Chevrolet Malibu LS 2007 - 2007 GENERAL MOTORS Malibu

Chevrolet Malibu LS 2007 - BUZZERS, RELAYS & TIMERS

Chevrolet Malibu LS 2007 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
A/C CLUTCH Relay	On underhood fuse block. See Fig. 4.
BACK UP LP Relay	On rear fuse block. See Fig. 5.
COOL FAN SER/PAR Relay	On underhood fuse block. See Fig. 4.
COOL FAN 1 Relay	On underhood fuse block. See Fig. 4.
COOL FAN 2 Relay	On underhood fuse block. See Fig. 4.
FRT FOG Relay	On underhood fuse block. See Fig. 4.
FUEL Relay	On rear fuse block. See Fig. 5.
HIGH BEAM Relay	On underhood fuse block. See Fig. 4.
HORN Relay	On underhood fuse block. See Fig. 4.
LOW BEAM Relay	On underhood fuse block. See Fig. 4.
PARK LPS Relay	On rear fuse block. See Fig. 5.
POWERTRAIN Relay	On underhood fuse block. See Fig. 4.
RR DEFOG Relay	On rear fuse block. See Fig. 5.
RUN/CRANK Relay	On underhood fuse block. See Fig. 4.
STARTER Relay	On underhood fuse block. See Fig. 4.
TRUNK Relay	On rear fuse block. See Fig. 5.
WIPER 1 Relay	On underhood fuse block. See Fig. 4.
WIPER 2 Relay	On underhood fuse block. See Fig. 4.

Chevrolet Malibu LS 2007 - CIRCUIT PROTECTION DEVICES

Chevrolet Malibu LS 2007 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Rear Fuse Block (Extended Sedan)	Left rear of passenger compartment. See Fig. 37.
Rear Fuse Block (Sedan)	Left rear quarterpanel. See Fig. 3.
Underhood Fuse Block	On left side of engine compartment. See Fig. 1.

Chevrolet Malibu LS 2007 - CONTROL UNITS

Chevrolet Malibu LS 2007 CONTROL UNITS LOCATION

Component	Location
Blower Motor Control Module (C68)	Right side of dash, on rear of HVAC case. See Fig. 11.
Body Control Module (BCM)	Under front of center console. See Fig. 42.
Electronic Brake Control Module (EBCM)	Inside left front fender. See Fig. 1.
Engine Control Module (ECM)	Left side of engine compartment, forward of battery.
Heated Seat Control Module	Under driver's seat. See Fig. 79.
HVAC Control Module	Center of dash. See Fig. 42.
Ignition Control Module (ICM) (2.2L)	Top of engine.
Ignition Control Module (ICM) (3.5L)	On top right side of engine. See Fig. 81.
Ignition Control Module (ICM) (3.9L)	On right side of engine. See Fig. 75.
Inflatable Restraint I/P Module	Above glove box. See Fig. 33.
Inflatable Restraint Roof Rail Module (Left) (Extended Sedan)	Above headliner, over both left doors. See Fig. 37.
Inflatable Restraint Roof Rail Module (Left) (Sedan)	Above headliner, over both left doors. See Fig. 36.
Inflatable Restraint Roof Rail Module (Right) (Extended Sedan)	Above headliner, over both right doors. See Fig. 39.
Inflatable Restraint Roof Rail Module (Right) (Sedan)	Above headliner, over both right doors. See Fig. 38.
Inflatable Restraint Sensing & Diagnostic Module (SDM)	Under center console, under carpet. See Fig. 35.
Inflatable Restraint Steering Wheel Module	Center of steering wheel.
Power Steering Control Module	Left of steering column. See Fig. 14.
Powertrain Control Module (PCM)	Front of battery. See Fig. 1.
Radio Antenna Amplifier Module (Sedan)	Above rear glass, under left side of headliner. See Fig. 44.
Remote Control Door Lock Receiver (RCDLR) (Extended Sedan)	On left "C" pillar. See Fig. 37.
Remote Control Door Lock Receiver (RCDLR) (Sedan)	On rear package shelf. See Fig. 46.
Roof Rail Air Bag (Left)	Above left side of headliner. See Fig. 41.
Roof Rail Air Bag (Right)	Above right side of headliner. See Fig. 40.
Sunroof Control Module	Rear of sunroof. See Fig. 52.
Theft Deterrent Module	Attached to ignition key cylinder housing. See Fig. 47.
Throttle Actuator Control (TAC) Module (2.2L)	On upper intake manifold. See Fig. 23.
Throttle Actuator Control (TAC) Module (3.5L)	On upper intake manifold.
Throttle Actuator Control (TAC) Module (3.9L)	On throttle body. See Fig. 73.
Transmission Control Module (TCM)	Left rear of engine compartment, near strut tower.

Chevrolet Malibu LS 2007 - MOTORS

Chevrolet Malibu LS 2007 MOTORS LOCATION

Component	Location
Air Temperature Actuator	On top right side of dash. See Fig. 9.
Blower Motor	Below right side of dash. See Fig. 11.
Cooling Fan-Left	On front of engine compartment. See Fig. 19.
Cooling Fan-Right	On front of engine compartment. See Fig. 19.
Fuel Pump & Sender Assembly	Under rear of vehicle, in fuel tank. See Fig. 29.
Mode Actuator	On left side of HVAC case. See Fig. 10.
Rear Compartment Lid Latch (Extended Sedan)	On rear compartment lid. See Fig. 49.
Rear Compartment Lid Latch (Sedan)	Center of rear compartment lid. See Fig. 48.
Recirculation Actuator	On right side of HVAC case. See Fig. 12.
Seat Front Vertical Motor	Under driver's seat, on frame. See Fig. 79.
Seat Horizontal Motor	Under driver's seat, on frame. See Fig. 79.
Seat Rear Vertical Motor	Under driver's seat, on frame. See Fig. 79.
Starter (2.2L)	On lower right side of engine. See Fig. 20.
Starter (3.5L)	On lower left side of engine. See Fig. 21.
Starter (3.9L)	On lower left side of engine. See Fig. 73.
Window Motor-LR	Left rear door. See Fig. 43.
Windshield Washer Fluid Pump	Left front wheelwell, bottom of reservoir. See Fig. 50.
Windshield Wiper Motor	On left rear of engine compartment. See Fig. 53.

Chevrolet Malibu LS 2007 - SENDING UNITS & SENSORS

Chevrolet Malibu LS 2007 SENDING UNITS & SENSORS LOCATION

Component	Location
Accelerator Pedal Position (APP) Sensor	Attached to accelerator pedal. See Fig. 9.
A/C Refrigerant Pressure Sensor	Left of right front strut tower. See Fig. 8.
Adjustable Pedals Position Sensor	Above brake pedal. See Fig. 51.
Air Duct Temperature Sensor-Upper (C68)	On upper duct, above accelerator pedal. See Fig. 9.
Ambient Air Temperature Sensor	Behind grille, on left side of front impact bar. See Fig. 13.
Ambient Light Sensor (C60)	On top of dash trim pad. See Fig. 2.
Ambient Light/Sunload Sensor (C68)	On top of dash trim pad. See Fig. 2.
Automatic Transmission Input Shaft Speed (A/T ISS) Sensor (4T65-E)	In automatic transmission. See Fig. 78.
Brake Pedal Position Sensor	On brake pedal support. See Fig. 51.
Camshaft Position (CMP) Sensor (3.5L)	On front of engine. See Fig. 59.
Camshaft Position (CMP) Sensor (3.9L)	On top front of engine. See Fig. 73.
Crankshaft Position (CKP) Sensor (2.2L)	On rear left side of engine. See Fig. 77.
Crankshaft Position (CKP) Sensor (3.5L)	On lower right side of engine. See Fig. 81.
Crankshaft Position (CKP) Sensor (3.9L)	In lower left side of engine. See Fig. 75.
Engine Coolant Temperature (ECT) Sensor (2.2L)	On top rear of engine. See Fig. 25.
Engine Coolant Temperature (ECT) Sensor (3.5L)	On right cylinder head, above transmission. See Fig. 81.
Engine Coolant Temperature (ECT) Sensor (3.9L)	In rear of left cylinder head. See Fig. 75.
Engine Oil Level Sensor (3.5L)	Bottom of engine oil pan. See Fig. 81.
Engine Oil Level Sensor (3.9L)	In bottom of oil pan. See Fig. 75.
Engine Oil Pressure (EOP) Sensor (3.9L)	On lower left side of engine. See Fig. 73.
Front End Sensor (Left)	Left front of engine compartment. See Fig. 41.
Front End Sensor (Right)	Right front of engine compartment. See Fig. 40.
Fuel Pump & Sender Assembly	Under rear of vehicle, in fuel tank. See Fig. 29.
Fuel Tank Pressure (FTP) Sensor	Under rear of vehicle. See Fig. 29.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 1 (3.5L)	Center of rear exhaust manifold. See Fig. 81.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 1 (3.9L)	In left exhaust manifold. See Fig. 73.
Heated Oxygen Sensor (HO2S) Bank 1 Sensor 2 (3.5L & 3.9L)	After catalytic converter. See Fig. 74.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 1 (3.5L)	On exhaust manifold.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 1 (3.9L)	In right exhaust manifold. See Fig. 75.
Heated Oxygen Sensor (HO2S) Bank 2 Sensor 2 (3.5L & 3.9L)	After catalytic converter. See Fig. 74.
Heated Oxygen Sensor (HO2S) Sensor 1 (2.2L)	Between exhaust manifold & catalytic converter. See Fig. 26.
Heated Oxygen Sensor (HO2S) Sensor 2 (2.2L)	At rear of catalytic converter. See Fig. 26.
Inflatable Restraint Front End Sensor-Left	Left front of engine compartment. See Fig. 32.
Inflatable Restraint Front End Sensor-Right	Right front of engine compartment. See Fig. 32.
Inflatable Restraint Side Impact Sensor-Left (Right Similar)	Behind door panel. See Fig. 34.
Input Speed Sensor (4T40/4T45-E)	In transmission valve body. See Fig. 31.
Knock Sensor (KS) 1 (3.9L)	On left side of engine. See Fig. 73.
Knock Sensor (KS) (2.2L)	Left side of engine, near oil dipstick.
Knock Sensor (KS) 2 (3.5L)	On left side of engine. See Fig. 21.
Knock Sensor (KS) 2 (3.9L)	On right side of engine. See Fig. 75.
Knock Sensor 1 (3.5L)	On lower left right of engine. See Fig. 81.
Manifold Absolute Pressure (MAP) Sensor (2.2L)	Front of engine, at cylinder 3 intake port. See Fig. 23.
Manifold Absolute Pressure (MAP) Sensor (3.9L)	On top of intake manifold. See Fig. 75.
MAP Sensor (3.5L)	In upper intake manifold. See Fig. 81.
Mass Air Flow (MAF)/ Intake Air Temperature (IAT) Sensor (3.9L)	In intake air duct. See Fig. 76.
Mass Air Flow (MAF) Sensor (W/ Intake Air Temperature (IAT) Sensor) (3.5L)	In intake air duct. See Fig. 24.
Output Speed Sensor (4T40/4T45-E)	On transmission output shaft. See Fig. 31.
Transmission Fluid Temperature (TFT) Sensor (4T65-E)	In automatic transmission. See Fig. 78.
Vehicle Speed Sensor (VSS) (4T65-E)	On transmission. See Fig. 78.
Wheel Speed Sensor LF	Inside wheel hub. See Fig. 17.
Wheel Speed Sensor LR	Inside wheel hub. See Fig. 17.
Wheel Speed Sensor RF	Inside wheel hub. See Fig. 17.
Wheel Speed Sensor RR	Inside wheel hub. See Fig. 17.

Chevrolet Malibu LS 2007 - SOLENOIDS & SOLENOID VALVES

Chevrolet Malibu LS 2007 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
A/C Compressor Clutch (2.2L)	Lower right front of engine. See Fig. 6.
A/C Compressor Clutch (3.5L & 3.9L)	Lower right front of engine. See Fig. 7.
Automatic Transmission Shift Lock Control Solenoid	Below center console shifter. See Fig. 30.
Camshaft Position (CMP) Actuator Solenoid (3.9L)	On front of engine. See Fig. 73.
Evaporative Emission (EVAP) Canister Purge Solenoid (2.2L)	Top rear of engine.
Evaporative Emission (EVAP) Canister Purge Solenoid (3.5L)	Rear of engine, near throttle body.
Evaporative Emission (EVAP) Canister Purge Solenoid (3.9L)	On top rear of engine. See Fig. 73.
Evaporative Emission (EVAP) Canister Vent Solenoid (Extended Sedan)	Under rear of vehicle, above fuel tank. See Fig. 28.
Fuel Injector 1 (2.2L)	Left side of engine. See Fig. 23.
Fuel Injector 2 (2.2L)	Left side of engine. See Fig. 23.
Fuel Injector 3 (2.2L)	Left side of engine. See Fig. 23.
Fuel Injector 4 (2.2L)	Left side of engine. See Fig. 23.
Intake Manifold Tuning (IMT) Valve Solenoid (3.9L)	On front of intake manifold. See Fig. 73.
Pressure Control (PC) Solenoid Valve (4T65-E)	In transmission. See Fig. 78.
Pressure Control Solenoid (4T40/4T45-E)	In transmission valve body. See Fig. 31.
Starter Solenoid (2.2L)	Lower right side of engine. See Fig. 20.
Starter Solenoid (3.5L)	Lower left side of engine. See Fig. 21.
Starter Solenoid (3.9L)	Lower left side of engine. See Fig. 73.
TCC Control PWM Solenoid (4T40/4T45-E)	In transmission valve body. See Fig. 31.
Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid Valve (4T65-E)	In automatic transmission. See Fig. 78.
1-2 & 2-3 Shift Solenoid Valves (4T40/4T45-E)	In transmission valve body. See Fig. 31.
1-2 & 3-4 Shift Solenoid (SS)Valve (4T65-E)	In transmission. See Fig. 78.
2-3 Shift Solenoid (SS) Valve (4T65-E)	In transmission. See Fig. 78.

Chevrolet Malibu LS 2007 - SWITCHES

Chevrolet Malibu LS 2007 SWITCHES LOCATION

Component	Location
Brake Fluid Level Switch	On brake master cylinder reservoir. See Fig. 16.
Cargo Lamp Switch	Part of liftgate latch. See Fig. 49.
Coolant Level Switch	On engine coolant surge tank. See Fig. 1.
Engine Oil Pressure (EOP) Switch (2.2L)	On rear left side of engine. See Fig. 77.
Engine Oil Pressure (EOP) Switch (3.5L)	On lower left side of engine. See Fig. 21.
Hood Ajar Switch	Integral to hood latch assembly.
Lever Assembly-Manual Shaft Detent/Shift Position Switch-Internal Mode Switch Assembly (4T65-E)	In transmission. See Fig. 78.
Liftgate Latch	In center of rear compartment.
Liftgate Release Switch - Exterior	In rear hatch center exterior trim bezel.
Park Brake Switch	On park brake assembly. See Fig. 15.
Park/Neutral Position (PNP) Switch (3.5L)	On top of transmission. See Fig. 81.
TFP Manual Valve Position Switch Assembly (4T40/4T45-E)	In transmission. See Fig. 31.
Windshield Washer Fluid Level Switch	Left front wheelwell, bottom of reservoir. See Fig. 50.

Chevrolet Malibu LS 2007 - MISCELLANEOUS

Chevrolet Malibu LS 2007 MISCELLANEOUS LOCATION

Component	Location
Battery	Left side of engine compartment. See Fig. 1.
Block Heater (3.9L)	On right side of engine. See Fig. 75.
Blower Motor Resistor (C60)	Right side of dash, on rear of HVAC case. See Fig. 11.
CARGO LP Diode	On rear fuse block. See Fig. 5.
Cellular Telephone Microphone	Mounted in overhead console, left of garage door opener.
Data Link Connector (DLC)	Below left side of dash, near steering column. See Fig. 2.
Digital Radio Receiver (Extended Sedan)	Right side of rear compartment, behind wheelwell. See Fig. 39.
Digital Radio Receiver (Sedan)	Center of rear package shelf. See Fig. 45.
Engine Coolant Heater (2.2L)	Lower right side of engine. See Fig. 27.
Generator (2.2L)	Front of engine. See Fig. 22.
Generator (3.5L)	Top front of engine.
Horn Assembly	Behind front fascia, mounted to frame rail extension, below left headlight. See Fig. 50.
Seat Belt Retractor Pretensioner (Left Front)	Bottom of left "B" pillar. See Fig. 41.
Seat Belt Retractor Pretensioner (Right Front)	Bottom of right "B" pillar. See Fig. 41.
Wiper Diode	On underhood fuse block. See Fig. 4.

Chevrolet Malibu LS 2007 - CONNECTORS

Chevrolet Malibu LS 2007 CONNECTORS LOCATION

Component	Location
C100 (Gray, 20 Pin)	Left side of engine compartment.
C101 (Black, 2 Pin)	Behind left front strut tower. See Fig. 1.
C102 (Black, 2 Pin)	On left side of engine. See Fig. 8.
C108 (3.5L) (Black, 8 Pin)	Left front of engine compartment, front of PCM. See Fig. 57.
C108 (3.9L) (Black, 16 Pin)	In front of PCM. See Fig. 57.
C109 (White, 5 Pin)	At left headlight. See Fig. 58.
C110 (White, 5 Pin)	At right headlight. See Fig. 58.
C130 (2.2L) (Black, 8 Pin)	Left front of engine. See Fig. 54.
C130 (3.5L & 3.9L) (Black, 16 Pin)	Top left side of engine. See Fig. 55.
C206 (Light Gray, 22 Pin)	Behind left dash panel. See Fig. 60.
C207 (Light Gray, 22 Pin)	Behind right dash access panel. See Fig. 42.
C208 (Yellow, 4 Pin)	Behind left dash access panel. See Fig. 60.
C214 (W/ DVD) (Black, 30 Pin)	Behind center console. See Fig. 18.
C214 (W/O DVD) (Black, 5 Pin)	Behind center console. See Fig. 18.
C291 (2 Pin)	Behind right access panel.
C300 (Black, 12 Pin)	Under right rear corner of driver's seat. See Fig. 79.
C304 (Yellow, 2 Pin)	Under left front door sill plate. See Fig. 65.
C305 (Yellow, 2 Pin)	Under right front sill plate. See Fig. 66.
C310 (Black, 4 Pin)	Under front passenger seat. See Fig. 35.
C315 (Black, 8 Pin)	In rear of floor console, at DVD screen hinge.
C319 (Yellow, 2 Pin)	Under driver's seat.
C320 (Yellow, 2 Pin)	Under passenger's seat.
C351 (Extended Sedan) (Black, 2 Pin)	On rear strut tower.
C351 (Sedan) (Black, 2 Pin)	Behind left rear seat, near door.
C401 (Black, 4 Pin)	Behind left rear tail lamp assembly.
C402 (Black, 4 Pin)	Behind right rear taillamp assembly.
C403 (Black, 4 Pin)	Under right rear of vehicle, attached to side of vapor canister. See Fig. 71.
C404 (Black, 6 Pin)	Top left side of liftgate.
C405 (Black, 6 Pin)	Behind left rear quarter trim, on top of strut tower.
C413 (Black, 10 Pin)	Under right rear of vehicle, side of vapor canister. See Fig. 71.
C421 (Extended Sedan) (2 Pin)	Behind left rear quarter trim. See Fig. 37.
C421 (Sedan) (2 Pin)	Behind left "C" pillar trim.
C422 (2 Pin)	Behind right quarter trim. See Fig. 39.
C500 (Gray, 40 Pin)	Left door jamb. See Fig. 63.
C600 (Gray, 40 Pin)	Right front door jamb. See Fig. 64.
C700 (Black, 14 Pin)	Left rear door jamb. See Fig. 67.
C707 (Black, 4 Pin)	Behind left taillamp assembly.
C800 (Black, 14 Pin)	Right rear door jamb. See Fig. 68.
C807 (Black, 4 Pin)	Behind right taillamp assembly.

Chevrolet Malibu LS 2007 - GROUNDS

Chevrolet Malibu LS 2007 GROUNDS LOCATION

Component	Location
G101	Near windshield wiper fluid reservoir. See Fig. 56.
G102	On core support, behind right headlamp. See Fig. 69.
G103	Top of left front strut tower. See Fig. 1.
G104	Left side of engine compartment. See Fig. 56.
G105 (3.5L)	Right rear of engine, on engine to transmission stud. See Fig. 80.
G106 (2.2L)	On engine, below generator. See Fig. 22.
G106 (3.5L)	On transmission, near park/neutral position switch. See Fig. 80.
G109	Near windshield wiper fluid reservoir. See Fig. 56.
G201	Center console, front of body control module. See Fig. 42.
G203	Center console, front of body control module. See Fig. 42.
G301 (Extended Sedan)	Behind right rear seat back. See Fig. 39.
G301 (Sedan)	Behind right rear seat back. See Fig. 38.
G302 (Extended Sedan)	Behind rear seat, on left quarterpanel. See Fig. 37.
G302 (Sedan)	Behind left rear seat. See Fig. 70.
G303	Left kick panel. See Fig. 61.
G304	Right kick panel. See Fig. 62.
G305	Right kick panel. See Fig. 62.
G401 (Extended Sedan)	Left rear side of rear compartment. See Fig. 72.
G403 (Extended Sedan)	Left rear side of rear compartment. See Fig. 72.

Chevrolet Malibu LS 2007 - SPLICES

Chevrolet Malibu LS 2007 SPLICES LOCATION

Component	Location
S106 (3.5L)	Fuel injector wiring harness, 3 cm from breakout to fuel injector 3.
S109	In left headlamp wiring harness.
S110	In right headlamp wiring harness.
S118 (3.5L)	Engine wiring harness, 7.5 cm from breakout to PCM.
S119 (3.5L)	Engine wiring harness, 15 cm from breakout to PCM.
S130 (2.2L)	In fuel injector wiring harness.
S130 (3.5L)	Fuel injector wiring harness, 4 cm from breakout to fuel injector 2.
S201	Behind inflatable restraint wheel module.
S202	Behind inflatable restraint wheel module.
S203	Behind inflatable restraint wheel module.
S301	Under left front seat.
S303	Under right front seat.
S901	In left taillamp harness.
S902	In left taillamp harness
S903	In right taillamp harness.
S904	In right taillamp harness.