Chevrolet Aveo 2007 - 2007 GENERAL MOTORS Aveo, Swift+ (Canadian) & Wave (Canadian)

Chevrolet Aveo 2007 - BUZZERS, RELAYS & TIMERS

Chevrolet Aveo 2007 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
A/C CMPRSR Relay	In underhood fuse block. See Fig. 31.
A/C RELAY	In underhood fuse block. See Fig. 36.
Blink Relay	In I/P fuse block. See Fig. 1.
Blower Relay	In I/P fuse block. See Fig. 1.
COOL FAN CNTRL Relay	In underhood fuse block. See Fig. 31.
COOL FAN HI Relay	In underhood fuse block. See Fig. 31.
COOL FAN LOW Relay	In underhood fuse block. See Fig. 31.
Defog Relay	In I/P fuse block. See Fig. 1.
Door Lock Relay	In right "A" pillar. See Fig. 4.
FAN HI RELAY	In underhood fuse block. See Fig. 36.
FAN LOW RELAY	In underhood fuse block. See Fig. 36.
FRT FOG Relay (Hatchback)	In underhood fuse block. See Fig. 31.
FRT FOG RELAY (Notchback)	In underhood fuse block. See Fig. 36.
FUEL PUMP Relay (Hatchback)	In underhood fuse block. See Fig. 31.
FUEL PUMP RELAY (Notchback)	In underhood fuse block. See Fig. 36.
HEAD LAMPS HI Relay	In underhood fuse block. See Fig. 31.
HEAD LAMPS LOW Relay	In underhood fuse block. See Fig. 31.
H/L HI RELAY	In underhood fuse block. See Fig. 36.
H/L LOW RELAY	In underhood fuse block. See Fig. 36.
Horn Relay	Behind left kick panel. See Fig. 21.
ILLUM LAMPS Relay	In underhood fuse block. See Fig. 31.
MAIN RELAY	In underhood fuse block. See Fig. 36.
PARK LAMP RELAY	In underhood fuse block. See Fig. 36.
Park/Neutral Position (PNP) Relay	In I/P fuse block. See Fig. 1.
P/WINDOW RELAY	In underhood fuse block. See Fig. 36.
PWR WNDW Relay	In underhood fuse block. See Fig. 31.
Rear Fog Relay	In I/P fuse block. See Fig. 1.
Turn Signal/Hazard Flasher	In I/P fuse block. See Fig. 1.
Wiper Relay	In I/P fuse block. See Fig. 1.

Chevrolet Aveo 2007 - CIRCUIT PROTECTION DEVICES

Chevrolet Aveo 2007 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Fuse Block - I/P	In left side of dash, in door opening. See Fig. 1.
Underhood Fuse Block	Left side of engine compartment.

Chevrolet Aveo 2007 - CONTROL UNITS

Chevrolet Aveo 2007 CONTROL UNITS LOCATION

Component	Location
DRL	Behind dash, right of center console. See Fig. 5.
Electronic Brake Control Module (EBCM)	Left side of engine compartment. See Fig. 28.
Engine Control Module (ECM)	Left front fender, near the battery. See Fig. 16.
Ignition Coil (IC) Module	Top of valve cover. See Fig. 16.
Ignition Lock Module	In I/P fuse block. See Fig. 1.
Inflatable Restraint Sensing & Diagnostic Module (SDM)	Below center console. See Fig. 29.
Lamp Driver Module	Lower left rear of engine compartment. See Fig. 35.
Multifunction Alarm Module	Under dash, right of steering column. See Fig. 22.
Remote Control Door Lock Receiver (RCDLR)	Under left side of dash. See Fig. 34.
Sunroof Module	In roof panel. See Fig. 30.
TCM	On driver's side of vehicle, above brake pedal assembly. See Fig. 2.
Theft Deterrent Control Module	Near the ignition switch. See Fig. 19.
Transmission Control Module (TCM) Harness Connector	On transmission control module. See Fig. 2.

Chevrolet Aveo 2007 - MOTORS

Chevrolet Aveo 2007 MOTORS LOCATION

Component	Location
Blower Motor	Behind right side of dash. See Fig. 9.
Cooling Fan (Dual)	Behind radiator. See Fig. 15.
Cooling Fan Motor (Aux)	Behind right side of radiator. See Fig. 3.
Cooling Fan Motor (Main)	Behind left side of radiator. See Fig. 3.
Cooling Fan (Single)	Behind radiator. See Fig. 14.
Door Latch - Front (Left/Right)	In rear of respective front door. See Fig. 24.
Door Latch - Rear (Left/Right)	In rear of respective rear door. See Fig. 24.
Fuel Pump/Sender Assembly	In fuel tank. See Fig. 13.
Intake Actuator	Near blower motor. See Fig. 5.
Outside Rearview Mirror Motor (Left/Right)	In respective outside rearview mirror. See Fig. 24.
Starter	Lower left of engine. See Fig. 18.
Sunroof Motor	Front of roof. See Fig. 30.
Window Motor - Front (Left/Right)	In front door. See Fig. 24.
Window Motor - Rear (Left/Right)	In rear door. See Fig. 24.
Windshield/Washer Fluid Pump - Front	In washer fluid reservoir. See Fig. 27.
Windshield/Washer Fluid Pump - Rear	In washer fluid reservoir. See Fig. 27.
Windshield Wiper Motor	In cowl at base of windshield. See Fig. 27.
Wiper Motor - Rear	On rear hatch. See Fig. 27.

Chevrolet Aveo 2007 - SENDING UNITS & SENSORS

Chevrolet Aveo 2007 SENDING UNITS & SENSORS LOCATION

Component	Location
A/C Refrigerant Pressure Sensor	On high pressure refrigerant line. See Fig. 7.
Brake Fluid Sensor	On brake master cylinder assembly. See Fig. 35.
Camshaft Position (CMP) Sensor	Top front of engine, near the camshaft gear. See Fig. 12.
Crankshaft Position (CKP) Sensor	On left rear of engine, below the oil filter. See Fig. 12.
Engine Coolant Temperature (ECT) Sensor	Rear of engine cylinder head, below intake manifold. See Fig. 11.
Front Wheel Speed Sensor - Right & Left	Integral to respective front wheel hub assembly. See Fig. 28.
Fuel Pump/Sender Assembly	In fuel tank. See Fig. 13.
Fuel Tank Pressure Sensor	In fuel tank. See Fig. 13.
Heated Oxygen Sensor (HO2S) 1	At left side of engine, on exhaust manifold. See Fig. 11.
Heated Oxygen Sensor (HO2S) 2	Downstream of catalytic converter. See Fig. 11.
Inflatable Restraint Front End Sensor (Left/Right)	At vehicle front end. See Fig. 29.
Inflatable Restraint Side Impact Sensor (Left/Right)	Near base of respective "B" pillar. See Fig. 29.
Input Speed Sensor (ISS) Connector	On top of transmission. See Fig. 2.
Intake Air Temperature (IAT) Sensor	On air intake hose, between air filter & throttle body. See Fig. 16.
Knock Sensor (KS)	On right side of cylinder block. See Fig. 17.
Manifold Absolute Pressure (MAP) Sensor	Right rear of engine. See Fig. 12.
Occupant Classification (OC) Sensor	Under right front seat. See Fig. 29.
Output Shaft Speed (OSS) Sensor Connector	On output speed sensor. See Fig. 2.
Output Shaft Speed (OSS) Sensor (Vehicle Speed Sensor (VSS))	On transmission. See Fig. 2.
Rear Wheel Speed Sensor - Right & Left	Integral to respective rear wheel hub assembly. See Fig. 28.
Rough Road Sensor	Left rear of engine, on frame rail. See Fig. 12.
Throttle Position (TP) Sensor	On throttle body assembly. See Fig. 17.
Vehicle Speed Sensor (VSS)	Left rear of engine. See Fig. 17.

Chevrolet Aveo 2007 - SOLENOIDS & SOLENOID VALVES

Chevrolet Aveo 2007 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
A/C Compressor Clutch	Lower right front of engine. See Fig. 7.
Brake Pressure Modulator Valve (BPMV)	Left side of engine compartment. See Fig. 28.
BTSI Solenoid	In center console, near shift selector. See Fig. 5.
Door Actuator - Front (Left/Right)	Rear of respective front door. See Fig. 6.
Door Actuator - Rear (Left/Right)	Rear of respective rear door. See Fig. 6.
EVAP Canister Purge Solenoid Valve	On intake manifold. See Fig. 11.
EVAP Canister Vent Solenoid Valve	Behind right rear wheel. See Fig. 13.
Exhaust Gas Recirculation (EGR) Valve	On top rear of engine. See Fig. 17.
Fuel Injector 1	Top right of engine. See Fig. 16.
Fuel Injector 2	Top right of engine. See Fig. 16.
Fuel Injector 3	Top right of engine. See Fig. 16.
Fuel Injector 4	Top right of engine. See Fig. 16.
Idle Air Control (IAC) Valve	Right rear of engine compartment. See Fig. 17.
Intake Manifold Tuning Valve Solenoid	Right rear of engine. See Fig. 11.
Lock-Up Solenoid Valve	In transmission valve body. See Fig. 8.
No. 1 Solenoid Valve	In transmission valve body. See Fig. 8.
No. 2 Solenoid Valve	In transmission valve body. See Fig. 8.
Pressure Control Solenoid Valve	In transmission valve body. See Fig. 8.
Recirculation Actuator	Under dash at right side of HVAC unit. See Fig. 9.
Starter Solenoid Assembly	On starter motor. See Fig. 26.
Timing Solenoid Valve	In transmission valve body. See Fig. 8.

Chevrolet Aveo 2007 - SWITCHES

Chevrolet Aveo 2007 SWITCHES LOCATION

Component	Location
Brake Fluid Level Switch	On brake fluid reservoir. See Fig. 10.
Door Jamb Switch (Front Left/Right)	In respective "B" pillar. See Fig. 24.
Door Jamb Switch (Rear Left/Right)	In respective "C" pillar. See Fig. 24.
Front Door AJAR Switch (Left)	On left "B" pillar. See Fig. 4.
Front Door AJAR Switch (Right)	Right "B" pillar. See Fig. 4.
Hood Ajar Switch	Left side of radiator support. See Fig. 19.
Horn Switch	In steering wheel. See Fig. 22.
Ignition Key Alarm Switch	On ignition switch. See Fig. 22.
Key Remind Switch	Near steering column. See Fig. 5.
Lock Cylinder Switch - Rear Compartment Lid	On rear compartment lid lock cylinder. See Fig. 23.
Octane Selection Switch	Right rear of engine. See Fig. 12.
Oil Pressure Switch	Front of engine, on oil pump housing. See Fig. 11.
Park Brake Switch	On park brake handle. See Fig. 25.
Park/Neutral Position (PNP) Switch	On side of transaxle. See Fig. 2.
Rear Door AJAR Switch (Left)	On left "C" pillar. See Fig. 4.
Rear Door AJAR Switch (Right)	Right "C" pillar. See Fig. 4.
Seat Belt Switch - Left	In driver seat belt buckle. See Fig. 33.
Stop Lamp Switch	On brake pedal assembly. See Fig. 10.
Tamper Switch	Near license plate light. See Fig. 32.
Trunk Lid AJAR Switch	Rear of trunk lid. See Fig. 32.

Chevrolet Aveo 2007 - MISCELLANEOUS

Chevrolet Aveo 2007 MISCELLANEOUS LOCATION

Component	Location
Battery	Left side of engine compartment. See Fig. 12.
Blower Motor Resistor	Behind right side of dash. See Fig. 9.
Contact Coil	Under left side of dash. See Fig. 5.
Diode (Fog)	In underhood fuse block. See Fig. 31.
DLC	Below left side of dash, right of steering column. See Fig. 5.
Generator	Right rear of engine. See Fig. 18.
Horn	Right side, behind grill. See Fig. 20.
Inflatable Restraint I/P Module	Right side of dash. See Fig. 29.
Inflatable Restraint Side Impact Module (Left/Right)	In the outer side of each front seat back. See Fig. 29.
Inflatable Restraint Steering Wheel Module	Center of steering wheel. See Fig. 29.
Inflatable Restraint Steering Wheel Module Coil	Under driver air bag module. See Fig. 29.
Roof Antenna Cable	Left kick panel. See Fig. 4.
Seat Belt Pretensioner - Left	In left "B" pillar. See Fig. 33.
Seat Belt Pretensioner - Right	In right "B" pillar. See Fig. 33.
Theft Deterrent Alarm	Left side of engine compartment. See Fig. 23.

Chevrolet Aveo 2007 - CONNECTORS

Chevrolet Aveo 2007 CONNECTORS LOCATION

Component	Location
C101 (Black, 4 Pin)	Behind coolant reservoir.
C102 (White, 20 Pin)	On underhood fuse block.
C104 (White, 15 Pin)	On underhood fuse block.
C105 (White, 3 Pin)	Near EBCM.
C113 (Black, 3 Pin)	At parklight assembly.
C114 (Black, 3 Pin)	At parklight assembly.
C201 (Blue, 18 Pin)	Behind I/P fuse block. See Fig. 5.
C202 (White, 11 Pin)	Behind I/P fuse block. See Fig. 5.
C203 (Black, 14 Pin)	Behind I/P fuse block. See Fig. 5.
C204 (Hatchback) (White, 4 Pin)	Behind I/P fuse block. See Fig. 5.
C204 (Notchback) (White, 18 Pin)	Behind I/P fuse block. See Fig. 5.
C205 (Gray, 36 Pin)	Behind I/P fuse block. See Fig. 5.
C206 (Black, 10 Pin)	Below transmission control module.
C207 (White, 12 Pin)	Below I/P fuse block.
C208 (White, 20 Pin)	Forward of transmission control module.
C209 (White, 4 Pin)	Forward of transmission control module.
C210 (Hatchback) (Blue, 8 Pin)	Behind left kick panel. See Fig. 4.
C210 (Notchback) (White, 10 Pin)	Behind left kick panel. See Fig. 4.
C211 (Yellow, 22 Pin)	Behind left kick panel. See Fig. 4.
C212 (Hatchback) (Black, 10 Pin)	Behind left kick panel. See Fig. 4.
C212 (Notchback) (Blue, 11 Pin)	Behind left kick panel. See Fig. 4.
C213 (Hatchback) (White, 15 Pin)	Behind left kick panel. See Fig. 4.
C213 (Notchback) (White, 20 Pin)	Behind left kick panel. See Fig. 4.
C214 (Hatchback) (Yellow, 10 Pin)	Behind left kick panel. See Fig. 5.
C214 (Notchback) (Black, 22 Pin)	Behind left kick panel. See Fig. 5.
C215 (Gray, 36 Pin)	Behind HVAC housing.
C216 (White, 12 Pin)	Behind HVAC housing.
C217 (White, 16 Pin)	Under blower motor.
C219 (Blue, 8 Pin)	Below I/P fuse block.
C351 (White, 29 Pin)	Behind left kick panel. See Fig. 4.
C361 (White, 29 Pin)	Behind right kick panel. See Fig. 4.
C371 (White, 6 Pin)	Left "B" pillar. See Fig. 4.
C381 (White, 6 Pin)	Right "B" pillar. See Fig. 4.
C401 (White, 8 Pin)	Near left "C" pillar. See Fig. 4.
C402 (Hatchback) (White, 4 Pin)	Underside of trunk lid. See Fig. 32.
C402 (Notchback) (White, 6 Pin)	Below left side of package tray.
C403 (White, 3 Pin)	Under left side of trunk lid.
C404 (White, 2 Pin)	Above trunk lid latch.
C415 (White, 6 Pin)	Rear harness to left taillight jumper.
C416 (White, 6 Pin)	Rear harness to right taillight jumper.
C417 (Black, 2 Pin)	Behind left side of rear fascia.

Chevrolet Aveo 2007 - GROUNDS

Chevrolet Aveo 2007 GROUNDS LOCATION

Component	Location
ECM/ABS Harness Ground	On rear of engine.
G101	Under ECM.
G102	Behind left headlight, left of battery.
G103	On starter mounting bolt.
G104	Behind right headlight, under air cleaner.
G105	On engine block, near starter motor.
G201	Behind left side of ashtray.
G202	Behind right side of ashtray.
G301	Behind right kick panel.
G401	On left side of rear compartment panel.
G402 (Hatchback)	On right side of rear compartment panel.
G402 (Notchback)	In rear compartment, near deck lid striker.

Chevrolet Aveo 2007 - SPLICES

Chevrolet Aveo 2007 SPLICES LOCATION

Component	Location
SP101 Splice Pack	In underhood fuse block.
SP201 Splice Pack	Behind I/P fuse block.
SP202 Splice Pack	In I/P harness, behind left tie bar.
SP205 Splice Pack	In cowl, left of brake booster.
S102	In engine harness.
S103	In engine harness.
S104	In engine harness.
S105	In engine harness.
S106	In engine harness.
S107	In engine harness.
S108	In engine harness.
S109	In engine harness.
S110	In engine harness.
S111	In engine harness.
S112	In engine harness.
S113	In engine harness.
S114	In engine harness.
S115	In engine harness.
S116	In engine harness.
S117	In engine harness.
S118	In front harness.
S119	In front harness.
S120	In front harness, near cooling fan resistor.
S121	In front harness, near horn breakout.
S122	In front harness.
S123	In front harness.
S124	In front harness.
S126	In engine harness.
S203	In I/P harness, near stop light switch.
S204	In I/P harness, near instrument cluster.
S205	In I/P harness, near radio.
S206	In I/P harness, near instrument cluster.
S207	In I/P harness.
S208	In I/P harness, near radio.
S209	In I/P harness, near stop light switch.
S210	In I/P harness.
S211	In I/P harness, near instrument cluster.
S212	In I/P harness, near instrument cluster.
S213	In I/P harness, near radio.
S214	In I/P harness.
S219	In TCM harness.
S220	In TCM harness, near C202.
S301	In body harness, near left "B" pillar.
S302	In body harness, near left "B" pillar.
S303	In body harness, near left "C" pillar.
S304	In body harness, near left "C" pillar.
S305	In body harness, near power outlet.
S306	In body harness, near power outlet.
S307	In body harness, near power outlet.
S308	In body harness, near power outlet.
S309	In body harness.
S310	In body harness.
S311	In body harness, near left "B" pillar.
S400	In tailgate harness, near C401.
S401	In rear harness.
S402	In rear harness.
S403	In rear harness.
S404	In rear harness.
S501	In left front door.
S520	In left front door.
S900	In tailgate harness, near C401.
S901	In tailgate extension harness, near license plate light breakout.
S902	In body harness.