All Wiring Diagrams for Ford Econoline E150 2002

AIR CONDITIONING

4.2L

4.2L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002

List of elements for 4.2L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002:

(engine control harness, near breakout to battery junction box) s110
(left rear of engine compartment) g113
(left rear of engine compt)
(left side of engine compt) s195
(not used)
(rear of engine) s107
(right rear of engine compartment) g114
87a
A/c clutch relay
A/c clutch solenoid
A/c compressor clutch diode
A/c demand signal
A/c on input signal
A/c relay control
A/c switch
Battery junction box (in left front of engine compartment)
Blower motor
Blower motor relay
C1026
Central junction box (left side of dash, near kick panel)
Fuse 10a
Fuse 15a
Fuse 30a
Fuse 50a
Fused blower motor feed
Hot at all times
Hot in run
Note: pcm power relay energized w/ignition switch in run or start position
Pcm power relay
Powertrain control module (in left rear of engine compartment, near brake master cylinder)
Red
S142

4.2L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002:

(front of right front fender) g101
(left kick panel) g204
(left rear of engine compt) s142
(near battery junction box) s110
(near battery junction box) s111
(rear of engine) s107
(under left side of dash) s223
87a
A/c clutch cycling pressure switch (in right front of engine compartment)
A/c clutch relay
A/c clutch solenoid
A/c compressor clutch diode
A/c high pressure switch) (in right front of engine compartment)
A/c on input signal
A/c relay control
Battery junction box (in left front of engine compartment)
Blend door actuator (behind right side of dash, on a/c heater plenum)
Central junction box (left side of dash, near kick panel)
Defrost
Floor
Front function selector switch assembly
Fuse 10a
Fuse 15a
Fuse 30a
Hot at all times
Hot in run
Max a/c
Mix
Norm a/c
Note: pcm power relay energized w/ignition switch in run or start position
Off
Pcm power relay
Powertrain control module (in left rear of engine compartment, near brake master cylinder)
Red
To blower motor relay (diagram 2 of 2)
To s400 (diagram 2 of 2)
Vent
Vent norm a/c

4.2L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002:

(behind left side of rear seats) s400
(behind upper left side of dash) g203
(front of right front fender) g101
(in right rear of engine compartment) blower motor resistor
(left rear corner of vehicle) g400
(left rear of engine compt) s122
(left upper radiator support) g100
(not used)
(top of "b" pillar) s303
.25 ohms +/- 10%
.8 ohms +/- 10%
2.7 ohms +/- 10%
87a
Auxiliary blower motor (above left rear wheelwell)
Auxiliary blower motor resistor assembly (above left rear wheelwell)
Battery junction box (in left front of engine compartment)
Blower motor (on right side of engine compartment)
Blower motor relay
Compartment)
Cutaways
From s111 (diagram 1 of 2)
Front function selector switch assembly
Fuse 50a
High
Hot at all times
Low
Low/rear
Off
Rear a/c blower speed relay 1 (in left rear corner of vehicle, above wheelwell)
Rear a/c blower speed relay 2 (in left rear corner of vehicle, above wheelwell)
Rear function selector switch assembly
S143 (right side of engine
S144 (right side of engine compt)
S202 behind center of dash)
S304 (top of "b" pillar)
S305 (top of "b" pillar)
S401 (behind left side of rear seats)
Thermal limiter
Vans & wagons
W/ auxiliary a/c
W/ rear control
W/o rear control

4.6L

4.6L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002:

(left rear of engine compartment) g113
(left side of engine compt) s195
(not used)
(rear of engine) s107
(right rear of engine compartment) g114
A/c clutch solenoid
A/c compressor clutch diode
A/c demand signal
A/c on input signal
A/c switch
Battery junction box (in left front of engine compartment)
Blower motor
Blower motor relay
C1026
Central junction box (left side of dash, near kick panel)
Fuse 15a
Fuse 50a
Fused blower motor feed
Hot at all times
Hot in run
Powertrain control module (in left rear of engine compartment, near brake master cylinder)

4.6L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002:

(front of right front fender) g101
(left kick panel) g204
(left rear of engine compt) s142
(near battery junction box) s110
(near battery junction box) s111
(rear of engine) s107
(under left side of dash) s223
87a
A/c clutch cycling pressure switch (in right front of engine compartment)
A/c clutch relay
A/c clutch solenoid
A/c compressor clutch diode
A/c high pressure switch (in right front of engine compartment)
A/c on input signal
A/c relay control
Battery junction box (in left front of engine compartment)
Blend door actuator (behind right side of dash, on a/c heater plenum)
Central junction box (left side of dash, near kick panel)
Defrost
Floor
Front function selector switch assembly
Fuse 15a
Fuse 30a
Hot at all times
Hot in run
Max a/c
Mix
Norm a/c
Note: pcm power relay energized w/ignition switch in run or start position
Off
Pcm power relay
Powertrain control module (in left rear of engine compartment, near brake master cylinder)
Red
S166 (right side of engine compartment)
To blower motor relay (diagram 2 of 2)
To s400 (diagram 2 of 2)
Vent
Vent norm a/c

4.6L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002:

(behind left side of rear seats) s400
(behind upper left side of dash) g203
(front of right front fender) g101
(in right rear of engine compartment) blower motor resistor
(left rear corner of vehicle) g400
(left rear of engine compt) s122
(left upper radiator support) g100
(not used)
(top of "b" pillar) s303
.25 ohms +/- 10%
.8 ohms +/- 10%
2.7 ohms +/- 10%
87a
Auxiliary blower motor (above left rear wheelwell)
Auxiliary blower motor resistor assembly (above left rear wheelwell)
Battery junction box (in left front of engine compartment)
Blower motor (on right side of engine compartment)
Blower motor relay
Compartment)
Cutaways
From s111 (diagram 1 of 2)
Front function selector switch assembly
Fuse 50a
High
Hot at all times
Low
Low/rear
Off
Rear a/c blower speed relay 1 (in left rear corner of vehicle, above wheelwell)
Rear a/c blower speed relay 2 (in left rear corner of vehicle, above wheelwell)
Rear function selector switch assembly
S143 (right side of engine
S144 (right side of engine compt)
S202 behind center of dash)
S304 (top of "b" pillar)
S305 (top of "b" pillar)
S401 (behind left side of rear seats)
Thermal limiter
Vans & wagons
W/ auxiliary a/c
W/ rear control
W/o rear control

5.4L

5.4L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Manual A/C Wiring Diagram, with Stripped Chassis for Ford Econoline E150 2002:

(left rear of engine compartment) g113
(left side of engine compt) s195
(not used)
(rear of engine) s107
(right rear of engine compartment) g114
A/c clutch solenoid
A/c compressor clutch diode
A/c demand signal
A/c on input signal
A/c switch
Battery junction box (in left front of engine compartment)
Blower motor
Blower motor relay
C1026
Central junction box (left side of dash, near kick panel)
Fuse 15a
Fuse 50a
Fused blower motor feed
Hot at all times
Hot in run
Powertrain control module (in left rear of engine compartment, near brake master cylinder)

5.4L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Manual A/C Wiring Diagram, without Stripped Chassis (1 of 2) for Ford Econoline E150 2002:

(front of engine) s189
(front of right front fender) g101
(left kick panel) g204
(under left side of dash) s223
5.4l, 5.4l ngv & 6.8l
7.3l di turbo diesel
A/c clutch cycling pressure switch (in right front of engine compartment)
A/c clutch solenoid
A/c compressor clutch diode
A/c high pressure switch (in right front of engine compartment)
A/c on input signal
Central junction box (left side of dash, near kick panel)
Defrost
Floor
Front function selector switch assembly
Fuse 15a
Hot in run
Max a/c
Mix
Norm a/c
Off
Powertrain control module (in left rear of engine compartment, near brake master cylinder)
S111 (near battery junction box)
S141 (right side of engine compt)
S143 (right side of engine compt)
Temperature blend door actuator (behind right side of dash, on a/c heater plenum)
To blower motor relay (diagram 2 of 2)
To s400 (diagram 2 of 2)
Vent
Vent norm a/c

5.4L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Manual A/C Wiring Diagram, without Stripped Chassis (2 of 2) for Ford Econoline E150 2002:

(behind left side of rear seats) s400
(behind upper left side of dash) g203
(front of right front fender) g101
(in right rear of engine compartment) blower motor resistor
(left rear corner of vehicle) g400
(left rear of engine compt) s122
(left upper radiator support) g100
(not used)
(top of "b" pillar) s303
.25 ohms +/- 10%
.8 ohms +/- 10%
2.7 ohms +/- 10%
87a
Auxiliary blower motor (above left rear wheelwell)
Auxiliary blower motor resistor assembly (above left rear wheelwell)
Battery junction box (in left front of engine compartment)
Blower motor (on right side of engine compartment)
Blower motor relay
Compartment)
Cutaways
From s111 (diagram 1 of 2)
Front function selector switch assembly
Fuse 50a
High
Hot at all times
Low
Low/rear
Off
Rear a/c blower speed relay 1 (in left rear corner of vehicle, above wheelwell)
Rear a/c blower speed relay 2 (in left rear corner of vehicle, above wheelwell)
Rear function selector switch assembly
S143 (right side of engine
S144 (right side of engine compt)
S202 behind center of dash)
S304 (top of "b" pillar)
S305 (top of "b" pillar)
S401 (behind left side of rear seats)
Thermal limiter
Vans & wagons
W/ auxiliary a/c
W/ rear control
W/o rear control

ANTI-LOCK BRAKES

Anti-lock Brake Wiring Diagrams, with Stripped Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Anti-lock Brake Wiring Diagrams, with Stripped Chassis for Ford Econoline E150 2002:

87a
Abs control module (at left side of engine compt)
Abs relay (behind center of dash)
Abs warning lamp output
Accy
Anti-lock brake indicator
Battery junction box (in left front of engine compartment)
Bpp switch input
Brake fluid level switch (at left side of engine compt)
Brake pedal position switch (on bracket, above brake pedal)
Brake warn lamp high
Brake warning indicator
Brake warning lamp low
C155a
C155b
C220b
C220c
Central junction box (left side of dash, near kick panel)
Data link conn
Data link connector (below left side of dash)
Fuse 1 20a
Fuse 11 15a
Fuse 19 60a
Fuse 2 15a
G113 (left rear of engine compt)
G114 (right rear of engine compt)
Ground
Hot at all times
Hot in run
Hot in run or start
Ignition switch
Instrument cluster
Instrument cluster system
Left front sensor high
Left front sensor low
Left front wheel speed sensor
Lock
Nca
Off
Ohm
Power
Rear axle speed sensor
Rear sensor high
Rear sensor low
Relay ctrl output
Right front sensor high
Right front sensor low
Right front wheel speed sensor
Run
S119 (left rear of engine compt)
S134 (left rear engine compt)
S195
S199
S213
Start

Anti-lock Brake Wiring Diagrams, without Stripped Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Anti-lock Brake Wiring Diagrams, without Stripped Chassis for Ford Econoline E150 2002:

(left front of engine compartment) vacuum warning switch
(not used)
(under left side of dash)
87a
Abs control module (at left side of engine compt)
Abs relay (behind center of dash)
Abs warning lamp output
Accy
Anti-lock brake indicator
Battery junction box (in left front of engine compartment)
Bpp switch input
Brake fluid level switch (at left side of engine compt)
Brake pedal position switch (on bracket, above brake pedal)
Brake warn lamp high
Brake warning indicator
Brake warning lamp low
C155a
C155b
C220b
C220c
Central junction box (left side of dash, near kick panel)
Data link conn
Data link connector (below left side of dash)
Diesel
Electronic crash sensor (ecs) module (behind right side of dash)
Engine controls system
Fuse 1 20a
Fuse 11 15a
Fuse 19 60a
Fuse 2 15a
G100 (left upper radiator support)
G101 (front of right front fender)
G203 (behind upper left side of dash)
Ground
Hot at all times
Hot in run
Hot in run or start
Ignition switch
Instrument cluster
Instrument cluster system
Left front sensor high
Left front sensor low
Left front wheel speed sensor
Lock
Nca
Off
Ohm
Power
Rear axle speed sensor
Rear sensor high
Rear sensor low
Relay ctrl output
Right front sensor high
Right front sensor low
Right front wheel speed sensor
Run
S119 (left rear of engine compt)
S122
S125 (left rear of engine compt)
S132 (right rear of engine compt)
S134 (left rear engine compt)
S143
S207
S213
S220 (center of dash)
S228
Start

COMPUTER DATA LINES

Computer Data Lines for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Computer Data Lines for Ford Econoline E150 2002:

(left kick panel) g204
(rear left side of engine compt)
Abs control module (left side of engine compt)
Acc
Auxiliary powertrain control module (7.3l diesel) (left side of dash)
Central junction box (left side of dash)
Data link connector (dlc) (below left side of dash)
Electronic crash sensor module (behind right side of dash)
Fuse 20a
G101 (front of right front fender)
G204 (left kick panel)
Hot at all times
Ignition switch
Lock
Natural gas vehicle module (left front inner fender)
Off
Powertrain control module (pcm) (near master brake cylinder)
Run
S140
S182 (rear left side of engine compt)
S184 (rear left side of engine compt)
S223
S228 (left side of dash)
S229
S230
S235 or s260
S262 (rear left side of engine compt)
S263
Start

CRUISE CONTROL

4.2L

4.2L, Cruise Control Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Cruise Control Wiring Diagram for Ford Econoline E150 2002:

Accel set/
Air bag sliding contact (top of steering column)
Battery junction box (left frt of eng compt)
Bpp sw input
Brake input
Brake pedal position (bpp) switch (on bracket, above brake pedal)
C175
C220a
C220c
C3140a
C930
Central junction box (left side of dash)
Coast
Deac- tivator switch (bottom of brake master cyl- inder)
Fuse 10a
Fuse 15a
G203 (behind upper left side of dash)
Ground
Horn relay (battery junction box)
Horn switch
Hot at all times
Hot at all times
Hot in run
Illumination
Instrument cluster
Interior lights system
Nca
Off
Ohms
On indicator
Overhead console
Power
Powertrain control module
Remote keyless entry module (behind left "b" pillar)
Resume
S116
S129
S131
S134 (left rear engine comp)
S135 (left rear engine compt)
S268
Scsa gnd
Scsa input
Speed control servo (left side of engine compt, near brake master cylinder)
Speed control switch assembly (top of steering column)
Speedo
Vss input

4.6L

4.6L, Cruise Control Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Cruise Control Wiring Diagram for Ford Econoline E150 2002:

Accel set/
Air bag sliding contact (top of steering column)
Battery junction box (left frt of eng compt)
Bpp sw input
Brake input
Brake pedal position (bpp) switch (on bracket, above brake pedal)
C175
C220a
C220c
C3140a
C930
Central junction box (left side of dash)
Coast
Deac- tivator switch (bottom of brake master cyl- inder)
Fuse 10a
Fuse 15a
G203 (behind upper left side of dash)
Ground
Horn relay (battery junction box)
Horn switch
Hot at all times
Hot at all times
Hot in run
Illumination
Instrument cluster
Interior lights system
Nca
Off
Ohms
On indicator
Overhead console
Power
Powertrain control module
Remote keyless entry module (behind left "b" pillar)
Resume
S116
S129
S131
S134 (left rear engine comp)
S135 (left rear engine compt)
S268
Scsa gnd
Scsa input
Speed control servo (left side of engine compt, near brake master cylinder)
Speed control switch assembly (top of steering column)
Speedo
Vss input

5.4L

5.4L, Cruise Control Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Cruise Control Wiring Diagram for Ford Econoline E150 2002:

Accel set/
Air bag sliding contact (top of steering column)
Battery junction box (left frt of eng compt)
Bpp sw input
Brake input
Brake pedal position (bpp) switch (on bracket, above brake pedal)
C175
C220a
C220c
C3140a
C930
Central junction box (left side of dash)
Coast
Deac- tivator switch (bottom of brake master cyl- inder)
Fuse 10a
Fuse 15a
G203 (behind upper left side of dash)
Ground
Horn relay (battery junction box)
Horn switch
Hot at all times
Hot at all times
Hot in run
Illumination
Instrument cluster
Interior lights system
Nca
Off
Ohms
On indicator
Overhead console
Power
Powertrain control module
Remote keyless entry module (behind left "b" pillar)
Resume
S116
S129
S131
S134 (left rear engine comp)
S135 (left rear engine compt)
S268
Scsa gnd
Scsa input
Speed control servo (left side of engine compt, near brake master cylinder)
Speed control switch assembly (top of steering column)
Speedo
Vss input

ENGINE PERFORMANCE

4.2L

4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002:

(ends in harness)
(front of left front fender)
(front of right front fender)
A/c on sig
Air conditioning system
Battery junction box (left front of engine compt)
Central junction box (below left side of dash, near left kick panel)
Ckp sensor (+)
Ckp sensor (-)
Cylinder head temperature sensor (left rear of engine compt, on heater outlet elbow)
Data link connector (partial) (left side of dash)
Digital transmission range sensor (dtr sensor) (left side of transmission)
Dtr-tr1
Dtr-tr2
Dtr-tr4
Egr sol ctrl
F gauge sender
Fuel pump out
Fuse 10a
Fuse 30a
Fuse 5a
G100
G101
G101 (front of right front fender)
Ground
Ho2s 12 input
Hot at all times
Hot in run or start
Iat input
Ign coil
Ign coil 1
Ignition coil (left front of engine)
Imrc
Imrc monitor
Instrument cluster system
Ks -
Maf rtn
Mil ctrl
Nca
Not used
O/d off
Od cancel sw
Overdrive cancel switch
Pcm power diode
Pcm power relay
Powertrain control module (left rear of engine compt, near brake master cylinder)
Prgrm signal
R n
Radio capacitor (attached to ignition coil)
Red
S110
S127
S140
S142 (eng ctrl harn, near breakout to maf sensor)
S169
S175
Scp bus (+)
Scp bus (-)
Shift sol b
Spark plugs
Tcil
Tfts input
To dtr sensor (diagram 4 of 4)
Transmission control indicator lamp
Water temp sens

4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002:

(engine control harn, near breakout to 76-pin conn in left rear of engine compt)
(fuel charge harn, near breakout to throttle position sensor)
(left side of dash)
(speedometer/ odometer) vehicle speed input
Battery junction box (left front of engine compt)
C220a
C220b
Crankshaft position sensor (lower right front of engine)
Differential pressure feedback egr sensor (top right front of engine)
Engine coolant temperature gauge
Engine coolant temperature sender (top front center of engine)
Except stripped chassis
Fuel pump relay
Fuel tank pressure transducer sensor (under left center of vehicle)
Fuse 30a
G101 (or g114) (front of right front fender or right rear of engine compt)
G203
G207 (center of dash panel)
Hot at all times
Instrument cluster
Intake manifold runner control module (on rear of intake)
Malfunction indicator
Red
Red/pnk
S103
S107
S126
S133 (engine control harn, near breakout to 16-pin conn near a/c pressure cut out switch)
S138 (engine control harn, near breakout to 16-pin conn near a/c pressure cut out switch)
Stripped chassis
Throttle position sensor (on top of engine, near air intake)

4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002:

(behind right kick panel) inertia fuel shut-off switch
(engine control harn, near a/c pressure cut out switch)
(fuel charge harn, near breakout to fuel injector 2)
(in center rear of engine compt)
(in fuel tank) fuel pump module
(on left frame rail) (cutaways/ stripped chassis) in transit fuel pump module
(trans cntrl harn, near breakout to dtr sensor)
(transmission control harn, near breakout to transmission)
4r70w transmission
Chassis
Egr vacuum regulator solenoid (above center of right valve cover)
Electronic pressure control solenoid
Evap canister purge valve
Except stripped chassis
Fuel injectors
G100 (front of left front fender)
G207 (center of dash)
Idle air control valve (right side of engine, near ignition coil)
Nca
Output shaft speed sensor (left side of transmission)
Red
Red/pnk
S100
S102
S105 (fuel charge harn, near breakout to fuel injector 3)
S106
S136
S307
S309 (fuel tank harn, below left center of vehicle)
Shift solenoids
Stripped
Stripped chassis
Tan
Torque converter clutch solenoid
Transmission fluid temperature sensor

4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002:

(engine control harn, near a/c pressure cut out switch) s135
(near brake master cylinder) speed control servo
(right rear side of engine) knock sensor
240 ohms
A/c rly cntrl
A/c system
Brake on/off
Brake pedal position switch
Camshaft position sensor (on front center of engine)
Canister vent
Central junction box (below left side of dash, near left kick panel)
Cht input
Cmp sensor
Digital transmission range (dtr) sensor (left side of transmission)
Dpfe input
Dtr-tr3a
Epc sol
Evap valve
Evaporative emissions canister vent solenoid (rear of vehicle, near fuel tank)
From dtr sensor (diagram 1 of 4)
Fuel pump ctrl
Fuel tank press
Fuse 15a
G101 (front of right front fender)
Gnd
Ground
Heated oxygen sensor 11 (ho2s) (lower right rear of engine)
Heated oxygen sensor 12 (ho2s) (right side of transmission)
Heated oxygen sensor 21 (ho2s) (left rear of engine)
Heated oxygen sensor 22 (ho2s) (under center of vehicle)
Heater ctrl
Ho2s 11
Ho2s 11 input
Ho2s 12
Ho2s 21
Ho2s 21 input
Ho2s 22
Ho2s 22 input
Hot at all times
Iac ctrl
Ign coil
Inj 1 ctrl
Inj 2 ctrl
Inj 3 ctrl
Inj 4 ctrl
Inj 5 ctrl
Inj 6 ctrl
Kap b(+)
Knock sensor
Maf sens out
Mass air flow sensor (on top center of engine compt)
Nca
Oss (-)
Over- head console
Powertrain control module (left rear of engine compt, near master cylinder)
Red
Red/pnk
Ref output volt
S134 (engine control harn, near a/c pressure cut out switch)
S140
Sig rtn
Tan
Tcc sol
Tcil
Tp sens in
Vpwr
Vss (+)
Vss input

4.6L

4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002:

(ends in harness)
(engine control harness, near breakout to fuel inj 7)
(engine control harness, near breakout to mass airflow sensor)
(front of left front fender)
(front of right front fender)
(front of right front fender) g101
A/c on sig
A/c system
Air ctrl sens
Battery junction box (left front of engine compt)
Central junction box (behind left side of dash, near left kick panel)
Coil on plug
Coil on plug 1
Coil on plug 3
Coil on plug 5
Coil on plug 6
Data link (+)
Data link (-)
Data link connector (partial) (left side of dash)
Digital transmission range sensor (dtr sensor) (left side of transmission)
Dtr sensor (tr1)
Dtr-tr2
Dtr-tr4
Ect
Evr sol
Feps (eprom)
Fuel pump mon
Fuel pump sender
Fuse 10a
Fuse 30a
Fuse 5a
G100
G101
Gnd
Hot at all times
Hot in run or start
Knock sensor
Maf
Mil
Misfire sens (+)
Misfire sens (-)
Nca
O/d off
Overdrive cancel switch
Pcm power diode
Pcm power relay
Powertrain control module (left rear of engine compt, near brake master cylinder)
Pwr gnd
R n
Radio capacitor 1 (right front of engine, attached to ignition coil)
Radio capacitor 2 (left front of engine, attached to ignition coil)
Red
Rr ho2s sig (12)
S110
S127
S140 (or s169)
S142
S150 (engine control harness, near breakout to fuel inj 2)
S193
Shift sol a
Shift sol b
Tach sig
Tcil ind
Tcil lamp
Tcs
Tft
To dtr sensor (diagram 4 of 4)

4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002:

(behind upper left side of dash) g203
(engine control harn, left rear of engine compt)
(engine control harn, near a/c pressure cutout switch)
(engine control harn, near breakout to 76-pin conn in left rear of engine compt) s126
(speedometer/ odometer) vehicle speed input
Battery junction box (left front of engine compt)
Crankshaft position sensor (lower right front of engine)
Differential pressure feedback egr sensor (top left rear of engine)
Engine coolant temperature gauge
Fuel level gauge
Fuel pump relay
Fuel tank pressure transducer (under left center of vehicle)
Fuse 30a
Hot at all times
Inlet manifold runner control module (left front of engine)
Instrument cluster
Instrumentation engine coolant temperature sensor (top front center of engine)
Malfunction indicator
Power
Red
Red/pnk
S103 (fuel charge harn, near breakout to tp sensor)
S120
S133
S138
S153 (fuel charge harn, near a/c pressure cutout switch)
S154 (engine control harn, near breakout to fuel injector 7)
S175 (engine control harn, left rear of engine compt)
Throttle position sensor (on top of engine, near air intake)

4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002:

(engine control harn, in breakout to pcm)
(engine control harn, near a/c pressure cutout switch)
(front of left front fender) g100
(fuel tank harn, below left center of vehicle)
(in center rear of engine compt)
(left end of dash) g203
(transmission control harn, near breakout to dtr sensor)
(transmission control harn, near breakout to transmission)
4r70w transmission
Egr vacuum regulator solenoid (above left valve cover, on bracket)
Electronic pressure control solenoid
Evap canister purge valve
Fuel injectors
Fuel pump module (in fuel tank)
Idle air control valve (rear of engine, near air intake)
In transit fuel pump module (cutaways) (under vehicle, on left frame rail)
Inertia fuel shut-off switch (behind right kick panel)
Nca
Output shaft speed sensor (left side of transmission)
Red
Red/pnk
S100
S102
S136
S137
S151 (engine control harn, near breakout to fuel injector 4)
S152 (engine control harn, near breakout to fuel injector 8)
S268
S309
S310
Shift solenoids
Tan
Tan/ red
Tan/red
Torque converter clutch solenoid
Transmission fluid temperature sensor

4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002:

(ends in harness)
(engine control harn, near a/c pressure cutout switch)
(left side of engine compt) speed control servo
(rear of vehicle, near fuel tank) evap canister vent valve
(top of left cyl head) cylinder head temperature sensor
(top right rear side of engine) knock sensor
240 ohms
5v ref
A/c relay ctrl
A/c system
Brake on/off
Brake pedal position switch
Camshaft position sensor (front of left cylinder head)
Central junction box (behind left side of dash, near left kick panel)
Coil on plug 2
Coil on plug 4
Coil on plug 7
Coil on plug 8
Cyl head temp
Cylinder id
Digital transmission range sensor (dtr sensor) (left side of transmission)
Dpfe sens
Dtr-tr3a
Epc sol
Evap sol
From dtr sensor (diagram 1 of 4)
Fuel inj 1
Fuel inj 2
Fuel inj 3
Fuel inj 4
Fuel inj 5
Fuel inj 6
Fuel inj 7
Fuel inj 8
Fuel pump ctrl
Fuel tank press
Fuse 15a
G101 (front of right front fender)
Heated oxygen sensor (ho2s) 11 (lower right rear of engine)
Heated oxygen sensor (ho2s) 12 (right side of transmission)
Heated oxygen sensor (ho2s) 21 (lower left rear of engine)
Heated oxygen sensor (ho2s) 22 (under center of vehicle)
Heater ctrl
Hot at all times
Iac sol
Kap b(+)
Knock sensor
Lf ho2s
Lf ho2s sig (21)
Lr ho2s
Lr ho2s sig (22)
Maf sens in
Mass air- flow sensor (top center of engine compt)
Nca
Not used
Oss (+)
Over- head console
Powertrain control module (left rear of engine compt, near brake master cylinder)
Pwr gnd
Red
Red/pnk
Rf ho2s
Rf ho2s sig (11)
Rr ho2s
S135
S140
Sig rtn
Tan
Tan/red
Tcc sol
Tp sens in
Vapor valve
Vpwr
Vss (+)
Vss input

5.4L

5.4L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Engine Performance Wiring Diagrams (1 of 4) for Ford Econoline E150 2002:

(ends in harness)
(engine control harn, near breakout to coil on plug 6)
(engine control harn, near breakout to fuel injector 1)
(engine control harn, near breakout to mass air flow sensor)
(front of left front fender)
(front of right front fender) g101
4 low switch
A/c on sig
Air conditioning system
Battery junction box (left front of engine compt)
Bus +
Bus -
Central junction box (behind left side of dash, near left kick panel)
Ckp sens +
Ckp sens -
Coast clutch sw
Coil on plug
Coil on plug 1
Coil on plug 3
Coil on plug 5
Coil on plug 6
Data link connector (partial) (left side of dash)
Digital transmission range sensor (dtr sensor) (left side of transmission)
Dtr-tr1
Dtr-tr2
Dtr-tr4
Ect
Egr sol
Fp sender
Fuel pump mon
Fuse 10a
Fuse 30a
Fuse 5a
G100
Gen scan tool in
Gnd
Ho2s (12)
Hot at all times
Hot in run or start
Instrument cluster system
Ks sensor
Maf
Mil
Nca
Not used
O/d off
Overdrive cancel switch
Pcm power diode
Pcm power relay
Powertrain control module (left side of engine compt, near brake master cylinder)
Pwr gnd
R n
Radio capacitor (right rear of engine)
Radio capacitor (upper left rear of engine)
Rear pwr feed
Red
S110
S127
S140
S142
S156
S161
S169
Ss1
Ss2
Tcs
Tft
To dtr sensor (diagram 4 of 4)
Trans ctrl sw
Transmission control indicator lamp

5.4L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Engine Performance Wiring Diagrams (2 of 4) for Ford Econoline E150 2002:

(behind upper left side of dash) g202
(engine control harn, left rear of engine compt)
(engine control harn, near a/c pressure cutout switch)
(engine control harn, near breakout to 76-pin conn in left rear of engine compt) s126
(engine control harn, near breakout to pcm) s137
(on lower intake manifold) instrumentation engine coolant temperature sensor
(speedometer/ odometer) vehicle speed input
Battery junction box (left front of engine compt)
C224
C225
Crankshaft position sensor (lower center front of engine)
Differential pressure feedback egr sensor (california) (top right side of engine)
Engine coolant temperature gauge
Fuel pump relay
Fuel tank pressure transducer sensor (near fuel tank)
Fuse 30a
Hot at all times
Instrument cluster
Knock sensor (top right rear of engine)
Malfunction indicator
Nca
Power
Red
Red/pnk
S136
S138 (engine control harn, near a/c pressure cutout switch)
S157 (engine control harn, near breakout to coil on plug 9)
S158 (engine control harn, near breakout to radio capacitor 1)
S175
S268
Throttle position sensor (top of engine, near air intake)
Turbine shaft speed sensor (w 4r100 transmission) (right side of trans)

5.4L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Engine Performance Wiring Diagrams (3 of 4) for Ford Econoline E150 2002:

(behind right kick panel) inertia fuel shut-off switch
(center rear of engine compt)
(engine control harn, near breakout to coil on plug 2)
(front of left front fender) g100
(fuel tank harn, below left center of vehicle) s309
(in fuel tank) fuel pump module
(or g104) (left rear of eng compt)
(transmission control harn, near breakout to dtr sensor)
(transmission control harn, near breakout to transmission)
(under vehicle, on left frame rail) (cutaway/stripped) in transit fuel pump module
4r100
4r100 only
4r70w
Coast clutch solenoid (4r100)
Egr vacuum regulator solenoid (california) (above left rear of engine, on bracket)
Electronic pressure control solenoid
Evap canister purge valve
Except stripped chassis
Fuel injectors
Idle air control valve (top center rear of engine, near air intake)
Nca
Red
Red/pnk
S100
S102
S155 (engine control harn, near breakout to fuel injector 6)
S159 (engine control, harn, near breakout to transmission)
S160
S307
Shift solenoid (4r70w)
Shift solenoid a (4r100)
Shift solenoid b (4r100)
Stripped chassis
Tan
Tan/ red
Tan/red
Torque converter clutch solenoid
Transmission
Transmission fluid temperature sensor

5.4L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, Engine Performance Wiring Diagrams (4 of 4) for Ford Econoline E150 2002:

(engine control harn, near a/c pressure cutout switch)
(front of left cylinder head) cylinder head temperature sensor
(near brake master cylinder) speed control servo
(rear of vehicle, near fuel tank) evap canister vent valve
270 ohms
Brake on/off
Brake pedal position switch
Camshaft position sensor (on front of left cylinder head)
Central junction box (behind left side of dash, near kick panel)
Cmp
Coil on plug 2
Coil on plug 4
Coil on plug 7
Coil on plug 8
Cyl head temp
Digital transmission range sensor (dtr sensor) (left side of transmission)
Dpfe sens
Dtr-tr3a
Epc sol
Evap can purge
Evap sol
From dtr sensor (diagram 1 of 4)
Fuel inj 1
Fuel inj 2
Fuel inj 3
Fuel inj 4
Fuel inj 5
Fuel inj 6
Fuel inj 7
Fuel inj 8
Fuel pump ctrl
Fuel tank press
Fuse 15a
G101 (front of right front fender)
Heated oxygen sensor (ho2s) 11 (lower right rear of engine)
Heated oxygen sensor (ho2s) 21 (lower left rear of engine)
Heated oxygen sensor (ho2s) 22 (under center of vehicle)
Heater ctrl
Hego 11
Hego 21
Hego 22
Hot at all times
Idle air ctrl
Kap b(+)
Knock sensor
Maf sens in
Mass air- flow sensor (top center of engine)
Nca
Oss
Output shaft speed sensor (w/ 4r70w transmission) (on left side of transmission)
Overhead console
Powertrain control module (left rear of engine compt, near brake master cylinder)
Pwr gnd
Red
Red/pnk
Ref voltage
S135
S140
Sig rtn
Tan
Tan/red
Tcc sol
Tp sens in
Tss sensor
Vpwr
Vss
Vss input

EXTERIOR LIGHTS

Backup Lamps Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Backup Lamps Wiring Diagram for Ford Econoline E150 2002:

(left rear corner of vehicle) g400
Central junction box (below left side of dash)
Digital transmission range (dtr) sensor (on left side of transmission)
Exterior lights system (reversing lamp trailer tow relay)
Fuse 15a
Hot in run
Left reversing lamp
Right reversing lamp
S113
S130 (rear left side of engine compt)
S402
S403 (center top rear of (vehicle)
S406

Exterior Lamps Wiring Diagram (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Ford Econoline E150 2002:

"b" pillar)
(left side of dash)
(left side of dash) s232
(not used)
(rear left side of engine compt) s134
(right front of engine compt) s165
(wires end in harness) (cutaway models)
All others
Anti- lock brakes system
Batt
Battery junction box (left front of engine compt)
Brake pedal position switch (on bracket, above brake pedal)
C202a
C220a
C3140a
Central junction box (below left side of dash)
Cruise control system
E550 & cutaway
E550 only
Electronic flasher module (behind left side of dash)
Engine compt)
Engine controls system
Fuse 10a
Fuse 15a
Fuse 20a
G100 (upper left radiator support)
G102 (behind left front headlamp)
G203 (behind upper left side of dash)
G204 (left kick panel)
G400 (left rear corner of vehicle)
Hazard
Hazard switch
Head
High mounted stop lamp
Hot at all times
Hot in run
Ign
Instrument cluster
Left front park/ turn lamp
Left rear stop/ park/
Left turn indicator
License lamp
Main light switch
Multi- function switch
Normal
Off
Overhead console
Park r
Remote keyless entry module (behind left "b" pillar)
Right front park/ turn lamp
Right rear stop/ park/
Right turn indicator
S122
S129
S163
S207
S217 (left side of dash)
S218
S223
S224 (under left side of dash)
S226
S234 (bottom of "b" pillar)
S306 (top left rear of vehicle
S402
S406
Shift inter- lock system
Solid state
Stop lamp relay
To battery junction box (fuses 5 & 6) (digram 2 of 2)
To clearance lamp relay (diagram 2 of 2)
To electronic brake control connector (diagram 2 of 2)
To parking lamp trailer relay (diagram 2 of 2)
Turn lamp
Turn left
Turn right

Exterior Lamps Wiring Diagram (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Ford Econoline E150 2002:

(behind left side of dash) modified vehicle power
(class 1)
(class 2)
(class 2) (class 1)
(engine control harn, left rear of eng compt) s118
(left front of engine compt) battery junction block
(left front of engine compt) battery junction box
(left kick panel) g204
(left upper radiator support) g100
(taped in harness)
Auxiliary battery relay
Battery charge trailer tow relay
Battery ii
Battery junction box (in left front of engine compartment)
Battery junction box (left front of engine compt)
C419
Center roof marker lamp
Central junction box (below left side of dash)
Central junction box (left side of dash, near kick panel)
Clearance lamp relay
Digital transmission range (dtr) sensor (left side of transmission)
E550
E550 only
Except 5.4l ngv
Except e550
Exterior lights system (backup lamps circuit)
From brake pedal position switch (diagram 1 of 2)
From main light switch (diagram 1 of 2)
From multi- function switch (diagram 1 of 2)
Fuse 10a
Fuse 15a
Fuse 20a
Fuse 30a
Fuse 40a
Fuse 5a
Fuse 60a
G100 (left upper radiator support)
G110 (right side of engine)
G204 (left kick panel)
G401 (under left rear of vehicle, on frame rail)
Hot at all times
Hot in run
Interior lights system
Left center roof marker lamp
Left rear lamp assembly
Left roof marker lamp
Nca
Not used
Of engine compt) s112
Of roof)
Parking lamp trailer tow relay
Reversing lamp trailer tow relay
Right center roof marker lamp
Right rear lamp assembly
Right roof marker lamp
S108
S109 (near battery junction box)
S113
S122
S130 (rear left side of engine compt)
S223
S431 (left rear of vehicle)
S432
S950 (center of roof)
Trailer connector (7 pin) (class 2) (below center of rear bumper)
Trailer electronic brake control connector
Trailer tow connector (7 pin) (class 2) (below center of rear bumper)
Trailer tow connector (below center of rear bumper)
Trailer tow connector (below left side of rear bumper)
W/ auxiliary battery
W/ auxiliary battery jumper
W/o auxiliary battery

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram, without Stripped Chassis (1 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram, without Stripped Chassis (1 of 4) for Ford Econoline E150 2002:

(eng control harn, near breakout to a/c pressure cut-out switch)
4.2l
4.2l only
4.6l
5.4l ngv only
5.4l, 6.8l
6.8l
A/c clutch solenoid
A/c compressor clutch diode
Auxiliary battery
Battery junction box
Blower motor resistor
Brake fluid level switch
C175
Camshaft position sensor
Crankshaft position sensor shield
Data link connector
Data link connector (dlc)
Diesel
Diesel models
Engine compartment battery
Exc. 4.2l
Exhaust pressure regulator (epr)
Fuel rail cut- off valve
G101 (front of right front fender)
G107 (right side of engine)
G110 (right side of engine)
G199 (right rear of engine compt)
Gasoline models
Intake manifold runner control module
Mass airflow sensor
Ngv timer
Pcm power relay
Powertrain control module (pcm)
S107 (fuel charge harn, near breakout to fuel injector 6)
S140 (eng control harn, near breakout to a/c pressure cutout switch)
S143
S169 (engine control harness, near breakout to pcm)
S189 (eng control harn, near breakout to injection pressure sensor)
Windshield washer pump motor

Ground Distribution Wiring Diagram, without Stripped Chassis (2 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram, without Stripped Chassis (2 of 4) for Ford Econoline E150 2002:

(aero)
(e550) (except e550)
(engine control harn, left rear of engine compt)
(fuel tank sender harn, under left rear of vehicle) s320
(main harness, near breakout to airbag assembly)
(sealed beam)
5.4l ngv
5.4l ngv only
7.3l diesel
All others
Anti-lock brake system control module
Battery junction box
Blower motor relay
C220a
C220c
Clearance lamp relay
Cutaway
Daytime running lights module
Diesel
E550
Engine coolant temperature sender
Except 5.4l ngv
Extended range fuel tank valve 1
Front aft- axle fuel tank valve
Fuel pump
Fuel pump module
Fuel tank sender
G100 (left upper radiator support)
G102 (behind left front headlamp)
G103 (behind right front headlamp)
G202 (behind upper left side of dash)
Gas
In-transit fuel pump module
Injector driver module
Instrument cluster
Left front park/turn lamp
Left headlamp
Left rear lamp assembly
Midship fuel tank valve
Nca
Ngv module
Ngv timer
Powertrain control module
Rear aft- axle fuel tank valve
Right front park/turn lamp
Right headlamp
Right rear lamp assembly
S122
S139 (engine cntrl harn, near breakout to a/c pressure cutout switch)
S163 (dash to headlamp harn, near breakout to left front park/ turn signal lamp)
S205
S268 (main harn, left rear of engine compartment)
S307 (fuel tank harn, near breakout to fuel pump module)
S308 (fuel tank harn, below left center of vehicle)
S317 (fuel tank harn, near breakout to fuel tank sender)
Speed control servo
Stop lamp relay
To g203 (diagram 3 of 4)
Trailer tow battery charge relay
Trailer tow parking lamp relay
Trailer tow reversing lamp relay
Vacuum warning switch
Vehicle speed sensor
Wiper control module

Ground Distribution Wiring Diagram, without Stripped Chassis (3 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram, without Stripped Chassis (3 of 4) for Ford Econoline E150 2002:

(left front door harn, in left front door)
(lower dash harn, near left "b" pillar)
(not used)
(w/o entertain sys) s315 (seat control jumper harn, near breakout to driver's seat motor assembly)
7.3l diesel
Airbag sliding contact
Anti-lock brake system relay
Auxiliary powertrain control connector
Brake shift interlock
C220a
C294b
C294c
C294e
C3077a
C3140a
C508
C629
Center roof marker lamp
Cutaway w/o entertainment system
Data link connector (dlc)
Driver's safety belt retractor pretensioner
Driver's seat adjust switch
E550
Electronic flasher module
Ends in harness
Exterior rear view mirror switch
From s268 (diagram 2 of 4)
Front cigar lighter
Front function selector switch assembly
G203 (behind upper left side of dash)
G204 (left kick panel)
Instrument cluster
Left center roof marker lamp
Left roof marker lamp
Master window door lock/unlock switch
Memory lock module
Panel)
Power point
Power point console 1
Power point console 2
Radio
Rear seat entertainment module
Remote keyless entry module
Right center roof marker lamp
Right power door lock/window switch
Right roof marker lamp
S202 (main harn, near breakout to radio)
S207 (main harn, near breakout to airbag sliding contact)
S223 (lower dash harn, near breakout to brake on/off switch)
S235
S299 (w/ entertain sys) (under driver seat)
S316 (fuel tank harn, near breakout to fuel tank temp sensor)
S500
S600 (right front door harn, in right front door)
Temperature blend door actuator
To s300 (diagram 4 of 4)
Trailer/ camper adapter (class 1)
Trailer/camper adapter (electronic brake)
W/ driver's power seat
W/ manual a/c
W/ rear seat entertainment system
W/ sliding side door
W/o driver's power seat
W/o rear seat entertainment system
Warning buzzer chime module

Ground Distribution Wiring Diagram, without Stripped Chassis (4 of 4) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Ground Distribution Wiring Diagram, without Stripped Chassis (4 of 4) for Ford Econoline E150 2002:

Cargo lamp
Data link connector
From s235 (diagram 3 of 4)
Front interior/ map lamps assembly
G200 (under right side of dash)
G204 (left kick panel)
G400 (left rear corner of vehicle)
High mounted stoplamp
Left rear park/stop/ turn lamp
Left reversing lamp
Left video display
License plate lamp
Near left "b" pillar)
Not used
Overhead console
Radio
Rear a/c blower speed relay 1
Rear a/c blower speed relay 2
Rear interior map lamps assembly
Rear seat entertainment module
Remote keyless entry module
Right reversing lamp
Right video display
S204 (main harn, near breakout to radio)
S260 (lower dash harn, near left "b" pillar)
S297 (lower i/p harn, near left "b" pillar)
S300 (rear harn, near breakout to left safety belt retractor)
S313
S401 (auxiliary blower motor harn, in breakout to auxiliary motor)
S406 (rear harn, near breakout to right reversing lamp)
S913 (interior lamp harn, near breakout to interior switch/lamp)
S915 (rear of roof, near cargo lamp)
S920 (overhead console harness, left side of roof panel)
S930 (overhead console harness, front center of roof)
Video cassette player
W/ full headliner
W/ rear seat entertainment system
W/ rke
W/o full headliner
W/o rear seat entertainment system
Wagons w/ aux a/c
Wagons w/o aux a/c

HEADLIGHTS

Headlight Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Headlight Wiring Diagram for Ford Econoline E150 2002:

(w/drl)
507/13
527/12
Batt
Battery junction box
C202b
C220a
C220b
Central junction box
Daytime runnng lamps (drl) module (mounted to radiator support, under a/c condenser deflector cover)
Dimmer
Flash- to- pass
Fuse 10a
Fuse 15a
Fuse 20a
Fuse 40a
G102 (behind left front headlamp)
G202 (behind upper left side of dash)
G203 (behind upper left side of dash)
Gnd
Head
Hi beam in
Hi beam ind
Hot at all times
Hot in run
Ign
Instrument cluster
Left headlamp
Main light switch
Multi- function switch
Off
P v lo beam
Park
Pass
Right headlamp
S116
S131
S163
S164 (dash to headlamp panel harn, near drl module breakout)
S205
S207
S218
S270 (main harn, near breakout to air bag sliding contact)
S276 (main harn, near breakout to multifunction switch)
S278 (main harn, near breakout to shift lock actuator)

HORN

Horn Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Horn Wiring Diagram for Ford Econoline E150 2002:

(w/ stripped chassis)
15a
Air bag sliding contact
Battery junction box
Battery junction box (left front of engine compt)
C175
C3140a
Cruise control system
Fuse 27
G207 (behind center of dash)
High pitch horn (lower right front of engine compt)
Horn relay
Horn switch
Hot at all times
Low pitch horn (lower right front of engine compt)
Nca
Powertrain control module (left rear of engine compt, near brake master cylinder)
Remote keyless entry module (behind left "b" pillar)
S116
S121 (engine ctrl harn, left rear of engine compt)
S286
Switch ground
W/cruise control
W/o cruise control

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Instrument Cluster Wiring Diagram for Ford Econoline E150 2002:

(conn a)
(conn b)
(conn c)
(engine control harn, left rear of engine compartemnt) s120
(except stripped chassis)
(fuel tank harn, near left front wheel sensor) s310
(left upper radiator support) g100
(main harn, top of steering column) (except diesel or stripped chassis)
(not used)
(stripped chassis)
(stripped chassis) (behind left side of dash) g207
(upper left side of dash) g202
510 ohms
87a
A10
A11
A14
A16
Abs control module (on left front frame rail)
Abs relay (behind center of dash)
Airbag ind
Anti-lock brake ind
Anti-lock brake system
Anti-lock brakes system
B11
B12
Battery junction box
Brake warning ind
C10
C12
C224
C225
C226
Central junction box
Charge ind
Cruise control system
Cutaways, stripped chassis
Diesel
E250
Eng cool temp gauge
Eng oil press gauge
Engine controls system
Engine controls system (diesel)
Engine coolant temperature sender (on lower left front of engine)
Engine coolant temperature sensor (on top front center of engine)
Except 5.4l ngv
Except diesel
Exterior lights system
Fasten safety belt ind
Fuel gauge
Fuel pump module (under vehicle, in fuel tank)
Fuse 10a
Fuse 15a
Fuse 5a
G203 (behind upper left side of dash)
G203 (behind upper left side of dash) (except stripped chassis)
G207 (behind left side of dash) (stripped chassis)
Gas
Ground
Headlights system
Hi beam ind
Hot at all times
Hot in start or run
Illumination
In-transit fuel pump module (under vehicle, on left frame rail)
Instrument cluster
Interior lights system
Left turn ind
Low oil pressure/ high coolant temperature
Low vacuum warning switch (in left front engine compt)
Malfunction ind lamp
Microprocessor
Nca
Ngv module (on left front inner fender panel)
Oil pressure switch (on left front of engine, below a/c compressor)
Parking brake switch (near left kick panel)
Power
Red
Right turn ind
Rly ctrl
S119 (engine control harn, left rear engine compt)
S122
S133 (engine control harn, near breakout to a/c pressure cutout switch)
S135 (engine control harn, near a/c pressure cutout switch)
S146
S175
S207
S207 s284 (stripped chassis)
S213
S220
S267
S268
S308 (fuel tank harn, near transmission)
Seat belt lamp
Speedometer
Vans/wagons
Vehicle speed sensor (on left side of transmission)
Voltmeter
Wait to start ind
Warning systems
Warning systems (stripped chassis)
Water in fuel ind (diesel)

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram, Cutaway Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamps Wiring Diagram, Cutaway Chassis for Ford Econoline E150 2002:

(lower dash harn, near left kick panel)
Central junction box (left side of dash, near kick panel)
Dome
Exterior lights trailer electronic brake control connector
Fuse 15a
Hot at all times
Left front door ajar switch
Main light switch
Nca
Red/ pnk
Right front door ajar switch
S221
Warning systems (warning buzzer module)
Wire ends in harness

Courtesy Lamps Wiring Diagram, Except Cutaway with Entertainment System (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamps Wiring Diagram, Except Cutaway with Entertainment System (1 of 2) for Ford Econoline E150 2002:

(not used)
Base vans/ wagons
Battery
C3140a
C3140b
Central junction box (left side of dash, near kick panel)
Dome
Ends in harness
Front interior/ map lamps switch
Fuse 15a
Fuse 20a
G204 (left kick panel)
G400 (left rear corner of vehicle)
Ground
High mounted stoplamp
Hot at all times
Int lps out
Left
Left front door ajar switch
Left vanity mirror lamp
Main light switch
Mounted stop lamp) s405
Nca
Rear door ajar switch
Red/ pnk
Remote keyless entry module (behind left "b" pillar)
Right
Right front door ajar switch
Right vanity mirror lamp
Rv vans
S221
S231 (lower dash harn, near left kick panel)
S235
S259 (lower dash harn, behind left "b" pillar)
S260
S290
S296
S300
S302 (rear harn, near left "b" pillar)
S314 (interior lamp harn)
S402
S404 (rear harn, near high mounted stop lamp)
Side door ajar switch
Side door ctsy sw
To high mounted stop/ cargo lamp & rear courtesy lamp switch (diagram 2 of 2)
W/full headliner
W/o full headliner
Warning systems (warning buzzer module)

Courtesy Lamps Wiring Diagram, Except Cutaway with Entertainment System (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamps Wiring Diagram, Except Cutaway with Entertainment System (2 of 2) for Ford Econoline E150 2002:

(interior harn, near upper left "b' pillar)
(interior lamp harness) s314
(rear harn, near left "b" pillar)
(rear harn, near left "b" pillar) s301
(rear harn, rear center of roof)
Cargo lamp
From courtesy lights control circuit (diagram 1 of 2)
Front interior/ map lamps assembly
G400 (left rear corner of vehicle)
High mounted stoplamp
Left
Left vanity mirror lamp
Nca
Off
Rear door ajar switch
Rear interior/ map lamps assembly
Right
Right vanity mirror lamp
S300
S302
S402
S404 (rear harn, near rear center of roof)
S405
S911
S913
Wagons w/ aux a/c
Wagons w/o aux a/c

Courtesy Lamps Wiring Diagram, Except Cutaway without Entertainment System (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamps Wiring Diagram, Except Cutaway without Entertainment System (1 of 2) for Ford Econoline E150 2002:

(not used)
Base vans/ wagons
Battery
C3140a
C3140b
Central junction box (left side of dash, near kick panel)
Dome
Ends in harness
Front interior/ map lamps assembly
Fuse 15a
Fuse 20a
G204 (left kick panel)
G400 (left rear corner of vehicle)
Ground
High mounted stoplamp
Hot at all times
Int lps out
Left
Left front door ajar switch
Left vanity mirror lamp
Main light switch
Mounted stop lamp) s405
Nca
Rear door ajar switch
Red/ pnk
Remote keyless entry module (behind left "b" pillar)
Right
Right front door ajar switch
Right vanity mirror lamp
Rv vans
S221
S231 (lower dash harn, near left kick panel)
S235
S259 (lower dash harn, behind left "b" pillar)
S260
S300
S302 (rear harn, near left "b" pillar)
S314 (interior lamp harn)
S402
S404 (rear harn, near high mounted stop lamp)
Side door ajar switch
Side door ctsy sw
To high mounted stop/ cargo lamp & rear courtesy lamp switch (diagram 2 of 2)
W/ remote keyless entry
W/full headliner
W/o full headliner
W/o remote keyless entry
Warning systems (warning buzzer module)

Courtesy Lamps Wiring Diagram, Except Cutaway without Entertainment System (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Courtesy Lamps Wiring Diagram, Except Cutaway without Entertainment System (2 of 2) for Ford Econoline E150 2002:

(interior harn, near upper left "b' pillar)
(interior lamp harness) s314
(rear harn, near left "b" pillar)
(rear harn, near left "b" pillar) s301
(rear harn, rear center of roof)
Cargo lamp
From courtesy lights control circuit (diagram 1 of 2)
Front interior/ map lamps assembly
G400 (left rear corner of vehicle)
High mounted stoplamp
Left
Left vanity mirror lamp
Nca
Off
Rear door ajar switch
Rear interior/ map lamps assembly
Right
Right vanity mirror lamp
S300
S302
S402
S404 (rear harn, near rear center of roof)
S405
S911
S913
Wagons w/ aux a/c
Wagons w/o aux a/c

Instrument Illumination Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Instrument Illumination Wiring Diagram for Ford Econoline E150 2002:

(5) bulbs
(ends in harness)
(not used)
Air bag sliding contact
C2188a
C220a
C294e
C3077a
Central junction box (left side of dash, near kick panel)
Cutaway
Dimmer
Except cutaway
Except stripped chassis
Front function selector switch assembly
Fuse 15a
Fuse 20a
Fuse 5a
G203 (behind upper left side of dash)
G207 (behind left side of dash, near kick panel)
Head
Hot at all times
Hot in accy or run
I/p lamp feed
Ign
Instrument cluster
Main light switch
Nca
Off
Park
Radio
Radio backlight illumination
Rear seat entertainment module
S202
S207
S209
S212 (main harn, near instrument cluster breakout)
S218
S284
Speed control switch assembly
Speed control switch illum
Stripped chassis
W/ rear seat entertainment system

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 5) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (1 of 5) for Ford Econoline E150 2002:

(5.4l ngv only)
(at breakout to glow plug relay) s191
(diesel only)
(e550)
(engine control harn, near battery junction box breakout) s115
(engine control harn, near battery junction box breakout) s116
(engine harn, at breakout to glow plug module) s192
(engine harn, at breakout to glow plug relay) s191
(ex stripped chassis: lower i/p harn, left rear of engine compt) (stripped chassis: main harn, right side of steering column)
(except e550)
(lower i/p harn, near brake switch) s266
(right front of engine compt, near starter motor relay)
(taped in harness)
A/c clutch relay
Abs control module
Auxiliary battery (diesel only)
Battery (taped in harness)
Battery feed (taped in harness)
Battery junction box (left front of engine compt)
Blower motor relay
C135
C152
C153
C155b
C3140b
California
Central junction box (below left side of dash)
Daytime running lamps module (if equipped)
E550
Electronic trailer brakes harness (taped in harness)
Engine compartment battery
Except california
Except stripped chassis
From a fuse 1.15 (diagram 1 of 5)
Fuel pump relay
Fuse
Fuse 10a
Fuse 15a
Fuse 20a
Fuse 30a
Fuse 30a (diesel only)
Fuse 40a
Fuse 50a
Fuse 60a
Generator (gasoline) generator (primary) (diesel)
Generator (secondary: diesel w/ twin generators)
Glow plug control module
Glow plug relay
Horn relay
Idm relay
Main light switch
Manifold intake air heater relay
Modified vehicle power
Nca
Ngv module
Power point (except cutaway)
Power point console 1 (w/ rear seat entertainment system)
Power point console 2 (w/ rear seat entertainment system)
Rear a/c blower speed relay 1
Red
Remote keyless entry module
S1008
S101 (engine control harn, near battery junction box breakout)
S1010 (right front of engine compt, near battery junction box)
S1011 (right front of engine compt, near battery junction box)
S1012 (right front of engine compt, near starter motor relay)
S178 (right front of engine compt, near battery junction box)
S183 (5.4l ngv only) (engine control harn, left rear of engine compt)
S187 (engine harn, top right side of engine)
S225 (except stripped chassis)
S254 (lower i/p harn, near left kick panel)
S257 (lower i/p harn, behind left 'b' pillar, near floor)
S280 (stripped chassis)
Starter motor
Starter motor relay
Stripped chassis
To fuse 1.17 (diagram 1 of 5)
To fuse 1.9 (diagram 2 of 5)
To ignition switch (diagram 3 of 5)
W/ remote keyless entry
Wire ends in harness in cutaways

Power Distribution Wiring Diagram (2 of 5) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (2 of 5) for Ford Econoline E150 2002:

(door harn, inside left front door) (w/ rke only) s506
(engine ctrl harn, near battery junction box breakout)
(lower i/p harn, behind left side of dash)
(lower i/p harn, below left side of dash) s230
(lower i/p harn, left rear of engine compt) s227
(main harn, left side of dash)
(main wiring harn, base of steering column) s218
(stripped (except stripped chassis) (engine compt harn, left rear of engine compt) s129
Auxiliary battery
Auxiliary battery relay
Battery junction box (left front of engine compt)
Brake pedal position (bpp) switch
C1025
C175
C202a
C202b
C2031
C205
C2188a
C2209
C220a
C251
C278
C3131
C3140a
C360
C4121
C508
C629
Central junction box (below left side of dash)
Chassis) (main wiring harn, behind left side of dash) s2020
Cigar lighter
Cutaway
Data link connector (dlc)
Deactivator switch
Driver seat regulator control switch
Electronic crash sensor module
Except cutaway
Except stripped chassis
Exterior rear view mirror switch
Floor console
From b fuse 1.12 (diagram 1 of 5)
From s221 (diagram 5 of 5)
Fuse 10a
Fuse 15a
Fuse 20a
Fuse 25a
Fuse 30a
Fuse 40a 60a
Fuse 5a
Fuse 60a
G203 (behind upper left side of dash)
Instrument cluster
Main light switch
Master window/ door lock control switch
Memory lock module (sliding side door)
Multi- function switch
Nca
Pcm power relay
Power point
Power- train control module
Radio
Rear power door lock switch
Red
Remote keyless entry nodule
Right power door lock/ window switch
S108
S109 (engine control harn, near battery junction box breakout)
S110 (engine control harn, near battery junction box breakout)
S148
S175 (engine control harn, left rear of engine compt)
S207
S237
S276
Stop lamp relay
Stripped chassis
To fuse 2.4 (diagram 5 of 5)
Trailer battery charge relay
Trailer parking lamp relay
Trailer reversing lamp relay
W/ aux battery
W/ power seats
W/ remote keyless
W/ rke only
W/o aux battery
W/o remote keyless

Power Distribution Wiring Diagram (3 of 5) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (3 of 5) for Ford Econoline E150 2002:

(engine control harn, left rear of engine compt) (except stripped chassis) s131
(engine control harn, near battery junction box breakout) s113
(interior lamp harn) s314
(main wiring harn, center of dash) s203
(main wiring harn, left side of dash) (stripped chassis) s282
(stripped chassis) (except stripped chassis)
A/c demand signal (taped in harness)
Abs control module
Acc
Auxiliary battery relay
Auxiliary powertrain control module connector (diesel)
Batt
Blend door actuator
Brake shift interlock
C1030
C122
C155a
C167
C2008
C202a
C2176
C2209
C289
C294a
Cargo lamp
Central junction box (below left side of dash)
Daytime running lamps (drl) module
Digital transmission range (dtr) sensor
Electronic crash sensor (ecs) module
Except stripped chassis
From fuse 1.23 c (diagram 1 of 5)
From fuse 1.23 d (diagram 1 of 5)
From fuse 2.4 j (diagram 5 of 5)
Front interior/ map lamp assembly (wagon)
Function selector switch
Fuse 10a
Fuse 15a
Fuse 20a
High mounted stoplamp
Ign
Ignition switch
Left vanity mirror lamp
Lock
Multi- function switch
Nca
Not used
Off
R/v
Rear door ajar switch
Rear interior/ map lamps assembly
Right vanity mirror lamp
Run
S281 s229 (lower i/p harn, below left side of dash)
S302 (interior lamp harn, top of "b" pillar)
S405 (interior lamp harn, rear top center of vehicle)
S912 (interior harn, left "b" pillar)
Speed control servo (except stripped chassis)
Start
Stripped chassis
To fuse 2.2 (diagram 4 of 5)
To fuse 2.34 (diagram 4 of 5)
To fuse 2.9 (diagram 5 of 5)
W/ auxiliary battery
W/ full headliner
W/o full headliner
Wagons w/ auxiliary a/c
Wagons w/o auxiliary a/c

Power Distribution Wiring Diagram (4 of 5) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (4 of 5) for Ford Econoline E150 2002:

(engine control harn, left rear of engine compt) s127
(lower i/p harness, behind left side of dash) (except stripped chassis)
(main wiring harn, under right side of dash) s267
(other)
(stripped)
4.2l v6
4.6l/5.4l v8
5.4l ngv
6.8l v10
Abs relay
Battery junction box (left front of engine compt)
C1065
C1076
C1252
C1254
C167
C174
C2135
C2156
C2172
C2188a
C2206
C220a
C220c
Central junction box (below left side of dash)
Coil on plug 1
Coil on plug 10
Coil on plug 2
Coil on plug 3
Coil on plug 4
Coil on plug 5
Coil on plug 6
Coil on plug 7
Coil on plug 8
Coil on plug 9
Diesel
Digital transmission range sensor
From fuse 2.8 (diagram 4 of 5) (4.2l v6)
From fuse 2.8 (diagram 4 of 5) (4.6l/5.4l)
From fuse 2.8 (diagram 4 of 5) (6.8l v10)
From ignition switch f (diagram 3 of 5)
From ignition switch g (diagram 3 of 5)
Fuel line heater (diesel)
Fuel pump relay
Fuse 10a
Fuse 15a
Fuse 30a
Fuse 5a
Idle validation switch (diesel)
Idm relay
Ignition coil
Ignition transformer capacitor 1
Ignition transformer capacitor 2
Instrument cluster
Low vacuum warning switch (diesel)
Nca
Ngv timer
Overdrive cancel switch
Pcm diode
Pcm power relay
Radio (except stripped chassis)
S146 (engine control harn, left rear of engine compt)
S156 (5.4l) s193 (4.6l) (engine control harn, above left cylinder bank)
S161 (5.4l) s150 (4.6l) (engine control harn, above right cylinder bank)
S161 (engine control harn, above right cylinder bank)
S162 (engine control harn, above left cylinder bank)
S213 (main wiring harn, left side of dash)
S265 (lower i/p harn, under right side of dash)
S269
Tan/red
To ignition coils (gasoline engines) or glow plug relay (diesel engine) (diagram 4 of 5)
Warning buzzer module (except stripped chassis)

Power Distribution Wiring Diagram (5 of 5) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Distribution Wiring Diagram (5 of 5) for Ford Econoline E150 2002:

(engine harn, left rear of engine compt) s128
(left front door harn, inside left front door) s501
(lower i/p harn, left side of dash) s221
(lower i/p harn, left side of dash) s294
(lower i/p harn, right side of dash) s221
(main wiring harn, left side of dash) s219
(main wiring harn, top of steering column) s208
A sliding side door
B hinged side doors
Battery junction box
C125
C205
C2157
C2188a
C3076
C3129
C3140a
C3141
C4121
C508
C629
Central junction box (below left side of dash)
Circuit breaker 20a
Courtesy switch feed (taped in harness)
Ends in harness (cutaway)
Except cutaway
Except stripped chassis
From e fuse 2.28 (diagram 2 of 5)
From ignition switch (diagram 3 of 5)
Fuse 15a
Fuse 30a
Fuse 4 15a (except stripped chasis w/o entertainment)
Fuse 4 15a (except stripped chassis w/ entertainment)
Fuse 4 15a (stripped chassis)
Fuse 5a
Ign
Ignition switch feed (taped in harness)
Left front door ajar switch
Left video display
Main light switch
Master window/ door lock control switch
Nca
Overhead console
Radio
Rear power door lock switch
Remote keyless entry module
Right door ajar switch
Right front door ajar switch
Right power door lock/ window switch
Right power door lock/window switch
Right side door ajar switch
Right video display
S236 (lower i/p harn, above accelerator pedal)
S271 (lower i/p harn, behind left side of dash)
S296 (lower i/p harn, left side of dash)
Stripped chassis
To exterior rear view mirror switch (diagram 2 of 5)
To high mounted stoplamp (diagram 3 of 5)
Trailer battery charge relay
Video cassette player
W/ remote keyless entry
Windshield wiper motor
Wiper control module

POWER DOOR LOCKS

Door Lock Wiring Diagram, Cutaway Chassis for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Door Lock Wiring Diagram, Cutaway Chassis for Ford Econoline E150 2002:

(in center of driver door) s502
(in center of driver door) s503
Central junction box (left side of dash, near kick panel)
Front passenger window/ door lock/ switch
Fuse 20a
G204 (left kick panel)
Hot at all times
Left front door lock actuator
Lock
Master window/ door lock/ unlock switch
Red
Right front door lock actuator
S237
S600
Unlk

Door Lock Wiring Diagram, with Hinged Side Door for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Door Lock Wiring Diagram, with Hinged Side Door for Ford Econoline E150 2002:

(bottom
(in center of driver door) s503
(left
Central junction box (left side of dash, near kick panel)
Dash panel
Front passenger window/ door lock/ switch
Fuse 20a
G204 (left kick panel)
Hot at all times
Left front door lock actuator
Lock
Master window/ door lock/ unlock switch
Not used
Of "b" pillar) s239
Rear door lock actuator
Rear doors door lock switch
Red
Right front door lock actuator
S237
S238
S502 (in center of driver door)
S600
Side door lock actuator
Unlk

Door Lock Wiring Diagram, with Sliding Side Door for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Door Lock Wiring Diagram, with Sliding Side Door for Ford Econoline E150 2002:

(behind left "b" pillar) memory lock module
(bottom of "b" pillar)
(in center of driver door) s502
(left kick panel) g204
Battery
C384
C806
Central junction box (left side of dash, near kick panel)
Front passenger window/ door lock/ switch
Fuse 20a
G204 (left kick panel)
Ground
Hot at all times
Left front door lock actuator
Lock
Lock in
Lock out
Master window/ door lock/ unlock switch
Rear doors door lock switch
Rear doors lock actuator
Red
Right front door lock actuator
Right sliding door contact switch
S235
S237
S238 (left side of dash)
S239
S503
S600
Side door lock actuator
Unlk
Unlock in

Keyless Entry Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Keyless Entry Wiring Diagram for Ford Econoline E150 2002:

(bottom of "b" pillar)
(left kick panel) g204
(left side of dash)
(left side, bottom of "b" pillar)
Battery
C3140a
C3140b
C384
C806
Central junction box (left side of dash, near kick panel)
Door lock
Exterior lights system
Fuse 15a
Fuse 20a
Fuse 30a
Fuse 5a
Ground
Horn relay ctrl
Horns system
Hot at all times
Hot in acc or run
Ignition
Int lamps out
Interior lights system
Left front door lock actuator
Lf door lock
Light switch in
Lock
Lock in
Master window/ door lock/ unlock switch
Pass- enger window/ door lock switch
Rear door lock actuator
Rear doors door lock switch
Remote keyless entry module (behind left "b" pillar)
Rf door lock
Right front door lock actuator
Right side door lock actuator
Right sliding door contact switch
S221
S235
S238
S239
S245
S251
S252
S255
S257
S258 (left side, bottom of "b" pillar)
S260
S506
Side door lock
Side door sw in
Side/rear lock
Unlock
Unlock in
W/ hinged door
W/ sliding door

POWER MIRRORS

Power Mirror Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Mirror Wiring Diagram for Ford Econoline E150 2002:

Central junction box (cjb) (under left side of dash)
Down
Driver side exterior rear view mirror
Exterior rear view mirror switch
Fuse 5a
G204 (behind left kick panel)
Hot at all times
Left
Left mirror select
Left/ right
Nca
Passenger side exterior rear view mirror
Red
Right
Right mirror select
S500
S504 (in driver door)
S506
Up/ down m

POWER SEATS

Power Seat Wiring Diagrams for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Seat Wiring Diagrams for Ford Econoline E150 2002:

(entertain sys)
(exc entertain sys)
Central junction box (left side of dash, near kick panel)
Entire seat
Front driver side seat adjust switch
Front of seat
Fuse 16 30a
Fwd
G204 (left kick panel)
Hot at all times
Left power seat motor assembly
Nca
Rear of seat
Rwd
S299
S315

POWER WINDOWS

Power Window Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Power Window Wiring Diagram for Ford Econoline E150 2002:

Central junction box
Circuit breaker 43 20a
Down
G204 (left kick panel)
Hot in acc or run
Left power window motor
Master window/ door lock control switch
Right power door lock/ window switch
Right power window motor
S236
S500
S501

RADIO

Radio Wiring Diagrams, with Rear Entertainment (1 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Radio Wiring Diagrams, with Rear Entertainment (1 of 2) for Ford Econoline E150 2002:

(behind upper left side of dash) g202
(center dash panel) s209
(center vehicle floor) g301
Antenna
Bare
C212
C213
Central junction box (left side of dash, near kick panel)
Fuse 15a
Fuse 20a
Fuse 5a
G203 (upper left side of dash)
G204 (left kick panel)
Ground
Hot at all times
Hot in park or head
Hot in run or acc
Hot in start
Illumination
L front speaker
L rear speaker
Left front door speaker
Memory power
Nca
Noise reduction
Power
Power point console
R front speaker
R rear speaker
Radio
Red
Right front speaker
S202
S204
S212
S233 (left rocker panel)
S245
S291
Shield
Signal
Tan

Radio Wiring Diagrams, with Rear Entertainment (2 of 2) for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Radio Wiring Diagrams, with Rear Entertainment (2 of 2) for Ford Econoline E150 2002:

(bottom left of "b" pillar) s298
(bottom left side of "b" pillar)
(bottom of left side "b" pillar) s292
(center vehicle floor) g300
(in right side roof panel) s914
(left rear corner of vehicle) g400
(left side roof panel) s916
(under right side of dash) g200
1.2 mh
Bare
Button contact
C3076
C3077a
C3077b
Ground
Interior lights system
Left mid speaker
Left rear speaker
Left video display
Power
Power choke 1
Rear seat entertainment module
Red
Right rear speaker
Right side door speaker
Right video display
S235
S240 (right side dash panel)
S243
S288 (bottom left side of "b" pillar)
S297
S313
S915
S920 (left side roof panel)
S921 (left side roof panel)
Shield
Signal
Tan
Video cassette player

Radio Wiring Diagrams, without Rear Entertainment for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Radio Wiring Diagrams, without Rear Entertainment for Ford Econoline E150 2002:

(behind upper left side of dash) g203
(bottom left side of "b" pillar) s244
(right side dash panel)
Antenna
C213
C384
C806
Central junction box (cjb) (left side of dash, near kick panel)
Cutaways
Fuse 15a
Fuse 5a
G203 (under right side if dash)
Ground
Hinged side door
Hot at all times
Hot in park or head
Hot in run or acc
Hot in start
Illumination
L front speaker
L rear speaker
Left front door speaker
Left mid speaker (w/ 6 speakers)
Left rear speaker
Memory power
Nca
Noise reduction
Not used
Power
R front speaker
R rear speaker
Radio
Right front speaker
Right mid speaker (w/ 6 speakers)
Right rear speaker
Right sliding door contact switch
S202
S204
S209
S212
S240
S241
S243
Sliding side door
Vans/ wagons

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Shift Interlock Wiring Diagram for Ford Econoline E150 2002:

(except stripped chassis)
(stripped chassis)
(under left side of dash)
Brake pedal position (bpp) switch (on bracket, above brake pedal)
Central junction box (left side of dash)
Fuse 2.11 15a
Fuse 2.6 10a
G203 (behind upper left side of dash)
G207 (behind left side of dash, near kick panel)
Hot at all times
Hot in run
S131 (except stripped chassis) (left rear engine compt)
S207 (except stripped chassis) (center of dash)
S282 (stripped chassis) (on steering column)
S283 (stripped chassis)
S286 (stripped chassis)
Shift lock actuator (below right side steering column)
Solid state

STARTING/CHARGING

Charging Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Charging Wiring Diagram for Ford Econoline E150 2002:

(ex stripped chassis) (stripped chassis)
(right front corner of engine compt) starter relay
0hms
Accy
Auxiliary power- train control module connector (diesel) (behind left side of dash)
Battery junction box (left front of engine compt)
C1021a
C102b
C220c
C22oc
Central junction box (below left side of dash)
Charge ind
Engine compartment battery
Fuse 5a
Fuse 60a
G107 (right side of engine)
Generator
Ground distribution system
Ignition switch
Instrument cluster
Lock
Off
Red
Run
S1008
S1010
S1011
S225 s280
S229 s281
S265
S267
Start
Starting circuit

Starting Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Starting Wiring Diagram for Ford Econoline E150 2002:

(except stripped chassis)
(stripped chassis) (ex. stripped chassis)
5.4l cng
Acc
Battery junction box (left front of engine compt)
Central junction box (left side of dash, near kick panel)
Digital transmission range (dtr)
Engine compartment battery
Fuse 10a
Fuse 60a
G107 (right side of engine)
Ground distribution system
Ignition b+
Lock
Natural gas vehicle timer (left rear of engine compt, near pcm)
Off
Power distribution system
Red
Run
S1008
S269
Sensor (left side of transmission)
Start
Starter motor (lower right side of engine)
Starter relay (right front corner of engine compt, near battery)
Switch
Tan/ red

SUPPLEMENTAL RESTRAINTS

Supplemental Restraint Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Supplemental Restraint Wiring Diagram for Ford Econoline E150 2002:

(bottom left side "b" pillar)
(right side, dash panel) s265
(right side, dash panel) s267
(under left side dash panel) s221
(under left side, dash panel) s228
Abs control module (at left side of engine compartment)
Air bag bracket
Air bag bracket (right side dash panel)
Air bag ind
Air bag indicator
Air bag sliding contact
Battery
C155a
C220c
C303
C323
Central junction box (cjb) (left side of dash, near kick panel)
Crash sensor
Data link connector (dlc) (partial) (below left side of dash)
Door open input
Driver air bag
Driver air bag unit
Driver door open input
Driver safety belt retractor pretensioner (under driver seat)
Electronic crash sensor (ecs) module (behind right side of dash)
Feed
Forward crash sensor (in front center of engine compartment, behind grille)
Fuse 2.14 5a
Fuse 2.19 10a
Fuse 2.38 10a
Fuse 2.4 15a
G204 (left rocker panel)
G206 (right side dash panel)
Ground
Hot at all times
Hot in run
Hot in run or start
Ignition
Instrument cluster
Iso bus
Left front door ajar switch (left rocker panel)
Nca
Pass air bag
Passenger air bag module
Passenger safety belt retractor pretensioner (under passenger seat)
Pnk
Preten feed
Preten return
Pretensioner feed
Pretensioner nca
Pretensioner return
Red/ pnk (right side dash panel) s201
Red/pnk
S235
S275 (left side dash panel)
Safety belt buckle sw input
Safety belt buckle switch input
Shorting bar
Shorting bar engaged when module connector is disconnected from harness (shorting bars are connected between following pins: 1-15, 7-21 & 14-28)
Warning buzzer/ chime module (behind center of dash)

TRANSMISSION

4.2L

4.2L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.2L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002:

(behind center of dash) (w/ stripped chassis) g207
(eng control harn, near breakout to a/c pressure cutout switch)
(engine ctrl harn)
(fuel charge harn, near tp sensor)
(in battery junction box)
(left rear of engine compt)
(top front center of eng) instrumentation engine coolant temperature sensor
(trans ctrl harn, near breakout to dtr sensor)
(trans ctrl harn, near trans)
4r70w transmission
Abs system, warning buzzer module
Battery junction box
Battery junction box (left front of engine compt)
Bpp
Brake pedal position switch (on bracket, above brake pedal)
C220a
C220b
C220c
C224
C225
C226
Central junction box (behind left side of dash)
Cht
Cruise control system
Cylinder head temperature sensor
Data (+)
Data (-)
Data link connector (below left side of dash)
Digital transmission range sensor
Ect
Electronic pressure control solenoid
Eng compt)
Engine controls
Epc
Exterior lights
Fuse 10a
Fuse 15a
Fuse 30a
Fuse 5a
G101 (front of right front fender)
G203 (w/o stripped chasis) (behind upper left side of dash)
Gen data
Gnd
Hot at all times
Hot in run or start
Ignition coil, radio noise capacitor
Instrument cluster
Instrument cluster system
Kapwr
Maf
Malfunction indicator lamp
Mass airflow (maf) sensor (top center of engine compt)
Mil
Multifunction switch, deavtiator switch
Nca
Od off
Oss
Output shaft speed sensor (left side of transmission)
Overdrive cancel switch
Pcm diode
Pcm power relay
Powertrain control module (pcm) (left rear of engine compartment, near brake master cylinder)
Pwr in
Red
S100
S102
S103
S110
S127
S133 (eng ctrl harn near a/c press cutout switch)
S134 (eng ctrl harn, near a/c pressure cutout switch)
S135 (eng ctrl harn, near a/c press switch)
S137 (eng ctrl harn, near breakout to pcm)
S138
S140
S142
S169
S175
S213
S268
Shift solenoids
Sig rtn
Speedometer
Ssa
Ssb
Tcc
Tcil
Tcs
Tft
Throttle position sensor (tps) (on top of engine, near air intake)
Torque converter clutch solenoid
Tps
Tr1
Tr2
Tr3
Tr4
Transmission fluid temperature sensor
Vref
Vss

4.6L

4.6L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 4.6L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002:

(4.6l) (5.4l)
(behind center of dash) (w/ stripped chassis) g207
(eng control harn, near breakout to a/c pressure cutout switch)
(engine ctrl harn)
(front of right front fender)
(fuel charge harn, near tp sensor)
(in battery junction box)
(left rear of engine compt)
(top front center of eng) instrumentation engine coolant temperature sensor
(trans ctrl harn, near trans)
4r70w transmission
Abs system, warning buzzer module
Battery junction box
Battery junction box (left front of engine compt)
Bpp
Brake pedal position switch (on bracket, above brake pedal)
C220a
C220b
C220c
C224
C225
C226
Central junction box (behind left side of dash)
Cht
Cruise control system
Cylinder head temperature sensor
Data (+)
Data (-)
Data link connector (below left side of dash)
Digital transmission range sensor
Ect
Electronic pressure control solenoid
Eng compt)
Engine controls
Epc
Exterior lights
Fuse 10a
Fuse 15a
Fuse 30a
Fuse 5a
G101
G101 (front of right front fender)
G203 (w/o stripped chasis) (behind upper left side of dash)
Gen data
Gnd
Hot at all times
Hot in run or start
Ignition coil, radio noise capacitor
Instrument cluster
Instrument cluster system
Kapwr
Maf
Malfunction indicator lamp
Mass airflow (maf) sensor (top center of engine compt)
Mil
Multifunction switch, deavtiator switch
Nca
Od off
Oss
Output shaft speed sensor (left side of transmission)
Overdrive cancel switch
Pcm diode
Pcm power relay
Powertrain control module (pcm) (left rear of engine compt, near brake master cylinder)
Pwr in
Red
S102
S110
S127
S133 (eng ctrl harn near a/c press cutout switch)
S134 (eng ctrl harn, near a/c pressure cutout switch)
S135 (eng ctrl harn, near a/c press cutout switch)
S137 (eng ctrl harn, near breakout to pcm)
S138
S140
S142
S154 s157
S169
S175
S213
S268
Shift solenoids
Sig rtn
Speedometer
Ssa
Ssb
Tcc
Tcil
Tcs
Tft
Throttle position sensor (tps) (on top of engine, near air intake)
Torque converter clutch solenoid
Tps
Tr1
Tr2
Tr3
Tr4
Transmission fluid temperature sensor
Vref
Vss

5.4L

5.4L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for 5.4L, A/T Wiring Diagram, 4R70W for Ford Econoline E150 2002:

(4.6l) (5.4l)
(behind center of dash) (w/ stripped chassis) g207
(eng control harn, near breakout to a/c pressure cutout switch)
(engine ctrl harn)
(front of right front fender)
(fuel charge harn, near tp sensor)
(in battery junction box)
(left rear of engine compt)
(top front center of eng) instrumentation engine coolant temperature sensor
(trans ctrl harn, near trans)
4r70w transmission
Abs system, warning buzzer module
Battery junction box
Battery junction box (left front of engine compt)
Bpp
Brake pedal position switch (on bracket, above brake pedal)
C220a
C220b
C220c
C224
C225
C226
Central junction box (behind left side of dash)
Cht
Cruise control system
Cylinder head temperature sensor
Data (+)
Data (-)
Data link connector (below left side of dash)
Digital transmission range sensor
Ect
Electronic pressure control solenoid
Eng compt)
Engine controls
Epc
Exterior lights
Fuse 10a
Fuse 15a
Fuse 30a
Fuse 5a
G101
G101 (front of right front fender)
G203 (w/o stripped chasis) (behind upper left side of dash)
Gen data
Gnd
Hot at all times
Hot in run or start
Ignition coil, radio noise capacitor
Instrument cluster
Instrument cluster system
Kapwr
Maf
Malfunction indicator lamp
Mass airflow (maf) sensor (top center of engine compt)
Mil
Multifunction switch, deavtiator switch
Nca
Od off
Oss
Output shaft speed sensor (left side of transmission)
Overdrive cancel switch
Pcm diode
Pcm power relay
Powertrain control module (pcm) (left rear of engine compt, near brake master cylinder)
Pwr in
Red
S102
S110
S127
S133 (eng ctrl harn near a/c press cutout switch)
S134 (eng ctrl harn, near a/c pressure cutout switch)
S135 (eng ctrl harn, near a/c press cutout switch)
S137 (eng ctrl harn, near breakout to pcm)
S138
S140
S142
S154 s157
S169
S175
S213
S268
Shift solenoids
Sig rtn
Speedometer
Ssa
Ssb
Tcc
Tcil
Tcs
Tft
Throttle position sensor (tps) (on top of engine, near air intake)
Torque converter clutch solenoid
Tps
Tr1
Tr2
Tr3
Tr4
Transmission fluid temperature sensor
Vref
Vss

WARNING SYSTEMS

Warning System Wiring Diagrams for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Warning System Wiring Diagrams for Ford Econoline E150 2002:

(behind upper left side of dash) g203
(left kick panel) g204
Buckle switch
C220a
C220b
C220c
Central junction box (left side of dash, near kick panel)
Door open
Driver safety belt retractor pretensioner
Fasten belts
Fasten safety belt ind
Fuse 15a
Fuse 20a
Gnd
Ground
Head
Headlamps on
Hot at all times
Hot in run or start
Ignition key switch
Instrument cluster
Interior lights system
Key in ignition
Left front door ajar switch
Main light switch
Micro- processor & safety belt minder speaker
Nca
Of dash) s206
Off
Park
Power
Preten- sioner
Red/ pnk
Red/pnk
S201 (right side of dash)
S207
S213
S218
S221
S235
S275 (left side of dash)
Seat belt
Warning buzzer/ chime module (behind center of dash)

WIPER/WASHER

Wiper/Washer Wiring Diagram for Ford Econoline E150 2002

Get access to all wiring diagrams of the car

List of elements for Wiper/Washer Wiring Diagram for Ford Econoline E150 2002:

1.1k ohms
100k ohms
4.08k
7.25k
Central junction box (left side of dash, near kick panel)
Common
Fuse 30a
G101 (front of right front fender)
G202 (behind upper left side of dash)
Ground
Hot in acc or run
Int max
Int min
Intrvl ctl
Multi- function switch
Off
Off 36.27k ohms
Ohms
Park
Park sw
Power
Run
S143
S205
S208
Wash
Washer pump (on right fender apron)
Windshield wiper motor (left rear of engine compt)
Wiper control module (behind center of dash)
Wiper high
Wiper low
Wiper mode
Wshr pump