Dodge Caravan LE 1996 - 1996 CHRYSLER Caravan, Grand Caravan, Grand Voyager, Town & Country, & Voyager

Dodge Caravan LE 1996 - BUZZERS, RELAYS & TIMERS

Dodge Caravan LE 1996 BUZZERS, RELAYS & TIMERS

Component	Component Location
ABS Main Relay	On junction block, behind left side of dash.
ABS Pump Motor Relay	In power distribution center.
A/C Compressor Clutch Relay	In power distribution center.
Automatic Shutdown (ASD) Relay	In power distribution center.
Automatic Shutdown (ASD) Relay (CNG)	Left inner fender panel, in power distribution center. See Fig. 13 .
Back-Up Light Relay	In power distribution center.
Cigar/Accessory Relay	In power distribution center.
Combination Flasher/DRL Module	On junction block, behind left side of dash.
Courtesy Light Relay	In power distribution center.
Door Lock Relay	On junction block, behind left side of dash.
Door Unlock Relay	On junction block, behind left side of dash.
Engine Starter Motor Relay	In power distribution center.
Front Blower Motor Relay	Behind junction block. See Fig. 14 .
Fuel Pump Relay	In power distribution center.
High Beam Relay	In power distribution center.
High Pressure Fuel Shut-Off Relay (CNG)	Left inner fender panel, in power distribution center. See Fig. 13 .
Horn Relay	On junction block, behind left side of dash.
Left Front Door Unlock Relay	On junction block, behind left side of dash.
Left & Right Combination Relays	In left rear quarter panel.
Left & Right Stop/Turn Signal Relays	In left rear quarter panel.
Low Beam Relay	In power distribution center.
Low Pressure Fuel Shut-Off Relay (CNG)	Left inner fender panel, in power distribution center.
Park Light Relay	On junction block, behind left side of dash.
Radiator Fan Relay	Front of left frame rail. See Fig. 2 .
Rear Blower Relay	On junction block, behind left side of dash.
Rear Window Defogger Relay	On junction block, behind left side of dash.
Spare Relay	In power distribution center.
Speaker Relay	On junction block, behind left side of dash.
Transmission Control Relay	In power distribution center.
Wiper High/Low Relay	In power distribution center.
Wiper On Relay	In power distribution center.

Dodge Caravan LE 1996 - CIRCUIT PROTECTION DEVICES

Dodge Caravan LE 1996 CIRCUIT PROTECTION DEVICES

Component	Component Location
Junction Block	Behind left side of dash.
Power Distribution Center	Left side of engine compartment. See Fig. 2 .
Power Distribution Center (CNG)	Left inner fender panel, by battery. See Fig. 13 .

Dodge Caravan LE 1996 - CONTROL UNITS

Dodge Caravan LE 1996 CONTROL UNITS

Component	Component Location
A/C-Heater Control Module	Dash center stack.
ABS Control Module	Under dash, on left inboard brake pedal bracket. See Fig. 14 .
Air Bag Control Module	Behind lower portion of dash center stack.
Body Control Module	On junction block, behind left side of dash. See Fig. 14 .
Combination Flasher/DRL Module	On junction block, behind left side of dash.
Controller Anti-Lock Brake	Under dash, on left inboard brake pedal bracket.
Fuel Pump Module	On fuel tank.
Memory Seat/Mirror Module	Under driver's seat.
Powertrain Control Module	Left fender side shield. See Fig. 2 .
Powertrain Control Module (CNG)	Left inner fender panel, by battery.
Remote Keyless Entry Module	Under left side of dash top cover.
Speed Control Dimming Module	Base of steering column.
Transmission Control Module	Right side of engine compartment. See Fig. 1 .

Dodge Caravan LE 1996 - MOTORS

Dodge Caravan LE 1996 MOTORS

Component	Component Location
ABS Pump Motor	Near left front strut tower. See Fig. 2 .
EVAP Leak Detection Pump (2.4L)	Left side of crossmember. See Fig. 4 .
EVAP Leak Detection Pump (3.0L)	Left side of crossmember. See Fig. 7 .
Front Blower Motor	Dash, forward of glove box.
Front Washer Motor	Bottom of washer fluid bottle.
Front Wiper Motor	In wiper module, left rear of engine compartment.
Idle Air Control Motor (2.4L)	Left rear of engine compartment. See Fig. 3 .
Idle Air Control Motor (3.0L)	Below throttle body. See Fig. 8 .
Idle Air Control Motor (3.3L)	Below throttle body. See Fig. 10 .
Idle Air Control Motor (3.8L)	Below throttle body. See Fig. 10 .
Rear Blower Motor	In rear A/C-heater unit, bottom of right "D" pillar.
Rear Washer Motor	Bottom of washer fluid bottle.
Rear Wiper Motor	Center of liftgate.

Dodge Caravan LE 1996 - SENDING UNITS & SENSORS

Dodge Caravan LE 1996 SENDING UNITS & SENSORS

Component	Component Location
Air Bag Impact Sensor	Inside air bag control module.
Ambient Air Temperature Sensor	Behind bottom of front fascia, on radiator support.
Camshaft Position Sensor (2.4L)	Left side of intake manifold. See Fig. 3 .
Camshaft Position Sensor (3.0L)	In distributor. See Fig. 5 .
Camshaft Position Sensor (3.3L)	Right side of intake manifold. See Fig. 11 .
Camshaft Position Sensor (3.8L)	Right side of intake manifold. See Fig. 11 .
Crankshaft Position Sensor (2.4L)	On transmission bellhousing. See Fig. 4 .
Crankshaft Position Sensor (3.0L)	On transmission bellhousing. See Fig. 7 .
Crankshaft Position Sensor (3.3L)	On transmission bellhousing. See Fig. 12 .
Crankshaft Position Sensor (3.8L)	On transmission bellhousing. See Fig. 12 .
Engine Coolant Temperature Sensor (2.4L)	On thermostat housing.
Engine Coolant Temperature Sensor (3.0L)	Near distributor. See Fig. 5 .
Engine Coolant Temperature Sensor (3.3L)	Next to thermostat housing.
Engine Coolant Temperature Sensor (3.8L)	Next to thermostat housing.
Evaporator Temperature Sensor	Between coils of evaporator.
Fuel Gauge Pressure Sensor (CNG)	Below left rear of vehicle, end of fuel cylinder (rear). See Fig. 13 .
Fuel Pressure Sensor (CNG)	Top of engine, at end of fuel rail. See Fig. 13 .
Fuel Temperature Sensor (CNG)	Top of engine, at beginning of fuel rail. See Fig. 13 .
Heated Oxygen Sensor (2.4L)	On exhaust manifold. See Fig. 4 .
Heated Oxygen Sensor (3.0L)	On exhaust manifold. See Fig. 8 .
Heated Oxygen Sensor (3.3L)	On exhaust manifold. See Fig. 12 .
Heated Oxygen Sensor (3.8L)	On exhaust manifold. See Fig. 12 .
Intake Air Temperature Sensor (2.4L)	On intake manifold. See Fig. 3 .
Knock Sensor (2.4L)	Front of engine, below intake manifold. See Fig. 3 .
Knock Sensor (3.3L)	Front of engine, next to oil filter.
Knock Sensor (3.8L)	Front of engine, next to oil filter.
Manifold Absolute Pressure (MAP) Sensor (2.4L)	Right side of intake manifold.
Manifold Absolute Pressure (MAP) Sensor (3.0L)	Right side of intake manifold. See Fig. 5 .
Manifold Absolute Pressure (MAP) Sensor (3.3L)	Left side of intake manifold. See Fig. 10 .
Manifold Absolute Pressure (MAP) Sensor (3.8L)	Left side of intake manifold. See Fig. 10 .
Output Shaft Speed Sensor	On transmission. See Fig. 10 .
Throttle Position Sensor (2.4L)	On throttle body. See Fig. 3 .
Throttle Position Sensor (3.0L)	On throttle body. See Fig. 8 .
Throttle Position Sensor (3.3L)	On throttle body. See Fig. 10 .
Throttle Position Sensor (3.8L)	On throttle body. See Fig. 10 .
Turbine Speed Sensor	On transmission. See Fig. 10 .
Vehicle Speed Sensor (2.4L)	Left rear of engine. See Fig. 4 .
Vehicle Speed Sensor (3.0L)	On transmission. See Fig. 7 .
Wheel Speed Sensors	At respective wheel assemblies.

Dodge Caravan LE 1996 - SOLENOIDS & SOLENOID VALVES

Dodge Caravan LE 1996 SOLENOIDS & SOLENOID VALVES

Component	Component Location
A/C Pressure Transducer	In A/C line, right rear of engine. See Fig. 1 .
ABS Hydraulic Valves	Near left front strut tower. See Fig. 2 .
EGR Solenoid (2.4L)	Left rear of engine compartment. See Fig. 3 .
EGR Solenoid (3.0L)	Right side of intake. See Fig. 8 .
EGR Solenoid (3.3L)	Rear of intake. See Fig. 10 .
EGR Solenoid (3.8L)	Rear of intake. See Fig. 10 .
EVAP/Purge Solenoid	Right side of engine compartment. See Fig. 1 .
High Pressure Fuel Shut-Off Solenoid (CNG)	Under center left side of vehicle, forward of fuel cylinders. See Fig. 13 .
Low Pressure Fuel Shut-Off Solenoid (CNG)	Right rear corner of engine compartment, on bracket on strut tower. See Fig. 13 .
Torque Converter Clutch (TCC) Solenoid (2.4L)	Front of transmission. See Fig. 3 .
Torque Converter Clutch (TCC) Solenoid (3.0L)	Front of transmission. See Fig. 6 .
Transmission Solenoids & Pressure Switches	On transmission.
Vehicle Speed Control Servo (2.4L)	Left rear of engine. See Fig. 3 .
Vehicle Speed Control Servo (3.0L)	Right rear of engine. See Fig. 8 .
Vehicle Speed Control Servo (3.3L)	Left rear of engine. See Fig. 10 .
Vehicle Speed Control Servo (3.8L)	Left rear of engine. See Fig. 10 .

Dodge Caravan LE 1996 - SWITCHES

Dodge Caravan LE 1996 SWITCHES

Component	Component Location
Brake Pressure Switch	On brake master cylinder. See Fig. 2 .
Engine Oil Pressure Switch (2.4L)	Rear of engine. See Fig. 4 .
Engine Oil Pressure Switch (3.0L)	Near starter. See Fig. 9 .
Engine Oil Pressure Switch (3.3L)	Below A/C compressor. See Fig. 10 .
Engine Oil Pressure Switch (3.8L)	Below A/C compressor. See Fig. 10 .
Park Brake Switch	Top of park brake. See Fig. 14 .
Park/Neutral Position Switch (2.4L)	On transmission. See Fig. 3 .
Park/Neutral Position Switch (3.0L)	On transmission. See Fig. 6 .
Park/Neutral Position Switch (3.3L)	On transmission. See Fig. 10 .
Park/Neutral Position Switch (3.8L)	On transmission. See Fig. 10 .
PRNDL Switch	On transmission. See Fig. 10 .
Stoplight Switch	Left side of brake pedal bracket. See Fig. 14 .

Dodge Caravan LE 1996 - MISCELLANEOUS

Dodge Caravan LE 1996 MISCELLANEOUS

Component	Component Location
Blower Motor Resistor	Right rear of engine compartment. See Fig. 1 .
Data Link Connector	Below left side of dash.
Ignition Coil (2.4L)	Top of valve cover. See Fig. 3 .
Ignition Coil (3.0L)	Top of engine. See Fig. 8 .
Fuel Tank Pressure Transducer (CNG)	Below left rear of vehicle, left of fuel cylinder (rear).
Radio Choke	Behind junction block.

Dodge Caravan LE 1996 - CONNECTORS

Dodge Caravan LE 1996 CONNECTORS LOCATION

Component	Location
B01 (Black, 10 Pin)	Above left front door lower hinge.
B02 (Black, 14 Pin)	Below upper hinge on left front door.
B03 (Black, 14 Pin)	Below upper hinge on right front door.
B09 (Black, 4 Pin)	Under left front seat.
B17 (Black, 14 Pin)	At left quarter panel.
B23 (Black, 72 Pin)	Right of steering column.
B31 (Black, 10 Pin)	At wiper module.
B33 (Black, 10 Pin)	Below battery tray.
B52 (Black, 14 Pin)	Behind left lower side of dash.
B53 (Black, 14 Pin)	In access hole, at left "D" pillar.
B56 (Black, 4 Pin)	Under right front seat.
B57 (Black, 14 Pin)	At right side kick panel.
B70 (Light/Gray, 10 Pin)	On left frame rail, under battery tray.
B75 (Blue, 6 Pin)	At bottom of right "B" pillar.
B96 (Red, 6 Pin)	At bottom of right "B" pillar.
B98 (Black, 6 Pin)	Rear of right taillight.
B99 (Black, 6 Pin)	Rear of left taillight.
C12 (Blue, 6 Pin)	At bottom of right "B" pillar.
C13 (Red, 6 Pin)	At bottom of right "B" pillar.
D01 (Black, 14 Pin)	Below upper hinge on right front door.
D02 (Black, 10 Pin)	Above left front door lower hinge.
E40 (Black, 2 Pin)	At radiator fan module.
E43 (Light/Gray, 10 Pin)	On left frame rail, under battery tray.
E68 (3.0L) (Black, 8 Pin)	Near left side of intake manifold.
E69 (2.4L) (Black, 14 Pin)	At left side of intake manifold.
E78 (Black, 14 Pin)	At left side of engine block.
F02 (3.3L) (Black, 14 Pin)	At left side of engine block.
F02 (3.8L) (Black, 14 Pin)	At left side of engine block.
F09 (2.4L) (Black, 14 Pin)	At left side of intake manifold.
J01A (Black, 14 Pin)	At left rear quarter panel.
J01D (Black, 14 Pin)	Behind right side of dash, at top of HVAC.
J02A (Black, 6 Pin)	At top right of liftgate.
J03A (Black, 6 Pin)	At top left of liftgate.
J03B (Black, 2 Pin)	At radiator fan module.
L11 (Black, 14 Pin)	In liftgate.
L15 (Black, 6 Pin)	At top right of liftgate.
L16 (Black, 6 Pin)	At top left of liftgate.
P18 (Black, 36 Pin)	Right of steering column.
P25 (Black, 14 Pin)	Left of dash center stack.
P30 (Black, 14 Pin)	At right side of HVAC.
P34 (36 Pin)	Right of steering column.
S02 (Black, 4 Pin)	Under driver's seat.
T05 (Black, 6 Pin)	At left rear quarter panel, behind taillight.
T08 (Black, 6 Pin)	At right rear quarter panel, behind taillight.

Dodge Caravan LE 1996 - GROUNDS

Dodge Caravan LE 1996 GROUNDS LOCATION

Component	Location
G100	At left frame rail.
G101 (2.4L)	At rear of cylinder head.
G101 (3.0L)	At rear of cylinder block.
G101 (3.3L)	At rear of cylinder block.
G101 (3.8L)	At rear of cylinder block.
G102	At left frame rail.
G103 (2.4L)	At rear of cylinder head.
G103 (3.0L)	At rear of cylinder block.
G103 (3.3L)	At rear of cylinder block.
G103 (3.8L)	At rear of cylinder block.
G200	Behind center of dash.
G201	Behind center of dash.
G202	Behind center of dash.
G203	Behind center of dash.
G300	At left side kick panel.
G301	At right side kick panel.
G302 (Black, 14 Pin)	At left rear quarter panel ground block.
G400 (Black, 14 Pin)	At liftgate ground block.

Dodge Caravan LE 1996 - SPLICES

Dodge Caravan LE 1996 SPLICES LOCATION

Component	Location
BS01	Near split for taillights.
BS02	Near breakout for fuel tank.
BS03	Near breakout for connector B23.
BS05	Near breakout for left kick panel ground.
BS06	Near breakout for park brake switch.
BS08	Near breakout for connector B23.
BS09	Near breakout for right kick panel ground.
BS10	Near breakout for right kick panel ground.
BS13	Near breakout for park brake switch.
BS14	Near breakout for left kick panel ground.
BS15	Near breakout for left headlight.
BS16	Near breakout for right park light.
BS17	Near split for taillights.
BS18	Near breakout for left door.
BS19	Near breakout for horn.
CS01	Above right door.
CS02	Near left "B" pillar.
CS03	Near right "B" pillar.
CS04	Near right "B" pillar.
DS01	Near breakout for left power window.
ES01 (3.3L)	Near breakout for transmission control module. See Fig. 1 .
ES01 (3.8L)	Near breakout for transmission control module. See Fig. 1 .
ES02 (2.4L)	Near breakout for fuel rail. See Fig. 3 .
ES02 (3.0L)	Near breakout for injector harness. See Fig. 8 .
ES02 (3.3L)	Near breakout for knock sensor. See Fig. 12 .
ES02 (3.8L)	Near breakout for knock sensor. See Fig. 12 .
ES03 (2.4L)	Near breakout for power distribution center. See Fig. 2 .
ES03 (3.0L)	Near breakout for speed control. See Fig. 8 .
ES03 (3.3L)	Near breakout for body ground. See Fig. 2 .
ES03 (3.8L)	Near breakout for body ground. See Fig. 2 .
ES05 (W/Automatic Transmission)	Near breakout for PRNDL switch. See Fig. 10 .
ES06 (W/Automatic Transmission)	Near breakout for starter motor. See Fig. 10 .
ES07 (2.4L)	Near breakout for E43. See Fig. 2 .
ES07 (3.0L)	Near breakout for negative battery terminal. See Fig. 2 .
ES07 (3.3L)	Near breakout for starter motor. See Fig. 10 .
ES07 (3.8L)	Near breakout for starter motor. See Fig. 10 .
ES08 (W/Automatic Transmission)	Near breakout for PRNDL switch. See Fig. 10 .
ES09 (2.4L)	Near battery positive terminal. See Fig. 2 .
ES09 (3.0L)	Near battery positive terminal. See Fig. 2 .
ES09 (3.3L)	Near breakout for fuse link. See Fig. 2 .
ES09 (3.8L)	Near breakout for fuse link. See Fig. 2 .
ES10 (W/Automatic Transmission)	Near breakout for PRNDL switch. See Fig. 10 .
ES11 (2.4L)	Near breakout for engine grounds. See Fig. 2 .
ES11 (3.0L)	Near breakout for negative battery terminal. See Fig. 2 .
ES11 (3.3L)	Near breakout for negative battery terminal. See Fig. 2 .
ES11 (3.8L)	Near breakout for negative battery terminal. See Fig. 2 .
ES12 (2.4L)	Near breakout for throttle body. See Fig. 3 .
ES12 (3.0L)	Near breakout for throttle body. See Fig. 8 .
ES12 (3.3L)	Near breakout for upstream heated O2 sensor. See Fig. 12 .
ES12 (3.8L)	Near breakout for upstream heated O2 sensor. See Fig. 12 .
ES13 (3.3L) (W/Automatic Transmission)	At breakout for positive battery terminal. See Fig. 2 .
ES13 (3.8L) (W/Automatic Transmission)	At breakout for positive battery terminal. See Fig. 2 .
ES14 (3.3L) (W/Automatic Transmission)	At breakout for positive battery terminal. See Fig. 2 .
ES14 (3.8L) (W/Automatic Transmission)	At breakout for positive battery terminal. See Fig. 2 .
ES15 (W/Automatic Transmission)	At breakout for starter motor. See Fig. 10 .
ES17 (2.4L)	Near breakout for leak detection pump. See Fig. 4 .
ES17 (3.0L)	At breakout for TCC solenoid. See Fig. 6 .
ES17 (3.3L)	At breakout for positive battery terminal. See Fig. 2 .
ES17 (3.8L)	At breakout for positive battery terminal. See Fig. 2 .
ES18 (2.4L)	Near breakout for engine ground. See Fig. 3 .
ES18 (3.0L)	Near breakout for negative battery terminal. See Fig. 6 .
ES18 (3.3L)	Near breakout for E43. See Fig. 2 .
ES18 (3.8L)	Near breakout for E43. See Fig. 2 .
ES21 (3.0L)	Near breakout for engine ground. See Fig. 8 .
ES21 (3.3L)	Near breakout for A/C clutch. See Fig. 11 .
ES21 (3.8L)	Near breakout for A/C clutch. See Fig. 11 .
ES22 (W/Automatic Transmission)	Near breakout for radiator fan. See Fig. 10 .
ES23 (2.4L)	At breakout for radiator fan. See Fig. 2 .
ES23 (3.0L)	Near breakout for radiator fan. See Fig. 2 .
ES23 (3.3L)	At breakout for radiator fan. See Fig. 2 .
ES23 (3.8L)	At breakout for radiator fan. See Fig. 2 .
ES24	Near breakout for PRNDL switch. See Fig. 10 .
FS01 (2.4L)	Near breakout for coolant temperature sensor.
FS01 (3.0L)	Near breakout for MAP sensor.
FS01 (3.3L)	Near breakout for MAP sensor.
FS01 (3.8L)	Near breakout for MAP sensor.
FS02 (2.4L)	Near breakout for injector No. 2.
FS02 (3.0L)	Between breakout for injector No. 4 & No. 6.
FS02 (3.3L)	Between breakout for injector No. 4 & No. 6.
FS02 (3.8L)	Between breakout for injector No. 4 & No. 6.
FS03 (2.4L)	Between breakout for injector No. 2 & No. 3.
JS01	Near breakout for recirculation motor.
JS01 (AWD)	Near fuel tank grommet.
JS02	At radiator fan module.
JS03	Near breakout for mode door motor.
PS01	Near connector P18.
PS02	Near connector P18.
SS01	Near breakout for horizontal motor.
SS02	Near breakout for horizontal motor.