All Wiring Diagrams for Ford F-Super Duty 1997 model

AIR CONDITIONING

5.8L

5.8L, A/C Wiring Diagram for Ford F-Super Duty 1997

List of elements for 5.8L, A/C Wiring Diagram for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (heater switch to blower motor harn, near blower motor breakout)
• (left front of engine compartment)
• 15a
• 49 states or super duty only
• A/c clutch cycling pressure switch (right rear of engine compartment on accumulator)
• A/c clutch diode
• A/c clutch field coil
• A/c high pressure cut out switch (right side engine compartment)
• A/c-heater control assembly
• Blower motor
• Blower motor resistor (near blower motor)
• Blower motor switch
• Calif except super duty only
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G108
• G200
• Hot in accy or run
• Hot in run
• Max
• Mix
• Norm
• Off
• Power- train control module (pcm) (on right side of engine compartment)
• S102 (eng cntrl sens harn, near brake warning resistor/ diode assembly breakout)
• S152 (heater sw to blower mtr harn, near blower mtr breakout)
• S153
• S205 (main harn, near radio breakout)
• S229 (main harness, near blower motor switch breakout)
• Vent

Heater Wiring Diagram for Ford F-Super Duty 1997

List of elements for Heater Wiring Diagram for Ford F-Super Duty 1997:

• (heater switch to blower motor harn, near blower motor breakout)
• (not used)
• 15a
• Blower motor
• Blower motor resistor (near blower motor)
• Blower motor switch
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G203 (behind bottom of right kick panel)
• Heater control assembly
• Hot in accy or run
• Hot in run
• Mix
• Off
• S152
• S205 (main harness, near radio breakout)
• S229 (main harn, near blower motor switch breakout)
• Vent

7.3L

7.3L DI Turbo Diesel, A/C Wiring Diagram for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, A/C Wiring Diagram for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (not used)
• (right front fender apron)
• 15a
• A/c clutch cycling pressure switch (right rear of engine compartment on accumulator)
• A/c clutch diode
• A/c compressor clutch
• A/c high pressure cut out switch (left side engine compartment)
• A/c-heater control assembly
• Blower motor
• Blower motor resistor (right side of safety wall, on plenum)
• Blower motor switch
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G101
• G200
• Hot in accy or run
• Hot in run
• Max
• Mix
• Nca
• Norm
• Off
• Powertrain control module (pcm) (left side of fire- wall)
• S100 (eng cntrl sens harn, near right front park/ turn lamp breakout)
• S152 (heater sw to blower mtr harn, near blower mtr breakout)
• S153 (heater switch to blower motor harn, near blower motor breakout)
• S205 (main harn, near radio breakout)
• S229 (main harness, near blower motor switch breakout)
• Vent

Heater Wiring Diagram for Ford F-Super Duty 1997

List of elements for Heater Wiring Diagram for Ford F-Super Duty 1997:

• (heater switch to blower motor harn, near blower motor breakout)
• (not used)
• 15a
• Blower motor
• Blower motor resistor (near blower motor)
• Blower motor switch
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G203 (behind bottom of right kick panel)
• Heater control assembly
• Hot in accy or run
• Hot in run
• Mix
• Off
• S152
• S205 (main harness, near radio breakout)
• S229 (main harn, near blower motor switch breakout)
• Vent

7.5L

7.5L, A/C Wiring Diagram for Ford F-Super Duty 1997

List of elements for 7.5L, A/C Wiring Diagram for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (heater switch to blower motor harn, near blower motor breakout)
• (left front of engine compartment)
• 15a
• 49 states or super duty only
• A/c clutch cycling pressure switch (right rear of engine compartment on accumulator)
• A/c clutch diode
• A/c clutch field coil
• A/c high pressure cut out switch (right side engine compartment)
• A/c-heater control assembly
• Blower motor
• Blower motor resistor (near blower motor)
• Blower motor switch
• Calif except super duty only
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G108
• G200
• Hot in accy or run
• Hot in run
• Max
• Mix
• Norm
• Off
• Power- train control module (pcm) (on right side of engine compartment)
• S102 (eng cntrl sens harn, near brake warning resistor/ diode assembly breakout)
• S152 (heater sw to blower mtr harn, near blower mtr breakout)
• S153
• S205 (main harn, near radio breakout)
• S229 (main harness, near blower motor switch breakout)
• Vent

Heater Wiring Diagram for Ford F-Super Duty 1997

List of elements for Heater Wiring Diagram for Ford F-Super Duty 1997:

• (heater switch to blower motor harn, near blower motor breakout)
• (not used)
• 15a
• Blower motor
• Blower motor resistor (near blower motor)
• Blower motor switch
• Def
• Floor
• Fuse 1 30a
• Fuse 6
• Fuse panel
• G203 (behind bottom of right kick panel)
• Heater control assembly
• Hot in accy or run
• Hot in run
• Mix
• Off
• S152
• S205 (main harness, near radio breakout)
• S229 (main harn, near blower motor switch breakout)
• Vent

ANTI-LOCK BRAKES

Anti-lock Brake Wiring Diagrams for Ford F-Super Duty 1997

List of elements for Anti-lock Brake Wiring Diagrams for Ford F-Super Duty 1997:

• (main harn, left rear of engine compt)
• (rear lamp harn, near breakout to output shaft speed sensor) s429
• (w/o airbag) (w/ airbag)
• 4x4 input sig
• Acc
• Anti-lock brake ind
• Boo sw input
• Brake fluid level switch (on brake fluid reservoir)
• Brake fluid lvl sens (lo)
• Brake on/off (boo) switch (on bracket above brake pedal)
• Diag test/keep alive input
• Diff spd sens (hi)
• Diff spd sens (lo)
• Dump sol output
• Dump solenoid
• Fuse 13 15a
• Fuse 15 20a
• Fuse 17 10a
• Fuse panel
• G101 (right front of engine compartment, front of fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G200 (behind bottom of left kick panel)
• G203 (behind bottom of right kick panel)
• Ground
• Hot at all times
• Hot in run
• Hot in start or run
• Ignition switch
• Instrument cluster
• Instrument cluster system
• Iso sol output
• Isolation solenoid
• Lock
• Nca
• Off
• Power input
• Programmable speedometer/ odometer module
• Rabs data link connector (all gasoline: left rear of engine compartment) (7.3l diesel: behind lower center of dash)
• Rabs valve assembly (on frame rail, near front of transmission)
• Rear anti-lock brake (rabs) module (behind glove box)
• Rear axle sensor
• Red/pnk
• Run
• S102
• S202
• S215
• S216 s258
• S220
• S228 (main harn, in breakout to rabs module)
• S236
• S240
• S247 (main harn, left rear of engine compt)
• S248
• S428 (rear lamp harn, near breakout to output shaft speed sensor)
• Start
• Transmissions system
• Valve reset switch
• Vlv reset input
• Warn lp output

COMPUTER DATA LINES

5.8L

5.8L, Computer Data Lines, 49 States Or Super Duty for Ford F-Super Duty 1997

List of elements for 5.8L, Computer Data Lines, 49 States Or Super Duty for Ford F-Super Duty 1997:

• (engine sensor harn, near break- out to brake warn- ing resistor/ diode assenbly) s137
• (in left rear of engine compt, on bracket) vip data link connector (dlc)
• C198
• C199
• Data (+)
• Data (-)
• Dlc
• Egr valve position (evp) sensor (5.8l: on top right front of engine) (7.5l: on right side of engine compt)
• Engine coolant temperature (ect) sensor (5.8l: on t'stat housing) (7.5l: near left side of distributor)
• Fuel pump enable
• Fuel pump relay (on engine compt fuse box)
• Intake air temperature (iat) sensor (5.8l: near intake manifold runner 6) (7.5l: behind distributor)
• Manifold absolute pressure (map) sensor (on right side of firewall)
• Nca
• Powertrain control module (pcm) (on left side of firewall, left of main harness connectors)
• S251 (fuel charge harn, near breakout to fuel injector 3)
• Signal return
• Throttle position (tp) sensor (on throttle body)
• Transmission range (tr) sensor (on left side of trans)

5.8L, Computer Data Lines, California Except Super Duty for Ford F-Super Duty 1997

List of elements for 5.8L, Computer Data Lines, California Except Super Duty for Ford F-Super Duty 1997:

• (behind lower right side of dash, below glove compartment) data link connector (dlc)
• Cigar lighter
• Data link (+)
• Data link (-)
• Data link feps
• Fuse 16 15a
• Fuse panel
• G101 (right front of engine compt, on front fender apron)
• G200 (behind bottom of left kick panel)
• Hot at all times
• Powertrain control module (pcm) (on left side of firewall, left of main harness connectors)
• S203

7.3L

7.3L DI Turbo Diesel, Computer Data Lines for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Computer Data Lines for Ford F-Super Duty 1997:

• (behind center of dash) auxiliary powertrain control connector
• (behind lower right side of dash, below glove compartment) data link connector (dlc)
• (main harn, behind lower below center of dash)
• (power lumbar/ bolster harn, below left front seat) s241
• Aux pwrtrn in
• Cigar lighter
• Fuse 16 15a
• Fuse 18 10a
• Fuse panel
• G108 (left front of engine compt)
• G200 (behind bottom of left kick panel)
• Generic scan tool
• Hot at all times
• Hot in run
• Powertrain control module (pcm) (on left side of firewall, left of main harness connectors)
• S172
• S203
• S205
• S242
• S243
• Scan tool generic

7.5L

7.5L, Computer Data Lines, 49 States Or Super Duty for Ford F-Super Duty 1997

List of elements for 7.5L, Computer Data Lines, 49 States Or Super Duty for Ford F-Super Duty 1997:

• (engine sensor harn, near break- out to brake warn- ing resistor/ diode assenbly) s137
• (in left rear of engine compt, on bracket) vip data link connector (dlc)
• C198
• C199
• Data (+)
• Data (-)
• Dlc
• Egr valve position (evp) sensor (5.8l: on top right front of engine) (7.5l: on right side of engine compt)
• Engine coolant temperature (ect) sensor (5.8l: on t'stat housing) (7.5l: near left side of distributor)
• Fuel pump enable
• Fuel pump relay (on engine compt fuse box)
• Intake air temperature (iat) sensor (5.8l: near intake manifold runner 6) (7.5l: behind distributor)
• Manifold absolute pressure (map) sensor (on right side of firewall)
• Nca
• Powertrain control module (pcm) (on left side of firewall, left of main harness connectors)
• S251 (fuel charge harn, near breakout to fuel injector 3)
• Signal return
• Throttle position (tp) sensor (on throttle body)
• Transmission range (tr) sensor (on left side of trans)

7.5L, Computer Data Lines, California Except Super Duty for Ford F-Super Duty 1997

List of elements for 7.5L, Computer Data Lines, California Except Super Duty for Ford F-Super Duty 1997:

• (behind lower right side of dash, below glove compartment) data link connector (dlc)
• Cigar lighter
• Data link (+)
• Data link (-)
• Data link feps
• Fuse 16 15a
• Fuse panel
• G101 (right front of engine compt, on front fender apron)
• G200 (behind bottom of left kick panel)
• Hot at all times
• Powertrain control module (pcm) (on left side of firewall, left of main harness connectors)
• S203

CRUISE CONTROL

Cruise Control Wiring Diagram, Diesel for Ford F-Super Duty 1997

List of elements for Cruise Control Wiring Diagram, Diesel for Ford F-Super Duty 1997:

• (behind bottom of right kick panel)
• (behind glove box)
• (behind left side of instrument panel)
• (left rear of engine compartment, on bracket)
• (left side of firewall, left of main harness, connectors)
• (not used)
• (on rear axle assembly)
• 10a
• 15a
• 49 states or super duty only
• A/t
• Accel
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C240
• Clock- spring
• Clutch pedal position (ccp) switch (on bracket, above clutch pedal)
• Clutch pedal position (ccp) switch jumper (taped to main harness, near steering column)
• Coast
• Diff speed sensor high
• Diff speed sensor low
• Engine compartment fuse box
• Fuse 13
• Fuse 18
• Fuse 3 30a
• Fuse 5 15a
• Fuse panel
• G203
• Horn
• Horn relay
• Horn relay (in engine compt fuse box)
• Hot at all times
• Hot in run
• Instrument cluster
• M/t
• Nca
• Off
• Ohms
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module (psom)
• Rabs data link connector
• Rear anti-lock brake (rabs) module
• Rear axle sensor
• Red/
• Red/ pnk
• Red/pnk
• Remote keyless entry (rke) module (behind left side of dash)
• Resume
• S105
• S115
• S208 (main harness, near breakout to remote keyless entry module)
• S216
• S236
• S240 (main harn, in breakout to clutch pedal position switch or jumper)
• S242
• S247 (main harness, left rear of engine compt, on firewall)
• S248 (main harness, left rear of engine compt, on firewall)
• S429 (rear lamps harness, near breakout to ouput shaft speed sensor)
• S429 (rear lamps harness, near breakout to output shaft speed sensor)
• Set/
• Speed control/ horn switch assembly (in steering wheel)
• W/ 152" wheel base or greater

Cruise Control Wiring Diagram, Gasoline for Ford F-Super Duty 1997

List of elements for Cruise Control Wiring Diagram, Gasoline for Ford F-Super Duty 1997:

• (behind bottom of right kick panel)
• (behind glove box)
• (behind left side of instrument panel)
• (left rear of engine compartment, on bracket)
• (left side of engine compartment, near master cylinder)
• (left side of firewall, left of main harness connectors)
• (on rear axle assembly)
• 15a
• 49 states or super duty
• A/t
• Accel
• Brake on/off (boo) switch (on bracket, above brake pedal)
• Brake on/off in
• Brake press in
• Brake pressure switch (on left frame rail, below driver's floor pan)
• C240
• California except super duty
• Clock- spring
• Clutch pedal position (ccp) switch (on bracket, above clutch pedal)
• Clutch pedal position (ccp) switch jumper (taped to main harness, near steering column)
• Coast
• Diff speed sensor high
• Diff speed sensor low
• Engine compartment fuse box
• Fuse 13
• Fuse 3 30a
• Fuse 5 15a
• Fuse panel
• G203
• Ground
• Horn
• Horn relay
• Horn relay (in engine compt fuse box)
• Hot at all times
• Hot in run
• Instrument cluster
• M/t
• Nca
• Off
• Ohms
• Power
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module (psom)
• Rabs data link connector
• Rear anti-lock brake (rabs) module
• Rear axle sensor
• Red/ pnk
• Red/pnk
• Remote keyless entry (rke) module (behind left side of dash)
• Resume
• S105
• S115
• S208 (main harness, near breakout to remote keyless entry module)
• S216
• S236
• S240 (main harness, in breakout to clutch pedal position switch or jumper)
• S246 (main harness, near breakout to speed control amplifier)
• S247 (main harness, left rear of engine compt, on firewall)
• S248 (main harness, left rear of engine compt, on firewall)
• S429 (rear lamps harness, near breakout to ouput shaft speed sensor)
• S429 (rear lamps harness, near breakout to output shaft speed sensor)
• Set/
• Spd ctrl sw rtn
• Speed control servo/ amplifier assembly
• Speed control/ horn switch assembly (in steering wheel)
• Speed ctrl sw in
• Vehicle speed (vss) input
• Vss input
• W/ 152" wheel base or greater

ENGINE PERFORMANCE

5.8L

5.8L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, near brake warning resistor/diode assembly) s136
• (engine control sensor harness, near breakout to pcm)
• (fuel charge harness, near breakout to distributor)
• (fuel charge harness, near breakout to ignition coil)
• (low range indicator)
• A/c clutch sig
• Air conditioning system
• Aird solenoid
• Bbp feed
• Body builder power feed
• Case gnd
• Ckp sensor
• Coil
• Data link (+)
• Data link (-)
• Data link connector (right side of dash)
• Data link feps
• Distributor (top front of engine)
• Distributor ignition shield
• Ect sens
• Egr solnd ctrl
• Engine compartment fuse box
• Fuel pump mon
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front radiator support)
• G203 (right kick panel)
• Hot at all times
• Hot in start or run
• Iat sens
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left side of engine, above valve cover)
• Ignition control module (left rear side of engine compartment, on fender apron)
• Instrument cluster system
• Low rnge 4x4
• Maf sig rtn
• Mil
• Misfire sens
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Power
• Powertrain control module (top left side of firewall)
• Pwr gnd
• Pwr grd
• Radio capacitor (left side of engine, near coil)
• Red
• Red/
• Rr ho2s sig
• S102
• S104
• S145
• S148
• S171
• S199
• S216
• Spout
• Spout check connector (left rear of engine compartment, near icm)
• Trans ctrl sw
• Trans temp
• Tss 1
• Tss 2
• Vss (-)

5.8L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford F-Super Duty 1997:

• (fuel charge harness, near breakout to fuel injector 3)
• C250
• C251
• C252
• Delta pressure feedback egr sensor (5.8l - on top right front of of engine) (7.5l - on lrft side of throttle body)
• Engine compartment fuse box
• Engine coolant temperature sensor (left front of engine, near distributor)
• Fuel pump relay
• Fuse 20a
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (top center of engine, behind distributor)
• Malfunction indicator input
• Misfire sensor (center front of engine, on timing chain cover)
• Misfire sensor shield
• Nca
• Psom vehicle speed output
• Red
• Rpm input
• S135 (fuel charge harness, near breakout to canister purge solenoid)
• S151
• S246 (main harness, near breakout to speed control amplifier)
• Throttle position sensor (top left front of engine, on throttle body)

5.8L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (fuel charge harness, near breakout to act solenoid)
• (fuel charge harness, near breakout to fuel injector 3)
• (not used)
• 5.8l
• 7.5l
• Coast clutch solenoid
• E4od transmission
• Egr control solenoid (5.8l - on ignition coil support bracket) (7.5l - in left side of engine compt)
• Electronic pressure control solenoid
• Front tank fuel pump/ fuel gauge sender
• Fuel tank selector switch
• G108 (on upper left radiator support)
• Idle air control valve (on throttle body)
• Inertia fuel shut-off switch (behind right kick panel)
• Injectors fuel
• Nca
• Rear tank fuel pump/ fuel gauge sender
• Red
• S137
• S149
• S151
• S169
• S400
• Secondary air injection bypass (airb) solenoid (7.5l) (near ignition coil)
• Secondary air injection diverter (aird) solenoid (7.5l) (rear of left valve cover)
• Shift solenoids
• Ss1
• Ss2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (center of engine)

5.8L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, in breakout to engine compt. fuse panel box)
• (engine control sensor harness, near breakout to pcm)
• (main harness, near breakout to clutch pedal position switch or jumper) s240
• (not used)
• 5.8l
• 7.5l
• Airb solenoid
• Batt
• Brake on/off
• Brake on/off (boo) switch (on bracket, above brake pedal)
• Coast clutch
• Dpfe sens
• Epc sol
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 10a
• Fuse 15a
• Fuse panel
• G101 (right fender apron, right side of battery)
• H02s heater ctrl
• Heated oxygen sensor 11 (near top of transmission)
• Heated oxygen sensor 12 (near rear of transmission)
• Heated oxygen sensor 21 (near left side of transmission)
• Hot at all times
• Hot in run or start
• Iac sol
• Lf ho2s sig
• Maf sens in
• Mass air flow sensor (right front side of engine compartment)
• Misfire in
• Nca
• Power
• Power gnd
• Powertrain control module (top left side of firewall)
• Pwr gnd
• Red
• Ref volt
• Rf ho2s sig
• S106
• S122
• S123
• S146
• S215
• S236
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens in
• Trans ctrl ind
• Trans- mission control switch
• Transmission range sensor (lower left side of transmission)
• Vapor valve
• Vss (+)

5.8L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford F-Super Duty 1997:

• #1 shift solenoid
• #2 shift solenoid
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout near breakout to pcm)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (fuel charge harness, near breakout to distributor)
• (left rear of engine compt, on bracket) data link connector
• (left side of firewall) powertrain control module
• (low range indicator)
• (main harness, near breakout to clutch pedal position switch or jumper)
• (right front of engine compt, on fender apron)
• (top left side of brake/ clutch pedal support)
• (top of upper left radiator support)
• A/c demand sig
• A/c system
• Accs
• Air conditioning system
• Airb solnd ctrl
• Aird solnd ctrl
• Boo
• Brake on/off (boo) switch
• C198
• C250
• C251
• Ccs
• Ckp sensor
• Coast clutch solenoid
• Coil
• Coil wire
• Cse gnd
• Distributor
• E40d transmission
• Ect
• Egr cntrl solnd.
• Egr valve pos
• Electronic pres- sure control solenoid
• Engine compartment fuse box
• Epc
• Evap can solnd.
• Fp enable
• Fpm
• Fuse 13 15a
• Fuse 17 10a
• Fuse 22 20a
• Fuse 30a
• Fuse panel
• G101
• G104 (rear of left fender apron)
• G108
• Gnd
• Ho2s ground
• Ho2s sig input
• Hot at all times
• Hot in run or start
• Hot in start or run
• Iac
• Iat
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left rear of engine)
• Ignition control module (left rear of engine compartment, on fender apron)
• Inj 1, 4, 5, 8
• Inj 2, 3, 6, 7
• Instrument cluster
• Instrument cluster system
• Kapwr
• Low range ind
• Malfunction indicator
• Map sensor input
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Pwr
• Pwr gnd
• Radio capacitor (left side of engine, near ignition coil)
• Red
• S102
• S106
• S136
• S145
• S148
• S169
• S171
• S199
• S215
• S216
• S236
• S240
• S246 (main harness, near breakout to speed control amplifier)
• Sig rtn
• Speed control servo/amplifier assembly (near master cylinder)
• Spout
• Spout check connector (left rear of engine compt, taped to harness, near ignition control module)
• Sto/mil
• Tan
• Tcc
• Tcil
• Tcs
• Tft sensor input
• Torque con- verter clutch solenoid
• Tps input
• Tr sensor input
• Transmission fluid temp sensor
• Tss 1
• Tss 2
• Vip dlc
• Vpwr
• Vref
• Vss ground
• Vss signal input

5.8L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford F-Super Duty 1997

List of elements for 5.8L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford F-Super Duty 1997:

• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to left head- lamp)
• (engine control sensor harness, near breakout to powertrain control module)
• (fuel charge harn, near breakout to fuel inj 5)
• (fuel charge harn, near breakout to fuel inj 8)
• (fuel charge harness, near breakout to air charge temperature solenoid)
• (fuel charge harness, near breakout to canister purge solenoid)
• (fuel charge harness, near breakout to fuel injector 3)
• (not used)
• (on upper left radiator support) g108
• (on upper radiator support)
• 5.8l
• 7.5l
• A/t
• C199
• Data link connector (left rear of engine compt, on bracket)
• Egr control solenoid (on ignition coil support bracket)
• Egr valve position sensor (top right front of engine)
• Engine compart- ment fuse box
• Engine compartment fuse box
• Engine coolant temperature sensor (5.8l - on thermostat housing) (7.5l - on left side of distributor)
• Evap canister purge solenoid (right front of engine)
• Front tank fuel pump/ fuel gauge sender
• Fuel injectors
• Fuel pump relay
• Fuel tank selector switch
• Fuse 16 20a
• Fuse 5 15a
• G108
• Heated oxygen sensor no.11 (near top of trans)
• Hot at all times
• Hot in run
• Idle air control valve (top of throttle body)
• Inertia fuel shut-off switch (behind right kick panel)
• Intake air temperature sensor (top center front of engine, near intake runner #6)
• M/t
• Manifold absolute pressure sensor (top right side of firewall)
• Nca
• Rear tank fuel pump/ fuel gauge sender
• Red
• S102
• S122
• S134
• S135
• S137
• S146
• S149
• S151
• S159
• S160
• S163
• S165
• S400
• Secondary air injection bypass solenoid (7.5l) (near rear of left valve cover)
• Secondary air injection diverter solenoid (near rear of left valve cover)
• Starting/ charging system
• Tan
• Tcil
• Throttle position sensor (top right front of engine, on throttle body)
• Transmission control switch
• Transmission range sensor (left side of transmission)

7.3L

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (1 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (1 of 3) for Ford F-Super Duty 1997:

• "wait to start" indicator
• (engine control sensor harness, near breakout to brake warning resistor/ diode assembly)
• (engine control sensor harness, near breakout to pcm)
• (in main harness, near breakout to lower center of dash)
• (left side of firewall)
• (power lumbar/bolster harness, near breakout to lower center of dash)
• 4x4 hi/low indicator switch (front of transfer case)
• Acc
• Aux rpm input
• Auxiliary powertrain control connector (center of dash)
• Brake press sw
• Brake warning ind
• C250
• C251
• Cam pos sens
• Ccs
• Cruise control system
• Data link connector (behind lower center of dash)
• Diesel warning lamps display
• Dlc
• Ebp
• Engine compartment fuse box
• Engine oil temperature (eot) sensor (front top of engine)
• Eot
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse 3a
• Fuse panel
• G104 (rear of left fender apron)
• G108 (left front of engine compart- ment, on upper radiator support)
• Glow plug relay
• Gnd
• Hot at all times
• Hot in run
• Hot in run or start
• Iat
• Idle validation sw
• Idle validation switch (open at idle) (near accele- rator pedal)
• Idm relay
• Ignition switch
• Injection pressure regulator (ipr) (top center of engine)
• Instrument cluster
• Instrument cluster system
• Intake air temper- ature (iat) sensor (top center of engine)
• Lock
• Low range 4x4 sw
• Malfunction indicator lamp (mil)
• Nca
• Off
• Pcm dlc
• Pcm power diode
• Pcm power relay
• Power take-off feed
• Powertrain control module (pcm)
• Pto feed
• Pwr gnd
• Red
• Run
• S101
• S105
• S125
• S157
• S166 (engine control sensor harness, near breakout to pcm)
• S174
• S206
• S215
• S241
• S243
• Speed ctrl gnd
• Ss1
• Start
• Tachometer
• Tcil
• Tcs
• Tft
• Vss gnd

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (2 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (2 of 3) for Ford F-Super Duty 1997:

• (engine control harness, near breakout to engine compt fuse box)
• (engine control sensor harness, near breakout to left headlamp)
• (engine control sensor harness, near breakout to starter relay)
• (left front of engine compartment, on radiator support)
• (left side of firewall)
• A/c cyl press sw
• Accelerator pedal position sensor (under left side of dash)
• Accl pdl pos sens
• Air conditioning system
• Baro
• Barometric pressure (baro) sensor (below dash, at base of steering column)
• Boo
• C252
• Camshaft position (cmp) sensor (front center of engine)
• Cid sig
• Cmp rtn
• Cruise control system
• Epc
• Epr
• Exhaust back pressure (ebp) sensor (right side of engine)
• Exhaust pressure regulator (epr) (top center of engine)
• Fuel delivery sig
• G108
• G203 (behind bottom of right kick panel)
• Glow plug ctrl
• Gnd
• Icp
• Idm enable out
• Idm sig in
• Injection control pressure (icp) sensor (top left side of engine)
• Instrument cluster
• Ipr
• Kapwr
• Manifold absolute pressure (map) sensor (top right side of firewall)
• Map
• Nca
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module
• Pwr gnd
• Red
• S106
• S126
• S129 (pia harness, in breakout to ect)
• S163
• S164
• S192
• S216
• S235 (main harn, in breakout to throttle position sensor)
• Sig rtn
• Speed ctrl gnd
• Tcc
• Tcil
• Tcs
• Tr sensor
• Transmission control switch
• Vpwr
• Vref
• Vss
• Vss out
• Wait to start out

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (3 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, California (3 of 3) for Ford F-Super Duty 1997:

• #1 shift solenoid
• #2 shift solenoid
• (backup lamp switch to rear lamp feed harness, in breakout)
• (in pia harn)
• (left side of engine compartment)
• (main harness, near breakout to clutch pedal position switch or jumper)
• (pia harness, near breakout to fuel charge pump motor)
• (pia harness, near breakout to fuel charge pump motor) s141
• Brake on/off (boo) switch (on bracket, above brake pedal)
• Cid sig in
• Coast clutch solenoid
• E4od transmission
• Electronic pressure control solenoid
• Engine compart- ment fuse box
• Fuel delivery sig
• Fuel inj feed left
• Fuel inj feed right
• Fuel injector #1
• Fuel injector #2
• Fuel injector #3
• Fuel injector #4
• Fuel injector #5
• Fuel injector #6
• Fuel injector #7
• Fuel injector #8
• Fuel injectors/ glow plugs (1,3)
• Fuel injectors/ glow plugs (2,4)
• Fuel injectors/ glow plugs (5,7)
• Fuel injectors/ glow plugs (6,8)
• Fuel line heater (right side of engine, on top of fuel filter/heater)
• Fuse 15a
• Fuse 30a
• Fuse panel
• Glow plug relay (top center rear of engine)
• Hot at all times
• Hot in run or start
• Idm feedback sig
• Inj shield gnd
• Injector driver module (idm)
• Nca
• Pwr gnd
• Red
• S112
• S113
• S128
• S142
• S143
• S146
• S236
• S240
• Sig rtn
• Tan
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Transmission range (tr) sensor
• Vpwr

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (1 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (1 of 3) for Ford F-Super Duty 1997:

• "wait to start" indicator
• (a/t)
• (engine control sensor harness, near breakout to brake warning resistor/ diode assembly)
• (engine control sensor harness, near breakout to pcm)
• (in main harness, near breakout to lower center of dash)
• (left side of firewall)
• (m/t)
• (power lumbar/bolster harness, near breakout to center of dash)
• 4x4 hi/low indicator switch (front of transfer case)
• A/t
• Acc
• Aux rpm input
• Auxiliary powertrain control connector (center of dash)
• Brake press sw
• Brake warning ind
• C250
• C251
• Clutch pedal position switch (top right side of brake/clutch pedal support)
• Cruise control system
• Data link connector (behind lower center of dash)
• Diesel warning lamps display
• Dlc
• Ebp
• Engine compartment fuse box
• Engine oil temperature (eot) sensor (front top of engine)
• Eot
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• Fuse 3a
• Fuse panel
• G104 (rear of left fender apron)
• G108 (left front of engine compart- ment, on upper radiator support)
• Gnd
• Hot at all times
• Hot in run
• Hot in run or start
• Iat
• Idle validation sw
• Idle validation switch (open at idle) (near accele- rator pedal)
• Idm relay
• Ignition switch
• Injection pressure regulator (ipr) (top center of engine)
• Instrument cluster
• Instrument cluster system
• Intake air temper- ature (iat) sensor (top center of engine)
• Lock
• Low range 4x4 sw
• M/t
• Malfunction indicator lamp (mil)
• Map
• Nca
• Off
• Pcm dlc
• Pcm power diode
• Pcm power relay
• Power take-off feed
• Powertrain control module (pcm)
• Pto feed
• Pwr gnd
• Red
• Run
• S101
• S105
• S125
• S157
• S166 (engine control sensor harness, near breakout to pcm)
• S174
• S206
• S215
• S241
• S242
• S243
• Speed ctrl gnd
• Ss1
• Ss2
• Start
• Tcc
• Tcs or cpp
• Tft
• Vss gnd

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (2 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (2 of 3) for Ford F-Super Duty 1997:

• (engine control sensor harness, near breakout to engine compartment fuse box)
• (engine control sensor harness, near breakout to left headlamp)
• (engine control sensor harness, near breakout to starter relay)
• (left front of engine compartment, on radiator support)
• (left side of firewall)
• A/c cyl press sw
• Accelerator pedal position sensor (under left side of dash)
• Accl pdl pos sens
• Air conditioning system
• Baro
• Barometric pressure (baro) sensor (below dash, at base of steering column)
• Boo
• C252
• Cam pos sens
• Camshaft position (cmp) sensor (front center of engine)
• Ccs
• Cid sig
• Cmp rtn
• Cruise control system
• Epc
• Epr
• Exhaust back pressure (ebp) sensor (right side of engine)
• Exhaust pressure regulator (epr) (top center of engine)
• Fuel delivery sig
• G108
• G203 (behind bottom of right kick panel)
• Glow plug ctrl
• Gnd
• Icp
• Idm enable out
• Idm sig in
• Injection control pressure (icp) sensor (top left side of engine)
• Instrument cluster
• Instrument cluster system
• Ipr
• Kapwr
• Manifold absolute pressure (map) sensor (top right side of firewall)
• Nca
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module
• Pwr gnd
• Red
• S106
• S126
• S129 (pia harness, in breakout to ect)
• S163
• S164
• S192
• S216
• S235 (main harness, in breakout to throttle position sensor)
• Sig rtn
• Speed ctrl gnd
• Tachometer
• Tcil
• Tcs
• Tr sensor
• Transmission control switch
• Vpwr
• Vref
• Vss
• Vss out
• Wait to start out

7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (3 of 3) for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Engine Performance Wiring Diagrams, Federal (3 of 3) for Ford F-Super Duty 1997:

• #1 shift solenoid
• #2 shift solenoid
• (backup lamp switch to rear lamp feed harness, in breakout to transmission)
• (left side of engine compartment)
• (main harness, near breakout to clutch pedal position switch or jumper)
• (pia harness, near breakout to fuel charge pump motor)
• (pia harness, near breakout to fuel charge pump motor) s141
• Brake on/off (boo) switch (brake/clutch pedal support)
• Cid sig in
• Coast clutch solenoid
• E4od transmission
• Electronic pressure control solenoid
• Engine compart- ment fuse box
• Fuel delivery sig
• Fuel inj feed left
• Fuel inj feed right
• Fuel injector #1
• Fuel injector #2
• Fuel injector #3
• Fuel injector #4
• Fuel injector #5
• Fuel injector #6
• Fuel injector #7
• Fuel injector #8
• Fuel injectors/ glow plugs (1,3)
• Fuel injectors/ glow plugs (2,4)
• Fuel injectors/ glow plugs (5,7)
• Fuel injectors/ glow plugs (6,8)
• Fuel line heater (right side of engine, on top of fuel filter/heater)
• Fuse 15a
• Fuse 30a
• Fuse panel
• Glow plug relay (top center rear of engine)
• Hot at all times
• Hot in run or start
• Idm feedback sig
• Inj shield gnd
• Injector driver module (idm)
• Nca
• Pwr gnd
• Red
• S112 (in pia harn)
• S113 (in pia harn)
• S128
• S142
• S143
• S146
• S236
• S240
• Sig rtn
• Tan
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Transmission range (tr) sensor
• Vpwr

7.5L

7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (1 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, near brake warning resistor/diode assembly) s136
• (engine control sensor harness, near breakout to pcm)
• (fuel charge harness, near breakout to distributor)
• (fuel charge harness, near breakout to ignition coil)
• (low range indicator)
• A/c clutch sig
• Air conditioning system
• Aird solenoid
• Bbp feed
• Body builder power feed
• Case gnd
• Ckp sensor
• Coil
• Data link (+)
• Data link (-)
• Data link connector (right side of dash)
• Data link feps
• Distributor (top front of engine)
• Distributor ignition shield
• Ect sens
• Egr solnd ctrl
• Engine compartment fuse box
• Fuel pump mon
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front radiator support)
• G203 (right kick panel)
• Hot at all times
• Hot in start or run
• Iat sens
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left side of engine, above valve cover)
• Ignition control module (left rear side of engine compartment, on fender apron)
• Instrument cluster system
• Low rnge 4x4
• Maf sig rtn
• Mil
• Misfire sens
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Power
• Powertrain control module (top left side of firewall)
• Pwr gnd
• Pwr grd
• Radio capacitor (left side of engine, near coil)
• Red
• Red/
• Rr ho2s sig
• S102
• S104
• S145
• S148
• S171
• S199
• S216
• Spout
• Spout check connector (left rear of engine compartment, near icm)
• Trans ctrl sw
• Trans temp
• Tss 1
• Tss 2
• Vss (-)

7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (2 of 4) for Ford F-Super Duty 1997:

• (fuel charge harness, near breakout to fuel injector 3)
• C250
• C251
• C252
• Delta pressure feedback egr sensor (5.8l - on top right front of of engine) (7.5l - on lrft side of throttle body)
• Engine compartment fuse box
• Engine coolant temperature sensor (left front of engine, near distributor)
• Fuel pump relay
• Fuse 20a
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (top center of engine, behind distributor)
• Malfunction indicator input
• Misfire sensor (center front of engine, on timing chain cover)
• Misfire sensor shield
• Nca
• Psom vehicle speed output
• Red
• Rpm input
• S135 (fuel charge harness, near breakout to canister purge solenoid)
• S151
• S246 (main harness, near breakout to speed control amplifier)
• Throttle position sensor (top left front of engine, on throttle body)

7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (3 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (fuel charge harness, near breakout to act solenoid)
• (fuel charge harness, near breakout to fuel injector 3)
• (not used)
• 5.8l
• 7.5l
• Coast clutch solenoid
• E4od transmission
• Egr control solenoid (5.8l - on ignition coil support bracket) (7.5l - in left side of engine compt)
• Electronic pressure control solenoid
• Front tank fuel pump/ fuel gauge sender
• Fuel tank selector switch
• G108 (on upper left radiator support)
• Idle air control valve (on throttle body)
• Inertia fuel shut-off switch (behind right kick panel)
• Injectors fuel
• Nca
• Rear tank fuel pump/ fuel gauge sender
• Red
• S137
• S149
• S151
• S169
• S400
• Secondary air injection bypass (airb) solenoid (7.5l) (near ignition coil)
• Secondary air injection diverter (aird) solenoid (7.5l) (rear of left valve cover)
• Shift solenoids
• Ss1
• Ss2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (center of engine)

7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, California (4 of 4) for Ford F-Super Duty 1997:

• (engine control sensor harness, in breakout to engine compt. fuse panel box)
• (engine control sensor harness, near breakout to pcm)
• (main harness, near breakout to clutch pedal position switch or jumper) s240
• (not used)
• 5.8l
• 7.5l
• Airb solenoid
• Batt
• Brake on/off
• Brake on/off (boo) switch (on bracket, above brake pedal)
• Coast clutch
• Dpfe sens
• Epc sol
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 10a
• Fuse 15a
• Fuse panel
• G101 (right fender apron, right side of battery)
• H02s heater ctrl
• Heated oxygen sensor 11 (near top of transmission)
• Heated oxygen sensor 12 (near rear of transmission)
• Heated oxygen sensor 21 (near left side of transmission)
• Hot at all times
• Hot in run or start
• Iac sol
• Lf ho2s sig
• Maf sens in
• Mass air flow sensor (right front side of engine compartment)
• Misfire in
• Nca
• Power
• Power gnd
• Powertrain control module (top left side of firewall)
• Pwr gnd
• Red
• Ref volt
• Rf ho2s sig
• S106
• S122
• S123
• S146
• S215
• S236
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens in
• Trans ctrl ind
• Trans- mission control switch
• Transmission range sensor (lower left side of transmission)
• Vapor valve
• Vss (+)

7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (1 of 2) for Ford F-Super Duty 1997:

• #1 shift solenoid
• #2 shift solenoid
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout near breakout to pcm)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (fuel charge harness, near breakout to distributor)
• (left rear of engine compt, on bracket) data link connector
• (left side of firewall) powertrain control module
• (low range indicator)
• (main harness, near breakout to clutch pedal position switch or jumper)
• (right front of engine compt, on fender apron)
• (top left side of brake/ clutch pedal support)
• (top of upper left radiator support)
• A/c demand sig
• A/c system
• Accs
• Air conditioning system
• Airb solnd ctrl
• Aird solnd ctrl
• Boo
• Brake on/off (boo) switch
• C198
• C250
• C251
• Ccs
• Ckp sensor
• Coast clutch solenoid
• Coil
• Coil wire
• Cse gnd
• Distributor
• E40d transmission
• Ect
• Egr cntrl solnd.
• Egr valve pos
• Electronic pres- sure control solenoid
• Engine compartment fuse box
• Epc
• Evap can solnd.
• Fp enable
• Fpm
• Fuse 13 15a
• Fuse 17 10a
• Fuse 22 20a
• Fuse 30a
• Fuse panel
• G101
• G104 (rear of left fender apron)
• G108
• Gnd
• Ho2s ground
• Ho2s sig input
• Hot at all times
• Hot in run or start
• Hot in start or run
• Iac
• Iat
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left rear of engine)
• Ignition control module (left rear of engine compartment, on fender apron)
• Inj 1, 4, 5, 8
• Inj 2, 3, 6, 7
• Instrument cluster
• Instrument cluster system
• Kapwr
• Low range ind
• Malfunction indicator
• Map sensor input
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Pwr
• Pwr gnd
• Radio capacitor (left side of engine, near ignition coil)
• Red
• S102
• S106
• S136
• S145
• S148
• S169
• S171
• S199
• S215
• S216
• S236
• S240
• S246 (main harness, near breakout to speed control amplifier)
• Sig rtn
• Speed control servo/amplifier assembly (near master cylinder)
• Spout
• Spout check connector (left rear of engine compt, taped to harness, near ignition control module)
• Sto/mil
• Tan
• Tcc
• Tcil
• Tcs
• Tft sensor input
• Torque con- verter clutch solenoid
• Tps input
• Tr sensor input
• Transmission fluid temp sensor
• Tss 1
• Tss 2
• Vip dlc
• Vpwr
• Vref
• Vss ground
• Vss signal input

7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford F-Super Duty 1997

List of elements for 7.5L, Engine Performance Wiring Diagrams, Federal (2 of 2) for Ford F-Super Duty 1997:

• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to left head- lamp)
• (engine control sensor harness, near breakout to powertrain control module)
• (fuel charge harn, near breakout to fuel inj 5)
• (fuel charge harn, near breakout to fuel inj 8)
• (fuel charge harness, near breakout to air charge temperature solenoid)
• (fuel charge harness, near breakout to canister purge solenoid)
• (fuel charge harness, near breakout to fuel injector 3)
• (not used)
• (on upper left radiator support) g108
• (on upper radiator support)
• 5.8l
• 7.5l
• A/t
• C199
• Data link connector (left rear of engine compt, on bracket)
• Egr control solenoid (on ignition coil support bracket)
• Egr valve position sensor (top right front of engine)
• Engine compart- ment fuse box
• Engine compartment fuse box
• Engine coolant temperature sensor (5.8l - on thermostat housing) (7.5l - on left side of distributor)
• Evap canister purge solenoid (right front of engine)
• Front tank fuel pump/ fuel gauge sender
• Fuel injectors
• Fuel pump relay
• Fuel tank selector switch
• Fuse 16 20a
• Fuse 5 15a
• G108
• Heated oxygen sensor no.11 (near top of trans)
• Hot at all times
• Hot in run
• Idle air control valve (top of throttle body)
• Inertia fuel shut-off switch (behind right kick panel)
• Intake air temperature sensor (top center front of engine, near intake runner #6)
• M/t
• Manifold absolute pressure sensor (top right side of firewall)
• Nca
• Rear tank fuel pump/ fuel gauge sender
• Red
• S102
• S122
• S134
• S135
• S137
• S146
• S149
• S151
• S159
• S160
• S163
• S165
• S400
• Secondary air injection bypass solenoid (7.5l) (near rear of left valve cover)
• Secondary air injection diverter solenoid (near rear of left valve cover)
• Starting/ charging system
• Tan
• Tcil
• Throttle position sensor (top right front of engine, on throttle body)
• Transmission control switch
• Transmission range sensor (left side of transmission)

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Ford F-Super Duty 1997

List of elements for Back-up Lamps Wiring Diagram for Ford F-Super Duty 1997:

• A/t
• Backup
• Backup lamp switch (below center of vehicle, on top left side of transmission)
• Bulbs are case grounded for chassis cab models
• Engine compartment fuse box (on left inner fender panel)
• Exterior lamps circuit (trailer backup lamps relay)
• Fuse 5 15a
• G108 (left front of engine compt, on upper radiator support)
• Hot in run
• Lamp
• Left
• M/t
• Right backup lamp
• S134
• S404
• S426 (rear lamp conn harn, under left
• Transmission range (tr) sensor (below center of vehicle, on left side of transmission)

Exterior Lamps Wiring Diagram (1 of 2) for Ford F-Super Duty 1997

List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Ford F-Super Duty 1997:

• (eng control sensor harn, near left front park/turn lamp breakout) s110
• (eng control sensor harn, near left front park/turn lamp breakout) s156
• (if equipped) (diagram 2 of 2)
• (main harn, left rear of eng compt)
• (rear lamp conn harn, under rear of vehicle)
• (rear license lamp harn, under center rear of vehicle)
• Brake on/ off (boo) switch (on bracket, above brake pedal)
• Bumper
• C250
• C251
• Cab marker lamps (pick-up only)
• Cap center high mount stop lamp
• Cargo/ high mount stop lamps
• Door locks system (remote/ keyless entry)
• Fuse 15a
• G101 (right front of engine compartment, on fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G200 (behind bottom of left kick panel)
• Hazard
• Hazard flasher (behind left side of dash, on fuse panel)
• Head
• High mount stop lamp
• Hot at all times
• Hot in run
• I/p fuse panel (behind left side of dash)
• Instrument cluster
• Left
• Left front park/turn lamp
• Left front side marker lamps
• Left rear park/stop/ turn lamp (case grounded for f-series chassis cab)
• Left turn indicator
• License lamp
• License lamps
• Main light switch
• Multi-function switch
• Normal
• Off
• Only
• Park
• Right
• Right front park/turn lamp
• Right front side marker lamps
• Right rear park/stop/ turn lamp (case grounded for f-series chassis cab)
• Right turn indicator
• S100
• S103
• S200
• S202
• S213 (main harn, near warning chime module breakout)
• S236
• S240 (main harn, behind left side of dash,
• S260
• S261
• S403
• S404
• S417
• S418
• Style/ flare side
• To engine compartment fuse box (fuse 6) (diagram 2 of 2)
• To engine compartment fuse box (fuse 7) (diagram 2 of 2)
• To trailer marker lamps relay (diagram 2 of 2)
• Trailer illumination feed
• Trailer stop lamps feed
• Turn flasher (behind left side of dash, on fuse panel)
• W/ rear
• W/o rear bumper only

Exterior Lamps Wiring Diagram (2 of 2) for Ford F-Super Duty 1997

List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Ford F-Super Duty 1997:

• (customer use)
• (eng cntrl sens harn, left side of eng compt)
• (rear lamp conn harn, under center rear of vehicle)
• (rear lamps harn, under left rear of vehicle)
• Backup lamp circuit
• Backup lamps
• Battery charge
• Cab marker lamps (if equipped)
• Dual rear
• Electric brakes
• Engine compartment fuse box (on left inner fender panel)
• From main light switch (diagram 1 of 2)
• From multi- function switch (diagram 1 of 2)
• Fuse 10a
• Fuse 15a
• Fuse 25a
• Fuse 30a
• G108 (left front of engine compartment, on upper radiator support)
• G200 (behind bottom of left kick panel)
• G415 (center rear of vehicle, on rear crossmember)
• Hot at all times
• Hot in run or start
• Left side body marker lamps (if equipped)
• Left turn lamp
• Marker lamps
• Nca
• Pick-up w/
• Quarter panel)
• Rear body marker lamps (if equipped)
• Red
• Right side body marker lamps (if equipped)
• Right turn lamp
• S102
• S104
• S109
• S203
• S203 or s205
• S412
• S419
• Trailer backup lamps relay (in trailer relay box)
• Trailer battery charge relay (in trailer relay box)
• Trailer battery feed
• Trailer electric brakes feed
• Trailer ground
• Trailer marker lamps relay (in engine compartment fuse box)
• Trailer/camper adapter
• Wheels only

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 4) for Ford F-Super Duty 1997

List of elements for Ground Distribution Wiring Diagram (1 of 4) for Ford F-Super Duty 1997:

• (frame)
• (left front of engine)
• (lower right front of engine)
• 49 states or super duty
• A/c clutch diode
• A/c clutch field coil
• All engines
• Amplifier
• Battery
• C212
• C241
• C251
• C252
• C277
• Calif. ex. super duty & diesel
• California ex. super duty
• Data link connector
• Diesel
• Diesel engines
• Front of engine)
• G101 (right front of engine compartment, front of fender apron)
• G101 (right front of engine compartment, on front fender apron)
• G104 (rear of left fender apron)
• G110
• G119
• G119 (lower right
• G203 (behind bottom of right kick panel)
• Gasoline
• Gasoline 49 states or super duty
• Gasoline engines
• Generator/ voltage regulator
• Instrument cluster
• Lamp
• Left battery
• Mass air flow (maf) sensor
• Nca
• Powertrain control module (pcm)
• Programmable speedometer/ odometer module
• Rabs valve assembly
• Radio
• Rear abs module
• Remote keyless entry module
• Right battery
• Right front park/ turn
• Right front park/ turn lamp
• Right front side marker lamps
• Right headlamp
• S100 (engine harness, near breakout to right front park/turn lamp)
• S106 (engine harness, near breakout to g101)
• S216 (engine harness, near breakout to g203)
• Speed control servo/ amplifier assembly
• W/ ambulance prep package
• W/ premium sound
• W/o premium sound
• Windshield washer pump motor

Ground Distribution Wiring Diagram (2 of 4) for Ford F-Super Duty 1997

List of elements for Ground Distribution Wiring Diagram (2 of 4) for Ford F-Super Duty 1997:

• (not
• (rear of left fender apron)
• Brake fluid level switch
• Bumper
• Chassis cab
• Data link connector
• Diesel engines
• Engine compart- ment lamp
• Engine compartment fuse box
• Exhaust pressure regulator (epr)
• Front tank fuel gauge sender
• G104
• G108 (left front of engine compartment, on upper radiator support)
• Injector driver module
• Left backup lamp
• Left front park/ turn lamp
• Left front side marker lamps
• Left headlamp
• Left rear park/ stop/ turn lamp
• License lamps
• Nca
• Only
• Others
• Pcm power relay
• Powertrain control module (pcm)
• Rear
• Rear tank fuel gauge sender
• Right backup lamp
• Right rear park/ stop/ turn lamp
• S101 (engine harness, near breakout to engine compt fuse box)
• S103 (engine harness, near breakout to left front park lamp)
• S104 (body harness, near breakout to trailer relay box)
• S106 (engine harness, near breakout to g108)
• S403 (body harness, near breakout to c400, center rear of vehicle)
• S404 (body harness, center rear of vehicle)
• Trailer backup lamps relay
• Trailer battery charge relay
• Trailer marker lamps relay
• Trailer relay box
• Used)
• Windshield wiper motor
• With

Ground Distribution Wiring Diagram (3 of 4) for Ford F-Super Duty 1997

List of elements for Ground Distribution Wiring Diagram (3 of 4) for Ford F-Super Duty 1997:

• (engine harness, near breakout to left front park/turn lamp) s103
• (left front of engine compartment, on upper radiator support)
• (not used)
• 49 states or super duty
• 5.0l calif. ex. super duty w/e4od
• A/c clutch field coil
• A/c clutch resistor diode
• Brake fluid level switch
• Bumper
• C151
• C170
• C250
• Cab
• Chassis
• Engine compart- ment lamp
• Engine compartment fuse box
• Flare side
• Front tank fuel pump/fuel gauge sender
• G108
• Gasoline engines
• Heated oxygen sensor (ho2s)
• Instrument cluster
• Left backup lamp
• Left front park/ turn lamp
• Left front side marker lamps
• Left headlamp
• Left rear park/ stop/ turn lamp
• License lamps
• Nca
• Only
• Pcm power relay
• Rabs valve assembly
• Rear tank fuel pump/fuel gauge sender
• Right backup lamp
• Right rear park/ stop/ turn lamp
• S102 (engine harness, near breakout to brake resistor/diode assembly)
• S104 (body harness, near breakout trailer relay box)
• S400 (body harness, near breakout to front fuel tank gauge sender)
• S403 (engine harness, in breakout conn c400, center rear of vehicle)
• S404 (engine harness, left rear of vehicle)
• Style side &
• Tanks only
• Tow
• Trailer
• Trailer backup lamps relay
• Trailer battery charge relay
• Trailer relay box
• Trailer/ marker lamps relay
• Trans- mission range (tr) sensor
• Transmission
• W/ 4r70w
• W/ dual
• W/ e4od
• W/ rear
• Wind- shield washer pump motor
• Wind- shield wiper motor

Ground Distribution Wiring Diagram (4 of 4) for Ford F-Super Duty 1997

List of elements for Ground Distribution Wiring Diagram (4 of 4) for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (body harness, near breakout to right window control switch) s602
• (center rear of vehicle, on rear crossmember)
• (i/p harness, left side of dash) s202
• Ashtray illumination
• Auxiliary power socket
• Auxiliary powertrain control connector
• Blower motor resistor
• Blower motor switch
• C242
• C250
• Cab marker lamps
• Captain chairs w/ power lumbar
• Cargo/ high mount stop lamps
• Cigar lighter
• Crew cab w/ xlt
• Crew cab w/o xlt
• Data link connector
• Diesel only
• Diesel warning lamps display
• F-350 w/ dual rear wheels
• Fuel tank selector switch
• G200
• G415
• Gas
• Glove compartment lamp
• Gnd
• Heater control illumination
• Ignition switch
• Instrument cluster
• Left front door courtesy lamp
• Left power lumbar compressor motor
• Left power lumbar/ bolster compressor motor
• Left rear door courtesy lamp
• Left side body marker lamps
• Master window/ door lock control switch
• Nca
• Power lumbar compressor motor
• Power mirror switch
• Radio
• Rear body marker lamps
• Remote keyless entry module
• Right door lock control switch
• Right front door courtesy lamp
• Right power lumbar compressor motor
• Right power lumbar/ bolster compressor motor
• Right rear door courtesy lamp
• Right side body marker lamps
• S200 (body harness, near breakout to g200)
• S203 (i/p harness, near breakout to enable psom conn)
• S205 (i/p harness, near breakout to radio)
• S226 (body harness, below left front seat)
• S309 (body harness, left "b" pillar)
• S409 (body harness, left rear quarter panel)
• S412 (rear lamp harn, near breakout to body marker lamps)
• S500 (i/p harness, near breakout to master window switch)
• Seat belt switch
• Shift lock actuator
• Trailer electronic brake control
• Trailer ground feed
• Trailer/camper adapter
• W/ power bolsters
• W/ remote keyless entry
• W/ trailer tow only
• W/o crew cab
• W/o power bolsters
• W/trailer tow only
• Warning chime module
• Wiper control module

HEADLIGHTS

Headlight Wiring Diagram, with DRL for Ford F-Super Duty 1997

List of elements for Headlight Wiring Diagram, with DRL for Ford F-Super Duty 1997:

• (eng control sensor harn, near left headlamp breakout) s154
• (not used)
• 40a
• Acc
• Battery power
• Brake fluid level switch (left rear of engine compartment, on brake fluid reservoir)
• Brake warn in
• Brake warning indicator
• C250
• C251
• Daytime running lamps (drl) module (front left side of lower radiator support)
• Diesel only
• Dimmer
• Engine compartment fuse box (left side of engine compartment, on top of front wheelwell)
• Engine controls system
• Flash-to- pass
• Fuse 17 10a
• Fuse 19
• Fuse 3 30a
• Fuse 5 15a
• Fuse panel (behind lower left side of i/p, left of steering column)
• G101 (right front of engine compartment, on fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G200 (behind bottom of left cowl panel)
• G200 (behind bottom of left kick panel)
• Gnd
• Head
• Hi beam indicator
• Hi headlamp
• High beam ind
• Hot at all times
• Hot in run
• Hot in start or run
• Ignition switch
• Instrument cluster
• Instrument cluster system
• Left headlamp
• Lo headlamp
• Lock
• Main light switch
• Multi- function switch
• Off
• Park
• Park brake sw in
• Park brake switch (behind left side of i/p, top of park brake pedal)
• Pass
• Power (hot in run)
• Right headlamp
• Run
• S100
• S102
• S103
• S105
• S115
• S140
• S155 (eng control sensor harn, near left front of eng compartment)
• S202
• S215
• Start

Headlight Wiring Diagram, without DRL for Ford F-Super Duty 1997

List of elements for Headlight Wiring Diagram, without DRL for Ford F-Super Duty 1997:

• (eng control sensor harn, near left headlamp breakout)
• 22.5 a c.b.
• C250
• Dimmer
• Engine compartment fuse box (left side of engine compartment, on top of front wheelwell)
• Flash-to -pass
• Fuse 19 40a
• Fuse 3 30a
• G101 (right front of engine compartment, on fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G200 (behind bottom of right cowl panel)
• Head
• Hi beam indicator
• Hot at all times
• Instrument cluster
• Left headlamp
• Main light switch
• Multi- function switch
• Off
• Park
• Pass
• Right headlamp
• S100
• S103
• S115
• S154
• S155 (eng control sensor harn, near left front of eng compartment)
• S202

HORN

Horn Wiring Diagram for Ford F-Super Duty 1997

List of elements for Horn Wiring Diagram for Ford F-Super Duty 1997:

• C219
• C242
• Engine compt relay box (eng compt, left inner fender panel)
• Fuse 30a
• High pitch horn (right front of engine compt, below headlamp)
• Horn relay
• Horn switch
• Hot at all times
• Low pitch horn (right front of engine compt, below headlamp)
• Nca
• Remote keyless entry module (behind left side of dash)
• Return
• S115
• S208 (main harness, near breakout to remote keyless entry module)
• Speed control servo/amplifier assembly (left side of engine compartment, near master cylinder)
• Speed control switch c216
• Speed control/ horn switch assembly

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram (1 of 2) for Ford F-Super Duty 1997

List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Ford F-Super Duty 1997:

• (behind bottom of right kick panel)
• (behind lower
• (left front of engine compt, on upper radiator support)
• 20 ohms
• 4x4 ind.
• 500 ohms
• A10
• A11
• A12
• A13
• A14
• Acc
• Anti-lock brake ind.
• B10
• B11
• B13
• Bat
• Brake fluid level
• Brake warning ind.
• C250 conn a
• C251 conn b
• C252 conn c
• Center of dash)
• Charge ind.
• Check engine ind.
• Chime module
• Coolant temp. gauge
• Diesel
• Diesel only
• Diesel warning lamps display
• Enable psom programming connector (below glove compt)
• Engine controls
• Engine warning ind.
• Except diesel
• Exterior lights system (multi-function switch)
• Fasten seat belt ind.
• Fuel gauge
• Fuel water switch (right side of engine, on bottom of fuel filter/heater)
• Fuse 10a
• Fuse 15a
• Fuse 4a
• Fuse panel
• G108
• G200 (behind bottom of left kick panel)
• G203
• Gas
• Gas only
• Generator/ voltage regulator
• Gnd
• Headlights system (multi-function switch)
• Hi beam ind.
• Hot at all times
• Hot in run
• Hot in run or start
• Hot w/ light sw in head or park
• Ign (run)
• Ignition switch
• Illumination lamps
• Instrument cluster
• Left turn ind.
• Lock
• Low range ind.
• Off
• Oil press. gauge
• Overheat warning switch (left front of engine)
• Plugged fuel filter ind.
• Plugged fuel filter switch (right side of engine, in fuel filter/heater housing)
• Powertrain control module (left side of firewall)
• Programmable speedometer/ odometer module
• Red
• Red/pnk
• Right turn ind.
• Run
• S102
• S117
• S202
• S206
• S214
• S215
• S216
• S218
• S242
• S246 (main harn, near b/o to spd ctrl amp)
• Solid state
• Speed control servo/ amplifier assembly (near brake master cylinder)
• Start
• Tachometer
• Test
• Volt- meter
• Vss input
• Vss output
• Vss return
• Wait-to-start ind.
• Warning
• Water-in- fuel ind.
• Water-in- fuel sensor (right side of engine, near fuel filter)

Instrument Cluster Wiring Diagram (2 of 2) for Ford F-Super Duty 1997

List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Ford F-Super Duty 1997:

• (below right center of
• (below right rear of
• (left rear of engine
• 4x2
• 4x4
• 4x4 hi/low indicator switch (below vehicle, on front of transfer case)
• Brake fluid level switch (left rear of engine compt, on brake fluid reservoir)
• Compt, on bracket)
• Daytime running lamps module (on radiator support)
• Diesel
• Diesel only
• Engine coolant temperature sender (top left front of engine)
• Engine oil pressure switch (5.8l-lower left front of engine, near oil filter) (7.3l & 7.5l-top center rear of engine)
• Front
• Front tank fuel gauge sender
• Front tank fuel pump/ fuel gauge sender (below right center of vehicle, in front fuel tank)
• Fuel tank selector switch
• Fuel tank selector valve (under left center of vehicle, on left frame rail)
• Fuse 6 15a
• Fuse panel
• G108 (left front of engine compartment, on upper radiator support)
• G200 (bottom of left kick panel)
• Gas
• Gasoline
• Hot in acc or run
• Ignition coil (left rear of engine, near intake manifold)
• Ignition control module (left side of inner fender panel)
• Link connector
• Low
• Low vacuum warning switch (diesel only) (left side of engine compt, behind battery)
• Nca
• Only
• Park brake switch
• Power- train control module (left side of firewall)
• Powertrain control module (left side of firewall)
• Powertrain control module (left side of firewall)
• Rabs data
• Rear
• Rear anti-lock brake module (behind glove box)
• Rear axle speed sensor (on axle assembly)
• Rear tank fuel gauge sender
• Rear tank fuel pump/ fuel gauge sender (below right rear of vehicle, in rear fuel tank)
• Red
• Red/
• Red/ pnk
• Red/pnk
• S140
• S171 (engine harn, near distributor)
• S174 (engine harn, near brake resistor/diode assembly)
• S202
• S205
• S229
• S244 (main harn, center of dash)
• S247 (main harn, left rear of eng compt)
• S248 (main harn, left rear of eng compt)
• S400
• Solid state
• Vehicle, in front fuel tank)
• Vehicle, in rear fuel tank)
• W/ drl
• W/o drl

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram, with Keyless Entry for Ford F-Super Duty 1997

List of elements for Courtesy Lamps Wiring Diagram, with Keyless Entry for Ford F-Super Duty 1997:

• (crew-cab)
• (interior lamp feed harn, near front tank fuel gauge sender breakout) s324
• (interior lp feed harn, near cargo lamp breakout) s322
• (main harn, in remote keyless entry module breakout) s212
• C240
• C241
• C242
• Crew cab only
• Dome
• Engine compartment lamp
• Front map lamps
• Fuse 15a
• Fuse panel
• G108 (left front of engine compt, on upper radiator support)
• G200 (behind bottom of left kick panel)
• Glove compartment lamp
• Hot at all times
• Left front courtesy lamp switch (on front of door jamb)
• Left front door courtesy lamp
• Left rear courtesy lamp switch (crew-cab) (lower rear of door)
• Left rear door courtesy lamp (crew-cab)
• Main light switch
• Mirrors system (power mirror switch)
• Outside cargo lamp
• Outside cargo/ high mount stop lamps
• Rear dome lamp (crew-cab)
• Rear map lamps
• Red/ pnk
• Remote keyless entry (rke) module (behind left side of dash)
• Right front courtesy lamp switch (on front of door jamb)
• Right front door courtesy lamp
• Right rear courtesy lamp switch (crew-cab) (lower rear of door)
• Right rear door courtesy lamp (crew-cab)
• S102
• S203
• S214
• S221 (right seat belt retractor switch harn, near left kick panel)
• S251
• S299 (main harn, near right front courtesy lamp switch breakout)
• S305 (right seat belt retractor switch harn, near base of left "b" pillar)
• S309
• S315 (main harn, near remote keyless entry module breakout)
• S316 (seat belt ret switch harn, near seat belt ret switch breakout)
• S317 (interior lamp feed harn, near cargo lamp breakout)
• S323
• S500
• S602
• Warning system (warning chime module)

Courtesy Lamps Wiring Diagram, without Keyless Entry for Ford F-Super Duty 1997

List of elements for Courtesy Lamps Wiring Diagram, without Keyless Entry for Ford F-Super Duty 1997:

• (crew-cab)
• (interior lamp feed harn, near right rear courtesy lamp sw breakout) s324
• Breakout)
• Crew cab only
• Crew cab w/ xlt
• Dome
• From splice s251 (diagram 1 of 1)
• Front dome lamp
• Front map lamps
• Fuse 15a
• Fuse panel
• G200 (behind bottom of left kick panel)
• Glove compartment lamp
• Hot at all times
• Left front courtesy lamp switch (on front of door jamb)
• Left front door courtesy lamp
• Left rear courtesy lamp switch (crew-cab) (lower rear of door)
• Left rear door courtesy lamp
• Main light switch
• Mirror system (power mirror switch)
• Outside cargo lamp
• Outside cargo/ high mount stop lamps
• Rear dome lamp
• Rear map lamps (crew-cab)
• Red/ pnk
• Right front courtesy lamp switch (on front of door jamb)
• Right front door courtesy lamp
• Right rear courtesy lamp switch (crew-cab) (lower rear of door)
• Right rear door courtesy lamp
• S200
• S203
• S214
• S251
• S305 (right seat belt ret switch harn, near base of left "b" pillar)
• S309
• S322 (interior lamp feed harn, near cargo lamp breakout)
• S323
• S500
• To map lamps (diagram 1 of 1)
• Warning system (warning chime module)

Instrument Illumination Wiring Diagram for Ford F-Super Duty 1997

List of elements for Instrument Illumination Wiring Diagram for Ford F-Super Duty 1997:

• (main harn, near radio breakout)
• (prem snd)
• (standard)
• Ashtray illumination
• Auxiliary power socket
• C211
• C250
• C265
• Cigar lighter
• Exterior lights system
• Fuse 15a
• Fuse 4a
• Fuse panel
• G200 (behind bottom of left kick panel)
• G203 (behind bottom of right kick panel)
• Gnd
• Head
• Heater control illumination
• Hot at all times
• I/p feed
• Ign
• Instrument cluster (5 bulbs)
• Main light switch
• Off
• Park
• Power distribution system (fuse panel) (fuse 11)
• Radio
• Remote keyless entry module
• S202
• S205
• S218
• Sound systems (radio)

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 3) for Ford F-Super Duty 1997

List of elements for Power Distribution Wiring Diagram (1 of 3) for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (body harness, near breakout to conn c500, left front window motor) s502
• (diesel)
• (ex. premium sound)
• (gas)
• (i/p harness, near breakout to blower motor switch) s229
• (i/p harness, near breakout to fuse panel) s211
• (i/p harness, near breakout to fuse panel) s217
• (i/p harness, near breakout to fuse panel) s242
• (i/p harness, near breakout to wiper control module) s238
• (premium sound)
• 200a generator/ voltage regulator
• A/c-heater control assembly
• Acc
• Auxiliary powertrain control connector
• C1029
• C153
• C154
• Circuit breaker 14 20a
• Clutch pedal position switch
• Diesel only
• Diesel warning lamps display
• Diesel with 200 amp generator
• Engine compartment fuse box
• Fuel tank selector switch
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 25a
• Fuse 30a
• Fuse 50a
• Fuse panel (left side of i/p)
• G200
• Generator/ voltage regulator
• Glow plug relay
• Gnd
• Heater control assembly
• Heater or a/c-heater control module
• Ign
• Ignition switch
• Instrument cluster
• Instrument cluster system
• Left battery (diesel only)
• Left side of safety wall)
• Lock
• Main light switch
• Master window/ door lock control switch
• Mega fuse 300a (diesel only)
• Off
• Programmable speedometer/ odometer module
• Radio
• Rear anti-lock brake (rabs) module
• Red
• Remote keyless entry module
• Right battery
• Right window/ door lock control switch
• Run
• S202
• Shift lock actuator
• Sta
• Start
• Starter relay
• Starter solenoid
• Starting/charging system (clutch pedal position switch)
• To engine compartment fuse box (fuse 22) (diagram 2 of 3)
• To engine compartment fuse box (fuse 5) (diagram 2 of 3)
• To engine compartment fuse box (fuse 9) (diagram 2 of 3)
• Trailer backup lamp relay
• Trailer battery charge relay
• Trailer relay box
• Trailer/ marker lamps relay
• Turn flasher
• W/ a/c
• W/ trailer tow
• W/o a/c
• Windshield wiper motor
• Wiper control module

Power Distribution Wiring Diagram (2 of 3) for Ford F-Super Duty 1997

List of elements for Power Distribution Wiring Diagram (2 of 3) for Ford F-Super Duty 1997:

• (49 states or super duty)
• (calif. ex. super duty, diesel)
• (e4od transmission)
• (engine harness, near breakout to engine compt fuse box) s105
• (engine harness, near breakout to ignition coil) s199
• (not used)
• (s5-42 zf transmission)
• 200 a generator/ voltage regulator
• Backup lamp switch
• Brake pressure switch
• C250
• C251
• Cruise control servo/amplifier assembly
• Daytime running lamp (drl) module
• Diesel only
• Diesel only (i/p harness, near breakout to conn c251, left side of i/p) s215
• Diesel warning lamps display
• Distributor
• Engine comparment fuse box
• Engine compartment fuse box
• From engine compartment fuse box (fuse 17) (diagram 1 of 3)
• From ignition b switch (diagram 1 of 3)
• From ignition switch (diagram 1 of 3)
• Fuel line heater
• Fuel pump relay
• Fuel water switch
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 3 3a
• Fuse 30a
• Fuse panel (left side of i/p)
• Gas only
• Gasoline only
• Glow plug relay
• Heated oxygen sensor (ho2s)
• Idle validation switch (diesel only)
• Ignition coil
• Ignition control module
• Injector driver module (idm) relay (diesel only)
• Instrument cluster
• Low vacuum warning switch
• Nca
• Pcm power diode
• Pcm power relay
• Power- train control module
• Radio capacitor
• Red/
• S114 (engine harness, near breakout to brake warning resistor)
• S117 (engine harness, near breakout to left headlamp)
• S128 (engine harness, in breakout to fuel line heater)
• S134 (engine harness, near breakout to back-up lamp switch)
• S134 (engine harness, near breakout to transmission range sensor)
• S148 (engine harness, near breakout to brake warning resistor)
• S206 (i/p harness, near breakout to fuse panel)
• To engine compartment fuse box (fuse 13) (diagram 3 of 3)
• Trailer battery charge relay
• Trailer relay box
• Trans- mission control switch
• Transmission range (tr) sensor
• W/ diesel engine
• W/ e40d transmission
• W/ gasoline engine
• W/ manual transmission
• Warning chime module
• With electronic shift only

Power Distribution Wiring Diagram (3 of 3) for Ford F-Super Duty 1997

List of elements for Power Distribution Wiring Diagram (3 of 3) for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (body harness, near breakout to cargo lamp) s322
• (body harness, near breakout to conn c214, left kick panel) s501
• (body harness, near breakout to conn c300, left "b" pillar)
• (diagram 2 of 3)
• (i/p harness, near breakout to fuse box) s236
• (i/p harness, near premium sound amplifier) s233
• (premium sound)
• (reg cab)
• (super cab)
• 5a * 10a **
• Auxiliary power socket
• Brake on/off (boo) switch
• Brake pressure switch
• C240
• C241
• Circuit breaker 12 20a
• Crew cab
• Data link connector
• Daytime running lamp (drl) module
• Engine compart- ment lamp
• Engine compartment fuse box
• Ex. calif. * super duty
• Exterior lights system (multi-function switch)
• From engine compartment d fuse box (fuse 16)
• Front map lamps
• Fuse
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 25a
• Fuse 30a
• Fuse 40a
• Fuse 4a
• Fuse 50a
• Fuse panel (left side of dash)
• G200
• Gasoline
• Gasoline only
• Glove compart- ment lamp
• Hazard flasher
• Horn relay
• Instrument cluster
• Interior lights system
• Interior lights system (main light switch)
• Left front courtesy lamp switch
• Left power lumbar switch
• Left power lumbar/ bolster switch
• Lighter
• Main light switch
• Master window/ door lock control switch
• Multi- function switch
• Nca
• Others **
• Power mirror switch
• Premium sound ampli- fier
• Premium sound only
• Program- mable speedo- meter/ odometer module
• Radio
• Rear anti- lock brake (rabs) module
• Rear map lamps
• Red
• Remote keyless entry module
• Remote keyless entry module
• Right front courtesy lamp switch
• Right power lumbar switch
• Right power lumbar/ bolster switch
• Right window/ door lock control switch
• S115 (engine harness, near breakout to left headlamp)
• S214 (i/p harness, near breakout to warning chime module)
• S222 (body harness, near breakout to g201)
• S237 (body harness, near breakout to brake on/off switch)
• S241
• S251 (body harness, near breakout to conn c300, left "b" pillar)
• S259 (engine harness, near breakout to conn c202, left side of safety wall)
• S307 (body harness, near breakout to power lumbar compressor motor)
• To trailer electronic brake control unit
• To trailer left turn lamps
• To trailer right turn lamps
• Trailer provision
• Trailer provisions
• W/o remote keyless entry
• W/o rke
• With captain's chair
• With cloth bench
• With power bolster
• With power lumbar seats
• With remote keyless entry
• With remote keyless entry only

POWER DOOR LOCKS

Door Lock Wiring Diagram for Ford F-Super Duty 1997

List of elements for Door Lock Wiring Diagram for Ford F-Super Duty 1997:

• (seat belt sw harn, near breakout to seat belt sw) (w/ crew cab) s312
• (window reg left door harn, near breakout to 8 pin conn, behind left kick panel)
• (window reg right door harn, near breakout to right front windw mtr)
• (window reg right door harn, near breakout to right windw ctrl sw)
• Circuit breaker 12 20a
• Fuse panel
• G200 (behind bottom of left kick panel)
• Hot at all times
• Left front door lock motor
• Left rear door lock motor
• Lock
• Master window/ door lock control switch
• Pnk/
• Right front door lock motor
• Right rear door lock motor
• Right window/ door lock control switch
• S222
• S225 (rear lamp harn, near breakout to 24 pin conn, in firewall)
• S256
• S500
• S501
• S600
• S601
• Unlock
• W/ crew cab

Keyless Entry Wiring Diagram for Ford F-Super Duty 1997

List of elements for Keyless Entry Wiring Diagram for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (behind bottom of right kick panel)
• (main harn, near break- out to enable psom prog conn, below glove compt) s303
• (window harn, near breakout to door speaker) s301
• (window harn, near breakout to door speaker) s302
• Antenna
• Battery saver input
• Battery saver output
• C240
• C241
• C242
• Circuit breaker 12 20a
• Courtesy lamps output
• Crtsy lamp sw input
• Exterior lights system
• Fuse 15a
• Fuse panel
• G200
• G200 (behind bottom of left kick panel)
• G203
• Ground
• Horn relay
• Horns system
• Hot at all times
• Hot in accy or run
• Ignition switch input
• Interior lights system
• Interior lights system (door courtesy lamp switches)
• Left front door lock motor
• Left rear door lock motor (crew cab only)
• Lock
• Lock doors output
• Lock input
• Master window/ door lock control switch
• Nca
• Park lamps output
• Power
• Program a
• Program b
• Remote keyless entry module (behind left side of dash)
• Right front door lock motor
• Right rear door lock motor (crew cab only)
• Right window/ door lock control switch
• Rke program connector (behind left side of dash)
• S205
• S214
• S216
• S223 (seat belt retrac- tor switch harn, near breakout to 8 pin conn, behind left kick panel)
• S229
• S237
• S304 (window right door harn, near breakout to right front door lock motor)
• S306 (main harn, near breakout to trailer brake controller)
• S318 (window left door harn, near breakout to 6 pin conn, behind left kick panel)
• S319 (seat belt retractor switch harn, near breakout seat belt retractor switch)
• S320 (seat belt retractor switch harn, near breakout seat belt retractor switch)
• S500
• S602
• Unlock
• Unlock doors output
• Unlock driver's door
• Unlock input
• W/crew cab

POWER MIRRORS

Power Mirror Wiring Diagram for Ford F-Super Duty 1997

List of elements for Power Mirror Wiring Diagram for Ford F-Super Duty 1997:

• Battery saver output
• Direct- ional control switch
• Fuse 15a
• G200 (behind bottom of left kick panel)
• Hot at all times
• I/p fuse panel (behind left side of dash)
• L/r motor
• Left power mirror nca
• Left/ right switch
• Nca
• Nca entry
• Power mirror switch
• Red
• Remote keyless entry module (behind left side of dash)
• Right power mirror nca
• S251
• S316
• S500
• Up/dn motor
• W/ keyless entry
• W/o keyless

POWER SEATS

Lumbar Wiring Diagram, with Captain's Chairs for Ford F-Super Duty 1997

List of elements for Lumbar Wiring Diagram, with Captain's Chairs for Ford F-Super Duty 1997:

• Circuit breaker 12 20a
• Fuse panel
• G200 (behind bottom of left kick panel)
• Hot at all times
• Left power lumbar compressor motor
• Left power lumbar switch
• Nca
• Right power lumbar compressor motor
• Right power lumbar switch
• S200
• S222

Lumbar Wiring Diagram, with Cloth Bench for Ford F-Super Duty 1997

List of elements for Lumbar Wiring Diagram, with Cloth Bench for Ford F-Super Duty 1997:

• (front seatback pad harn, near break- out to power lumbar compressor motor) s310
• Circuit breaker 12 20a
• Fuse panel
• G200 (behind bottom of left kick panel)
• Hot at all times
• Left power lumbar switch
• Nca
• Power lumbar compressor motor
• Right power lumbar switch
• S200
• S222
• S307

Lumbar/Bolster Wiring Diagram, with Captain's Chairs for Ford F-Super Duty 1997

List of elements for Lumbar/Bolster Wiring Diagram, with Captain's Chairs for Ford F-Super Duty 1997:

• Circuit breaker 12 20a
• Fuse panel
• G200 (behind bottom of left kick panel)
• Hot at all times
• Left power lumbar/ bolster compressor motor
• Left power lumbar/ bolster switch
• Nca
• Right power lumbar/ bolster compressor motor
• Right power lumbar/ bolster switch
• S226

POWER WINDOWS

Power Window Wiring Diagram, with Crew Cab for Ford F-Super Duty 1997

List of elements for Power Window Wiring Diagram, with Crew Cab for Ford F-Super Duty 1997:

• Circuit breaker 14 20a
• Fuse panel (behind left side of dash)
• G200 (behind bottom of left kick panel)
• Hot in acc or run
• Left front window
• Left front window motor
• Left rear window
• Left rear window control switch
• Left rear window motor
• Master window/ door lock control switch
• Nca
• Right front window
• Right front window motor
• Right front window/ door lock control switch
• Right rear window
• Right rear window control switch
• Right rear window motor
• S321 (seat belt retractor switch harn, near breakout to seat belt retractor switch)
• S500
• S503 (door window reg ctrl harn, near breakout to power mirror motor)
• Window lock switch

Power Window Wiring Diagram, without Crew Cab for Ford F-Super Duty 1997

List of elements for Power Window Wiring Diagram, without Crew Cab for Ford F-Super Duty 1997:

• Circuit breaker 14 20a
• Fuse panel (behind left side of dash)
• G200 (behind bottom of left kick panel)
• Hot in acc or run
• Left front window motor
• Left window
• Master window/ door lock control switch
• Nca
• Right front window motor
• Right front window/ door lock control switch
• Right window
• S500
• S502

RADIO

Base Radio for Ford F-Super Duty 1997

List of elements for Base Radio for Ford F-Super Duty 1997:

• Antenna
• C265
• C266
• Engine compartment fuse box (left side of engine compt)
• Fuse 15a
• Fuse 20a
• Fuse panel (behind left side of dash)
• Fused ignition
• G200 (bottom of left kick panel)
• G203 (bottom of right kick panel)
• Ground
• Hot at all times
• Hot in run or acc
• Illuminaton
• Interior lights system
• L front spkr (+)
• L front spkr (-)
• L rear spkr (+)
• L rear spkr (-)
• Left front door speaker
• Left rear speaker
• Nca
• Power (b+)
• R front spkr (+)
• R front spkr (-)
• R rear spkr (+)
• R rear spkr (-)
• Radio
• Right front door speaker
• Right rear speaker
• S205

Premium Sound Radio Wiring Diagram for Ford F-Super Duty 1997

List of elements for Premium Sound Radio Wiring Diagram for Ford F-Super Duty 1997:

• Antenna
• C211
• C212
• C282
• C283
• Engine compartment fuse box (left side of engine compt)
• Fuse 15a
• Fuse 20a
• Fuse panel (under left side of dash)
• Fused ignition
• G200 (bottom of left kick panel)
• G203 (bottom of right kick panel)
• Ground
• Hot at all times
• Hot in run or acc
• Illulminaton
• Interior lights system
• L front (+)
• L front (-)
• L front sig (+)
• L front sig (-)
• L rear (+)
• L rear (-)
• L rear sig (+)
• L rear sig (-)
• Left front door speaker
• Left rear speaker
• Logic mode
• Nca
• Power (b+)
• Premium sound amplifier (behind center of dash)
• R front (+)
• R front (-)
• R front sig (+)
• R front sig (-)
• R rear (+)
• R rear (-)
• R rear sig (+)
• R rear sig (-)
• Radio
• Right front door speaker
• Right rear speaker
• S205
• S233

SHIFT INTERLOCKS

Shift Interlock Wiring Diagram for Ford F-Super Duty 1997

List of elements for Shift Interlock Wiring Diagram for Ford F-Super Duty 1997:

• Brake on/off (boo) switch (on bracket, above brake pedal)
• Exterior lights system
• Fuse 13 15a
• Fuse 18 10a
• Fuse panel (behind left side of dash)
• G200 (behind bottom of left kick panel)
• Hot at all times
• Hot in run
• S202
• S236
• S240 (main harn, near breakout to clutch pedal position switch or jumper)
• S242
• Shift lock actuator (in steering column)
• Solid state

STARTING/CHARGING

5.8L

5.8L, Charging Wiring Diagram for Ford F-Super Duty 1997

List of elements for 5.8L, Charging Wiring Diagram for Ford F-Super Duty 1997:

• Acc
• Battery
• C1063
• C153
• C154
• C250
• Charge indicator
• G101 (right front of engine compt, on fender apron)
• G119 (lower right front of engine)
• Generator/ voltage regulator
• Hot at all times
• Ignition
• Instru- ment cluster
• Lock
• Off
• Ohms
• Red
• Run
• S206
• Start
• Starter relay (right front fender apron)
• Starting circuit
• Switch

Starting Wiring Diagram for Ford F-Super Duty 1997

List of elements for Starting Wiring Diagram for Ford F-Super Duty 1997:

• (gasoline) (diesel)
• A/t
• Acc
• C1012
• Clutch pedal position (ccp) switch (on bracket above clutch pedal)
• Clutch pedal position (ccp) switch jumper (taped to harness, near steering column)
• Diesel
• Engine compartment fuse box
• Ex gasoline w/ mt
• Fuse 20a
• G101 (right front fender apron)
• G101 (right front of engine compartment, on fender apron)
• G108 (on left upper radiator support)
• G110 (left front of engine)
• G119 (lower right front of engine)
• Gasoline
• Gasoline w/ mt
• Ignition switch
• Left battery
• Lock
• M/t
• Off
• Power- train control module (pcm) (left side of fire- wall)
• Red
• Right battery
• Run
• S262
• Sta
• Start
• Starter relay (front of right fender panel, behind battery)
• Starter solenoid
• Transmission range (tr) sensor (left side of transmission)

7.3L

7.3L DI Turbo Diesel, Charging Wiring Diagram for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Charging Wiring Diagram for Ford F-Super Duty 1997:

• (right front fender apron)
• (right front fender apron) starter relay
• 0hms
• Accy
• C1029
• C1063
• C165
• C250
• Charge indicator
• Engine compartment fuse box
• Fuse 50a
• G101
• G108 (on left radiator support)
• G110 (left front of engine)
• G119 (lower right front of engine)
• Generator/ voltage regulator
• Ignition switch
• Instrument cluster
• Left battery
• Lock
• Off
• Power distri- bution system
• Red
• Right battery
• Run
• S206
• S234
• Start
• Starting circuit

7.3L DI Turbo Diesel, Charging Wiring Diagram, 215 AMP for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Charging Wiring Diagram, 215 AMP for Ford F-Super Duty 1997:

• (right front fender apron)
• (right front fender apron) starter relay
• 0hms
• Accy
• C1063
• C250
• Charge indicator
• Engine compart- ment fuse box
• Fuse 15a
• Fuse 50a
• G101
• G108 (on left radiator support)
• G110 (left front of engine)
• G119 (lower right front of engine)
• Generator/ voltage regulator
• Ignition switch
• Instrument cluster
• Left battery
• Lock
• Mega fuse 300a (right front of eng)
• Off
• Power distri- bution system
• Red
• Right battery
• Run
• S206
• S234
• Start
• Starting circuit

Starting Wiring Diagram for Ford F-Super Duty 1997

List of elements for Starting Wiring Diagram for Ford F-Super Duty 1997:

• (gasoline) (diesel)
• A/t
• Acc
• C1012
• Clutch pedal position (ccp) switch (on bracket above clutch pedal)
• Clutch pedal position (ccp) switch jumper (taped to harness, near steering column)
• Diesel
• Engine compartment fuse box
• Ex gasoline w/ mt
• Fuse 20a
• G101 (right front fender apron)
• G101 (right front of engine compartment, on fender apron)
• G108 (on left upper radiator support)
• G110 (left front of engine)
• G119 (lower right front of engine)
• Gasoline
• Gasoline w/ mt
• Ignition switch
• Left battery
• Lock
• M/t
• Off
• Power- train control module (pcm) (left side of fire- wall)
• Red
• Right battery
• Run
• S262
• Sta
• Start
• Starter relay (front of right fender panel, behind battery)
• Starter solenoid
• Transmission range (tr) sensor (left side of transmission)

7.5L

7.5L, Charging Wiring Diagram for Ford F-Super Duty 1997

List of elements for 7.5L, Charging Wiring Diagram for Ford F-Super Duty 1997:

• Acc
• Battery
• C1063
• C153
• C154
• C250
• Charge indicator
• G101 (right front of engine compt, on fender apron)
• G119 (lower right front of engine)
• Generator/ voltage regulator
• Hot at all times
• Ignition
• Instru- ment cluster
• Lock
• Off
• Ohms
• Red
• Run
• S206
• Start
• Starter relay (right front fender apron)
• Starting circuit
• Switch

Starting Wiring Diagram for Ford F-Super Duty 1997

List of elements for Starting Wiring Diagram for Ford F-Super Duty 1997:

• (gasoline) (diesel)
• A/t
• Acc
• C1012
• Clutch pedal position (ccp) switch (on bracket above clutch pedal)
• Clutch pedal position (ccp) switch jumper (taped to harness, near steering column)
• Diesel
• Engine compartment fuse box
• Ex gasoline w/ mt
• Fuse 20a
• G101 (right front fender apron)
• G101 (right front of engine compartment, on fender apron)
• G108 (on left upper radiator support)
• G110 (left front of engine)
• G119 (lower right front of engine)
• Gasoline
• Gasoline w/ mt
• Ignition switch
• Left battery
• Lock
• M/t
• Off
• Power- train control module (pcm) (left side of fire- wall)
• Red
• Right battery
• Run
• S262
• Sta
• Start
• Starter relay (front of right fender panel, behind battery)
• Starter solenoid
• Transmission range (tr) sensor (left side of transmission)

TRANSMISSION

5.8L

5.8L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford F-Super Duty 1997

List of elements for 5.8L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford F-Super Duty 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range sensor)
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout to brake warn resistor/diode assembly)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to powertrain control module (pcm))
• (fuel charge harness, near breakout to canister purge solenoid) (5.8l engine) (no location available) (7.5l engine)
• (fuel charge harness, near breakout to fuel injector 4) (5.8l engine) (no location available) (7.5l engine)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier)
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Cse gnd
• Data
• E40d transmission
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender pnl)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ign
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Malfunction indicator lamp (mil)
• Manifold absolute pressure (map) sensor (right side of firewall)
• Map
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S163
• S169
• S215
• S216
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vip data link connector (left rear of engine compt, on bracket)
• Vip data link connector (partial) (left rear of engine compt, on bracket)
• Vref
• Vss gnd
• Vss input
• Vss output
• Warning chime module

5.8L, Transmission Wiring Diagram, California Except Super Duty for Ford F-Super Duty 1997

List of elements for 5.8L, Transmission Wiring Diagram, California Except Super Duty for Ford F-Super Duty 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range (tr) sensor)
• (behind bottom of right kick panel) g203
• (dash engine gauge feed harness, near breakout to throttle position sensor (tps))
• (dash engine harness, near breakout to egr control solenoid)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (left front of engine compartment, top of upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier) s246
• (right front of engine, compartment, on front of fender apron) g101
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of dash, before glove compt)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender panel)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, on front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow sensor (right front of engine compartment)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S169
• S215
• S216
• S236
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output
• Warning chime module

7.3L

7.3L DI Turbo Diesel, Transmission Wiring Diagram for Ford F-Super Duty 1997

List of elements for 7.3L DI Turbo Diesel, Transmission Wiring Diagram for Ford F-Super Duty 1997:

• (backup lamp switch to rear lamp feed harness, in break out to e40d transmission)
• (backup lamp switch to rear lamp feed harness, in breakout to tr sensor sensor)
• (engine control sensor harness, near breakout to powertrain control module (pcm)) s157
• (engine control sensor harness, near breakout to starter relay)
• (engine control sensor harness, near left headlamp)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, in breakout to throttle position sensor)
• (main harness, near breakout to speed ctrl amplifier)
• (main harness, near breakout to, harness in-line connector, behind lower center of dash)
• 49 states (or) super duty
• 4x4 ind
• Accelerator pedal sensor (ap) (under left side of dash)
• Acel pdl
• Amb
• Ap sens
• Aux data
• Auxiliary powertrain control (behind center of dash)
• Baro
• Barometric pressure (baro) sensor (at base of steering column)
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• California except super duty
• Chk eng
• Coast clutch solenoid
• Cpps
• Data link connector (behind lower right side of dash, below glove compartment)
• Diesel warning lamps display, warning chime module, fuel water switch,
• E40d transmission (below center of vehicle)
• Electronic pressure control solenoid
• Eng oil
• Engine compartment fuse box
• Engine compartment fuse box in engine compt, on left inner fender panel)
• Engine controls
• Engine oil temperature (eot) sensor (right side of engine)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front of engine compartment, on upper radiator support)
• G203 (behind bottom of right kick panel)
• Gen data
• Glow plug relay, fuel line heater
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Instrument cluster
• Intake air temperature (iat) sensor (top center of engine)
• Kapwr
• Low vacuum warning switch
• Malfunction indicator lamp (mil) "check engine light"
• Manifold absolute pressure sensor (top right side firewall)
• Map
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Pwr in
• Rabs module, hazard flasher
• Red
• S101
• S106
• S114
• S126
• S129 (pia harness, in breakout to engine coolant temp sensor)
• S143
• S146
• S163
• S164
• S215
• S216
• S235
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S241
• S243
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tft
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output

7.5L

7.5L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford F-Super Duty 1997

List of elements for 7.5L, Transmission Wiring Diagram, 49 States Or Super Duty for Ford F-Super Duty 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range sensor)
• (behind bottom of right kick panel) g203
• (engine control sensor harness, near breakout to brake warn resistor/diode assembly)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (engine control sensor harness, near breakout to powertrain control module (pcm))
• (fuel charge harness, near breakout to canister purge solenoid) (5.8l engine) (no location available) (7.5l engine)
• (fuel charge harness, near breakout to fuel injector 4) (5.8l engine) (no location available) (7.5l engine)
• (left front of engine compartment, on upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier)
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Cse gnd
• Data
• E40d transmission
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender pnl)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ign
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Malfunction indicator lamp (mil)
• Manifold absolute pressure (map) sensor (right side of firewall)
• Map
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S163
• S169
• S215
• S216
• S236
• S240 (main harness, near breakout to clutch pedal position switch or jumper)
• S246
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly (left side of engine compartment, near brake master cylinder)
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vip data link connector (left rear of engine compt, on bracket)
• Vip data link connector (partial) (left rear of engine compt, on bracket)
• Vref
• Vss gnd
• Vss input
• Vss output
• Warning chime module

7.5L, Transmission Wiring Diagram, California Except Super Duty for Ford F-Super Duty 1997

List of elements for 7.5L, Transmission Wiring Diagram, California Except Super Duty for Ford F-Super Duty 1997:

• (backup lamp switch to rear lamp feed harness, in breakout to transmission range (tr) sensor)
• (behind bottom of right kick panel) g203
• (dash engine gauge feed harness, near breakout to throttle position sensor (tps))
• (dash engine harness, near breakout to egr control solenoid)
• (engine control sensor harness, near breakout to brake warning resistor/diode assembly)
• (left front of engine compartment, top of upper radiator support) g108
• (main harness, near breakout to speed ctrl amplifier) s246
• (right front of engine, compartment, on front of fender apron) g101
• (transmission harness, near breakout to e40d transmission)
• 4x4 ind
• Boo
• Brake on/off (boo) switch (on bracket, above brake pedal)
• C250
• C251
• C252
• Ccs
• Coast clutch solenoid
• Data (+)
• Data (-)
• Data feps
• Data link connector (dlc) (partial) (behind lower right side of dash, before glove compt)
• E40d transmission (below center of vehicle)
• Ect
• Electronic pressure control solenoid
• Engine compartment fuse box
• Engine compartment fuse box (in engine compt, on left inner fender panel)
• Engine controls
• Engine coolant temperature (ect) sensor (5.8l engine - on thermostat housing) (7.5l engine - near left side of distributor)
• Epc
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 30a
• G101 (right front of engine compartment, on front of fender apron)
• G104 (rear of left fender apron)
• Gnd
• Hot at all times
• Hot in start or run
• I/p fuse panel (behind left side of dash)
• Iat
• Ignition ctrl module, radio ignition coil, distributor
• Instrument cluster
• Intake air temperature (iat) sensor (5.8l engine - near intake runner 6) (7.5l engine - behind distributor)
• Kapwr
• Maf
• Malfunction indicator lamp (mil)
• Mass air flow sensor (right front of engine compartment)
• Mil
• N d
• Nca
• Pcm power diode
• Pcm power relay
• Power
• Powertrain control module (left side of firewall)
• Psom module
• Rabs module, brake press switch
• Red
• S102
• S104
• S106
• S135
• S136
• S137
• S146
• S148
• S151
• S169
• S215
• S216
• S236
• Shift solenoid
• Sig rtn
• Speed control servo/amplifier assembly
• Ss1
• Ss2
• Tcc
• Tcil
• Tcs
• Tft
• Throttle position sensor (tps) (on throttle body)
• Torque converter clutch solenoid
• Transmission control switch
• Transmission fluid temperature sensor
• Transmission range (tr) sensor (left side of transmission)
• Vref
• Vss
• Vss gnd
• Vss input
• Vss output
• Warning chime module

WARNING SYSTEMS

Warning System Wiring Diagrams for Ford F-Super Duty 1997

List of elements for Warning System Wiring Diagrams for Ford F-Super Duty 1997:

• (behind bottom of left kick panel)
• (inside left front seat belt buckle assembly)
• C250
• Dr door open input
• Fasten seat belt indicator
• Fuse 10a
• Fuse 15a
• G200
• Ground
• Head
• Headlamps on input
• Hot at all times
• Hot in run or start
• I/p fuse panel (behind left side of dash)
• Indicator output
• Instrument cluster
• Key in ignition input
• Key warning switch
• Left front courtesy lamp switch
• Main light switch
• Nca
• Off
• Park
• Power
• Red/pnk
• Remote keyless entry module
• S200
• S202
• S213 (main harn, near warning chime module breakout)
• S215
• S251
• Seat belt buckled
• Seat belt switch
• Speed control/ horn switch assembly (in steering wheel)
• Warning chime module (behind lower center of dash)

WIPER/WASHER

Wiper/Washer Wiring Diagram for Ford F-Super Duty 1997

List of elements for Wiper/Washer Wiring Diagram for Ford F-Super Duty 1997:

• (right front of engine compt, front of fender apron) (diesel) g101
• 100k ohms
• 3.3k ohms
• 4.07k
• 7.25k
• Fuse 30a
• Fuse panel (behind left side of dash)
• G108 (gasoline) (left front of engine compt, on upper radiator support)
• G108 (left front of engine compt, on upper radiator support)
• G200 (behind bottom of left kick panel)
• Ground
• Hot in acc or run
• Int max
• Int min
• Motor (hi)
• Motor (lo)
• Motor com
• Mult-func
• Multi- function switch
• Off
• Off 36.27k ohms
• Ohms
• Park
• Park sw
• Power
• Pump motr
• Run
• S100 (diesel) s103 (gasoline)
• S102 (gasoline) s101 (diesel)
• S203
• S238
• Wash
• Windshield washer pump motor (in fluid reservoir)
• Windshield wiper motor (on left side of firewall)
• Wiper control module (above right kick panel)