All Wiring Diagrams for Ford Ranger 2005 model

AIR CONDITIONING

Heater Wiring Diagram for Ford Ranger 2005

List of elements for Heater Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (at left side of engine compt) g103
• (at right rear of engine compartment) g105
• (in dash to headlight junction harness, at breakout for c144) s108
• (in dash to headlight junction harness, near breakout for heater blower motor) s123
• (in main harness, near breakout for power point) s203
• (in main harness, near breakout for smart junction box (sjb))
• Battery junction box (bjb) (at left rear side of engine compartment)
• Blend door actuator (behind right side of dash)
• Blower motor relay
• Blower motor switch
• C2280b
• C294a
• C294b
• C294c
• C294d
• Defrost
• Floor
• Front function selector switch assembly
• Front heater blower motor resistor (right rear of engine compt, near blower motor)
• Fuse 10a
• Fuse 30a
• G205 (at left front of vehicle floor)
• Heater blower motor (right rear of engine compartment, on firewall)
• High
• Hot at all times
• Hot in run
• Illumination
• Interior lights system
• Low
• Max
• Medium high
• Medium low
• Microprocessor
• Mix
• Mode switch
• Normal
• Off
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• S108 (in dash to headlight junction harness, at breakout for c144)
• S206 (in main harness, near breakout for audio unit)
• S216
• Smart junction box (sjb) (behind right side of dash)
• Temperature control potentiometer
• Vent

Manual A/C Wiring Diagram for Ford Ranger 2005

List of elements for Manual A/C Wiring Diagram for Ford Ranger 2005:

• (3.0l: near breakout for fuel injector 6) (4.0l: near breakout for engine coolant temperature sender)
• (at breakout for c144) s108
• (at left front of vehicle floor)
• (at left side of engine compartment) g103
• (behind right side of dash) blend door actuator
• (in dash to headlight junction harness, at breakout for c144) s108
• (left front of engine compartment) g104
• (near breakout for abs control module) s110
• (near breakout for g102) s118
• (near breakout for idle air control valve) s151
• (near breakout for smart junction box (sjb))
• A/c clutch field coil (right front of engine)
• A/c clutch relay
• A/c clutch relay ctrl
• A/c clutch relay output
• A/c compressor cycling switch (at right rear of engine compartment)
• A/c demand signal
• A/c high pressure switch (at left front side of engine)
• Battery junction box (bjb) (at left rear side of engine compartment)
• Battery junction box (bjb) (at left rear side of engine compt)
• Blower motor relay
• Blower motor switch
• C2280a
• C2280b
• C294a
• C294b
• C294c
• C294d
• Cooling fan relay ctrl
• Cylinder sensor input
• Cylinder-head temperature sensor (2.3l) (right side of cylinder head)
• Defrost
• Ect sensor input
• Engine controls system
• Engine coolant temperature (ect) sensor (except 2.3l) (3.0l: on top front of engine) (4.0l: on top right front of engine)
• Engine cooling fan motor (at right front of engine compt)
• Engine cooling fan relay (2.3l)
• Floor
• Front function selector switch assembly
• Front heater blower motor resistor (right rear of engine compt, near blower motor)
• Fuse 10a
• Fuse 20a
• Fuse 30a
• G103 (at left side of engine compt)
• G103 (left side of engine compt)
• G105 (at right rear of engine compt)
• G205
• G205 (at left front of vehicle floor)
• Heater blower motor (right rear of engine compt, on firewall)
• High
• Hot at all times
• Hot in run
• Hot in start or run
• Illumination
• Interior lights system
• Low
• Max
• Medium high
• Medium low
• Microprocessor
• Mix
• Mode switch
• Nca
• Normal
• Of engine compartment) g104
• Off
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compartment)
• Ptc 1a
• Red
• S108 (at breakout for c144)
• S113 (at breakout for battery junction box (bjb))
• S123 (near breakout for heater blower motor)
• S124 (near breakout for heater blower motor)
• S133 (4.0l) s139 (3.0l)
• S143 (breakout for pcm)
• S203 (near breakout for power point)
• S206 (in main harness, near breakout for audio unit)
• S216
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Temperature control potentiometer
• Vent

ANTI-LOCK BRAKES

Anti-lock Brakes Wiring Diagram for Ford Ranger 2005

List of elements for Anti-lock Brakes Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (at right front wheel) right front wheel speed sensor
• 4wd
• 4x4 sta
• Abs control module (on left front of engine compt)
• Abs ind
• Abs pump motor (at left front side of engine compt)
• Battery junction box (bjb) (at left rear side of engine compartment)
• Brake fluid level switch (at left rear of engine compartment, brake fluid reservoir)
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220b
• C2280b
• Computer data lines system
• Fuse 10a
• Fuse 17 40a
• Fuse 33 30a
• Fuse 5a
• G102 (at left side of engine compt)
• G103 (at left side of engine compartment)
• Ground
• Hot at all times
• Hot in run
• Instrument cluster
• Iso
• Left front wheel speed sensor (at left front wheel)
• Low brake fluid level/ park brake
• Nca
• Pwr
• Rear axle speed sensor (top of rear differential)
• Red
• Red red
• Red/pnk
• S110
• S117 (in dash to headlight junction harness, near breakout for abs control module)
• S221
• Smart junction box (sjb) (behind right side of dash)
• Vbatt
• Vpwr

ANTI-THEFT

Anti-theft Wiring Diagram for Ford Ranger 2005

List of elements for Anti-theft Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor)
• C2280a
• C2280b
• C2280c
• C2280d
• Data link connector (dlc) (at bottom of steering column)
• Door lock/
• Driver door unlock relay
• Driver side door lock switch
• Driver side rear door ajar switch (4 door) (at bottom rear of left rear door)
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• G200 (at left kick panel)
• G204 (under front of center console)
• G205
• G205 (at left front of vehicle floor)
• Horn relay
• Horns system
• Hot at all times
• Instrument cluster system
• Interior lights system
• Left front door ajar switch (at rear of left front door)
• Left front door lock actuator (w/ power equipment: at rear of left front door)
• Lock
• Low current board
• Main light switch
• Park lamp relay
• Passenger side door lock switch
• Passenger side rear door ajar switch (4 door) (at bottom rear right rear door)
• Red
• Right front door ajar switch (at rear of right front door)
• Right front door lock actuator (w/ power equipment: at rear of right front door)
• S203
• S209
• S234 (in main harness, near breakout for audio unit)
• S409
• S410 (w/ 4 door) (in interior light harness, near breakout for c710)
• S501
• S600
• S600 (w/ power equipment)
• Smart junction box (sjb) (behind right side of dash)
• Unlock
• Unlock relay

BODY CONTROL MODULES

Body Control Modules Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for Body Control Modules Wiring Diagram (1 of 2) for Ford Ranger 2005:

• Acc
• Air conditioning & transmissions systems
• Air conditioning system
• Anti-lock brakes & shift interlock systems
• Battery junction box (bjb) (at left rear side of engine compartment)
• C2280a
• C2280b
• Computer data lines system
• Cruise control system
• Door locks & anti-theft systems
• Driver door lock output
• Emer warning flasher
• Engine controls system
• Exterior lights system
• Fuse 40a
• Fuse 50a
• Headlights system
• High beam indicator feed
• Horn relay switch
• Horns system
• Hot at all times
• Hot with high beams on
• Ignition switch
• Instrument cluster & transmissions systems
• Instrument cluster system
• Interior lamp relay
• Interior lamp/batt relay
• Interior lights system
• L headlamp fused feed
• Lock
• Mirrors system
• Off
• On off
• Pass door lock output
• Power distribution system
• Power exterior lamps
• R headlamp fused feed
• Red
• Smart junction box (sjb) (behind right side of dash)
• Sound systems
• Start
• Starting/charging system
• Tan/red
• Transmissions & exterior lights systems
• Transmissions & sound systems
• Transmissions system
• Volt in run or acc
• Volt sply at all times
• Volt sply in start
• Volt sply in start & run
• Voltage sply in start
• Windshield washer relay
• Wiper high/low relay
• Wiper run/park relay
• Wiper/washer system

Body Control Modules Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for Body Control Modules Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (under front of center console) g204
• Accessory relay out
• Anti-theft & door locks systems
• Brake indicator ctrl
• Brake pedal position sw in
• C2280c
• C2280d
• Computer data lines system
• Door ajar switch
• Door locks system
• Drv door lock sw unlock
• Drv door unlock
• Drv side door lock switch
• Engine controls system
• Exterior lights system
• Feed
• Fog lamp relay sw pwr
• G205 (at left front of vehicle floor)
• Ground
• Headlights system
• Horn relay ctrl
• Horns system
• Hot with low beams on
• Instrument cluster system
• Instrument cluster system power windows system
• Interior lights system
• Iso bus
• Lf door ajar switch
• Master window adj sw
• Park lamp relay
• Park lamp relay ctrl
• Park lamp relay out
• Parking brake switch sig
• Pass door unlock out
• Passenger door lock sw
• Power windows system
• Red
• Rf door ajar switch
• S203
• S209
• Smart junction box (sjb) (behind right side of dash)
• Sound systems
• Volt in run & acc
• Volt sply at all times
• Volt sply in start & run
• Voltage in run or acc
• Window adjust sw feed
• Window motor
• Wiper switch circuit a
• Wiper switch circuit b
• Wiper switch circuit c
• Wiper switch circuit high
• Wiper switch circuit washer
• Wiper/washer system

COMPUTER DATA LINES

Computer Data Lines Wiring Diagram for Ford Ranger 2005

List of elements for Computer Data Lines Wiring Diagram for Ford Ranger 2005:

• Abs control module (on left front of engine compt)
• C220b
• C2280b
• C2280d
• C281a
• Can+
• Can-
• Data link connector (dlc) (at bottom of steering column)
• Feps
• Four-wheel drive control module (behind left center of dash)
• Fuse 29 20a
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Hot at all times
• Instrument cluster
• Iso
• Low current board
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Restraints control module (under front of center console)
• S208 (in main harness, near breakout for audio unit)
• S209
• S236
• Scp +
• Scp -
• Smart junction box (sjb) (behind right side of dash)

COOLING FAN

2.3L

2.3L, Cooling Fan Wiring Diagram for Ford Ranger 2005

List of elements for 2.3L, Cooling Fan Wiring Diagram for Ford Ranger 2005:

• (at left front of engine compartment) g104
• (at left side of engine compartment) g103
• (in dash to headlight junction harness, at breakout for battery junction box (bjb))
• (in engine control sensor & fuel charge harness, near breakout for idle air control valve)
• Battery junction box (bjb) (at left rear side of engine compartment)
• C2280a
• Cylinder head temperature sensor (on right side of cylinder head)
• Engine cooling fan motor (at right front of engine compartment)
• Engine cooling fan relay
• Fuse 20a
• Fuse 30a
• Hot at all times
• Hot in start or run
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Ptc 1a
• Red
• Relay ctrl
• S108
• S113
• S118
• S151
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Vref

CRUISE CONTROL

Cruise Control Wiring Diagram for Ford Ranger 2005

List of elements for Cruise Control Wiring Diagram for Ford Ranger 2005:

• 10a
• A/t
• Air bag sliding contact (at bottom of steering column)
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C218a
• C220a
• C2280b
• C2280c
• Clutch pedal position switch (behind left side of dash, top of brake pedal support)
• Coast(-)
• Cruise ctrl ind
• Deactivator switch (at left rear of engine compt)
• Fuse 20
• Fuse 26
• Fuse 32
• Fuse 7
• G105 (at right rear of engine compartment)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Gnd
• Ground steering wheel assembly
• Harness, near breakout for smart junction box (sjb))
• Head
• Horns system
• Hot at all times
• Hot in run
• Hot in start or run
• Illumination
• In put
• Instrument cluster
• Interior lights system
• M/t
• Main light switch
• Micro- processor
• Off
• Park
• Powertrain control module (pcm) (right rear of engine compartment, through firewall)
• Rest
• Resume
• S116 (in dash to headlight junction harness, near breakout for g102)
• S123
• S209
• S236
• Set(+)
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Speed control servo (in right rear of engine compartment)
• Speed control indicator
• Speed control on/off switch
• Speed control set/ resume switch
• Vpwr
• Vref
• Vss

ENGINE PERFORMANCE

2.3L

2.3L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005

List of elements for 2.3L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005:

• (at bottom of steering column)
• (at breakout for powertrain control module)
• (left front of engine compt)
• (right rear of engine compt, through firewall) powertrain control module (pcm)
• A/c demand sig
• Act sens in
• Air conditioning system
• Battery junction box (bjb) (left rear side of engine compt)
• Ccs
• Ckp sens +
• Ckp sens -
• Cool fan rly
• Cooling fans system
• Crankshaft position (ckp) sensor (on lower right front of engine)
• Data link connector (dlc)
• Digital transmission range (dtr) sensor (left side of transmission)
• Fail safe cool in
• Fuel pump rly
• Fuel pump/gauge
• Fuse 11 30a
• G104
• G106 (at top rear of engine compt)
• Gnd
• Ho2s 11 in
• Hot at all times
• Hot in run or start
• Ignition coil
• Ignition coil (on top right side of engine)
• Ignition transformer capacitor
• Knock sens
• Knock sensor (at left front of engine)
• Maf sig
• Mil
• Mod prog sig
• Nca
• Pcm power diode
• Pcm power relay
• Psp sw
• Ptc 1a
• Red
• S107
• S118
• S145
• S147
• Scp bus+
• Scp bus-
• Sensor tr1
• Sensor tr2
• Sensor tr4
• Shift sol a
• Shift sol b
• Smart junction box (sjb) (behind right side of dash)
• Spark plugs
• Start rly cntl
• Starting/charging system
• Tachometer
• Tft sens in
• Trans cntl sw
• Tss

2.3L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005

List of elements for 2.3L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005:

• (in dash to headlight junction harness, at breakout for battery junction box) s113
• (in dash to headlight junction harness, at breakout for c144)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for swirl control monitor)
• (in engine control sensor & fuel charge harness, near breakout for transmission) s152
• A/c clutch relay
• A/t
• Battery junction box (bjb) (left rear side of engine compt)
• Clutch pedal position (cpp) switch (behind left side of dash, top of brake pedal support)
• Cooling fans system (engine cooling fan relay)
• Cylinder head temperature (cht) sensor (right side of cylinder head)
• Evap canister purge valve (in left front of engine compt)
• Fuel pump relay
• Fuse 23 20a
• Fuse 41 15a
• Hot at all times
• Intermediate shaft speed (iss) sensor (a/t) (left side of transmission)
• M/t
• Manifold absolute pressure (map) sensor (at top of engine)
• Output shaft speed (oss) sensor (left rear of transmission)
• Power steering pressure (psp) switch (left front of engine)
• Red
• S111
• S137
• S143
• S151 (in engine control sensor & fuel charge harness, near breakout for idle air control valve)
• Throttle position (tp) sensor (top right side of engine, on throttle body)

2.3L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005

List of elements for 2.3L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005:

• (at left side of engine compt) g103
• (in dash to headlight junction harness, near breakout for p93)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for swirl control solenoid valve)
• (in main harness, near breakout for instrument cluster) s213
• (under front of center console) g204
• A/t
• C220a
• C220b
• C281b
• Check fuel cap ind
• Egr stepper motor (on rear of engine)
• Evap emissions canister vent valve (at fuel tank)
• Fail- safe cool ind
• Four-wheel drive control module (behind left center of dash)
• Fuel injectors (at top left side of engine)
• Fuel lev sig
• Fuel tank pressure transducer sensor (at fuel tank assembly)
• Fuel tank unit (in fuel tank assembly)
• Fuse 10a
• Hot in run
• Inertia fuel shut-off (ifs) switch (in right kick panel)
• Instrument cluster
• M/t
• Malfunction indicator lamp (mil)
• Microprocessor
• Nca
• O/d off ind
• Red
• Red/pnk
• S125
• S148
• S149 (in engine control red sensor & fuel charge harness, near breakout for fuel injector 4)
• S150
• S153
• S215
• S237
• S405
• Smart junction box (sjb) (behind right side of dash)
• Speed control servo (in right rear of engine compt)
• Tach sig
• Tan
• Tan/red
• Transmission control switch (on steering column)

2.3L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005

List of elements for 2.3L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005:

• (a/t)
• (at left front of vehicle floor) g205
• (b+) power
• (behind left side of dash, on brake pedal support) brake pedal position switch (bpp)
• (m/t)
• (near breakout for transmission)
• 5r44e transmission control solenoids (at left side of transmission)
• A/c clutch rly
• Air conditioning system
• Battery junction box (bjb) (at left rear side of engine compartment)
• Bpp sw
• C2280b
• Camshaft position (cmp) sensor (on rear of engine)
• Canister vent
• Check cap ind
• Cht sensor
• Cmp sens in
• Egr step motor
• Electronic pressure control (epc) solenoid
• Epc sol
• Evap purge
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel pump rly
• Fuel tank press
• Fuse 21 10a
• Fuse 5a
• G104 (at left front of engine compt)
• Gnd
• Heated oxygen sensor (ho2s) 11 (in rear of engine compt, in exhaust)
• Heated oxygen sensor (ho2s) 12 (near right rear of transmission, in exhaust)
• Ho2s 11 heater
• Ho2s 11 in
• Ho2s 12 heater
• Hot at all times
• Iac valve
• Idle air control (iac) valve (on top right of engine)
• Iss sens
• Knock sensor
• M/t
• Maf sensor
• Map sens
• Mass air flow (maf) sensor (right side of engine compt, within air cleaner assembly)
• Oss sensor
• Pcm rly power
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Red
• Red/pnk
• Ref voltage
• S107
• S117 (in dash to headlight junction harness, near breakout for abs control module)
• S154
• S236
• Shift sol c
• Shift solenoids
• Sig return
• Smart junction box (sjb) (behind right side of dash)
• Tan
• Tan/red
• Tcc sol
• Tcil
• Torque converter clutch (tcc) solenoid
• Tps in
• Tr sensor
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed sensor (tss)
• Vss +

3.0L

3.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005

List of elements for 3.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005:

• (at left front of engine compt) g104
• (ckp) sensor (+)
• (ckp) sensor (-)
• (dlc) (at bottom of steering column)
• (ect) sensor
• (ho2s) 12
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (maf) sensor rtn
• (mil)
• (pwr) ground
• (tft) sensor
• 4wd low ind
• A/c demand sig
• Act sens in
• Air conditioning system
• Battery junction box (bjb) (left rear side of engine compt)
• Connector
• Crankshaft position (ckp) sensor (on lower front of engine)
• Data link
• Digital transmission range (dtr) sensor (left side of transmission)
• Dlc bus (+)
• Dlc bus (-)
• Eprom power
• Fuel gauge
• Fuel pmp mon
• Fuse 11 30a
• G106 (at top rear of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition coil
• Ignition coil (on top right side of engine)
• Ks input
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Ptc 1a
• Red
• S107
• S118
• S145
• Sensor tr1
• Sensor tr2
• Sensor tr4
• Shift sol a
• Shift sol b
• Shift sol d
• Smart junction box (sjb) (behind right side of dash)
• Spark plugs
• Start rly cntl
• Starting/charging system
• Tachometer
• Trans ctrl (tcs)
• Tss

3.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005

List of elements for 3.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005:

• (a/t)
• (in dash to headlight junction harness, at breakout for battery junction box) s113
• (in dash to headlight junction harness, at breakout for c144)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 6)
• (m/t)
• A/c clutch relay
• A/t
• Battery junction box (bjb) (at left rear side of engine compt)
• Cooling fans system (engine cooling fan relay)
• Engine coolant temperature (ect) sensor (on top front of engine)
• Evap canister purge valve (in left front of engine compt)
• Evap emissions canister vent valve (at fuel tank)
• Fuel pump relay
• Fuse 23 20a
• Fuse 41 15a
• Hot at all times
• Intermediate shaft speed (iss) sensor (a/t) (on left side of transmission)
• Knock sensor (on right side of engine)
• M/t
• Nca
• Output shaft speed (oss) sensor (on left rear of transmission)
• Red
• S111
• S139
• S143
• Throttle position (tp) sensor (top left front of engine, on throttle body)

3.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005

List of elements for 3.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005:

• (at left side of engine compt) g103
• (in dash to headlight junction harness, near breakout for p93) s125
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 3) s101
• (in engine control sensor & fuel charge harness, near breakout for heated oxygen sensor 21)
• (in main harness, near breakout for smart junction box)
• (under front of center console) g204
• 4wd low ind
• A/t
• C220a
• C220b
• C2280b
• C281b
• Check fuel cap ind
• Four wheel drive control module (behind left center of dash)
• Fuel injectors (at top right of engine)
• Fuel lev sig
• Fuel tank pressure transducer sensor (at fuel tank assembly)
• Fuel tank unit (in fuel tank assembly)
• Fuse 10a
• Heated oxygen sensor (ho2s) 22 (at right rear of engine, in exhaust)
• Hot in run
• Inertia fuel shut-off (ifs) switch (in right kick panel)
• Instrument cluster
• M/t
• Malfunction indicator lamp (mil)
• Microprocessor
• Nca
• O/d off ind
• Red
• Red/pnk
• S104 red
• S213 (in main harness, near breakout for instrument cluster)
• S215
• S237
• S258
• S405
• Smart junction box (sjb) (behind right side of dash)
• Speed control servo (in right rear of engine compt)
• Tach sig
• Tan
• Transmission control switch (on steering column)

3.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005

List of elements for 3.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005:

• (a/t)
• (at left front of vehicle floor) g205
• (at pcm breakout)
• (b+) power
• (behind left side of dash, on brake pedal support) brake pedal position switch (bpp)
• (bpp) switch
• (cmp) sensor
• (epc) solenoid
• (evap) purge
• (evap) vent
• (ho2s) 11
• (ho2s) 11 htr
• (ho2s) 12 htr
• (ho2s) 21
• (ho2s) 21 htr
• (ho2s) 22
• (ho2s) 22 htr
• (iac) solenoid
• (m/t)
• (maf) sensor
• (near breakout for camshaft position sensor)
• (near breakout for transmission)
• (near trans breakout)
• (pcm relay) pwr
• (pwr) ground
• (tcc) solenoid
• (tcil) lp output
• (tp) sensor
• (tr) sensor
• (vss) input
• 5r44e transmission control solenoids (at left side of transmission)
• A/c cycling
• A/c relay
• A/t
• Air conditioning system
• Battery junction box (bjb) (at left rear side of engine compt)
• C2280b
• Camshaft position (cmp) sensor (on top rear of engine)
• Check cap ind
• Electronic pressure control (epc) solenoid
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pmp rly
• Fuel pressure
• Fuse 21 10a
• Fuse 5a
• G104 (at left front of engine compt)
• Heated oxygen sensor (ho2s) 11 (in right rear of engine compt, in exhaust)
• Heated oxygen sensor (ho2s) 12 (near right rear of trans- mission, in exhaust)
• Heated oxygen sensor (ho2s) 21 (in left rear of engine compt, in exhaust)
• Heated positive crankcase ventilation valve
• Hot at all times
• Idle air control (iac) valve (on top left front of engine)
• Ignition coil
• Iss sensor
• Ks 1 rtn
• M/t
• Mass air flow (maf) sensor (right side of engine compt, within air cleaner assembly)
• Nca
• Oss sensor
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Red
• Red/pnk
• Ref volt
• S100
• S106
• S107
• S117 (in dash to headlight junction harness, near breakout for abs control module)
• S129
• S141
• S145 (at top rear of engine compt) g106
• S236
• Shift sol c
• Shift solenoids
• Signal rtn
• Smart junction box (sjb) (behind right side of dash)
• Tan
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed (tss) sensor

4.0L

4.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005

List of elements for 4.0L, Engine Performance Wiring Diagram (1 of 4) for Ford Ranger 2005:

• (act) sensor
• (at bottom of steering column)
• (ckp) sensor (+)
• (ckp) sensor (-)
• (ect) sensor
• (ho2s) 12
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (left front of engine compt) g104
• (maf) sensor rtn
• (mil)
• (pwr) ground
• (tft) sensor
• (tss) sensor
• 4wd low ind
• A/c demand sig
• Air conditioning system
• Battery junction box (bjb) (left rear side of engine compt)
• Crankshaft position (ckp) sensor (on lower front of engine)
• Data link connector (dlc)
• Digital transmission range (dtr) sensor (left side of transmission)
• Dlc bus (+)
• Dlc bus (-)
• Egr valve
• Eprom power
• Fuel gauge
• Fuel pmp mon
• Fuse 11 30a
• G106 (at top rear of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition coil
• Ignition coil (on top left rear of engine)
• Knock sensor
• Nca
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Ptc 1a
• Red
• S107
• S118
• S145
• Sensor tr1
• Sensor tr2
• Sensor tr4
• Shift sol a
• Shift sol b
• Shift sol d
• Smart junction box (sjb) (behind right side of dash)
• Spark plugs
• Start rly cntl
• Starting/charging system
• Tachometer
• Trans ctrl (tcs)

4.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005

List of elements for 4.0L, Engine Performance Wiring Diagram (2 of 4) for Ford Ranger 2005:

• (a/t)
• (dash to headlight harness, at breakout for c144)
• (engine control sensor & fuel charge harness, near breakout for fuel injector 4)
• (in dash to headlight junction harness, at breakout for battery junction box) s113
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for oxygen sensor 12)
• (in engine control sensor & fuel charge harness, near breakout for trans- mission
• (m/t)
• A/c clutch relay
• Battery junction box (bjb) (at left rear side of engine compt)
• Cooling fans system (engine cooling fan relay)
• Egr pressure transducer (at top left of engine)
• Egr valve actuator (at top left of engine)
• Engine coolant temperature (ect) sensor (on top right front of engine)
• Evap canister purge valve (in left front of engine compt)
• Fuel pump relay
• Fuse 23 20a
• Fuse 41 15a
• Hot at all times
• Intermediate shaft speed (iss) sensor (a/t) (on left side of transmission)
• Knock sensor (on top center of engine)
• Nca
• Output shaft speed (oss) sensor (on left rear of transmission)
• Red
• S111
• S133 (in engine control sensor & fuel charge harness, near breakout for engine coolant temperature sender)
• S135
• S137
• S143
• S144
• Throttle position (tp) sensor (top front of engine, on throttle body)

4.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005

List of elements for 4.0L, Engine Performance Wiring Diagram (3 of 4) for Ford Ranger 2005:

• (at left side of engine compt) g103
• (dash to headlight junction harness, near breakout for g102)
• (in dash to headlight junction harness, near breakout for p93)
• (in main harness, near breakout for smart junction box)
• (main harness, s213
• (near fuel injector 3 breakout) s101
• (near ignition coil breakout) s104 red
• (under front of center console) g204
• 4wd low ind
• C220a
• C220b
• C2280b
• C281b
• Check fuel cap ind
• Evap emissions canister vent valve (at fuel tank)
• Four wheel drive control module (behind left center of dash)
• Fuel injectors
• Fuel lev sig
• Fuel tank pressure transducer sensor (at fuel tank assembly)
• Fuel tank unit (in fuel tank assembly)
• Fuse 10a
• Heated oxygen sensor (ho2s) 22 (at right rear of engine, in exhaust)
• Hot in run
• Ignition trans- former capacitor (on top center of engine)
• Inertia fuel shut-off (ifs) switch (in right kick panel)
• Instrument cluster
• Malfunction indicator lamp (mil)
• Microprocessor
• Nca
• Near breakout for instrument cluster)
• O/d off ind
• Red
• Red/pnk
• S116
• S125
• S215
• S237
• S258
• S405
• Smart junction box (sjb) (behind right side of dash)
• Speed control servo (in right rear of engine compt)
• Tach sig
• Tan
• Transmission control switch (on steering column)

4.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005

List of elements for 4.0L, Engine Performance Wiring Diagram (4 of 4) for Ford Ranger 2005:

• (at pcm breakout)
• (b+) power
• (behind left side of dash, on brake pedal support) brake pedal position switch (bpp)
• (bpp) switch
• (cmp) sensor
• (epc) solenoid
• (evap) purge
• (evap) vent
• (ho2s) 11
• (ho2s) 11 htr
• (ho2s) 12 htr
• (ho2s) 21
• (ho2s) 21 htr
• (ho2s) 22
• (ho2s) 22 htr
• (iac) solenoid
• (iss) sensor
• (left front of vehicle floor) g205
• (maf) sensor
• (near hos2 11 breakout)
• (near trans break- out)
• (oss) sensor
• (pcm relay) pwr
• (pwr) ground
• (tcc) solenoid
• (tcil) lp output
• (tp) sensor
• (tr) sensor
• (vss) input
• 5r55e transmission control solenoids (at left side of transmission)
• A/c cycling
• A/c relay
• A/t
• Air conditioning
• Battery junction box (bjb) (at left rear side of engine compartment)
• C2280b
• Camshaft position (cmp) sensor (at top left of engine)
• Check cap ind
• Egr prssr trans
• Electronic pressure control (epc) solenoid
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pmp rly
• Fuel pressure
• Fuse 21 10a
• Fuse 5a
• G104 (at left front of engine compt)
• Heated oxygen sensor (ho2s) 11 (in right rear of engine, in exhaust)
• Heated oxygen sensor (ho2s) 12 (near right rear of trans- mission, in exhaust)
• Heated oxygen sensor (ho2s) 21 (near right rear of trans- mission, in exhaust)
• Hot at all times
• Idle air control (iac) valve (on top front of engine)
• Ignition coil
• Ignition coil 4
• Knock sensor
• Mass air flow (maf) sensor (right side of engine compt, within air cleaner assembly)
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Red
• Red/pnk
• Ref volt
• S107
• S117 (dash to headlight junction harness, near breakout for abs control module)
• S129
• S140
• S141
• S236
• Shift sol c
• Shift solenoids
• Signal rtn
• Smart junction box (sjb) (behind right side of dash)
• System
• Tan
• Torque converter clutch (tcc) solenoid
• Transmission fluid temperature (tft) sensor
• Turbine shaft speed (tss) sensor

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Ford Ranger 2005

List of elements for Back-up Lamps Wiring Diagram for Ford Ranger 2005:

• (at left side of engine compartment) g103
• A/t
• C2280b
• Digital transmission range (dtr) sensor (left side of transmission)
• Fuse 10a
• Hot in run
• Left reversing lamp
• M/t
• Reversing lamps switch (top left side of transmission)
• Right reversing lamp
• S237
• S406
• S408 (near breakout for right rear park/ stop/turn light)
• Smart junction box (sjb) (behind right side of dash)

Exterior Lamps Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (at left side of engine compartment) g103
• (behind left side of dash) indicator flasher relay
• (in main harness, near breakout for left side of dash) s214
• (in main harness, near breakout for smart junction box (sjb)) s211
• (in rear light con- nector harness, near breakout for c421)
• (near breakout for smart junction box (sjb)) s207
• 87a
• Battery junction box (bjb) (at left rear side of engine compt)
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C202a
• C202b
• C220a
• C220b
• C2280b
• Except stx
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 7.5a
• Hazard
• High mounted stoplamp
• Hot at all times
• Hot in run
• Instrument cluster
• Left license plate lamp
• Left rear park/stop lamp
• Left rear park/stop/ turn lamp
• Left turn
• Left turn indicator
• Microprocessor
• Multi-function switch
• Off
• Right license plate lamp
• Right rear park/ stop lamp
• Right rear park/stop/ turn lamp
• Right turn
• Right turn indicator
• S203
• S206
• S206 (except four- door model)
• S404 (in taillight harness, near breakout for c421)
• S405
• S406
• S407
• S409 (four-door model)
• S411
• Smart junction box (sjb) (behind right side of dash)
• Stx
• Trailer tow connector (at center of rear bumper)

Exterior Lamps Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (at left side of engine compt) g103
• (at right rear of engine compt) g105
• (in dash to headlight junction harness, at breakout for left front wheel speed sensor) s121
• C2280a
• C2280c
• C2280d
• Fuse 10a
• Fuse 20a
• Fuse 5a
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Head
• Hot at all times
• Interior lights system
• Left front park/turn lamp
• Left front side lamp
• Left rear turn lamp (w/ stx)
• Low current board
• Main light switch
• Off
• Park
• Park lamp relay
• Right front park/turn lamp
• Right front side lamp
• Right rear turn lamp (w/ stx)
• S119
• S123
• S162
• S163
• S209
• S236
• S406
• Smart junction box (sjb) (behind right side of dash)
• Trailer/ camper adapter circuit

Trailer Tow Wiring Diagram for Ford Ranger 2005

List of elements for Trailer Tow Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• C2280a
• C2280c
• C2280d
• Exterior lamps circuit
• Fuse 10a
• Fuse 20a
• Fuse 5a
• G103 (at left side of engine compartment)
• G204 (under front of center console)
• Head
• Hot at all times
• Interior lights system
• Low current board
• Main light switch
• Off
• Park
• Park lamp relay
• S209
• S236
• S405
• Smart junction box (sjb) (behind right side of dash)
• Trailer tow connector (at center of rear bumper)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for Ground Distribution Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (2.3l) engine cooling fan motor
• (at left rear side of engine compt) battery junction box (bjb)
• (behind right side of dash) smart junction box (sjb)
• (except stx) left rear park/stop turn lamp (stx) left rear park/stop lamp
• (except stx) right rear park/stop/ turn lamp (stx) right rear park/stop lamp
• (not used)
• (stx) left rear turn lamp
• (stx) right rear turn lamp
• A/c clutch field coil
• A/c high pressure switch
• Abs control module
• Air bag sliding contact
• Audio unit
• Battery
• Blower motor relay
• Brake fluid level switch
• C218a
• C220b
• C2280c
• C281b
• C290a
• C294c
• C2982a
• Data link connector (dlc)
• Driver side door lock switch
• Engine coolant temperature (ect) sender
• Except tremor
• Exterior rear view mirror switch
• For fuel tank unit)
• Four- wheel drive control module
• Front function selector switch assembly
• Fuel tank unit
• G100 (at left front of engine compt)
• G101 (at left rear of engine)
• G102 (at left side of engine compartment)
• G103 (at left side of engine compartment)
• G104 (at left front of engine compt)
• G200 (at left kick panel)
• G202 (at right kick panel)
• G203 (at right kick panel)
• G204 (under front of center console)
• Instrument cluster
• Junction harness, near breakout for abs control module)
• Left front door ajar switch
• Left front fog lamp
• Left front park/turn lamp
• Left front side lamp
• Left headlamp
• Left license plate lamp
• Left reversing lamp
• Low current board
• Mass air flow (maf) sensor
• Master window adjust switch
• Nca
• Parking brake switch
• Passenger air bag deactivation (pad) switch
• Pcm power relay
• Powertrain control module (pcm)
• Restraints control module
• Right license plate lamp
• Right reversing lamp
• S107 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S108 (in dash to headlight junction harness, at breakout for c144)
• S118 (in dash to headlight junction harness, near breakout for g102)
• S119 (in dash to headlight junction harness, at breakout for left front side light)
• S209 (in main harness, near breakout for steering column air bag sliding contact)
• S215
• S230 (in main harness, near breakout for audio unit)
• S406 (in rear light connector harness, near breakout for c421)
• Subwoofer amplifier
• Trailer tow connector
• W/ power equipment
• Windshield wiper motor

Ground Distribution Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for Ground Distribution Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (3.0l) heated positive crankcase ventilation valve
• (behind right side of dash) smart junction box (sjb)
• (w/ four-wheel drive) digital transmission range (dtr) sensor
• Accessory relay
• Audio unit
• Blend door actuator
• Brake pedal position switch
• Brake shift interlock
• C202a
• C2031b
• C220a
• C2280c
• C281a
• C290a
• C294b
• C3154a
• Data link connector (dlc)
• Door lock/unlock relay
• Driver door unlock relay
• Driver safety belt retractor pretensioner
• Driver side rear door ajar switch
• Fog lamp switch
• Four- wheel drive control module
• Four- wheel drive switch
• Four-door
• Front cigar lighter
• Front function selector switch assembly
• Front heater blower motor resistor
• G105 (at right rear of engine compt)
• G106 (at top rear of engine compt)
• G205 (at left front of vehicle floor)
• G300 (center of floor, behind front seats)
• High mounted stop lamp
• Horn
• Indicator flasher relay
• Instrument cluster
• Main light switch
• Multifunction switch
• Nca
• Passenger side door lock switch
• Passenger side rear door ajar switch
• Power point
• Powertrain control module (pcm)
• Radio amplifier
• Right front door ajar switch
• Right front fog lamp
• Right front park/turn lamp
• Right front side lamp
• Right headlamp
• S145 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S203 (in main harness, near breakout power point)
• S206 (in main harness, near breakout for audio unit)
• S300 (in radio speaker jumper harness, at breakout for c314)
• S409 (w/ four-door) (in interior light harness, near breakout for c710)
• S600 (w/ power equipment) (in right front door window regulator harness, near breakout for power window motor)
• Shield
• Speed control servo
• W/ power equipment
• Windshield washer pump motor

HEADLIGHTS

Headlights Wiring Diagram, with DRL for Ford Ranger 2005

List of elements for Headlights Wiring Diagram, with DRL for Ford Ranger 2005:

• (in dash to headlight junction harness, near breakout for g102) s122
• Battery junction box (bjb) (at left rear side of engine compt)
• C202b
• C220b
• C2280a
• C2280c
• Drl driver
• Flash to pass
• Fog lamp relay
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G103 (at left side of engine compt)
• G105 (at right rear of engine compt)
• G200 (at left kick panel)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Head
• High
• High beam ind
• Hot at all times
• Instrument cluster
• Interior lights system
• Left front fog lamp
• Left head- lamp
• Low
• Low current board
• Main light switch
• Microprocessor
• Multi-function switch
• Off
• Park
• Parking brake switch (below left side of dash, on park brake assembly)
• Pwr
• Right front fog lamp
• Right head- lamp
• S102
• S119
• S123
• S203
• S209
• S215
• S501
• Smart junction box (sjb) (behind right side of dash)
• Tan/orh
• Vbatt
• Vref

Headlights Wiring Diagram, without DRL for Ford Ranger 2005

List of elements for Headlights Wiring Diagram, without DRL for Ford Ranger 2005:

• (in dash to headlight junction harness, near breakout for g102) s122
• Battery junction box (bjb) (at left rear side of engine compt)
• C202b
• C220b
• C2280a
• C2280c
• Flash to pass
• Fog lamp relay
• Fog lamp switch
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G103 (at left side of engine compt)
• G105 (at right rear of engine compt)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Head
• High
• High beam ind
• Hot at all times
• Instrument cluster
• Interior lights system
• Left front fog lamp
• Left head- lamp
• Low
• Low current board
• Main light switch
• Microprocessor
• Multi-function switch
• Off
• Park
• Pwr
• Right front fog lamp
• Right head- lamp
• S119
• S123
• S203
• S209
• S215
• Smart junction box (sjb) (behind right side of dash)
• Vbatt

HORN

Horn Wiring Diagram for Ford Ranger 2005

List of elements for Horn Wiring Diagram for Ford Ranger 2005:

• Air bag sliding contact (at bottom of steering column)
• C218a
• C2280a
• C2280c
• C2280d
• Fuse 13 15a
• G105 (at right rear
• G204 (under front of center console)
• Horn (at right front of engine compt)
• Horn relay
• Horn switch
• Hot at all times
• Low current board
• Of engine compt)
• Off
• S123
• S209
• Smart junction box (sjb) (behind right side of dash)
• Speed control on/off switch

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Ford Ranger 2005

List of elements for Instrument Cluster Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (conn "a")
• (conn "b")
• (in dash to headlight junction harness, near breakout for p93)
• (in main harness, near breakout for audio unit) s234
• (in main harness, near breakout for instrument cluster)
• (under front of center console) g204
• (w/ power equipment) s600
• 2.3l
• 4wd ind
• 4wd low ind
• 4x4 status
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• Abs ind
• Air bag ind
• Anti-lock brakes system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B18
• B20
• C220a
• C220b
• C2280b
• C2280c
• C2280d
• Can +
• Can -
• Charge ind
• Check engine ind
• Check fuel cap ind
• Computer data lines system
• Cruise control system
• Door ajar ind
• Driver side rear door ajar switch (four-door model) (at bottom rear of left rear door)
• Ect sig
• Engine controls system
• Engine coolant temperature (ect) sender (2.3l: on top rear of engine) (3.0l: on front left of engine, near thermostat housing) (4.0l: on top right front of engine)
• Engine coolant temperature gauge
• Exterior lights system
• Failsafe cooling ind
• Fuel gauge
• Fuel lvl sig
• Fuel tank unit (in fuel tank assembly)
• Fuse 10a
• Fuse 5a
• G200 (at left kick panel)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Gnd
• Headlights system
• High beam ind
• Hot at all times
• Hot in start or run
• Illumination (6 bulbs)
• Instrument cluster
• Interior lights system
• Left front door ajar switch (at rear of left front door)
• Left turn signal ind
• Low brake fluid level/park brake ind
• Low current board
• Low fuel ind
• Low oil pressure ind
• Microprocessor
• O/d off ind
• Odometer/ tripmeter
• Oil pressure switch (2.3l: on left rear of cylinder head) (3.0l: on right rear of engine) (4.0l: on lower left front of engine)
• Park lmp rly out
• Parking brake switch (below left side of dash, on park brake assembly)
• Passenger side rear door ajar switch (four-door model) (at bottom rear of right rear door)
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Prndl
• Right front door ajar switch (at rear of right front door)
• Right turn signal ind
• S125
• S203
• S206 (w/o power equipment)
• S209
• S213
• S215
• S223
• S410 (four-door model) (in interior light harness, near breakout for c710)
• S501
• Safety belt ind
• Smart junction box (sjb) (behind right side of dash)
• Speed control ind
• Speedometer
• Starting/ charging system
• Tach sig
• Tachometer
• Tone sig
• Transmissions system
• Vbatt
• Vpwr
• Vref
• Vss
• Warning chime
• Warning system

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram for Ford Ranger 2005

List of elements for Courtesy Lamps Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (in main harness, near breakout for audio unit) s234
• (near breakout for c710) s410
• 4 door
• C2280b
• C2280c
• C2280d
• Driver side rear door ajar switch (at bottom rear of left rear door)
• Front interior/ map lamps assembly
• Fuse 13 15a
• G200 (at left kick panel)
• G204 (under front of center console)
• Hot at all times
• Instrument cluster system
• Instrument panel dimming module (behind left side of dash)
• Interior lamp
• Interior lamp/ battery saver relay
• Left front door ajar switch (at rear of left front door)
• Low current board
• Passenger side rear door ajar switch (at bottom rear of right rear door)
• Right front door ajar switch (at rear of right front door)
• S206 (w/o power equipment)
• S209
• S409
• S501
• S600 (w/ power equipment)
• Smart junction box (sjb) (behind right side of dash)

Instrument Illumination Wiring Diagram for Ford Ranger 2005

List of elements for Instrument Illumination Wiring Diagram for Ford Ranger 2005:

• (in main harness, near breakout for smart junction box (sjb)) s217
• Air bag sliding contact (at bottom of steering column)
• Audio unit
• C218a
• C220a
• C2280c
• C290a
• C294b
• Courtesy lamps circuit
• Dimmer
• Exterior lights system
• Fog lamp switch
• Four- wheel drive switch
• Front function selector switch assembly
• Fuse
• Fuse 1 5a
• Fuse 20a
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Ground, steering wheel assembly
• Head
• Hot at all times
• Hot in start or run
• Illumination
• Illumination (6 bulbs)
• Instrument cluster
• Instrument panel dimming module (behind left side of dash)
• Low current board
• Main light switch
• Micro- processor
• Off
• Park
• Park lamp relay
• S203
• S209
• S236
• Smart junction box (sjb) (behind right side of dash)
• Speed control on/off switch
• Speed control set/ resume switch
• Switch

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for Power Distribution Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (at left rear side of engine compartment) battery junction box (bjb)
• (behind right side of dash) smart junction box (sjb)
• (in dash to headlight junction harness, near breakout for p93) s127
• (in radio speaker jumper harness, at breakout for c314) s301
• (not used)
• A/c clutch relay
• Abs control module
• Acc
• Accessory relay
• Audio unit
• Battery
• Battery junction box (bjb) (at left rear side of engine compartment)
• Battery junction box (bjb) (at left rear side of engine compt)
• Blower motor relay
• C102a
• C197a
• C220b
• C2280a
• C2280b
• C2280c
• C281a
• C281b
• C290a
• C3154a
• Door lock/ unlock relay
• Driver door unlock relay
• Drl driver
• Engine cooling fan relay
• Exterior rear view mirror switch
• Fog lamp relay
• Four- wheel drive control module
• Four-wheel drive control module
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 20a (2.3l)
• Fuse 30a
• Fuse 40a
• Fuse 50a
• Fuse 5a
• G205 (at left front of vehicle floor)
• Generator
• Ignition switch
• Instrument cluster
• Lock
• Low current board
• Main light switch
• Multi-function switch
• Off
• Park lamp relay
• Passenger air bag deactivation (pad) switch
• Pcm power relay
• Power point
• Powertrain control module (pcm)
• Radio amplifier (tremor)
• Red
• Restraints control module
• Run
• S130 (in battery cable assembly, at breakout for fusible link a)
• S131 (in battery cable assembly, at breakout for fusible link b)
• S201 (in main harness, near breakout for center of dash)
• S203
• S223 (in main harness, near breakout for left side of dash)
• S228 (in main harness, near breakout for ignition switch)
• Smart junction box (sjb) (behind right side of dash)
• Start
• Starter motor
• Starter relay
• To fuse 17 (diagram 2 of 2)
• To fuse 22 (diagram 2 of 2)
• To fuse 27 (diagram 2 of 2)
• To fuse 33 (diagram 2 of 2)
• To ptc circuit breaker (diagram 2 of 2)
• Windshield washer relay
• Windshield wiper motor
• Wiper high/low relay
• Wiper run/park relay

Power Distribution Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for Power Distribution Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (behind right side of dash) smart junction box (sjb)
• (in main harness, near breakout for smart junction box (sjb)) s216
• (not used)
• 4x2
• 4x4
• A/t
• Abs control module
• Accessory relay
• Audio unit
• Battery junction box (bjb) (at left rear side of engine compartment)
• Blend door actuator
• Brake pedal position switch
• Brake shift interlock
• C2031a
• C2031b
• C220b
• C2280a
• C2280b
• C2280c
• C2280d
• C281a
• C290a
• C294a
• C2982a
• Clutch pedal position switch
• Data link connector (dlc)
• Deactivator switch
• Digital transmission range (dtr) sensor
• Four-wheel drive control module
• Four-wheel drive control module (m/t)
• From fuse 3 (diagram 1 of 2)
• From fuse 5 (diagram 1 of 2)
• From fuse 10 (diagram 1 of 2)
• From ignition switch (diagram 1 of 2)
• Front cigar lighter
• Front function selector switch assembly
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 2a
• Fuse 30a
• Fuse 5a
• Horn relay
• Indicator flasher relay
• Instrument cluster
• Interior lamp/battery saver relay
• Low current board
• M/t
• Nca
• Off
• Pcm power diode
• Pcm power relay
• Pnk
• Ptc circuit breaker 1a
• Red
• Reversing lamps switch
• S200 (in main harness, near breakout for center of dash)
• S203
• S221 (in main harness, near breakout for left side of engine compt)
• S231 (in main harness, near breakout for audio unit)
• S237 (in main harness, near breakout for smart junction box (sjb))
• Smart junction box (sjb) (behind right side of dash)
• Speed control servo
• Subwoofer amplifier (w/ audiophile sound system)
• Transmission control switch

POWER DOOR LOCKS

Power Door Locks Wiring Diagram for Ford Ranger 2005

List of elements for Power Door Locks Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor)
• C2280a
• C2280b
• C2280c
• C2280d
• Data link connector (dlc) (at bottom of steering column)
• Door lock/
• Driver door unlock relay
• Driver side door lock switch
• Driver side rear door ajar switch (4 door) (at bottom rear of left rear door)
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• G200 (at left kick panel)
• G204 (under front of center console)
• G205
• G205 (at left front of vehicle floor)
• Horn relay
• Horns system
• Hot at all times
• Instrument cluster system
• Interior lights system
• Left front door ajar switch (at rear of left front door)
• Left front door lock actuator (w/ power equipment: at rear of left front door)
• Lock
• Low current board
• Main light switch
• Park lamp relay
• Passenger side door lock switch
• Passenger side rear door ajar switch (4 door) (at bottom rear right rear door)
• Red
• Right front door ajar switch (at rear of right front door)
• Right front door lock actuator (w/ power equipment: at rear of right front door)
• S203
• S209
• S234 (in main harness, near breakout for audio unit)
• S409
• S410 (w/ 4 door) (in interior light harness, near breakout for c710)
• S501
• S600
• S600 (w/ power equipment)
• Smart junction box (sjb) (behind right side of dash)
• Unlock
• Unlock relay

POWER MIRRORS

Power Mirrors Wiring Diagram for Ford Ranger 2005

List of elements for Power Mirrors Wiring Diagram for Ford Ranger 2005:

• (at left kick panel) g200
• C2280b
• Down
• Exterior rear view mirror switch
• Fuse 5a
• Hot at all times
• Left
• Left exterior rear view mirror
• Left mirror
• Left/right
• Nca
• Red
• Right
• Right exterior rear view mirror
• Right mirror
• S501
• S502 (near breakout for left front speaker)
• Smart junction box (sjb) (behind right side of dash)
• Up/down

POWER WINDOWS

Power Windows Wiring Diagram for Ford Ranger 2005

List of elements for Power Windows Wiring Diagram for Ford Ranger 2005:

• (in left front door window regulator harness, near breakout for exterior rearview mirror) s500
• (w/ power equipment: at center of left front door) driver side front power window motor
• (w/ power equipment: at center of right front door)
• 11a
• Accessory relay
• C2280c
• C2280d
• Down
• Driver
• Fuse 10a
• Fuse 30a
• G200 (at left kick panel)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Hot at all times
• Hot in run or acc
• Low current board
• Master window adjust switch
• Off
• One-touch window relay
• Passenger
• Passenger side front power window motor
• Passenger side window adjust switch
• Ptc circuit breaker
• Red
• Resistor
• Rest
• S203
• S209
• S501
• Smart junction box (sjb) (behind right side of dash)

RADIO

Audiophile Sound Radio Wiring Diagram for Ford Ranger 2005

List of elements for Audiophile Sound Radio Wiring Diagram for Ford Ranger 2005:

• (+)
• (-)
• (left front of vehicle floor) g205
• Antenna
• Audio unit
• C2280b
• C2280c
• C290a
• C290b
• C2982a
• C2982b
• Enable
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• Fused ignition
• G202 (at right kick panel)
• G203 (at right kick panel)
• Gnd
• Hot at all times
• Hot in run or acc
• Hot in start
• Illumination
• Interior lights system
• L front spkr (+)
• L front spkr (-)
• L rear spkr (+)
• L rear spkr (-)
• Left front speaker
• Left rear speaker
• Nca
• R front spkr (+)
• R front spkr (-)
• R rear spkr (+)
• R rear spkr (-)
• Red
• Right front speaker
• Right rear speaker
• S200
• S203
• S230
• S231
• Sig(+)
• Sig(-)
• Smart junction box (sjb) (behind right side of dash)
• Subwoofer
• Subwoofer amplifier (in center console)
• Vbatt
• Vpwr

Base Radio Wiring Diagram for Ford Ranger 2005

List of elements for Base Radio Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• Antenna
• Audio unit
• C2280b
• C2280c
• C290a
• Fuse 10a
• Fuse 20a
• Fuse 5a
• Fused ignition
• G203 (at right kick panel)
• Ground
• Hot at all times
• Hot in run or acc
• Hot in start
• Illumination
• Interior lights system
• L front spkr (+)
• L front spkr (-)
• L rear spkr (+)
• L rear spkr (-)
• Left front speaker
• Left rear speaker
• Nca
• Power
• R front spkr (+)
• R front spkr (-)
• R rear spkr (+)
• R rear spkr (-)
• Right front speaker
• Right rear speaker
• S200
• S203
• Smart junction box (sjb) (behind right side of dash)

Tremor Audio Radio Wiring Diagram for Ford Ranger 2005

List of elements for Tremor Audio Radio Wiring Diagram for Ford Ranger 2005:

• (+)
• (-)
• (at left front of vehicle floor) g205
• Antenna
• Audio unit
• Battery junction box (bjb) (at left rear side of engine compartment)
• C2280b
• C2280c
• C290a
• C290b
• C3154a
• C3154b
• Enable
• Fuse 10a
• Fuse 20a
• Fuse 40a
• Fuse 5a
• G203 (at right kick panel)
• G300 (center of floor, behind front seats)
• Gnd
• Hot at all times
• Hot in run or acc
• Hot in start
• Illumination
• Interior lights system
• L front (+)
• L front (-)
• L front spkr (+)
• L front spkr (-)
• L rear (+)
• L rear (-)
• L rear spkr (+)
• L rear spkr (-)
• Left front speaker
• Left rear speaker
• Nca
• R front (+)
• R front (-)
• R front spkr (+)
• R front spkr (-)
• R rear (+)
• R rear (-)
• R rear audio (+)
• R rear audio (-)
• R rear spkr (+)
• R rear spkr (-)
• Radio amplifier (behind front seats)
• Right front speaker
• Right rear speaker
• S200
• S203
• S300
• S301
• Shield
• Sig(+)
• Sig(-)
• Smart junction box (sjb) (behind right side of dash)
• Subwoofer
• Vbatt
• Vpwr

SHIFT INTERLOCK

Shift Interlock Wiring Diagram for Ford Ranger 2005

List of elements for Shift Interlock Wiring Diagram for Ford Ranger 2005:

• Brake pedal position switch (behind left side of dash, on brake pedal support)
• Brake shift interlock (on steering column)
• C2280b
• Fuse 20 10a
• Fuse 32 5a
• G205 (at left front of vehicle floor)
• Hot at all times
• Hot in run
• Red
• S221
• S227 (in main harness, near breakout for smart junction box (sjb))
• S236
• Smart junction box (cjb) (behind right side of dash)

STARTING/CHARGING

Charging Wiring Diagram for Ford Ranger 2005

List of elements for Charging Wiring Diagram for Ford Ranger 2005:

• 3.0l, 4.0l
• Battery
• Battery junction box (bjb) (at left rear side of engine compt)
• C102a
• C102c
• C220a
• C220b
• C2280b
• C2280c
• Charge indicator
• Fuse 10a
• Fuse 5a
• G100 (at left front of engine compt)
• G101 (at left rear of engine)
• Generator
• Hot in run or start
• Instrument cluster
• Microprocessor
• Red
• S130
• S131
• S223
• Smart junction box (sjb) (behind right side of dash)
• Starter motor

Starting Wiring Diagram for Ford Ranger 2005

List of elements for Starting Wiring Diagram for Ford Ranger 2005:

• 2.3l except 2.3l
• A/t
• Acc
• Battery
• Battery junction box (bjb) (at left rear side of engine compt)
• C2280a
• C2280b
• Charging circuit
• Clutch pedal position switch (behind left side of dash, top of brake pedal support)
• Digital transmission range (dtr) sensor (left side of transmission)
• Fuse 40a
• Fuse 5a
• G100 (at left front of engine compt)
• G101 (at left rear of engine)
• Ignition switch
• Lock
• M/t
• Off
• Pnk
• Pnk (or tan/red)
• Powertrain control module (pcm) (right rear of engine compt through firewall)
• Red
• Run
• S228
• Smart junction box (sjb) (behind right side of dash)
• Start
• Starter motor
• Starter relay
• Tan/red

SUPPLEMENTAL RESTRAINTS

Supplemental Restraints Wiring Diagram for Ford Ranger 2005

List of elements for Supplemental Restraints Wiring Diagram for Ford Ranger 2005:

• (under front of center console) g204
• Air bag ind ctrl
• Air bag indicator
• Air bag sliding contact (at bottom of steering column)
• Air bag tone driver
• Buckled
• C218b
• C220a
• C220b
• C2280c
• Computer data lines system
• Data link connector (dlc) (at bottom of steering column)
• Dedicated ground
• Driver air bag feed
• Driver air bag return
• Driver air bag unit (in steering wheel)
• Driver safety belt feed
• Driver safety belt retractor pretensioner (at left rear of vehicle floor)
• Driver safety belt rtn
• Fuse 10a
• Fuse 5a
• G205 (at left front of vehicle floor)
• Hot in run or start
• Ignition
• Instrument cluster
• Iso bus
• Microprocessor
• Nca
• Near breakout for center of dash) s201
• Off
• Pad switch ind ctrl
• Pad switch input
• Pass air bag feed
• Pass air bag return
• Pass safety belt feed
• Pass safety belt rtn
• Passenger air bag deactivation (pad) switch
• Passenger air bag module (behind right side of dash)
• Passenger safety belt retractor pretensioner (at right rear of vehicle floor)
• Pin shorting bars engaged when module connector is disconnected from harness: (shorting bars are connected between following pins: 3-4, 6-7 & 20-21)
• Pretensioner
• Restraints control module (under front of center console)
• S206 (in main harness, near breakout for audio unit)
• S208 (in main harness, near breakout for audio unit)
• Safety belt ind
• Shorting bar
• Smart junction box (sjb) (behind right side of dash)
• Steering column air bag sliding contact)
• Tone sig
• Unbuckled
• Warning chime

TRANSMISSION

4WD Wiring Diagram for Ford Ranger 2005

List of elements for 4WD Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• (in dash to headlight junction harness, near breakout for g102)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module) g106 (at top rear of engine compt)
• (in main harness, near breakout for smart junction box) s236
• (in main harness, near breakout for instrument cluster) s213
• (in main harness, near breakout for power point)
• (in main harness, near breakout for steering column air bag sliding contact)
• (left side of transmission) digital transmission range (dtr) sensor
• 2.3l
• 4wd hi
• 4wd hi ind
• 4wd lo
• 4wd lo ind
• 4wd switch
• A/t
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp switch
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C2280a
• C2280b
• C2280c
• C281a
• C281b
• Clutch pedal position switch (behind left side of dash, top of brake pedal support)
• Computer data lines system
• Cruise control system
• Data link connector (dlc) (at bottom of steering column)
• Except 2.3l
• Four-wheel drive control module (behind left center of dash)
• Four-wheel drive switch
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Gearmotor encoder assembly (on transfer case)
• Ground
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start
• Ign (run)
• Ign (st/run)
• Illum
• Instrument cluster
• Instrument cluster system
• Interior lights system
• Interior lights system (dimmer)
• Iso bus
• M/t
• Main light switch
• Micro- processor
• Motor 1
• Motor 2
• Motor 3
• Motor 4
• Motor 5
• Neutral sens
• Off
• Park
• Pnk
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• S116
• S145
• S200 (in main harness, near breakout for center of dash)
• S203
• S208 (in main harness, near breakout for audio unit)
• S209
• S216
• S223 (in main harness, near breakout for left side of dash)
• S227
• S258 (in main harness, near breakout for smart junction box)
• Sig return
• Smart junction box (sjb) (behind right side of dash)
• Starter relay
• Tan/ red
• Tan/red
• Transfer case
• Vss input

2.3L

2.3L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for 2.3L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (dlc) (at bottom of steering column)
• (in dash to headlight junction harness, at breakout to battery junction box)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 4)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (in engine control sensor & fuel charge harness, near breakout to swirl control solenoid valve)
• 5r44e transmission control solenoids (at left side of transmission)
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Cht
• Data link connector
• Dlc
• Dlc (+)
• Dlc (-)
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Harness, near breakout for smart junction box) nca
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left side of transmission)
• Iss
• Junction box)
• Junction harness, near breakout to abs control module)
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (on left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Prndl
• Processor
• Ptc 1a
• Red
• S107
• S113
• S143
• S148
• S149
• S150
• S153
• S154
• S236 (in main harness, near breakout for smart junction box)
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

2.3L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for 2.3L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (in dash to headlight junction harness, near breakout for g102) s118
• (in engine control sensor & fuel charge harness, near breakout for idle air valve)
• (in engine control sensor & fuel charge harness, near breakout for swirl control monitor)
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (left rear side of engine compt)
• Cylinder head temperature (cht) sensor (on right side of cylinder head)
• Engine controls system
• G104 (at left front of engine compt)
• Pcm power relay
• R p
• Red
• S137
• S151
• S152 (in engine control sensor & fuel charge harness, near breakout for transmission)
• Throttle position (tp) sensor (top right side of engine, on throttle body)

3.0L

3.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for 3.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (dlc) (bottom of steering column)
• (in dash to headlight junction harness, at breakout to battery junction box)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for heated oxygen sensor 21)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (in engine control sensor & fuel charge harness, near breakout to fuel injector 3)
• (main harness, near breakout for smart junction box)
• 5r44e transmission control solenoids (at left side of transmission)
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Data link connector
• Dlc
• Dlc (+)
• Dlc (-)
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left side of transmission)
• Iss
• Junction box)
• Junction harness, near breakout to abs control module)
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (on left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compt, through firewall)
• Prndl
• Processor
• Ptc 1a
• Red
• S100
• S104
• S106
• S107
• S113
• S129 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S143
• S236
• S237 (in main harness, near breakout for smart junction box)
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

3.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for 3.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (in dash to headlight junction harness, near breakout for g102) s118
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 5)
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 6)
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (at left rear side of engine compt)
• Engine controls system
• Engine coolant temperature (ect) sensor (on top front of engine)
• G104 (at left front of engine compt)
• Pcm power relay
• R p
• Red
• S137
• S139
• Throttle position (tp) sensor (top left front of engine, on throttle body)

4.0L

4.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005

List of elements for 4.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2005:

• (dlc) (at bottom of steering column)
• (in dash to headlight junction harness, at breakout to battery junction box)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for ignition coil)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (in engine control sensor & fuel charge harness, near breakout to heated oxygen sensor 11)
• (in engine control sensor & fuel charge harness, near breakout to heated oxygen sensor 12)
• 5r55e transmission control solenoids (at left side of transmission)
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Data link connector
• Dlc
• Dlc (+)
• Dlc (-)
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Harness, near breakout for smart junction box) nca
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left rear of transmission)
• Iss
• Junction box)
• Junction harness, near breakout to abs control module)
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (on left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compart through firewall)
• Prndl
• Processor
• Ptc 1a
• Red
• S104
• S107 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S113
• S129
• S140
• S141
• S143
• S144
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

4.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005

List of elements for 4.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2005:

• (in dash to headlight junction harness, near breakout for g102) s118
• (in engine control sensor & fuel charge harness, near breakout for engine coolant temperature sender) s133
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 4)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (left rear side of engine compt)
• Engine controls system
• Engine coolant temperature (ect) sensor (on top right front of engine)
• G104 (at left front of engine compt)
• Pcm power relay
• R p
• Red
• S135
• S137
• Throttle position (tp) sensor (top front of engine, on throttle body)

WARNING SYSTEMS

Warning Systems Wiring Diagram for Ford Ranger 2005

List of elements for Warning Systems Wiring Diagram for Ford Ranger 2005:

• Air bag sliding contact (at bottom of steering column)
• C218a
• C220a
• C220b
• C2280b
• C2280c
• Can+
• Can-
• Computer data lines system
• Door ajar ind
• Driver safety belt retractor pretensioner (at left rear of vehicle floor)
• Fuse 10a
• Fuse 5a
• G200 (at left kick panel)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Ground
• Head
• Hot at all times
• Hot in start or run
• Ignition key switch
• Instrument cluster
• Interior lights system
• Left front door ajar switch (at rear of left front door)
• Low current board
• Main light switch
• Microprocessor
• Nca
• Off
• Park
• Restraints control module (under front of center console)
• S203
• S206
• S215
• S223
• S501
• Safety belt ind
• Smart junction box (sjb) (behind right side of dash)
• Sw in
• Tone sig
• Vbatt
• Vpwr
• Warning chime

WIPER/WASHER

Wiper/Washer Wiring Diagram for Ford Ranger 2005

List of elements for Wiper/Washer Wiring Diagram for Ford Ranger 2005:

• (at left front of vehicle floor) g205
• 0. off 1. high 2. low 6. wash 7. mist 21. interval 1 22. interval 2 23. interval 3 24. interval 4 25. interval 5
• Battery junction box (bjb) (at left rear side of engine compartment)
• C2280a
• Circuit breaker
• Fuse 5 30a
• G103 (at left side of engine compartment)
• G105 (at right rear of engine compartment)
• Hot in run or acc
• Multi-function switch
• Park
• Park sense
• Red
• Run
• Run/park relay control
• S109 (in dash to headlight junction harness, at breakout for c100)
• S110
• S123
• S127
• S236
• Smart junction box (sjb) (behind right side of dash)
• Tan/red
• Vref
• Washer pump relay control
• Windshield washer pump motor (right rear of engine compartment, on washer fluid reservoir)
• Windshield washer relay
• Windshield wiper motor (top left center of firewall)
• Wiper high/low relay
• Wiper high/low relay control
• Wiper run/ park relay