left turn signal/ anti-theft alarm relay
• Middle front interior lamp
• Middle rear interior lamp
• Passenger door courtesy lamp
• Radio
• Rear 1 interior lamp
• Rear 2 interior lamp
• Red
• Relay block
• Relay block (under driver's seat)
• Right interior lamp
• Right sliding door courtesy lamp
• Right turn signal/ anti-theft alarm relay
• S223 (behind dash)
• S250
• S353
• To fuse block 1, fuse 20 (diagram 4 of 7)
• To ignition switch (diagram 5 of 7)

Power Distribution Wiring Diagram (5 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (5 of 7) for Dodge Sprinter 2004 2500:

• (behind center of dash)
• (left side of engine compt) s200
• (near brake lamp switch) s204
• (near optional equipment relay) s206
• 87a
• Airbag control module
• Brake lamp switch
• Central timer module
• Circulation pump relay
• Data link connector
• Engine control module
• From fuse block 1 (diagram 4 of 7)
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse block 1 (under steering column)
• Fused ignition switch run/start relay
• Hazard warning switch
• Horn (vtss)
• Horn pump
• Ignition switch 0 off 1 acc 2 run 3 start
• Instrument cluster
• Mass air flow sensor
• Multifunction switch
• Nca
• Radio
• Radio/ cellular antenna
• Rear window defogger switch
• Red
• Relay block (under driver's seat)
• S210
• Seat)
• Sentry key remote entry module
• Shifter assembly
• Starter motor relay
• To optional equipment relay (diagram 6 of 7)
• Transmission pump
• Turn signal switch

Power Distribution Wiring Diagram (6 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (6 of 7) for Dodge Sprinter 2004 2500:

• (behind center of dash) s365
• (not used)
• 87a
• Additional heat exchanger relay
• Cabin heater assembly
• Circulation pump diode (w/o program timer)
• Controller anti-lock brake
• Ctel connector
• Driver heated seat switch
• Driver power mirror motor
• Driver power window switch
• From fuse block 1, fuse 7 (diagram 5 of 7)
• From power distribution center, fuse 2 (diagram 1 of 7)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 7.5a
• Fuse block 2 (under driver's seat)
• Fuse block 3 (under driver's seat)
• Fuse/ relay block (under driver's seat)
• G202 (under driver's
• High idle switch
• Locker switch
• Master power window switch
• Nca
• Of dash) s202
• Optional equipment relay
• Passenger heated seat switch
• Passenger power mirror motor
• Passenger power window switch
• Power mirror switch
• Red
• Relay block (under driver's seat)
• Roof fan switch
• S302
• S305 (in left front door)
• S306
• S307
• S311 (under driver's seat)
• S362
• S364 (behind center of dash)
• Security system module

Power Distribution Wiring Diagram (7 of 7) for Dodge Sprinter 2004 2500

List of elements for Power Distribution Wiring Diagram (7 of 7) for Dodge Sprinter 2004 2500:

• (behind center of dash)
• (near trailer tow connector) s350
• (under driver's seat)
• 87a
• Auxiliary battery relay
• Central timer module
• D+ relay 1
• D+ relay 2
• Daytime running lamps relay
• From splice s100 (diagram 3 of 7)
• Fuse 15a
• Fuse 7.5a
• Fuse block 2 (under driver's seat)
• Fuse block 3
• G202 (under driver's
• Instrument cluster
• Left lamp relay
• Left side daytime running lamp relay
• Rear window defogger module
• Red
• Relay block (under driver's seat)
• Right lamp relay
• Right side daytime running lamp relay
• Roof a/c switch
• S256 (behind center of dash)
• S310

POWER DOOR LOCKS

Power Door Locks Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Power Door Locks Wiring Diagram for Dodge Sprinter 2004 2500:

• (left rear of engine compt)
• Can c bus (+)
• Can c bus (-)
• Central timer module (behind dash)
• Computer data lines system
• Data link connector (under dash)
• Dr door ajar ind
• Dr dr lk drv
• Dr dr lk sns
• Dr dr unlk
• Dr dr unlk sns
• Driver door lock motor/ajar switch assembly
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse block 1 (under steering column)
• Fuse/relay block (under driver's seat)
• G200
• G203 (behind left side of dash)
• Ground
• Hot at all times
• Hot in run or start
• Ign sw out
• Interior lights system
• K-skreem
• Left sliding door lock motor/ajar switch assembly
• Lock all doors
• Lt sld dr lk sns
• Lt sld dr unlk sns
• Lt turn sig
• Master door lock switch
• Nca
• Pass door ajar
• Pass dr lk
• Pass dr lk sns
• Pass dr unlk
• Passenger door lock motor/ajar switch assembly
• Ps ft dr lk sns
• Ps ft dr unlk sns
• Rear door lock motor/ajar switch assembly
• Right sliding door lock motor/ajar switch assembly
• Rke ant
• Rke antenna
• Rke interface
• Rr dr lk sns
• Rr dr unlk sns
• Rt sld dr lk sns
• Rt sld dr unlk sns
• Rt turn sig
• S206
• S226
• S328
• S329
• Sec sys intr
• Sec syst interface
• Security system module (behind dash)
• Sentry key remote entry module (skreem) (behind dash)
• Skreem transponder
• Trans coil (+)
• Trans coil (-)
• W/ security
• W/o security

POWER MIRRORS

Power Mirrors Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Power Mirrors Wiring Diagram for Dodge Sprinter 2004 2500:

• Defogger system
• Driver power mirror motor
• Fuse 10a
• Fuse block 2 (under driver's seat)
• G203 (behind left side of dash)
• Horiz motor
• Hot w/ optional equipment relay energized
• Nca
• Passenger power mirror motor
• Power mirror switch
• S304
• S305
• Vert motor

POWER SEATS

Heated Seats Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Heated Seats Wiring Diagram for Dodge Sprinter 2004 2500:

• (under driver's seat)
• Driver heated seat module
• Driver heated seat switch
• Fuse 15a
• Fuse block 3
• G202
• G203 (behind left side of dash)
• Hot w/ optional equipment relay energized
• Interior lights system
• Passenger heated seat module
• Passenger heated seat switch
• S300
• S301
• S302
• S363
• S366

POWER WINDOWS

Power Windows Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Power Windows Wiring Diagram for Dodge Sprinter 2004 2500:

• Driver power window motor
• Driver power window switch
• Fuse 25a
• Fuse block 2 (under driver's seat)
• G203 (behind left side of dash)
• Hot w/ optional equipment relay energized
• Master power window switch
• Nca
• Passenger power window motor
• Passenger power window switch
• S303
• S321

RADIO

Radio Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Radio Wiring Diagram for Dodge Sprinter 2004 2500:

• Acc-run-start
• Antenna
• Computer data lines system
• Ctel connector
• Ctel mute
• Fuse 15a
• Fuse 20a
• Fuse block 1 (under steering column)
• Fused b (+)
• G203 (behind left side of dash)
• Grd
• Hot at all times
• Hot in acc, run or start
• Instrument cluster
• Interior lights system
• K-tcm/radio
• Left front door speaker assembly
• Left rear speaker
• Lf speaker (+)
• Lf speaker (-)
• Lmp driver
• Lr speaker
• Nca
• Radio
• Radio antenna
• Radio/cellular antenna
• Rf speaker (+)
• Rf speaker (-)
• Right front door speaker
• Right rear speaker
• Rr speaker
• S210
• S228
• S230
• S252
• Shield
• Vss out
• W/ cellular antenna
• W/o cellular antenna

SHIFT INTERLOCK

Shift Interlock Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Shift Interlock Wiring Diagram for Dodge Sprinter 2004 2500:

• Brake lamp switch (on brake pedal support)
• Brk lmp sw
• Fuse 10a
• Fuse block 1 (under steering column)
• G203 (behind left side of dash)
• Grd
• Hot in run or start
• Run-start
• S204
• Shifter assembly

STARTING/CHARGING

Charging Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Charging Wiring Diagram for Dodge Sprinter 2004 2500:

• Auxiliary battery
• Auxiliary battery relay (in relay block)
• Battery
• Fuse 19 15a
• Fuse 200a
• Fuse block no.3
• G200 (left rear of eng compt)
• G202 (under driver's seat)
• Generator
• Generator field driver
• Hot when no.1 d+ relay energized
• Instrument cluster
• Nca
• Power distribution center (left side of eng compt)
• Red

Starting Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Starting Wiring Diagram for Dodge Sprinter 2004 2500:

• Battery
• Engine control module (left end of dash)
• Fuel pump relay
• Fuel pump relay ctrl
• Fuse block 1 (under steering column)
• G200 (left rear of eng compt)
• Hold- in
• Hot at all times
• Ignition switch 0 off 1 acc 2 run 3 start
• Ignition switch output (start)
• Nca
• Pull- in
• S219 (under driver's seat)
• Starter motor
• Starter motor relay (in fuse relay block)
• Starter motor relay ctrl

SUPPLEMENTAL RESTRAINTS

Supplemental Restraints Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Supplemental Restraints Wiring Diagram for Dodge Sprinter 2004 2500:

• Airbag control module (under driver's seat)
• Central timer module (behind dash)
• Clock- spring
• Data link connector (under dash)
• Dr ab squib 1 ln 1
• Dr ab squib 1 ln 2
• Dr ab warn ind
• Dr enhncd accdnt rep
• Dr seat belt tens ln 1
• Dr seat belt tens ln 2
• Driver airbag squib
• Driver airbag squib 1 ln 1
• Driver airbag squib 1 ln 2
• Driver seat belt tensioner
• Engine control module (left end of dash)
• Fuse 15a
• Fuse block 1 (under steering column)
• Fused ign (run/strt)
• G201 (under driver's seat)
• G202 (under driver's seat)
• Ground
• Hot in run or start
• Instrument cluster
• K-acm
• Nca
• Pass ab squib 1 ln 1
• Pass ab squib 1 ln 2
• Pass airbag squib 1 ln 1
• Pass airbag squib 1 ln 2
• Pass seat belt tens ln 1
• Pass seat belt tens ln 2
• Passenger airbag squib
• Passenger seat belt tensioner
• S200
• S220 (near central timer module)
• Sb sw sig
• Seat belt switch (driver's seat belt lock)
• Twisted pair

TRANSMISSION

Rear Differential Lock Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Rear Differential Lock Wiring Diagram for Dodge Sprinter 2004 2500:

• (behind left side of dash)
• Differential lock solenoid valve (under vehicle)
• Fuse 15a
• Fuse block 3
• G100 (left front of engine compt)
• G203
• Hot in run or start
• Interior lights system
• Locker switch 1
• Locker switch 2
• S306

Transmission Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Transmission Wiring Diagram for Dodge Sprinter 2004 2500:

• (behind left side of dash)
• 1-2/4-5 sol ctrl
• 2-3 sol ctrl
• 3-4 sol ctrl
• B/u lp sw
• Bk lp sw
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Data link connector (under dash)
• Fuse 10a
• Fuse 15a
• Fuse block (under steering column)
• Fuse block 2 (under driver's seat)
• G202 (under driver's seat)
• G203
• Ground
• Hot at all times
• Hot in run or start
• Ign sw out
• Interior lights system
• K-abs/shift
• K-tcm/radio
• Lamp driver
• Mod pres sol ctrl
• N2 in spd sens
• N2 input spd sensor
• N3 input spd sens
• N3 input spd sensor
• Pnk
• Red
• Relay block (under driver's seat)
• S229
• S257
• S258
• Sens ground
• Sensor ground
• Shift pres sol ctrl
• Shifter assembly
• System shift interlock
• Tcc sol ctrl
• Temp sens p/n
• Temp sens p/n sw
• Trans rly out
• Transmission control module (under driver's seat)
• Transmission relay
• Transmission solenoid assembly (bottom of transmission)

WARNING SYSTEMS

Warning Systems Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Warning Systems Wiring Diagram for Dodge Sprinter 2004 2500:

• Air bag control module (under driver's seat)
• Air bag warning ind
• Air conditioning system
• Ambient temp sens sig (+)
• Ambient temp sens sig ret
• Ambient temperature sensor (under left side of dash)
• Anti-theft system
• Brake fluid level ind sig
• Brake fluid level switch (on master cylinder)
• Brake wear sensor sig
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• D+ relay 1 control
• Data link connector (under dash)
• Driver door jamb switch
• Eng cool level sw sig
• Engine coolant level switch (front of eng compt)
• Exterior lights system
• Frt crtsy lps cntrl
• Fuel level sens sig (+)
• Fuel level sens sig ret
• Fuel level sensor (top of fuel tank)
• Fuse 15a
• Fuse 7.5a
• Fuse block 1 (under steering column)
• Fuse block 2 (under driver's seat)
• Fused b(+)
• Fused hi beam sel sw out
• Fused ign sw (run/start)
• G100 (left front of engine compt)
• G200 (left rear of engine compt)
• G202 (under driver's seat)
• G203 (behind left side of dash)
• G300 (rear of vehicle)
• Gen field driver
• Generator
• Ground
• Headlights system
• Hot at all times
• Hot in run or start
• Ignition lock switch
• Instrument cluster
• Instrument panel socket
• Interior lights system
• K-ic/atc/hbm/chm
• Key-in ign sw signal
• Lamp driver
• Left front brake wear sensor
• Left rear brake wear sensor
• Left turn signal
• Nca
• Park brake ind sig
• Parking brake switch (under dash)
• Passenger door jamb switch
• Radio
• Red
• Right front brake wear sensor
• Right rear brake wear sensor
• Right turn signal
• S200
• S221 (near data link connector)
• S228
• S230
• S261
• S322 (behind dash)
• S323 (near left rear brake pad sensor)
• S326 (near front center of roof)
• S332
• Seat belt sw sig
• Seat belt switch (driver's seat belt lock)
• Vss out
• Vss output

WIPER/WASHER

Wiper/Washer Wiring Diagram for Dodge Sprinter 2004 2500

List of elements for Wiper/Washer Wiring Diagram for Dodge Sprinter 2004 2500:

• (left rear of engine compt)
• 87a
• Eng ctrl rly ctrl
• Eng ctrl rly sig
• Engine controls system
• Exterior lights system
• Front washer pump motor (in engine compt)
• Front wiper motor (left rear of engine compt)
• Fuse 20a
• Fuse block 1 (under steering column)
• G102 (right front of engine compt)
• G200
• G200 (left rear of engine compt)
• Gnd
• Ground
• Hot in run and start
• Hzrd warn sw sens
• Ign sw (run start)
• Ign sw (run/ strt)
• Multifunction switch
• Nca
• S180
• Trn sig rly ctrl
• Trn sig rly feed
• Trn sig rly output
• Trn sig rly sig
• Washer on/off switch
• Wiper on/off relay
• Wiper switch
• Wiper/turn signal/engine start control module
• Wpr mtr ctrl
• Wpr on/ off rly output
• Wpr on/off rly ctrl
• Wpr on/off rly output
• Wpr sw output
• Wshr on/off sw output