Chevrolet Aveo 2006 - 2006 GENERAL MOTORS Aveo, Swift+ (Canadian) & Wave (Canadian)

Chevrolet Aveo 2006 - BUZZERS, RELAYS & TIMERS

Chevrolet Aveo 2006 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
A/C Compressor	In underhood fuse block. See Fig. 31.
Blink Relay	In passenger compartment fuse block. See Fig. 1.
Blower Relay	In passenger compartment fuse block. See Fig. 1.
Cooling Fan Control Relay	In underhood fuse block. See Fig. 31.
Cooling Fan Hi	In underhood fuse block. See Fig. 31.
Cooling Fan Low	In underhood fuse block. See Fig. 31.
Defog Relay	In passenger compartment fuse block. See Fig. 1.
Door Lock Relay	In passenger "A" pillar.
Front Fog Light Relay	In underhood fuse block. See Fig. 31.
Fuel Pump Relay	In underhood fuse block. See Fig. 31.
Head Lamp High Relay	In underhood fuse block. See Fig. 31.
Headlamp Low Relay	In underhood fuse block. See Fig. 31.
Horn Relay	Behind left kick panel. See Fig. 21.
Illumination Lamps	In underhood fuse block. See Fig. 31.
Park/Neutral Position (PNP) Relay	In passenger compartment fuse block. See Fig. 1.
Power Window Relay	In underhood fuse block. See Fig. 31.
Rear Fog Relay	In passenger compartment fuse block. See Fig. 1.
Turn Signal/Hazard Flasher	In passenger compartment fuse block. See Fig. 1.
Wiper Relay	In passenger compartment fuse block. See Fig. 1.

Chevrolet Aveo 2006 - CIRCUIT PROTECTION DEVICES

Chevrolet Aveo 2006 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Passenger Compartment Fuse Block	Behind left side of dash. See Fig. 1.
Underhood Fuse Block	Left side of engine compartment.

Chevrolet Aveo 2006 - CONTROL UNITS

Chevrolet Aveo 2006 CONTROL UNITS LOCATION

Component	Location
ABS Warning Lamp Module	Near left shock tower.
Central Door Locking Unit	Bottom of right windshield pillar. See Fig. 4.
Chime Module	Under left side of dash.
DRL	Behind dash, right of center console. See Fig. 5.
Electronic Brake Control Module (EBCM) & Brake Pressure Modulator Valve (BPMV)	Left engine compartment. See Fig. 28.
Engine Control Module (ECM)	Left front fender, near the battery. See Fig. 16.
Ignition Coil (IC) Module	Top of valve cover. See Fig. 16.
Ignition Lock Module	In passenger compartment fuse block. See Fig. 1.
Inflatable Restraint Sensing & Diagnostic Module (SDM)	Below center console. See Fig. 29.
Lamp Control Module	Behind driver side knee bolster.
Multifunction Alarm Module	Under dash, right of steering column. See Fig. 22.
Remote Control Door Lock Receiver (RCDLR)	Under floor console. See Fig. 19.
Sunroof Module	In roof panel. See Fig. 30.
TCM	On driver's side of vehicle, above brake pedal assembly. See Fig. 2.
Theft Deterrent Control Module	Near the ignition switch. See Fig. 19.
Transmission Control Module (TCM) Harness Connector	On transmission control module. See Fig. 2.

Chevrolet Aveo 2006 - MOTORS

Chevrolet Aveo 2006 MOTORS LOCATION

Component	Location
Blower Motor	Behind right side of dash. See Fig. 9.
Cooling Fan (Dual)	Behind radiator. See Fig. 15.
Cooling Fan Motor (Aux)	Behind right side of radiator. See Fig. 3.
Cooling Fan Motor (Main)	Behind left side of radiator. See Fig. 3.
Cooling Fan (Single)	Behind radiator. See Fig. 14.
Headlamp Leveling Motor	On headlamp.
Idle Air Control Valve (IAC)	In throttle body housing.
Intake Actuator	Near blower motor. See Fig. 5.
Outside Rearview Mirror Motor	On outside of door. See Fig. 24.
Power Window Motor	In each door. See Fig. 6.
Starter	Lower left of engine. See Fig. 18.
Sunroof Motor	Front of roof. See Fig. 30.
Windshield/Washer Fluid Pump (Front)	Left side of engine compartment. See Fig. 27.
Windshield/Washer Fluid Pump (Rear)	Left side of engine compartment. See Fig. 27.
Windshield Wiper Motor	In cowl at base of windshield. See Fig. 27.
Wiper Motor (Rear)	On rear hatch. See Fig. 27.

Chevrolet Aveo 2006 - SENDING UNITS & SENSORS

Chevrolet Aveo 2006 SENDING UNITS & SENSORS LOCATION

Component	Location
A/C Refrigerant Pressure Sensor	On high pressure refrigerant line. See Fig. 7.
Camshaft Position (CMP) Sensor	Top front of engine, near the camshaft gear. See Fig. 12.
Crankshaft Position (CKP) Sensor	On left front of engine, below the oil filter. See Fig. 12.
Engine Coolant Temperature (ECT) Sensor	Rear of engine cylinder head, below intake manifold. See Fig. 11.
Evaporator Temperature Sensor	In HVAC module, near evaporator.
Front Wheel Speed Sensor - Right & Left	On the inside of the front wheel. See Fig. 28.
Fuel Pump/Sender Assembly	In fuel tank. See Fig. 13.
Fuel Tank Pressure Sensor	In fuel tank. See Fig. 13.
Heated Oxygen Sensor (HO2S) 1	At left side of engine, on exhaust manifold. See Fig. 11.
Heated Oxygen Sensor (HO2S) 2	Downstream of catalytic converter. See Fig. 11.
Inflatable Restraint Front End Sensor	At vehicle front end. See Fig. 29.
Inflatable Restraint Side Impact Sensor	Near base of "B" pillar. See Fig. 29.
Input Speed Sensor (ISS) Connector	On top of transmission. See Fig. 2.
Intake Air Temperature (IAT) Sensor	On air intake hose, between air filter & throttle body. See Fig. 16.
Knock Sensor (KS)	On right side of cylinder block. See Fig. 17.
Manifold Absolute Pressure (MAP) Sensor	Left rear of engine. See Fig. 12.
Occupant Classification (OC) Sensor	Under right front seat. See Fig. 29.
Output Shaft Speed (OSS) Sensor Connector	On output speed sensor. See Fig. 2.
Output Shaft Speed (OSS) Sensor (Vehicle Speed Sensor (VSS))	On transmission. See Fig. 2.
Rear Wheel Speed Sensor - Right & Left	On the inside of the rear wheel. See Fig. 28.
Rough Road Sensor	Left rear of engine, on frame rail. See Fig. 12.
Throttle Position (TP) Sensor	On throttle body assembly. See Fig. 17.

Chevrolet Aveo 2006 - SOLENOIDS & SOLENOID VALVES

Chevrolet Aveo 2006 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
A/C Compressor Clutch	Lower right front of engine. See Fig. 7.
BTSI Solenoid	Near selector lever. See Fig. 5.
Door Actuator-Front	In rear of left front door. See Fig. 6.
Door Actuator-Rear	In rear of left rear door. See Fig. 6.
EVAP Canister Purge Solenoid Valve	On intake manifold. See Fig. 11.
Evaporative Emission (EVAP) Canister Vent Solenoid Valve	Behind right rear wheel. See Fig. 13.
Exhaust Gas Recirculation (EGR) Valve	On top rear of engine. See Fig. 17.
Fuel Injector 1	Top right of engine. See Fig. 16.
Fuel Injector 2	Top right of engine. See Fig. 16.
Fuel Injector 3	Top right of engine. See Fig. 16.
Fuel Injector 4	Top right of engine. See Fig. 16.
Intake Manifold Tuning Valve Solenoid	Underhood, behind center of engine. See Fig. 11.
Lock-Up Solenoid Valve	In transmission valve body. See Fig. 8.
No. 1 Solenoid Valve	In transmission valve body. See Fig. 8.
No. 2 Solenoid Valve	In transmission valve body. See Fig. 8.
Pressure Control Solenoid Valve	In transmission valve body. See Fig. 8.
Recirculation Actuator	Under dash at right side of HVAC unit. See Fig. 9.
Starter Solenoid Assembly	On starter motor. See Fig. 26.
Timing Solenoid Valve	In transmission valve body. See Fig. 8.

Chevrolet Aveo 2006 - SWITCHES

Chevrolet Aveo 2006 SWITCHES LOCATION

Component	Location
Brake Fluid Level Switch	On brake fluid reservoir.
Clutch Start Switch	On the clutch pedal, near the pivot.
Door Ajar Switch (Left Front)	On left "B" pillar. See Fig. 4.
Door Ajar Switch (Left Rear)	On left "C" pillar. See Fig. 4.
Door Ajar Switch (Right Front)	Right "B" pillar. See Fig. 4.
Door Ajar Switch (Right Rear)	Right "C" pillar. See Fig. 4.
Hood Ajar Switch	Left side of radiator support. See Fig. 19.
Ignition Key Alarm Switch	On ignition switch. See Fig. 22.
Key Remind Switch	Near steering column. See Fig. 5.
Lock Cylinder Switch - Rear Compartment Lid	On rear compartment lid lock cylinder. See Fig. 23.
Manual Transmission Back Up Lamp Switch	On top, side of transmission.
Octane Selection Switch	Left rear of engine. See Fig. 12.
Oil Pressure Switch	Front of engine, on oil pump housing. See Fig. 11.
Parking Brake Switch	On park brake handle. See Fig. 25.
Park/Neutral Position (PNP) Switch	On side of transaxle. See Fig. 2.
Park Position Switch	On transmission select lever, in center console.
Seat Belt Switch	In driver seat belt buckle.
Stop Lamp Switch	On brake pedal assembly. See Fig. 10.
Tamper Switch	Near license plate lamp. See Fig. 32.
Trunk Lid Ajar Switch	Rear of trunk lid. See Fig. 32.

Chevrolet Aveo 2006 - MISCELLANEOUS

Chevrolet Aveo 2006 MISCELLANEOUS LOCATION

Component	Location
Blower Motor Resistor	Behind right side of dash. See Fig. 9.
Cooling Fan Resistor	On radiator, near G102.
Diode (Fog)	In underhood fuse block. See Fig. 31.
DLC	Below left side of dash, right of steering column. See Fig. 5.
Generator	Right rear of engine. See Fig. 18.
Horn	Right side, behind grill. See Fig. 20.
Inflatable Restraint I/P Module	Right side of dash. See Fig. 29.
Inflatable Restraint Side Impact Module	In the outer side of each front seat back. See Fig. 29.
Inflatable Restraint Steering Wheel Module	Center of steering wheel. See Fig. 29.
Inflatable Restraint Steering Wheel Module Coil	Under driver air bag module. See Fig. 29.
Roof Antenna Cable	Left kick panel. See Fig. 4.
Seat Belt Pretensioner - Left	In left "B" pillar.
Seat Belt Pretensioner - Right	In right "B" pillar.
Theft Deterrent Alarm	Left side of engine compartment. See Fig. 23.

Chevrolet Aveo 2006 - CONNECTORS

Chevrolet Aveo 2006 CONNECTORS LOCATION

Component	Location
C101 (Black, 4 Pin)	Behind coolant reservoir.
C102 (White, 20 Pin)	On underhood fuse block.
C113 (Black, 3 Pin)	At parklamp assembly.
C114 (Black, 3 Pin)	At parklamp assembly.
C201 (Blue, 18 Pin)	Behind passenger compartment fuse block.
C202 (White, 11 Pin)	Behind the passenger compartment fuse block.
C203 (Black, 14 Pin)	Behind passenger compartment fuse block.
C204 (White, 4 Pin)	Behind passenger compartment fuse block.
C205 (Gray, 18 Pin)	Behind passenger compartment fuse block.
C210 (Green, 8 Pin)	Left kick panel. See Fig. 4.
C211 (Yellow, 22 Pin)	Left kick panel. See Fig. 4.
C212 (Black, 10 Pin)	Left kick panel. See Fig. 4.
C213 (White, 15 Pin)	Left kick panel. See Fig. 4.
C214 (White, 4 Pin)	Near HVAC controls. See Fig. 5.
C351 (29 Pin)	Front of left front door. See Fig. 4.
C361 (29 Pin)	Front of right front door. See Fig. 4.
C371 (White, 6 Pin)	In left "B" pillar. See Fig. 4.
C381 (White, 6 Pin)	Right "B" pillar. See Fig. 4.
C401 (White, 8 Pin)	Near left "C" pillar. See Fig. 4.
C402 (Hatchback) (Clear, 4 pin)	Underside of trunk lid.
C402 (Notchback) (White, 4 Pin)	Underside of trunk lid. See Fig. 32.
C403 (White, 2 Pin)	Under left side of trunk lid.
C404 (White, 2 Pin)	Above trunk lid latch.
C415 (White, 6 Pin)	Rear harness to left taillamp jumper.
C416 (White, 6 Pin)	Rear harness to right taillamp jumper.
C417 (Black, 2 Pin)	Behind left side of rear fascia.

Chevrolet Aveo 2006 - GROUNDS

Chevrolet Aveo 2006 GROUNDS LOCATION

Component	Location
ECM/ABS Harness Ground	On rear of engine.
G101	Under ECM.
G102	Behind left headlamp, left of battery.
G103	On starter mounting bolt.
G104	Behind right headlamp, under air cleaner.
G105	On engine block, near starter motor.
G201	Behind left side of ashtray.
G202	Behind right side of ashtray.
G301	Behind right side kick panel.
G401	On left side of rear compartment panel.
G402 - Hatchback	On right side of rear compartment panel.
G402 - Notchback	In rear compartment, near deck lid striker.

Chevrolet Aveo 2006 - SPLICES

Chevrolet Aveo 2006 SPLICES LOCATION

Component	Location
SP101 Splice Pack	In underhood fuse block.
SP201 Splice Pack	Behind passenger compartment fuse block.
SP202 Splice Pack	In I/P harness, behind left tie bar.
SP205 Splice Pack	In cowl, left of brake booster.
S102	In engine harness.
S103	In engine harness.
S104	In engine harness.
S105	In engine harness.
S106	In engine harness.
S107	In engine harness.
S108	In engine harness.
S109	In engine harness.
S110	In engine harness.
S111	In engine harness.
S112	In engine harness.
S113	In engine harness.
S114	In engine harness.
S115	In engine harness.
S116	In engine harness.
S117	In engine harness.
S118	In front harness.
S119	In front harness.
S120	In front harness near cooling fan resistor.
S121	In front harness, near horn breakout.
S122	In front harness.
S123	In front harness.
S124	In front harness.
S203	In I/P harness, near stoplamp switch.
S204	In I/P harness, near instrument cluster.
S205	In I/P harness, near radio.
S206	In I/P harness, near instrument cluster.
S207	In I/P harness.
S208	In I/P harness, near radio.
S209	In I/P harness, near stoplamp switch.
S210	In I/P harness.
S211	In I/P harness, near instrument cluster.
S212	In I/P harness, near instrument cluster.
S213	In I/P harness, near radio.
S219	In TCM harness.
S220	In TCM harness, near C202.
S301	In body harness, near left "B" pillar.
S302	In body harness, near left "B" pillar.
S303	In body harness, near left "C" pillar.
S304	In body harness, near left "C" pillar.
S305	In body harness, near power outlet.
S306	In body harness, near power outlet.
S307	In body harness, near power outlet.
S308	In body harness, near power outlet.
S309	In body harness.
S310	In body harness.
S311	In body harness, near left "B" pillar.
S400	In trunk harness, near C401.
S401	In rear harness.
S402	In rear harness.
S403	In rear harness.
S404	In rear harness.
S501	In left front door.
S520	In left front door.
S900	In trunk harness, near C401.
S901	In trunk extension harness, near license plate lamp breakout.
S902	In body harness.