Chevrolet Malibu LS 1997 - 1997 GENERAL MOTORS Cutlass & Malibu

Chevrolet Malibu LS 1997 - BUZZERS, RELAYS & TIMERS

Chevrolet Malibu LS 1997 BUZZERS, RELAYS & TIMERS

Component	Component Location
A/C Compressor Clutch Relay	On underhood bussed electrical center.
Automatic Lamp Control Relay	On underhood bussed electrical center.
Blower Motor Relay	On underhood bussed electrical center.
Daytime Running Lamps (DRL) Relay	On underhood bussed electrical center.
Door Lock Relay	On left dash bussed electrical center.
Door Unlock Relay	On left dash bussed electrical center.
Electronic Brake Control (ABS) Relay	On underhood bussed electrical center.
Fan Control Relay No. 1	On underhood bussed electrical center.
Fan Control Relay No. 2	On underhood bussed electrical center.
Fog Lamps Relay	On right dash bussed electrical center.
Fuel Pump Relay	On underhood bussed electrical center.
Horn Relay	On underhood bussed electrical center.
Mode Control Relay	On underhood bussed electrical center.
Park Lamp Relay	On underhood bussed electrical center.
Rear Compartment Lid Release Relay	On left dash bussed electrical center.
Rear Defogger Relay	On underhood bussed electrical center.

Chevrolet Malibu LS 1997 - CIRCUIT PROTECTION DEVICES

Chevrolet Malibu LS 1997 CIRCUIT PROTECTION DEVICES

Component	Component Location
Fusible Link (2.4L)	On lower front of engine. See Fig. 1 .
Fusible Link (3.1L)	On front of engine. See Fig. 4 .
Left Dash Bussed Electrical Center (Left Dash BEC)	On left side of dash. See Fig. 8 .
Right Dash Bussed Electrical Center (Right Dash BEC)	On right side of dash. See Fig. 7 .
Underhood Bussed Electrical Center (U/H BEC)	On left side of engine compartment.

Chevrolet Malibu LS 1997 - CONTROL UNITS

Chevrolet Malibu LS 1997 CONTROL UNITS

Component	Component Location
Body Function Controller	Below right side of dash. See Fig. 7 .
Cruise Control Module	On right side of engine compartment.
Driver Inflator Module	On top of steering column.
Electronic Brake Control Module (EBCM)	Inside left front fender.
Fuel Tank Module	Under rear of vehicle.
Ignition Control Module (2.4L)	On top left of engine. See Fig. 3 .
Ignition Control Module (3.1L)	On top rear of engine. See Fig. 5 .
Lamp Dimmer Module	On left side of dash.
Passenger Inflator Module	On right upper dash.
Powertrain Control Module (PCM)	Below left side of dash, near steering column.
Remote Control Door Lock Receiver	On rear package shelf.
Sensing Diagnostic Module (SDM)	Under right front seat.

Chevrolet Malibu LS 1997 - MOTORS

Chevrolet Malibu LS 1997 MOTORS

Component	Component Location
ABS Actuator Motor Assembly	On left front of engine compartment.
Air Temperature Actuator	On top right side of dash.
Blower Motor	Below right side of dash. See Fig. 7 .
Cooling Fan Motor (2)	On front of engine compartment.
Forward-Back Motor	Under left front seat.
Front Height Motor	Under left front seat.
Rear Compartment Lid Release Motor	On rear compartment lid.
Rear Height Motor	Under left front seat.
Starter Motor (2.4L)	On lower front of engine. See Fig. 1 .
Starter Motor (3.1L)	On lower front of engine. See Fig. 4 .
Sun Roof Assembly	On headliner.
Washer Motor	Between washer solvent reservoir & frame rail.
Wiper Motor Assembly	On rear of engine compartment.

Chevrolet Malibu LS 1997 - SENDING UNITS & SENSORS

Chevrolet Malibu LS 1997 SENDING UNITS & SENSORS

Component	Component Location
7X Crankshaft Position (CKP) Sensor (3.1L)	On lower rear of engine.
24X Crankshaft Position (CKP) Sensor (3.1L)	On lower front of engine.
A/C Refrigerant Pressure Sensor	On front of engine compartment.
Ambient Lamp Sensor	On top of dash trim pad.
Camshaft Position (CMP) Sensor (2.4L)	On top front of engine. See Fig. 2 .
Camshaft Position (CMP) Sensor (3.1L)	On top rear of engine.
Crankshaft Position (CKP) Sensor (2.4L)	On lower front of engine. See Fig. 1 .
Engine Coolant Temperature (ECT) Sensor (2.4L)	On top left of engine. See Fig. 3 .
Engine Coolant Temperature (ECT) Sensor (3.1L)	On top rear of engine.
Engine Oil Pressure Sensor (2.4L)	On top left of engine. See Fig. 3 .
Engine Oil Pressure Sensor (3.1L)	On front of engine. See Fig. 4 .
Fuel Tank Pressure Sensor	Under rear of vehicle.
Intake Air Temperature (IAT) Sensor (2.4L)	On left side of engine compartment.
Intake Air Temperature (IAT) Sensor (3.1L)	On top left side of engine. See Fig. 6 .
Knock Sensor (2.4L)	On top left of engine. See Fig. 3 .
Knock Sensor (3.1L)	On front of engine. See Fig. 4 .
Manifold Absolute Pressure (MAP) Sensor (2.4L)	On top front of engine. See Fig. 2 .
Manifold Absolute Pressure (MAP) Sensor (3.1L)	On top rear of engine.
Mass Air Flow (MAF) Sensor (3.1L)	On top left side of engine. See Fig. 6 .
Passlock Cylinder	On left side of dash.
Post Converter Heated Oxygen Sensor (HO2S 2) (3.1L)	At center of passenger compartment, under vehicle.
Pre-Converter Heated Oxygen Sensor (HO2S 1) (3.1L)	On top rear of engine. See Fig. 5 .
Pre-Converter Oxygen Sensor (O2S) (2.4L)	On top left of engine. See Fig. 3 .
Throttle Position Sensor (TPS) (2.4L)	On top front of engine. See Fig. 2 .
Throttle Position Sensor (TPS) (3.1L)	On top left side of engine. See Fig. 6 .
Vehicle Speed Sensor (VSS)	On rear of engine/transaxle.
Washer Solvent Level Sensor	Inside of left front fender.
Wheel Speed Sensors (4)	On respective wheel hub.

Chevrolet Malibu LS 1997 - SOLENOIDS & SOLENOID VALVES

Chevrolet Malibu LS 1997 SOLENOIDS & SOLENOID VALVES

Component	Component Location
Brake Transaxle Shift Interlock (BTSI) Solenoid	Under center console.
Evaporative Emission (EVAP) Canister Purge Valve (2.4L)	On lower front of engine. See Fig. 1 .
Evaporative Emission (EVAP) Canister Purge Valve (3.1L)	On top rear of engine. See Fig. 5 .
Evaporative Emission (EVAP) Canister Vent Solenoid	Under rear of vehicle.
Exhaust Gas Recirculation (EGR) Valve (2.4L)	On top front of engine. See Fig. 2 .
Exhaust Gas Recirculation (EGR) Valve (3.1L)	On top rear of engine. See Fig. 5 .
Fuel Injectors (2.4L)	On top front of engine. See Fig. 2 .
Fuel Injectors (3.1L)	On top rear of engine.
Idle Air Control (IAC) Valve (2.4L)	On top front of engine. See Fig. 2 .
Idle Air Control (IAC) Valve (3.1L)	On top left side of engine. See Fig. 6 .
Left Front ABS Solenoid	On left front corner of engine compartment.
Right Front ABS Solenoid	On right front corner of engine compartment.
Starter Solenoid (2.4L)	On lower front of engine. See Fig. 1 .
Starter Solenoid (3.1L)	On lower front of engine. See Fig. 4 .

Chevrolet Malibu LS 1997 - SWITCHES

Chevrolet Malibu LS 1997 SWITCHES

Component	Component Location
Brake Fluid Level Switch	On rear of engine compartment.
Brake Switch	On upper brake pedal support.
Cruise Control Brake Switch	On upper brake pedal support.
Cruise Control Switch	On steering column.
Engine Coolant Level Switch	On right side of engine compartment.
Engine Oil Level Switch (3.1L)	On rear of engine.
Glove Box Lamp/Switch	On top right side of dash.
Hazard Switch	On center of dash.
Park Brake Switch	On left side of passenger compartment.
Power Sun Roof Switch	On headliner.
Rear Compartment Lid Release Switch	Below left side of dash. See Fig. 8 .
Seat Belt Switch	On left side of passenger compartment.
Transaxle Range Switch	On left side of engine.

Chevrolet Malibu LS 1997 - MISCELLANEOUS

Chevrolet Malibu LS 1997 MISCELLANEOUS

Component	Component Location
A/C Compressor Clutch (2.4L)	On lower front of engine. See Fig. 1 .
A/C Compressor Clutch (3.1L)	On front of engine. See Fig. 4 .
A/C Compressor Clutch Diode	In underhood bussed electrical center.
Auxiliary Power Outlet	On top right side of dash.
Battery	On left side of engine compartment.
Blower Resistor Assembly	Below right side of dash. See Fig. 7 .
Data Link Connector (DLC)	Below left side of dash. See Fig. 8 .
Driver's Safing Connector	On left end of dash.
DRL Resistor	On rear of front impact bar.
Generator (2.4L)	On lower front of engine. See Fig. 1 .
Generator (3.1L)	On lower front of engine.
Horn Assembly	Inside right front fender.
Passenger Safing Connector	On right end of dash. See Fig. 7 .
Program Connector	On right side of rear compartment.
SIR Coil Assembly	On top of steering column.
Transaxle Indicator Lamp	Under center console.

Chevrolet Malibu LS 1997 - CONNECTORS

Chevrolet Malibu LS 1997 CONNECTORS

Component	Component Location
C101 (Black, 10 Pin)	On left side of engine compartment.
C102 (Gray, 20 Pin)	On left side of engine.
C120 (Gray, 2 Pin)	On top rear of engine.
C130 (Black, 10 Pin)	On top rear of engine.
C200 (Black, 18 Pin)	Below left side of dash, near steering column.
C300 (Natural, 10 Pin)	Below left side of dash, near steering column.
C301 (Black, 3 Pin)	In headliner.
C306 (Black, 2 Pin)	In left side of passenger compartment.
C400 (Black, 8 Pin)	In left rear of passenger compartment.
C413 (Gray, 16 Pin)	Under rear of vehicle.
C500 (Gray, 18 Pin)	In left front corner of passenger compartment.
C501 (Gray, 18 Pin)	In left front corner of passenger compartment.
C600 (Gray, 18 Pin)	In right front corner of passenger compartment.
C700 (Black, 7 Pin)	In left side of passenger compartment.
C800 (Black, 7 Pin)	In right side of passenger compartment.

Chevrolet Malibu LS 1997 - GROUNDS

Chevrolet Malibu LS 1997 GROUNDS

Component	Component Location
G101	On left side of engine compartment.
G102	On front of engine.
G103	On left side of engine.
G104	On left side of engine compartment.
G105	On left side of engine compartment.
G201	On left side of dash.
G202	On left side of dash.
G203	On right side of dash.
G204	On right side of dash.
G301	On left side of passenger compartment.
G302	On right side of passenger compartment.
G401	On left side of passenger compartment, on rear package shelf.
G402	On right side of passenger compartment, on rear package shelf.

Chevrolet Malibu LS 1997 - SPLICES

Chevrolet Malibu LS 1997 SPLICES

Component	Component Location
S101	In injector harness, approximately 16 cm from C130.
S102	In engine harness, approximately 15 cm from P100.
S103	In engine harness, approximately 15 cm from P100.
S104	In engine harness, approximately 15 cm from P100.
S105	In engine harness, approximately 15 cm from P100.
S301	Under right front seat.