How quickly will I get access to the wiring diagrams after payment?

Access is activated instantly after a successful payment. A payment receipt and an activation email with a link to the wiring diagrams will be sent to your email.

How long will my access be valid?

Access is activated permanently and is not limited in time, just like if you purchased a physical book.

Where can I find the wiring diagrams I purchased?

In your personal account. To access it, click the user icon in the upper right corner of the website.

What if the wiring diagrams do not match my car model?

This is very rare, but if the diagrams do not match your vehicle, contact us at support@portal-diagnostov.com and attach a few photos of the connector or wiring that does not match. We will issue a refund.

All Wiring Diagrams for Ford Econoline E150 1996 model

AIR CONDITIONING

4.9L

4.9L, A/C Wiring Diagram for Ford Econoline E150 1996

List of elements for 4.9L, A/C Wiring Diagram for Ford Econoline E150 1996:

53

(behind instrument cluster)
(behind right side of i/p)
(left front of engine compartment)
(left rear corner of vehicle)
(left rear of engine compartment near brake master cylinder)
(left side of engine compartment near battery)
(left side of engine compartment, near battery)
(right front of engine compartment)
(right side of safety wall)
15a
A/c pressure cut out switch
A/c clutch cycling pressure switch
A/c clutch diode
A/c compressor clutch
A/c control assembly
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Engine compartment fuse panel
Floor
Front blower switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108
G108 (left side of engine compartment near battery)
G202
G206
G404 (left rear corner of vehicle, near left tail light)
Hot at all times
Hot in run
Interior fuse panel
Lo/ rear
Max
Mix
Norm
Off
Pcm power relay
Power- train control module
Rear auxiliary blower switch
Red
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol
Wide open throttle relay (lower left side of engine compartment)

Heater Wiring Diagram for Ford Econoline E150 1996

List of elements for Heater Wiring Diagram for Ford Econoline E150 1996:

39

(behind instrument cluster)
(behind right side of i/p)
(left rear corner of vehicle)
(not used)
(right side of safety wall)
15a
5.8l 49 states over 8600 gvw and 7.5l except california
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Engine compartment fuse panel
Floor
Front blower switch
Function selector switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108 (left side of engine compartment near battery)
G202
G206
G404 (left rear corner of vehicle, near left tail light)
Hot at all times
Hot in run
Interior fuse panel
Mix
Off
Power- train control module (left rear of engine compartment near brake master cylinder)
Rear auxiliary blower switch
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol

5.0L

5.0L, A/C Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.0L, A/C Wiring Diagram for Ford Econoline E150 1996:

52

(5.8l 49 states over 8600 gvw and 7.5l exc. california)
(all others)
(behind right side of i/p)
(left front of engine compartment)
(left rear corner of vehicle)
(left rear of engine compt near brake master cylinder)
(right front of engine compartment)
(right side of safety wall)
15a
5.8l 49 states over 8600 gvw and 7.5l except california
A/c pressure cut out switch
A/c clutch cycling pressure switch
A/c clutch diode
A/c compressor clutch
A/c control assembly
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Diesel
Engine compartment fuse panel
Floor
Front blower switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108 (left side of engine compartment near battery)
G108 (left side of engine compartment, near battery)
G202
G206 (behind instrument cluster)
G404 (left rear corner of vehicle, near left tail light)
Gasoline
Hot at all times
Hot in run
Interior fuse panel
Lo/ rear
Max
Mix
Norm
Off
Power- train control module
Rear auxiliary blower switch
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol

Heater Wiring Diagram for Ford Econoline E150 1996

List of elements for Heater Wiring Diagram for Ford Econoline E150 1996:

39

(behind instrument cluster)
(behind right side of i/p)
(left rear corner of vehicle)
(not used)
(right side of safety wall)
15a
5.8l 49 states over 8600 gvw and 7.5l except california
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Engine compartment fuse panel
Floor
Front blower switch
Function selector switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108 (left side of engine compartment near battery)
G202
G206
G404 (left rear corner of vehicle, near left tail light)
Hot at all times
Hot in run
Interior fuse panel
Mix
Off
Power- train control module (left rear of engine compartment near brake master cylinder)
Rear auxiliary blower switch
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol

5.8L

5.8L, A/C Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.8L, A/C Wiring Diagram for Ford Econoline E150 1996:

52

(5.8l 49 states over 8600 gvw and 7.5l exc. california)
(all others)
(behind right side of i/p)
(left front of engine compartment)
(left rear corner of vehicle)
(left rear of engine compt near brake master cylinder)
(right front of engine compartment)
(right side of safety wall)
15a
5.8l 49 states over 8600 gvw and 7.5l except california
A/c pressure cut out switch
A/c clutch cycling pressure switch
A/c clutch diode
A/c compressor clutch
A/c control assembly
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Diesel
Engine compartment fuse panel
Floor
Front blower switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108 (left side of engine compartment near battery)
G108 (left side of engine compartment, near battery)
G202
G206 (behind instrument cluster)
G404 (left rear corner of vehicle, near left tail light)
Gasoline
Hot at all times
Hot in run
Interior fuse panel
Lo/ rear
Max
Mix
Norm
Off
Power- train control module
Rear auxiliary blower switch
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol

Heater Wiring Diagram for Ford Econoline E150 1996

List of elements for Heater Wiring Diagram for Ford Econoline E150 1996:

39

(behind instrument cluster)
(behind right side of i/p)
(left rear corner of vehicle)
(not used)
(right side of safety wall)
15a
5.8l 49 states over 8600 gvw and 7.5l except california
Aux- iliary high blower motor relay
Auxiliary blower motor
Auxiliary blower motor relay (left rear corner of vehicle)
Auxiliary blower motor resistor (left rear corner of vehicle)
Auxiliary blower switch
Blend door actuator (behind center of i/p)
Blower motor
Blower motor relay (left side of engine compartment)
Blower motor resistor
Def
Engine compartment fuse panel
Floor
Front blower switch
Function selector switch
Fuse 9
Fuse a 60a
Fuse f 60a
G108 (left side of engine compartment near battery)
G202
G206
G404 (left rear corner of vehicle, near left tail light)
Hot at all times
Hot in run
Interior fuse panel
Mix
Off
Power- train control module (left rear of engine compartment near brake master cylinder)
Rear auxiliary blower switch
Temper- ature control switch
Vent
W/ rear control
W/o rear con- trol

ANTI-LOCK BRAKES

4.9L

4.9L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 4.9L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996:

84

(attached to instrument panel assembly, behind instrument cluster) g202
(not used)
4 wheel anti-lock brakes (4wabs) hydraulic unit (on left front frame rail)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4 wheel anti-lock brakes (4wabs) pump motor (on left front frame rail)
5.8l federal over 8600 gvw & 7.5l except calif. w/o drl
Abs data link connector (dlc) (below left side of i/p) (all gas engines, except 5.8l federal over 8600 gvw & 7.5l except california) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Abs ind ctrl
Acc
All others
Anti-lock brake indicator
Brake fluid level sw
Brake indicator out
Brake on/off (boo) switch (on brake pedal bracket)
Brake sw input
Brake warning ind
Brake warning indicator
C233
Daytime running lamps (drl) module (lower right front of engine, near horns)
Diode c (in main harness)
Dual brake warning switch (left side of engine compt., bottom of brake master cylinder)
Emf ctrl output
Engine compartment fuse panel (left side of engine compartment)
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
Fuse u 30a
Fuse v 60a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in run
Hot in start or run
If equipped
Ignition switch
Instrument cluster
Interior fuse panel (behind left side of i/p)
Lamp ground
Left fnt dump sol
Left fnt iso sol
Left fnt sig ground
Left fnt speed input
Left front dump valve
Left front iso valve
Left front wheel sensor (at left front wheel)
Lock
Module ground
Module power
Not used
Off
Park brake on input
Parking brake switch (above left cowl panel)
Pnk
Power ground 1
Power ground 2
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Pump motor power
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear dump sol
Rear dump valve
Rear iso sol
Rear iso valve
Rear reset
Rear reset switch
Rear sig ground
Rear speed input
Red/ pnk
Red/pnk
Right fnt dump sol
Right fnt iso sol
Right fnt sig ground
Right fnt speed input
Right front dump valve
Right front iso valve
Right front wheel sensor (at right front wheel)
Rly ctrl output
Run
Serial communication
Start
Tan
Tan/red
W/ premium sound system
W/drl
W/o drl
Wabs relay

Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996

List of elements for Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996:

50

Abs data link connector (dlc) (below left side of i/p) (all gas/diesel engines except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif.)
Accy
Anti-lock brake indicator
Boo sw input
Brake on/off (boo) switch (on brake pedal bracket)
C233
Diesel
Diode a (engine control sensor harness)
Diode c (in main harness)
Dual brake warn sw
Dual brake warning switch (left side of engine compartment, bottom of brake master cylinder)
Dump solenoid 1-3 ohms
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
G106 (left side of engine compartment, near battery)
G201 (behind right side of i/p, near wiper control module)
Gas base model
Gas base model only
Gas ex base model
Ground
Hot at all times
Hot in run
Hot in start or run
Ignition switch
Ind ctrl
Instrument cluster
Instrument cluster system (diode c)
Instrument cluster system (dual/brake warning diode/resistor assembly)
Interior fuse panel (behind left side of i/p)
Isolation solenoid 3-6 ohms
Keep alive power input
Lock
Not used
Off
Power input
Programable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear anti-lock brake system (rabs) valve assembly (on left front frame rail)
Rear axle sens (hi)
Rear axle sens (lo)
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Red
Red/ pnk
Red/pnk
Run
Start
Valve assembly ctrl
Valve assembly input
Valve reset switch

5.0L

5.0L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 5.0L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996:

84

(attached to instrument panel assembly, behind instrument cluster) g202
(not used)
4 wheel anti-lock brakes (4wabs) hydraulic unit (on left front frame rail)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4 wheel anti-lock brakes (4wabs) pump motor (on left front frame rail)
5.8l federal over 8600 gvw & 7.5l except calif. w/o drl
Abs data link connector (dlc) (below left side of i/p) (all gas engines, except 5.8l federal over 8600 gvw & 7.5l except california) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Abs ind ctrl
Acc
All others
Anti-lock brake indicator
Brake fluid level sw
Brake indicator out
Brake on/off (boo) switch (on brake pedal bracket)
Brake sw input
Brake warning ind
Brake warning indicator
C233
Daytime running lamps (drl) module (lower right front of engine, near horns)
Diode c (in main harness)
Dual brake warning switch (left side of engine compt., bottom of brake master cylinder)
Emf ctrl output
Engine compartment fuse panel (left side of engine compartment)
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
Fuse u 30a
Fuse v 60a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in run
Hot in start or run
If equipped
Ignition switch
Instrument cluster
Interior fuse panel (behind left side of i/p)
Lamp ground
Left fnt dump sol
Left fnt iso sol
Left fnt sig ground
Left fnt speed input
Left front dump valve
Left front iso valve
Left front wheel sensor (at left front wheel)
Lock
Module ground
Module power
Not used
Off
Park brake on input
Parking brake switch (above left cowl panel)
Pnk
Power ground 1
Power ground 2
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Pump motor power
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear dump sol
Rear dump valve
Rear iso sol
Rear iso valve
Rear reset
Rear reset switch
Rear sig ground
Rear speed input
Red/ pnk
Red/pnk
Right fnt dump sol
Right fnt iso sol
Right fnt sig ground
Right fnt speed input
Right front dump valve
Right front iso valve
Right front wheel sensor (at right front wheel)
Rly ctrl output
Run
Serial communication
Start
Tan
Tan/red
W/ premium sound system
W/drl
W/o drl
Wabs relay

Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996

List of elements for Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996:

50

Abs data link connector (dlc) (below left side of i/p) (all gas/diesel engines except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif.)
Accy
Anti-lock brake indicator
Boo sw input
Brake on/off (boo) switch (on brake pedal bracket)
C233
Diesel
Diode a (engine control sensor harness)
Diode c (in main harness)
Dual brake warn sw
Dual brake warning switch (left side of engine compartment, bottom of brake master cylinder)
Dump solenoid 1-3 ohms
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
G106 (left side of engine compartment, near battery)
G201 (behind right side of i/p, near wiper control module)
Gas base model
Gas base model only
Gas ex base model
Ground
Hot at all times
Hot in run
Hot in start or run
Ignition switch
Ind ctrl
Instrument cluster
Instrument cluster system (diode c)
Instrument cluster system (dual/brake warning diode/resistor assembly)
Interior fuse panel (behind left side of i/p)
Isolation solenoid 3-6 ohms
Keep alive power input
Lock
Not used
Off
Power input
Programable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear anti-lock brake system (rabs) valve assembly (on left front frame rail)
Rear axle sens (hi)
Rear axle sens (lo)
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Red
Red/ pnk
Red/pnk
Run
Start
Valve assembly ctrl
Valve assembly input
Valve reset switch

5.8L

5.8L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 5.8L, Anti-lock Brake Wiring Diagrams, 4 Wheel ABS for Ford Econoline E150 1996:

84

(attached to instrument panel assembly, behind instrument cluster) g202
(not used)
4 wheel anti-lock brakes (4wabs) hydraulic unit (on left front frame rail)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4 wheel anti-lock brakes (4wabs) pump motor (on left front frame rail)
5.8l federal over 8600 gvw & 7.5l except calif. w/o drl
Abs data link connector (dlc) (below left side of i/p) (all gas engines, except 5.8l federal over 8600 gvw & 7.5l except california) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Abs ind ctrl
Acc
All others
Anti-lock brake indicator
Brake fluid level sw
Brake indicator out
Brake on/off (boo) switch (on brake pedal bracket)
Brake sw input
Brake warning ind
Brake warning indicator
C233
Daytime running lamps (drl) module (lower right front of engine, near horns)
Diode c (in main harness)
Dual brake warning switch (left side of engine compt., bottom of brake master cylinder)
Emf ctrl output
Engine compartment fuse panel (left side of engine compartment)
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
Fuse u 30a
Fuse v 60a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in run
Hot in start or run
If equipped
Ignition switch
Instrument cluster
Interior fuse panel (behind left side of i/p)
Lamp ground
Left fnt dump sol
Left fnt iso sol
Left fnt sig ground
Left fnt speed input
Left front dump valve
Left front iso valve
Left front wheel sensor (at left front wheel)
Lock
Module ground
Module power
Not used
Off
Park brake on input
Parking brake switch (above left cowl panel)
Pnk
Power ground 1
Power ground 2
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Pump motor power
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear dump sol
Rear dump valve
Rear iso sol
Rear iso valve
Rear reset
Rear reset switch
Rear sig ground
Rear speed input
Red/ pnk
Red/pnk
Right fnt dump sol
Right fnt iso sol
Right fnt sig ground
Right fnt speed input
Right front dump valve
Right front iso valve
Right front wheel sensor (at right front wheel)
Rly ctrl output
Run
Serial communication
Start
Tan
Tan/red
W/ premium sound system
W/drl
W/o drl
Wabs relay

Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996

List of elements for Anti-lock Brake Wiring Diagrams, Rear Wheel ABS for Ford Econoline E150 1996:

50

Abs data link connector (dlc) (below left side of i/p) (all gas/diesel engines except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif.)
Accy
Anti-lock brake indicator
Boo sw input
Brake on/off (boo) switch (on brake pedal bracket)
C233
Diesel
Diode a (engine control sensor harness)
Diode c (in main harness)
Dual brake warn sw
Dual brake warning switch (left side of engine compartment, bottom of brake master cylinder)
Dump solenoid 1-3 ohms
Fuse 1 15a
Fuse 17 20a
Fuse 18 15a
G106 (left side of engine compartment, near battery)
G201 (behind right side of i/p, near wiper control module)
Gas base model
Gas base model only
Gas ex base model
Ground
Hot at all times
Hot in run
Hot in start or run
Ignition switch
Ind ctrl
Instrument cluster
Instrument cluster system (diode c)
Instrument cluster system (dual/brake warning diode/resistor assembly)
Interior fuse panel (behind left side of i/p)
Isolation solenoid 3-6 ohms
Keep alive power input
Lock
Not used
Off
Power input
Programable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear anti-lock brake system (rabs) valve assembly (on left front frame rail)
Rear axle sens (hi)
Rear axle sens (lo)
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Red
Red/ pnk
Red/pnk
Run
Start
Valve assembly ctrl
Valve assembly input
Valve reset switch

ANTI-THEFT

Anti-theft Wiring Diagram for Ford Econoline E150 1996

List of elements for Anti-theft Wiring Diagram for Ford Econoline E150 1996:

62

(right rear corner of engine compartment) anti-theft hood switch
Alarm indicator
Anti-theft indicator
Anti-theft module (left side of vehicle, behind "b" pillar)
Battery
C333
C334
C335
C336
Circuit breaker 20a
Courtesy lamp switch input
Courtesy lp switches
Diode b (in window reg. relay switch harness)
Disarm switch
Door lock control
Door locks system (keyless entry circuit)
Door open input
Driver's door lock control
Exterior lights system
Fuse 10a
Fuse 15a
Fuse 20a
G106 (left side of engine compartment, near battery)
G200 (behind left cowl)
Ground
Headlights system
Hood tamper det. input
Horn relay output
Horns system
Hot at all times
Hot in accy or run
Hot in start
Ign key cyl sensor
Ignition key cylinder sensor
Interior fuse panel (behind left side of i/p)
Interior lights system (courtesy lights)
Left courtesy lamp switch (mounted in left door jamb)
Left door lock cylinder switch (lower left corner of left door)
Lock all doors
Low beam hdlps output
Nca
Panic activate out
Panic alarm input
Parking lamps output
Rear courtesy lamp switch (in right rear door jamb)
Rear door lock cylinder switch (below license plate)
Red/ pnk
Red/pnk
Remote keyless entry module (behind left "b" pillar)
Right courtesy lamp switch (mounted in right door jamb)
Right door key cylinder switch in
Right door key cylinder switch (lower right side of door)
Run/accy input
Side door courtesy lamp switch (behind right "b" pillar)
Side door lock ctrl
Starter interrupt in
Starter interrupt out
Starting/ charging system (starter circuit)
Steering column assembly
Unlock driver's door
Unlock sense
Warning buzzer module (below left side of i/p)

COMPUTER DATA LINES

4.9L

4.9L, Computer Data Lines for Ford Econoline E150 1996

List of elements for 4.9L, Computer Data Lines for Ford Econoline E150 1996:

12

Bus +
Bus -
C143
C247
Data link connector (dlc) (below left side of i/p)
Fuse 1 15a
G106 (left side of engine, compartment near battery)
G200 (behind left cowl)
Generic scan tool input
Hot at all times
Interior fuse panel (behind left side of i/p)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)

5.0L

5.0L, Computer Data Lines for Ford Econoline E150 1996

List of elements for 5.0L, Computer Data Lines for Ford Econoline E150 1996:

12

Bus +
Bus -
C143
C247
Data link connector (dlc) (below left side of i/p)
Fuse 1 15a
G106 (left side of engine, compartment near battery)
G200 (behind left cowl)
Generic scan tool input
Hot at all times
Interior fuse panel (behind left side of i/p)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)

5.8L

5.8L, Computer Data Lines, Federal over 8600 GVW for Ford Econoline E150 1996

List of elements for 5.8L, Computer Data Lines, Federal over 8600 GVW for Ford Econoline E150 1996:

21

C162
C163
C175
C233
Coil
Data (sti) (5.8l) data link conn (7.5l)
Data link conn (+)
Data link conn (-)
Data link connector (dlc) (left front corner of engine compartment)
Engine compartment fuse panel (left side of engine compartment)
Fuel pump enable output
Fuel pump relay
Fuse 18 15a
Ho2s sens (ho2s) gnd
Hot in start or run
Instrument cluster
Interior fuse panel (behind left side of i/p)
Malfunction ind lp
Malfunction indicator lamp (mil) "check engine light"
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Sens sig rtn

5.8L, Computer Data Lines, Federal under 8600 GVW & Calif. for Ford Econoline E150 1996

List of elements for 5.8L, Computer Data Lines, Federal under 8600 GVW & Calif. for Ford Econoline E150 1996:

12

Bus +
Bus -
C143
C247
Data link connector (dlc) (below left side of i/p)
Fuse 1 15a
G106 (left side of engine, compartment near battery)
G200 (behind left cowl)
Generic scan tool input
Hot at all times
Interior fuse panel (behind left side of i/p)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)

CRUISE CONTROL

4.9L

4.9L, Cruise Control Wiring Diagram for Ford Econoline E150 1996

List of elements for 4.9L, Cruise Control Wiring Diagram for Ford Econoline E150 1996:

51

(attached to instrument panel assembly, behind instrument cluster)
(left side of engine compartment- 5.8l federal over 8600 gvw & 7.5l federal engines)
(not used)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4-wheel abs system
4.9l, 5.0l, 5.8l federal under 8600 gvw & all calif. engines
5.8l federal over 8600 gvw & 7.5l federal engines
Abs data link connector (dlc) (below left side of i/p- all models except 5.8l federal over 8600 gvw & 7.5l federal engines)
Accel
Boo switch input
Brake on/off (boo) switch (on brake pedal bracket)
Brake pressure input
Brake pressure switch (left side of engine compartment, bottom of brake master cylinder)
C143
C175
Clock spring assembly (top of steering column)
Coast
Fuse 1 15a
Fuse 6 20a
G202
Ground
Horn
Horns system
Hot at all times
Hot in accy or run
Interior fuse panel (behind left side of i/p)
Nca
Off
Ohms
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear axle speed input
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear sensor high
Rear sensor low
Rear-wheel abs system
Red/ pnk
Red/pnk
Resume
Set/
Speed control servo amplifier assembly (left rear of engine compartment, near brake master cylinder)
Speed control/ horn switch (steering column assembly)
Speed ctrl sw gnd
Speed ctrl sw input
Vehicle power
Vehicle speed input
Vehicle speed output
Vehicle speed sensor or psom input (vss +)
Wheel speed sensor high
Wheel speed sensor low

5.0L

5.0L, Cruise Control Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.0L, Cruise Control Wiring Diagram for Ford Econoline E150 1996:

51

(attached to instrument panel assembly, behind instrument cluster)
(left side of engine compartment- 5.8l federal over 8600 gvw & 7.5l federal engines)
(not used)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4-wheel abs system
4.9l, 5.0l, 5.8l federal under 8600 gvw & all calif. engines
5.8l federal over 8600 gvw & 7.5l federal engines
Abs data link connector (dlc) (below left side of i/p- all models except 5.8l federal over 8600 gvw & 7.5l federal engines)
Accel
Boo switch input
Brake on/off (boo) switch (on brake pedal bracket)
Brake pressure input
Brake pressure switch (left side of engine compartment, bottom of brake master cylinder)
C143
C175
Clock spring assembly (top of steering column)
Coast
Fuse 1 15a
Fuse 6 20a
G202
Ground
Horn
Horns system
Hot at all times
Hot in accy or run
Interior fuse panel (behind left side of i/p)
Nca
Off
Ohms
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear axle speed input
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear sensor high
Rear sensor low
Rear-wheel abs system
Red/ pnk
Red/pnk
Resume
Set/
Speed control servo amplifier assembly (left rear of engine compartment, near brake master cylinder)
Speed control/ horn switch (steering column assembly)
Speed ctrl sw gnd
Speed ctrl sw input
Vehicle power
Vehicle speed input
Vehicle speed output
Vehicle speed sensor or psom input (vss +)
Wheel speed sensor high
Wheel speed sensor low

5.8L

5.8L, Cruise Control Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.8L, Cruise Control Wiring Diagram for Ford Econoline E150 1996:

51

(attached to instrument panel assembly, behind instrument cluster)
(left side of engine compartment- 5.8l federal over 8600 gvw & 7.5l federal engines)
(not used)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4-wheel abs system
4.9l, 5.0l, 5.8l federal under 8600 gvw & all calif. engines
5.8l federal over 8600 gvw & 7.5l federal engines
Abs data link connector (dlc) (below left side of i/p- all models except 5.8l federal over 8600 gvw & 7.5l federal engines)
Accel
Boo switch input
Brake on/off (boo) switch (on brake pedal bracket)
Brake pressure input
Brake pressure switch (left side of engine compartment, bottom of brake master cylinder)
C143
C175
Clock spring assembly (top of steering column)
Coast
Fuse 1 15a
Fuse 6 20a
G202
Ground
Horn
Horns system
Hot at all times
Hot in accy or run
Interior fuse panel (behind left side of i/p)
Nca
Off
Ohms
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Rear anti-lock brake system (rabs) module (behind right side of i/p)
Rear axle speed input
Rear axle speed sensor (below rear of vehicle, mounted on differential)
Rear sensor high
Rear sensor low
Rear-wheel abs system
Red/ pnk
Red/pnk
Resume
Set/
Speed control servo amplifier assembly (left rear of engine compartment, near brake master cylinder)
Speed control/ horn switch (steering column assembly)
Speed ctrl sw gnd
Speed ctrl sw input
Vehicle power
Vehicle speed input
Vehicle speed output
Vehicle speed sensor or psom input (vss +)
Wheel speed sensor high
Wheel speed sensor low

ENGINE PERFORMANCE

4.9L

4.9L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 1996:

66

bus -
ground
intake air temp. fuel pump mon. a/c on input
shift sol #1
tfi module gnd
trans ctrl sw
(not used)
Air conditioning system
Aird sol.
Anti-theft module (left side of vehicle, behind "b" pillar)
Bus +
C143
C233
C336
C6 trans.
Cat monitor sens
Coil
Coil wire
Data link connector (dlc) (below left side of i/p)
Distributor (left side of engine)
Distributor shield
E40d trans.
Egr sol.
Eng temp sens.
Fuse 18 15a
Fuse 5 15a
Fuse 7 10a
G106 (left side of engine compartment, near battery)
G200 (behind left cowl)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gen scan tool in
Gnd
Ground
Hot in run
Hot in start or run
Idm
Idm monitor
Ign gnd
Ignition coil (left front of engine)
Ignition control module (icm) (left rear of engine compartment)
Ignition control module (icm) shield
Instrument cluster
Interior fuse panel (behind left side of i/p)
Malfunction indicator lamp (mil)
Mass air flw rtn
Mil lp ctrl
Misfire sens gnd
Nca
O/d off
Park/neutral position switch (left side of transmission)
Pip
Pnk
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Pwr
Radio capacitor (left side of engine, attached to ignition coil)
Shield gnd
Shift sol #2
Shorting bar (left rear of engine compartment)
Spk angle pulse
Spout
Tc3
Tcil
Trans temp sens.
Transmission control switch/ indicator lamp
W/ anti- theft
W/o anti- theft

4.9L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 1996:

32

Acc
Coast clutch solenoid
Diode (plug- in)
E4od transmission
Electronic pressure control (epc) solenoid
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temperature (ect) sensor (top front of engine, on heater outlet elbow)
Fuel pump relay
Fuse c 30a
Fuse g 60a
Fuse h 30a
Fuse u 30a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in start or run
Ignition switch
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Lock
Misfire sensor (lower right front of engine)
Off
Pcm power relay
Red
Run
Shift solenoid #1
Shift solenoid #2
Start
Starter motor relay (left front corner of engine compartment)
Torque converter clutch (tcc) solenoid
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)
W/ c6 trans.
W/ e40d trans.

4.9L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 1996:

26

Airb solenoid (rear of left valve cover, on bracket)
Aird solenoid (rear of left valve cover, on bracket)
All cutaways
All vans & wagons
Brake on/off (boo) switch (on brake pedal bracket)
C422
Class 1 trailer adapter only
Egr solenoid (rear of left valve cover, on bracket)
Fuel injectors (in intake manifold)
Fuel pump/ sender (below vehicle in fuel tank)
Fuse i 15a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Hot at all times
Idle air control (iac) valve (left side of engine, above distributer)
In-transit fuel pump/ sender (below vehicle, along left frame rail)
Inertia fuel shutoff (ifs) (behind right cowl panel)
Instrument cluster system (anti-slosh module/fuel gauge)
Interior fuse panel (behind left side of i/p)
Mass air flow (maf) sensor (center of engine compartment)
Nca
Rear fuel pump/ sender (mounted on left rear frame crossmember)
Red
Tan
Trailer/camper adapter connector
W/trailer adapter only

4.9L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 1996

List of elements for 4.9L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 1996:

52

Airb solenoid
Boo switch input
Catalyst monitor sensor (cms) (near lower right side of transmission)
Cms sensor
Coast clutch sol.
Delta pressure feedback egr (dpfe) sensor (right side of engine)
Dpfe sensor
Epc solenoid
Fuel injector #1
Fuel injector #2
Fuel injector #3
Fuel injector #4
Fuel injector #5
Fuel injector #6
Fuel pmp rly ctrl
G106 (left side of engine compartment, near battery)
Ground
Heated oxygen sensor (ho2s) #11 (lower right side of engine)
Heated oxygen sensor (ho2s) #21 (lower right side of engine)
Hego #11
Hego #21
Hego sns mn #11
Hego sns mn #21
Iac valve
Keep alive pwr in
Knock sensor
Knock sensor (ks) (left side of engine, near ignition coil)
Mass air fl sens.
Misfire sens.
Nca
Power input
Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
Ref output volt
Sens sig rtn
Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
Tan
Tcc solenoid
Tcil ind. lp.
Throttle position (tp) sensor (top left side of engine)
Tp sensor
Trans rng sensor
Vapor man. valve
Vapor management valve (center of engine compartment)
Vehicle spd sens.
Vss input
Vss output
W/ e40d trans.
W/c6 trans.
Wide open throt.
Wide open throttle (wot) relay (lower left side of engine compartment, near starter motor relay)

5.0L

5.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 1996:

66

(not used)
A/c on input
Air conditioning system
Aird sol.
Anti-theft module (left side of vehicle, behind "b" pillar)
Bus +
Bus -
C143
C233
C336
Cat monitor sens
Coil
Coil wire
Data link connector (dlc) (below left side of i/p)
Distributor (center front of engine)
Distributor shield
Egr sol.
Eng temp sens.
Fuel pump mon.
Fuse 18 15a
Fuse 5 15a
Fuse 7 10a
G106 (left side of engine compartment, near battery)
G200 (behind left cowl)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gen scan tool in
Gnd
Ground
Hot in run
Hot in start or run
Idm
Idm monitor
Ign gnd
Ignition coil (left rear of engine)
Ignition control module (icm) (left rear of engine compartment)
Ignition control module (icm) shield
Instrument cluster
Intake air temp.
Interior fuse panel (behind left side of i/p)
Malfunction indicator lamp (mil)
Mass air flw rtn
Mil lp ctrl
Misfire sens gnd
Nca
O/d off
Pip
Pnk
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Pwr
Radio capacitor (left side of engine, attached to ignition coil)
Shield gnd
Shift sol #1
Shift sol #2
Shorting bar (left rear of engine compartment)
Spk angle pulse
Spout
Tc3
Tcil
Tfi module gnd
Trans ctrl sw
Trans temp sens.
Transmission control switch/ indicator lamp
Vss ground
W/ anti- theft
W/o anti- theft
Wire coil

5.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 1996:

28

4r70w transmission
Acc
Diode (plug- in)
Electronic pressure control (epc) solenoid
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temperature (ect) sensor (top front of engine, near distributor
Fuel pump relay
Fuse c 30a
Fuse g 60a
Fuse h 30a
Fuse u 30a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in start or run
Ignition switch
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Lock
Misfire sensor (lower right front of engine)
Off
Pcm power relay
Red
Run
Shift solenoid
Start
Starter motor relay (left front corner of engine compartment)
Torque converter clutch (tcc) solenoid
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)

5.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 1996:

24

Airb solenoid (rear of left valve cover, on bracket)
Aird solenoid (rear of left valve cover, on bracket)
All cutaways
All vans & wagons
C422
Class 1 trailer adapter only
Egr solenoid (rear of left valve cover, on bracket)
Fuel injectors (in intake manifold)
Fuel pump/ sender (below vehicle in fuel tank)
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Idle air control (iac) valve (front of engine, near distributor)
In-transit fuel pump/ sender (below vehicle, along left frame rail)
Inertia fuel shutoff (ifs) (behind right cowl panel)
Instrument cluster system (anti-slosh module/ fuel gauge)
Mass air flow (maf) sensor (center of engine compartment)
Nca
Rear fuel pump/ sender (mounted on left rear frame crossmember)
Red
Tan
Tan/ red
Tan/red
Trailer/camper adapter connector
W/trailer adapter only

5.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 1996:

54

Air man. #1
Boo switch input
Brake on/off (boo) switch (on brake pedal bracket)
Catalyst monitor sensor (cms) (lower middle side of vehicle) (california only) (near lower right side of transmission) (federal)
Cms sensor
Delta pressure feedback egr (dpfe) sensor (top right front of engine)
Dpfe sensor
Epc solenoid
Fuel injector #1
Fuel injector #2
Fuel injector #3
Fuel injector #4
Fuel injector #5
Fuel injector #6
Fuel injector #7
Fuel injector #8
Fuel pmp rly ctrl
Fuse i 15a
G106 (left side of engine compartment, near battery)
Ground
Heated oxygen sensor (ho2s) #11 (lower right side of engine)
Heated oxygen sensor (ho2s) #21 (lower left side of engine)
Hego #11
Hego #21
Hego sns mn #11
Hego sns mn #21
Hot at all times
Iac valve
Interior fuse panel (behind left side of i/p)
Keep alive pwr in
Mass air fl sens.
Misfire sens.
Nca
Power input
Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
Ref output volt
Sens sig rtn
Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
Tan
Tan/red
Tcc solenoid
Tcil ind. lp.
Throttle position (tp) sensor (right front of engine)
Tp sensor
Trans rng sensor
Transmission speed sensor (tss) (on transmission)
Tss sensor
Vapor man. valve
Vapor management valve (center of engine compartment)
Vehicle spd sens.
Vss input
Vss output

5.8L

5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (1 of 2) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (1 of 2) for Ford Econoline E150 1996:

81

(not used)
A/c on
Air conditioning system
Aird
Boo
Brake on/off (boo) switch (on brake pedal support)
C162
C163
C175
C233
Canp
Ccs
Coil
Coil wire
Data (+)
Data (-)
Data link connector (left front corner of engine compt.)
Data link connector (left front of engine compt.)
Diode (plug-in) (in engine compartment fuse panel)
Distributor
Distributor shield
Ect
Egr sol
Egr valve
Engine compartment fuse panel (left side of engine compartment)
Epc
Fpm
Fuse 1 15a
Fuse 18 15a
Fuse c 30a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gnd
Ho2s
Ho2s gnd
Hot at all times
Hot in start or run
Iac
Iat
Idm
Ign gnd
Ign power
Ignition coil (left rear of engine)
Ignition control module (icm) (left rear of engine compartment)
Ignition control module (icm) shield
Inj 1,4,5,8 out
Inj 2,3,6,7 out
Instrument cluster
Interior fuse panel (behind left side of i/p)
Kapwr
Malfunction indicator lamp (mil)
Map
Mil
Nca
Or
Pcm power relay
Pip
Pnk
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Psom (+)
Pwr
Radio capacitor (attached to ignition coil)
Red
Shorting bar (left rear of engine compartment)
Sig rtn
Speed control servo/amplifier assembly (near brake master cylinder)
Spout
Ss1
Ss2
Sti
Tan
Tcc sol
Tcil
Tcs
Tft
Tr sensor
Transmission range (tr) sensor (left side of transmission)
Vehicle speed input
Vref
Vss (-)

5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (2 of 2) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal over 8600 GVW (2 of 2) for Ford Econoline E150 1996:

54

(not used)
Aird solenoid (rear of left valve cover, on bracket)
All cutaways
All vans and wagons
Coast clutch solenoid
Compartment, near battery)
E40d transmission
Egr solenoid (rear of left valve cover, on bracket)
Egr valve (evp) position sensor (top right front of engine, on egr valve)
Electronic pressure (epc) control solenoid
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
Evaporative emissions (evap) canister purge valve (right side of engine, connected to throttle body)
Fuel injectors
Fuel pump relay
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse h 30a
G106 (left side of engine compartment, near battery)
Heated oxygen sensor (ho2s) no.11 (middle lower right side of vehicle)
Hot at all times
Hot in run
Idle air control (iac) valve (front of engine, near distributor)
Ignition switch acc
In-transit fuel pump/sender (below vehicle, along left frame rail)
Inertia fuel shut off (ifs) switch (behind right cowl panel)
Intake air temperature (iat) sensor (right side of engine, near fuel injector no.1)
Interior fuse panel (behind left side of i/p)
Lock
Manifold absolute pressure (map) sensor (right side of engine compartment)
Nca
No.1
No.2
No.3
No.4
No.5
No.6
No.7
No.8
Od off
Off
Rear fuel pump sender (mounted on left rear frame crossmember)
Red
Run
Shift solenoid no.1
Shift solenoid no.2
Start
Tan
Tc3
Tcil
Throttle position (tp) sensor (right front of engine)
Torque converter clutch solenoid
Trans- mission fluid temper- ature sensor
Transmission control switch/ indicator lamp

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (1 of 4) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (1 of 4) for Ford Econoline E150 1996:

65

(not used)
A/c on in sig
Air conditioning system
Anti-theft module (left side of vehicle, behind "b" pillar)
Bus +
Bus -
C143
C233
C336
Cat monitor sens
Coil
Coil wire
Data link connector (dlc) (below left side of i/p)
Distributor (center front of engine)
Distributor shield
Egr sol.
Eng temp sens.
Fuel pump mon.
Fuse 18 15a
Fuse 5 15a
Fuse 7 10a
G106 (left side of engine compartment, near battery)
G200 (behind left cowl)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gen scan tool in
Gnd
Ground
Hot in run
Hot in start or run
Idm
Idm monitor
Ign gnd
Ignition coil (left rear of engine)
Ignition control module (icm) (left rear of engine compartment)
Ignition control module (icm) shield
Instrument cluster
Intake air temp.
Interior fuse panel (behind left side of i/p)
Malfunction indicator lamp (mil)
Mass air flw rtn
Mil lp ctrl
Misfire sens gnd
Nca
O/d off
Pip
Pnk
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Pwr
Radio capacitor (left side of engine, attached to ignition coil)
Shield gnd
Shift sol #1
Shift sol #2
Shorting bar (left rear of engine compartment)
Spk angle pulse
Spout
Tc3
Tcil
Tfi module gnd
Trans ctrl sw
Trans temp sens.
Transmission control switch/ indicator lamp
Vss ground
W/ anti- theft
W/o anti- theft
Wire coil

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (2 of 4) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (2 of 4) for Ford Econoline E150 1996:

30

Acc
Coast clutch solenoid
Diode (plug- in)
E4od transmission
Electronic pressure control (epc) solenoid
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
Fuel pump relay
Fuse c 30a
Fuse g 60a
Fuse h 30a
Fuse u 30a
G106 (left side of engine compartment, near battery)
Hot at all times
Hot in start or run
Ignition switch
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Lock
Misfire sensor (lower right front of engine)
Off
Pcm power relay
Red
Run
Shift solenoid #1
Shift solenoid #2
Start
Starter motor relay (left front corner of engine compartment)
Torque converter clutch (tcc) solenoid
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (3 of 4) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (3 of 4) for Ford Econoline E150 1996:

30

All cutaways
All vans & wagons
C422
Egr solenoid (rear of left valve cover, on bracket)
Fuel injectors (in intake manifold)
Fuel pump/ sender (below vehicle, vehicle, in fuel tank)
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Idle air control (iac) valve (front of engine, near distributor)
In-transit fuel pump/ sender (below vehicle, along left frame rail)
Inertia fuel shutoff (ifs) (behind right cowl panel)
Instrument cluster (anti-slosh module)
Mass air flow (maf) sensor (center of engine compartment)
Nca
No.1
No.2
No.3
No.4
No.5
No.6
No.7
No.8
Rear fuel pump/ sender (mounted on left rear frame crossmember)
Red
Tan
Tan/ red
Tan/red
Trailer/camper adapter connector
W/class 1 trailer adapter only
W/trailer adapter only

5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (4 of 4) for Ford Econoline E150 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal under 8600 GVW & Calif. (4 of 4) for Ford Econoline E150 1996:

54

Boo switch input
Brake on/off (boo) switch (on brake pedal bracket)
C143
Catalyst monitor sensor (cms) (lower middle side of vehicle)
Cms sensor
Coast clutch sol.
Delta pressure feedback egr (dpfe) sensor (right side of engine)
Dpfe sensor
Epc solenoid
Fuel inj. no.1
Fuel inj. no.2
Fuel inj. no.3
Fuel inj. no.4
Fuel inj. no.5
Fuel inj. no.6
Fuel inj. no.7
Fuel inj. no.8
Fuel pmp rly ctrl
Fuse i 15a
G106 (left side of engine compartment, near battery)
Ground
Heated oxygen sensor (ho2s) no.11 (beneath center of vehicle)
Heated oxygen sensor (ho2s) no.21 (lower left side of transmission)
Hego mn no.11
Hego mn no.21
Hego no.11
Hego no.21
Hot at all times
Iac valve
Interior fuse panel (behind left side of i/p)
Keep alive pwr in
Mass air fl sens.
Misfire sens.
Nca
Power distribution system
Power input
Powertrain control module (pcm) (left rear of engine, compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
Ref output volt
Sens sig rtn
Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
Tan
Tan/red
Tcc solenoid
Tcil ind. lp.
Throttle position (tp) sensor (right front of engine)
Tp sensor
Trans rng sensor
Vapor man. valve
Vapor management valve (center of engine compartment)
Vehicle spd sens.
Vss input
Vss output

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Ford Econoline E150 1996

List of elements for Back-up Lamps Wiring Diagram for Ford Econoline E150 1996:

19

(4r70w)
(e40d diesel)
(e40d gasoline) (4r70w)
(e40d gasoline) (e40d diesel)
(not used)
4r70w or e40d transmission
C6 transmission
Cutaways
Fuse 15a
G999 (left rear corner of vehicle, near left stop/ park/turn lamp)
Hot in run
Interior fuse panel (behind left side of i/p)
Left backup lamp
Park/ neutral position switch (left side of transmission)
Right backup lamp
To trailer/camper adapter circuit (trailer backup lamp relay)
Transmission range (tr) sensor (left side of transmission)
Vans & wagons
W/class 2 trailer package

Exterior Lamps Wiring Diagram for Ford Econoline E150 1996

List of elements for Exterior Lamps Wiring Diagram for Ford Econoline E150 1996:

50

(at base of left "b" pillar) c330
(not used)
Anti-theft system (anti-theft module)
Brake on/off (boo) switch (on brake pedal bracket)
Brake test connector (behind left "b" pillar)
C217
C232
C233
Cut- aways
Cutaways only
Electronic flasher (behind left side of i/p)
Fuse 15a
Fuse 20a
G107 (right front corner of engine compartment)
G200 (behind left cowl)
G202 (attached to instrument panel assembly, behind instrument cluster)
G999 (left rear corner of vehicle, near left/stop/ park/turn lamp)
Hazard
Hazard switch
Head
High mounted stop/ cargo lamp
Hot at all times
Hot in run
Instrument cluster
Interior fuse panel (behind left side of i/p)
Interior fuse panel (behind left side of i/p)
Left front park/ turn signal lamp
Left stop/ park/
Left turn indicator
License lamp
Main light switch
Modified vehicle power (all cutaways) (w/class 2 trailer adapter only)
Multi- function switch (right side of steering column)
Normal
Off
Park r
Right front park/ turn signal lamp
Right stop/ park/
Right turn indicator
Solid state
To trailer/ camper adapter circuit (electronic brake) (class 2 only)
To trailer/camper adapter circuit (electronic brake) (class 2 only)
To trailer/camper adapter circuit (engine compartment fuse panel) (fuse p)
To trailer/camper adapter circuit (engine compartment fuse panel) (fuses n & m)
Turn lamp
Turn left
Turn right
Vans & wagons
Vans & wagons only
Warning systems (warning buzzer module)

Trailer Adapter/Electronic Brake Wiring Diagram for Ford Econoline E150 1996

List of elements for Trailer Adapter/Electronic Brake Wiring Diagram for Ford Econoline E150 1996:

50

(at base of left "b" pillar) c330
(behind left cowl) g200
Ambulance package only
B+ (park or head)
Back up lamps circuit (transmission range (tr) sensor or park/neutral position switch
Back-up lamp output
Battery (b+)
Brake switch input
C184 (left rear corner of engine compartment)
C231 (behind left side of i/p)
C422
Dome
Dome switch input
Electronic brake
Electronic brake (left side of i/p, near airbag module)
Engine compartment fuse panel (left side of engine compartment)
From exterior lamps circuit (brake on/off (boo) switch)
From exterior lamps circuit (headlamp switch)
From exterior lights circuit (multi-function switch)
Fuse 20a
Fuse d 20a
Fuse j 40a
Fuse k 30a
Fuse m 10a
Fuse n 10a
Fuse p 10a
G106 (left side of engine compartment, near battery
G106 (left side of engine compartment, near battery)
G999 (left rear corner of vehicle, near trailer/camper adapter)
Ground
Hot at all times
Hot in acc or run
Interior fuse panel (behind left side of i/p)
Left turn output
Main light switch
Modified vehicle power
Nca
Red
Right turn output
Starting/ charging system (generator/ regulator)
Trailer backup lamp relay (lower left side of engine compartment, near starter motor relay)
Trailer battery charge relay (lower left side of engine compartment, near starter motor relay)
Trailer connector
Trailer running lamp relay (lower left side of engine compartment, near starter motor relay)
Trailer running lamp relay output
Trailer/camper adapter class 2
Trailer/camper adapter connector (below left side of bumper)
Trailer/camper adapter connector (below left side of rear bumper)
W/ auxiliary battery
W/o auxiliary battery

Trailer/Camper Adapter Wiring Diagram for Ford Econoline E150 1996

List of elements for Trailer/Camper Adapter Wiring Diagram for Ford Econoline E150 1996:

20

(not used)
C422
C430
Cut- aways
Engine compartment fuse panel (left side of engine compartment)
From exterior lamps circuit (main light switch)
From exterior lamps circuit (multi-function switch)
Fuse m 10a
Fuse n 10a
Fuse p 10a
G106 (left side of engine compartment, near battery)
G999 (left rear corner of vehicle, near trailer/camper adapter)
Ground
Left turn output
Main light switch (park or head)
Right turn output
Trailer/camper adapter class 1
Trailer/camper adapter connector (below left side of rear bumper)
Vans & wagons
Vans & wagons only

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (1 of 6) for Ford Econoline E150 1996:

31

(right front corner of engine compartment)
4 wheel anti-lock brakes (4wabs) module
4.9l & 7.5l
4.9l, 5.0l (50 states), 5.8l california & 49 states under 8600 gvw & 7.5l california
5.0l & 5.8l
5.8l 49 states over 8600 gvw & 7.5l except california
All models
C143
C175
C232
Data link connector
Engine compartment fuse panel
G106 (left side of engine compartment, near battery)
G107
G120 (right side of engine)
Gasoline models
Heated oxygen sensor (ho2s) #11
Instrument cluster
Left battery
Left front park/turn signal lamp
Left headlamp
Mass airflow (maf) sensor
Nca
Pcm power relay
Powertrain control module (pcm)
Rear anti-lock brake system (rabs) valve assembly
Right front park/turn signal lamp
Right headlamp
To gasoline model components (schematic page 2)
W/ 4wabs only
W/rear abs only

Ground Distribution Wiring Diagram (2 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (2 of 6) for Ford Econoline E150 1996:

48

& 7.5l california only
(not used)
4.9l, 5.0l (50 states),
49 states under 8600 gvw
5.8l 49 states over 8600 gvw & 7.5l except california
5.8l california &
7.3l di turbo diesel model
A/c compressor clutch
A/c compressor clutch diode
All cutaway
All vans/ wagons w/ trailer adapter
All vans/ wagons w/o trailer adapter
Ambulance package only
Anti-theft hood switch
Blower motor relay
Blower motor resistor
C143
C175
C409
Class 1 trailer adapter
Class 2 trailer adapter
Data link connector (dlc)
Dual brake warning switch
From gasoline model engines (on schematic page 1)
Fuel pump/ sender
G101 (lower right front of engine compartment, on frame rail)
G101 (right side of engine compartment)
G112 (left side of engine)
G119 (lower right front of engine)
Gasoline models
Generator/ regulator
In-transit fuel-pump/ sender
Injector driver module (idm)
Left battery
Nca
Powertrain control module
Powertrain control module (pcm)
Rear fuel pump/ sender
Right battery
Trailer backup lamp relay
Trailer battery charge relay
Trailer running lamp relay
Trailer/camper adapter connector
W/ anti- theft
W/class 2 trailer adapter
W/trailer adapter
Washer pump motor
Windshield wiper motor

Ground Distribution Wiring Diagram (3 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (3 of 6) for Ford Econoline E150 1996:

33

(not used)
4 wheel anti-lock brakes (4abs) module
7.3l di turbo diesel model
A/c compressor clutch
A/c compressor clutch diode
Blower motor relay
Blower motor resistor
C121
C143
C232
C409
C430
Class 1 trailer adapter
Class 2 trailer adapter
Dual brake warning switch
Engine compartment fuse panel
Exhaust pressure regulator (epr)
External fuel pump
G106 (left side of engine compartment, near battery)
Instrument cluster
Low vacuum warning switch
Pcm power relay
Powertrain control module (pcm)
Rear anti-lock brake system (rabs) valve assembly
Trailer backup lamp relay
Trailer battery charge relay
Trailer running lamp relay
Trailer/camper adapter connector
Vans/ wagons w/trailer adapter
W/ 4wabs only
W/rabs only
Washer pump motor
Windshield wiper motor

Ground Distribution Wiring Diagram (4 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (4 of 6) for Ford Econoline E150 1996:

71

(dlc)
* w/o door trim
***
****
**all except 5.8l 49 states over 8600 gvw & 7.5l except california
Air bag module
Airbag module (vans/wagon only)
Anti-theft module
Auxiliary powertrain control connector
Brake test connector
C208
C209
C332
C333
C334
C336
C337
C512
C513
C605
C610
Clockspring assembly
Cutaway w/illuminated entry only
Cutaways
Cutaways only
Data link connector
Diesel only
Dome/map switch & lamp
Driver's lumbar pump
Driver's seat regulator control switch
Electronic flasher
G200 (behind left cowl)
Ignition key cylinder sensor
Illuminated entry module
Left door handle switch
Left door lock cylinder switch
Left front courtesy lamp
Master window/door l,ock control switch or left power window switch
Memory lock module
Nca
Passenger's lumbar pump
Power mirror switch
Rear door lock cylinder switch
Rear power outlet
Remote keyless entry module
Remote radio control
Remote/keyless entry module
Right door handle switch
Right door key cylinder switch
Right front courtesy lamp
Right power door lock switch or right power door lock/window switch
Seat belt switch
Shift lock actuator
To ground g999 (schematic page 6)
Trailer/ camper adapter
Vans & wagons
Vans/wagon only
W/ anti- theft
W/ illuminated entry
W/ power lumbar
W/anti- theft
W/anti-theft
W/illuminated entry
W/o anti-theft
W/o power lumbar
W/o speed control
W/power door locks
W/power mirrors
W/rear radio only
W/trailer adapter
Warning buzzer module

Ground Distribution Wiring Diagram (5 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (5 of 6) for Ford Econoline E150 1996:

39

(attached to instrument panel assembly, behind instrument cluster)
(not used)
* 5.8l 49 states over 8600 gvw & 7.5l except california
4 wheel anti-lock brakes (4wabs) module
All cutaways
All models except diesel vans & wagons w/o premium sound & rabs
All vans & wagons
Amplifier
Auxiliary heater blower switch or auxiliary a/c-heater blower switch
Blend door actuator
C143
C175
C213
C224
C232
C233
C234
C302
Cigar lighter
Diesel vans & wagons w/o premium sound & rabs
Diesel warning lamps display module
Front blower switch
Fuel pump/ sender
Function selector switch illumination
G202
Gasoline models w/speed control
In-transit fuel pump sender
Instrument cluster
Nca
Powertrain control module (pcm)
Programmable speedometer/ odometer module (psom)
Radio
Rear fuel pump/ sender
Speed control servo/ amplifier assembly
W/ 4wabs
W/ auxiliary a/c
W/ premium sound
W/o premium sound
Wiper control module

Ground Distribution Wiring Diagram (6 of 6) for Ford Econoline E150 1996

List of elements for Ground Distribution Wiring Diagram (6 of 6) for Ford Econoline E150 1996:

25

(left rear corner of vehicle, near left stop/ park/ turn lamp)
All except chateau wagon
All reguilar vans w/o full headliner
All regular or extended vans & wagons w/ rear headliner
All regular vans w/o full headliner
All rv vans w/ auxiliary a/c
Auxiliary a/c illumination
Auxiliary blower motor relay
Auxiliary high blower motor relay
Cargo lamp
Chateau wagon
Chateau wagon
Dome/ switch lamp
Dome/map switch & lamp
From ground g200 (schematic page 4)
G999
High mounted stop/ cargo lamp
Left backup lamp
Left stop/ park/ turn lamp
License lamp
Right backup lamp
Right stop/ park/ turn lamp
W/ auxiliary a/c
W/ auxiliary heat or a/c
W/ full headliner

HEADLIGHTS

Headlight Wiring Diagram, with DRL for Ford Econoline E150 1996

List of elements for Headlight Wiring Diagram, with DRL for Ford Econoline E150 1996:

49

ign input park bk on in
(not used)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
Anti-theft module (left side of vehicle, behind "b" pillar)
Battery pwr in pulsed output
Brake warning lamp high
Brake ind out
Brake warning indicator
C218
C232
C233
C335
Daytime running lamps (drl) module (lower right front of engine, near horns)
Diesel (w/4abs)
Diesel (w/rabs)
Dimmer
Drl disable
Dual brake warning diode/ resistor assembly (in main harness, near t/o to psom module)
Engine compartment fuse panel (left side of engine compartment)
Flash-to- pass
Fuse 18 15a
Fuse 4 20a
Fuse 5 15a
Fuse r 15a
Fuse s 60a
G107 (right front corner of engine compartment)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gasoline (w/4abs)
Gasoline (w/rabs)
Head
Hi beam in out
High beam indicator
Hot at all times
Hot in run
Hot in start
Instrument cluster
Interior fuse panel (behind left side of i/p)
Left headlamp
Lo beams in
Low vacuum warning switch (left front of engine compartment)
Main light switch
Multi- function switch (dimmer)
Off
Or run
Park
Parking brake switch (above left cowl panel)
Pass
Right headlamp
W/4 wheel anti-lock brakes only

Headlight Wiring Diagram, without DRL for Ford Econoline E150 1996

List of elements for Headlight Wiring Diagram, without DRL for Ford Econoline E150 1996:

28

Anti-theft module (left side of vehicle, behind 'b' pillar)
C218
C232
C335
Dimmer
Drl jumper (left front of engine, compartment near left headlamp)
Engine compartment fuse panel (left side of engine compartment)
Flash- to- pass
Fuse 4 20a
Fuse s 60a
G107 (right front corner of engine compartment)
G202 (attached to instrument panel assembly, behind instrument cluster)
Head
Hi beam indicator
Hot at all times
Instrument cluster
Interior fuse panel (behind left side of i/p)
Left headlamp
Low beam output
Main light switch
Multi- function switch (dimmer)
Off
Park
Pass
Right headlamp
W/ drl jumper
W/drl jumper only
W/o drl jumper

HORN

Horn Wiring Diagram for Ford Econoline E150 1996

List of elements for Horn Wiring Diagram for Ford Econoline E150 1996:

28

15a
Anti-theft module (left side of vehicle, behind "b" pillar)
C143
C335
Clock- spring assembly
Diesel models
Engine compartment fuse panel (left side of engine compartment)
Fuse r
G200 (behind left cowl)
Gasoline models
High pitch horn (lower right front of engine compartment, behind grille)
Horn
Horn relay (left rear of engine compartment (gasoline) (lower left side of engine compartment, near starter relay (diesel)
Horn switch
Hot at all times
If equipped
Low pitch horn (lower right front of engine compartment, behind grille)
Nca
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Relay output
Speed control ground
Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
Speed control switch ground
Speed control switches
Steering column assembly
Steering column assembly (speed control/ horn switch)
W/cruise control
W/o cruise control

INSTRUMENT CLUSTER

4.9L

4.9L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 4.9L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996:

105

(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
(right front of engine compt)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif. w/o drl
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) '(left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Acc
Air bag ind.
Air bag module (behind left side of i/p)
All cutaways
All other models
All vans/wagons
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Bat
Brake warning ind.
C143
C175
C190
C209
C232
C233
Charge ind.
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module
Diode c (in main harness, near t/o to psom)
Dss input
Dss return
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
In-transit fuel pump/sender (below vehicle, along left frame rail)
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear axle speed sensor (mounted on differ- ential)
Rear fuel pump/sender (mounted on left rear frame crossmember)
Red/
Red/ pnk
Red/pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/ amplifier assembly (left side of engine compt., near brake master cylinder)
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
W/premium sound system
Warning buzzer module

4.9L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996

List of elements for 4.9L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996:

110

in-transit fuel pump/sender (below vehicle, along left frame rail)
rear fuel pump/sender (mounted on
red/pnk
(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
1000 ohms
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif.
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif)
Acc
Air bag ind.
Air bag module (left side of i/p)
All other models
All cutaways
All vans/wagons
Amplifier assembly (left side of engine compt., near brake master cylinder)
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Base models w/rabs
Base models: w/rabs
Bat
Brake warning ind.
C190
C209
C232
C233
Charge ind.
Ci43
Ci75
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module (lower right front of engine compt)
Diode c (in main harness, near psom)
Dss input
Dss return
Dual brake warning diode/ resistor assembly
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Except base models
Except base models: 5.8l fed over 8600 gvw & 7.5l except calif.
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left rear frame crossmember)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear anti-lock brake (rabs) system module (behind right side of i/p)
Rear axle speed sensor (mounted on differential)
Red/ pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
Warning buzzer module

5.0L

5.0L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 5.0L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996:

105

(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
(right front of engine compt)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif. w/o drl
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) '(left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Acc
Air bag ind.
Air bag module (behind left side of i/p)
All cutaways
All other models
All vans/wagons
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Bat
Brake warning ind.
C143
C175
C190
C209
C232
C233
Charge ind.
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module
Diode c (in main harness, near t/o to psom)
Dss input
Dss return
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
In-transit fuel pump/sender (below vehicle, along left frame rail)
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear axle speed sensor (mounted on differ- ential)
Rear fuel pump/sender (mounted on left rear frame crossmember)
Red/
Red/ pnk
Red/pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/ amplifier assembly (left side of engine compt., near brake master cylinder)
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
W/premium sound system
Warning buzzer module

5.0L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996

List of elements for 5.0L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996:

110

in-transit fuel pump/sender (below vehicle, along left frame rail)
rear fuel pump/sender (mounted on
red/pnk
(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
1000 ohms
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif.
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif)
Acc
Air bag ind.
Air bag module (left side of i/p)
All other models
All cutaways
All vans/wagons
Amplifier assembly (left side of engine compt., near brake master cylinder)
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Base models w/rabs
Base models: w/rabs
Bat
Brake warning ind.
C190
C209
C232
C233
Charge ind.
Ci43
Ci75
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module (lower right front of engine compt)
Diode c (in main harness, near psom)
Dss input
Dss return
Dual brake warning diode/ resistor assembly
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Except base models
Except base models: 5.8l fed over 8600 gvw & 7.5l except calif.
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left rear frame crossmember)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear anti-lock brake (rabs) system module (behind right side of i/p)
Rear axle speed sensor (mounted on differential)
Red/ pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
Warning buzzer module

5.8L

5.8L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996

List of elements for 5.8L, Instrument Cluster Wiring Diagram, with 4 Wheel ABS for Ford Econoline E150 1996:

105

(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
(right front of engine compt)
4 wheel anti-lock brakes (4wabs) module (on left front frame rail)
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif. w/o drl
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) '(left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except california)
Acc
Air bag ind.
Air bag module (behind left side of i/p)
All cutaways
All other models
All vans/wagons
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Bat
Brake warning ind.
C143
C175
C190
C209
C232
C233
Charge ind.
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module
Diode c (in main harness, near t/o to psom)
Dss input
Dss return
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
In-transit fuel pump/sender (below vehicle, along left frame rail)
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear axle speed sensor (mounted on differ- ential)
Rear fuel pump/sender (mounted on left rear frame crossmember)
Red/
Red/ pnk
Red/pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/ amplifier assembly (left side of engine compt., near brake master cylinder)
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
W/premium sound system
Warning buzzer module

5.8L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996

List of elements for 5.8L, Instrument Cluster Wiring Diagram, with Rear Wheel ABS for Ford Econoline E150 1996:

110

in-transit fuel pump/sender (below vehicle, along left frame rail)
rear fuel pump/sender (mounted on
red/pnk
(a)
(b)
(behind left side of i/p) programmable speedometer/ odometer module (psom)
(below left side of i/p)
(not used)
1000 ohms
4.9l, 5.0l, 5.8l federal under 8600 gvw & 7.5l calif. only
5.8l fed. over 8600 gvw & 7.5l except calif.
5.8l federal over 8600 gvw & 7.5l except calif.
A10
A11
A12
A14
Abs data link connector (dlc) (below left side of i/p) (all gas engines: except 5.8l federal over 8600 gvw & 7.5l except calif.) (left side of engine compartment) (5.8l federal over 8600 gvw & 7.5l except calif)
Acc
Air bag ind.
Air bag module (left side of i/p)
All other models
All cutaways
All vans/wagons
Amplifier assembly (left side of engine compt., near brake master cylinder)
Anti- lock brake ind.
Anti- slosh module
B10
B11
B12
B13
Base models w/rabs
Base models: w/rabs
Bat
Brake warning ind.
C190
C209
C232
C233
Charge ind.
Ci43
Ci75
Coolant temp.
Data link connector (dlc) (left front corner of engine compartment)
Daytime running lamps (drl) module (lower right front of engine compt)
Diode c (in main harness, near psom)
Dss input
Dss return
Dual brake warning diode/ resistor assembly
Dual brake warning switch (in bottom of brake master cylinder)
Enable
Engine compartment fuse panel (left side of engine compartment)
Engine coolant temp. gauge
Engine coolant temperature sender (4.9l-right rear of engine, near fuel injector no.6) (5.0l & 5.8l-lower left side of engine) (7.5l-lower left side of engine)
Engine oil press. gauge
Engine oil pressure switch (4.9l-left side of engine, near distributor) (5.0l-front of engine, near a/c compressor) (5.8l-left side of engine, near oil cooler) (7.5l-top center rear of engine)
Except base models
Except base models: 5.8l fed over 8600 gvw & 7.5l except calif.
Exterior lights system
Fasten seat belt ind.
Fuel gauge
Fuel level
Fuel pump/ sender (below vehicle, in fuel tank)
Fuse 15a
Fuse 20a
Fuse 5a
Fuse u 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Generator/ regulator
Gnd
Headlights
High beam ind.
Hot at all times
Hot in run
Hot in start or run
Hot w/main light switch in park or head
Ign
Ign (run)
Ignition switch
Illum.
Instrument cluster
Instrument lamps illumination
Interior fuse panel (behind left side of i/p)
Left rear frame crossmember)
Left turn ind.
Lock
Malfunction ind. "check engine light"
Nca
Off
Ohms
Oil press.
Parking brake switch (above left cowl panel)
Powertrain control module (pcm) (left rear of engine compt., near brake master cylinder)
Programming
Psom data link connector (behind left side of i/p)
Rear anti-lock brake (rabs) system module (behind right side of i/p)
Rear axle speed sensor (mounted on differential)
Red/ pnk
Red/pnk
Right turn ind.
Run
Solid state
Speed control servo/
Start
System
Volt- meter
Vss output
W/ drl
W/o drl
Warning buzzer module

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram (1 of 3) for Ford Econoline E150 1996

List of elements for Courtesy Lamps Wiring Diagram (1 of 3) for Ford Econoline E150 1996:

41

(left rear corner of vehicle, near left stop/park/ turn lamp) g999
(not used)
Battery
Ctsy lp ctrl
Cutaway models
Cutaway only
Dome
Dome/map switch & lamp
Door sw input
Exterior lights system (trailer/ camper adapter)
Fuse 15a
Fuse 20a
G200 (behind left cowl)
Ground
High mounted stop/ cargo lamp
High mounted stop/cargo lamp & rear courtesy lamp switch
Hinge door
Hot at all times
Hot in accy or run
Ignition
Illuminated entry module (cutaways: behind left side of i/p) (all other: behind left 'b' pillar)
Interior fuse panel (behind left side of i/p)
Left
Left courtesy lamp switch
Left door handle switch
Left front courtesy lamp
Main light switch
Red/ pnk
Right
Right courtesy lamp switch
Right door handle switch
Right front courtesy lamp
Side door courtesy lamp switch
Sliding door
Vans/ wagons only
Vans/wagons only
W/ cut- away
W/ full headliner
W/illuminated entry vans/wagons & cutaways
W/o full headliner
Warning systems (warning buzzer module)

Courtesy Lamps Wiring Diagram (2 of 3) for Ford Econoline E150 1996

List of elements for Courtesy Lamps Wiring Diagram (2 of 3) for Ford Econoline E150 1996:

36

(not used)
Anti- theft system
Battery
C333
C334
Dome
Dome/map switch & lamp
Door hndle sw
Fuse 15a
G200 (behind left cowl)
G999 (left rear corner of vehicle, near left taillamp)
Ground
High mounted stop/ cargo lamp
High mounted stop/cargo lamp & rear courtesy lamp switch
Hinge door
Hot at all times
Int lps out
Interior fuse panel (behind left side of i/p)
Left
Left courtesy lamp switch
Left door handle switch
Left front courtesy lamp
Main light switch
Red/ pnk
Remote keyless entry module (behind left "b" pillar)
Right
Right courtesy lamp switch
Right door handle switch
Right front courtesy lamp
Side door courtesy lamp switch
Side door ctsy sw
Sliding door
W/full headliner
W/keyless entry vans & wagons
W/o full headliner
Warning systems (warning buzzer module)

Courtesy Lamps Wiring Diagram (3 of 3) for Ford Econoline E150 1996

List of elements for Courtesy Lamps Wiring Diagram (3 of 3) for Ford Econoline E150 1996:

19

All chateau wagons
All regular or extended vans & wagons
All rv vans w/auxiliary a/c
All vehicles except rv van, rv cutaway, chateau wagon
Anti-theft system
Cargo lamp
Chateau wagon
Dome switch/ lamp
Dome/map switch & lamp
From courtesy lights control circuit (courtesy lights w/illuminated entry) or (courtesy lights w/keyless entry)
G999 (left rear corner of vehicle, near left/stop/park turn lamp)
High mounted stop/ cargo lamp
Left
Left visor lamp
Off
Rear courtesy lamp switch
Right
Right visor lamp
Vans/ wagons only

Instrument Illumination Wiring Diagram for Ford Econoline E150 1996

List of elements for Instrument Illumination Wiring Diagram for Ford Econoline E150 1996:

28

(4) bulbs
(attached to instrument panel assembly, behind instrument cluster) g202
(behind left cowl)
Auxiliary a/c illumination
C224
C232
Dimmer
Function selector switch illumination
Fuse 15a
Fuse 20a
Fuse 5a
G200
Ground
Head
Hot at all times
Hot in accy or run
Ign
Instrument cluster
Interior fuse panel (behind left side of i/p)
Lcd illumination
Main light switch
Off
Park
Radio
Radio backlight illumination
Remote radio control
Sound systems
W/o premium sound

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 4) for Ford Econoline E150 1996

List of elements for Power Distribution Wiring Diagram (1 of 4) for Ford Econoline E150 1996:

68

(5.8l 49 states over 8600 gvw & 7.5l except california)
(all other gasoline models)
(pcm) power relay
(right side of engine compt.)
300a
4wabs relay
Auxiliary battery
Auxiliary battery relay
C1010
C143
C175
C184
C190
C231
C330
C422
Class 2 trailer adapter
Daytime running lamps (drl) module
Diesel only
Diesel only: w/ambulance package
Electronic brake
Engine compartment fuse panel
From fuse #5 (interior fuse panel) (schematic page 3)
Fuel pump relay
Fuse b 50a
Fuse c 30a
Fuse d 20a
Fuse h 30a
Fuse j 40a
Fuse k 30a
Fuse r 15a
Fuse s 60a
Fuse t 60a
Fuse v 60a
G101
Gasoline only
Generator/regulator
Glow plug relay
Horn relay
Idm relay
If equipped
Left battery
Main light switch
Mega fuse
Modified vehicle power
Pcm power relay
Power- train control module (pcm)
Powertrain control module (pcm)
Red
Right battery (diesel only)
S162
Starter motor
Starter motor relay
To interior fuse panel (schematic page 2)
To schematic page 2
Trailer backup lamp relay
Trailer battery charge relay
Trailer running lamp relay
Trailer/ camper adapter connector
W/ auxiliary battery
W/ trailer adapter
W/ambulance package
W/auxiliary battery only
W/auxiliary battery or auxiliary battery jumper
W/o ambulance package
W/o auxiliary battery
W/o auxiliary battery only
W/o trailer adapter

Power Distribution Wiring Diagram (2 of 4) for Ford Econoline E150 1996

List of elements for Power Distribution Wiring Diagram (2 of 4) for Ford Econoline E150 1996:

94

(attached to instrument panel assembly, behind instrument cluster)
(combination switch
(door lock switch only)
(left cowl
(main light switch)
(multi-function switch)
(not used)
(pin 10)
(pin 2)
(pin r)
(w/o door trim)
All vehicles except rv van, rv cutaway, chateau wagon
Amplifier
Anti- theft indicator
Auxiliary blower motor relay
Blower motor relay
Brake on/off (boo) switch
Brake pressure switch
C213
C223
C224
C230
C235
C247
C333
C334
C430
Cargo lamp
Chateau wagon
Cigar lighter
Cutaways
Data link connector (dlc)
Dome switch/ lamp
Dome/ map switch & lamp
Dome/map switch & lamp
Dome/map switch and lamp
Driver's power lumbar switch
Driver's seat regulator control switch
Engine compartment fuse panel
Exterior lights system
From c schematic page 1
From fuse s (engine compartment b fuse panel (schematic page 1)
Fuse 15a
Fuse 25a
Fuse a 50a
Fuse e 50a
Fuse f 60a
Fuse g 60a
Fuse m 10a
Fuse n 10a
Fuse p 10a
G200
G202
High mounted stop/cargo lamp
If equipped
Illuminated entry module
Interior fuse panel
Left courtesy lamp switch
Left visor lamp
Main light switch
Master window/ door lock control switch or left power door lock switch
Multi-function switch
Panel)
Power mirror switch
Programmable speedometer/ odometer module (psom)
Radio
Rear anti-lock brake system (rabs) module
Rear courtesy lamp switch
Rear power outlet
Red
Regular or extended vans & wagons
Remote keyless entry module
Right courtesy lamp switch
Right power door lock/window switch or right power door lock switch
Right visor lamp
Rv van w/auxiliary a/c
Side door courtesy lamp switch
To ignition switch (on schematic page 3)
To schematic page 3
Trailer running lamp relay
Trailer/ camper adapter
Trailer/camper adapter connector
Vans & wagons
Vans/ wagons only
W/ anti-theft
W/ class i trailer adapter
W/ class ii trailer adapter
W/ cruise control only
W/ full headliner
W/ premium sound
W/ rabs only
W/anti- theft
W/o full headliner
W/power door locks only

Power Distribution Wiring Diagram (3 of 4) for Ford Econoline E150 1996

List of elements for Power Distribution Wiring Diagram (3 of 4) for Ford Econoline E150 1996:

81

(4r70w)
(combination switch)
(door lock switch only)
(e4od)
(not used)
(w/4r7ow trans.)
(w/c6 trans.)
(w/e40d trans.)
4 wheel anti-lock brakes (4wabs) module
Accy
Air bag module
Air bag module (all except cutaways)
All except cutaways
Anti- theft module
Anti-theft module
Auxiliary powertrain control connector
Batt
Blend door actuator
C1012
C139
C143
C151
C201
C209
C217
C317
C330
C335
C336
C339
C6 transmission
Circuit breaker 20a
Daytime running lamps (drl) module
Diesel only
Diesel w/o anti-theft
E40d & 4r70w transmission
From fuse g engine compartment fuse panel (schematic page 2)
From schematic e page 2
Function selector switch
Fuse 10a
Fuse 15a
Fuse 20a
Fuse 30a
Gasoline w/o anti-theft
Heated oxygen sensor (ho2s) #11
Ignition switch
Interior fuse panel
Lock
Main light switch
Master window/ door lock control switch or left power door lock switch
Memory lock module
Modified vehicle power
Multi- function switch
Nca
Off
Park/ neutral position switch
Passenger's power lumbar switch
Powertrain control module (pcm)
Programmable speedometer/ odometer module (psom)
Rear anti-lock brakes system (rabs) module
Red/
Right power door lock/window switch or right power door lock switch
Run
Shift lock actuator
Start
To auxiliary battery relay (schematic page 1)
To diesel warning lamps display module, dual brake warning diode/ resistor assembly, instrument cluster, fuel water switch & low vacuum warning switch (schematic page 4)
To fuse u (engine compt. fuse panel) (schematic page 4)
To fuses 2,6,11 & circuit breaker 14 (interior fuse panel) (schematic page 4)
Transmission control switch/ indicator lamp
Transmission range (tr) sensor
Transmission range (tr) sensor or park/neutral position switch
W/ 4wabs
W/ anti- theft
W/ anti-theft
W/4wabs
W/o anti-theft
W/power door locks
W/power seats
W/rabs
Warning buzzer module

Power Distribution Wiring Diagram (4 of 4) for Ford Econoline E150 1996

List of elements for Power Distribution Wiring Diagram (4 of 4) for Ford Econoline E150 1996:

64

(combination switch)
(power window switch only)
4wabs relay
Accessory tap
Anti-theft module
C1009
C124
C164
C214
C224
C232
C233
C241
C333
C335
C512
C513
Circuit breaker 20a
Diesel models only
Diesel only
Diesel warning lamps display module
Diode (plug-in)
Distributor
Dual brake warning diode/ resistor assembly (w/rabs)
Engine compartment fuse panel
From ignition switch (schematic page 3)
From fuse 18 (interior fuse panel) (schematic page 3)
Fuel line heater
Fuel water switch
Fuse 15a
Fuse 20a
Fuse 30a
Fuse 5a
Fuse u 30a
Gasoline only
Glow plug relay
Idle validation switch
If equipped
Ign
Ignition coil
Ignition control module (icm) (gasoline only)
Illuminated entry module (w/o anti- theft)
Instrument cluster
Interior fuse panel
Interior lights system (instrument illumination circuit)
Interior lights system (main light switch) (dimmer)
Low vacuum warning switch
Main light switch
Master window/ door lock control switch or left power window switch
Nca
Pcm power relay
Radio
Radio capacitor
Remote keyless entry module
Remote radio control
Right power door lock/ window switch or right power window switch
Speed control servo/amplifier assembly (gasoline models only)
Trailer battery charge relay
W/ premium sound
W/anti-theft only
W/o premium sound
W/power windows only
Windshield wiper motor
Wiper control module

POWER DOOR LOCKS

Door Lock Wiring Diagram, with Memory Lock for Ford Econoline E150 1996

List of elements for Door Lock Wiring Diagram, with Memory Lock for Ford Econoline E150 1996:

23

(behind
Battery side door lock output
Button contact
Circuit breaker 12 20a
G200
Ground
Hot at all times
Interior fuse panel (behind left side of i/p)
Left cowl)
Left front door lock motor
Lock
Lock input
Master window/door lock control switch or left power door lock switch
Memory lock module (behind left "b" pillar)
Rear door lock motor
Red
Right front door lock motor
Right power door lock/window switch or right power door lock switch
Side door lock motor (sliding door)
Unlock
Unlock input
W/combination power door lock/ * window switch
W/o combination ** power door lock/ window switch

Door Lock Wiring Diagram, without Memory Lock for Ford Econoline E150 1996

List of elements for Door Lock Wiring Diagram, without Memory Lock for Ford Econoline E150 1996:

19

(behind left cowl)
20a
Circuit breaker 12
G200
Hot at all times
Interior fuse panel (behind left side of i/p)
Left front door lock motor
Lock
Master window/ door lock control switch or left power door lock switch
Memory lock jumper
Pnk/
Rear door lock motor
Red
Right front door lock motor
Right power door lock/ window switch or right power door lock switch
Side door lock motor (hinged door)
Unlock
W/ combination power door lock/ * window switch
W/o combination ** power door lock/ window switch

Keyless Entry Wiring Diagram for Ford Econoline E150 1996

List of elements for Keyless Entry Wiring Diagram for Ford Econoline E150 1996:

54

* w/ combination power door lock/ window switch
Anti-theft module (left side of vehicle, behind "b" pillar)
Anti-theft system (courtesy lamp switches)
Anti-theft system (side door courtesy lamp switch)
Button contact (attached to rear of "b" pillar)
C333
C334
C335
C336
Courtesy lamp sw input
Disarm switch
Door handle switch input
Door lock ctrl
Driver's door lock ctrl
Engine compartment fuse panel (left side of engine compartment)
Fuse 15a
Fuse 20a
Fuse a 50a
G200 (behind left cowl)
Ground
Hot at all times
Hot in accy or run
Interior fuse panel (behind left side of i/p)
Interior lamps ctrl
Left door handle switch
Left front door lock motor
Lock
Lock all doors
Lock input
Master window/ door lock control switch/ or left power door lock switch
Panic activate output
Panic alarm in
Power (hot at all times)
Power (ignition)
Program a
Program b
Rear door lock ctrl
Rear door lock motor
Remote keyless entry module (behind left "b" pillar)
Right door handle switch
Right door key cyl sw in
Right door key cylinder switch
Right front door lock motor
Right power door lock/ window switch or right power door lock switch
Rke data link connector (dlc) (behind left side of i/p)
Side door courtesy sw in
Side door lock ctrl
Side door lock motor
Unlock
Unlock dr door
Unlock input
Unlock sense
W/o sliding door
W/sliding door

POWER MIRRORS

Power Mirror Wiring Diagram for Ford Econoline E150 1996

List of elements for Power Mirror Wiring Diagram for Ford Econoline E150 1996:

16

(w/door trim)
(w/o door trim)
Direct- tional switch
Fuse 15a
G200 (behind left cowl)
Hot at all times
Interior fuse panel (behind left side of i/p)
L/r motor
Left & right switch
Left power mirror
Power mirror switch
Red
Right power mirror
Up/dn motor
W/0 door trim
W/door trim

POWER SEATS

Driver Power Seat Wiring Diagram for Ford Econoline E150 1996

List of elements for Driver Power Seat Wiring Diagram for Ford Econoline E150 1996:

16

Driver's seat motor assembly
Driver's seat regulator control switch
Engine compartment fuse panel (left side of engine compartment)
Entire seat
Front height motor
Front of seat
Fuse e 50a
Fwd
Fwd/rwd motor
G200 (behind left cowl)
Hot at all times
Power lumbar seats
Rear height motor
Rear of seat
Rwd
W/power lumbar seats

Lumbar Wiring Diagram for Ford Econoline E150 1996

List of elements for Lumbar Wiring Diagram for Ford Econoline E150 1996:

12

(behind left cowl) g200
Driver's lumbar pump
Driver's power lumbar switch
Engine compartment fuse panel (left side of engine compartment)
Fuse 16 30a
Fuse e 50a
Hot at all times
Interior fuse panel (behind left side of i/p)
Passenger's lumbar pump
Passenger's power lumbar switch
Power seats
Red

POWER WINDOWS

Power Window Wiring Diagram for Ford Econoline E150 1996

List of elements for Power Window Wiring Diagram for Ford Econoline E150 1996:

14

* **
** *
Circuit breaker 14 20a
G200 (behind left cowl)
Hot in accy or run
Interior fuse panel (behind left side of i/p)
Left power window motor
Master window/ door lock control switch or left power window switch
Power door lock/ window switch
Right power door lock/ window switch or right power window switch
Right power window motor
Up down
W/ combination *
W/o combination power door lock/ window switch

RADIO

Base Radio for Ford Econoline E150 1996

List of elements for Base Radio for Ford Econoline E150 1996:

30

(1)
(1) not available w/ cutaways
(behind instrument cluster) g202
Batt (b+)
C224
C225
Fuse 11 15a
Fuse 8 15a
Ground
Hinged side doors
Hot at all times
Hot in accy or run
Ignition
Illum
Interior fuse panel
Interior lights system
Lcd illum
Left front door speaker
Left mid speaker
Left rear speaker
Lt front spk
Lt rear spk
Radio
Right front door speaker
Right rear speaker
Right side door speaker
Rt front spk
Rt rear spk
Sliding door plunger contacts
Sliding side door

Premium Sound Radio Wiring Diagram for Ford Econoline E150 1996

List of elements for Premium Sound Radio Wiring Diagram for Ford Econoline E150 1996:

54

(behind instrument cluster) g202
Amp input
Amplifier (behind right side of dash)
Batt (b+)
C213
C224
C243
C244
C296
C319
Fuse 10 25a
Fuse 11 15a
Fuse 8 15a
G200 (behind left kick panel)
Ground
Hinged side doors
Hot at all times
Hot in accy or run
Ignition
Illum
Illumination
Interior fuse panel
Interior lights system
Lcd illum
Left front door speaker
Left mid speaker
Left rear speaker
Left speaker
Logic mute
Lt amp input
Lt front amp in
Lt front speaker
Lt front spk
Lt rear amp in
Lt rear speaker
Lt rear speakere
Lt rear spk
Power
Radio
Radio receiver
Remote ctrl
Remote radio control
Right front door speaker
Right rear speaker
Right side door speaker
Right speaker
Rt amp input
Rt front amp in
Rt front speaker
Rt front spk
Rt rear speaker
Rt/rear spk
Sliding door plunger contacts
Sliding side door

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Ford Econoline E150 1996

List of elements for Shift Interlock Wiring Diagram for Ford Econoline E150 1996:

12

(behind left cowl)
(behind left side of i/p, on brake pedal bracket)
Brake on/off (boo) switch
Fuse 1 15a
Fuse 5 15a
G200
Hot at all times
Hot in run
Interior fuse panel (behind left side of i/p)
Ohms
Shift lock actuator (on steering column)
Solid state

STARTING/CHARGING

4.9L

4.9L, Charging Wiring Diagram for Ford Econoline E150 1996

List of elements for 4.9L, Charging Wiring Diagram for Ford Econoline E150 1996:

30

0hms
Accy
Auxiliary battery
Auxiliary battery relay (left side of engine compt, below headlamp)
Battery
C233
Charge indicator
Cluster
Distribution
Engine compartment fuse panel (left side of engine compartment)
Engine compartment fuse panel (left side of engine compt)
Fuse g 60a
Fuse t 60a
Fuse u 30a
G101 (right side of engine compt.)
G120 (right side of engine)
Generator/ regulator
Ground distribution system
Ignition switch
Instrument
Lock
Off
Optional
Power
Red
Run
Start
Starter motor relay
Starting circuit
System

4.9L, Starting Wiring Diagram for Ford Econoline E150 1996

List of elements for 4.9L, Starting Wiring Diagram for Ford Econoline E150 1996:

29

(4r70w)
(e40d)
Acc
Anti-theft module (left side of vehicle, behind "b" pillar)
Battery
C143
C336
C6 transmission
E40d or 4r70w transmission
Engine compartment fuse panel (left side of engine compartment)
Fuse 10a
Fuse g 60a
G120 (right side of engine)
Ground distribution system
Ignition switch
Interior fuse panel (behind left side of i/p)
Lock
Off
Park/ neutral position switch (left side of transmission)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Red
Run
Start
Starter motor (lower right side of engine)
Starter motor relay (left front corner of engine compartment)
Transmission range (tr) sensor
Transmission range (tr) sensor (left side of transmission)
W/ anti-theft
W/o anti-theft

5.0L

5.0L, Charging Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.0L, Charging Wiring Diagram for Ford Econoline E150 1996:

30

0hms
Accy
Auxiliary battery
Auxiliary battery relay (left side of engine compt, below headlamp)
Battery
C233
Charge indicator
Cluster
Distribution
Engine compartment fuse panel (left side of engine compartment)
Engine compartment fuse panel (left side of engine compt)
Fuse g 60a
Fuse t 60a
Fuse u 30a
G101 (right side of engine compt.)
G120 (right side of engine)
Generator/ regulator
Ground distribution system
Ignition switch
Instrument
Lock
Off
Optional
Power
Red
Run
Start
Starter motor relay
Starting circuit
System

5.0L, Starting Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.0L, Starting Wiring Diagram for Ford Econoline E150 1996:

29

(4r70w)
(e40d)
Acc
Anti-theft module (left side of vehicle, behind "b" pillar)
Battery
C143
C336
C6 transmission
E40d or 4r70w transmission
Engine compartment fuse panel (left side of engine compartment)
Fuse 10a
Fuse g 60a
G120 (right side of engine)
Ground distribution system
Ignition switch
Interior fuse panel (behind left side of i/p)
Lock
Off
Park/ neutral position switch (left side of transmission)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Red
Run
Start
Starter motor (lower right side of engine)
Starter motor relay (left front corner of engine compartment)
Transmission range (tr) sensor
Transmission range (tr) sensor (left side of transmission)
W/ anti-theft
W/o anti-theft

5.8L

5.8L, Charging Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.8L, Charging Wiring Diagram for Ford Econoline E150 1996:

30

0hms
Accy
Auxiliary battery
Auxiliary battery relay (left side of engine compt, below headlamp)
Battery
C233
Charge indicator
Cluster
Distribution
Engine compartment fuse panel (left side of engine compartment)
Engine compartment fuse panel (left side of engine compt)
Fuse g 60a
Fuse t 60a
Fuse u 30a
G101 (right side of engine compt.)
G120 (right side of engine)
Generator/ regulator
Ground distribution system
Ignition switch
Instrument
Lock
Off
Optional
Power
Red
Run
Start
Starter motor relay
Starting circuit
System

5.8L, Starting Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.8L, Starting Wiring Diagram for Ford Econoline E150 1996:

29

(4r70w)
(e40d)
Acc
Anti-theft module (left side of vehicle, behind "b" pillar)
Battery
C143
C336
C6 transmission
E40d or 4r70w transmission
Engine compartment fuse panel (left side of engine compartment)
Fuse 10a
Fuse g 60a
G120 (right side of engine)
Ground distribution system
Ignition switch
Interior fuse panel (behind left side of i/p)
Lock
Off
Park/ neutral position switch (left side of transmission)
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Red
Run
Start
Starter motor (lower right side of engine)
Starter motor relay (left front corner of engine compartment)
Transmission range (tr) sensor
Transmission range (tr) sensor (left side of transmission)
W/ anti-theft
W/o anti-theft

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Ford Econoline E150 1996

List of elements for Supplemental Restraint Wiring Diagram for Ford Econoline E150 1996:

32

(behind left i/p) air bag module
* pin shorting bar is engaged when module connector is disconnected
10*
11*
Air bag ind
Air bag indicator
C crash sens
C208
C209
C232
Clock- spring assembly
Drvr air bag
Fuse 15a
Fuse 20a
G200 (behind left cowl)
Gnd
Hot at all times
Hot in run
Hot in start or run
Instrument cluster
Interior fuse panel (behind left side of i/p)
Nca
Ohms +/- 20 ohms
Pass bag off
Pwr (bat)
Pwr (run)
R crash sens
Radiator center forward primary crash sensor (lower center front of engine compartment)
Right frame rail primary crash sensor (mounted near right cowl panel)
Right kick panel safing sensor (mounted on right side frame rail)
Safing sens
Steering column air bag (steering column assembly)

TRANSMISSION

4.9L

4.9L, Transmission Wiring Diagram for Ford Econoline E150 1996

List of elements for 4.9L, Transmission Wiring Diagram for Ford Econoline E150 1996:

92

connector (dlc) (partial) (below left side of i/p)
(attached to instrument panel assembly, behind instrument cluster) g202
(back up lamp switch to rear lamp feed harness, in break out to e40d transmission)
(dash engine gage feed harness, near break out to a/c compressor clutch)
(dash engine gage feed harness, near break out to airb solenoid)
(dash engine gage feed harness, near break out to engine oil pressure switch) s119
(engine control sensor harness, near break out to harness in line connector, left rear of engine compartment)
(engine control sensor harness, near break out to powertrain control module (pcm))
(engine control sensor harness, near break out; to powertrain control module (pcm) (without cruise control) to speed control servo/amplifier assembly) (with cruise control) s151
(fuel charge harness, near break out to fuel injector 2)
(in engine compartment fuse panel)
(left side of engine compartment, near battery) g111
Boo
Brake on/off (boo) switch (on brake pedal bracket)
Bus +
Bus -
C143
C230
C233
Ccs
Check engine light "malfunction indicator lamp (mil)"
Coast clutch solenoid
Control module (pcm) (without cruise control) near break out to speed control servo/ amplifier assembly) (with cruise control) s147
Data link
Diode (plug-in)
E40d transmission (right side of transmission)
Ect
Electronic pressure control solenoid
Engine compartment fuse panel
Engine coolant temperature (ect) sensor (top front of engine, on heater outlet elbow)
Epc
Fuse 15a
Fuse c 30a
Fuse u 30a
G111 (left side of engine compartment, near battery)
Gen scan
Gnd
Hot at all times
Hot in run
Hot in start or run
Iat
Instrument cluster
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Interior fuse panel
Kapwr
Maf
Maf rtn
Mass air flow (maf) sensor (center of engine compartment)
Mil
N d
Nca
Od off
Pcm power relay
Power
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
S100
S104
S116
S117
S120
S133
S140
S141
S145
S146
S153
S160
S187
S206
S208
S218
S221
Shift solenoid
Sig rtn
Speed control servo/ amplifier assembly (left side of engine compartment, near brake master cylinder)
Ss1
Ss2
Tcc
Tcil
Tcs
Tft
Throttle position (tp) sensor (top left side of engine)
Torque converter clutch solenoid
Transmission control switch/indicator lamp
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)
Vref
Vss
Vss input
Vss output

5.0L

5.0L, Transmission Wiring Diagram for Ford Econoline E150 1996

List of elements for 5.0L, Transmission Wiring Diagram for Ford Econoline E150 1996:

90

(back up lamp switch to rear lamp feed harness, in break out to 4r70w transmission)
(back up lamp switch to rear lamp feed harness, in break out to 4r70w transmission) s104
(below left side of i/p)
(engine control sensor harness, near break out to harness to in line connector, left rear of engine compartment)
(engine control sensor harness, near break out to powertrain control module (pcm) (without cruise control) near break out to speed control servo/amplifier assembly) (with cruise control) s147
(engine control sensor harness, near break out; to powertrain control module (pcm) (without cruise control) to speed control servo/amplifier assembly) (with cruise control) s151
(fuel charge harness, near break out to fuel injector 2) s114
(fuel charge harness, near break out to throttle position (tp) sensor)
(in engine compartment fuse panel)
(left side of engine compartment, near battery) g111
4r70w transmission (left side of transmission)
Boo
Brake on/off (boo) switch (on brake pedal bracket)
Bus (+)
Bus (-)
C143
C230
C233
Check engine light "malfunction indicator lamp (mil)"
Data link connector (dlc) (partial)
Diode (plug-in)
Ect
Electronic pressure control (epc) solenoid
Engine compartment fuse panel
Engine coolant temperature (ect) sensor (top front of engine, near distributor)
Epc
Fuse 15a
Fuse c 30a
Fuse u 30a
G111 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Gen scan
Gnd
Hot at all times
Hot in run
Hot in start or run
Iat
Instrument cluster
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Interior fuse panel
Kapwr
Maf
Mass air flow (maf) sensor (center of engine compart- ment)
Mil
N d
Nca
Od off
Pcm power relay
Power
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
S100 (fuel charge harness, near break out to fuel injector 2)
S1000
S117
S120
S133
S140
S141
S145 (engine control sensor harness, near break out to powertrain control module (pcm))
S146
S153
S160
S187
S206
S208
S218
S221
Sens gnd
Shift solenoid
Sig rtn
Speed control servo/ amplifier assembly (left side of engine compartment, near brake master cylinder)
Ss1
Ss2
Tcc
Tcil
Tcs
Tft
Throttle position (tp) sensor (right front of engine)
Torque converter converter clutch (tcc) solenoid
Transmission control switch/indicator lamp
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)
Transmission speed sensor (tss)
Tss
Vref
Vss
Vss gnd
Vss input
Vss output

5.8L

5.8L, Transmission Wiring Diagram, Federal over 8600 GVW for Ford Econoline E150 1996

List of elements for 5.8L, Transmission Wiring Diagram, Federal over 8600 GVW for Ford Econoline E150 1996:

86

(attached to instrument panel assembly, behind instrument cluster) g202
(back up lamp switch to rear lamp feed harness, in break out to e40d transmission)
(engine control sensor harness, near break out to harness in line connector, left rear of engine compartment)
(engine control sensor harness, near break out to harness in line connector, left rear of engine compartment) s143
(engine control sensor harness, near break out; to powertrain control module (pcm) (without cruise control) to speed control servo/amplifier assembly) (with cruise control) s151
(fuel charge harness, near break out to evaporative emissions (evap) canister purge valve)
(fuel charge harness, near break out to fuel injector 2) s114
(in engine compartment fuse panel)
Boo
Brake on/off (boo) switch (on brake pedal bracket)
C175
C230
C233
Ccs
Check engine light "malfunction indicator light (mil)"
Coast clutch solenoid
Control module (pcm) (without cruise control) near break out to speed control servo/ amplifier assembly) (with cruise control) s147
Data
Data (+)
Data (-)
Data link connector (dlc) (left front corner of engine compartment)
Diode (plug-in)
E40d transmission (right side of transmission)
Ect
Electronic pressure control solenoid
Engine compartment fuse panel
Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
Epc
Fuse 15a
Fuse c 30a
Fuse u 30a
G111 (left side of engine compartment, near battery)
Gnd
Ho2s gnd
Hot at all times
Hot in run
Hot in start or run
Iat
Ign
Instrument cluster
Intake air temperature (iat) sensor (right side of engine, near fuel injector 1)
Interior fuse panel
Kapwr
Manifold absolute pressure (map) sensor (right side of engine compartment)
Map
Mil
N d
Nca
Od off
Pcm power relay
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
S104
S116
S118
S120
S133
S140
S141
S146
S153
S160
S206
S208
S218
S221
Shift solenoid
Sig rtn
Speed control servo/ amplifier assembly (left side of engine compartment, near brake master cylinder)
Ss1
Ss2
Tcc
Tcil
Tcs
Tft
Throttle position (tp) sensor (right front of engine)
Torque converter clutch solenoid
Transmission control switch/indicator lamp
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)
Vref
Vss (+)
Vss (-)
Vss input
Vss output

5.8L, Transmission Wiring Diagram, Federal under 8600 GVW & Calif. for Ford Econoline E150 1996

List of elements for 5.8L, Transmission Wiring Diagram, Federal under 8600 GVW & Calif. for Ford Econoline E150 1996:

89

connector (dlc) (partial) (below left side of i/p)
(attached to instrument panel assembly, behind instrument cluster) g202
(back up lamp switch to rear lamp feed harness, in break out to e40d transmission)
(engine control sensor harness, near break out to harness in line connector, left rear of engine compartment)
(engine control sensor harness, near break out; to powertrain control module (pcm) (without cruise control) to speed control servo/amplifier assembly) (with cruise control) s151
(fuel charge harness, near break out to fuel injector 2)
(fuel charge harness, near break out to fuel injector 2) s114
(in engine compartment fuse panel)
(left side of engine compartment, near battery) g111
Boo
Brake on/off (boo) switch (on brake pedal bracket)
Bus +
Bus -
C143
C230
C233
Ccs
Check engine light "malfunction indicator lamp (mil)"
Coast clutch solenoid
Control module (pcm) (without cruise control) near break out to speed control servo/ amplifier assembly) (with cruise control) s147
Data link
Diode (plug-in)
E40d transmission (right side of transmission)
Ect
Electronic pressure control solenoid
Engine compartment fuse panel
Engine coolant temperature (ect) sensor (top front of engine, near distributor, on heater tube)
Epc
Fuse 15a
Fuse c 30a
Fuse u 30a
G111 (left side of engine compartment, near battery)
Gen scan
Gnd
Hot at all times
Hot in run
Hot in start or run
Iat
Instrument cluster
Intake air temperature (iat) sensor (center of engine compartment, part of clean air tube)
Interior fuse panel
Kapwr
Maf
Maf rtn
Mass air flow (maf) sensor (center of engine compartment)
Mil
N d
Nca
Od off
Pcm power relay
Power
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Programmable speedometer/ odometer module (psom) (behind left side of i/p)
Red
S100
S104
S117
S120
S133
S140
S141
S145 (engine control sensor harness, near break out to powertrain control module(pcm))
S146
S153
S160
S187
S206
S208
S218
S221
Shift solenoid
Sig rtn
Speed control servo/ amplifier assembly (left side of engine compartment, near brake master cylinder)
Ss1
Ss2
Tcc
Tcil
Tcs
Tft
Throttle position (tp) sensor (right front of engine)
Torque converter clutch solenoid
Transmission control switch/indicator lamp
Transmission fluid temperature sensor
Transmission range (tr) sensor (left side of transmission)
Vref
Vss
Vss gnd
Vss input
Vss output

WARNING SYSTEMS

Warning System Wiring Diagrams for Ford Econoline E150 1996

List of elements for Warning System Wiring Diagrams for Ford Econoline E150 1996:

29

"fasten belts" indicator
(below left side of i/p)
Anti-theft system (diode b)
C232
Door open input
Fuse 15a
Fuse 20a
G200 (behind left cowl)
G202 (attached to instrument panel assembly, behind the i/p cluster)
Head
Headlamps on input
Hot at all times
Hot in start or run
Instrument cluster
Interior fuse panel (behind left side of i/p)
Interior lights system
Key warning switch
Left courtesy lamp switch
Main light switch
Nca
Off
Park
Power distribution system
Red/ pnk
Red/pnk
Seat belt buckled key in ignition input ground fasten belts output power input
Seat belt switch (in driver's seat belt buckle)
Steering column assembly
Warning buzzer module

WIPER/WASHER

Wiper/Washer Wiring Diagram for Ford Econoline E150 1996

List of elements for Wiper/Washer Wiring Diagram for Ford Econoline E150 1996:

35

100k ohms
3.3k ohms
4.08k
7.25k
8.25a c.b.
Common
Fuse 30a
G106 (left side of engine compartment, near battery)
G202 (attached to instrument panel assembly, behind instrument cluster)
Ground
Hot in accy or run
Int max
Int min
Interior fuse panel (behind left side of i/p)
Interval control
Multi- function switch
Off
Off 36.27k ohms
Ohms
Park
Power
Red
Run
Wash
Washer pump motor
Washer pump motor (attached to washer on right fender apron)
Windshield wiper motor
Wiper common
Wiper control module (behind right side of i/p)
Wiper mode
Wiper motor
Wiper motor high
Wiper motor low
Wiper motor switch
Wiper motor/ park posit sw