Chevrolet Cavalier RS 1998 - 1998 GENERAL MOTORS Cavalier & Sunfire

Chevrolet Cavalier RS 1998 - BUZZERS, RELAYS & TIMERS

Chevrolet Cavalier RS 1998 BUZZERS, RELAYS & TIMERS

Component	Component Location
ABS Relay	In engine compartment fuse/relay center.
A/C Compressor Control Relay (2.2L VIN 4)	In engine compartment fuse/relay center. See Fig. 1 .
A/C Compressor Control Relay (2.4L VIN T)	In engine compartment fuse/relay center. See Fig. 2 .
Blower Motor Relay	In engine compartment fuse/relay center.
Coolant Fan Relay (2.2L VIN 4)	In engine compartment fuse/relay center. See Fig. 1 .
Coolant Fan Relay (2.4L VIN T)	In engine compartment fuse/relay center. See Fig. 2 .
Daytime Running Lamps (DRL) Relay	In fuse block.
Door Lock Relay	Behind right kick panel.
Electronic Brake Control (ABS) Relay	In engine compartment fuse/relay center.
Fog Lamp Cut-Off Relay	On front impact bar.
Fog Lamp Relay	On front impact bar.
Folding Top Relay	Left of rear seat.
Fuel Pump Relay (2.2L VIN 4)	In engine compartment fuse/relay center. See Fig. 1 .
Fuel Pump Relay (2.4L VIN T)	In engine compartment fuse/relay center. See Fig. 2 .
Horn Relay	On convenience center.
Turn/Hazard Flasher	On brake pedal bracket.

Chevrolet Cavalier RS 1998 - CIRCUIT PROTECTION DEVICES

Chevrolet Cavalier RS 1998 CIRCUIT PROTECTION DEVICES

Component	Component Location
Convenience Center	Right side of dash, behind glove box.
Engine Compartment Fuse/Relay Center (2.2L VIN 4)	Left front of engine compartment. See Fig. 1 .
Engine Compartment Fuse/Relay Center (2.4L VIN T)	Left front of engine compartment. See Fig. 2 .
Fuse Block (2.2L VIN 4)	Behind lower left side of dash. See Fig. 1 .
Fuse Block (2.4L VIN T)	Behind lower left side of dash. See Fig. 2 .
Fusible Link	At starter solenoid.

Chevrolet Cavalier RS 1998 - CONTROL UNITS

Chevrolet Cavalier RS 1998 CONTROL UNITS

Component	Component Location
Cruise Control Module (2.2L VIN 4)	In right rear corner of engine compartment. See Fig. 1 .
Cruise Control Module (2.4L VIN T)	In right rear corner of engine compartment. See Fig. 2 .
Electronic Brake Control Module	Behind lower left side of dash, near fuse block.
Fuel Tank Module	Under rear of passenger compartment.
Ignition Control Module (2.2L VIN 4)	On top rear of engine. See Fig. 1 .
Ignition Control Module (2.4L VIN T)	On top left of engine. See Fig. 2 .
Lamp Dimmer Module	Behind dash, on left side of steering column bracket.
Multi-Function Alarm Module	On convenience center.
Powertrain Control Module (PCM) (2.2L VIN 4)	Behind right side of front fascia, on impact bar. See Fig. 1 .
Powertrain Control Module (PCM) (2.4L VIN T)	Behind right side of front fascia, on impact bar. See Fig. 2 .
Remote Control Door Lock Receiver	In left front of luggage compartment.
Sensing & Diagnostic Module (SDM)	Below right front seat.

Chevrolet Cavalier RS 1998 - MOTORS

Chevrolet Cavalier RS 1998 MOTORS

Component	Component Location
ABS Actuator Motor Assembly	Below master cylinder.
Blower Motor	Under center of dash, in HVAC assembly.
Cooling Fan Motor	In center front of engine compartment.
Folding Top Motor (Right/Left)	In respective side of rear compartment.
Washer Pump	Left front of engine compartment, in washer reservoir.
Wiper Motor Assembly	On left side of firewall.

Chevrolet Cavalier RS 1998 - SENDING UNITS & SENSORS

Chevrolet Cavalier RS 1998 SENDING UNITS & SENSORS

Component	Component Location
A/C Refrigerant Pressure Sensor (2.2L VIN 4)	In right front corner of engine compartment, on refrigerant line. See Fig. 1 .
A/C Refrigerant Pressure Sensor (2.4L VIN T)	In right front corner of engine compartment, on refrigerant line. See Fig. 2 .
Auxiliary Discriminating Sensor	On front of hood latch support bracket.
Camshaft Position (CMP) Sensor (2.2L VIN 4)	On right side of engine, near oil filter. See Fig. 1 .
Camshaft Position (CMP) Sensor (2.4L VIN T)	On top left side of engine. See Fig. 2 .
Crankshaft Position (CKP) Sensor (2.2L VIN 4)	On right side of engine, near oil filter. See Fig. 1 .
Crankshaft Position (CKP) Sensor (2.4L VIN T)	On left front side of engine, above oil filter. See Fig. 2 .
Engine Coolant Temperature (ECT) Sensor (2.2L VIN 4)	On left front of engine. See Fig. 1 .
Engine Coolant Temperature (ECT) Sensor (2.4L VIN T)	On rear of engine, near coolant outlet. See Fig. 2 .
Engine Oil Pressure Sensor (2.2L VIN 4)	Near oil filter. See Fig. 1 .
Engine Oil Pressure Sensor (2.4L VIN T)	On top rear of engine. See Fig. 2 .
Fuel Tank Pressure Sensor (2.2L VIN 4)	On top of fuel tank. See Fig. 1 .
Fuel Tank Pressure Sensor (2.4L VIN T)	On top of fuel tank. See Fig. 2 .
Heated Oxygen Sensor (HO2S) (Post-Converter) (2.2L VIN 4)	Rearward of catalytic converter. See Fig. 1 .
Heated Oxygen Sensor (HO2S) (Post-Converter) (2.4L VIN T)	Rearward of catalytic converter. See Fig. 2 .
Intake Air Temperature (IAT) Sensor (2.2L VIN 4)	On air cleaner outlet duct assembly. See Fig. 1 .
Intake Air Temperature (IAT) Sensor (2.4L VIN T)	On air cleaner outlet duct assembly. See Fig. 2 .
Knock Sensor (2.2L VIN 4)	On right rear side of engine block. See Fig. 1 .
Knock Sensor (2.4L VIN T)	On right rear side of engine block. See Fig. 2 .
Manifold Absolute Pressure (MAP) Sensor (2.2L VIN 4)	Mounted on side of throttle body. See Fig. 1 .
Manifold Absolute Pressure (MAP) Sensor (2.4L VIN T)	Mounted on side of throttle body. See Fig. 2 .
Oxygen Sensor (O2S) (Pre- Converter) (2.2L VIN 4)	On exhaust manifold. See Fig. 1 .
Oxygen Sensor (O2S) (Pre- Converter) (2.4L VIN T)	On exhaust manifold. See Fig. 2 .
Throttle Position (TP) Sensor (2.2L VIN 4)	On throttle body assembly. See Fig. 1 .
Throttle Position (TP) Sensor (2.4L VIN T)	On throttle body assembly. See Fig. 2 .
Vehicle Speed Sensor (VSS) (A/T) (2.2L VIN 4)	On rear of transaxle. See Fig. 1 .
Vehicle Speed Sensor (VSS) (M/T) (2.2L VIN 4)	On top right front of transaxle. See Fig. 1 .
Vehicle Speed Sensor (VSS) (A/T) (2.4L VIN T)	On rear of transaxle. See Fig. 2 .
Vehicle Speed Sensor (VSS) (M/T) (2.4L VIN T)	On top right front of transaxle.
Wheel Speed Sensors (4)	On each wheel hub assembly.

Chevrolet Cavalier RS 1998 - SOLENOIDS & SOLENOID VALVES

Chevrolet Cavalier RS 1998 SOLENOIDS & SOLENOID VALVES

Component	Component Location
ABS Solenoids (2)	On brake master cylinder.
Brake Transaxle Shift Interlock (BTSI) Solenoid	Behind dash, on steering column.
Evaporative Canister Vent Solenoid (2.2L VIN 4)	On right front of engine compartment, behind fascia. See Fig. 1 .
Evaporative Canister Vent Solenoid (2.4L VIN T)	On right front of engine compartment, behind fascia. See Fig. 2 .
Evaporative Emission Canister Purge Valve (2.2L VIN 4)	On top left front of engine. See Fig. 1 .
Evaporative Emission Canister Purge Valve (2.4L VIN T)	On left front of engine, near generator. See Fig. 2 .
Exhaust Gas Recirculation (EGR) Valve (2.2L VIN 4)	On top rear of engine. See Fig. 1 .
Exhaust Gas Recirculation (EGR) Valve (2.4L VIN T)	On left rear of engine. See Fig. 2 .
Fuel Injector (2.2L VIN 4)	On top of engine. See Fig. 1 .
Fuel Injector (2.4L VIN T)	On top of engine. See Fig. 2 .
Idle Air Control (IAC) Valve (2.2L VIN 4)	On throttle body assembly. See Fig. 1 .
Idle Air Control (IAC) Valve (2.4L VIN T)	On throttle body assembly. See Fig. 2 .
Luggage Compartment Lid Release Solenoid	On rear deck lid.
Torque Converter Clutch (TCC) Solenoid (2.2L VIN 4)	In transaxle valve body. See Fig. 1 .
Torque Converter Clutch (TCC) Solenoid (2.4L VIN T)	In transaxle valve body. See Fig. 2 .

Chevrolet Cavalier RS 1998 - SWITCHES

Chevrolet Cavalier RS 1998 SWITCHES

Component	Component Location
Back-Up Lamps Switch (M/T)	On top of transaxle.
Brake Fluid Level Switch	In brake fluid reservoir.
Brake Switch	On brake pedal support bracket.
Clutch Pedal/Position Switch	On clutch pedal support bracket.
Cruise Control Brake Switch	On brake pedal support bracket.
Cruise Control Clutch Switch	On clutch pedal support bracket.
Engine Coolant Level Switch (2.2L VIN 4)	On right side of engine compartment, in surge tank. See Fig. 1 .
Engine Coolant Level Switch (2.4L VIN T)	On right side of engine compartment, in surge tank. See Fig. 2 .
Folding Top Bypass Switch	In left side of rear compartment.
Park Brake Switch	In console, at base of parking brake lever.
Seat Belt Switch	In driver seat belt assembly.
Transaxle Range Switch (2.2L VIN 4)	On top of transaxle. See Fig. 1 .
Transaxle Range Switch (2.4L VIN T)	On top of transaxle. See Fig. 2 .

Chevrolet Cavalier RS 1998 - MISCELLANEOUS

Chevrolet Cavalier RS 1998 MISCELLANEOUS

Component	Component Location
A/C Compressor Clutch Diode	In A/C compressor clutch connector breakout.
Blower Resistor	Under center of dash, in HVAC assembly.
Convenience Center	On top of right kick panel.
Data Link Connector (DLC) (2.2L VIN 4)	Below left side of dash. See Fig. 1 .
Data Link Connector (DLC) (2.4L VIN T)	Below left side of dash. See Fig. 2 .
Generator (2.2L VIN 4)	Left front of engine. See Fig. 1 .
Generator (2.4L VIN T)	Left front of engine. See Fig. 2 .
Program Connector	On left front of luggage compartment.

Chevrolet Cavalier RS 1998 - CONNECTORS

Chevrolet Cavalier RS 1998 CONNECTORS

Component	Component Location
C100 (Black/Gray, 38 Pin)	At left side of engine compartment.
C101 (Black, 15 Pin)	At left front of engine compartment.
C118 (Natural, 5 Pin)	On left side of engine.
C200 (Black, 23 Pin)	Behind left end of dash.
C201 (Black, 8 Pin)	Behind left center of dash.
C202 (Black, 6 Pin)	Behind left end of dash.
C204 (Black, 8 Pin)	Behind right side of dash.
C205 (Black, 4 Pin)	Behind center of dash.
C206 (Yellow, 2 Pin)	At lower dash tie bar.
C207 (Yellow, 2 Pin)	At lower dash tie bar.
C220 (Green, 6 Pin)	Behind left end of dash.
C275 (Black/Natural, 14 Pin)	Behind center of dash.
C313 (Green/Gray, 16 Pin)	Under center of rear seat.

Chevrolet Cavalier RS 1998 - GROUNDS

Chevrolet Cavalier RS 1998 GROUNDS

Component	Component Location
G102	At left front of engine compartment.
G103	At left front of engine compartment.
G105	At left front of engine compartment.
G110	On rear of engine.
G112	On rear of engine.
G203	Behind upper left side of dash.
G204	Behind upper left side of dash.
G301	On inside of rear compartment lid.
G302	Below right front seat, on frame rail.
G303	Below right front seat.
G304	Below left front seat, on frame rail.

Chevrolet Cavalier RS 1998 - SPLICES

Chevrolet Cavalier RS 1998 SPLICES

Component	Component Location
S101 (2.2L VIN 4)	In engine harness, at left side of engine, 33 cm from coolant fan connector.
S101 (2.4L VIN T)	In engine harness, at left side of engine, 28 cm from coolant fan connector.
S102	In engine harness, at left rear of engine, 16 cm from engine compartment fuse/relay center.
S107	In engine harness, at left rear of engine, 34 cm from engine compartment fuse/relay center breakout.
S110	In engine harness, at left front of engine, 20 cm from A/C compressor clutch connector.
S111	In engine harness, at left front of engine, 20 cm from A/C compressor clutch connector.
S115	In forward light harness, 50 cm from C101.
S117	In forward light harness, 44 cm from C101.
S118	In forward light harness, 29 cm from C101.
S119	In forward light harness, 33 cm from horn.
S121 (2.2L VIN 4)	In engine harness, at left rear of engine, 27 cm from C100.
S121 (2.4L VIN T)	In engine harness, at left rear of engine, 32 cm from C100.
S122	In forward light harness, 52.5 cm from horn.
S124	In HVAC wiring harness, 78 cm from C204.
S125	In HVAC wiring harness, 85 cm from C205.
S151	In forward light harness, 12.5 cm from C101.
S152	In forward light harness, 12.5 cm from C101.
S153	In forward light harness, 95.5 cm from C101.
S154	In forward light harness, 95.5 cm from C101.
S165	In fuel injector harness, 29.5 cm from C118.
S171 (2.2L VIN 4)	In engine harness, 54.5 cm from C100.
S171 (2.4L VIN T)	In engine harness, 54.5 cm from C101.
S200	In dash harness, 41.5 cm from firewall grommet.
S201	In dash harness, 35 cm from firewall grommet.
S202	In dash harness, 30 cm from firewall grommet, toward column switches.
S203	In dash harness, 29 cm from electronic brake control module.
S204	In dash harness, 28.5 cm from firewall grommet.
S205	In dash harness, 51 cm from firewall grommet, toward instrument cluster connectors.
S206	In dash harness, 21.5 cm from firewall grommet, toward instrument cluster connectors.
S207	In dash harness, 22 cm from firewall grommet.
S209	In dash harness, 71 cm from firewall grommet, toward data link connector.
S210	In dash harness, 4 cm from firewall grommet, toward electronic brake control module connector No. 2.
S211	In radio harness, 26 cm from C205.
S212	In body harness, 105 cm from left front door grommet.
S213	In dash harness, 64.5 cm from firewall grommet, toward data link connector.
S214	In dash harness, 18 cm from electronic brake control module connector No. 2.
S215	In dash harness, 85 cm from firewall grommet, toward sensing diagnostic module connector.
S216	In dash harness, 15 cm from P210, toward instrument cluster connectors.
S217	In dash harness, 43 cm from P210, toward instrument cluster connectors.
S218	In dash harness, 65.5 cm from firewall grommet, toward passenger inflator module connector.
S219	In dash harness, 30 cm from firewall grommet, toward instrument cluster connectors.
S220	In dash harness, 36.5 cm from firewall grommet, toward instrument cluster connectors.
S221	In dash harness, 59 cm from firewall grommet, toward passenger inflator module connector.
S222	In dash harness, 47.5 cm from I/P compartment light connector.
S223	In radio harness, 20 cm from C205.
S224	In dash harness, 72 cm from firewall grommet, toward passenger inflator module connector.
S225	In dash harness, 15.5 cm from firewall grommet.
S226	In radio harness, 32.5 cm from C205.
S227 (Convertible)	In body harness, 117 cm from left front door grommet.
S227 (Coupe & Sedan)	In body harness, 95 cm from left front door grommet.
S231	In light dimmer harness, 16 cm from C201.
S232	In light dimmer harness, 19 cm from panel dimmer switch connector.
S233	In HVAC harness, 93 cm from C204.
S240	In forward light harness, 36.5 cm from C101.
S241	In forward light harness, 32.5 cm from C102.
S242	In dash harness, 84 cm from firewall grommet, toward data link connector.
S243	In forward light harness, 35.5 cm from C101.
S244	In forward light harness, 56.5 from C101.
S246	In dash harness, 25.5 cm from firewall grommet, toward column switches.
S248 (Convertible)	In body harness, 38 cm from left front door grommet.
S248 (Coupe & Sedan)	In body harness, 62 cm from right front door grommet.
S277	In dash harness, 77.5 cm from firewall grommet, toward data link connector.
S280	In HVAC harness, 58 cm from C204.
S281	In HVAC harness, 98.5 cm from C204.
S300 (Convertible)	In body harness, 102 cm from right front door grommet.
S300 (Coupe)	In body harness, 93 cm from right front door grommet.
S301 (Convertible)	In body harness, 50 cm from seat belt switch connector, toward right side of vehicle.
S301 (Coupe & Sedan)	In body harness, 41.5 cm from seat belt switch connector, toward left side of vehicle.
S302	In body harness, 257 cm from left front door grommet.
S303 (Convertible)	In body harness, 45 cm from left front door grommet.
S303 (Coupe)	In body harness, 70 cm from right front door grommet.
S303 (Sedan)	In body harness, 47 cm from park brake switch, toward right side of vehicle.
S304	In body harness, 137 cm from left front door grommet.
S305 (Convertible)	In body harness, 108.5 cm from seat belt switch connector, toward left side of vehicle.
S305 (Coupe)	In body harness, 102 cm from seat belt switch connector, toward left front of vehicle.
S305 (Sedan)	In body harness, 41.5 cm from seat belt switch connector, toward right side of vehicle.
S306	In body harness, 69 cm from seat belt switch connector, toward right side of vehicle.
S307	In body harness, 47 cm from left front door grommet.
S330	In body harness, 143 cm from tail/stoplight connector.
S331 (Convertible)	In body harness, 122.5 cm from right front door grommet.
S331 (Coupe & Sedan)	In body harness, 113 cm from right front door grommet.
S332	In body harness, 147 cm from left front door grommet.
S350	In headliner harness, 105 cm from dome light connector.
S351	In headliner harness, 46 cm from dome light connector.
S352	In headliner harness, 56 cm from dome light connector.
S353	In headliner harness, 36 cm from dome light connector.
S371	In body harness, 21 cm from folding top motor connector.
S372	In body harness, 30 cm from folding top switch connector.
S400 (Convertible)	In body harness, 59 cm from right back-up light connector.
S400 (Coupe & Sedan)	In body harness, 86 cm from left tail/stoplight connector.