All Wiring Diagrams for Ford Aerostar 1995 model

AIR CONDITIONING

A/C Wiring Diagram for Ford Aerostar 1995

List of elements for A/C Wiring Diagram for Ford Aerostar 1995:

(3.0l)
(4.0l)
(lower left front of engine)
(pcm power relay)
(right rear of engine compartment on a/c accumulator)
(top rear corner of right fender apron)
(top rear corner of right fender apron) g100
A/c clutch diode
A/c control assembly
A/c clutch field coil
A/c cutout relay (in engine compartment relay box )
Auxiliary a/c system refrigerant valve solenoid (behind left b pillar)
Auxiliary blower motor
Auxiliary blower motor resistor assembly (behind left b pillar)
Auxiliary power relay (behind left b pillar)
Blower motor
Blower motor resistor assembly (top right side of safety wall)
C 1995 vftc
Clutch cycling pressure switch
Def
Defrost
Floor
Front auxiliary blower motor switch
Fuse 6 20a
Fuse 9 30a
Fuse panel
G105
G206 (behind center of i/p, left of radio)
Heat
High pressure cutoff switch (right front of engine) (3.0l) (left front of engine) (4.0l)
Hot at all times
Hot in accy or run
Hot in run
Main blower motor switch
Max
Med
Mix
Norm
Off
Power- train control module (top left side of safety wall)
Rear
Rear auxiliary blower motor switch
Red
Vent

Heater Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Heater Wiring Diagram for Ford Aerostar 1995:

(not used)
(top rear corner of right fender apron)
Auxiliary blower motor
Auxiliary blower motor resistor assembly (behind left b pillar)
Auxiliary power relay (behind left b pillar)
Blower motor
Blower motor resistor assembly (top right side of safety wall)
C 1995 vftc
Defrost
Front auxiliary blower motor switch
Fuse 9 30a
Fuse panel
G105
G206 (behind center of i/p, left of radio)
Heat
Heater control assembly
Hot at all times
Hot in accy or run
Main blower motor switch
Med
Mix
Off
Rear
Rear auxiliary blower motor switch
Vent

ANTI-LOCK BRAKES

Anti-lock Brake Wiring Diagrams for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Anti-lock Brake Wiring Diagrams for Ford Aerostar 1995:

(behind left side of instrument panel, taped to main harness)
(on brake pedal support)
(top of rear axle)
Acc
Brake fluid level switch (left rear of engine compartment, on brake master cylinder)
Brake input
Brake on/off (boo) switch
Diag input/kapr
Diff sensor ground
Diff speed input
Differential speed sensor
Dss input
Dss return
Dss test connector (left rear of engine compt)
Dump sol output
Dump solenoid
Dump valve solenoid
Fuse 15a
Fuse 20a
Fuse panel
G100 (front of left fender apron, left of battery)
G206 (behind center of instrument panel, below left side of radio)
G206 (behind center of i/p, below left side of radio)
Hot at all times
Hot in run
Hot in start or run
Ignition switch
Instrument cluster
Instrument cluster system
Isolation sol output
Isolation valve solenoid
Lock
Low fluid lvl input
Module ground
Nca
Off
Pressure differential warning switch (left rear of engine compartment, below brake fluid reservoir)
Psom module (instrument cluster)
Rabs proportioning valve switch assembly (left rear of engine compartment, below master cylinder)
Rabs test connector
Rear abs indicator
Rear anti-lock brake module (rabs) (behind center of i/p, below ashtray)
Red
Red/pnk
Run
Start
Switched power
Valve reset
Warning lamp

COMPUTER DATA LINES

Computer Data Lines for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Computer Data Lines for Ford Aerostar 1995:

3.0l
4.0l
Data link connector (dlc) (left rear of engine compartment)
Engine compartment fuse box
Fuel pump relay
Fuse 18 20a
Fuse panel
Hot at all times
Hot in start or run
Instrument cluster
Malfunction ind
Pcm power relay
Powertrain control module (pcm) (top left side of safety wall)
Red

CRUISE CONTROL

Cruise Control Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Cruise Control Wiring Diagram for Ford Aerostar 1995:

(behind center of i/p,
(in steering wheel)
(left rear corner of engine compartment)
(on brake pedal support)
100-
40-
50,000 ohms
Accel
Actuator (connects to throttle linkage)
Battery
Below left side of radio)
Below right side of radio)
Brake input
Brake on/off (boo) switch
C249
Clock- spring assembly (inside steering column)
Cntl sw input
Coast
Exterior lights system (multi-function switch)
Fast
Fuse 1 15a
Fuse 12 30a
Fuse 17 10a
Fuse 6 20a
Fuse 8 15a
Fuse panel
G206
Gnd
Ground
Horn relay (right side of steering column)
Horns system
Horns system
Hot at all times
Hot in accy or run
Hot in run
Ignition
Instrument cluster
Nca
Off
Ohms
Pnk
Pnk/
Psom module
Red
Red/
Resume
Run
Servo motor
Servo posit feed
Servo posit gnd
Servo posit signal
Set/
Slow
Sol volt source
Sol+
Speed output
Speed control amplifier (right side of instrument panel, above cowl panel)
Speed control servo
Speed control switch assembly (partial)
Speed input
Vac
Vac sol cntl
Vacuum distribution
Vacuum dump valve (vents to atmosphere when brake is depressed)
Vent
Vent sol cntl

DEFOGGERS

Defogger Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Defogger Wiring Diagram for Ford Aerostar 1995:

(behind center of i/p,
(center of left fender apron, at starter relay)
(top right side of rear door/liftgate header)
Below left side of radio)
Fuse 15a
Fuse panel
G206
G410
Hot at all times
Hot in run
Illumination
Interior lights system
Momentary switch
On indicator
Rear window defrost control
Rear window defrost grid
Relay
Timing circuit

ENGINE PERFORMANCE

3.0L

3.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 3.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995:

(not used)
3-4/4-3 shift solenoid
A4ld automatic transmission
Accs
Air conditioning
Air conditioning system
Boo
Brake on/off switch (behind steering column)
C256
Canp
Coil output
Cse gnd
Data (+)
Data (-)
Data link connector (right rear corner of engine compartment)
Distributor
Ect
Engine compartment relay box
Fpm
Fuse 15a
Fuse panel
G100 (front left fender apron, left of battery)
G206 (behind center of i/p, below right side of radio)
H2os
Hot at all times
Hot in start or run
Iac
Iat
Idm
Ign gnd
Ign pwr
Ignition coil
Ignition control module (icm) (center of right fender apron, near air cleaner)
Inj 1
Inj 2
Inj 3
Inj 4
Inj 5
Inj 6
Instrument cluster
Kapwr
Maf
Maf rtn
Nca
Pcm power relay
Pcm power relay diode
Pip
Pnk
Pnp
Power distribution system
Powertrain control module (pcm) (top left side of safety wall, left side of brake master cylinder)
Psom (+)
Psom (-)
Pwr gnd
Radio noise capacitor (top left rear of engine, near ignition coil)
Red
Sig rtn
Spout
Spout check connector (left rear of engine compartment, tape to engine control sensor harness, near master cylinder)
Ss 3/4
Starting/ charging system
Sti
Sti connector (right rear corner of engine compartment)
Sto/mil
System
Tan
Tcc
Torque converter clutch solenoid
Vpwr
Vref
Wac

3.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 3.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995:

(behind center of i/p, below left side of battery)
C251
Canister purge solenoid (top left side of engine, below intake manifold)
Cruise control system
Engine compartment relay box
Engine coolant temperature (ect) sensor (top center front of engine, above water pump pulley)
Fuel injectors
Fuel pump relay
Fuel pump/ fuel gauge sender (below rear of vehicle, top of fuel tank)
Fuse 18 15a
Fuse 5 15a
Fuse panel
G117 (right rear of engine, near oil pressure switch)
G206
Heated oxygen sensor (ho2s) (lower left rear of engine, on exhaust manifold)
Hot at all times
Hot in run
Hot in run or start
Idle air control valve (top left front of engine, left side of air air intake assembly)
Inertia fuel shut-off switch (opens on impact) (behind center of right cowl panel)
Instrument cluster
Intake air temperature (iat) sensor (top left side of engine, behind idle air control valve)
Malfunction indicator
Mass air flow sensor (right rear of engine compartment, on air intake assembly)
Nca
Psom module
Red
Tan
Throttle position (tp) sensor (top center front of engine, on throttle body)

4.0L

4.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 4.0L, Engine Performance Wiring Diagrams (1 of 2) for Ford Aerostar 1995:

(not used)
3-4/4-3 shift solenoid
A4ld automatic transmission
Accs
Air conditioning system
Boo
Brake on/off switch (behind steering column)
C198
C199
Canp
Ckp (+)
Ckp (-)
Coil 1
Coil 2
Coil 3
Cpp m/t-pnp a/t
Crankshaft position sensor (lower right front of engine compartment)
Cse gnd
Data (+)
Data (-)
Data link connector (left rear of engine compartment on safety wall)
Diode
Ect
Engine compartment relay box
Fpm
Fuse 1 15a
Fuse panel
G100 (front left fender apron, left of battery)
G206 (behind center of i/p, below right side of radio)
Ground
Ho2s
Ho2s gnd
Hot at all times
Hot start or run
Iac
Iat
Idm
Ign gnd
Ign pwr
Ignition coil (right side of valve cover)
Ignition control module (center of right fender apron near air cleaner)
Inj bank 1
Inj bank 2
Instrument cluster
Kapwr
Maf
Maf rtn
Nca
Oct adj
Octane adjust plug (top left rear of engine compt)
Pcm power relay
Pip
Pnk
Powertrain control module (left side of brake master cylinder)
Psom (+)
Psom (-)
Pwr gnd
Radio noise capacitor (near ignition coil)
Red
Shield
Sig rtn
Spark plugs
Speed output
Spout
Spout check connector (near master cylinder)
Ss3/4
Starting charging system
Sti
Sti connector (left rear of engine compt on safety wall)
Sto/mil
Tan
Tcc
Torque converter clutch solenoid
Vpwr
Vref
Wac

4.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 4.0L, Engine Performance Wiring Diagrams (2 of 2) for Ford Aerostar 1995:

Canister purge solenoid (left side of engine near throttle body)
Engine compartment relay box
Engine coolant temperature sensor (top left front of engine)
Fuel injectors
Fuel pump relay
Fuel pump/ fuel gauge sender (top of fuel tank)
Fuse 5 15a
Fuse panel
G206 (behind center of i/p, below left side of radio)
Heated oxygen sensor (lower right rear of engine, on exhaust manifold)
Hot in run
Idle air control valve (left side of air intake assembly)
Inertia fuel shut-off switch (behind center of right cowl panel)
Instrument cluster
Intake air temperature sensor (top left side of engine)
Malfunction indicator lamp
Mass air flow sensor (right rear of engine compt, on air intake assembly)
Nca
Red
Tan
Throttle position sensor (attached to throttle body)

EXTERIOR LIGHTS

Exterior Light Wiring Diagram (1 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Exterior Light Wiring Diagram (1 of 2) for Ford Aerostar 1995:

(behind center of i/p, below left side of radio)
(left front fender apron, left of battery)
Brake on/ off switch (behind left side i/p, on brake pedal support)
C250
C251
Electronic flasher (behind left side of i/p, on front of fuse panel)
Fuse 15a
Fuse panel
G100
G105 (top rear corner of right fender apron, below hood hinge)
G206
G206 (behind center of i/p, below left side of radio)
G906 (top left side of rear door/ liftgate header)
Hazard
Head
High mount stop lamp
Hot at all times
Hot in run
Instrument cluster
Lamp
Left
Left front park/turn lamp
Left rear stop/side marker lamp
Left rear turn lamp
Left turn indicator
License
License lamps
Main light switch
Multi-function switch
Normal
Off
Park
Red/
Right
Right front park/turn lamp
Right rear stop/side marker lamp
Right rear turn lamp
Right turn indicator
To trailer tow relay module
W/ dual rear doors
W/liftgate

Exterior Light Wiring Diagram (2 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Exterior Light Wiring Diagram (2 of 2) for Ford Aerostar 1995:

(not used)
Backup lamps
Backup lamps fuse 10a
Backup lamps relay
From
From main light switch
Fuse 15a
Fuse panel
G206 (behind center of i/p, below left side of radio)
G402 (center of left side 'd' pillar)
Ground
Hot at all times
Hot in run
Left backup lamp
Left turn lamp
Left turn/ stop lamps fuse 3a
Multi-function switch
Park lamps
Park/neutral position switch (left side of transmission)
Red
Right backup lamp
Right turn lamp
Right turn/ stop lamps fuse 3a
Running lamps fuse 10a
Running lamps relay
Trailer electric connector
Trailer tow relay module (left rear of cargo area, above rear of wheel well)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram (1 of 2) for Ford Aerostar 1995:

(3.0l)
(4.0l)
(behind center of i/p, below left side of radio)
(front left fender apron, left of battery)
(lower left front of engine)
(lower left rear of engine, near
(not used)
(right rear of engine, near oil
(top left center of safety wall near,
(top rear corner of right fender apron, below hood hinge)
A/c clutch diode
A/c clutch field coil
A/c heater control illum-
Air bag diagnostic monitor
Battery
Blower motor resistor assembly
Brake fluid level switch
Button connectors
C232
C233
C250
C251
Clock spring assembly
Crankshaft position sensor shield #1
Crankshaft position sensor shield #2
Cruise control amplifier
Distributor shield
Door lock/ unlock control relay
Electronic 4 wheel drive module
Electronic flasher
Engine
Engine compartment lamp
Engine compartment relay box
From ignition switch
G100
G105
G110
G114
G116
G117
G206
Heated oxygen sensor
Ignition control module
Ignition control module shield #1
Ignition control module shield #2
Ination
Instrument cluster
Left front park/ turn lamp
Left headlamp
Mass air flow sensor
Nca
Pcm power relay
Power- train control module
Power- train control module shield
Powertrain control module
Pressure switch)
Rear anti-lock brake (rabs) module
Red
Right front park/ turn lamp
Right headlamp
Sliding door ajar relay
Starter motor/ solenoid)
Stepwell lamp
W/ 3.0l engine
W/ 4.0l engine
W/ 4.0l w/ 3.0l engine
Warning chime module
Windshield washer pump motor
Windshield wiper motor
Windshield wiper motor)
Wiper control module

Ground Distribution Wiring Diagram (2 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram (2 of 2) for Ford Aerostar 1995:

(behind center of i/p, below left side of radio)
(behind center of i/p, below right
(not used)
Ashtray lamp
Auxiliary power relay
Blower motor switch
C249
C250
C255
Cargo lamp
Dome and reading lamps
Dome lamp
Engine low oil level relay
From clock spring assembly
Front auxiliary blower motor switch
Fuel pump/ fuel gauge sender
G206
G206 (behind center of i/p, below right side of radio)
G906 (top left side of rear door/ liftgate header)
G907 (top right side of rear door/liftgate header)
Glove box lamp and switch
Gnd
High mount stop lamp
High mount stop lamp
Ignition switch
Illumi- nated entry timer
Instrument cluster
Instrument panel cigar lighter
Instrument panel cigar lighter lamp
Left backup lamp
Left license lamp
Left lumbar seat pump motor
Left rear stop/side marker lamp
Left rear turn lamp
License lamp
Liftgate ajar switch
Liftgate washer pump motor
Liftgate wiper motor
Liftgate wiper/ washer switch
Master window/ door lock switch
Nca
Power door lock module
Power mirror switch
Power- train control module
Radio
Rear auxiliary blower motor switch illumi- nation
Rear cigar lighter
Rear cigar lighter illumi- nation
Rear window defrost control
Rear window defrost grid
Remote head- phone module
Right backup lamp
Right license lamp
Right lumbar seat pump motor
Right rear door ajar switch
Right rear door latch switch
Right rear stop/side marker lamp
Right rear turn lamp
Seat belt buckle switch
Shift lock actuator
Side of radio)
Standard
To g206
With auxiliary blower
With dual rear doors
With dual rear doors
With illuminated entry
With lift gate
With liftgate
With liftgate wiper/washer
With reading lamps
Without reading lamps

HEADLIGHTS

Headlamps Wiring Diagram, with DRL for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Headlamps Wiring Diagram, with DRL for Ford Aerostar 1995:

(center of left fender apron, at starter relay)
Battery input
Brake indicator
Brake indicator output
Brake warning resistor/diode assembly (behind left side of i/p, taped to main harness near g206)
C250
C251
Daytime running lamps (drl) module (front of left fender apron, forward of starter relay)
Dimmer
Exterior lights system
Flash-to- pass
Fuse 12 30a
Fuse 18 15a
Fuse 4 15a
Fuse 5 15a
Fuse panel (behind left side of i/p, left of steering column)
G100 (front left fender apron, left of battery)
G105 (top rear corner of right fender apron, below hood hinge)
G206 (behind center of i/p, below left side of radio)
Head
Hi beam indicator
High beam ind output
Hot at all times
Hot in run
Hot in start or run
Ignition input
Instrument cluster
Left headlamp
Low beam input
Main light switch
Multi- function switch
Off
Park
Park brake on input
Park brake switch (on park brake support)
Pass
Pulsed hi beam output
Right headlamp

Headlamps Wiring Diagram, without DRL for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Headlamps Wiring Diagram, without DRL for Ford Aerostar 1995:

22a
C250
Dimmer
Flash- to- pass
Fuse 12 30a
Fuse panel (behind left side of i/p, left of steering column)
G100 (front left fender apron, left of battery)
G105 (top rear corner of right fender apron, below hood hinge)
G206 (behind center of i/p, below left side of radio)
Head
Hi beam indicator
Hot at all times
Instrument cluster
Left headlamp
Main light switch
Multi- function switch
Off
Park
Pass
Right headlamp

HORN

Horn Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Horn Wiring Diagram for Ford Aerostar 1995:

(behind center of i/p, below left side of radio)
30a
Clock- spring assembly
Fuse 12
Fuse panel
G206
High pitch horn (lower right front of engine compt, behind lower radiator support)
Horn relay (behind lower left side of i/p, right of steering column)
Horn switch
Hot at all times
Low pitch horn (lower right front of engine compt, behind lower radiator support)
Nca
Speed control switch assembly

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Ford Aerostar 1995:

(behind center of i/p, below right side of radio)
(behind left side of i/p, near top
(behind left side of i/p, near top of
(behind right
(below rear of vehicle, top of
(not
4 wheel
A10
A11
A12
A13
A14
Acc
Air bag
Air bag ind.
Alternator
Amp ind.
Amplifier
Anti- slosh module
B10
B11
B12
B13
Bat
Battery ground
Brake ind.
Check oil ind.
Chime module
Conn a
Conn b
Conn c
Coolant temp.
Coolant temp. gauge
Coolant temperature sender (3.0l-top center front of engine) (4.0l-top right front of engine)
Cowl panel)
Diagnostic
Door ajar ind.
Drive module (under right side of left
Electronic
Electronic 4 wheel drive ind.
Enable
Enable psom programming connector (behind right cowl panel)
Engine)
Exterior lights system (multi- function switch)
Fasten belts ind.
Front of
Front seat)
Fuel gauge
Fuel level
Fuel pump/fuel
Fuel tank)
Fuse 10a
Fuse 15a
Fuse 5a
Fuse panel: i/p
G206
Gauge sender
Gnd
Headlights system (multi- function switch)
High beam ind.
Hot at all times
Hot in run
Hot w/ lamp sw in park or head
Ign
Ign (run)
Ignition switch
Illum.
Illum. lamps
Instrument cluster
Integral
Left turn ind.
Lock
Malfunction ind.
Module
Odometer select
Of cowl panel)
Off
Ohms
Oil press.
Oil press. gauge
Oil pressure switch (3.0l-top right rear of engine, behind valve cover) (4.0l-lower left front of engine, above engine oil pan)
Panel)
Programming
Psom module
Rear abs ind.
Red/ lt
Red/pnk
Regulator (top right
Right turn ind.
Run
Side of i/p, above cowl
Speed control
Start
Trip reset
Used)
Volt- meter
Vss input
Vss output
Vss return
Warning

Instrument Cluster Wiring Diagram (2 of 2) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Ford Aerostar 1995:

"b" pillar)
(69db-
(behind center of i/p, below right side of radio)
(front of sliding door)
(left front fender apron, left of battery)
(left rear corner of cargo area)
(lower right side
(rear of right
(top left side of safety wall,
Acc
Brake fluid level switch (on brake master cylinder)
Button connectors
Courtesy lamp relay
Data link connector (left rear of engine compt, on safety wall)
Daytime running lamps module (front of left fender apron, forward of starter relay)
Differential speed sensor (top of rear axle)
Dss test connector (left rear of engine compt, on safety wall)
Fuse
Fuse 15a
Fuse panel: i/p
G100
G206
Gnd
Hot in acc or run
Hot in run or start
Ign
Ignition switch
Ind. ctrl
Interior lights system
Left front door ajar switch
Left of brake master cylinder)
Level switch
Liftgate ajar switch
Lock
Low oil
Low oil level relay (behind left side of i/p, on relay bracket)
Of engine, on
Off
Oil lvl in
Park brake
Powertrain control module
Pressure differential warning switch (below brake fluid reservoir)
Rear anti-lock brake module (below lower center of i/p)
Rear door latch switch
Red
Red/pnk
Right front door ajar switch
Right rear door ajar switch
Run
Side of oil pan)
Sliding door ajar relay (right of steering column)
Start
Switch (on park brake support)
W/ drl
W/ dual rear doors
W/ liftgate
W/o drl

INTERIOR LIGHTS

Courtesy Lamp Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamp Wiring Diagram for Ford Aerostar 1995:

(below center of i/p, below left side of radio) g206
Acc/run
Bat
Cargo lamp
Courtesy lamp relay (front of left "d" pillar, above rear lamps grommet)
Dome
Dome and reading lamps
Dome lamp
Door handles input
Engine compartment lamp
Engine compartment lamp mercury switch
Fuse 15a
Fuse 20a
Fuse panel: i/p
G100 (left front fender apron, left of battery)
G206 (behind center of i/p, below left side of radio)
G206 (below center of i/p, below left side of radio)
Glove box lamp and switch
Ground
Hot at all times
Hot in accy or run
Illuminated entry output
Illuminated entry timer (center rear of left "b" pillar)
Instrument clusters system
Left courtesy lamp switch
Left door handle switch (on top of latch assembly)
Left instrument panel courtesy lamp
Left vanity mirror lamp and switch
Liftgate ajar switch (in lower center of liftgate, on latch assembly)
Main light switch
Mirrors system
Nca
Off
Rear door latch switch (in top of right rear door)
Right courtesy lamp switch
Right door handle switch (on top of latch assembly)
Right instrument panel courtesy lamp
Right rear door ajar switch (in lower left corner of right rear door)
Right vanity mirror lamp and switch
Sliding door courtesy lamp switch
Stepwell lamp
W/ dual rear doors
W/ illuminated entry
W/ liftgate
W/ reading lamps
W/o reading lamps

Instrument Illumination Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Instrument Illumination Wiring Diagram for Ford Aerostar 1995:

15a
5 bulbs
A/c- heater control illumination
Ashtray lamp
Dimmer
Fuse 11
Fuse 13
Fuse 4
Fuse panel
G100 (front left fender apron, left of battery)
G206 (behind center of i/p, below right side of radio)
G206 (below center of i/p, below left side of radio)
Head
Hot at all times
Hot in accy or run
Ign
Instrument cluster
Instrument panel cigar lighter lamp
Lcd display
Liftgate wiper/ washer switch
Main light switch
Off
Park
Power distribution system
Radio
Rear auxiliary blower motor switch illumination
Rear cigar lighter illumination
Rear window defrost control
Remote headphone module
W/ auxiliary blower motor

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 4) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (1 of 4) for Ford Aerostar 1995:

(3.0l
(4.0l
(fuse panel: i/p)
(not used)
(w/ illuminated
12 ga-
16 ga-
18 ga-
20 ga-
A/c- heater control assembly
Acc
Auxiliary power relay
Battery
C172
Door lock/ unlock control relay
Engine compartment relay box
Entry only)
Fuel pump relay
Fuse 15a
Fuse 20a
Fuse 6a
Fuse link a
Fuse link b
Fuse link c
Fuse link d
Fuse link e
Fuse link f
Fuse link j
Fuse link k
Fuse panel: i/p
Ignition switch
Illum- inated entry timer
Inline fuse 30a
Integral alternator regulator
Lock
Master window/ door lock switch
Off
Only)
Pcm power relay
Power door lock module
Power- train control module
Radio
Rear window defrost control
Red
Right window/ door lock switch
Run
Sliding door ajar relay
Speed control amplifier
Sta
Start
Starter motor/ solenoid
Starter relay
To clutch pedal position switch or park/neutral position switch
To fuse 17 (fuse panel: i/p)
To fuse 7 (fuse panel: i/p)
To fuses 10 & 1 (fuse panel: i/p)
To fuses 15 & 18 (fuse panel: i/p), fuse link g & instrument cluster
To fuses 4, 8, 12 & 16
To fuses 5 & 9 (fuse panel: i/p)
To main light switch
Trailer tow relay module
Wind- shield wiper motor
Wiper control module

Power Distribution Wiring Diagram (2 of 4) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (2 of 4) for Ford Aerostar 1995:

** c254
Air bag diagnostic module
Brake on/off (boo) switch
C172
C249
Cargo lamp
Courtesy lamp relay
Daytime running lamps module (canadian only)
Dome & reading lamps
Engine compart- ment lamp mercury switch
From a fuse link a
From fuse link b
From ignition switch
Fuse 15a
Fuse 20a
Fuse 30a
Fuse panel: i/p
G206 (center of i/p, left side of radio)
Glove box lamp & switch
Horn relay
Illum- inated entry timer
Instrument cluster
Instrument panel cigar lighter
Left courtesy lamp switch
Left lumbar seat switch
Left vanity mirror lamp & switch
Main light switch
Multi- function switch
Nca
Park/ neutral position switch
Power mirror switch
Powertrain control module switch
Radio
Rear anti-lock brake module
Rear cigar lighter
Red
Right courtesy lamp switch
Right lumbar seat switch
Right vanity mirror lamp & switch
Sliding door courtesy lamp switch
W/ illum- inated entry only

Power Distribution Wiring Diagram (3 of 4) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (3 of 4) for Ford Aerostar 1995:

(3.0l only)
(canadian vehicles
(not used)
(w/ air conditioning)
(w/o air conditioning)
(wagon w/ liftgate wiper/ washer only)
Air bag diagnostic monitor
Brake warning resistor/ diode assembly
C250
C251
Daytime running lamps module
Distributor
Electronic 4 wheel drive module
Engine compartment relay box
From ignition switch
Fuse 15a
Fuse 30a
Fuse panel: i/p
Heated oxygen sensor
Heater control assembly
Heater-a/c control assembly
Ignition coil
Ignition control module
Ignition switch
Inline circuit breaker 4.5a
Instrument cluster
Lift gate wiper motor
Lift gate wiper/ washer switch
Low oil engine level relay
Multi- function switch
Nca
Only)
Park/ neutral position switch
Pcm power relay
Pcm power relay diode
Radio noise capacitor
Rear window defrost control
Red
Shift lock actuator
Warning chime module

Power Distribution Wiring Diagram (4 of 4) for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (4 of 4) for Ford Aerostar 1995:

22a
C249
C257
Dimmer
Dome
Exterior lights system
From fuse panel: i/p
From ignition switch
Fuse 10a
Fuse 11
Fuse 20a
Fuse 4
Fuse 5a
Fuse 8
Fuse panel: i/p
Head
Ign
Instrument cluster
Instrument clusters system
Interior lights system
Main light switch
Multi- func- tion switch
Off
Park
Radio
Rear anti- lock brake module
Warning chime module

POWER DOOR LOCKS

Power Door Lock Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Door Lock Wiring Diagram for Ford Aerostar 1995:

"b" pillar)
(18 ga -brown)
(behind center of
(behind left side of i/p, taped to main harness near fuse panel)
(center of left fender
(in bottom of right
30a
Apron, at starter relay)
Bat
Behind left "b" pillar)
Button
Connectors
Door lock/unlock control relay
Fuse link c
G206
Ground
Hot at all times
In-line fuse
Instrument panel, below left side of radio)
Left front door lock motor
Liftgate door lock motor
Lk sldg dr cntl
Lock
Lock cntl
Master window/door lock switch
Pnk/
Power door lock module (left front of cargo area,
Right front door lock motor
Right rear door lock motor
Right window/door lock switch
Sliding door lock motor
Un- lock
Unlk cntl
Unlock
With dual rear doors
With liftgate

POWER MIRRORS

Power Mirror Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Mirror Wiring Diagram for Ford Aerostar 1995:

Direct- tional switch
Fuse 15a
G200 (behind center of i/p, below left side of radio)
Hot at all times
I/p fuse panel
L/r motor
Left power mirror nca
Left/ right switch
Nca
Power mirror switch
Red
Right power mirror nca
Up/dn motor

POWER SEATS

Lumbar Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Lumbar Wiring Diagram for Ford Aerostar 1995:

30a
Fuse 12
Fuse panel
G202 (behind center of i/p, below left side of radio)
Hot at all times
Left lumbar seat switch
Left lumbar seat pump motor
Nca
Red
Right lumbar seat pump motor
Right lumbar seat switch

POWER WINDOWS

Power Window Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Power Window Wiring Diagram for Ford Aerostar 1995:

20a
Circuit breaker 14
Fuse panel
G206 (behind center of i/p, below left side of radio)
Hot in acc or run
Left power window motor
Master window/ door lock switch
Mirrors system (power mirror switch)
Nca
Right power window motor
Right window/ door lock switch
Tan/
Up down

RADIO

AM Radio Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for AM Radio Wiring Diagram for Ford Aerostar 1995:

Battery
C257
C258
Common
Fuse 11 15a
Fuse 8 15a
Fuse panel (behind left end of dash)
G206 (behind center of dash, near radio)
Ground
Hot at all times
Hot in acc or run
Illumination
Interior lights system
Lcd display
Left front speaker
Lf spkr
Not used
Radio
Radio pwr
Rf spkr
Right front speaker
S254
S259
Tan

AM/FM Stereo, with Remote Headphones for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for AM/FM Stereo, with Remote Headphones for Ford Aerostar 1995:

C257
C258
Common
Fuse 11 15a
Fuse 8 15a
Fuse panel (behind left side of dash)
G206 (behind center of dash, near radio)
Ground
Hot at all times
Hot in acc or run
Illumination
Illumination in
Interior lights system
Lcd display
Left front speaker
Left frt
Left liftgate speaker
Left rear
Left rear door speaker
Left rear in
Left rear out
Left rear seat speaker
Memory
Nca
Power
Radio
Radio memory
Remote headphone module (behind left side of cargo area, behind trim panel)
Right front speaker
Right frt
Right liftgate speaker
Right rear
Right rear door speaker
Right rear seat speaker
Rt rear in
Rt rear out
S254
S259
Seek down
Seek up
Tan
W/ cargo doors
W/ rear liftgate

AM/FM Stereo, without Remote Headphones for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for AM/FM Stereo, without Remote Headphones for Ford Aerostar 1995:

(not used)
C257
C258
Common
Fuse 11 15a
Fuse 8 15a
Fuse panel (behind left side of dash)
G206 (behind center of dash, near radio)
Hot at all times
Hot in acc or run
Illumination
Interior lights system
Lcd display
Left front speaker
Left rear door or liftgate speaker
Left rear seat speaker
Lf spkr
Lr channel
Memory pwr
Not used
Radio
Radio pwr
Rf spkr
Right front speaker
Right rear door or liftgate speaker
Right rear seat speaker
Rr channel
S254
S259
Tan

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Shift Interlock Wiring Diagram for Ford Aerostar 1995:

(behind center of i/p,
Below left side of radio)
Brake on/off switch (behind left side of i/p, on brake pedal support)
Fuse 1 15a
Fuse 5 15a
Fuse panel
G206
Hot at all times
Hot in run
Shift lock actuator (on lower part of steering column)
Solid state

STARTING/CHARGING

Charging Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Charging Wiring Diagram for Ford Aerostar 1995:

"amp" indicator
(3.0l) (lower left rear of engine, near starter motor solenoid)
(lower left front of engine) (4.0l)
(top left center of safety wall, near windshield wiper motor)
Acc
Battery
C125
C153
C154
C251
Field
G110
G114
G116
Ignition switch
Instrument cluster
Integral alternator regulator
Lock
Off
Red
Run
Start
Stator
Voltage regulator

Starting Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Starting Wiring Diagram for Ford Aerostar 1995:

(3.0l) (lower left rear of engine, near starter motor solenoid)
(lower left front of engine) (4.0l)
(top left center of safety wall, near windshield wiper motor)
3.0l only
4.0l only
A/t
Acc
Battery
Clutch pedal position switch (top of clutch pedal support)
G110
G114
G116
Hold
Ignition switch
Lock
M/t
Nca
Off
Park/neutral position switch (left side of transmission)
Pnp
Powertrain control module (left side of brake master cylinder)
Pull-in
Red
Run
Sta
Start
Starter motor/solenoid
Starter relay (center of left fender apron)

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for Supplemental Restraint Wiring Diagram for Ford Aerostar 1995:

(behind left side of i/p, near top of cowl panel) air bag diagnostic monitor
(left side of radio)
Air bag indicator
Air bag safing sensor (behind left cowl panel)
Battery
C232
C233
C250
Center radiator crash sensor (on upper radiator support)
Clock- spring assembly
Driver air bag return driver airbag feed monitor safing sensor output monitor
Driver's air bag
Fuse 15a
Fuse panel
G206
Ground
Hot at all times
Hot in run
Ignition
Indicator
Instrument cluster
Nca
Right kick panel crash sensor
Rt crash sens grd monitor cntr radiator grd monitor cntr radiator grd monitor safing sensor feed monitor
Safing sens fd
Safing sensor gnd monitor rt crash sensor feed cntr radiator sensor feed

TRANSMISSION

3.0L

3.0L, Transmission Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 3.0L, Transmission Wiring Diagram for Ford Aerostar 1995:

(engine control sensor harness, near break out above pcm)
(engine control sensor harness, near break out to pcm) s116
(fuel charge harness, near red
(top left center of safety wall, near windshield wiper motor) g116
3-4/4-3 shift solenoid
A4ld automatic transmission (under center of vehicle, behind engine, on left side of transmission)
Brake on/off (boo) switch (on brake pedal support)
Break out to fuel injector 2) s119
C172
C249
C251
Data link connector (dlc) (left rear of engine compartment, on safety wall)
Differential speed sensor (dss) (top of rear axle)
Dss input
Dss return
Dss test connector (left rear of engine compartment, on safety wall)
Engine compartment fuse box
Engine controls system (ignition system)
Engine coolant temperature (ect) sensor (top center front of engine, above water pump pulley)
Fuel pump relay
Fuse 15a
Fuse panel
G116 (top left center of safety wall, near windshield wiper motor)
Hot at all times
Hot in run
Hot in start or run
Instrument cluster
Malfunction indicator lamp (mil) (check engine)
Of engine compartment, on safety wall)
Pcm power relay
Pcm power relay diode
Pnk
Powertrain control module (pcm) (top left side of safety wall, left side of brake master cylinder)
Psom module
Red
Red/ pnk
S122
S125
S128 (fuel charge harness, near break out to fuel injector 4)
S228 (main harness, near break out to main light switch)
S232 (main harness, near break out to instrument cluster)
S273 (main harness, near break out to instrument cluster)
Speed output
Throttle position (tp) sensor (top center front of engine, on throttle body)
Torque converter clutch (tcc) solenoid

4.0L

4.0L, A4LD Transmission Wiring Diagram for Ford Aerostar 1995

Get access to all wiring diagrams of the car

List of elements for 4.0L, A4LD Transmission Wiring Diagram for Ford Aerostar 1995:

(engine control sensor harness, near break out above powertrain control module (pcm)
(engine control sensor harness, near break out to powertrain control module (pcm)) s116
(fuel charge harness, near break out to fuel injector 3) s119
(top left center of safety wall, near windshield wiper motor) g116
3-4/4-3 shift solenoid
A4ld automatic transmission (under center of vehicle, behind engine, on left side of transmission)
Brake on/off (boo) switch (on brake pedal support)
C172
C249
C251
Data link connector (dlc) (left rear of engine compartment, on safety wall)
Differential speed sensor (dss) (top of rear axle)
Dss input
Dss return
Dss test connector (left rear of engine compartment, on safety wall)
Engine compartment fuse box
Engine controls system (ignition system)
Engine coolant temperature (ect) sensor (top left front of engine)
Fuel pump relay
Fuse 15a
Fuse panel
G116 (top left center of safety wall, near windshield wiper motor)
Hot at all times
Hot in run
Hot in start or run
Instrument cluster
Malfunction indicator lamp (mil) (check engine)
Of engine compartment, on safety wall)
Pcm power relay
Pcm power relay diode
Pnk
Powertrain control module (pcm) (top left side of safety wall, left side of brake master cylinder)
Psom module
Red
Red/ pnk
S122
S125
S128 (fuel charge harness, near break out to canister purge (canp) solenoid)
S228 (main harness, near break out to main light switch)
S232 (main harness, near break out to instrument cluster)
S273 (main harness, near break out to instrument cluster)
Speed output
Throttle position (tp) sensor (top left front of engine, on throttle body)
Torque converter clutch (tcc) solenoid