All Wiring Diagrams for Volvo S60 T-5 2005 model

AIR CONDITIONING

2.4L

2.4L, Manual A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for 2.4L, Manual A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (not used)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• Battery fuse box
• C21
• C22
• Central electronic module (cem) (behind left side of dash)
• Climate control module
• Climate control system relay
• Computer data lines system
• D29
• D32
• D42
• D47
• Damper motor module (behind center of dash)
• Electromagnetic clutch (left front of engine)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine management system main relay
• Evaporator temperature sensor (behind center of dash, on lower side of evaporator assembly)
• Fuse a8 60a
• Fuse b11 20a
• Fuse b23 10a
• Fuse b8 10a
• Fuse e5 50a
• G84 (at right kick panel)
• Hot at all times
• Left-hand side temperature damper motor module (on hvac assembly)
• Recirculation damper motor module (bottom of damper motor, under right side of dash)
• Red
• Right-hand side temperature damper motor module (on hvac assembly)
• Solar sensor, twilight sensor & indicator alarm (on top of left side of dash)
• Solid state

2.4L, Manual A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for 2.4L, Manual A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (at left side of engine compt, forward of strut tower) engine compartment relay/fuse box
• A14
• A18
• A21
• A37
• A40
• A55
• A58
• A61
• Ambient temperature sensor
• B11
• B13
• B38
• B44
• Climate control system pressure sensor (at right front of engine compt)
• Computer data lines system
• Coolant temperature sensor (on left front of engine)
• Cooling fan control module (at right front of engine compt)
• Electric cooling fan motor (front of engine compt)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Fan control module (behind right side of dash, near blower fan)
• Fuse c3 30a
• G10 (at right kick panel)
• G2 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Passenger compartment fan motor (behind right side of dash, in right end of hvac unit)
• Passenger compartment fuse box (at left end of dash)
• Passenger power door mirror (in front passenger door mirror)
• Passenger/driver door module (pdm/ddm)
• Red
• Solid state

2.4L TURBO

2.4L Turbo, Automatic A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for 2.4L Turbo, Automatic A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (not used)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• Air quality sensor (at right rear of engine compt)
• Battery fuse box
• C21
• C22
• Central electronic module (cem) (behind left side of dash)
• Climate control module
• Climate control system relay
• Computer data lines system
• D29
• D30
• D32
• D42
• D47
• Defroster damper motor module (behind center of dash, on right side of hvac unit)
• Electromagnetic clutch (left front of engine)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine management system main relay
• Evaporator temperature sensor (behind center of dash, on lower side of evaporator assembly)
• Floor/ventilation damper motor module (behind center of dash, on right side of hvac unit)
• Fuse a8 60a
• Fuse b11 20a
• Fuse b23 10a
• Fuse b8 10a
• Fuse e5 50a
• G84 (at right kick panel)
• Hot at all times
• Left-hand side temperature damper motor module (on hvac assembly)
• Recirculation damper motor module (bottom of damper motor, under right side of dash)
• Red
• Right-hand side temperature damper motor module (on hvac assembly)
• Solar sensor, twilight sensor & indicator alarm (on top of left side of dash)
• Solid state

2.4L Turbo, Automatic A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for 2.4L Turbo, Automatic A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (at left side of engine compt, forward of strut tower) engine compartment relay/fuse box
• A14
• A18
• A39
• A60
• A68
• Ambient temperature sensor
• B11
• B13
• B38
• B44
• Climate control system pressure sensor (at right front of engine compt)
• Computer data lines system
• Coolant temperature sensor (on left front of engine)
• Cooling fan control module (at right front of engine compt)
• Electric cooling fan motor (front of engine compt)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Fan control module (behind right side of dash, near blower fan)
• Fuse c3 30a
• G10 (at right kick panel)
• G2 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Passenger compartment fan motor (behind right side of dash, in right end of hvac unit)
• Passenger compartment fuse box (at left end of dash)
• Passenger power door mirror (in front passenger door mirror)
• Passenger/driver door module (pdm/ddm)
• Red
• Solid state

2.5L TURBO

2.5L Turbo, Automatic A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for 2.5L Turbo, Automatic A/C Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (not used)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• Air quality sensor (at right rear of engine compt)
• Battery fuse box
• C21
• C22
• Central electronic module (cem) (behind left side of dash)
• Climate control module
• Climate control system relay
• Computer data lines system
• D29
• D30
• D32
• D42
• D47
• Defroster damper motor module (behind center of dash, on right side of hvac unit)
• Electromagnetic clutch (left front of engine)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine management system main relay
• Evaporator temperature sensor (behind center of dash, on lower side of evaporator assembly)
• Floor/ventilation damper motor module (behind center of dash, on right side of hvac unit)
• Fuse a8 60a
• Fuse b11 20a
• Fuse b23 10a
• Fuse b8 10a
• Fuse e5 50a
• G84 (at right kick panel)
• Hot at all times
• Left-hand side temperature damper motor module (on hvac assembly)
• Recirculation damper motor module (bottom of damper motor, under right side of dash)
• Red
• Right-hand side temperature damper motor module (on hvac assembly)
• Solar sensor, twilight sensor & indicator alarm (on top of left side of dash)
• Solid state

2.5L Turbo, Automatic A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for 2.5L Turbo, Automatic A/C Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (at left side of engine compt, forward of strut tower) engine compartment relay/fuse box
• A14
• A18
• A39
• A60
• A68
• Ambient temperature sensor
• B11
• B13
• B38
• B44
• Climate control system pressure sensor (at right front of engine compt)
• Computer data lines system
• Coolant temperature sensor (on left front of engine)
• Cooling fan control module (at right front of engine compt)
• Electric cooling fan motor (front of engine compt)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Fan control module (behind right side of dash, near blower fan)
• Fuse c3 30a
• G10 (at right kick panel)
• G2 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Passenger compartment fan motor (behind right side of dash, in right end of hvac unit)
• Passenger compartment fuse box (at left end of dash)
• Passenger power door mirror (in front passenger door mirror)
• Passenger/driver door module (pdm/ddm)
• Red
• Solid state

ANTI-LOCK BRAKES

Anti-lock Brakes Wiring Diagram, with Dynamic Stability Control for Volvo S60 T-5 2005

List of elements for Anti-lock Brakes Wiring Diagram, with Dynamic Stability Control for Volvo S60 T-5 2005:

• (at brake master cylinder) dstc activation module
• (left rear of engine) vacuum pump switch
• A10
• A11
• A37
• A55
• Abs pump motor
• B11
• B13
• B22
• B26
• Body cluster sensor (under front passenger's seat)
• Brake control module (at left rear corner of engine compt)
• Brake pedal sensor (at left rear of engine compt)
• Brake pressure sensor 1 (on brake master cylinder)
• Brake pressure sensor 2 (on brake master cylinder)
• Brakelight contact (under left side of dash, at top of brake pedal assembly)
• C21
• C22
• C34
• C35
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Contact reel
• D31
• D32
• D34
• D46
• D47
• D49
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (at right side of engine compt, forward of strut tower)
• Fuse 20a
• Fuse 50a
• Fuse 5a
• Fuse b14 30a
• Fuse b19 30a
• Fuse c9 5a
• G84 (at right kick panel)
• G93 (left side of engine compt, on fender)
• G95 (at left side of engine compt, on fender)
• Hot at all times
• Left front abs sensor (on left hub assembly)
• Left rear abs sensor (on left rear hub assembly)
• Main fuses
• Nca
• Passenger compartment relay box (behind left side of dash)
• Red
• Right front abs sensor (on right hub assembly)
• Right rear abs sensor (on right rear hub assembly)
• Spin control switch
• Steering angle sensor module
• Steering wheel module (swm) (in steering column)
• Vacuum pump (at left rear of engine)

Anti-lock Brakes Wiring Diagram, without Dynamic Stability Control for Volvo S60 T-5 2005

List of elements for Anti-lock Brakes Wiring Diagram, without Dynamic Stability Control for Volvo S60 T-5 2005:

• (left rear of engine) vacuum pump switch
• A10
• A11
• A37
• A55
• Abs pump motor
• B11
• B13
• B22
• B26
• Brake control module (at left rear corner of engine compt)
• Brake pedal sensor (at left rear of engine compt)
• Brakelight contact (under left side of dash, at top of brake pedal assembly)
• C21
• C22
• C34
• C35
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Contact reel
• D32
• D34
• D47
• D49
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (at right side of engine compt, forward of strut tower)
• Fuse 20a
• Fuse 50a
• Fuse 5a
• Fuse b14 30a
• Fuse b19 30a
• Fuse c9 5a
• G84 (at right kick panel)
• G93 (left side of engine compt, on fender)
• G95 (at left side of engine compt, on fender)
• Hot at all times
• Left front abs sensor (on left hub assembly)
• Left rear abs sensor (on left rear hub assembly)
• Main fuses
• Nca
• Passenger compartment relay box (at left side of dash)
• Red
• Right front abs sensor (on right hub assembly)
• Right rear abs sensor (on right rear hub assembly)
• Spin control switch
• Steering wheel module (swm) (in steering column)
• Vacuum pump (at left rear of engine)

ANTI-THEFT

Forced Entry Wiring Diagram for Volvo S60 T-5 2005

List of elements for Forced Entry Wiring Diagram for Volvo S60 T-5 2005:

• (at right side of engine compt, on fender) g94
• A10
• A11
• A12
• A13
• Alarm siren
• B25
• Battery fuse box
• C12
• C13
• C14
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• D26
• D29
• D31
• D33
• D34
• D35
• D42
• D49
• D50
• Driver door module (in driver's door)
• Front mass movement sensor (at center rear of sun roof)
• Fuse c6 10a
• Fuse e1 60a
• Fuse e4 50a
• Fuse f8 5a
• G46 (at rear left seat riser)
• G67 (below passenger's seat, near kick panel)
• G72 (at left rear of passenger's compt, near floor)
• G93 (at left side of engine compt, on fender)
• G98 (above center of windshield)
• Hood alarm contact (at left front corner of engine compt)
• Hot at all times
• Key
• Left front door lock unit (rear of left front door)
• Left rear door lock unit (rear of left rear door)
• Level sensor alarm (left rear of trunk)
• Lock
• Passenger compartment fuse box (behind left side of dash)
• Passenger door module (in passenger's door module)
• Pnk
• Rear electronic module (rem) (at left rear corner of trunk)
• Red
• Reduced alarm switch
• Right front door lock unit (rear of right front door)
• Right rear door lock unit (rear right rear door)
• Right rear door power window switch
• Solar sensor, twilight sensor & indicator alarm (on top of left side of dash)
• Sunroof control module (forward of sun roof opening)
• Trunk lid lock unit (center rear of trunk lid)
• Unlock
• Upper electronic module (above center of windshield, on rearview mirror)

Immobilizer Wiring Diagram for Volvo S60 T-5 2005

List of elements for Immobilizer Wiring Diagram for Volvo S60 T-5 2005:

• (in instrument cluster) driver information module (dim)
• Antenna ring/ ignition lighting
• B13
• C21
• C22
• Central electronic module (behind left side of dash)
• Computer data lines system
• D34
• D49
• D56
• D57
• Engine control module (at right side of engine compt, forward of strut tower)
• Fuse c8 7.5a
• G83 (at left kick panel)
• G98 (above center of windshield)
• Hot at all times
• Ignition switch
• Interior lights system
• Key in ignition switch
• Passenger compartment fuse box (behind left side of dash)

BODY CONTROL MODULES

Central Electronic Module Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for Central Electronic Module Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (behind left side of dash) central electronic module
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• Air conditioning system
• Anti-lock brakes & engine controls systems
• Anti-lock brakes system
• Anti-theft system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• Battery fuse box
• C10
• C11
• C12
• C13
• C14
• C15
• C16
• C17
• C18
• C19
• C20
• C21
• C22
• C23
• C24
• C25
• C26
• C27
• C28
• C29
• C30
• C31
• C32
• C33
• C34
• C35
• Computer data lines system
• Electronic power steering system
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine controls system
• Exterior lights system
• Fuse b17 20a
• Fuse b18 15a
• Fuse b20 20a
• Fuse b21 15a
• Fuse e4 50a
• Fuse e5 50a
• G93 (at left side of engine compt, on fender)
• Headlights & electronic power steering systems
• Headlights system
• Horns system
• Hot at all times
• Pnk
• Red
• Shift interlock & transmission systems
• Starting/charging & engine controls systems
• Starting/charging system
• Transmissions system
• Wiper/washer system

Central Electronic Module Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for Central Electronic Module Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (at left kick panel) g6
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• Acc
• Air conditioning system
• Air conditioning, instrument cluster & seats systems
• Anti-theft system
• Central electronic module (behind left side of dash)
• Computer data lines system
• Cruise control system
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• D17
• D18
• D19
• D20
• D21
• D22
• D23
• D24
• D25
• D26
• D27
• D28
• D29
• D30
• D31
• D32
• D33
• D34
• D35
• D36
• D37
• D38
• D39
• D40
• D41
• D42
• D43
• D44
• D45
• D46
• D47
• D48
• D49
• D50
• D51
• D52
• D53
• D54
• D55
• D56
• D57
• D58
• D59
• D60
• Engine controls & instrument cluster systems
• Engine controls system
• Exterior lights system
• Hot at all times
• Ignition switch
• Interior lights system
• Key in ignition switch
• Key-in
• Lock
• Off
• Power distribution system
• Seats system
• Shift interlock system
• Sound systems
• Start
• Wiper/washer system

Rear Electronic Module Wiring Diagram for Volvo S60 T-5 2005

List of elements for Rear Electronic Module Wiring Diagram for Volvo S60 T-5 2005:

• (13 pin)
• (7 pin)
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• Acc
• Anti-theft & interior lights systems
• Anti-theft system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• Battery fuse box
• C10
• C11
• C12
• C13
• C14
• Computer data data lines system
• Computer data lines system
• D10
• D11
• D12
• D13
• D14
• D15
• D16
• D17
• D18
• D19
• D20
• D21
• D22
• D23
• D24
• D25
• D26
• D27
• D28
• D29
• D30
• D31
• D32
• D33
• D34
• D35
• D36
• Defogger system
• Door locks & interior lights systems
• Door locks system
• Electronic power steering system
• Electronic suspension system
• Engine controls system
• Exterior & interior lights systems
• Exterior lights system
• F10
• Fuse e1 60a
• G47 (at left rear of passenger's compt, near floor)
• G72 (at left rear of passenger's compt, near floor)
• Headlights lights system
• Hot at all times
• Ignition switch
• Interior lights system
• Lock
• Navigation system
• Off
• Pnk
• Power distribution system
• Power windows system
• Rear electronic module (at left rear corner of trunk)
• Red
• Sound system
• Start
• Transmission system

COMPUTER DATA LINES

Computer Data Lines Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for Computer Data Lines Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (at left side of engine compartment, forward of of strut tower) engine compartment relay/fuse box
• 2wd
• A15
• A16
• Alternator control module (acm) (in alternator)
• Awd
• B23/51
• B24/52
• B25/53
• B26/54
• Body sensor cluster (bsc) (under front passenger seat)
• Brake control module (bcm) (at left rear of engine compartment)
• C16
• C21
• C22
• C32
• Central electronic module (behind left side of dash)
• Combustion preheater module (cpm) (behind left side of front bumper)
• D31
• D32
• D33
• D34
• D35
• D36
• D37
• D38
• D39
• D40
• D41
• D46
• D47
• D48
• D49
• D50
• D51
• D52
• D53
• D54
• D55
• D58
• Data link connector (dlc) (below left side of dash)
• Differential electronic module (under left rear seat)
• Driver door module (ddm) (in driver's door)
• Fuse c9 5a
• G84 (at right kick panel)
• Hot at all times
• Lights switch unit (lsm)
• Passenger compartment relay box (behind left side of dash)
• Pnk
• Rain sensor module (rsm) (forward of inside rearview mirror)
• Red
• Siren control module (scm) (at right front corner of engine compartment)
• Steering angle sensor module
• Steering wheel module (swm) (in steering column)
• Sunroof control module (srm) (forward of sun roof opening)
• Suspension module (sum) (under left side of center console)
• Upper electronic module (uem) (above center of windshield, on on rearview mirror)
• W/ dstc dstc
• W/ four-c
• W/ sunroof
• W/o four-c
• W/o sunroof

Computer Data Lines Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for Computer Data Lines Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• A/t
• A10
• A11
• A12
• A37
• A55
• Accessory electronic module (aem) (at right rear corner of trunk)
• Air quality sensor (aqs) (at right rear of engine compartment)
• Audio module (aum) (center of dash)
• Automatic transmission program selector (below center floor console)
• B13
• B14
• B21
• C13
• C14
• Climate control module (ccm)
• D19
• D20
• D21
• D26
• D30
• D32
• Damper motor module (automatic a/c) (behind center of dash)
• Damper motor module (dmm) (manual a/c) (bottom of damper motor, under right side of dash)
• Driver information module (dim) (in instrument cluster)
• Electronic throttle module (etm) (gasoline) (on left side of engine)
• Engine control module (ecm) (at right side of engine compartment, forward of strut tower)
• Gear selector module (gsm) (under center floor console)
• Left seat heater (in left seat bottom)
• Level sensor alarm (lsm) (left rear of trunk)
• M/t
• Nca
• Parking assistance module (pam) (left rear of luggage compartment)
• Passenger door module (pdm) (in passenger's door module)
• Phone module (phm) (center of dash)
• Power seat module (psm) (under seat)
• Rear electronic module (rem) (at left rear corner of trunk)
• Right seat warmer (in right seat bottom)
• Road traffic information (rti) (at left side of trunk)
• Transmission control module (tcm) (at right side of engine compartment, forward of strut tower)

COOLING FAN

Cooling Fan Wiring Diagram for Volvo S60 T-5 2005

List of elements for Cooling Fan Wiring Diagram for Volvo S60 T-5 2005:

• (at right front of engine compt) cooling fan control module
• (front of engine compt) electric cooling fan motor
• A21
• A39
• A40
• A58
• A60
• A61
• A68
• B13
• Climate control system pressure sensor (at right front of engine compt)
• Computer data lines system
• Coolant temperature sensor (on left front of engine)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Except turbo
• Fuse a8 60a
• G2 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Red
• Turbo

CRUISE CONTROL

Cruise Control Wiring Diagram for Volvo S60 T-5 2005

List of elements for Cruise Control Wiring Diagram for Volvo S60 T-5 2005:

• (center of steering column) contact reel
• (under left side of dash, at top of accelerator pedal assembly) accelerator pedal sensor
• 2.4l
• 2.4l turbo, 2.5l turbo
• A19
• A20
• A25
• A35
• A36
• A43
• A59
• B11
• B13
• B15
• B17
• B25
• B38
• Brake control module (at left rear of engine compt)
• Brake pedal sensor (at left rear of engine compt)
• Central electronic module (behind left side of dash)
• Clutch pedal sensor (under left side of dash, at top of clutch pedal assembly)
• Computer data lines system
• Cruise control switch
• D17
• D31
• D46
• D58
• Engine
• Engine compt relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (at right side of engine compt, forward of strut tower)
• Engine throttle body (on top of throttle body assembly)
• Fuse b23 10a
• Fuse b8 10a
• Fuse c9 5a
• G84 (at right kick panel)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Instrument cluster
• Left-hand front abs sensor (on left hub assembly)
• Management system main relay
• Nca
• Passenger compartment relay box (behind left side of dash)
• Red
• Right-hand front abs sensor (on right hub assembly)
• Steering wheel module (in steering column)

DEFOGGERS

Heated Mirrors Wiring Diagram for Volvo S60 T-5 2005

List of elements for Heated Mirrors Wiring Diagram for Volvo S60 T-5 2005:

• A10
• A11
• B10
• B11
• B12
• Climate control module
• Computer data lines system
• Driver door control module (ddm) (in driver's door)
• Driver's power door mirror (in driver's door mirror)
• Fuse c4 25a
• Fuse c5 25a
• G66 (below drivers seat, near kick panel)
• G67 (below passengers seat, near kick panel)
• Heated rear window/door mirrors switch
• Hot at all times
• Interior lights system
• Mirror heating element
• Nca
• Passenger compartment relay & fuse box (behind left side of dash)
• Passenger door control module (pdm) (in driver's door)
• Passenger power door mirror (in front passenger door mirror)
• Red

Rear Defogger Wiring Diagram for Volvo S60 T-5 2005

List of elements for Rear Defogger Wiring Diagram for Volvo S60 T-5 2005:

• A11
• A15
• A16
• Battery fuse box
• C13
• C14
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• D35
• D50
• Fuse 20a
• Fuse e1 60a
• G5 (at right "c" pillar)
• Heated rear window
• Heated rear window/ door mirrors switch
• Hot at all times
• Nca
• Rear electronic module (at left rear corner of trunk)
• Red
• Right window antenna amplifier 1 (on right "c" pillar)
• W/ road traffic information (rti)
• W/o road traffic information (rti)
• Window antenna amplifier

ELECTRONIC POWER STEERING

Electronic Power Steering Wiring Diagram for Volvo S60 T-5 2005

List of elements for Electronic Power Steering Wiring Diagram for Volvo S60 T-5 2005:

• A37
• A55
• B13
• B23
• Brake control module (left rear of engine compt)
• C17
• C21
• C22
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• D32
• D47
• Driver information module (dim)
• Electronic power steering control module (under left side of dash)
• Engine control module (ecm) (right side of engine compt)
• Fuse 10a
• Fuse e4 50a
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Main fuses
• Nca
• Red
• Speed dependent power steering valve

ELECTRONIC SUSPENSION

Electronic Suspension Wiring Diagram for Volvo S60 T-5 2005

List of elements for Electronic Suspension Wiring Diagram for Volvo S60 T-5 2005:

• (at left rear of vehicle) (four-c/bi-xenon) left rear angle sensor
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• Battery fuse box
• C13
• C14
• Computer data lines system
• Continuous controlled damping switch unit(ccd) (s60r)
• Fuse e1 60a
• G10 (at right kick panel)
• Hot at all times
• Left front four-c acceleration sensor (behind left front bumper)
• Left front four-c shock absorber (in left front wheelwell)
• Left front four-c shock absorber acceleration sensor (at left front shock absorber assembly)
• Left rear four-c acceleration sensor (at left rear quarterpanel)
• Left rear four-c shock absorber (in left rear wheelwell)
• Nca
• Pnk
• Rear electronic module (rem) (at left rear corner of trunk)
• Red
• Right front four-c acceleration sensor (behind right side of front bumper)
• Right front four-c shock absorber (in right front wheelwell)
• Right front four-c shock absorber acceleration sensor (at right front shock absorber assembly)
• Right rear angle sensor (four-c/bi-xenon) (at right rear of vehicle)
• Right rear four-c shock absorber (in right rear wheelwell)
• Suspension module (sum) (under left side of center console)

ENGINE PERFORMANCE

2.4L

2.4L, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005:

• (at left side of engine in intake manifold) intake manifold pressure sensor
• (at rear of engine on air intake) mass airflow (maf) sensor
• (at right front of engine compt) climate control pressure sensor
• (rear of engine) pressure & temperature sensor
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• A33
• A34
• A35
• A36
• A37
• A38
• A39
• A40
• A41
• A42
• A43
• A44
• A45
• A46
• A47
• A48
• A49
• A50
• A51
• A52
• A53
• A54
• A55
• A56
• A57
• A58
• A59
• A60
• A61
• A62
• A63
• A64
• A65
• A66
• A67
• A68
• A69
• A70
• Computer data lines system
• Cooling fans system
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Engine throttle body (on top of throttle body assembly)
• Evap valve (at left front of engine compt)
• Exhaust side camshaft position sensor (at rear of engine)
• Front knock sensor (at top left front of engine)
• Fuel injectors (top of engine)
• G96 (at right side of engine compt, (on fender)
• Impulse sensor (gasoline) (at rear of engine)
• Intake side camshaft position sensor (on top rear of engine)
• Oil level sensor (at left side of engine)
• Pnk
• Red
• Variable valve time inlet solenoid (at top front of engine)

2.4L, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005:

• (behind left side of dash) central electronic module (cem)
• (in exhaust down pipe) front heated oxygen sensor
• (on left front of engine) coolant temperature sensor
• (up stream of right catalytic converter) rear heated oxygen sensor
• A16
• Acc
• Air preheating ptc resistor (center of engine compt)
• B11
• B16
• Battery fuse box
• Brake light contact (under left side of dash, at top of brake pedal assembly)
• C14
• C21
• C22
• C34
• C35
• Computer data lines system
• D16
• D60
• Fuse e4 15a
• Fuse e5 10a
• G88 (at top front of engine, near spark plugs)
• G89 (at top rear of engine, near spark plugs)
• G96 (at right side of engine compt, on fender)
• Hot at all times
• Ignition switch
• Lock
• Nca
• Off
• Oil pressure sensor (on lower left rear of engine)
• Pnk
• Red
• Run
• Spark plug & ignition coils (top of cylinder head cover)
• Spark plugs
• Start
• Variable valve timing outlet solenoid (top front of engine)

2.4L, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005:

• (at top of fuel tank) fuel pump
• Accelerator pedal sensor (under left side of dash, at top of accelerator pedal assembly)
• Air conditioning system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• B33
• B34
• B35
• B36
• B37
• B38
• B39
• B40
• B41
• B42
• B43
• B44
• B45
• B46
• B47
• B48
• Clutch pedal sensor (manual) (under left side of dash, at top of clutch pedal assembly)
• Computer data lines system
• Cooling fans system
• Driver information module (in instrument cluster)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (ecm) (at right side of engine compt forward of strut tower)
• Engine control system main relay
• Fuel leakage control pump (under rear of vehicle, forward of fuel tank)
• Fuel pump control module (on fuel tank assembly)
• Fuse b11 20a
• Fuse b21 15a
• Fuse b23 10a
• Fuse b3 10a
• Fuse b4 20a
• Fuse b5 15a
• Fuse b6 15a
• Fuse b8 10a
• G48 (at right rear of passenger's compt, near floor)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Outside temperature sensor (integral to left sideview mirror)
• Red

2.4L TURBO

2.4L Turbo, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L Turbo, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005:

• (at left side of engine in intake manifold) intake manifold pressure sensor
• (at left side of engine) oil level sensor
• (at rear of engine on air intake) mass airflow (maf) sensor
• (at right front of engine compt) climate control system pressure sensor
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• A33
• A34
• A35
• A36
• A37
• A38
• A39
• A40
• A41
• A42
• A43
• A44
• A45
• A46
• A47
• A48
• A49
• A50
• A51
• A52
• A53
• A54
• A55
• A56
• A57
• A58
• A59
• A60
• A61
• A62
• A63
• A64
• A65
• A66
• A67
• A68
• A69
• A70
• Computer data lines system
• Cooling fans system
• Engine control module (at right side of engine compt, forward of strut tower)
• Engine throttle body (on top of throttle body assembly)
• Evap valve (at left front of engine compt)
• Exhaust side camshaft position sensor (at rear of engine)
• Front knock sensor (at top left front of engine)
• Fuel injectors (top of engine)
• G96 (at right side of engine compt, on fender)
• Impulse sensor (gasoline) (at rear of engine)
• Intake side camshaft position sensor (on top rear of engine)
• Nca
• Pnk
• Pressure & temperature sensor (rear of engine)
• Rear knock sensor (at top left rear of engine)
• Red
• Variable valve timing outlet solenoid (top front of engine)

2.4L Turbo, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L Turbo, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005:

• (behind left side of dash) central electronic module (cem)
• (in exhaust down pipe) front heated oxygen sensor
• (on left front of engine) coolant temperature sensor
• (up stream of right catalytic converter) rear heated oxygen sensor
• A16
• Acc
• Air preheating ptc resistor (center of engine compt)
• B11
• B16
• Battery fuse box
• Brake light contact (under left side of dash, at top of brake pedal assembly)
• C14
• C21
• C22
• C34
• C35
• Computer data lines system
• D16
• D43
• D44
• D45
• D60
• Fuse e4 15a
• Fuse e5 10a
• G88 (at top front of engine, near spark plugs)
• G89 (at top rear of engine, near spark plugs)
• G96 (at right side of engine compt, on fender)
• Hot at all times
• Ignition switch
• Inlet variable valve time solenoid (at top front of engine)
• Lock
• Nca
• Off
• Oil pressure sensor (on lower left rear of engine)
• Pnk
• Red
• Run
• Spark plug & ignition coils (top of cylinder head cover)
• Spark plugs
• Start
• Turbocharger control valve (on top rear of engine)

2.4L Turbo, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005

List of elements for 2.4L Turbo, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005:

• (at top of fuel tank) fuel pump
• Accelerator pedal sensor (under left side of dash, at top of accelerator pedal assembly)
• Air conditioning system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• B33
• B34
• B35
• B36
• B37
• B38
• B39
• B40
• B41
• B42
• B43
• B44
• B45
• B46
• B47
• B48
• Clutch pedal sensor (w/ m/t) (under left side of dash, at top of clutch pedal assembly)
• Computer data lines system
• Cooling fans system
• Driver information module (in instrument cluster)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Engine control system main relay
• Fuel leakage control pump (under rear of vehicle, forward of fuel tank)
• Fuel pump control module (on fuel tank assembly)
• Fuse b11 20a
• Fuse b21 15a
• Fuse b23 10a
• Fuse b4 20a
• Fuse b5 15a
• Fuse b6 15a
• Fuse b8 10a
• G48 (at right rear
• G48 (at right rear of passenger's compt, near floor)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Of passenger's compt, near floor)
• Outside temperature sensor
• Red

2.5L TURBO

2.5L Turbo, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005

List of elements for 2.5L Turbo, Engine Performance Wiring Diagram (1 of 3) for Volvo S60 T-5 2005:

• (at left side of engine in intake manifold) intake manifold pressure sensor
• (at left side of engine) oil level sensor
• (at rear of engine on air intake) mass airflow (maf) sensor
• (at right front of engine compt) climate control system pressure sensor
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• A33
• A34
• A35
• A36
• A37
• A38
• A39
• A40
• A41
• A42
• A43
• A44
• A45
• A46
• A47
• A48
• A49
• A50
• A51
• A52
• A53
• A54
• A55
• A56
• A57
• A58
• A59
• A60
• A61
• A62
• A63
• A64
• A65
• A66
• A67
• A68
• A69
• A70
• Computer data lines system
• Cooling fans system
• Engine control module (at right side of engine compt, forward of strut tower)
• Engine throttle body (on top of throttle body assembly)
• Evap valve (at left front of engine compt)
• Exhaust side camshaft position sensor (at rear of engine)
• Front knock sensor (at top left front of engine)
• Fuel injectors (top of engine)
• G96 (at right side of engine compt, on fender)
• Impulse sensor (gasoline) (at rear of engine)
• Intake side camshaft position sensor (on top rear of engine)
• Nca
• Pnk
• Pressure & temperature sensor (rear of engine)
• Rear knock sensor (at top left rear of engine)
• Red
• Variable valve timing outlet solenoid (top front of engine)

2.5L Turbo, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005

List of elements for 2.5L Turbo, Engine Performance Wiring Diagram (2 of 3) for Volvo S60 T-5 2005:

• (behind left side of dash) central electronic module (cem)
• (in exhaust down pipe) front heated oxygen sensor
• (on left front of engine) coolant temperature sensor
• (up stream of right catalytic converter) rear heated oxygen sensor
• A16
• Acc
• Air preheating ptc resistor (center of engine compt)
• B11
• B16
• Battery fuse box
• Brake light contact (under left side of dash, at top of brake pedal assembly)
• C14
• C21
• C22
• C34
• C35
• Computer data lines system
• D16
• D43
• D44
• D45
• D60
• Fuse e4 15a
• Fuse e5 10a
• G88 (at top front of engine, near spark plugs)
• G89 (at top rear of engine, near spark plugs)
• G96 (at right side of engine compt, on fender)
• Hot at all times
• Ignition switch
• Inlet variable valve time solenoid (at top front of engine)
• Lock
• Nca
• Off
• Oil pressure sensor (on lower left rear of engine)
• Pnk
• Red
• Run
• Spark plug & ignition coils (top of cylinder head cover)
• Spark plugs
• Start
• Turbocharger control valve (on top rear of engine)

2.5L Turbo, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005

List of elements for 2.5L Turbo, Engine Performance Wiring Diagram (3 of 3) for Volvo S60 T-5 2005:

• (at top of fuel tank) fuel pump
• Accelerator pedal sensor (under left side of dash, at top of accelerator pedal assembly)
• Air conditioning system
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• B22
• B23
• B24
• B25
• B26
• B27
• B28
• B29
• B30
• B31
• B32
• B33
• B34
• B35
• B36
• B37
• B38
• B39
• B40
• B41
• B42
• B43
• B44
• B45
• B46
• B47
• B48
• Clutch pedal sensor (w/ m/t) (under left side of dash, at top of clutch pedal assembly)
• Computer data lines system
• Cooling fans system
• Driver information module (in instrument cluster)
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Engine control system main relay
• Fuel leakage control pump (under rear of vehicle, forward of fuel tank)
• Fuel pump control module (on fuel tank assembly)
• Fuse b11 20a
• Fuse b21 15a
• Fuse b23 10a
• Fuse b4 20a
• Fuse b5 15a
• Fuse b6 15a
• Fuse b8 10a
• G48 (at right rear
• G48 (at right rear of passenger's compt, near floor)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Nca
• Of passenger's compt, near floor)
• Outside temperature sensor
• Red

EXTERIOR LIGHTS

Back-up Lamps Wiring Diagram for Volvo S60 T-5 2005

List of elements for Back-up Lamps Wiring Diagram for Volvo S60 T-5 2005:

• A15
• A18
• B13
• B14
• B23
• C13
• C14
• C21
• C22
• C28
• Central electronic module (behind left side of dash)
• Computer data lines system
• D35
• D50
• Fuse 1 10a
• Fuse e1 60a
• G72 (at left rear of passenger's compt, near floor)
• G73 (at right rear of passenger's compt, near floor)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Left rear lamp housing
• Left reversing light
• Main fuses (next to battery)
• Rear electronic module (rem) (at left rear corner of trunk)
• Reversing light contact (m/t) (on top of transmission)
• Right rear lamp housing
• Right reversing light
• S60
• S80
• Transmission control module (at right side of engine compt, forward of strut tower)

Exterior Lamps Wiring Diagram (1 of 3) for Volvo S60 T-5 2005

List of elements for Exterior Lamps Wiring Diagram (1 of 3) for Volvo S60 T-5 2005:

• (at left kick panel) g6
• (s60)
• (s80)
• A12
• A15
• A29
• Auxiliary brake lamp
• B/u
• B11
• B24
• B31
• B32
• Back-up
• Brake
• Brake light switch (under left side of dash, at top of brake pedal assembly)
• C19
• C20
• C34
• Central electronic module (behind left side of dash)
• Computer data lines system
• D14
• D22
• D34
• D35
• D41
• D49
• D50
• D58
• Driver information module (in instrument cluster)
• Engine compartment fuse box (at left side of engine compt, forward of strut tower)
• Fog
• Fuse 9 60a
• Fuse b18 15a
• Fuse c9 5a
• G72 (at left rear of passenger's compt, near floor)
• G84 (at right kick panel)
• G93 (at left side of engine compt, on fender)
• G94 (at right side of engine compt, on fender)
• G98 (above center of windshield)
• Hazard warning flasher switch
• Headlights
• Hot at all times
• Left front direction lamp
• Left front lamp housing
• Left front position/ parking lamp (s80)
• Left front side marker lamp
• Left rear lamp housing
• Lighting switch unit
• Lights circuit
• Park
• Park/ position
• Passenger compartment fuse box (behind left side of dash)
• Pnk
• Red
• Right front direction lamp
• Right front position/ parking lamp (s80)
• S60
• S80
• Steering wheel module (in steering column)
• System
• Tail
• Turn

Exterior Lamps Wiring Diagram (2 of 3) for Volvo S60 T-5 2005

List of elements for Exterior Lamps Wiring Diagram (2 of 3) for Volvo S60 T-5 2005:

• (s60)
• (s80)
• A13
• A18
• A20
• A21
• B/u
• B10
• B11
• Back-up lights circuit
• Battery fuse box
• Brake
• C13
• C14
• Computer data lines system
• D18
• F10
• Fog
• Fuse 20a
• Fuse 25a
• Fuse e1 60a
• Fuse e4 50a
• Fuse e5 50a
• G73 (at right rear of passenger's compt, near floor)
• G94 (at right side of engine compt, on fender)
• Headlights system
• Hot at all times
• License plate light
• Nca
• Park
• Park/ position
• Pnk
• Rear electronic module (at left rear corner of trunk)
• Red
• Right front lamp housing
• Right front side marker lamp
• Right rear lamp housing
• S60
• S80
• Tail
• Trunk handle switch
• Turn

Exterior Lamps Wiring Diagram (3 of 3) for Volvo S60 T-5 2005

List of elements for Exterior Lamps Wiring Diagram (3 of 3) for Volvo S60 T-5 2005:

• 13-pin socket
• 4-pin socket
• 7-pin socket
• A10
• A11
• A12
• Fog light
• G120 (left rear of cargo compt)
• Gnd
• L turn
• Pnk
• Position
• R turn
• Red
• Stop light
• Stop/l turn
• Stop/l turn sig
• Stop/r turn
• Stop/r turn sig
• Towbar cable harness (13-pin socket)
• Towbar cable harness (4-pin socket)
• Towbar cable harness (7-pin socket)
• Towbar converter
• Trailer module (trm) (left rear of trunk)

GROUND DISTRIBUTION

Ground Distribution Wiring Diagram for Volvo S60 T-5 2005

List of elements for Ground Distribution Wiring Diagram for Volvo S60 T-5 2005:

• (left kick panel)
• Accelerator pedal sensor
• Accessory electronic module (aem)
• Air preheating ptc resistor
• Air quality sensor (aqs)
• Alarm siren (scm)
• Amplifier
• Antenna ring/ ignition switch lighting
• Audio module (aum)
• Automatic transmission solenoids
• Auxiliary brake light
• Auxiliary heater
• Auxiliary heater fuel pump
• Battery
• Brake control module (bcm)
• Brake fluid level sensor
• Capacitor
• Cargo compartment outlet
• Cd changer
• Cd changer (if equipped)
• Central electronic module (cem)
• Climate control module (ccm)
• Cng/lpg gas fuel distributor
• Combustion preheater module (cpm)
• Coolant level sensor
• Damper motor module (dmm)
• Data link connector
• Defroster damper motor module (dmm)
• Differential electronic module (dem)
• Dome light switch unit
• Driver door module (ddm)
• Driver information module
• Driver information module (dim)
• Driver's side seat heater module (shm)
• Electric cooling fan control module
• Electronic power steering control module
• Engine compartment distribution box
• Engine control module (ecm)
• Engine heater relay
• Eu/os left front fender direction indicator
• Eu/os right front fender direction indicator
• Fan control module
• Feed pump ejectors
• Floor/ventilation damper motor module (dmm)
• Front 12 volt outlet
• Front left side airbag igniter
• Front mass movement sensor (mms)
• Front right side airbag igniter
• Fuel pump
• Fuel pump control module
• G1 (right side of engine compt, on fender)
• G10 (right kick panel)
• G102 (behind left side of front bumper)
• G120 (left rear of cargo compt)
• G2 (left side of engine compt, on fender)
• G4 (rear left side of engine)
• G44 (left front of engine compt)
• G46 (at rear left seat riser)
• G47 (left rear of passenger's compt, near floor)
• G48 (right rear of passengers compt, near floor)
• G5 (right "c" pillar)
• G53 (at left side of firewall)
• G6 (left kick panel)
• G66 (below driver's seat, near kick panel)
• G67 (below passenger's seat, near kick panel)
• G70 (lower left side of engine compt)
• G72 (left rear of passenger's compt, near floor)
• G73 (right rear of passengers compt, near floor)
• G83
• G84 (right kick panel)
• G88 (top front of engine, near spark plugs)
• G89 (top rear of engine near spark plugs)
• G93 (left side of engine compt, on fender)
• G94 (right side of engine compt, on fender)
• G95 (left side of engine compt, on fender)
• G96 (right side of engine compt, on fender)
• G98 (above center of windshield)
• Glove compartment lighting
• Hazard warning flasher switch
• Heated rear window
• High pressure headlight washer motor
• Hood alarm contact
• Horn 1
• Horn 2
• Ignition coil 1
• Ignition coil 2
• Ignition coil 3
• Ignition coil 4
• Ignition coil 5
• Ignition coil 6 (2.9l)
• Inclination sensor module (ism)
• Intermittent wiping relay
• Left cargo compartment lighting
• Left front accessory auxiliary light
• Left front cng fuel tank solenoid
• Left front courtesy lighting
• Left front direction indicator
• Left front foglight
• Left front lamp housing
• Left front parking light
• Left front side marker light
• Left headlight level adjustment motor
• Left headlight wiper motor
• Left rear door power window switch
• Left rear lamp housing
• Left vanity mirror lighting
• Left-hand rear door lock unit
• Left-hand vanity mirror lighting
• Light switch module (lsm)
• Manual solenoid reverse interlock
• Mass movement sensor (mms) alarm
• Parking assistance module (pam)
• Passenger door module (pdm)
• Passenger side seat heater module (shm)
• Phone module (phm)
• Power passenger seat switch unit
• Power seat module (psm)
• Rain sensor
• Rain sensor module (rsm)
• Rear 12 volt outlet
• Rear cng gas tank solenoid
• Rear electronic module (rem)
• Rear left head restraint solenoid
• Rear reading light
• Remote parking heater start control module
• Remote parking heater start radio signal relay
• Reversing light contact (manual transmission)
• Right & left-hand side damper motor module (dmm)
• Right cargo compartment lighting
• Right front accessories auxiliary light
• Right front cng fuel tank solenoid
• Right front courtesy lighting
• Right front direction indicator
• Right front foglight
• Right front lamp housing
• Right front parking light
• Right front side marker light
• Right headlight level adjustment motor
• Right rear head restraint solenoid
• Right rear courtesy lighting (s80)
• Right rear door power window switch
• Right tail light lamp housing
• Right vanity mirror lighting
• Right-hand headlight wiper motor
• Rti display
• Rti system control module
• Steering wheel module (swm)
• Sunroof control module
• Sunroof control module (srm)
• Suspension control module (sum)
• Thermostatic switch & fuel filter heating
• Towbar cable harness (13-pin outlet)
• Towbar cable harness (7-pin outlet)
• Trailer module (trm)
• Transmission control module (tcm)
• Upper electronic module (uem)
• Vacuum pump
• Washer fluid level sensor
• Windshield wiper motor

HEADLIGHTS

Headlights Wiring Diagram for Volvo S60 T-5 2005

List of elements for Headlights Wiring Diagram for Volvo S60 T-5 2005:

• (at right kick panel) g84
• (behind left side of dash) central electronic module
• A15
• A18
• B17
• B18
• B23
• B27
• B28
• B35
• B50
• Battery fuse box
• Bifunc gdl
• C13
• C14
• Central electronic module (behind left side of dash)
• Computer data lines system
• D34
• D41
• D49
• D58
• Driver information module (dim)
• Drl
• Engine compartment fuse box (left side of engine compt (forward of strut tower)
• Fog light
• Fuse b17 20a
• Fuse b20 20a
• Fuse c9 5a
• Fuse e1 60a
• Fuse e4 50a
• Fuse e5 50a
• Fuse f16 10a
• Fuse f17 7.5a
• Fuse f18 7.5a
• Fuse f22 10a
• Fuse f23 10a
• G72 (at left rear of passenger's compt near floor)
• G73 (at right rear of passenger's compt near floor)
• G93 (left side of engine compt on fender)
• G94 (right side of engine compt on fender)
• High
• Hot at all times
• Left front fog light
• Left front lamp housing
• Left rear lamp housing
• Light switch module
• Low
• Passenger compartment relay box (behind left side of dash)
• Pnk
• Rear electronic module (at left rear corner of trunk)
• Red
• Right front fog light
• Right front lamp housing
• Right rear lamp housing
• Steering wheel module (in steering column)

HORN

Horn Wiring Diagram for Volvo S60 T-5 2005

List of elements for Horn Wiring Diagram for Volvo S60 T-5 2005:

• (in steering column) steering wheel module
• B15
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• Contact reel (center of steering column)
• D17
• D34
• D35
• D49
• D50
• D58
• Fuse c9 5a
• Fuse e5 50a
• Fuse f3 15a
• G84 (at right kick panel)
• G93 (at left side of engine compt, on fender)
• Horn 1 (left front of engine compt)
• Horn 2 (left front of engine compt)
• Horn contact (in steering wheel)
• Hot at all times
• Main fuses
• Nca
• Passenger compartment relay box (behind left side of dash)
• Red

INSTRUMENT CLUSTER

Instrument Cluster Wiring Diagram for Volvo S60 T-5 2005

List of elements for Instrument Cluster Wiring Diagram for Volvo S60 T-5 2005:

• (at left rear of engine compt) brake control module (bcm)
• (behind left side of dash) central electronic module
• (on left hub assembly) left front abs sensor
• (on right hub assembly) right front abs sensor
• (on washer fluid tank, at right front of engine compt) washer fluid level sensor
• 2.4l
• 2.5l turbo & 2.4l turbo
• A/t
• A10
• A14
• A18
• A26
• A39
• A40
• A48
• A58
• A60
• A61
• A66
• A68
• B13
• B14
• B46
• Battery fuse box
• Brake fluid level sensor (on brake master cylinder reservoir)
• C10
• C13
• C14
• C21
• C22
• Computer data lines system
• Coolant level sensor (at right side of engine compt, in coolant tank)
• Coolant temperature sensor (on left front of engine)
• D34
• D35
• D43
• D44
• D45
• D49
• D50
• Driver information module (in instrument cluster)
• Ejector side fuel level sensor
• Engine control module (ecm) (at right side of engine compt, forward of strut tower)
• Except 2.4l 2.4l
• Except s60r
• Fuel pump (at top of fuel tank)
• Fuse e5 50a
• Fuse f10 10a
• G1 (at right side of engine compt, on fender)
• G83 (at left kick panel)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Impulse sensor (at rear of engine)
• M/t
• Nca
• Oil level sensor (at left side of engine)
• Oil pressure sensor (on lower left rear of engine)
• Outside temperature sensor
• Parking brake switch (at base of parking brake lever)
• Passenger door module (pdm) (in passenger's door module)
• Passenger door power mirror
• Pump side fuel level sensor
• Rear electronic module (rem) (at left rear corner of trunk)
• Red
• S60r
• Transmission control module (tcm) (at right side of engine compt, forward of strut tower)

INTERIOR LIGHTS

Courtesy Lamps Wiring Diagram for Volvo S60 T-5 2005

List of elements for Courtesy Lamps Wiring Diagram for Volvo S60 T-5 2005:

• (above center of windshield) g98
• (at rear left seat riser)
• (behind left side of dash) central electronic module
• (below driver's seat near kick panel)
• (in driver's door) driver door module
• (in passenger's door module
• (in trunk lid)
• (rear of left front door) left front door lock unit
• (rear of right front door) right front door lock unit
• A10
• Antenna ring/ ignition switch light
• B10
• B12
• Battery fuse box
• C12
• C13
• C14
• Computer data lines system
• D11
• D13
• D29
• D33
• D34
• D35
• D49
• D50
• Dome light switch unit
• Door
• Driver's power door mirror
• Fuse c4 25a
• Fuse c5 25a
• Fuse c6 10a
• Fuse e1 60a
• Fuse e4 50a
• G46
• G6 (left kick panel)
• G66
• G66 (below driver's seat near kick panel)
• G67 (below passenger's seat near kick panel)
• G72 (left rear of passengers compt near floor)
• G73 (right rear of passenger's compt near floor)
• G98 (above center of windshield)
• Glove compartment light
• Hot at all times
• Left door mirror light
• Left front courtesy light
• Left rear courtesy light (s80)
• Left rear door lock unit (rear of left rear door)
• Left side cargo compartment light
• Left vanity mirror light
• Nca
• Passenger
• Passenger compartment relay box (behind left side of dash)
• Pnk
• Rear electronic module (left rear corner of trunk)
• Rear reading light
• Red
• Right door mirror light
• Right front courtesy light
• Right power door mirror
• Right rear courtesy light (s80)
• Right rear door lock unit (rear right rear door)
• Right rear door/ power window switch
• Right side cargo compartment light
• Right vanity mirror light
• Steering wheel module (in steering column)
• Trunk lid lock unit
• Upper electronic module (above center of windshield on rearview mirror)

Instrument Illumination Wiring Diagram for Volvo S60 T-5 2005

List of elements for Instrument Illumination Wiring Diagram for Volvo S60 T-5 2005:

• (at rear left seat riser)
• (below drivers seat, near kick panel) g66
• (below passengers seat, near kick panel)
• A10
• A11
• A16
• A19
• Audio module (center of dash)
• Audio/cellular phone switch
• B12
• B30
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Contact reel (center of steering column)
• Continuously controlled damping switch unit (s80)
• Cruise control switch unit
• D14
• D34
• D35
• D41
• D49
• D50
• Dome light switch unit
• Driver door module (in driver's door)
• Driver information module (in instrument cluster)
• Fuse c4 25a
• Fuse c5 25a
• Fuse c9 5a
• Fuse e1 60a
• Fuse e4 50a
• Fuse f10 20a
• Fuse f9 20a
• G46
• G6 (left kick panel)
• G67
• G67 (below passengers seat, near kick panel)
• G84 (right kick panel)
• Hazard warning flasher switch
• Hot at all times
• Left heated seat switch
• Left rear door power window switch
• Light control module switch
• Main fuses
• Nca
• Passenger compartment relay box (behind left side of dash)
• Passenger door module (in passenger's door module
• Power sun roof switch
• Rear adjustable head restraint relay
• Rear electronic module (at left rear corner of trunk)
• Rear heated window/door mirror switch
• Red
• Reduced alarm switch
• Retractable door mirrors switch
• Right heated seat switch
• Right rear door power window switch
• Spin control switch
• Steering wheel module (in steering column)
• Trunk lid/ private lock switch
• Upper electronic module (above center of windshield, on rearview mirror)

MEMORY SYSTEMS

Driver"s Memory Seat Wiring Diagram for Volvo S60 T-5 2005

List of elements for Driver"s Memory Seat Wiring Diagram for Volvo S60 T-5 2005:

• A10
• B10
• B11
• B12
• Back
• Backrest angle switch
• Battery fuse box
• Central electronic module (behind left side of dash)
• D36
• D51
• Down
• Driver seat backrest angle motor (in driver's seat back)
• Driver seat forward/backward motor (in driver seat)
• Driver seat front edge up/down motor (in driver's seat bottom)
• Driver seat rear edge up/down motor (in driver's seat bottom)
• Driver's side power seat switch
• Forw
• Forward/ backward switch
• Front edge up/down switch
• Fuse 20a
• Fuse c1 25a
• Fuse e5 50a
• G46 (at rear left seat riser)
• Hot at all times
• Passenger compartment relay & fuse box (behind left side of dash)
• Position
• Position 1
• Position 2
• Position 3
• Power seat module (psm) (under seat)
• Rear edge up/down switch
• Rearw
• Red

Memory Mirrors Wiring Diagram for Volvo S60 T-5 2005

List of elements for Memory Mirrors Wiring Diagram for Volvo S60 T-5 2005:

• A10
• A11
• A25
• A26
• A27
• A28
• A29
• B12
• Climate control module (ccm)
• Computer data lines system
• Defogger system
• Driver/passenger door module (ddm/pdm) (in driver's door)
• Fold-back
• Fuse c4 25a
• Fuse c5 25a
• G66 (below driver's seat, near kick panel)
• G67 (below passenger's seat, near kick panel)
• Hot at all times
• Mem x
• Mem y
• Nca
• Nca nca
• Passenger compartment fuse box (behind left side of dash)
• Passenger/driver door module (pdm/ddm) (in passenger's door module)
• Pnk
• Power driver's door mirror (in driver's door mirror)
• Power passenger door mirror (in front passenger door mirror)
• Red
• Retractable door mirrors switch
• X-direction
• Y-direction

NAVIGATION

Navigation Wiring Diagram for Volvo S60 T-5 2005

List of elements for Navigation Wiring Diagram for Volvo S60 T-5 2005:

• (at left rear
• (at rear window) window antenna
• (behind left side of dash) central electronic module
• (behind right side of rear bumper) bumper antenna
• (center of rear window) rti gps antenna
• (on right "c" pillar) right window antenna amplifier
• (s80)
• A13
• A15
• Audio module (center of dash)
• Audio/cellular phone switch
• B10
• Bumper amplifier antenna (behind right side of rear bumper)
• C10
• C13
• C14
• Cd changer
• Cd-changer
• Central electronic module (behind left side of dash)
• Computer data lines system
• Contact reel (center of steering column)
• Corner of trunk) rear electronic module
• D20
• D21
• D35
• D37
• D50
• D52
• D58
• Fuse c12 10a
• Fuse e1 60a
• Fuse e4 50a
• Fuse f28 5a
• Fuse f6 7.5a
• G120 (left rear of cargo compt)
• G72 (at left rear of passenger's compt, near floor)
• G84 (at right kick panel)
• Hot at all times
• Hot in on or start
• Left front door speaker
• Main fuses (at battery)
• Nca
• Nca nca
• Passenger compartment fuse box (behind left side of dash)
• Pnk
• Rear electronic module (at left rear corner of trunk)
• Red
• Road traffic information (at left side of trunk)
• Rti display
• Rti switch
• Rti/tv
• Steering wheel module (in steering column)
• Sws cruise control switch
• Tv receiver (left rear of luggage compt)
• Window antenna amplifier

Parking Assistant Wiring Diagram for Volvo S60 T-5 2005

List of elements for Parking Assistant Wiring Diagram for Volvo S60 T-5 2005:

• (at left rear corner of trunk) rear electronic module
• (at left rear of
• (behind bumper cover)
• A10
• A11
• A12
• B21
• C10
• C11
• C12
• C13
• C14
• Computer
• D32
• Data lines
• Front parking assistance sensor 5 (right side of front bumper)
• Front parking assistance sensor 6 (center right side of front bumper)
• Front parking assistance sensor 7 (center left side of front bumper)
• Front parking assistance sensor 8 (left side of front bumper)
• Fuse e1 60a
• G72
• Hot at all times
• Main fuses (at battery)
• Parking assistance module (left rear of luggage compt)
• Passenger's compt, near floor)
• Rear parking assistance sensor 1
• Rear parking assistance sensor 2
• Rear parking assistance sensor 3
• Rear parking assistance sensor 4
• System

POWER DISTRIBUTION

Power Distribution Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for Power Distribution Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (at left side of engine compt, forward of strut tower) engine compartment relay/fuse box
• (at left side of firewall)
• (left side of engine compt)
• (not used)
• 15/30 red
• Accelerator pedal sensor
• Auxiliary light relay (accessory)
• Battery
• Brake control module
• Capacitor
• Central electronic module
• Climate control system relay
• Combustion preheater module
• Cooling fan control module
• Engine compartment cooling fan electrics box
• Engine control module
• Engine control module, fuel injectors, mass airflow sensor
• Engine management system main relay
• Evap valve, engine control module, variable valve time inlet solenoid & air preheating ptc resistor turbocharger control valve (5 cyl turbo)
• Front & rear heated oxygen sensor & engine control module (5 cly w/o turbo)
• Fuel leakage control pump
• Fuel system relay
• Fuse a1 60a
• Fuse a2 40a
• Fuse a3 40a
• Fuse a4
• Fuse a8 60a
• Fuse b1 25a
• Fuse b11 20a
• Fuse b12 5a
• Fuse b13 25a
• Fuse b14 30a
• Fuse b15 35a
• Fuse b17 20a
• Fuse b18 15a
• Fuse b19 30a
• Fuse b2 20a
• Fuse b20 20a
• Fuse b21 15a
• Fuse b22 35a
• Fuse b23 10a
• Fuse b3 10a
• Fuse b4 20a
• Fuse b5 10a
• Fuse b6 15a
• Fuse b7
• Fuse b8 10a
• Fuse b9 10a
• G53
• G93 (at left side of engine compt, on fender)
• Generator
• Glow plug unit relay
• High pressure headlight washer motor
• High pressure headlight washer motor relay
• Intermittent wiping relay
• Jump start terminal
• Low/high speed windshield wiper relay
• Red
• Spark plug & ignition coil
• Starter motor
• Starter motor relay
• To battery fuse box (diagram 2 of 2)

Power Distribution Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for Power Distribution Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (behind left end of dash) passenger compartment relay & fuse box
• (behind left side of dash) central electronic module
• (not used)
• (s80)
• 12v outlet cargo compartment
• A red
• A17
• Acc
• Amplifier
• Audio module
• B31
• Battery fuse box
• Central electronic module
• D12
• Data link connector, steering wheel module & light switch module
• Driver/ passenger door module
• Fan control module
• From battery (diagram 1 of 2)
• Front 12v outlet
• Front ashtray lighting
• Fuse 15a
• Fuse c1 25a
• Fuse c10 20a
• Fuse c11 30a
• Fuse c12 10a
• Fuse c13 5a
• Fuse c2 25a
• Fuse c3 30a
• Fuse c4 25a
• Fuse c5 25a
• Fuse c6 10a
• Fuse c7 15a
• Fuse c8 7.5a
• Fuse c9 5a
• Fuse e1 60a
• Fuse e2
• Fuse e3
• Fuse e4 50a
• Fuse e5 50a
• Fuse e6 50a
• Fuse e7 50a
• G10 (at right kick panel)
• G73 (at right rear of passenger's compt, near floor)
• Ignition switch
• Key in ignition switch
• Key-in
• Lock
• Nca
• Off
• Passenger/ driver door module
• Phone module
• Power passenger seat & switch unit
• Power seat module & rear electronic module
• Rear 12v outlet
• Rear electronic module
• Rear electronic module (at left rear corner of trunk)
• Red
• Rti display
• Start
• Sunroof control module
• Upper electronic module,

POWER DOOR LOCKS

Power Door Locks Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for Power Door Locks Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (below driver's seat, near kick panel) g66
• (below passenger's seat, near kick panel) g67
• A10
• A11
• A12
• A13
• B12
• Bll
• Climate control module
• Computer data lines system
• Driver door module (ddm) (in driver's door)
• Fuse c4 25a
• Fuse c5 25a
• Hot at all times
• Key
• Left front door lock unit (rear of left front door)
• Lock
• Passenger compartment fuse box (behind left side of dash)
• Passenger door module (pdm) (in passenger's door module)
• Pnk
• Red
• Right front door lock unit (rear of right front door)
• Trunk lid private lock switch
• Unlock
• Upper electronic module (above center of windshield, on rearview mirror)

Power Door Locks Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for Power Door Locks Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• A23
• A24
• A27
• B12
• B24
• B26
• Battery fuse box
• Bll
• C12
• C13
• C14
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• D15
• D28
• D29
• D33
• D34
• D35
• D38
• D49
• D50
• D53
• F10
• Fuel filler flap locking motor (at right side of trunk, near fuel filler)
• Fuse e1 60a
• Fuse f28 15a
• G46 (at rear left seat riser)
• G67 (below passenger's seat, near kick panel)
• Hot at all times
• Ignition switch
• Key in ignition
• Left-hand rear door lock unit (rear of left rear door)
• License plate lighting
• Nca
• Pnk
• Rear electronic module (rem) (at left rear corner of trunk)
• Right rear door lock unit (rear of right rear door)
• Right rear door power window switch
• Trunk lid handle switch
• Trunk lid lock unit (center rear of trunk lid)

POWER MIRRORS

Power Mirrors Wiring Diagram for Volvo S60 T-5 2005

List of elements for Power Mirrors Wiring Diagram for Volvo S60 T-5 2005:

• (below driver's seat near kick panel) g66
• (below passenger's seat near kick panel) g67
• A10
• A11
• A25
• A26
• A27
• A28
• A29
• B12
• Climate control module (ccm)
• Computer data lines system
• Driver door module (in driver's door)
• Driver's power door mirror (in driver's door mirror)
• Fold back
• Fold-back
• Fuse c4 25a
• Fuse c5 25a
• Hot at all times
• Mem x
• Mem y
• Nca
• Passenger compartment relay box (behind left side of dash)
• Passenger door module
• Passenger power door mirror (in front passenger door mirror)
• Pnk
• Red
• Retractable door mirrors switch
• X direction
• X-direction
• Y direction
• Y-direction

POWER SEATS

Driver Power Seat Wiring Diagram for Volvo S60 T-5 2005

List of elements for Driver Power Seat Wiring Diagram for Volvo S60 T-5 2005:

• A10
• B10
• B11
• B12
• Back
• Battery fuse box
• Central electronic module (behind left side of dash)
• D36
• D51
• Down
• Driver seat backrest angle motor (in driver's seat back)
• Driver seat forward/backward motor (in driver seat)
• Driver seat front edge up/down motor (in driver's seat bottom)
• Driver seat rear edge up/down motor (in driver's seat bottom)
• Driver's side power seat switch
• Forw
• Forward/ backward
• Front edge
• Fuse 20a
• Fuse c1 25a
• Fuse e5 50a
• G46 (at rear left seat riser)
• Hot at all times
• Lumbar switch
• Passenger compartment relay & fuse box (behind left side of dash)
• Position
• Position 1
• Position 2
• Position 3
• Power seat module (psm) (under seat)
• Rear edge
• Rearw
• Red
• Switch
• Up/down

Heated Seats Wiring Diagram for Volvo S60 T-5 2005

List of elements for Heated Seats Wiring Diagram for Volvo S60 T-5 2005:

• A10
• A11
• A12
• A18
• A19
• Air conditioning system
• Backrest heater
• Battery fuse box
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Fuse 15a
• Fuse e4 50a
• G46 (at rear left seat riser)
• G67 (below passenger's seat near kick panel)
• Hot at all times
• Left heated seat switch
• Left seat heater module (in left seat bottom)
• Nca
• Red
• Right heated seat switch
• Right seat heater module (in right seat bottom)
• Seat heater
• Temperature sensor

Passenger"s Power Seat Wiring Diagram for Volvo S60 T-5 2005

List of elements for Passenger"s Power Seat Wiring Diagram for Volvo S60 T-5 2005:

• (in front passenger seat bottom) passenger forward/ backward seat motor
• (in passenger seat back) passenger backrest angle seat motor
• (in passenger seat bottom) passenger up/down front edge seat motor
• (in passenger seat bottom) passenger up/down rear edge seat motor
• A22
• Back
• Backrest switch
• Battery fuse box
• Central electronic module (behind left side of dash)
• Down
• Forw
• Forward/ backward switch
• Front edge up/down switch
• Fuse 5a
• Fuse c2 25a
• Fuse e4 50a
• G67 (below passenger's seat, near kick panel)
• Hot at all times
• Passenger compartment fuse box (at left end of dash)
• Power passenger seat module
• Rear edge up/down switch
• Red
• Stop logic

Rear Head Restraint Wiring Diagram for Volvo S60 T-5 2005

List of elements for Rear Head Restraint Wiring Diagram for Volvo S60 T-5 2005:

• A10
• A11
• A25
• B28
• Battery fuse box
• Climate control module
• Computer data lines system
• Fuse 15a
• Fuse e1 60a
• G46 (at rear left seat riser)
• G73 (at right rear of passenger's compt, near floor)
• Hot at all times
• Left rear head restraint solenoid (in left head rest assembly)
• Nca
• Rear adjustable head restraint switch
• Rear electronic module (rem) (at left rear corner of trunk)
• Right rear head restraint solenoid (in right rear head rest assembly)

POWER TOP/SUNROOF

Power Top/Sunroof Wiring Diagram for Volvo S60 T-5 2005

List of elements for Power Top/Sunroof Wiring Diagram for Volvo S60 T-5 2005:

• Bwd
• Computer data lines system
• Dome light switch unit
• Fuse c7 15a
• Fwd
• G6 (at left kick panel)
• G98 (above center of windshield)
• Hot at all times
• Passenger compartment relay box (behind left side of dash)
• Pnk
• Power sun roof switch
• Red
• Solid state
• Sun roof control module (srm) (forward of sunroof opening)
• Sun roof motor (in roof, forward of sun roof)
• Upper electronic module (uem) (above center of windshield, on rearview mirror)

POWER WINDOWS

Power Windows Wiring Diagram for Volvo S60 T-5 2005

List of elements for Power Windows Wiring Diagram for Volvo S60 T-5 2005:

• (below driver's seat, near kick panel)
• (in driver's door) driver door module (ddm)
• (in left front door) left front power window motor
• (in right front door) right front power window motor
• A16
• A19
• A23
• A24
• B12
• B30
• Computer data lines system
• Fuse 20a
• Fuse c4 25a
• Fuse c5 25a
• Fuse e1 60a
• G66
• G67 (below passenger's seat, near kick panel)
• Hot at all times
• Interior lights system
• Left rear door power window switch
• Left rear power window motor (in left rear door)
• Main fuses
• Passenger compartment fuse relay box (behind left side of dash)
• Passenger door module (pdm) (in passenger's door module)
• Rear electronic module (at left rear corner of trunk)
• Red
• Right rear door power window switch
• Right rear power window motor (in right rear door)
• S60
• S80
• Solid state

RADIO

Audio Adapter Harness Wiring Diagram for Volvo S60 T-5 2005

List of elements for Audio Adapter Harness Wiring Diagram for Volvo S60 T-5 2005:

• (at left rear corner of trunk) accessory electronic module
• (left rear of cargo compt) g120
• A10
• A11
• A12
• A13
• A14
• Acc +
• Audio module (center of dash)
• B10
• B12
• B13
• B14
• B22
• B30
• Batt
• D19
• D30
• Fuse 15a
• Gnd
• Hot at all times
• Lf+
• Lf-
• Lr+
• Lr-
• Pwr ant amp
• Rear electronic module (at left rear corner of trunk)
• Red
• Rf+
• Rf-
• Rheostat
• Rr+
• Rr-
• Speed-in
• Tele-mute

Radio Wiring Diagram, with Amplifier for Volvo S60 T-5 2005

List of elements for Radio Wiring Diagram, with Amplifier for Volvo S60 T-5 2005:

• (center of dash) audio module
• (left rear of passengers compt, near floor)
• (on right side of passenger compt) amplifier
• (right kick panel) g84
• (s80)
• +ant
• +cs
• -cs
• A10
• A11
• A12
• Acc
• Audio phone switch
• B10
• B11
• B12
• Bat
• Brake control module (at left rear of engine compt)
• Bumper antenna
• Bumper antenna amplifier
• Cd changer
• Center dashboard speaker
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Contact reel
• Cruise control switch (sws)
• Din (or coaxial cable)
• Fuse c10 20a
• Fuse c11 30a
• Fuse f28 5a
• Fuse f6 7.5a
• G72
• Gnd
• Hot at all times
• Hot in on or acc
• Left front door speaker
• Left front tweeter
• Left rear door speaker
• Left rear shelf speaker
• Nca
• Passenger compartment relay box (behind left side of dash)
• Rear electronic module (at left rear corner of trunk)
• Red
• Right front door speaker
• Right front tweeter
• Right rear door speaker
• Right rear shelf speaker
• Rti control module (left side of trunk)
• Solid state
• Steering wheel module (swm)
• Tv receiver (left rear of luggage compt)
• Window antenna
• Window antenna amplifier

Radio Wiring Diagram, without Amplifier for Volvo S60 T-5 2005

List of elements for Radio Wiring Diagram, without Amplifier for Volvo S60 T-5 2005:

• (center of dash) audio module
• (left rear of passengers compt, near floor)
• (s80)
• +ant
• +lf
• +lr
• +rf
• +rr
• -lf
• -lr
• -rf
• -rr
• A10
• A11
• A12
• Acc
• Audio phone switch
• B10
• B11
• B12
• Bat
• Brake control module (at left rear of engine compt)
• Bumper antenna
• Bumper antenna amplifier
• Cd changer
• Central electronic module (behind left side of dash)
• Climate control module
• Computer data lines system
• Contact reel
• Cruise control switch (sws)
• Din (or coaxial cable)
• Fuse c10 20a
• Fuse f28 5a
• Fuse f6 7.5a
• G72
• G84 (right kick panel)
• Gnd
• Hot at all times
• Hot in on or acc
• Left front door speaker
• Left front tweeter
• Left rear door speaker
• Left rear shelf speaker
• Nca
• Passenger compartment relay box (behind left side of dash)
• Rear electronic module (at left rear corner of trunk)
• Red
• Right front door speaker
• Right front tweeter
• Right rear door speaker
• Right rear shelf speaker
• Rti control module (left side of trunk)
• Solid state
• Steering wheel module (swm)
• Tv receiver (left rear of luggage compt)
• Window antenna
• Window antenna amplifier

SHIFT INTERLOCK

Shift Interlock Wiring Diagram for Volvo S60 T-5 2005

List of elements for Shift Interlock Wiring Diagram for Volvo S60 T-5 2005:

• (at left side of engine compartment, on fender) g93
• (at right side of engine compartment,on fender) g94
• (at top of brake pedal) brake light contact
• A/t
• A25
• A53
• A54
• B11
• B13
• B14
• B21
• C21
• C22
• C34
• Central electronic module (behind left side of dash)
• Computer data lines system
• D23
• D32
• D47
• Fuse e5 50a
• Fuse f21 10a
• Fuse f9 5a
• Gear selector module (under center floor console)
• Hot at all times
• M/t
• Main fuses
• Nca
• Red
• Reverse interlock solenoid
• Shift lock solenoid (in floor console, at base of gear selector lever)
• Transmission control module (at right side of engine compartment, forward of strut tower)

STARTING/CHARGING

Charging Wiring Diagram for Volvo S60 T-5 2005

List of elements for Charging Wiring Diagram for Volvo S60 T-5 2005:

• (left rear of engine compartment) jump start connection
• Battery
• Battery fuse box
• C16
• C21
• C22
• Central electronic module (behind left side of dash)
• Computer data lines system
• D34
• D49
• Engine compartment relay/fuse box (at left side of engine compartment, forward of strut tower)
• G53 (at left side of firewall)
• Generator
• Instrument cluster
• Power distribution system
• Red
• Starter motor

Starting Wiring Diagram for Volvo S60 T-5 2005

List of elements for Starting Wiring Diagram for Volvo S60 T-5 2005:

• (left rear of engine compartment) jump start connection
• 2.9l turbo
• A/t
• A/t solenoid (a/t)
• A44
• A53
• Acc
• B13
• B14
• B15
• B23
• Battery
• C21
• C22
• C28
• Central electronic module (behind left side of dash)
• Clutch pedal sensor (m/t) (under left side of dash, at top clutch pedal assembly)
• Computer data lines system
• D15
• D16
• D32
• D47
• D60
• Engine compartment relay/fuse box (at left side of engine compartment, forward of strut tower)
• Engine control module (at right side of engine compartment, forward of strut tower)
• Except 2.9l turbo
• Fuse b22 20a
• Fuse c8 7.5a
• G53 (at left side of firewall)
• G93 (at left side of engine compartment, on fender)
• G94 (at right side of engine compartment, on fender)
• Generator
• Hot at all times
• Ignition switch
• Key in ignition
• Lock
• Nca
• Off
• Passenger compartment fuse box (behind left side of dash)
• Red
• Start
• Starter motor (left side of engine)
• Starter motor relay
• Transmission control module (a/t) (at right side of engine compartment, forward of strut tower)

SUPPLEMENTAL RESTRAINTS

Supplemental Restraints Wiring Diagram (1 of 2) for Volvo S60 T-5 2005

List of elements for Supplemental Restraints Wiring Diagram (1 of 2) for Volvo S60 T-5 2005:

• (on left "b" pillar) left hand front side impact sensor
• (on left "c" pillar) rear left belt tensioner igniter
• 31/46 (at rear left seat riser)
• Acc
• Central electronic module (behind left side of dash)
• Contact reel (center of steering column)
• D20
• D33
• D34
• D37
• D40
• D48
• D49
• D52
• D55
• Data link connector (partial) (below left side of dash)
• Driver information module (dim) (in instrument cluster)
• Driver side air bag igniter (in steering wheel)
• Driver side air bag igniter step 2 (in steering wheel assembly)
• Front left belt tensioner igniter (on left "b" pillar)
• Front left side air bag igniter (on left "b" pillar)
• Hot at all times
• Ignition switch
• Left hand rear side impact sensor (at left rear quarter panel)
• Nca
• Off
• Passenger side air bag igniter (right side of dash)
• Passenger side air bag stage 2 igniter (right side of dash)
• Solid state
• Start

Supplemental Restraints Wiring Diagram (2 of 2) for Volvo S60 T-5 2005

List of elements for Supplemental Restraints Wiring Diagram (2 of 2) for Volvo S60 T-5 2005:

• (on right "b" pillar) right hand front side impact sensor
• 31/67 (below passenger's seat, near kick panel)
• Center rear seat belt tensioner igniter (in top center of rear seat)
• Computer data lines system
• Front right seat belt tensioner igniter (on right "b" pillar)
• Front right side air bag igniter (on right "b" pillar)
• Left hand inflatable curtain igniter (on left "c" pillar)
• Left hand seat belt buckle switch
• Nca
• Rear hand seat belt buckle switch
• Rear right belt tensioner igniter (on right "c" pillar)
• Right hand inflatable curtain igniter (on right "c" pillar)
• Right hand rear side impact sensor (at right rear quarter panel)
• Solid state

TRANSMISSION

Transmission Wiring Diagram, 4T65EV for Volvo S60 T-5 2005

List of elements for Transmission Wiring Diagram, 4T65EV for Volvo S60 T-5 2005:

• (at left rear corner of trunk) rear electronic module (rem)
• (at left side of engine compt, forward of strut tower) engine compartment distribution box
• (at left side of engine compt, on fender)
• (at right side of engine compt, forward of strut tower) engine control module (ecm)
• (at right side of engine compt, forward of strut tower) transmission control module (tcm)
• (under center floor console) gear selector module (gsm)
• (under left
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• A33
• A34
• A35
• A36
• A37
• A38
• A39
• A40
• A41
• A42
• A43
• A44
• A45
• A46
• A47
• A48
• A49
• A50
• A51
• A52
• A53
• A54
• A55
• A56
• A57
• A58
• A59
• A60
• A61
• A62
• A63
• A64
• A65
• A66
• A67
• A68
• A69
• A70
• Automatic transmission
• Automatic transmission program selector
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• Brake control module (bcm) (at left rear of engine compt)
• C13
• C14
• C21
• C22
• C28
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• D23
• D32
• D47
• Differential electronic module (dem)
• Fuse e1 60a
• Fuse e5 50a
• Fuse f21 10a
• Fuse f23 7.5a
• G46 (at rear left seat riser)
• G93 (at left side of engine compt, on fender)
• G94
• Gear selector contacts
• Gear shifting solenoid 1
• Gearshifting solenoid 2
• Hot at all times
• Input speed sensor
• Lock-up solenoid
• Main fuse
• Nc1+
• Nc1-
• Nca
• Oil pressure sensor
• Oil temperature sensor
• Otg
• Output speed sensor (near output shaft of transmission)
• Pressure solenoid
• Ps1
• Ps2
• Ps3
• Ps4
• Rear seat)
• Red
• Shift interlock system
• Sht
• Slhg

Transmission Wiring Diagram, AW55-50 for Volvo S60 T-5 2005

List of elements for Transmission Wiring Diagram, AW55-50 for Volvo S60 T-5 2005:

• (at left rear corner of trunk) rear electronic module (rem)
• (at left rear of engine compt)
• (at right side of engine compt, forward of strut tower) engine control module (ecm)
• (at right side of engine compt, forward of strut tower) transmission control module (tcm)
• (at right side of engine compt, on fender)
• (under center floor console) gear selector module (gsm)
• (under left
• A10
• A11
• A12
• A13
• A14
• A15
• A16
• A17
• A18
• A19
• A20
• A21
• A22
• A23
• A24
• A25
• A26
• A27
• A28
• A29
• A30
• A31
• A32
• A33
• A34
• A35
• A36
• A37
• A38
• A39
• A40
• A41
• A42
• A43
• A44
• A45
• A46
• A47
• A48
• A49
• A50
• A51
• A52
• A53
• A54
• A55
• A56
• A57
• A58
• A59
• A60
• A61
• A62
• A63
• A64
• A65
• A66
• A67
• A68
• A69
• A70
• Automatic transmission
• B10
• B11
• B12
• B13
• B14
• B15
• B16
• B17
• B18
• B19
• B20
• B21
• Brake control module (bcm)
• C13
• C14
• C21
• C22
• C28
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• D23
• D32
• D47
• Differential electronic module (dem)
• Fuse e1 60a
• Fuse e5 50a
• Fuse f21 10a
• Fuse f23 7.5a
• G46 (at rear left seat riser)
• G93 (at left side of engine compt, on fender)
• G94
• Gear selector contacts
• Gear shifting solenoid 1
• Gearshifting solenoid 2
• Hot at all times
• Input speed sensor
• Lock-up solenoid
• Main fuse
• Nc1+
• Nc1-
• Nca
• Oil temperature sensor
• Otg
• Output speed sensor
• Pressure solenoid
• Program selector
• Rear seat)
• Red
• Shift interlock system
• Shift solenoid 3
• Shift solenoid 4
• Shift solenoid 5
• Slgs
• Sls
• Slt
• Sltg
• Slu
• Slug
• Sp+
• Sp-
• St+
• St-
• Throttle solenoid

WARNING SYSTEMS

Warning Systems Wiring Diagram for Volvo S60 T-5 2005

List of elements for Warning Systems Wiring Diagram for Volvo S60 T-5 2005:

• A25
• A26
• Acc
• B23/51
• B24/52
• B25/53
• B26/54
• B27/55
• B28/56
• Brake control module (bcm) (at left rear of engine compt)
• C25/81
• C26/82
• Central electronic module (cem) (behind left side of dash)
• Computer data lines system
• D16
• D34
• D36
• D49
• D51
• D60
• Driver information module (dim) (in instrument cluster)
• G6 (at left kick panel)
• Hot at all times
• Ignition switch
• Key-in ignition switch
• Left front abs sensor (on left hub assembly)
• Left seat belt buckle switch (on seat belt buckle)
• Lock
• Nca
• Off
• Right front abs sensor (on right hub assembly)
• Right seat belt buckle switch (in seat belt latch switch)
• Start
• Steering wheel module (swm) (in steering column)
• Upper electronic module (uem) (above center of windshield, on rearview mirror)

WIPER/WASHER

Front Wiper/Washer Wiring Diagram for Volvo S60 T-5 2005

List of elements for Front Wiper/Washer Wiring Diagram for Volvo S60 T-5 2005:

• (in steering column) steering wheel module
• (not used)
• 87a
• B21
• B29
• B30
• C10
• C31
• Central electronic module (behind left side of dash)
• Computer data lines system
• D11
• D34
• D35
• D49
• D50
• D58
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Fuse 15a
• Fuse b13 25a
• Fuse c6 10a
• Fuse e5 50a
• G1 (at right side of engine compartment, on fender)
• G93 (at left side of engine compartment, on fender)
• G98 (above center of windshield)
• Hot at all times
• Intermittent wiping relay
• Main fuses
• Passenger compartment relay box (behind left side of dash)
• Rain sensor module (if equipped) (forward of inside rearview mirror)
• Red
• Upper electronic module (above center of windshield, on rearview mirror)
• Washer fluid level sensor (on washer fluid tank, at right front of engine compartment)
• Washer motor
• Windshield wiper low/high speed relay
• Windshield wiper motor (at left rear of engine compt)

Headlamp High Pressure Washer Wiring Diagram for Volvo S60 T-5 2005

List of elements for Headlamp High Pressure Washer Wiring Diagram for Volvo S60 T-5 2005:

• 87a
• C10
• C25
• Central electronic module (behind left side of dash)
• Computer data lines system
• D34
• D35
• D49
• D50
• Engine compartment relay/fuse box (at left side of engine compt, forward of strut tower)
• Fuse b15 35a
• G1 (at right side of engine compartment, on fender)
• Headlight high pressure washer motor (bottom of washer reservoir)
• Headlight high pressure washer motor relay
• Hot at all times
• Washer fluid level sensor (on washer fluid tank, at right front of engine compartment)

Headlamp Wiper/Washer Wiring Diagram for Volvo S60 T-5 2005

List of elements for Headlamp Wiper/Washer Wiring Diagram for Volvo S60 T-5 2005:

• (behind left side of dash) central electronic module
• B19
• B21
• B29
• B30
• C10
• Computer data lines system
• D34
• D35
• D49
• D50
• Fuse 15a
• Fuse e4 50a
• Fuse e5 50a
• G1 (at right side of engine compartment, on fender)
• G93 (at left side of engine compt, on fender)
• Hot at all times
• Left headlight wiper motor (under left headlight assemblies)
• Main fuses
• Nca
• Red
• Right headlight wiper motor (under right headlight assemblies)
• Washer fluid level sensor (on washer fluid tank, at right front of engine compartment)
• Washer motor