Diagram sections — 33 (138 total)
AIR CONDITIONING ANTI-LOCK BRAKES ANTI-THEFT BODY CONTROL MODULES COMPUTER DATA LINES COOLING FAN CRUISE CONTROL DEFOGGERS ELECTRONIC POWER STEERING ELECTRONIC SUSPENSION ENGINE PERFORMANCE EXTERIOR LIGHTS GROUND DISTRIBUTION HEADLIGHTS HORN INSTRUMENT CLUSTER INTERIOR LIGHTS MEMORY SYSTEMS NAVIGATION POWER DISTRIBUTION POWER DOOR LOCKS POWER MIRRORS POWER SEATS POWER TOP/SUNROOF POWER WINDOWS RADIO SHIFT INTERLOCK STARTING/CHARGING SUPPLEMENTAL RESTRAINTS TRANSMISSION TRUNK, TAILGATE, FUEL DOOR WARNING SYSTEMS WIPER/WASHER
AIR CONDITIONING Automatic A/C Wiring Diagram, Dual Fans (1 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (1 of 6) for Saab 9-5 Aero 2011: 42 (left center of dash) (or tan) 5-volt ref A/c compressor solenoid valve (rear of a/c compressor) A/c refrigerant pressure sensor Air quality sens sig Auxiliary heater cntl Auxiliary heater status sig Battery positive voltage Blower mtr spd ctrl Body control module (left end of dash) Computer data lines system Defogger system Duct lower air temperature sensor (mounted on hvac module) Duct upper air temperature sensor (mounted on hvac module) Electric variable displacement ctrl Electric variable displacement sply G206 Gnd Humidity sens sig Humidity temp sens sig Hvac control module (center of dash) Inside air temp sens sig J299 Linear interconnect network bus 9 Low ref Low speed gmlan serial data Lower air temp sens sig Rear blower mtr spd ctrl Rear defog rly ctrl Run relay coil cntl Run rly coil ctrl Security ind ctrl Solar sens drv sig Twilight sentinel delay sig Underhood fuse block (left side of engine compt) Upper air temp sens sig Windshield temp sens sig X108 X118 X200 X201 Automatic A/C Wiring Diagram, Dual Fans (2 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (2 of 6) for Saab 9-5 Aero 2011: 39 (2.8l) air quality sensor (engine harness, in formed conduit by throttle body) (on branch leading to remote control door lock receiver) (or 151) (or 2761) (or tan) 2.0l 2.8l 5v ref 1 A/c refrigerant press Ambient light/sunload sensor (top center of dash) Auxiliary blower motor Auxiliary blower motor control module Computer data lines system Coolant temp sens sig Engine control module (right rear of engine compt) Engine controls system Engine coolant temperature sensor (right rear of engine) Fuse 10a Fuse 5a Fuse 7.5a G109 (engine compt, on left strut tower) G201 (left kick panel) Hi spd cooling fan rly ctrl Hot at all times Hot w/ ignition main relay energized J126 (2.8l) J131 J136 J204 J318 Logic Lw spd cooling fan rly ctrl Rear body fuse block (left side of luggage compt) Sens sig Sig gnd Underhood fuse block (left side of engine compt) Windshield temperature & inside moisture sensor (top center of windshield) X200 Automatic A/C Wiring Diagram, Dual Fans (3 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (3 of 6) for Saab 9-5 Aero 2011: 31 (right side of dash) blower motor (right side of dash) blower motor control module (under driver's seat) A/c evaporator temperature sensor Auxiliary heater ctrl Auxiliary underhood fuse block Batt + volt Batt positive volt Blower mtr fan ctrl Blower mtr spd ctrl Blower mtr sply volt Computer data lines system Electrical auxiliary heater (part of hvac module) Fuse 100a Fuse 10a Fuse 50a G111 (engine compt, rearward of battery) G305 Gnd Heater status sig Hot at all times Instrument cluster Instrument panel fuse block (left end of dash) J207 J298 Left duct lower air temperature sensor (mounted on hvac module) Left duct upper air temperature sensor (mounted on hvac module) Red Right duct lower air temperature sensor (mounted on hvac module) Right duct upper air temperature sensor (mounted on hvac module) Run/crank ign 1 volt Automatic A/C Wiring Diagram, Dual Fans (4 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (4 of 6) for Saab 9-5 Aero 2011: 60 (body harness, in branch to body control module, near breakout to left front door inline) (body harness, in main bundle between breakout to left front door inline & g201) A/c request switch Air inlet door actuator Air inlet dr stepper mtr ctrl 1 Air inlet dr stepper mtr ctrl 2 Air inlet dr stepper mtr ctrl 3 Air inlet dr stepper mtr ctrl 4 Air recirculation door motor Air recirculation switch Auto switch Auxiliary mode door actuator Blower switch Defog switch Defrost switch Evap core temp sens sig Floor switch Hvac control module (center of dash) Hvac mtr sply volt Inlet dr stepper mtr ctrl 1 Inlet dr stepper mtr ctrl 2 Inlet dr stepper mtr ctrl 3 Inlet dr stepper mtr ctrl 4 J232 J233 Left air temperature door actuator Lf dr temp stepper mtr ctrl 1 Lf dr temp stepper mtr ctrl 2 Lf dr temp stepper mtr ctrl 3 Lf dr temp stepper mtr ctrl 4 Logic Lwr lf air temp sens sig Lwr rh air temp sens sig Mode door actuator Mode dr stepper mtr ctrl 1 Mode dr stepper mtr ctrl 2 Mode dr stepper mtr ctrl 3 Mode dr stepper mtr ctrl 4 Mode ind Mode switch Panel switch Pnk Radio/ hvac controls Rear mode motor sply voltage Red Rh dr temp stepper mtr pass ctrl 1 Rh dr temp stepper mtr pass ctrl 2 Rh dr temp stepper mtr pass ctrl 3 Rh dr temp stepper mtr pass ctrl 4 Right air temperature door actuator Sens low reference Temp dr stepper mtr ctrl 1 Temp dr stepper mtr ctrl 2 Temp dr stepper mtr ctrl 3 Temp dr stepper mtr ctrl 4 Tempe- rature down switch Tempe- rature up switch Upper left air temp sens sig Upper rh air temp sens sig Zone switch Automatic A/C Wiring Diagram, Dual Fans (5 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (5 of 6) for Saab 9-5 Aero 2011: 18 (not used) Cooling fan high speed relay Cooling fan low speed relay Cooling fan relay Cooling fan speed control relay Fuse 10a Fuse 30a Fuse 42 20a G109 (engine compt, on left strut tower) Hot at all times Hot w/ engine control module relay energized J115 (engine harness, between fuse block underhood & g120) J137 Left cooling fan motor (behind radiator) Underhood fuse block (left side of engine compt) X117 X119 X3 (not used) Automatic A/C Wiring Diagram, Dual Fans (6 of 6) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Dual Fans (6 of 6) for Saab 9-5 Aero 2011: 14 (engine compartment, left center of radiator support) (engine cooling harness, on branch, between main bundle & relay block- underhood) (engine cooling harness, on branch, between main bundle & relay block-underhood) Cooling fan speed control 2 relay G106 J105 (engine cooling harness, on branch, between main bundle & relay block - underhood) J106 J107 J108 Left cooling fan medium speed relay Right cooling fan medium speed relay Right cooling fan motor (behind radiator) Underhood relay block (left side of engine compt) X117 Automatic A/C Wiring Diagram, Single Fan (1 of 5) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Single Fan (1 of 5) for Saab 9-5 Aero 2011: 42 (left center of dash) (or tan) 5-volt ref A/c compressor solenoid valve (rear of a/c compressor) A/c refrigerant pressure sensor Air quality sens sig Auxiliary heater cntl Auxiliary heater status sig Battery positive voltage Blower mtr spd ctrl Body control module (left end of dash) Computer data lines system Defogger system Duct lower air temperature sensor (mounted on hvac module) Duct upper air temperature sensor (mounted on hvac module) Electric variable displacement ctrl Electric variable displacement sply G206 Gnd Humidity sens sig Humidity temp sens sig Hvac control module (center of dash) Inside air temp sens sig J299 Linear interconnect network bus 9 Low ref Low speed gmlan serial data Lower air temp sens sig Rear blower mtr spd ctrl Rear defog rly ctrl Run relay coil cntl Run rly coil ctrl Security ind ctrl Solar sens drv sig Twilight sentinel delay sig Underhood fuse block (left side of engine compt) Upper air temp sens sig Windshield temp sens sig X108 X118 X200 X201 Automatic A/C Wiring Diagram, Single Fan (2 of 5) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Single Fan (2 of 5) for Saab 9-5 Aero 2011: 37 (2.8l) air quality sensor (on branch leading to remote control door lock receiver) (or 151) (or 2761) (or tan) 2.0l 2.8l 5v ref 1 A/c refrigerant press Ambient light/sunload sensor (top center of dash) Auxiliary blower motor Auxiliary blower motor control module Computer data lines system Coolant temp sens sig Engine control module (right rear of engine compt) Engine coolant temperature sensor (right rear of engine) Engine main rly coil ctrl Fuse 10a Fuse 5a Fuse 7.5a G109 (engine compt, on left strut tower) G201 (left kick panel) Hi spd cooling fan rly ctrl Hot at all times Hot w/ ignition main relay energized J131 J136 J204 J318 Logic Lw spd cooling fan rly ctrl Rear body fuse block (left side of luggage compt) Sens sig Sig gnd Underhood fuse block (left side of engine compt) Windshield temperature & inside moisture sensor (top center of windshield) X200 Automatic A/C Wiring Diagram, Single Fan (3 of 5) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Single Fan (3 of 5) for Saab 9-5 Aero 2011: 31 (right side of dash) blower motor (right side of dash) blower motor control module (under driver's seat) A/c evaporator temperature sensor Auxiliary heater ctrl Auxiliary underhood fuse block Batt + volt Batt positive volt Blower mtr fan ctrl Blower mtr spd ctrl Blower mtr sply volt Computer data lines system Electrical auxiliary heater (part of hvac module) Fuse 100a Fuse 10a Fuse 50a G111 (engine compt, rearward of battery) G305 Gnd Heater status sig Hot at all times Instrument cluster Instrument panel fuse block (left end of dash) J207 J298 Left duct lower air temperature sensor (mounted on hvac module) Left duct upper air temperature sensor (mounted on hvac module) Red Right duct lower air temperature sensor (mounted on hvac module) Right duct upper air temperature sensor (mounted on hvac module) Run/crank ign 1 volt Automatic A/C Wiring Diagram, Single Fan (4 of 5) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Single Fan (4 of 5) for Saab 9-5 Aero 2011: 60 (body harness, in branch to body control module, near breakout to left front door inline) (body harness, in main bundle between breakout to left front door inline & g201) A/c request switch Air inlet door actuator Air inlet dr stepper mtr ctrl 1 Air inlet dr stepper mtr ctrl 2 Air inlet dr stepper mtr ctrl 3 Air inlet dr stepper mtr ctrl 4 Air recirculation door motor Air recirculation switch Auto switch Auxiliary mode door actuator Blower switch Defog switch Defrost switch Evap core temp sens sig Floor switch Hvac control module (center of dash) Hvac mtr sply volt Inlet dr stepper mtr ctrl 1 Inlet dr stepper mtr ctrl 2 Inlet dr stepper mtr ctrl 3 Inlet dr stepper mtr ctrl 4 J232 J233 Left air temperature door actuator Lf dr temp stepper mtr ctrl 1 Lf dr temp stepper mtr ctrl 2 Lf dr temp stepper mtr ctrl 3 Lf dr temp stepper mtr ctrl 4 Logic Lwr lf air temp sens sig Lwr rh air temp sens sig Mode door actuator Mode dr stepper mtr ctrl 1 Mode dr stepper mtr ctrl 2 Mode dr stepper mtr ctrl 3 Mode dr stepper mtr ctrl 4 Mode ind Mode switch Panel switch Pnk Radio/ hvac controls Rear mode motor sply voltage Red Rh dr temp stepper mtr pass ctrl 1 Rh dr temp stepper mtr pass ctrl 2 Rh dr temp stepper mtr pass ctrl 3 Rh dr temp stepper mtr pass ctrl 4 Right air temperature door actuator Sens low reference Temp dr stepper mtr ctrl 1 Temp dr stepper mtr ctrl 2 Temp dr stepper mtr ctrl 3 Temp dr stepper mtr ctrl 4 Temperature down switch Temperature up switch Upper left air temp sens sig Upper rh air temp sens sig Zone switch Automatic A/C Wiring Diagram, Single Fan (5 of 5) for Saab 9-5 Aero 2011 List of elements for Automatic A/C Wiring Diagram, Single Fan (5 of 5) for Saab 9-5 Aero 2011: 18 (engine harness, between fuse block-underhood & g120) (not used) Cooling fan high speed relay Cooling fan medium speed 1 relay Cooling fan medium speed 2 relay Cooling fan motor (behind radiator) Cooling fan relay Cooling fan speed control relay Engine control module relay Fuse 10a Fuse 60a G106 (engine compartment, left center of radiator support) G109 (engine compartment, on left strut tower) Hot at all times J115 J137 Underhood fuse block (left side of engine compt) X117
ANTI-LOCK BRAKES Anti-lock Brakes Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Anti-lock Brakes Wiring Diagram for Saab 9-5 Aero 2011: 85 (engine compartment, left center of radiator support) g110 5 volt ref Abs ind Bat pos volt Body control module (bcm) (left end of dash) Brake booster pump motor (front of right front wheelwell) Brake booster pump motor relay (2.8l) Brake booster vacuum sensor (on brake vacuum booster) Brake booster vacuum switch (on brake vacuum booster) Brake fluid level sens sig Brake fluid level switch (on brake fluid reservoir) Brake ind Brake pressure modulator valve (bpmv) Brake vacuum sens sig Combined veh inertial sens sply volt Computer data lines system Electronic brake control module (ebcm) (lower left rear of engine compt) Fuse 16 7.5a Fuse 22 50a Fuse 26 60a Fuse 41 30a G102 (engine compartment, on right strut tower) G110 (engine compt left center of radiator support) G206 (left center of dash) G304 (left kick panel) Gnd Ground Hi spd gmlan serial data + 1 Hi spd gmlan serial data + 2 Hi spd gmlan serial data - 1 Hi spd gmlan serial data - 2 Hot at all times Hot w/ ignition main relay energized Infotainment display Instrument cluster J135 J215 J221 (instrument panel harness, in main bundle in formed conduit, near center of instrument panel) J301 J335 J337 Left front wheel speed sensor (wss) (on left front wheel hub assembly) Left rear wheel speed sensor (wss) (on left rear wheel hub assembly) Lf wheel spd sens sig Lf wheel spd sens sply volt Logic Low ref Lr wheel spd sens sig Lr wheel spd sens sply volt Multi-axis acceleration sensor Pump motor control Radio Red Rf wheel spd sens sig Rf wheel spd sens sply volt Right front wheel speed sensor (wss) (on right front wheel hub assembly) Right rear wheel speed sensor (wss) (on right rear wheel hub assembly) Rr wheel spd sens sig Rr wheel spd sens sply volt Serial data + 1 hi spd gmlan Serial data - 1 hi spd gmlan Serial data communication enable Sig gnd Sport mode switch Steering wheel angle sensor (on steering column) Traction control ind Traction control switch Traction ctrl sw sig 1 Traction off ind Underhood fuse block (left side of engine compt) Vss W/ chassis continuosly variable real time damping W/ switch flexride mode sysytem W/o chassis continuosly variable real time damping W/o switch flexride mode sysytem X106 X107 X113 X114 X125 X126 X200 X202 X420 X425
ANTI-THEFT Forced Entry Wiring Diagram, with Passive Keyless Entry (1 of 3) for Saab 9-5 Aero 2011 List of elements for Forced Entry Wiring Diagram, with Passive Keyless Entry (1 of 3) for Saab 9-5 Aero 2011: 70 (behind center of rear bumper) rear fascla keyless entry antenna (center front of luggage compt) rear compartment keyless entry antenna (front of center console) center console front keyless entry antenna (left end of dash) (rear of center console) center console rear keyless entry antenna A13 Acc volt Ant 1 sig hi Ant 1 sig lo Ant 2 sig hi Ant 2 sig lo Ant 3 sig hi Ant 3 sig lo Ant sig hi Ant sig lo B13 Bat pos volt Co drv ant sig lo Co drv dr ant sig hi Co drv extr sw lk sig Co drv handle sw sig Co drv mtr unlatch rtn Co drv unlatch ctrl Computer data lines system Driver interior door handle switch Drv dr handle sw sig Drv mtr unlatch ctrl Drv mtr unlatch rtn Drv unlatch sig Exterior door handle switch Fuse 30a Fuse 5a G302 G304 G304 (right kick panel) Gnd Handle sw sig Hot at all times Instrument panel fuse block J335 J337 J341 Keyless entry control module (right kick panel) Left rear Lo ref Lo spd gmlan ser data Lr dr handle sw sig Lr mtr unlatch rtn Lr unlatch ctrl Nca Passenger interior door handle switch Passive start sw sig 2 Right rear exterior door handle switch Rr closure ant sig hi Rr dr handle sw sig Rr mtr unlatch ctrl Rr mtr unlatch rtn Run/crank ign 1 vol Shift interlock system Sig gnd Starting/ charging system Steering column lk sig Tan Underhood fuse block (left side of engine compt) X200 X299 X500 X600 X700 X800 Forced Entry Wiring Diagram, with Passive Keyless Entry (2 of 3) for Saab 9-5 Aero 2011 List of elements for Forced Entry Wiring Diagram, with Passive Keyless Entry (2 of 3) for Saab 9-5 Aero 2011: 37 (in driver's door) driver window motor (in main bundle between breakout to left front door inline & g201) j233 (in main bundle between g201 & formed conduit near left front seat) j311 (in main bundle between g201 & formed conduit near left front seat) j312 (in passenger's door) passenger window motor (left rear door harness, in main bundle between door latch assembly & breakout to window motor) j703 (left side of engine compt) underhood fuse block (right kick (right rear door harness, in main bundle between door latch assembly & breakout to window motor) j803 Door lock security relay Driver door latch assembly G109 (engine compt, on left strut tower) G201 (left kick panel) G302 G302 (right kick panel) J314 (in main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) J315 (in main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) J701 J801 Left rear door latch assembly Left rear window motor Lf dr ajar sw sig Lh rr dr ajar sw sig Panel) Passenger door latch assembly Right rear door latch assembly Sw sig rf dr ajar Tan Trunk, tailgate, fuel doors system W/ express up/down W/ theft deterent body security content W/o express down W/o theft deterent body security content X500 X600 X700 X800 Forced Entry Wiring Diagram, with Passive Keyless Entry (3 of 3) for Saab 9-5 Aero 2011 List of elements for Forced Entry Wiring Diagram, with Passive Keyless Entry (3 of 3) for Saab 9-5 Aero 2011: 62 (left end of dash) instrument panel fuse block (left kick panel) g304 Acc volt Actuator recv sig Actuator rtn Actuator sply volt Actuator transmit sig Ajar sw sig rh rr dr Bat pos volt Body control module (left end of dash) Computer data lines system Door lock security relay Dr acutator lk ctrl 2 Dr lk ctrl Dr unlk ctrl Drive exterior door handle assembly Driver door handle keyless entry antenna Driver exterior door handle switch Driver information center display Drv dr unlatch sig Fuse 5a G203 G203 (left end of dash) G304 (left kick panel) G401 (left side of luggage compt) Gmlan ser data + Gmlan ser data - Gnd Hdlp hi beam rly ctrl Headlights system Horn relay ctrl Horns system Hot all times Instrument panel cluster (ipc) J113 J220 J335 J337 J410 Lift gate ajar sw sig Lk rey ctrl Logic Lr security lk mtr sig Nca Non drv unlatch sig Passenger door handle keyless entry antenna Passenger exterior door handle assembly Passenger exterior door handle switch Rear compartment lid latch Remote control door lock receiver (above inside rearview mirror) Right rear window motor Rr security lk mtr sig Run/crank ign 1 volt Security indicator Security lk rly ctrl Tan Underhood fuse block (left side of engine compt) W/ express up/down W/o express down X200 X500 X600 Forced Entry Wiring Diagram, without Passive Keyless Entry for Saab 9-5 Aero 2011 List of elements for Forced Entry Wiring Diagram, without Passive Keyless Entry for Saab 9-5 Aero 2011: 79 (in main bundle between breakout to side impact sensor lf & formed conduit near lf seat) (in main bundle between lower grommet & breakout to speaker) j803 (left end of dash) g203 (left end of dash) instrument panel fuse block (left side of engine compt) (w/ theft deterent body security content) underhood fuse block Actr rtn Actr unlck ctrl Batt pos volt Body control module (left end of dash) Center display Child lkout ind Child lockout security ind Computer data lines system Door lock security relay Dr lck ctrl (2) Dr lk ctrl Driver Driver door latch assembly Driver window motor (in driver's door) Drv dr lk sw lk sig Drv dr lk sw unlk sig Fuse 5a G109 (engine compt, on left strut tower) G201 (left kick panel) G203 (left end of dash) G302 (right kick panel) G401 (left side of luggage compt) Gmlan ser data (+) Gmlan ser data (-) Hdlp hi beam rly ctrl Headlights system horns system Horn rly ctrl Hot at all times Information Instrument panel cluster (ipc) Instrument panel multifunction switch Interior lights system J113 J233 (in main bundle between breakout to lf door inline & g201) J311 (in main bundle between g201 & formed conduit near lf seat) J312 (in main bundle between g201 & formed conduit near lf seat) J314 (in main bundle between breakout to side impact sensor - lf & formed conduit near lf seat) J315 J410 J509 J609 J701 J801 Left rear door latch assembly Lf dr ajar sw sig Lk rly ctrl Logic Lr lk mtr status sig Passenger door latch assembly Passenger window motor (in passenger's door) Rcv sig Rear compartment lid latch Remo actr sply volt Remo actr trans sig Remo func actr rtn Remote control door lock receiver (above inside rearview mirror) Rf dr ajar sw sig Right rear door latch assembly Rr lk mtr status sig Security content Security indicator Security lk rly ctrl Security lk sw sig Sply volt Trans sig Trunk, tailgate, fuel doors system Underhood fuse block (left side of engine compt) W/ theft deterent body W/o theft deterent body X200 X500 X600 X700 X800 Immobilizer Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Immobilizer Wiring Diagram for Saab 9-5 Aero 2011: 29 (center front of engine compt) hood ajar switch 2.0l 2.8l Body control module (left end of dash) Computer data lines system Engine control module (right rear of engine compt) Fuse 30a G109 (engine compt, on left strut tower) Gmlan serial data Hood sw sig Hot at all times Hs gmlan Immobilize sply volt Immobilizer control module (under center console) Immobilizer return Immobilizer reurn Immobilizer sply volt Instrument cluster Instrument panel fuse block (left end of dash) J136 Linear interconnect Linear interconnect network 11 Lo spd serial data Logic Network 11 Security indicator Srl data+ X2 srl data- hs gmlan X210
BODY CONTROL MODULES Body Control Modules Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Body Control Modules Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 75 (engine compartment, forward of battery) g107 (left kick panel) g201 Acc pow fuse sup volt Accessory wakeup serial data Air conditioning system Anti-theft system Battery positive voltage Body control module (left end of dash) Bonn switch signal Bt lid/tail motor res ctrl Child security lock rly ctrl Computer data Computer data lines system Cruise control system Cruise/etc/tcc brake signal Current sensor signal Current sensor sply voltage Door lock ctrl 2 Door locks system Dr lck actuator unlock ctrl Dr lock actuator lock ctrl 2 Exterior Exterior lights system Exterior lights system transmissions system Fog lamp relay cont Ft winscr wip sw hi sig Fuse 20a Fuse 5a Ground Headlamp high beam rly ctrl Headlights system Hed lmp beam relay cont Hed lmp was relay cont Hi speed gmlan serial data(+) Hi speed gmlan serial data(-) Horn rly ctrl Horns system Hot at all times Instrument panel fuse block (left end of dash) Interconnect network bus 1 Interconnect network bus 2 Interconnect network bus 3 Lf turn sig lamp sply volt Liftgate ajar switch sig 1 Lights system Lines system Low reference Lr turn sig lamp sply volt Lt hdlp low beam sply volt Power distribution system Rear closure handle sw open sig Rear fog lamp ctrl Rear license lamp sply volt Rear turn lamp feedback sig Rf turn sig lp sply volt Right tail lamp sply volt Rr turn sig lp sply volt Rt hdlp low beam sply volt Run ignition 3 voltage Run/crank relay coil control Serial data comm enable Slr coil sply volt Sport mode sw sig Starting/charging system Tramis comf mod ind ctrl Tramis inte mod ind ctrl Tramis sport mod ind ctrl Transmissions system Trunk, tailgate, fuel doors system Underhood fuse block (left side of engine compartment) Windshield washer relay ctrl Windshield wiper mtr sply vol Wiper/washer system Wiser wip motpk sw sig X200
COMPUTER DATA LINES Computer Data Lines Wiring Diagram (1 of 4) for Saab 9-5 Aero 2011 List of elements for Computer Data Lines Wiring Diagram (1 of 4) for Saab 9-5 Aero 2011: 58 (body harness, in branch to body control module, near breakout to left front door inline) j232 (body harness, in main bundle between breakout to left front door inline & g201) j236 (body harness, in main bundle between breakout to left front door inline & g201) j243 (instrument panel harness, in main bundle between g201 & data link connector) j225 (instrument panel harness, in main bundle between g201 & data link connector) j226 (instrument panel harness, in main bundle near data link resistor) j202 (instrument panel harness, in main bundle near data link resistor) j203 (left end of dash) g203 A/t Acc wake-up data Body control module (left end of dash) Data link connector (dlc) (under left side of dash) Data link resistor (center of dash) Driver seat memory control module (under driver's seat) Driver window motor (in driver's door) Driver window switch Express down Express up/down Fuse 14 7.5a G206 (left center of dash) Gm lan ser data + Gm lan ser data - Hi spd gmlan Hi spd gmlan serial data bus + x2 Hi spd gmlan serial data bus - Hot at all times Instrument panel fuse block (left end of dash) Left rear window motor (in left rear doors) Left rear window switch Lin interconnect network 2 Linear intconn bus 3 Linear intconn network 9 Linear interconnect network 1 Linear interconnect network 2 Linear interconnect network 3 Linear interconnect network 3 x6 Linear interconnect network 4 Low gmlan serial data Multi-axis acceleration sensor Passenger window motor (in passenger's door) Right rear window motor (in right rear doors) Right rear window switch Security siren (if equipped) (right rear of engine compt) Serial dat comm enable Serial data (+) Serial data (-) Serial data bus + Serial data bus - Steering wheel angle sensor (on steering column) Tire pressure indicator module (if equipped) (left side of luggage compt) Transmission shift lever X108 X200 X301 X500 X600 X700 X800 Computer Data Lines Wiring Diagram (2 of 4) for Saab 9-5 Aero 2011 List of elements for Computer Data Lines Wiring Diagram (2 of 4) for Saab 9-5 Aero 2011: 49 (a/t) j117 (engine harness, between fuse block- underhood & g120) (if equipped) (instrument panel harness, in main bundle in formed conduit, near center of instrument panel) j218 (instrument panel harness, in main bundle near instrument cluster) 2.0l 2.8l A/t Accessory/ crank ign 0 volt Control solenoid valve assembly (a/t) (inside transmission) Digital radio receiver control module (if equipped) Engine control module (right rear of engine compt) Gm lan ser data + Gm lan ser data - Gm lan serial data Head up display Headlamp control module (left end of dash) High speed gmlan serial data bus + Hvac control module (center of dash) In temp sens sig Inflatable restraint sensing & diagnostic module (front of center console) Info display module Instrument cluster J217 Linear intc Lo spd gmlan serial data Low speed gm lan data Low speed gmlan data M/t Mid serial data (+) Mid serial data (-) Mid spd gmlan serial data + Mid spd gmlan serial data - Mobile telephone control module (center of dash) Multimedia player interface module (if equipped) (right end of dash) Multimedia player interface module (kta+uye/uyj) (right end of dash) Radio Radio/hvac control module Rear audio control module (if equipped) Ser data comm enable Serial data Serial data bus + Serial data bus - Steering column lock control module (on steering column) Temp sens sig Tr7 W/ digital audio system broadcast W/o digital audio system broadcast X210 Computer Data Lines Wiring Diagram (3 of 4) for Saab 9-5 Aero 2011 List of elements for Computer Data Lines Wiring Diagram (3 of 4) for Saab 9-5 Aero 2011: 49 (body harness, in branch to left rear wheel well, between breakout to keyless entry antenna & main bundle) (body harness, in main bundle between breakout to electronic brake control module & left bulkhead grommet) (body harness, in main bundle between breakout to left front door inline & g201) (body harness, in main bundle between breakout to left front door line & g201) j231 (body harness, in main bundle between g401 & breakout to left rear wheel well) (lower left rear engine compt) electronic brake control module (right side of luggage compt) (lau/lhu/llu) fuel pump control module -f45/ f46 lau/ ldk 2.0l 2.8l B11 Between g401 & breakout to left rear wheel well) Control module D9 serial data - Data comm enable F46+ f45/ ldk +lau/ Gm lan ser data Hi spd gmlan serial data (+) Hi spd gmlan serial data (-) J141 J142 J237 J238 J405 J406 J407 (body harness, in branch to left rear wheel well, between breakout to keyless entry antenna & grommet) J408 J414 K3 serial data + Lau/ ldk Lau/ldk -f45/f46 +lau/ldk Linear intc P data comm enable Parking brake Power steering control module (if equipped) (lower left side of dash) Rear differential clutch control module (if equipped) (mounted to rear differential) Ser data (+) Ser data (-) Serial data + Serial data - Serial data bus (+) Serial data bus (-) Suspension control module (if equipped) (left side of luggage compt) Telematics communication interface control module (if equipped) (center of dash) Transmission control module (top of transmission) W/ awd W/ chassis continuously variable real time damping & w/o awd X200 X408 Computer Data Lines Wiring Diagram (4 of 4) for Saab 9-5 Aero 2011 List of elements for Computer Data Lines Wiring Diagram (4 of 4) for Saab 9-5 Aero 2011: 28 C3u+utv/ce1 Ce1 Ce1-c3u+utv Driver seat heating control module (w/ front seat heater) (under driver's seat) Inside rearview mirror (control intelligent high beam) J313 (body harness, in main bundle between g305 & formed conduit near left front seat) J339 (body harness, in main bundle rearward of formed conduit near left b-pillar, near c-pillar) Keyless entry control module (right kick panel) Left side object sensor (if equipped) (behind left side of front bumper) Linear interconnect network 1 Linear interconnect network 9 Lo spd gmlan serial data Outside rearview mirror switch Parking assist control module (if equipped) (left side of luggage compt) Passenger presence detection module (if equipped) (under front passenger's seat) Passenger window switch Rain sensor (w/ windshield wiper system) Right side object sensor (behind right side of front bumper) Sunroof motor (forward of sunroof) Sunroof sunshade motor module (if equipped) (top center rear of roof) Ultrasonic intrusion sensor (in overhead console) Utv Vehicle direction camera control module (if equipped) (above headliner) X301 X307 X397 X500 X600
COOLING FAN Cooling Fan Wiring Diagram, Dual Fans (1 of 2) for Saab 9-5 Aero 2011 List of elements for Cooling Fan Wiring Diagram, Dual Fans (1 of 2) for Saab 9-5 Aero 2011: 30 (not used) (or 151) (or 2761) (or tan) 2.0l 2.8l Computer data lines system Cooling fan high speed relay Cooling fan low speed relay Cooling fan relay Cooling fan speed control relay Engine control module (right rear of engine compt) Engine controls system Engine coolant temperature sensor (right rear of engine) Fuse 10a Fuse 30a Fuse 42 20a G109 (engine compt, on left strut tower) Hi spd cooling fan rly Hot at all times Hot w/ engine control module relay energized J115 (engine harness, between fuse block- underhood & g120) J126 (2.8l) (engine harness, in formed conduit by throttle body) J137 Left cooling fan motor (behind radiator) Lw spd cooling fan rly Underhood fuse block (left side of engine compt) X117 X119 X3 (not used) Cooling Fan Wiring Diagram, Dual Fans (2 of 2) for Saab 9-5 Aero 2011 List of elements for Cooling Fan Wiring Diagram, Dual Fans (2 of 2) for Saab 9-5 Aero 2011: 13 (engine compartment, left center of radiator support) (engine cooling harness, on branch, between main bundle & relay block - underhood) Cooling fan speed control 2 relay G106 J105 (engine cooling harness, main bundle & on branch, between relay block- underhood) J106 (engine cooling harness, on branch, between main bundle & relay block-underhood) J107 J108 Left cooling fan medium speed relay Right cooling fan medium speed relay Right cooling fan motor (behind radiator) Underhood relay block (left side of engine compt) X117 Cooling Fan Wiring Diagram, Single Fan for Saab 9-5 Aero 2011 List of elements for Cooling Fan Wiring Diagram, Single Fan for Saab 9-5 Aero 2011: 31 (engine harness, between fuse block-underhood & g120) (not used) (or 151) (or 2761) (or tan) 2.0l 2.8l Computer data lines system Cooling fan high speed relay Cooling fan medium speed 1 relay Cooling fan medium speed 2 relay Cooling fan motor (behind radiator) Cooling fan relay Cooling fan speed control relay Engine control module (right rear of engine compt) Engine control module relay Engine controls system Engine coolant temperature sensor (right rear of engine) Engine main rly coil ctrl Fan rly ctrl lw spd cooling Fuse 10a Fuse 60a G106 (engine compartment, left center of radiator support) G109 (engine compartment, on left strut tower) Hi spd cooling fan rly ctrl Hot at all times J115 J126 (2.8l) (engine harness, in formed conduit by throttle body) J137 Underhood fuse block (left side of engine compt) X117
CRUISE CONTROL Cruise Control Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Cruise Control Wiring Diagram for Saab 9-5 Aero 2011: 83 (instrument panel harness, on branch leading to info display module) (or 151) (or 416) (or 560) (or 561) (or tan) 2.0l turbo 2.8l turbo 5 voct ref 5 volt ref 5v4 Accelerator pedal position sensor (on pedal bracket) Automatic transmission assembly Body control module (left end of dash) Brake pedal position sensor (on brake pedal bracket) Brake sig Brk sply vol Cancel Cltc sply low ref Cltc sply sig Cltc sply vol ref Clutch pedal position sensor (2.0l turbo) (on clutch pedal bracket) Computer data lines system Cruise ctrl sw sig Cruise ind Cruise switch Driver information center display Engine control module (right rear of engine compt) Fuse 10a Fuse 15a Fuse 5a G121 (2.0l: left side of engine) (2.8l: right side of engine) G206 (left end of dash) Ground High signal Hot at all times Hot w/ ignition main relay energized Ign Instrument cluster Instrument panel fuse block (left end of dash) Interior lights system J113 J114 J205 J216 Left steering wheel controls switch Logic Low ref Low signal Nca Pdl position sig 1 Pdl position sig 2 Pnk Positive voltage Res+ Sensor sig Ser data Ser data + Ser data - Serial bus + Serial bus - Serial data (+) Serial data (-) Set- Sound systems Steering wheel air bag coil Sw ref Tan Throttle body actuator (integral with throttle body) Tp mtr low ref Tp mtr sply volt Tp sens sig 1 Tp sens sig 2 Transmission control module Transmission input shaft speed sensor Transmission output shaft speed sensor Underhood fuse block (left side of engine compt) Vehicle speed sensor (2.0l turbo) Vss hi sig Vss lo sig Vss ref X108 X200
DEFOGGERS Defoggers Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Defoggers Wiring Diagram for Saab 9-5 Aero 2011: 33 Battery fuse block (left rear of engine compt) Computer data lines system Defogger indicator Defogger switch Display Driver outside rearview mirror Driver outside rearview mirror class Fuse 250a Fuse 40a Fuse 7.5a G109 (engine compt, on left strut tower) G201 (left kick panel) G302 (right kick panel) G404 (right "c" pillar) Heating element Hot at all times Hvac control module (center of dash) Hvac controls J137 J509 J609 Linear interconnect network bus 9 Logic Passenger outside rearview mirror Passenger outside rearview mirror class Rear defog rly ctrl Rear defogger grid Rear defogger relay Underhood fuse block (left side of engine compt) X2 a X200 X500 X600
ELECTRONIC POWER STEERING Electronic Power Steering Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Electronic Power Steering Wiring Diagram for Saab 9-5 Aero 2011: 34 Anti-lock brakes system Computer data lines Computer data lines system Data + Data - Driver information center display Electronic brake control module (lower left rear of engine compt) Fuse 23 10a G201 (left kick panel) G206 (left center of dash) Gnd Ground Hot at all times Instrument cluster J215 J221 (instrument panel harness, in main bundle in formed conduit, near center center of instrument panel) J336 Logic Low ref Nca Power steering control module (lower left side of dash) Serial data Serial data (+) Serial data (-) Serial data + Serial data - Sol ctrl Sply volt Steering wheel angle sensor (on steering column) System Underhood fuse block (left side of engine compt) Variable power steering solenoid valve (on steering rack assembly) X116 X200
ELECTRONIC SUSPENSION Electronic Suspension Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Electronic Suspension Wiring Diagram for Saab 9-5 Aero 2011: 52 (body harness, in main bundle between breakout to left front door inline & left bulkhead grommet) (body harness, in main bundle between breakout to left front door inline & left bulkhead grommet) j228 (body harness, in main bundle rearward of formed conduit near left b-pillar, near c-pillar) j340 All times Bat pos volt Computer data lines system Driver information center display Fuse 31 10a G304 (left kick panel) Gmlan ser data (+) Gmlan ser data (-) Gnd Hot at Ign Instrument cluster Instrument panel fuse block (left end of dash) J229 J337 Left front shock absorber actuator (left front strut) Left front vertical body acceleration sensor (left front rear corner of engine compt) Left front vertical suspension acceleration sensor (near top of left bottom of left strut) Left rear shock absorber actuator (left rear strut) Lf accel sig Lf damp serv ctrl Lf damp serv sply volt Lf whl acc low ref Lf whl acce vol ref Lf whl damp accel sig Logic Lr damp serv ctrl Lr damp serv sply volt Rear accel sig Rear vertical body acceleration sensor (behind left rear seat) Rf accel sig Rf damp serv ctrl Rf damp serv sply volt Rf whl damp accel sig Right front shock absorber actuator (right front strut) Right front vertical body acceleration sensor (right front rear corner of engine compt) Right front vertical suspension acceleration sensor (near top of right front steering knuckle) Right rear shock absorber actuator (right rear strut) Rr damp serv ctrl Rr damp serv sply volt Serial data comm enable Suspension control module (left side of luggage compt) X106 X107 X108 X113 X114 X401 X402
ENGINE PERFORMANCE
2.0L TURBO 2.0L Turbo, Engine Performance Wiring Diagram (1 of 5) for Saab 9-5 Aero 2011 List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (1 of 5) for Saab 9-5 Aero 2011: 51 (in main bundle forward of breakout to right rear wheel well) j401 (on bottom right side of radiator) a/c refrigerant pressure sensor (on pedal bracket) accelerator pedal position (app) sensor 5-v ref A/c refrigerant pressure sens sig Accessory vol Air pressure sig App sens sig (1) App sens sig (2) Cltc sply low ref Cltc sply sig Cltc sply vol ref Clutch pedal position sensor (m/t) (on clutch pedal bracket) Computer data lines system Cooling fan rly ctrl Cooling fans system Cruise control system Cruise/etc/tcc brake sig Engine control module (right rear of engine compt) Engine ctrl ign rly Engine ind ctrl Evap conister vent sol ctrl Evaporative emission vent solenoid valve (top left side of engine) Fuel level sens sig Fuel pump & level sensor assembly Fuel pump primary rly ctrl Fuel tank pressure sens sig Fuel tank pressure sensor (on fuel pump & sender assembly) Fuel temp/composition sig Fuse 10a Fuse 15a Gmlan serial data bus + (1) Gmlan serial data bus - (1) Hot at all times Ign Intake manifold pressure & air temperature sensor (on engine intake air duct) Low ref Low speed cooling fan rly ctrl Pre-throttle air press temp sig Starter enable rly ctrl Starting/charging system Tan Tan a Underhood fuse block (left side of engine compt) X108 X108 computer data lines system X115 X118 X200 X350 X403 2.0L Turbo, Engine Performance Wiring Diagram (2 of 5) for Saab 9-5 Aero 2011 List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (2 of 5) for Saab 9-5 Aero 2011: 42 (on steering column) steering column lock control module (top of transmission) transmission control module 5-v ref 87a Batt vol Battery fuse block (left rear of engine compt) Body control module (left end of dash) Coil ctrl Computer data lines system Data bus + Data bus - Engine control module relay Engine coolant temperature sensor (right rear of engine) Exhaust camshaft position actuator solenoid valve (front of right cylinder bank) Fuel pressure sensor Fuel pump control module (right side of luggage compt) Fuel pump sply Fuse 10a Fuse 15a Fuse 20a Fuse 250a Fuse 5a Fuse 7.5a G109 (engine compt, on left strut tower) G306 (right rear of luggage compt) Gnd Hot at all times Ign Ign 1 volt Ignition main relay J114 J137 Logic Low ref Relay ctrl Sens sig Serial data Tan Underhood fuse block (left side of engine compt) X108 X200 X403 2.0L Turbo, Engine Performance Wiring Diagram (3 of 5) for Saab 9-5 Aero 2011 List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (3 of 5) for Saab 9-5 Aero 2011: 52 (top of 1 cylinder) (top of 2 cylinder) (top of 3 cylinder) (top of 4 cylinder) 5-v 1 ref 5-volt 2 ref Actuator hi ctrl Actuator low ctrl Camshaft pos intake Computer data lines system Crankshaft sens sig Ctrl cylinder 1 Ctrl cylinder 2 Ctrl cylinder 3 Ctrl cylinder 4 Data Driver information center (dic) Ect sens sig Engine control module (right rear of engine compt) Engine oil ind Engine oil pressure switch (lower left front of engine) Exhaust sens (1) Exhaust sol (1) G122 (top rear of engine) G206 (left center of dash) Gnd High pressure fuel pump (top left rear of engine) Ic ctrl (1) Ic ctrl (2) Ic ctrl (3) Ic ctrl (4) Ign Ignition coil 1 Ignition coil 2 Ignition coil 3 Ignition coil 4 Instrument cluster Intake sol (1) J117 (between fuse block-underhood & g120) J122 J124 (in formed conduit by throttle body) J130 J216 Logic Low ref Malfunction ind lamp (mil) Nca Oil press sw sig Serial gmlan Spark plug Tan X200 2.0L Turbo, Engine Performance Wiring Diagram (4 of 5) for Saab 9-5 Aero 2011 List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (4 of 5) for Saab 9-5 Aero 2011: 26 (above 1 cylinder) (above 2 cylinder) fuel injector 2 (above 3 cylinder) fuel injector 3 (above 4 cylinder) fuel injector 4 (top left side of engine) evaporative emission purge solenoid valve (under turbocharger) turbocharger by-pass solenoid valve Crankshaft position sensor (lower left rear of engine) Engine control module (right rear of engine compt) Engine oil level switch Exhaust camshaft position sensor (front of right cylinder head) Fuel composition sensor Fuel injector 1 G121 (left side of engine) Gnd Intake camshaft position actuator solenoid valve (top front of engine) Intake camshaft position sensor (left rear of cylinder head) J113 J118 Low ref Sply cylinder 1 Sply cylinder 2 Sply cylinder 3 Sply cylinder 4 Tan Turbocharger wastegate solenoid valve (on turbocharger) X160 2.0L Turbo, Engine Performance Wiring Diagram (5 of 5) for Saab 9-5 Aero 2011 List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (5 of 5) for Saab 9-5 Aero 2011: 48 (downstream of catalytic converter) heated oxygen sensor 2 (upstream of catalytic converter) heated oxygen sensor 1 5-v ref 5-v ref fuel rail press sens sig Air temp sens sig Backup lamp sply Bank 1 sens (1) Bank 1 sens (2) Engine control module (right rear of engine compt) Exterior lights system Fuel rail pressure sensor (top of engine on fuel rail) G121 (left side of engine) Generator field Gnd Hi sig bank 1 sens (1) Hi sig bank 1 sens (2) J113 Knock sens (1) Knock sens (2) transmission park/ neutral signal (1) Knock sens sig (1) Knock sens sig (2) Knock sensor 1 (left side of engine) Knock sensor 2 (rear left side of engine) Low ref Maf sens sig generator turn on sig low ref Manifold absolute pressure sensor (on intake manifold) Map sens sig Mass air flow/ intake air temperature sensor (on engine air intake duct) Nca Oil level sw sig Overrun air valve Purge sol ctrl Sens sig Starting/charging system Tac close Tac open Tan Throttle body Throttle inlet absolute pressure sensor Tp sens sig (1) Tp sens sig (2) Transmissions system Vehicle speed sensor (m/t) Vss ho sig Vss lo sig Vss ref Waste gate sol ctrl X160
2.8L TURBO 2.8L Turbo, Engine Performance Wiring Diagram (1 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (1 of 6) for Saab 9-5 Aero 2011: 53 (engine harness, 90 mm from breakout toward camshaft position sensors) j116 (info not available) 5 volt ref C phase exhaust sol 1 C phase exhaust sol 2 C phase intake sol 1 C phase intake sol 2 Camshaft position sensor exhaust bank 1 (front of right cylinder head) Camshaft position sensor exhaust bank 2 (front of left cylinder head) Camshaft position sensor intake bank 1 (front of right cylinder head) Camshaft position sensor intake bank 2 (front of left cylinder head) Ckp pos sens sig 1 Ckp sens low ref Ckp sens sply volt Cms pos sens low ref Cp exhaust sens 1 Cp exhaust sens 2 Cp intake sens 1 Cp intake sens 2 Cp sens 5v sply volt Crankshaft position sensor (lower right rear of engine) Engine control module (right rear of engine compt) Evap can pur sol ctrl Fuel inj ctrl 1 Fuel inj ctrl 2 Fuel inj ctrl 3 Fuel inj ctrl 4 Fuel inj ctrl 5 Fuel inj ctrl 6 Gen fld duty cle sig Gen turn on sig Gnd Gnd sig Ho2s low sig b 1 sens Ign ctrl 1 Ign ctrl 3 Ign ctrl 5 Ign ctrl low ref b 1 J109 Knock sens low ref Knock sensor sig 1 Low ref bank 1 Map sens low ref Map sens sig Oil level sw sig Oil pressure sens sig Overrun air valve sol Starting/charging system T rel mot low ref Thtl rel mot sply volt Tp sens 5 volt ref Turbocharger bypass solenoid valve (under turbocharger) Waste gate sol ctrl 2.8L Turbo, Engine Performance Wiring Diagram (2 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (2 of 6) for Saab 9-5 Aero 2011: 24 (engine harness, in formed conduit by throttle body) j124 (lower left front of engine) engine oil pressure sensor (on turbocharger) turbocharger wastegate solenoid valve (top left side of engine) secondary air injection pressure sensor (top of right cylinder bank) (top of right cylinder bank) fuel injector 1 (upstream of catalytic converter) heated oxygen sensor 1 Camshaft position actuator solenoid valve exhaust bank 1 (front of right cylinder head) Camshaft position actuator solenoid valve exhaust bank 2 (front of left cylinder head) Camshaft position actuator solenoid valve intake bank 1 (front of left cylinder head) Camshaft position actuator solenoid valve intake bank 2 (front of right cylinder head) Evaporative emissions purge solenoid valve (left side of engine) Fuel injector 3 Fuel injector 5 Ignition coil 5 (top of right cylinder bank) J120 J127 (engine harness, in formed conduit near g123) J128 (engine harness, in formed conduit near g123) J129 J144 J147 Nca Spark plug X160 2.8L Turbo, Engine Performance Wiring Diagram (3 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (3 of 6) for Saab 9-5 Aero 2011: 23 (engine harness, in formed conduit near g123) j121 (top of left cylinder bank) (top of left cylinder bank) fuel injector 2 (top of left cylinder bank) fuel injector 6 Evaporative emission vent solenoid valve (left of fuel tank) Fuel injector 4 G122 (right side of engine) G123 (left side of engine) Ignition coil 1 (top of right cylinder bank) Ignition coil 2 (top of left cylinder bank) Ignition coil 3 (top of right cylinder bank) Ignition coil 4 (top of left cylinder bank) Ignition coil 6 J119 J122 J123 J145 Nca Secondary fuel level sensor (awd) (top of fuel tank) Spark plug X108 X160 X403 2.8L Turbo, Engine Performance Wiring Diagram (4 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (4 of 6) for Saab 9-5 Aero 2011: 34 (body harness, in main bundle forward of breakout to right rear wheel well) (lower left rear of engine) secondary air injector pump (on engine intake air duct) intake manifold pressure & air temperature sensor Battery fuse block (left rear of engine compt) Computer data lines system Fuel pump & level sensor assembly Fuse 10a Fuse 15a Fuse 250a G120 (engine compt, below engine control module) G122 (right side of engine) G206 (left center of dash) Gnd Heated oxygen sensor 2 (downstream of catalytic converter) Hot at all times Ign Ind mil Instrument cluster J120 J216 J222 J402 (awd) Knock sensor 1 (lower right side of engine) Knock sensor 2 (lower left side of engine) Logic Low engine oil pressure ind Mass air flow sensor (on engine air intake duct) Nca Serial data gmlan Underhood fuse block (left side of engine compt) X108 X122 X200 X403 2.8L Turbo, Engine Performance Wiring Diagram (5 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (5 of 6) for Saab 9-5 Aero 2011: 37 (not used) 5v ref 87a Batt pos vol Computer data lines system Data bus + Data bus - Engine control module relay Fscm shield Fuel pressure sensor Fuel pump Fuel pump control module (right side of luggage compt) Fuse 10a Fuse 15a Fuse 20a Fuse 5a Fuse 7.5a G109 (engine compt, on left strut tower) G111 (engine compt, rearward of battery) G306 (right rear of luggage compt) Gnd Ign 1 volt Ignition main relay J114 J137 Low ref Nca Relay ctrl Secondary air injection pump relay Sens sig Serial data Sply Steering column lock control module (on steering column) Underhood fuse block (left side of engine compt) X108 X200 X403 2.8L Turbo, Engine Performance Wiring Diagram (6 of 6) for Saab 9-5 Aero 2011 List of elements for 2.8L Turbo, Engine Performance Wiring Diagram (6 of 6) for Saab 9-5 Aero 2011: 73 (engine harness, between fuse block - underhood & g120) (engine harness, in formed conduit by throttle body) (info not available) (top of transmission) transmission control module A/c comp clutch rly ctrl A/c pres sens 5 volt ref A/c refrgnt pres sens lo ref A/c refrigerant sens sig Acc/run/crank ign 0 volt Accelerator pedal position sensor (on pedal bracket) Air conditioning system Air inj rp rly coil ctrl Air inj rpp sens sig App 5 volt ref 1 App 5 volt ref 2 App low ref 1 App low ref 2 App sens sig 1 App sens sig 2 Batt pos volt Body control module (left end of dash) Chk eng ind ctrl Computer data lines system Coolant temp sens sig Cooling fans system Cruise control system Cruise/etc/tcc brk sig Engine control module (right rear of engine compt) Engine coolant temperature sensor (right rear of engine) Engine main rly coil ctrl Evap canister vent sol ctrl Exterior lights system Fuel pump prm rly ctrl G121 (right side of engine) Gnd Gnd sig Hi spd cool fan rly ctrl Hi spd gmlan ser data + 1 Hi spd gmlan ser data - 1 Ho2s hi sig b 1 s 1 Ho2s hi sig b 1 s 2 Ho2s htr lo ctrl b 1 s 1 Ho2s htr low ctrl b 1 s 2 Ho2s low b 1 s 2 Ign Ign ctrl 2 Ign ctrl 4 Ign ctrl 6 J113 J117 J126 Knock sens low ref 1 Knock sens sig 2 Logic Low ref Low spd cool fan rly ctrl Maf sens sig Map sens 5 volt ref Mfld air temp sens sig P/n pos sw park sig Prm fuel level sens sig Pwtr main rly f sply 1 Reverse sw sig Run/crank ign 1 volt Sec fuel level sens sig Starter rly coil ctrl Starting/charging system Throttle body Tp sens sig 1 Tp sens sig 2 Transmissions system X108 X200
EXTERIOR LIGHTS Backup Lamps Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Backup Lamps Wiring Diagram for Saab 9-5 Aero 2011: 40 (body harness, in main bundle between breakout to left front door inline & g201) j241 (front of transmission) backup lamp switch (or 1796) 2.0l 2.8l Backup lp ctrl Backup lp sply volt Backup nca Body control module (left end of dash) Computer data lines system Engine control module (right rear of engine compt) Fuse 32 20a G120 (engine compartment, below engine control module) G206 (left center of dash) G306 (right side of luggage compt) G401 (left side of luggage compt) Gear shift position sensor Gnd Hot at all times Inside rearview mirror J120 J216 J400 J409 Left backup lamp Left tail lamp assembly Logic Lp ctrl Park/neutral sig Rearview mirror Right backup lamp Right tail lamp assembly Rw sw sig Serial data(+) Serial data(-) Sply volt Tan Transmission control module (a/t) Underhood fuse block (left side of engine compt) X411 Exterior Lamps Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 64 (body harness, in main bundle between breakout to left front door inline & left bulkhead grommet) j227 (on brake pedal bracket) brake pedal position sensor Ambient light sens sig Auto Backup lp sply volt sig Body control module (left side of dash) Center high mounted stop lamp Fuse 30a G102 (engine compt, on right strut tower) G109 (engine compt, on left strut tower) G203 (left end of dash) G206 (left center of dash) G302 (right G306 (right rear of luggage compt) G401 (left side of luggage compt) Haz sw left turn sig Haz sw right turn sig Haz sw sig Hazard led dimming sig Head Headlamp sw on sig Headlamp sw park lp sig Headlamp switch Headlamps off sig ctrl Hot at all times Instrument panel multi-function switch J104 J135 J216 J220 J235 (body harness, in branch to body control module, near breakout to left front door inline) J400 J609 J900 Kick panel) Left Left prk lp sply volt Lf turn sig lp sply volt Lo ref Lr stop lp sply volt Lr turn sig lp sply volt Off Park Passenger outside rearview mirror Rear license lp sply volt Rf turn sig lp sply volt Right Right front side marker lamp Right front turn signal lamp Right headlamp Right prk lp sply volt Right rear side marker lamp Right rear turn signal lamp Right stop lamp Right tail lamp assembly Right turn signal repeater lamp Rr stop lp sply volt Sp lp rly coil sply volt Turn signal/ multi-function switch Underhood fuse block (left side of engine compt) X1 center tail lamp X101 X411 X500 Exterior Lamps Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 35 (body harness, in main bundle between breakout to left front door inline & left bulkhead grommet) j230 (left side of luggage compt) g401 Air conditioning system Ambient light/sunload sensor (top center of dash) Computer data lines system Driver outside rearview mirror G102 (engine compt, on right strut tower) G109 (engine compt, on left strut tower) G201 (left kick panel) Instrument cluster J104 J135 J204 (instrument panel harness, on branch leading to remote control door lock receiver) J234 (body harness, in branch to body control module, near breakout to left front door inline) J409 J509 J900 Left front side marker lamp Left front turn signal lamp Left headlamp Left license plate lamp Left rear side marker lamp Left rear turn signal lamp Left stop lamp Left tail lamp assembly Left turn ind Left turn signal repeater lamp Logic Park light ind Right turn ind Serial data X1 right license plate lamp x2 X101 X411 X500 Trailer Tow Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Trailer Tow Wiring Diagram for Saab 9-5 Aero 2011: 14 Center trailer connector Fuse 20a Fuse 40a Fuse 7.5a G403 Hot at all times Hot w/ ign relay energized Rear body fuse block (left side of luggage compt) Red Trailer connector Trailer ignition relay Trailer lighting control module W/ electrical center trailer connector W/o electrical
GROUND DISTRIBUTION Ground Distribution Wiring Diagram (1 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (1 of 8) for Saab 9-5 Aero 2011: 41 2.8l Air quality sensor Battery Brake booster pump motor relay G102 (engine compt, on right strut tower) G103 (engine compt, forward of battery) G105 (engine compartment, on left strut tower) G108 (engine compt, on radiator support right of center) Hood ajar switch Horn J100 (front bumper harness, between fog left lamp & ambient temperature sensor) J104 (front bumper harness, in main bundle right of breakout to x101) J135 (body harness, under cowling, between security siren & g102) J136 (body harness, in main bundle between g109 & fuse block - underhood) J138 (body harness, in main bundle between x109 & horn) Left front fog lamp Left front side marker lamp Left front turn signal lamp Left headlamp Left headlamp ballast Left headlamp horizontal motor Left headlamp leveling actuator Left high beam headlamp (w/o hid) Left low beam headlamp (w/o hid) Left position lamp (w/o hid) N x101 Right front fog lamp Right front side marker lamp Right front turn signal lamp Right headlamp Right headlamp ballast Right headlamp horizontal motor Right headlamp leveling actuator Right high beam headlamp (w/o hid) Right position lamp (w/o hid) To splice j137 (diagram 2 of 8) Transmission control module W/ automatic leveling system W/ hid W/ theft deterrent Windshield wiper motor Ground Distribution Wiring Diagram (2 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (2 of 8) for Saab 9-5 Aero 2011: 54 (2.0l) ignition coil 2 (2.0l) ignition coil 4 (2.8l) ignition coil 5 (2.8l) mass air flow sensor (if equipped) electrical auxiliary heater (left side of engine compt) underhood fuse block 2.0l 2.8l 87a Backup lamp switch (m/t) Body control module Cooling fan motor (w/ single fan) Cooling fan relay Cooling fan speed control 2 relay (w/ dual fan) Electronic brake control module Engine control module From splice j136 (diagram 1 of 8) From splice j138 (diagram 1 of 8) Fuel composition sensor (2.0l) G106 (engine compt, left center of radiator support) G107 (engine compt, forward of battery) G109 (engine compt, on left strut tower) G110 (engine compt, left center of radiator support) G111 (engine compt, rearward of battery) G120 (engine compt, below engine control module) G121 (6 cyl: right side of engine) G122 (right side of engine) G123 (2.8l) (left side of engine) Headlamp washer fluid pump Headlamp washer fluid pump relay Ignition coil 1 Ignition coil 2 Ignition coil 3 Ignition coil 4 Ignition coil 6 Ignition main relay J108 (engine cooling harness, on branch, between main bundle & cooling fan motor - left) J113 (engine harness, on breakout to x108) J120 (engine harness, in formed conduit by throttle body) J122 (engine harness, in breakout to g122) J123 (engine harness, in breakout to g123) Mass air flow/ intake air temperature sensor (2.0l) Rear compartment lid release relay Rear defogger relay Right cooling fan motor (w/ dual fan) Secondary air injection pump Secondary air injection pump relay Security door lock relay (if equipped) Starter relay Underhood fuse block (left side of engine compt) Windshield washer fluid level sensor Windshield washer pump Windshield wiper relay Winshield washer pump relay Ground Distribution Wiring Diagram (3 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (3 of 8) for Saab 9-5 Aero 2011: 41 (left end of dash) instrument panel fuse block (w/ interior lights package) driver door accent lamp Auxiliary blower motor control module Auxiliary power relay Body control module Data link connector Door lock security relay Driver door courtesy lamp Driver door handle accent lamp Driver door latch assembly Driver outside rearview mirror Driver window motor Driver window switch From splice j336 (diagram 4 of 8) G201 (left kick panel) G203 (left end of dash) Head-up display switch Headlamp switch Instrument panel multi-function switch J113 (engine harness, on breakout to x108) J220 (instrument panel harness, in main bundle in formed conduit, near center of instrument panel) J318 (body harness, in main bundle between breakout to side impact sensor-left front & formed conduit near left b-pillar) J505 (driver door harness, in branch between outside rearview mirror switch & lower door grommet) J509 (driver door harness, in branch between outside rearview mirror switch & lower door grommet) J701 (left rear door harness, in main bundle between lower grommet & breakout to window motor) Left instrument panel courtesy lamp Left rear door accent lamp Left rear door handle accent lamp Left rear door latch assembely Left rear window motor Left rear window switch Nca Night panel switch Outside rearview mirror switch Right lower instrument panel accent lamp Sunroof control module W/ express down W/ express up/down X300 b9 X500 X700 Ground Distribution Wiring Diagram (4 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (4 of 8) for Saab 9-5 Aero 2011: 39 (if equipped) (if equipped) garage door opener (if equipped) mobile telephone control module (if equipped) rear audio control module (if equipped) sunroof sunshade switch (if equipped) ultrasonic intrusion sensor disable switch (left side of engine compt) underhood fuse block (w/ audio interface) multimedia player interface module (w/ digital audio system) digital radio receiver control module (w/ hid) headlamp control module (w/ onstar) telematics communication interface control module (w/ premium audio) audio amplifier Driver seatback video display Engine coolant level switch Front dome/ reading lamps G205 (right kick panel) Info display module J140 (body harness,in main bundle between breakout to electronic brake control module & left bulkhead grommet) J201 (instrument panel harness, in main bundle near data link tresistor) J336 (body harness,in main bundle rearward of formed conduit near left "b" pillar near "c" pillar) J346 (right front & sunshade headliner hareness, in main bundle between dome/reading lamp) J356 (passenger seat harness, in main bundle near breakout to recline motor) J366 (passenger seat harness, between x302 & video display- passenger seat headrest) Left sunshade mirror lamp Middle dome/ reading lamps Nca Passenger seatback video display Power steering control module Radio Radio/hvac controls Rear compartment lid release relay Right sunshade mirror lamp Sunroof control module Sunroof switch motor To splice j318 (diagram 3 of 8) X210 X301 X307 X397 Ground Distribution Wiring Diagram (5 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (5 of 8) for Saab 9-5 Aero 2011: 39 (if equipped) center console multifunction switch (if equipped) head-up display (if equipped) steering column lock control module (w/ deluxe interior lamp package) left lower instrument panel accent lamp (w/ flexride mode system switch) (w/o flexride mode system switch) Body control module Center console compartment lamp Data link connector module G206 (left center of dash) G303 (under driver's seat) Horn switch Hvac control module Ignition mode switch Inflatable restraint sensing & diagnostic module Instrument cluster Instrument panel compartment lamp J210 (instrument panel harness, in branch between breakout to hvac control module & steering column) J215 (instrument panel harness, in main bundle near instrument cluster) J216 (instrument panel harness, in main bundle near instrument clkuster) J301 (console harness,in main bundle between ignition mode switch & multifunction switch-center console) J304 (console harness, in main bundle between ignition mode switch & multifunction switch - center console) Left rear side air bag Left steering wheel controls switch Nca Park brake switch Passenger instrument panel air bag Pnk Right instrument panel courtesy lamp Right rear side air bag Right steering wheel controls switch Sport mode switch Steering column lock control module Steering wheel angle sensor Transmission shift lever Transmission shift lever position indicator Turn signal/ multi-function switch X207 X210 Ground Distribution Wiring Diagram (6 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (6 of 8) for Saab 9-5 Aero 2011: 55 (awd) rear differential clutch control module (if equipped) driver seat lumbar adjuster valve assembly (if equipped) driver seat lumbar support pump (if equipped) keyless entry control module (if equipped) passenger back seat blower motor (if equipped) passenger cushion seat blower motor (if equipped) passenger seat lumbar adjuster valve assembly (if equipped) passenger seat lumbar support pump (w/ driver fan seat) driver back seat blower motor (w/ driver fan seat) driver cushion seat blower motor (w/ express down) (w/ express up/down) (w/ express up/down) right rear window motor (w/ interior lights package) passenger door accent lamp (w/ memory) driver seat adjuster switch (w/ memory) driver seat heating control module (w/ memory) driver seat lumbar support switch (w/ memory) driver seat memory control module (w/o memory) driver seat adjuster switch (w/o memory) passenger seat adjuster switch (w/o memory) passenger seat lumbar support switch Blower motor control module Center console accessory power receptacle Cigarette lighter receptacle G302 (righgt kick panel) G305 (under driver's seat) G404 (right "c" pillar) J207 (instrument panel harness, in branch between g305 & x210) J319 (body harness, in main bundle between breakout to side impact sensor - left front & formed conduit near left b-pillar) J341 (body harness, in main bundle between g302 & formed conduit near right front seat) J354 (driver seat harness, in main bundle near breakout to recline motor) J364 (passenger seat harness, in main bundle near breakout to recline motor) J605 (passenger door harness, in branch between outside rearview mirror switch & lower door grommet) J609 (passenger door harness, in branch between outside rearview mirror switch & lower door grommet) J801 (rihght rear door harness, in main bundle between lower grommet & breakout to window motor) Nca Passenger door courtesy lamp Passenger door handle accent lamp Passenger door latch assembly Passenger outside rearview mirror Passenger window motor Passenger window switch Rear defogger grid Right rear door accent lamp Right rear door handle accent lamp Right rear door latch assembly Right rear window switch X1 a X1 e X210 X301 X307 X408 e X600 X800 Ground Distribution Wiring Diagram (7 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (7 of 8) for Saab 9-5 Aero 2011: 43 (if equipped) inside rearview mirror (if equipped) keyless entry control module (if equipped) parking assist control module (if equipped) passenger presence detection module (if equipped) rearview camera (w/ automatic leveling system) rain sensor (w/ camera lane departure warning & traffic sign recognition) vehicle direction camera control module Brake fluid level switch Driver exterior door handle switch Driver interior door handle switch G304 (left kick panel) G403 Hazard lamps switch If equipped J244 (body harness, on branch to inside rearview mirror, before breakout) J335 (body harness, in main bundle rearward of formed conduit near left b-pillar) J337 (body harness, in main bundle rearward of formed conduit near left b-pillar, near c-pillar) J403 (body harness, near grommet at rear of body) Left rear exterior door handle switch Left side object sensor Multi-axis acceleration sensor Nca Overhead console multi-function switch Passenger air bag disable indicator Passenger exterior door handle switch Passenger interior door handle switch Right rear exterior door handle switch Right side object sensor Suspension control module Tire pressure indicator module Trailer connector Trailer ignition relay Trailer lighting control module W/ light sensitive mirror & w/o lane departure warning & windshield wiper system W/ light sensitive mirror, lane departure warning & windshield wiper system W/ passive remote keyless entry X307 X398 X407 X500 X600 X700 X800 Ground Distribution Wiring Diagram (8 of 8) for Saab 9-5 Aero 2011 List of elements for Ground Distribution Wiring Diagram (8 of 8) for Saab 9-5 Aero 2011: 36 (awd) rear differential clutch control module (if equipped) cargo accessory power receptacle (left side of luggage compt) rear body fuse block Center high mounted stop lamp Center park lamp Courtesy lamp Exterior rear compartment lid unlatch switch Fuel door release actuator relay Fuel pump control module G306 (rihgt rear of luggage compt) G401 (left side of luggage compt) J400 (body harness, in main bundle rearward of breakout to right rear wheel well) J409 (body harness, in main bundle between g401 & breakout to left rear wheel well) J410 (body harness, in main bundle between g401 & breakout to left rear wheel well) J900 L x408 Left backup lamp Left license plate lamp Left rear compartment courtesy lamp Left rear side marker lamp Left rear turn signal lamp Left stop lamp Left tail lamp assembly Parking brake control module Rear cargo door latch assembly Rear compartment lid latch Rear fog lamp Right backup lamp Right license plate lamp Right rear compartment Right rear turn signal lamp Right side rear marker lamp Right stop lamp Right tail lamp assembly Sunroof sunshade motor module X411
HEADLIGHTS Headlamps Wiring Diagram, with High Intensity Discharge (1 of 2) for Saab 9-5 Aero 2011 List of elements for Headlamps Wiring Diagram, with High Intensity Discharge (1 of 2) for Saab 9-5 Aero 2011: 61 (engine compt, on left strut tower) g105 (engine compt, on left strut tower) g109 (engine compt, on radiator support right of center) g108 (engine compt, on right strut tower) g102 Air conditioning system Ambient light sens sig Ambient light/ sunload sensor (a/t) (top center of dash) Body control module left end of dash) Computer data lines system Dim sw Fog lamp rly ctrl Front fog lamp relay Ftp Fuse 10a Fuse 15a Fuse 30a G206 (left center of dash) Ground Hdlp dimmer sw hi beam sig x3 Hdlp hi beam rly ctrl Hdlp lw beam rly ctrl Hdlp off sig ctrl Hdlp sw flash Hdlp sw on sig Hdlp sw park lp sig Headlamp high beam relay Headlamp low beam relay Hi spd gmlan ser data+ Hi spd gmlan ser data- Hot at all times Hvac control module (center of dash) Instrument panel fuse block (left end of dash) J101 (front bumper harness, between fog left lamp & ambient temperature sensor) J135 J138 J204 (instrument panel harness, on branch leading to remote control door lock receiver) J216 Left headlamp Left headlamp ballast Left high beam headlamp Left low beam headlamp Left position headlamp Lh park lamp sply v Lighting ctrl sw ref Lighting ctrl sw sig Low Low ref Nca Rear fog lamp rly ctrl Rh park lamp sply v Right headlamp Right headlamp ballast Right high beam headlamp Right low beam headlamp Right position headlamp To pass sig Turn signal/ multi-function switch Underhood fuse block (left side of engine compt) X101 X110 X120 Headlamps Wiring Diagram, with High Intensity Discharge (2 of 2) for Saab 9-5 Aero 2011 List of elements for Headlamps Wiring Diagram, with High Intensity Discharge (2 of 2) for Saab 9-5 Aero 2011: 45 Auto Battery fuse block (left rear of engine compt) Computer data lines system Cruise control & sound systems Dimmer switch Fog lamp switch Front fog lamp ind Fuse 250a Fuse 5a G109 (engine compt, on left strut tower) G203 (left end of dash) G206 (left center of dash) G401 (left side of luggage compt) Ground Head Headlamp switch High beam lamp ind High spd gmlan ser data (+) High spd gmlan ser data (-) Hot at all times Hot w/ ignition main relay energized Ign Instrument cluster J100 J211 (instrument panel harness, in branch leading to steering column) J216 J220 J410 Left front fog lamp Logic Low spd gmlan ser data Off Park Park brake control switch Park brk release sw sig Park brk release sw vol ref Park brk sw sply volt Parking brake control module Prk brk sw sig Rear fog lamp Rear lamp fog switch Right front fog lamp Underhood fuse block (left side of engine compt) X200 X300 Headlamps Wiring Diagram, without High Intensity Discharge for Saab 9-5 Aero 2011 List of elements for Headlamps Wiring Diagram, without High Intensity Discharge for Saab 9-5 Aero 2011: 83 (engine compt, on left strut tower) g109 (engine compt, on right strut tower) g102 (front bumper harness, between fog left lamp & ambient temperature sensor) j101 Air conditioning system Ambient light sens sig Ambient light/ sunload sensor (a/t) (top center of dash) Auto Battery fuse block (left rear of engine compt) Body control module (left end of dash) Computer data lines system Cruise control & sound systems Dimmer switch Driver infor- mation center display Fog lamp rly ctrl Fog lamp switch Front fog lamp ind Front fog lamp relay Ftp Fuse 10a Fuse 15a Fuse 250a Fuse 5a G109 (engine compt, on left strut tower) G203 (left end of dash) G206 (left center of dash) G401 (left side of luggage compt) Gnd Ground Hdlp dimmer sw hi beam sig Hdlp hi beam rly ctrl Hdlp off sig ctrl Hdlp sw flash to pass sig Hdlp sw on sig Hdlp sw park lp sig Head Headlamp high beam relay Headlamp switch Hi spd gmlan ser data+ Hi spd gmlan ser data- High High beam lamp ind Hot at all times Hot w/ ignition main relay energized Hvac control module (center of dash) Ign Instrument cluster Instrument panel fuse block (left end of dash) J100 J135 J138 J201 (instrument panel harness, in main bundle near data link resistor) J211 (instrument panel harness, in branch leading to steering column) J216 J220 J410 Left front fog lamp Left headlamp Left high beam headlamp Left low beam headlamp Lh hdlp lw beam sply volt Lighting ctrl sw ref Lighting ctrl sw sig Logic Low Low ref Low spd gmlan ser data Nca Off Off head Park Rear fog lamp Rear fog lamp rly ctrl Rear lamp fog switch Rh hdlp lw beam sply volt Right front fog lamp Right headlamp Right high beam headlamp Right low beam headlamp Turn signal/ multi-function switch Underhood fuse block (left side of engine compt) X110 X120 X200 Headlamps Leveling Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Headlamps Leveling Wiring Diagram for Saab 9-5 Aero 2011: 25 (engine compt, on left strut tower) g109 Body control module (bcm) (left end of dash) Computer data lines system Front headlamp leveling sensor (left front wheelwell) Fuse 15a Fuse 5a G102 (engine compt, on right strut tower) G109 (engine compt, on left strut tower) Gmlan ser data + Gmlan ser data - Headlamp control module (left end of dash) Hot at all times Hot w/ ignition main relay energized J132 (body harness, under cowling, between windshield wiper motor & air quality sensor) J135 J138 Left headlamp Left headlamp horizontal motor Left headlamp leveling actuator Logic Rear headlamp leveling sensor (left rear wheelwell) Right headlamp Right headlamp horizontal motor Right headlamp leveling actuator Underhood fuse block (left side of engine compt)
HORN Horn Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Horn Wiring Diagram for Saab 9-5 Aero 2011: 15 Battery fuse block (left rear of engine compt) Body control module (left end of dash) Fuse 15a Fuse 250a G109 (engine compt, on left strut tower) G206 (left center of dash) Horn (behind left side of grill) Horn relay ctrl Horn switch Hot at all times J136 Pnk Red Steering wheel air bag coil (top of steering column) Underhood fuse block (left side of engine compt)
INSTRUMENT CLUSTER Head-Up Display Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Head-Up Display Wiring Diagram for Saab 9-5 Aero 2011: 17 Computer data lines system Fuse 15a G206 (left center of dash) Ground Head-up display Head-up display switch Hot at all times Hud off/ dimming sig Hud sw sig Image dn Image up Instrument panel fuse block (left side of engine compt) Interior lights system J215 J219 Lo spd gmlan ser data Low reference Instrument Cluster Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 65 (left center of dash) (left center of dash) g206 Abs ind Air bag ind Ambient air temperature sensor (behind left side of front bumper) Awd ind Brake ind Brake warning ind Charge ind Computer data lines system Cruise ind Dic sw sig Driver information center (dic) display Engine controls system Fluid ind low washer Fog lamp ind Fuel gauge Fuel ind Fuse 10a Fuse 5a G206 Gauge temperature engine coolant Gnd High beam ind Hot at all times Hot w/ ignition main relay energized Ign Ign 1 volt Ind Instrument cluster Instrument panel fuse block (left end of dash) J210 J216 Lane departure warning ind Left turn ind Lights on ind Lo washer fluid ind ctrl Logic Low ref Low ref ambient air temp sens sig dic select menu sw sig Low tire pressure ind Malfunction ind Menu Oil pressure ind Park lamps ind Parking assist ind Pnk Right turn ind Seat belt ind Security ind Serial data Set/clr Speedometer Stability off ind Tachometer Tcs off ind Temperature ind engine coolant Traction control Transmission shift lever position indicator Turn signal/ multi-function switch Underhood fuse block (left side of engine compt) Wait-to-start ind Wiper/washer system X101 X200 Instrument Cluster Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 71 (body harness, in main bundle forward of breakout to right rear wheel well) (in formed conduit near g123) (left side of luggage compt) (lower left rear of engine compt) electronic brake control module (on brake fluid reservoir) brake fluid level switch 2.0l turbo 2.8l 5-volt ref Body control module (left end of dash) Brake fluid level sens sig Bus 3 network Computer data lines system Driver door latch assembly Driver window motor Engine control module (right rear of engine compt) Engine controls system Engine oil pressure sensor (2.8l) (lower left front of engine) Engine oil pressure switch (2.0l turbo) (rear left side of engine) Fuel level sens sig Fuel pump & level sensor assembly G201 (left kick panel) G203 (left end of dash) G302 (right kick panel) G304 (left kick panel) G401 Gmlan serial + Gmlan serial - Gnd Hi gmlan +2 Hi gmlan -2 High spd gmlan serial data bus + J127 (in formed conduit near g123) J128 J208 J220 J337 J401 J402 J509 J609 J701 J801 Left rear door latch assembly Left rear window motor (w/ express up/down) left rear window switch (w/ express down) Lf door ajar sw sig Lift gate ajar sw sig Lr door ajar sw sig Network bus 3 Network bus 4 Oil pres sw Oil press sen sig Passenger door latch assembly Passenger window motor Power distribution system Primary Rear cargo door latch assembly Rf door ajar sw sig Right rear door latch assembly Right rear window motor (w/ express up/down) right rear window switch (w/ express down) Rr door ajar sw sig Sec fuel level Secondary fuel level sensor Sens sig Signal gnd Tan W/ express down W/ express up/down X108 X1115 X200 X403
INTERIOR LIGHTS Courtesy Lamps Wiring Diagram (1 of 3) for Saab 9-5 Aero 2011 List of elements for Courtesy Lamps Wiring Diagram (1 of 3) for Saab 9-5 Aero 2011: 40 (body harness, in main bundle between g201 & formed conduit near left front seat) j306 (headliner harness, in main bundle between dome/reading lamp - middle & sunshade - left) j348 (left kick panel) g201 Body control module (left end of dash) Computer data lines system Defeat sw sig Front dome/ reading lamps Fuse 5a G201 (left kick panel) G203 (left end of dash) G206 (left center of dash) Gnd Hi spd gmlan ser data Hot at all times Instrument panel compartment lamp J113 J210 J212 (instrument panel harness, in main bundle near instrument cluster) J216 J318 J346 J349 (headliner harness, in main bundle between dome/reading lamp - middle & x397) Lamp ctrl Lamp sply vol Lamp sw sig Led lighting ctrl Left lower instrument panel accent lamp Left sunshade mirror lamp Low spd gmlan ser data Middle dome/ reading lamps Nca Pwr ctrl Right lower instrument panel accent lamp Right sunshade mirror lamp Tailgate lamp ctrl Underhood fuse block (left side of engine compt) X200 X207 X322 X397 Courtesy Lamps Wiring Diagram (2 of 3) for Saab 9-5 Aero 2011 List of elements for Courtesy Lamps Wiring Diagram (2 of 3) for Saab 9-5 Aero 2011: 49 (body harness, in main bundle between g201 & formed conduit near left front seat) j305 (driver door harness, in branch between speaker & lower door grommet) j502 (right rear door harness, in main bundle between lower grommet & break out to speaker) Ajar sw sig lh front door Ajar sw sig rh front door B11 Center console compartment lamp Computer data lines system Driver door accent lamp Driver door courtesy lamp Driver door handle accent lamp Driver door latch assembly Driver window motor G201 (left kick panel) G203 (left end of dash) G206 (left center of dash) G302 (right kick panel) J210 J214 (instrument panel harness, in main bundle near instrument cluster) J220 J301 J345 (body harness, in branch between formed conduit at center floor & formed conduit near right front seat) x500 J509 J602 J609 J701 J702 (left rear door harness, in main bundle between lower grommet & break out to speaker) J801 J802 Left instrument panel courtesy lamp Left rear door accent lamp Left rear door handle accent lamp Nca Network bus 3 Passenger door accent lamp Passenger door courtesy lamp Passenger door handle accent lamp Passenger door latch assembly Passenger window motor Right instrument panel courtesy lamp Right rear door accent lamp Right rear door handle accent lamp X200 X207 X300 X500 X600 X700 X800 Courtesy Lamps Wiring Diagram (3 of 3) for Saab 9-5 Aero 2011 List of elements for Courtesy Lamps Wiring Diagram (3 of 3) for Saab 9-5 Aero 2011: 37 (body harness, in main bundle between breakout to left front door inline & g201) j241 (body harness, in main bundle between g201 & formed conduit near left front seat) j310 (body harness, in main bundle between g401 & breakout to left rear wheel well) j411 Computer data lines system Driver outside rearview mirror G201 (left kick panel) G302 (right kick panel) G306 (right rear of luggage compt) G401 (left side of luggage compt) Inside rearview mirror J400 J409 J410 J509 J609 J701 J801 Lamp sply voltage Left rear compartment courtesy lamp Left rear door latch assembly Left rear window switch (w/ express down) left rear window motor (w/ express up/down) Left tail lamp assembly Lr door ajar sw sig Nca Network bus 4 Passenger outside rearview mirror Rearview camera (rear of vehicle) Right rear compartment courtesy lamp Right rear door latch assembly Right rear window switch (w/ express down) right rear window motor (w/ express up/down) Right tail lamp assembly Rr door ajar sw sig W/ express down W/ express up/down X411 X500 X600 Instrument Illumination Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Instrument Illumination Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 58 (console harness, in main bundle between ignition mode switch & multifunction switch- center console) Between breakout to side impact sensor- left front & formed conduit near left front seat) Body control module (left end of dash) Center console multi- function switch Child lockout ind Computer data lines system Cruise control system Dimm ctrl Dimmer sw + Dimmer sw - Flexride mode system switch Front dome/reading lamps Front fog lp sw Fuse 30a G201 (left kick panel) G206 (left center of dash) G302 (right kick panel) Garage door opener Gmlan serial data + Gmlan serial data - Headlamp switch Hot at all times Ind dimm ctrl Instrument panel fuse block (left end of dash) Instrument panel multi- function switch J211 (instrument panel harness, in branch leading to steering column) J301 J302 J346 J347 (headliner harness, in main bundle between dome/reading lamp - front & sunshade - left) J509 J609 J701 J801 Led dimm ctrl Left rear window switch Lighting ctrl sw ref Lighting ctrl sw sig Logic Lp sw rear fog Outside rearview mirror switch Passenger window switch Right rear window switch Sply vol sig Sport mode switch Sunroof sunshade switch Sunroof switch Ultrasonic intrusion sensor disable switch W/ express up/down W/ flexride mode system switch w/o parking aid & lane departure warning W/ parking aid & lane departure warning w/o W/ parking aid, lane departure warning & flexride mode system switch X210 X397 X500 X600 X700 X800 Instrument Illumination Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Instrument Illumination Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 29 (instrument panel harness, in main bundle in formed conduit, near center of instrument panel) j221 Cigarette lighter receptacle Computer data lines system G203 (left end of dash) G206 (left center of dash) G305 (under driver's seat) Head-up display switch Headlamp switch Instrument cluster J113 J207 J220 J301 J303 J304 Left steering wheel controls switch Logic Multi- function center console switch module Multi- function instrument panel switch Night panel switch Park brake switch (under center console) Pnk Right steering wheel controls switch Sport mode switch Steering wheel air bag coil (top of steering column) x3 System switch W/ flexride mode system switch W/o flexride mode X210
MEMORY SYSTEMS Memory Mirrors Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Memory Mirrors Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 33 Common ctrl Defogger system Down Driver outside rearview mirror folding motor Driver outside rearview mirror glass Driver outside rearview mirror motor Driver outside rearview mirror switch Folding switch Fuse 7.5a G201 (left kick panel) Gnd Hot w/ ignition relay energized Ign Interconnect bus 8 J508 J515 Left Logic Low ref Mirror dimming Mirror system Motor fold in ctrl Motor fold out ctrl Nca Outside rearview mirror switch Power windows system Right Rt (+) lt (-) ctrl Sel left Sel right Underhood fuse block (left side of engine compt) Up (+) down (-) ctrl X500 Memory Mirrors Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Memory Mirrors Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 14 Computer data lines system Defogger system G302 (right kick panel) J609 J615 Logic Mirror dimming Mirror system Passenger outside rearview mirror folding motor Passenger outside rearview mirror glass Passenger outside rearview mirror motor Passenger outside rearview mirror switch Passenger window switch X600 Memory Seat Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Memory Seat Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 19 (under driver's seat) g305 Computer data lines system Driver back seat heating element Driver front seat vertical motor (under driver seat) Driver memory seat switch Driver rear seat vertical motor (under driver seat) Driver seat cushion heating element Driver seat memory control module (under driver's seat) Fuse 13 circuit breaker 25a Fuse 5a Hot at all times Instrument panel fuse block (left end of dash) J354 Passenger back seat heating element Passenger seat cushion heating element Set X200 X301 X307 Memory Seat Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Memory Seat Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 19 (driver's front seat back) driver lumbar seat support horizontal motor (driver's front seat back) driver lumbar seat support vertical motor (not used) Computer data lines system Down Driver seat adjuster switch Driver seat horizontal motor (under driver seat back) Driver seat lumbar support switch Driver seat memory control module (under driver's seat) Driver seat recline motor (under driver seat back) Fwd G305 G305 (under driver's seat) J319 J351 J354 Rwd Seats system X301
NAVIGATION Blind Spot Monitoring Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Blind Spot Monitoring Wiring Diagram for Saab 9-5 Aero 2011: 24 Backup lp sply volt x7 Body control module (left end of dash) Camera drain wire Camera sig + Camera sig - Camera sig 2 Camera sig 2+ Exterior lights system Fuse 53 10a G304 (left kick panel) Ground Hot w/ ignition run relay energized Ign volt 1 J241 (body harness, in main bundle between breakout to left front door inline & g201) J416 J903 Nca Radio Rearview camera (rear of vehicle) Sply volt Underhood fuse block (left side of engine compt) X204 X407 X411 Lane Departure Warning Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Lane Departure Warning Wiring Diagram for Saab 9-5 Aero 2011: 23 Battery positive voltage Computer data lines system Driver outside rearview mirror Drv side object detection led sig Fuse 10a G201 (left kick G302 (right kick G304 (left kick panel) Hot at all times J403 J509 J609 Left side object sensor Low speed gmlan Low speed gmlan serial data Panel) Pass side object detection led sig Passenger outside rearview mirror Rear body fuse block (left side of luggage compt) Right side object sensor Sig gnd X500 X600 Navigation Wiring Diagram, with Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011: 73 (instrument panel harness, on branch leading to info display module) (or 5839) (or 5843) (right kick panel) Amplifier ctrl Anti-lock brakes system Audio common sig Audio sig Aux audio screen Auxiliary audio sig Batt+ volt Camera sig Cellular phone navigation & digital radio antenna (w/ digital system s band) Coax Computer data lines Computer data lines system Detection sig Display reset sig Display sig+ Display sig- Drain wire Fuse 10a Fuse 15a Fuse 20a G205 Gmlan serial - Gmlan serial data Gmlan serial data + Ground Hot at all times Instrument panel fuse block (left end of dash) J205 J219 J222 Lf aud sig Lf lo level aud- Lf rr seat aud sig Lf rr spkr+ Lf spd sig Lines system Lo level audio sig Lo level audio sig+ Lo level audio sig- Lo level audio- Lo refr Lo spd gmlan Nav+ Nav- Navigation & traffic data antenna Navigation antenna Navigation system Nca Radio Remote audio Remote enable sig Rf lo level aud- Rh aud sig Rh rr seat aud sig Rr au drain wire Rr spkr sig - Satellite radio circuit Serial data hi Serial data lo Shield Stack reset sig Telephone voice sig W/ navigation display W/ upj W/o navigation display W/o upj Wake-up sig X204 X207 Navigation Wiring Diagram, with Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011: 53 (right kick panel) (w/ gid) info display module A14 A15 Aud sig Audio sig B14 B15 Batt pos volt Batt+ Batt+ volt Cellular phone antenna Coax Comm sig Computer data lines system Data hi Data lo Data sh Drain wire G205 Gnd Ground Ir aud sig J201 Lo refr Logic Lr aud sig Mobile telephone control module (center of dash) Navigation and traffic data antenna Nca Net bus Net- bus 9 Radio antenna Radio antenna module (on right "c" pillar) Radio/hvac control Rear audio control module Reset sig Rr aud sig Serial data hi Serial data lo Serial data sh Voice sig W/ information display, color info display (cid) W/ onstar W/o information display, color info display (cid) W/o onstar Wake up sig Wake-up sig X200 X208 X210 X300 X301 Navigation Wiring Diagram, with Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011: 51 (body harness, in main bundle between breakout to side impact sensor left front & formed conduit near left b-pillar) (left end of dash) body control module (bcm) (right kick panel) Amplifier ctrl Audio amplifier (right side of luggage compt) Batt+ volt Computer data lines system Cruise control system Ctrl sw ref Fr center spkr Fr center spkr + Fr lo level audio G205 Ground Hi spd gmlan serial data+ Hi spd gmlan serial data- Interior lights system J320 Lader sig 1 Left subwoofer speaker Lf lo level audio- Lf rr speaker + Lf speaker + Lf speaker sig- Lo level audio Lo level audio sig Lo level audio sig lo level audio sig Lo level audio- Lr speaker - Lr speaker out + Lr spkr sig - Lr wfr speaker- Mute Nca R speaker out + Remote enable sig Rf speaker sig- Rf spkr + Rh rr speaker - Rh subufr - Right steering wheel control switch Right subwoofer speaker Rr lo level audio- Rr spkr sig - Seek down Seek up Source Steering wheel air bag coil (top of steering column) Voice Vol + Vol - Navigation Wiring Diagram, with Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011: 33 (body harness, in main bundle between breakout to side impact sensor - left front & formed conduit near left b-pillar) (body harness, in main bundle between g302 & formed conduit near right front seat) (instrument panel harness, in main bundle near data link resistor) (left kick panel) g201 Batt+ volt Bright ctrl Driver seatback video display Dvd vid sig+ Dvd vid sig- Enable sig G201 (left kick panel) G205 (right kick panel) Gnd Info display module (w/ cid & wvga touch screen) J201 J222 J322 J342 J343 J356 J366 Module sig Nca Nca drain wire Nca s Passenger seatback video display Sig + Video sig+ Video sig- X1 sig - X204 X301 X307 Navigation Wiring Diagram, with Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011: 47 Aud comm sig Aud screen Audio com sig Audio/video input adapter Aux sig Auxiliary audio input Batt + Bright ctrl Computer data lines system D wire Drain wire Dvd ado shld G205 (right kick panel) Gnd High sig J201 L spd data Lf aud sig Lf aud sig 2 Lf sig 3 Lh dvd sig + Low sig Lt audio sig 1 Mid spd Module sig Multimedia player interface module (right end of dash) Nca Radio Red Rh aud sig Rh aud sig 2 Rh audio sig 1 Rh sig 3 Rmt inf sig - Sig Sig 2 Sig 3 Vid sig - Video mode 2 Video sig 2+ Video sig 2- Video sig- W/ audio interface W/o audio interface X204 X210 X216 Navigation Wiring Diagram, with Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, with Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011: 61 (driver door harness, in branch between speaker & lower door grommet) (passenger door harness, in branch between speaker & lower door grommet) Batt + volt Batt sply volt Cellular phone microphone Cellular phone navigation & digital radio antenna Center instrument panel speaker Coax Computer data lines system Display color info display Fuse 35 30a G205 (right kick panel) G304 (left kick panel) Gnd Hot at all times Inside rear view mirror J201 J244 J335 J503 J504 J603 J604 Keypad sig Left front speaker Left front tweeter speaker Left rear speaker Left surround speaker Lo ref Lo refr Lo spd data Logic Lp ref Micro ph sig Navigation antenna signal splitter Nca Red led Right front speaker Right front tweeter speaker Right rear speaker Right surround speaker Serial data Serial data + Serial data - Shield Sply volt Tele voice sig Telematics button assembly Telematics communication interface control module (w/ onstar) (center of dash) Telematics communication interface control module battery Underhood fuse block (left side of engine compt) Voice aud sig W/ infotainment W/ light sensitive mirror & w/o lane departure warning & windshield wiper system W/ light sensitive mirror, lane departure warning & windshield wiper system W/o infotainment display color info display X200 X500 X600 X700 X800 Navigation Wiring Diagram, without Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011: 76 (right kick panel) Amplifier ctrl Anti-lock brakes system Audio common sig Audio sig Audio signal (1) Aux audio screen Auxiliary audio sig Batt+ volt Camera sig + Camera sig - Coax Computer data lines Computer data lines system Data wire Detection sig Display reset sig Display sig+ Display sig- Drain wire Fr audio drain wire Fuse 10a Fuse 15a Fuse 20a G205 Gmlan serial cata + Gmlan serial cata - Gmlan serial data Ground Hot at all times Instrument panel fuse block (left end of dash) J205 J219 J222 Lf lo level aud- Lf rr seat aud sig Lf rr spkr+ Lines system Lo level audio sig+ Lo level audio sig- Lo level audio- Lo refr Lo spd gmlan Navi+ Navi- Navigation & traffic data antenna Navigation antenna Navigation system Nca Radio Radio audio (-) Radio lf aud sig Remote enable sig Rf lo level aud- Rh rr seat aud sig Right audio sig 2 Rr au drain wire Rr spkr sig - Satellite radio circuit Serial data hi Serial data lo Shield Speed sensor sig Stack reset sig Telephone Telephone voice sig Usb W/ cellular W/ infotainment display W/ infotainment display color info display (cid) w/o onstar W/ premium 9 or 7 speaker system W/o cellular W/o infotainment display Wake-up sig X204 X207 Navigation Wiring Diagram, without Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011: 52 (w/ information display graphic info display (gid)) info display module A14 A15 Aud sig Audio sig B14 B15 Batt pos volt Batt+ Batt+ volt Cellular phone antenna Coax Comm sig Computer data lines system Data hi Data lo Data sh Drain wire G205 (right kick panel) Gnd Ground J201 Lo refr Logic Lr aud sig Mobile telephone control module (center of dash) Navigation & traffic data antenna Nca Net bus Net- bus 9 Radio antenna (integral to rear window) Radio antenna module (on right "c" pillar) Radio/hvac control Rear audio control module (if equipped) Red aud sig Reset sig Rr aud sig Serial data hi Serial data lo Serial data sh Up sig Voice sig W/ information display graphic info display (gid) W/ onstar W/o information display graphic info display (gid) W/o onstar Wake-up sig X200 X206 X210 X300 X301 Navigation Wiring Diagram, without Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011: 20 (body harness, in main bundle between breakout to side impact sensor - left front & formed conduit near left b-pillar) Body control module (bcm) (left end of dash) Computer data lines system Cruise control system Ctrl sw refr Hi spd gmlan serial data+ Hi spd gmlan serial data- Interior lights system J320 Lader sig 1 Mute Nca Right steering wheel control switch Seek down Seek up Src Steering wheel air bag coil (top of steering column) Voice Vol + Vol - Navigation Wiring Diagram, without Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011: 44 (body harness, in main bundle between breakout to side impact sensor) (driver door harness, in branch between speaker & lower door grommet) (instrument panel harness, in main bundle near data link resistor) (instrument panel harness, on branch leading to radio x1) (left kick panel) g201 Batt+ volt Bright ctrl Driver seatback video display Dvd video + Dvd video - Enable sig Enable sig + G201 (left kick panel) G205 (right kick panel) Gnd Info display module (w/ infotainment display color info display (cid)) J201 J245 J322 J323 J342 J343 J356 J366 J503 (driver door harness, in branch between speaker & lower door grommet) J504 Left front speaker Left front tweeter speaker Left rear speaker Module sig Nca Nca drain wire Nca s Passenger seatback video display Right rear speaker Video sig+ Video sig- X200 X204 X301 X307 X500 X700 X800 Navigation Wiring Diagram, without Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011: 54 (instrument panel harness, on branch leading to radio x1) (passenger door harness, in branch between speaker & lower door grommet) Aud comm sig Aud screen Audio/video input adapter Aux sig Auxiliary audio input Batt + Bright ctrl Center console speaker Coax Computer data lines system D wire Drain wire Fh video sig G205 (right kick panel) Gnd J201 J246 J603 J604 L spd data Lf aud sig Lf aud sig 2 Lf sig 3 Mid spd Module sig Multimedia player interface module (right end of dash) Nca Radio Red Rh aud sig Rh aud sig 2 Rh sig 3 Rh video sig Right front speaker Right front tweeter speaker Sig Sig 2 Sig 3 Video com sig Video hi Video l Video mode 2 Video sig 2+ Video sig 2- Video sig- W/ audio interface W/o audio interface X200 X204 X210 X216 X500 Navigation Wiring Diagram, without Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011 List of elements for Navigation Wiring Diagram, without Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011: 41 (in overhead console) cellular phone microphone Batt + volt Batt sply volt Cellular phone navigation & digital radio antenna Coax Computer data Computer data lines system Display color info display G205 (right kick panel) G304 (left kick panel) Gnd Inside rear view mirror J201 J244 J335 Keypad sig Lo ref Lo refr Lo spd data Logic Lp refr Micro ph sig Navigation antenna signal splitter (right end of dash) Nca Red led Serial data Serial data + Serial data - Shield Sply volt Tele voice sig Telematics button assembly Telematics communication interface control module battery Telematics communication interface control module w/ onstar (center of dash) Voice aud sig W/ digital audio system s-band W/ infotainment W/ light sensitive mirror & w/o lane departure warning & windshield wiper system W/ light sensitive mirror, lane departure warning & windshield wiper system W/o infotainment display color info display X200 Parking Assistant Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Parking Assistant Wiring Diagram for Saab 9-5 Aero 2011: 47 (left kick panel) Battery pos volt Center console multifunction switch Computer data lines system Front parking left corner sens Front parking left mid sens Front parking lf/ri/mi sens Front parking right corner sens Front parking right mid sens Fuse 15a G206 (left center of dash) G304 Hot at all times Instrument panel fuse block (left end of dash) J145 (fuel injector even harness, at top of engine, below intake mainfold, in main bundle) J146 J209 J301 J337 J479 (rear bumper harness, in main bundle between rear object sensor - left middle & rear object sensor - right middle) J480 (rear bumper harness, in main bundle between rear object sensor - left middle & rear object sensor - right middle) Left front parking aid side sensor (on left side of front bumper) Left middle front object sensor (behind left side of front bumper) Left middle rear object sensor (behind left middle of rear bumper) Left outer front object sensor (behind left side of front bumper) Left outer rear object sensor (behind left side of rear bumper) Lf front supp object sens sig Low reference Low speed gmlan serial data Lr corner object sens sig parallel park assist disable switch sig Lr middle object sens sig Park assist sensor sply Parking assist control module (left side of luggage compt) Rear park assist disable signal Rear park assist led disable sig Rf front supp object sens sig Right front parking aid side sensor (on right side of front bumper) Right middle front object sensor (behind right side of front bumper) Right middle rear object sensor (behind right middle of rear bumper) Right outer front object sensor (behind right side of front bumper) Right outer rear object sensor (behind right side of rear bumper) Rr corner object sens sig Rr middle object sens sig Sig ground X110 X200 X406 Rear View Camera Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Rear View Camera Wiring Diagram for Saab 9-5 Aero 2011: 24 (above headliner) Battery positive voltage Center console multi function switch Computer data lines system Fuse 10a G206 (left center of dash) G304 (left kick panel) Hot at all times Instrument cluster J244 J300 J301 Lane departure Led departure warning disable switch sig Led warning indicator control Logic Low Low speed gmlan serial data Rear body fuse block (left side of luggage compt) Sig gnd Spd- Vehicle direction camera control module Warning ind X200
POWER DISTRIBUTION Power Distribution Wiring Diagram (1 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (1 of 6) for Saab 9-5 Aero 2011: 70 (2.0l) (2.8l) (body harness, under cowling, between windshield wiper motor & air quality sensor) j132 (diagram 2 of 6) (in main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) (in main bundle between g201 & formed conduit near left front seat) (in main bundle between g401 & breakout to left rear wheel well) j416 (in main bundle near breakout to recline motor) j365 (left side of engine compt) underhood fuse block Battery Battery fuse block (left rear of engine compt) Driver cushion seat blower motor (w/ fan) Driver seat back blower motor (w/ fan) Driver seat lumbar support switch (if equipped) Driver window motor Electrical auxiliary heater Electronic brake control module Engine control module From fuse 52 j Fuel pump relay Fuse 100a Fuse 10a Fuse 15a Fuse 20a Fuse 250a Fuse 300a Fuse 30a Fuse 50a Fuse 5a Fuse 60a Generator Inside rear view mirror J309 J316 J355 Left headlamp (w/ headlamp leveling) Nca Parking brake control module Passenger cushion seat blower motor (w/ fan) Passenger seat back blower motor (w/ fan) Passenger seat lumbar support switch (if equipped) Passenger window motor Power steering control module Rearview camera Recline motor) Red Right headlamp (w/ headlamp leveling) Secondary air injection pump relay (2.8l) fuse/ heater relay (2.0l) Starter motor Starter relay Tire pressure indicator module To auxiliary underhood fuse block (diagram 5 of 6) To fuse 32 (diagram 5 of 6) To instrument panel fuse block (diagram 2 of 6) To instrument panel fuse block (diagram 4 of 6) To rear body fuse block (diagram 5 of 6) Transmission control module Used) (not W/ light sensitive mirror W/ rearview camera W/ tire pressure indicator W/ tire pressure indicator, light sensitive mirror & rear view camera X110 X120 X200 X301 X307 X407 X500 X600 Power Distribution Wiring Diagram (2 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (2 of 6) for Saab 9-5 Aero 2011: 73 (2.0l) x1 (2.8l) x2 (between windshield wiper motor & air quality sensor) (engine harness, between fuse block - underhood & g120) (left end of dash) instrument panel fuse block 2.0l 2.8l 87a A/t Air quality sensor Body control module Brake booster vacuum switch Cargo accessory power receptacle Circuit breaker 25a Cooling fan medium speed 1 relay Cooling fan medium speed 2 relay Data link connector Driver seat adjuster switch Engine control module From battery fuse block (diagram 1 of 6) From body control module (diagram 6 of 6) From engine control module relay g (diagram 3 of 6) From fuse 9 (diagram 4 of 6) Fuel composition sensor Fuel pump control module (2.8l) Fuse 10a Fuse 15a Fuse 20a Fuse 25a Fuse 30a Fuse 5a Fuse 60a Fuse 7.5a G109 (engine compartment, on left strut tower) G401 Headlamp washer fluid pump relay Hvac control module Ignition main relay Inflatable restraint sensing & diagnostic module Instrument cluster J114 J118 J131 J137 J409 Keyless entry control module M/t Mass air flow sensor Mass air flow/ intake air temperature sensor Overhead console multifunction switch Passenger presence detection module (if equipped) Passenger seat adjuster switch (if equipped) Radio/ hvac controls Red/ Seat adjuster Seat memory control module Steering column lock control module To auxiliary power relay (diagram 4 of 6) To fuse 54 (diagram 1 of 6) Transmission control module Underhood fuse block (left side of engine compt) W/ manual front seat adjuster W/ memory W/ on star W/o manual front W/o memory Windshield wiper relay Windshield wiper speed control relay X108 X200 X301 X307 X398 Power Distribution Wiring Diagram (3 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (3 of 6) for Saab 9-5 Aero 2011: 55 (2.0l) (2.8l) (at top of engine, below intake manifold, in main bundle) (engine harness, in formed conduit by throttle body) j119 (engine harness, in formed conduit near g123) (not used) 2.0l 2.8l A/c compr- essor clutch relay Cooling fan high speed relay Cooling fan left medium speed relay Cooling fan medium speed 1 relay Cooling fan medium speed 2 relay Cooling fan relay Cooling fan right medium speed relay Cooling fan speed control 2 relay Cooling fan speed control relay Engine control module Engine control module relay From fuse 46 l (diagram 3 of 6) From fuse 70 f (diagram 5 of 6) Front fog lamp relay Fuel injector Fuse 10a Fuse 15a Fuse 60a 30a Headlamp high beam relay Headlamp low beam relay Ignition coil 1 Ignition coil 2 Ignition coil 2 (2.8l) Ignition coil 3 Ignition coil 4 Ignition coil 4 (2.8l) Ignition coil 5 Ignition coil 6 (2.8l) J106 (between main bundle & relay block - underhood) J120 (in formed conduit by throttle body) J121 J144 Rear defogger relay Rear window washer pump relay Right cooling fan medium speed relay To fuse 11 (diagram 6 of 6) To fuse 9 (diagram 3 of 6) To ignition main relay (diagram 2 of 6) Underhood fuse block (left side of engine compt) Underhood relay block Underhood relay block (left side of engine compt) W/ dual fan W/ hid W/ single fan Windshield washer pump relay X117 X160 (fuel injector even harness, at top of engine, below intake manifold, in main bundle) j145 Power Distribution Wiring Diagram (4 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (4 of 6) for Saab 9-5 Aero 2011: 56 (if equipped) (in branch between breakout to hvac control module & steering column) (in main bundle near data link resistor) (in main bundle rearward of formed conduit near left "b" pillar) j323 (instrument panel harness, in main bundle in formed conduit, near center of instrument panel) j219 (left end of dash) A/t Auxiliary power relay Block - instrument panel) Blower motor control module Body control module Center console accessory power receptacle Cigarette lighter receptacle Digital radio receiver control module Driver seatback video display (if equipped) Entertainment package From battery fuse block (diagram 1 of 6) From fuse 24 (diagram 2 of 6) Fuse 10a Fuse 15a Fuse 20a Fuse 25a Fuse 30a Fuse 50a G203 G305 Head-up display (w/ rearview camera) Info display module (if equipped) Instrument panel fuse block Instrument panel fuse block (left end of dash) Interior lights system J113 J208 J222 J223 (in main bundle near fuse block - instrument panel) J224 (in main bundle near fuse block - instrument panel) J248 M/t Mobile telephone control module (w/ wireless interface) Multimedia player interface module Parking assist control module Passenger seatback video display (if equipped) Radio Radio/ hvac controls (w/ info- tainment display) Rear audio control module (if equipped) Security siren (if equipped) To circuit breaker 12 (diagram 2 of 5) Transmission shift lever W/ rear seat W/o rear seat X200 X200 (body harness, in main bundle rearward of formed conduit near left b-pillar, near c-pillar) j338 X204 X210 X301 X307 Power Distribution Wiring Diagram (5 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (5 of 6) for Saab 9-5 Aero 2011: 71 (if equipped) (in branch between window switch - driver & lower door grommet) j508 (in main bundle between g201 & formed conduit near left front seat) j307 (in main bundle rearward of formed conduit near left b-pillar, near c-pillar) j340 (left side of luggage compt) underhood fuse block 2.0l 2.8l Audio amplifier Auxiliary blower motor control module (w/ rear fan) Auxiliary electrical heater Auxiliary underhood fuse block Body control module Brake booster pump motor Cruise control vehicle distance sensor module (if equipped) Driver window switch Evaporative emission vent solenoid valve Express down Express up/down Formed conduit at center floor & formed conduit near right front seat) j344 From battery fuse block (diagram 1 of 6) From battery fuse block e (diagram 1 of 6) From fuse 27 (diagram 1 of 6) From underhood fuse block (diagram 1 of 6) Fuel pump control module Fuse 100a Fuse 10a Fuse 20a Fuse 25a Fuse 30a Fuse 5a Fuse 60a Fuse 7.5a Fuse 80a Garage door opener Glow plug control module (2.0l) Headlamp control module Horn relay Inside rearview mirror Keyless entry control module Keyless entry control module (2.8l) Left rear window motor Left rear window switch Left side object sensor (if equipped) Outside rearview mirror switch Overhead console multi- function switch Passenger window switch Rain sensor Rear body fuse block (left side of engine compt) Rear differential clutch control module (awd) Rear wiper relay Right rear window motor Right rear window switch Right side object sensor (if equipped) Seat heating control module Sun roof motor Sunroof sunshade motor module (if equipped) Suspension control module (w/ continuously variable real time damping) To engine control module relay (diagram 3 of 6) Underhood relay block Vehicle direction camera control module (if equipped) X117 X12 X300 X301 X397 X403 X408 X500 X600 X700 X800 Power Distribution Wiring Diagram (6 of 6) for Saab 9-5 Aero 2011 List of elements for Power Distribution Wiring Diagram (6 of 6) for Saab 9-5 Aero 2011: 50 (engine harness, between fuse block - underhood & g120) j117 (engine harness, in branch between g120 & main bundle) j129 (engine harness, in formed conduit by throttle body) j120 (engine harness, in formed conduit near g123) (left side of engine compartment) underhood fuse block 2.0l 2.8l A10 A12 Accy B12 Body control module (left end of dash) Engine control module Engine start/ stop Evaporative emission purge solenoid valve Exhaust camshaft position actuator solenoid valve bank 1 Exhaust camshaft position actuator solenoid valve bank 2 From fuse 8 (diagram 3 of 6) Fuse 10a Fuse 15a G206 (left center of dash) Heated oxygen sensor 1 Heated oxygen sensor 1 bank 1 Heated oxygen sensor 2 Heated oxygen sensor 2 bank 1 Ign mode sw acc led sig Ign mode sw mode volt Ign mode sw off led sig Ign mode sw st led sig Ignition mode switch Intake camshaft position actuator solenoid valve bank 1 Intake camshaft position actuator solenoid valve bank 2 J130 J147 J211 Keyless entry control module (right kick panel) Low ref Nca Passive st sw sig 2 Run/crank ign 1 volt Run/crank ign 1 volt x3 Run/crank rly coil ctrl To underhood fuse block (diagram 2 of 6) Turbo- charger bypass solenoid valve Turbo- charger wastegate solenoid valve Turbocharger bypass solenoid valve Turbocharger wastegate solenoid valve X200 X210 X300
POWER DOOR LOCKS Power Door Locks Wiring Diagram, with Passive Keyless Entry (1 of 3) for Saab 9-5 Aero 2011 List of elements for Power Door Locks Wiring Diagram, with Passive Keyless Entry (1 of 3) for Saab 9-5 Aero 2011: 70 (behind center of rear bumper) rear fascla keyless entry antenna (center front of luggage compt) rear compartment keyless entry antenna (front of center console) center console front keyless entry antenna (left end of dash) (rear of center console) center console rear keyless entry antenna A13 Acc volt Ant 1 sig hi Ant 1 sig lo Ant 2 sig hi Ant 2 sig lo Ant 3 sig hi Ant 3 sig lo Ant sig hi Ant sig lo B13 Bat pos volt Co drv ant sig lo Co drv dr ant sig hi Co drv extr sw lk sig Co drv handle sw sig Co drv mtr unlatch rtn Co drv unlatch ctrl Computer data lines system Driver interior door handle switch Drv dr handle sw sig Drv mtr unlatch ctrl Drv mtr unlatch rtn Drv unlatch sig Exterior door handle switch Fuse 30a Fuse 5a G302 G304 G304 (right kick panel) Gnd Handle sw sig Hot at all times Instrument panel fuse block J335 J337 J341 Keyless entry control module (right kick panel) Left rear Lo ref Lo spd gmlan ser data Lr dr handle sw sig Lr mtr unlatch rtn Lr unlatch ctrl Nca Passenger interior door handle switch Passive start sw sig 2 Right rear exterior door handle switch Rr closure ant sig hi Rr dr handle sw sig Rr mtr unlatch ctrl Rr mtr unlatch rtn Run/crank ign 1 vol Shift interlock system Sig gnd Starting/ charging system Steering column lk sig Tan Underhood fuse block (left side of engine compt) X200 X299 X500 X600 X700 X800 Power Door Locks Wiring Diagram, with Passive Keyless Entry (2 of 3) for Saab 9-5 Aero 2011 List of elements for Power Door Locks Wiring Diagram, with Passive Keyless Entry (2 of 3) for Saab 9-5 Aero 2011: 37 (in driver's door) driver window motor (in main bundle between breakout to left front door inline & g201) j233 (in main bundle between g201 & formed conduit near left front seat) j311 (in main bundle between g201 & formed conduit near left front seat) j312 (in passenger's door) passenger window motor (left rear door harness, in main bundle between door latch assembly & breakout to window motor) j703 (left side of engine compt) underhood fuse block (right kick (right rear door harness, in main bundle between door latch assembly & breakout to window motor) j803 Door lock security relay Driver door latch assembly G109 (engine compt, on left strut tower) G201 (left kick panel) G302 G302 (right kick panel) J314 (in main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) J315 (in main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) J701 J801 Left rear door latch assembly Left rear window motor Lf dr ajar sw sig Lh rr dr ajar sw sig Panel) Passenger door latch assembly Right rear door latch assembly Sw sig rf dr ajar Tan Trunk, tailgate, fuel doors system W/ express up/down W/ theft deterent body security content W/o express down W/o theft deterent body security content X500 X600 X700 X800 Power Door Locks Wiring Diagram, with Passive Keyless Entry (3 of 3) for Saab 9-5 Aero 2011 List of elements for Power Door Locks Wiring Diagram, with Passive Keyless Entry (3 of 3) for Saab 9-5 Aero 2011: 62 (left end of dash) instrument panel fuse block (left kick panel) g304 Acc volt Actuator recv sig Actuator rtn Actuator sply volt Actuator transmit sig Ajar sw sig rh rr dr Bat pos volt Body control module (left end of dash) Computer data lines system Door lock security relay Dr acutator lk ctrl 2 Dr lk ctrl Dr unlk ctrl Drive exterior door handle assembly Driver door handle keyless entry antenna Driver exterior door handle switch Driver information center display Drv dr unlatch sig Fuse 5a G203 G203 (left end of dash) G304 (left kick panel) G401 (left side of luggage compt) Gmlan ser data + Gmlan ser data - Gnd Hdlp hi beam rly ctrl Headlights system Horn relay ctrl Horns system Hot all times Instrument panel cluster (ipc) J113 J220 J335 J337 J410 Lift gate ajar sw sig Lk rey ctrl Logic Lr security lk mtr sig Nca Non drv unlatch sig Passenger door handle keyless entry antenna Passenger exterior door handle assembly Passenger exterior door handle switch Rear compartment lid latch Remote control door lock receiver (above inside rearview mirror) Right rear window motor Rr security lk mtr sig Run/crank ign 1 volt Security indicator Security lk rly ctrl Tan Underhood fuse block (left side of engine compt) W/ express up/down W/o express down X200 X500 X600 Power Door Locks Wiring Diagram, without Passive Keyless Entry for Saab 9-5 Aero 2011 List of elements for Power Door Locks Wiring Diagram, without Passive Keyless Entry for Saab 9-5 Aero 2011: 79 (in main bundle between breakout to side impact sensor lf & formed conduit near lf seat) (in main bundle between lower grommet & breakout to speaker) j803 (left end of dash) g203 (left end of dash) instrument panel fuse block (left side of engine compt) (w/ theft deterent body security content) underhood fuse block Actr rtn Actr unlck ctrl Batt pos volt Body control module (left end of dash) Center display Child lkout ind Child lockout security ind Computer data lines system Door lock security relay Dr lck ctrl (2) Dr lk ctrl Driver Driver door latch assembly Driver window motor (in driver's door) Drv dr lk sw lk sig Drv dr lk sw unlk sig Fuse 5a G109 (engine compt, on left strut tower) G201 (left kick panel) G203 (left end of dash) G302 (right kick panel) G401 (left side of luggage compt) Gmlan ser data (+) Gmlan ser data (-) Hdlp hi beam rly ctrl Headlights system horns system Horn rly ctrl Hot at all times Information Instrument panel cluster (ipc) Instrument panel multifunction switch Interior lights system J113 J233 (in main bundle between breakout to lf door inline & g201) J311 (in main bundle between g201 & formed conduit near lf seat) J312 (in main bundle between g201 & formed conduit near lf seat) J314 (in main bundle between breakout to side impact sensor - lf & formed conduit near lf seat) J315 J410 J509 J609 J701 J801 Left rear door latch assembly Lf dr ajar sw sig Lk rly ctrl Logic Lr lk mtr status sig Passenger door latch assembly Passenger window motor (in passenger's door) Rcv sig Rear compartment lid latch Remo actr sply volt Remo actr trans sig Remo func actr rtn Remote control door lock receiver (above inside rearview mirror) Rf dr ajar sw sig Right rear door latch assembly Rr lk mtr status sig Security content Security indicator Security lk rly ctrl Security lk sw sig Sply volt Trans sig Trunk, tailgate, fuel doors system Underhood fuse block (left side of engine compt) W/ theft deterent body W/o theft deterent body X200 X500 X600 X700 X800
POWER MIRRORS Electrochromic Mirror Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Electrochromic Mirror Wiring Diagram for Saab 9-5 Aero 2011: 42 (body harness, in main bundle between breakout to left front door inline & g201) j239 Ambient light sensor Body control module (left end of dash) Computer data lines system Driver outside rearview mirror Driver outside rearview mirror glass Emergency ind Emergency switch Exterior lights system Fuse 10a G304 (left kick panel) Green led Headlight sensor Hot at all times Hot w/ ignition relay energized Ign Inside rearview mirror J240 (body harness, in main bundle between breakout to left front door inline & g201) J241 (body harness, in main bundle between breakout to left front door inline & g201) J335 Keypad green led Keypad red led Keypad sig Keypad sply volt Logic Low ref Mirror dimming Onstar ind Onstar switch Passenger outside rearview mirror Passenger outside rearview mirror glass Phone ind Phone switch Rear body fuse block (left side of luggage compt) Red led Sig Sply volt Telematics communication interface control module (center of dash) Underhood fuse block (left side of engine compt) X200 X500 X600 Power Mirror Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Power Mirror Wiring Diagram for Saab 9-5 Aero 2011: 38 Common ctrl Computer data lines system Defogger system Down Driver outside rearview mirror Driver outside rearview mirror folding motor Driver outside rearview mirror motor Electrochromic mirror circuit Folding switch Fuse 7.5a G201 (left kick panel) Hot w/ ignition relay energized Ign Interconnect bus 8 J506 (driver door harness, in branch between outside rearview mirror switch & lower door grommet) J507 (driver door harness, in branch between outside rearview mirror switch & lower door grommet) J509 J515 nca J615 Left Logic Low ref Mirror dimming Motor fold in ctrl Motor fold out ctrl Nca Outside rearview mirror switch Passenger outside rearview mirror Passenger outside rearview mirror folding motor Passenger outside rearview mirror motor Right Rt (+) lt (-) ctrl Sel left Sel right Underhood fuse block (left side of engine compt) Up (+) down (-) ctrl X500 X600
POWER SEATS Driver Power Seat Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Driver Power Seat Wiring Diagram for Saab 9-5 Aero 2011: 17 Circuit breaker 25a Down Driver seat adjuster switch Driver seat front vertical motor (under driver's front seat) Driver seat horizontal motor (under driver's front seat) Driver seat rear vertical motor (under driver's front seat) Driver seat recline motor (in driver front seat back) Fwd G305 (under driver's seat) Hot at all times Instrument panel fuse block (lower left side of dash) J319 Recline fwd Recline rwd Rwd X200 X301 Driver"s Lumbar Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Driver"s Lumbar Wiring Diagram for Saab 9-5 Aero 2011: 12 Down Driver seat lumbar adjuster valve assembly Driver seat lumbar support pump Driver seat lumbar support switch Fuse 15a Fwd G305 (under driver's seat) Hot at all times J354 Rwd Underhood fuse block (left side of engine compt) X301 Heated Seats Wiring Diagram, with Memory for Saab 9-5 Aero 2011 List of elements for Heated Seats Wiring Diagram, with Memory for Saab 9-5 Aero 2011: 36 (driver seat harness, in main bundle near breakout to recline motor) j355 (passenger seat harness, in main bundle near breakout to recline motor) j365 Circuit breaker 25a Computer data lines system Driver back seat blower motor Driver back seat heating element Driver back switch Driver cushion seat blower motor Driver cushion seat heating element Driver cushion switch Driver seat memory control module (under driver's seat) Fuse 10a Fuse 5a G305 (under driver's G305 (under driver's seat) Hot at all times Hot w/ ignition main relay energized Instrument panel fuse block (left end of dash) J350 (driver seat harness, in main bundle near breakout to seat horizontal motor) J354 J360 (passenger seat harness, in main bundle past breakout to anchor pretensioner) J364 Logic Main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) Passenger back seat blower motor Passenger back seat heating element Passenger back switch Passenger cushion back switch Passenger cushion seat blower motor Passenger cushion seat heating element Radio/hvac controls Seat) Underhood fuse block (left side of engine compt) X200 X301 X307 Heated Seats Wiring Diagram, without Memory for Saab 9-5 Aero 2011 List of elements for Heated Seats Wiring Diagram, without Memory for Saab 9-5 Aero 2011: 32 (driver seat harness, in main bundle near breakout to recline motor) j355 (passenger seat harness, in main bundle near breakout to recline motor) j365 Computer data lines system Driver back seat blower motor Driver back seat heating element Driver back switch Driver cushion seat blower motor Driver cushion seat heating element Driver cushion switch Driver seat heating control module (under driver's seat) Fuse 10a Fuse 25a G305 (under driver's G305 (under driver's seat) Hot w/ ignition main relay energized In main bundle between breakout to side impact sensor - left front & formed conduit near left front seat) J350 (driver seat harness, in main bundle near breakout to seat horizontal motor) J354 J360 (passenger seat harness, in main bundle past breakout to anchor pretensioner) J364 Logic Passenger back seat blower motor Passenger back seat heating element Passenger back switch Passenger cushion back switch Passenger cushion seat blower motor Passenger cushion seat heating element Radio/hvac controls Seat) Underhood fuse block (left side of engine compt) X301 X307 Passenger Power Seat Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Passenger Power Seat Wiring Diagram for Saab 9-5 Aero 2011: 17 Circuit breaker 25a Down Fwd G305 (under driver's seat) Hot at all times Instrument panel fuse block (left end of dash) J319 Passenger seat adjuster switch Passenger seat front vertical motor (under passenger's front seat) Passenger seat horizontal motor (under passenger's front seat) Passenger seat rear vertical motor (under passenger's front seat) Passenger seat recline motor (in passenger front seat back) Recline fwd Recline rwd Rwd X200 X307 Passenger"s Lumbar Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Passenger"s Lumbar Wiring Diagram for Saab 9-5 Aero 2011: 12 Down Fuse 15a Fwd G305 (under driver's seat) Hot at all times J364 Passenger seat lumbar adjuster valve assembly Passenger seat lumbar support pump Passenger seat lumbar support switch Rwd Underhood fuse block (left side of engine compt) X307
POWER TOP/SUNROOF Power Top/Sunroof Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Power Top/Sunroof Wiring Diagram for Saab 9-5 Aero 2011: 31 (left kick panel) g201 (left side of luggage compt) g401 Batt pos volt Close Close express Computer data lines system Express close Express open Fuse 25a Fuse 30a G201 (left kick panel) G401 (left side of luggage compt) Gnd Hot at all times Interior lights system J318 J336 J409 J410 Lo ref linear interconnect network bus 1 fr sunshade sw sig Lo ref linear interconnect network bus 1 sunroof sw data 1 Logic Open Open express Rear body fuse block (left side of luggage compt) Sunroof control module (forward of sunroof) Sunroof sunshade motor module (top center rear of roof) Sunroof sunshade switch Sunroof switch Underhood fuse block (left side of engine compt) X397
POWER WINDOWS Power Windows Wiring Diagram, with Express Down (1 of 2) for Saab 9-5 Aero 2011 List of elements for Power Windows Wiring Diagram, with Express Down (1 of 2) for Saab 9-5 Aero 2011: 36 (left kick panel) Ajar sw sig B+ volt Computer data lines system Door locks system Down Down sig Driver window motor Driver window switch Express Express sig Fuse 30a Fuse 7.5a G201 G201 (left kick panel) G302 (right kick panel) Gnd Hot at all times J309 J505 J508 J509 J605 J609 Lock out ind Logic Network bus 3 Passenger window motor Passenger window switch Underhood fuse block (left side of engine compt) Up sig Window switch left rear Window switch right front Window switch right rear X500 X600 Power Windows Wiring Diagram, with Express Down (2 of 2) for Saab 9-5 Aero 2011 List of elements for Power Windows Wiring Diagram, with Express Down (2 of 2) for Saab 9-5 Aero 2011: 28 (left kick panel) (right kick panel) Computer data lines system Door locks system Down Express Fuse 21 30a G201 G302 Gnd Hot at all times J307 J701 Left rear window motor Left rear window switch Logic Lr down ctrl Lr dr ajar sw sig Lr up ctrl N/w bus 4 Right rear window motor Right rear window switch Rr down ctrl Rr dr ajar sw sig Rr up ctrl Underhood fuse block (left side of engine compt) X700 X800 Power Windows Wiring Diagram, with Express Up/Down (1 of 2) for Saab 9-5 Aero 2011 List of elements for Power Windows Wiring Diagram, with Express Up/Down (1 of 2) for Saab 9-5 Aero 2011: 36 (left kick panel) Ajar sw sig B+ volt Computer data lines system Door locks system Down Down sig Driver window motor Driver window switch Express Express sig Fuse 30a Fuse 7.5a G201 G201 (left kick panel) G302 (right kick panel) Gnd Hot at all times J309 J505 J508 J509 J605 J609 Lock out ind Logic Network bus 3 Passenger window motor Passenger window switch Underhood fuse block (left side of engine compt) Up sig Window switch left rear Window switch right front Window switch right rear X500 X600 Power Windows Wiring Diagram, with Express Up/Down (2 of 2) for Saab 9-5 Aero 2011 List of elements for Power Windows Wiring Diagram, with Express Up/Down (2 of 2) for Saab 9-5 Aero 2011: 25 Ajar sw sig Computer data lines system Door locks system Down Down sig Express Express sig Fuse 30a G201 (left kick panel) G302 (right kick panel) Gnd Hot at all times J307 J701 J801 Left rear window motor Left rear window switch Logic Network bus 3 Right rear window motor Right rear window switch Underhood fuse block (left side of engine compt) Up sig X700 X800
RADIO Radio Wiring Diagram, with Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011: 73 (instrument panel harness, on branch leading to info display module) (or 5839) (or 5843) (right kick panel) Amplifier ctrl Anti-lock brakes system Audio common sig Audio sig Aux audio screen Auxiliary audio sig Batt+ volt Camera sig Cellular phone navigation & digital radio antenna (w/ digital system s band) Coax Computer data lines Computer data lines system Detection sig Display reset sig Display sig+ Display sig- Drain wire Fuse 10a Fuse 15a Fuse 20a G205 Gmlan serial - Gmlan serial data Gmlan serial data + Ground Hot at all times Instrument panel fuse block (left end of dash) J205 J219 J222 Lf aud sig Lf lo level aud- Lf rr seat aud sig Lf rr spkr+ Lf spd sig Lines system Lo level audio sig Lo level audio sig+ Lo level audio sig- Lo level audio- Lo refr Lo spd gmlan Nav+ Nav- Navigation & traffic data antenna Navigation antenna Navigation system Nca Radio Remote audio Remote enable sig Rf lo level aud- Rh aud sig Rh rr seat aud sig Rr au drain wire Rr spkr sig - Satellite radio circuit Serial data hi Serial data lo Shield Stack reset sig Telephone voice sig W/ navigation display W/ upj W/o navigation display W/o upj Wake-up sig X204 X207 Radio Wiring Diagram, with Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011: 53 (right kick panel) (w/ gid) info display module A14 A15 Aud sig Audio sig B14 B15 Batt pos volt Batt+ Batt+ volt Cellular phone antenna Coax Comm sig Computer data lines system Data hi Data lo Data sh Drain wire G205 Gnd Ground Ir aud sig J201 Lo refr Logic Lr aud sig Mobile telephone control module (center of dash) Navigation and traffic data antenna Nca Net bus Net- bus 9 Radio antenna Radio antenna module (on right "c" pillar) Radio/hvac control Rear audio control module Reset sig Rr aud sig Serial data hi Serial data lo Serial data sh Voice sig W/ information display, color info display (cid) W/ onstar W/o information display, color info display (cid) W/o onstar Wake up sig Wake-up sig X200 X208 X210 X300 X301 Radio Wiring Diagram, with Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011: 51 (body harness, in main bundle between breakout to side impact sensor left front & formed conduit near left b-pillar) (left end of dash) body control module (bcm) (right kick panel) Amplifier ctrl Audio amplifier (right side of luggage compt) Batt+ volt Computer data lines system Cruise control system Ctrl sw ref Fr center spkr Fr center spkr + Fr lo level audio G205 Ground Hi spd gmlan serial data+ Hi spd gmlan serial data- Interior lights system J320 Lader sig 1 Left subwoofer speaker Lf lo level audio- Lf rr speaker + Lf speaker + Lf speaker sig- Lo level audio Lo level audio sig Lo level audio sig lo level audio sig Lo level audio- Lr speaker - Lr speaker out + Lr spkr sig - Lr wfr speaker- Mute Nca R speaker out + Remote enable sig Rf speaker sig- Rf spkr + Rh rr speaker - Rh subufr - Right steering wheel control switch Right subwoofer speaker Rr lo level audio- Rr spkr sig - Seek down Seek up Source Steering wheel air bag coil (top of steering column) Voice Vol + Vol - Radio Wiring Diagram, with Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011: 33 (body harness, in main bundle between breakout to side impact sensor - left front & formed conduit near left b-pillar) (body harness, in main bundle between g302 & formed conduit near right front seat) (instrument panel harness, in main bundle near data link resistor) (left kick panel) g201 Batt+ volt Bright ctrl Driver seatback video display Dvd vid sig+ Dvd vid sig- Enable sig G201 (left kick panel) G205 (right kick panel) Gnd Info display module (w/ cid & wvga touch screen) J201 J222 J322 J342 J343 J356 J366 Module sig Nca Nca drain wire Nca s Passenger seatback video display Sig + Video sig+ Video sig- X1 sig - X204 X301 X307 Radio Wiring Diagram, with Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011: 47 Aud comm sig Aud screen Audio com sig Audio/video input adapter Aux sig Auxiliary audio input Batt + Bright ctrl Computer data lines system D wire Drain wire Dvd ado shld G205 (right kick panel) Gnd High sig J201 L spd data Lf aud sig Lf aud sig 2 Lf sig 3 Lh dvd sig + Low sig Lt audio sig 1 Mid spd Module sig Multimedia player interface module (right end of dash) Nca Radio Red Rh aud sig Rh aud sig 2 Rh audio sig 1 Rh sig 3 Rmt inf sig - Sig Sig 2 Sig 3 Vid sig - Video mode 2 Video sig 2+ Video sig 2- Video sig- W/ audio interface W/o audio interface X204 X210 X216 Radio Wiring Diagram, with Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, with Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011: 61 (driver door harness, in branch between speaker & lower door grommet) (passenger door harness, in branch between speaker & lower door grommet) Batt + volt Batt sply volt Cellular phone microphone Cellular phone navigation & digital radio antenna Center instrument panel speaker Coax Computer data lines system Display color info display Fuse 35 30a G205 (right kick panel) G304 (left kick panel) Gnd Hot at all times Inside rear view mirror J201 J244 J335 J503 J504 J603 J604 Keypad sig Left front speaker Left front tweeter speaker Left rear speaker Left surround speaker Lo ref Lo refr Lo spd data Logic Lp ref Micro ph sig Navigation antenna signal splitter Nca Red led Right front speaker Right front tweeter speaker Right rear speaker Right surround speaker Serial data Serial data + Serial data - Shield Sply volt Tele voice sig Telematics button assembly Telematics communication interface control module (w/ onstar) (center of dash) Telematics communication interface control module battery Underhood fuse block (left side of engine compt) Voice aud sig W/ infotainment W/ light sensitive mirror & w/o lane departure warning & windshield wiper system W/ light sensitive mirror, lane departure warning & windshield wiper system W/o infotainment display color info display X200 X500 X600 X700 X800 Radio Wiring Diagram, without Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (1 of 6) for Saab 9-5 Aero 2011: 76 (right kick panel) Amplifier ctrl Anti-lock brakes system Audio common sig Audio sig Audio signal (1) Aux audio screen Auxiliary audio sig Batt+ volt Camera sig + Camera sig - Coax Computer data lines Computer data lines system Data wire Detection sig Display reset sig Display sig+ Display sig- Drain wire Fr audio drain wire Fuse 10a Fuse 15a Fuse 20a G205 Gmlan serial cata + Gmlan serial cata - Gmlan serial data Ground Hot at all times Instrument panel fuse block (left end of dash) J205 J219 J222 Lf lo level aud- Lf rr seat aud sig Lf rr spkr+ Lines system Lo level audio sig+ Lo level audio sig- Lo level audio- Lo refr Lo spd gmlan Navi+ Navi- Navigation & traffic data antenna Navigation antenna Navigation system Nca Radio Radio audio (-) Radio lf aud sig Remote enable sig Rf lo level aud- Rh rr seat aud sig Right audio sig 2 Rr au drain wire Rr spkr sig - Satellite radio circuit Serial data hi Serial data lo Shield Speed sensor sig Stack reset sig Telephone Telephone voice sig Usb W/ cellular W/ infotainment display W/ infotainment display color info display (cid) w/o onstar W/ premium 9 or 7 speaker system W/o cellular W/o infotainment display Wake-up sig X204 X207 Radio Wiring Diagram, without Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (2 of 6) for Saab 9-5 Aero 2011: 52 (w/ information display graphic info display (gid)) info display module A14 A15 Aud sig Audio sig B14 B15 Batt pos volt Batt+ Batt+ volt Cellular phone antenna Coax Comm sig Computer data lines system Data hi Data lo Data sh Drain wire G205 (right kick panel) Gnd Ground J201 Lo refr Logic Lr aud sig Mobile telephone control module (center of dash) Navigation & traffic data antenna Nca Net bus Net- bus 9 Radio antenna (integral to rear window) Radio antenna module (on right "c" pillar) Radio/hvac control Rear audio control module (if equipped) Red aud sig Reset sig Rr aud sig Serial data hi Serial data lo Serial data sh Up sig Voice sig W/ information display graphic info display (gid) W/ onstar W/o information display graphic info display (gid) W/o onstar Wake-up sig X200 X206 X210 X300 X301 Radio Wiring Diagram, without Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (3 of 6) for Saab 9-5 Aero 2011: 20 (body harness, in main bundle between breakout to side impact sensor - left front & formed conduit near left b-pillar) Body control module (bcm) (left end of dash) Computer data lines system Cruise control system Ctrl sw refr Hi spd gmlan serial data+ Hi spd gmlan serial data- Interior lights system J320 Lader sig 1 Mute Nca Right steering wheel control switch Seek down Seek up Src Steering wheel air bag coil (top of steering column) Voice Vol + Vol - Radio Wiring Diagram, without Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (4 of 6) for Saab 9-5 Aero 2011: 44 (body harness, in main bundle between breakout to side impact sensor) (driver door harness, in branch between speaker & lower door grommet) (instrument panel harness, in main bundle near data link resistor) (instrument panel harness, on branch leading to radio x1) (left kick panel) g201 Batt+ volt Bright ctrl Driver seatback video display Dvd video + Dvd video - Enable sig Enable sig + G201 (left kick panel) G205 (right kick panel) Gnd Info display module (w/ infotainment display color info display (cid)) J201 J245 J322 J323 J342 J343 J356 J366 J503 (driver door harness, in branch between speaker & lower door grommet) J504 Left front speaker Left front tweeter speaker Left rear speaker Module sig Nca Nca drain wire Nca s Passenger seatback video display Right rear speaker Video sig+ Video sig- X200 X204 X301 X307 X500 X700 X800 Radio Wiring Diagram, without Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (5 of 6) for Saab 9-5 Aero 2011: 54 (instrument panel harness, on branch leading to radio x1) (passenger door harness, in branch between speaker & lower door grommet) Aud comm sig Aud screen Audio/video input adapter Aux sig Auxiliary audio input Batt + Bright ctrl Center console speaker Coax Computer data lines system D wire Drain wire Fh video sig G205 (right kick panel) Gnd J201 J246 J603 J604 L spd data Lf aud sig Lf aud sig 2 Lf sig 3 Mid spd Module sig Multimedia player interface module (right end of dash) Nca Radio Red Rh aud sig Rh aud sig 2 Rh sig 3 Rh video sig Right front speaker Right front tweeter speaker Sig Sig 2 Sig 3 Video com sig Video hi Video l Video mode 2 Video sig 2+ Video sig 2- Video sig- W/ audio interface W/o audio interface X200 X204 X210 X216 X500 Radio Wiring Diagram, without Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011 List of elements for Radio Wiring Diagram, without Surround Amplifier (6 of 6) for Saab 9-5 Aero 2011: 41 (in overhead console) cellular phone microphone Batt + volt Batt sply volt Cellular phone navigation & digital radio antenna Coax Computer data Computer data lines system Display color info display G205 (right kick panel) G304 (left kick panel) Gnd Inside rear view mirror J201 J244 J335 Keypad sig Lo ref Lo refr Lo spd data Logic Lp refr Micro ph sig Navigation antenna signal splitter (right end of dash) Nca Red led Serial data Serial data + Serial data - Shield Sply volt Tele voice sig Telematics button assembly Telematics communication interface control module battery Telematics communication interface control module w/ onstar (center of dash) Voice aud sig W/ digital audio system s-band W/ infotainment W/ light sensitive mirror & w/o lane departure warning & windshield wiper system W/ light sensitive mirror, lane departure warning & windshield wiper system W/o infotainment display color info display X200 Satellite Radio Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Satellite Radio Wiring Diagram for Saab 9-5 Aero 2011: 27 Ant sig Batt pos volt Coax Computer data lines system Digital radio antenna (rear center of roof) Digital radio receiver control module (right rear corner of vehicle) Front audio drain wire Fuse 1 10a G205 (right kick panel) Gmlan serial data (+) Gmlan serial data (+) (kta) Gnd Hot at all times Instrument panel fuse block (under center dash, below radio, on right side of center console) J201 J222 (w/ rear seat enertainment package) Lf aud sig Nca Rad audio (-) Radio Remote radio audio (-) Remote radio lf aud sig Rh aud sig (1) Rh aud sig (2) Right audio signal (1) Right audio signal (2) X212
SHIFT INTERLOCK Park Brake System Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Park Brake System Wiring Diagram for Saab 9-5 Aero 2011: 24 Computer data lines system Driver information center display Fuse 27 30a G401 (left side of luggage compt) Ground Hi spd gmlan + Hot at all times Instrument cluster Interior lights system J340 J409 K hi spd gmlan - L hi spd gmlan - Logic M hi spd gmlan - P serial data enable r Park brake control switch (under center console) Park brake sw Park ind Parking brake control module Release sw Release sw sig Underhood fuse block (left side of engine compt) X300 Shift Interlock Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Shift Interlock Wiring Diagram for Saab 9-5 Aero 2011: 34 (engine compt, forward of battery) (or 275) 2.0l turbo 2.8l turbo 5v ref Body control module (left end of dash) Brake pedal position sensor (on brake pedal bracket) Computer data lines system Engine control module (right rear of engine compt) Fuse 24 20a G103 G206 (left center of dash) Hi speed gmlan serial data + Hi speed gmlan serial data - High speed serial data(+) High speed serial data(-) Hot at all times Instrument panel fuse block (left end of dash) J208 J210 Key capture/ column lock shift position signal Logic Low ref Park lock sol ctrl Park lock sol soft ctrl Park/neutral sig(1) Power distribution system Retained acc Tan Transmission control module (top of transmission) Transmission manual shift switch Transmission shift lever Transmission shift lock control solenoid actuator X200 Steering Lock Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Steering Lock Wiring Diagram for Saab 9-5 Aero 2011: 17 Body control module (bcm) (left end of dash) Computer data lines system Fuse 15a G206 (left center of dash) Gmlan serial data Gnd Hot at all times Hot w/ ignition main relay energized Instrument panel fuse block (left end of dash) J210 Keyless entry control module (right kick panel) Logic Steering column lock control module (on steering column) Steering column lock sig Steering column lock status sig off/accessory volt Steering column lock status sig x1 Underhood fuse block (left side of engine compartment)
STARTING/CHARGING Charging Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Charging Wiring Diagram for Saab 9-5 Aero 2011: 32 2.0l turbo 2.8l turbo Battery Battery current sensor (on battery (-) terminal) Battery fuse block (left rear of engine compt) Body control module (left end of dash) Charge ind Charge ind ctrl Computer Computer data lines system Current sens Current sens sig Current sensor sig Data lines system Driver information center display Engine control module (right rear of engine compt) Fuse 6 300a G103 (engine compt, forward of battery) G107 (engine compt, forward of battery) Generator Generator field duty cycle sig Gmlan serial data(+) x2 Gmlan serial data(-) Ground High speed serial data(+) High speed serial data(-) Instrument cluster Logic Low ref Red Starter motor Tan Starting Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Starting Wiring Diagram for Saab 9-5 Aero 2011: 44 (or 447) (or 6338) (or 7360) (or 7361) (or tan) 2.0l turbo 2.8l turbo A12 B12 Battery Battery fuse block (left rear of engine compt) Body control module (left side of dash) Charging circuit Clutch pedal position sensor (m/t) (on clutch pedal bracket) Computer Computer data lines system Data lines system Engine control module (right rear of engine compt) Fuse 12 30a Fuse 5 250a Fuse 6 300a G103 (engine compartment, forward of battery) G103 (engine compt, forward of battery) G120 (engine compt, below engine control module) G206 (left center of dash) Gmlan serial data(-) Gmlan serial x2 data(+) High speed serial data(+) High speed serial data(-) Ignition mode switch J120 Keyless entry control module (right kick panel) Logic Park/neutral sig (1) Red Starter enable relay ctrl Starter motor Starter relay Transmission control module (top of transmission) Underhood fuse block (left side of engine compt) X108 X200 X210 X300
SUPPLEMENTAL RESTRAINTS Supplemental Restraints Wiring Diagram (1 of 3) for Saab 9-5 Aero 2011 List of elements for Supplemental Restraints Wiring Diagram (1 of 3) for Saab 9-5 Aero 2011: 53 (in steering wheel) steering wheel air bag 1-2, 3-4, 5-6, 7-8, 3-4, 7-8, 13-14, 15-16, 17-18, 9-10, 11-12, 53-54 & 37-40 Computer data lines system Driver anchor hi ctrl Driver anchor lo ctrl Driver side impact hi ctrl Driver side impact lo ctrl G303 (under driver's seat) G304 (left kick panel) Gmlan Gnd Hazard lamps switch Ign Inflatable restraint sensing & diagnostic module (front of center console) Left front impact sensor (left front of engine compt) Left rear side impact sensor (if equipped) (base of left "c" pillar) Left roof rail air bag (on left roof rail) Left side impact sensor Lf head mod hi ctrl Lf head mod lo ctrl Lf side impact mod sig Lo ref Pass air bag off ind ctrl Pass air bag on ind ctrl Pass ip mdl dis sw retn Pass ip mdl dis sw sig Pass ip stage 1 high ctrl Pass ip stage 1 low ctrl Pass ip stage 2 high ctrl Pass ip stage 2 low ctrl Pass seat belt ind Pass side impact hi ctrl Pass side impact lo ctrl Passenger instrument panel air bag Pin shorting bars engaged Pnk Rf discriminating sens sig Rf side impact mod sig Right front impact sensor (right front of engine compt) Right rear side impact sensor (if equipped) (base of right "c" pillar) Right side impact sensor Shorting bar Stage 1 high ctrl Stage 1 low ctrl Stage 2 high ctrl Stage 2 low ctrl Steering wheel air bag coil (top of steering column) Tan When module connector is disconnected from harness: (shorting bars are connected between following pins: X1: x2: X200 X203 X398 Supplemental Restraints Wiring Diagram (2 of 3) for Saab 9-5 Aero 2011 List of elements for Supplemental Restraints Wiring Diagram (2 of 3) for Saab 9-5 Aero 2011: 33 (if equipped) passenger air bag disable switch (in passenger seat cushion) passenger presence detection sensor (under front passenger's seat) Air bag off Air bag on Computer data lines system Driver seat belt anchor pretensioner (integral to driver seat belt buckle assembly) Driver seat belt buckle Driver seat belt switch Fuse 10a Fuse 5a G304 (left kick panel) Hot at all times Ind air bag Ind seat belt Instrument cluster Instrument panel fuse block (left end of dash) Left front side air bag (left outer side of front seat backs) Logic Nca Passenger airbag disable indicator Passenger presence detection module Passenger seat belt anchor pretensioner (integral to passenger seat belt buckle assembly) Passenger seat belt buckle Passenger seat belt switch Right front side air bag (right outer side of front seat backs) Shorting bar Underhood fuse block (left side of engine comt) X200 X301 X307 X315 X398 Supplemental Restraints Wiring Diagram (3 of 3) for Saab 9-5 Aero 2011 List of elements for Supplemental Restraints Wiring Diagram (3 of 3) for Saab 9-5 Aero 2011: 34 (base of left "b" pillar) pretensioner driver seat belt pretensioner (base of right "b" pillar) passenger seat belt pretensioner (body harness, in main bundle rearward of formed conduit near left b-pillar) j324 (left outer side of rear seat backs) (if equipped) right rear side air bag (passenger seat harness, in main bundle past breakout to anchor pretensioner) j362 (right outer side of rear seat backs) (if equipped) left rear side air bag Cr seat belt sw sig Drv seat belt hi ctrl Drv seat belt lo ctrl Drv seat belt sw sig G303 (under driver's seat) Inflatable restraint sensing & diagnostic module (front of center console) Left rear seat belt buckle Left rear seat belt switch Low refr Lr seat belt sw sig Nca Pass seat belt hi ctrl Pass seat belt lo ctrl Pass seat belt rimd sig Pass seat belt sw sig Passenger presence detection sensor (w/right seat belt warning) (under passenger seat cushion) Rear middle seat belt buckle Rear middle seat belt switch Rf head hi ctrl Rf head lo ctrl Right rear seat belt buckle Right rear seat belt switch Right roof rail air bag Rr seat belt sw sig Shorting bar X307 X310 X315
TRANSMISSION A/T Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for A/T Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 35 (engine compartment, forward of battery) g103 1-2/3-4 shift solenoid valve 15a Automatic transmission assembly Computer data lines Computer data lines system Data bus (+) Data bus (-) Driver information center display Fuse 1 Fuse 5 15a Gear shift position sensor Gmlan serial data Gnd Hot at all times Hot w/ ignition main relay energized Ign volt Instrument cluster J114 Line pressure control solenoid valve Logic Parity bit signal, trans position sens Pressure control solenoid valve 1 Pressure control solenoid valve 2 Pressure control solenoid valve 3 Pressure control solenoid valve 4 Radio/run/start ign 0 volt Red System Torque converter clutch pressure control solenoid valve Transmission control module Transmission fluid temperature sensor Transmission input shaft speed sensor Transmission output shaft speed sensor Underhood fuse block (left side of engine compt) A/T Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for A/T Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 39 + - 2.0l 2.8l A11 Anti-lock brakes system B10 Body control module (left end of dash) Computer data lines system Data bus (+) Data bus (-) Engine control module (right rear of engine compt) G206 (left center of dash) Interior lights system J208 (in branch between breakout to hvac control module & steering column) J210 J301 Key capture/column lock shift position signal Key cptr/clmn lock shift position sig Logic Low speed gmlan serial data Park lock sol ctrl Park lock sol soft ctrl Power distribution system Retained acc Shift select switch performance signal Sport mode switch Sport mode switch signal Tap up/tap down switch signal Trans comfort mode ind ctrl Trans intelligent mode ind ctrl Trans sport mode ind ctrl Transmission manual shift switch Transmission pos sens x2 Transmission shift lever Transmission shift lever position indicator Transmission shift lock control solenoid actuator X200 X210 X300 Rear Differential Lock Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Rear Differential Lock Wiring Diagram for Saab 9-5 Aero 2011: 23 (left side of luggage compt) g401 (under driver's seat) g305 Computer data lines system Differential clutch pump Differential lock actuator Fuse 10a Gnd High speed gmlan serial data (+) High speed gmlan serial data (-) Hot at all times J319 J409 Limited slip diff valve ctrl Limited slip diff valve return Logic Rear body fuse block (left side of luggage compt) Rear differential clutch control module (mounted to rear differential) Rear drive motor control Rear drive motor return Red Serial data communication enable Transfer case solenoid value X408
TRUNK, TAILGATE, FUEL DOOR Fuel Door Release Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Fuel Door Release Wiring Diagram for Saab 9-5 Aero 2011: 40 (body harness, in main bundle between breakout to left front door inline & g201) (center rear of luggage compartment lid) rear compartment lid latch (in main bundle between breakout to side impact sensor-left front & formed conduit near left front seat) Batt pos volt Body control module (left end of dash) Computer data lines system Door lck actuator Door locks system Dr actr lck ctrl 2 Driver information center display Exterior rear compartment lid unlatch switch Fdl relay control Fuel door release actualor relay Fuel door unlatch actuator (right side of luggage compartment) Fuse 15a Fuse 25a G109 (engine compt, on left strut tower) G201 (left kick panel) G401 (left side of luggage compartment) G401 (left side of luggage compt) Handle sw open sig Hot at all times Instrument cluster J137 J140 J233 J315 J410 L ajar sw sig (1) Logic Mtr release ctrl Rear body fuse block (left side of luggage compt) Rear compartment lid release relay Red Serial data Underhood fuse block (left side of engine compt) Unlk control W/ theft deterrent security W/o theft deterrent security X411
WARNING SYSTEMS Chime Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011 List of elements for Chime Wiring Diagram (1 of 2) for Saab 9-5 Aero 2011: 51 Auto Battery positive vol Battery positive volt Body control module (left end of dash) Brake warning ind Computer data lines system Driver information center (dic) display Fuse 21 10a Fuse 24 20a Fuse 27 30a Fuse 52 5a G203 (left end of dash) G206 (left center of dash) G401 (left side of luggage compt) Gnd Hdlp sw hdlp off Hdlp sw on sig Hdlp sw start Head Headlamp switch Hi spd gmlan Hi spd gmlan srl data (+) Hi spd gmlan srl data (-) Hot at all times Hot w/ ignition main relay energized Instrument cluster Instrument panel fuse block (left end of dash) J216 J220 J404 J409 Led sig x1 Logic Low spd gmlan serial data Off Park Park brake control switch Park brk release sw sig Park brk sw sig Park brk sw sply volt Parking brake control module (left side of luggage compt) Run/crank ign1 volt Seat belt ind Serial data enable Sig control Srl data (+) Srl data (-) Underhood fuse block (left side of engine compt) Vol ref X200 X300 Chime Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011 List of elements for Chime Wiring Diagram (2 of 2) for Saab 9-5 Aero 2011: 38 Computer data lines system Driver door latch assembly Driver seat belt buckle Driver seat belt sw sig Driver seat belt switch Driver window motor (driver's door) Front passenger window motor (front passenger's door) G201 (left kick panel) G302 (right kick panel) G304 (left kick panel) Hazard lamps switch Inflatable restraint sensing & diagnostic module (front of center console) J509 J609 J701 J801 Left rear door latch assembly Left rear window motor (w/ express up/ down) left rear window switch (w/ express down) Lf door ajar sw sig Lo spd gmlan serial data Low ref Lr door ajar sw sig Nca Network bus 3 Network bus 4 Network bus 4 network bus 3 Pass seat belt ind Pass seat belt indicator Passenger door latch assembly Rf door ajar sw sig Right rear door latch assembly Right rear window motor (w/ express up/ down) right rear window switch (w/ express down) Rr door ajar sw sig W/ express down W/ express up/down X200 X310 X398 Tire Pressure Monitoring Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Tire Pressure Monitoring Wiring Diagram for Saab 9-5 Aero 2011: 26 Batt positive volt Battery positive vol Body control module (left end of dash) Computer data lines system Driver information center (dic) display Fuse 21 10a Fuse 53 10a G203 (left end of dash) G304 (left kick panel) Gnd Hi spd gmlan Hot at all times Hot w/ ignition main relay energized Instrument cluster Instrument panel fuse block (left end of dash) J216 J337 J416 (w/ light sensitive mirror & rearview camera) Lin bus 2 Logic Low spd gmlan serial data Low tire pressure ind Srl data (+) Srl data (-) Tire pressure indicator module (left side of luggage compt) Underhood fuse block (left side of engine compt)
WIPER/WASHER Wiper/Washer Wiring Diagram for Saab 9-5 Aero 2011 List of elements for Wiper/Washer Wiring Diagram for Saab 9-5 Aero 2011: 50 87a Body control module (left end of dash) Computer data lines system Delay switch Fr windshield wip sw hi sig Fuse 15a Fuse 44 25a Fuse 6 30a Fuse 70 5a G102 (engine compt, on right strut tower) G109 (engine compt, on left strut tower) G304 (left kick panel) Hdlp wash rly ctrl Headlamp washer fluid pump (on washer fluid reservoir) Headlamp washer fluid pump relay High Hot at all times Instrument cluster Int J135 J137 J244 Logic Low Low ref Mist Mtr rly coil spl vol Net work bus 1 Off Rain sensor Relay Sw hi sig Sw low sg Sw sig Underhood fuse block (left side of engine compt) Washer switch Windshield Windshield wash rly ctrl Windshield washer fluid level ind Windshield washer pump (on washer fluid reservoir) Windshield washer pump relay Windshield wip Windshield wip mtr prk sw sig Windshield wiper motor (on left side of firewall) Windshield wiper speed control relay Windshield wiper/washer switch Winshield washer fluid level sensor (in washer fluid reservoir) Wiper Wiper switch X200
