Dodge Grand Caravan Sport 2000 - 2000 ELECTRICAL COMPONENT LOCATOR FWD Van

Dodge Grand Caravan Sport 2000 - BUZZERS, RELAYS & TIMERS

Dodge Grand Caravan Sport 2000 BUZZERS, RELAYS & TIMERS LOCATION

Component	Location
A/C Compressor Clutch Relay	In power distribution center.
Automatic Shut Down (ASD) Relay	In power distribution center.
Cigar Lighter/Accessory Relay	In power distribution center.
Combination Flasher/DRL Module	On junction block, behind left side of dash.
Courtesy Light Relay	On junction block, behind left side of dash.
Door Lock Relay	On junction block, behind left side of dash.
Door Unlock Relay	On junction block, behind left side of dash.
Driver Door Unlock Relay	On junction block, behind left side of dash.
Engine Starter Motor Relay	In power distribution center.
Foglight Relay	On junction block, behind left side of dash.
Front Blower Motor Relay	In power distribution center.
Fuel Pump Relay	In power distribution center.
High Beam Relay	In power distribution center.
Horn Relay	In power distribution center.
Left & Right Combination Relays	In left rear quarterpanel.
Left & Right Stop/Turn Signal Relays	In left rear quarterpanel.
Low Beam Relay	In power distribution center.
Name Brand Speaker Relay	On junction block, behind left side of dash.
Park Light Relay	In power distribution center.
Radiator Fan Relay	Underneath left headlamp assembly. See Fig. 2.
Rear Window Defogger Relay	On junction block, behind left side of dash.
Spare Relay	In power distribution center.
Transmission Control Relay	In power distribution center.
Wiper High/Low Relay	In power distribution center.
Wiper On Relay	In power distribution center.

Dodge Grand Caravan Sport 2000 - CIRCUIT PROTECTION DEVICES

Dodge Grand Caravan Sport 2000 CIRCUIT PROTECTION DEVICES LOCATION

Component	Location
Junction Block	Behind left side of dash.
Power Distribution Center	Left side of engine compartment. See Fig. 2.
Power Seat Circuit Breaker	Under driver's seat.

Dodge Grand Caravan Sport 2000 - CONTROL UNITS

Dodge Grand Caravan Sport 2000 CONTROL UNITS LOCATION

Component	Location
Air Bag Control Module	Behind lower portion of dash center stack.
Body Control Module	On junction block, behind left side of dash.
Combination Flasher/DRL Module	On junction block, behind left side of dash.
Controller Anti-Lock Brake	Under driver side of vehicle, mounted to the front suspension cradle, attached to the hydraulic control unit.
Fuel Pump Module	On side of fuel tank.
Memory Seat/Mirror Module	Under driver's seat.
Powertrain Control Module	Left side of engine compartment. See Fig. 2.
Remote Keyless Entry Module	Under left side of dash top cover.
Transmission Control Module	Right side of engine compartment. See Fig. 1.

Dodge Grand Caravan Sport 2000 - MOTORS

Dodge Grand Caravan Sport 2000 MOTORS LOCATION

Component	Location
A/C Zone Door Actuator	Left side of HVAC.
Blend Door Actuator	Left side of HVAC.
Engine Starter Motor (2.4L)	On left rear of engine block. See Fig. 3.
Engine Starter Motor (3.0L)	On left rear of engine block. See Fig. 9.
Engine Starter Motor (3.3L)	On left rear of engine block. See Fig. 10.
Engine Starter Motor (3.8L)	On left rear of engine block. See Fig. 10.
EVAP Leak Detection Pump (2.4L)	Left side of crossmember. See Fig. 4.
EVAP Leak Detection Pump (3.3L)	Left side of crossmember.
EVAP Leak Detection Pump (3.8L)	Left side of crossmember.
Front Blower Motor	Right side of dash, forward of glove box.
Front Washer Motor	Bottom of washer fluid bottle.
Idle Air Control Motor (2.4L)	On throttle body. See Fig. 3.
Idle Air Control Motor (3.0L)	On throttle body. See Fig. 8.
Idle Air Control Motor (3.3L)	On throttle body. See Fig. 10.
Idle Air Control Motor (3.8L)	On throttle body. See Fig. 10.
Mode Door Actuator	Left side of HVAC.
Radiator Fan No. 1	Behind radiator.
Radiator Fan No. 2	Behind radiator.
Rear Blower Motor	In rear A/C-heater unit, bottom of right "D" pillar.
Rear Washer Motor	Bottom of washer fluid bottle.
Rear Wiper Motor	Center of liftgate.
Recirculation Door Actuator	Right side of HVAC.
Wiper Module	Left rear of engine compartment.

Dodge Grand Caravan Sport 2000 - SENDING UNITS & SENSORS

Dodge Grand Caravan Sport 2000 SENDING UNITS & SENSORS LOCATION

Component	Location
A/C Pressure Transducer	In A/C line, right rear of engine compartment. See Fig. 1.
Ambient Temperature Sensor	Behind bottom of front fascia, on radiator support.
Camshaft Position Sensor (2.4L)	On rear of cylinder head. See Fig. 3.
Camshaft Position Sensor (3.0L)	In distributor. See Fig. 5.
Camshaft Position Sensor (3.3L)	On front of engine. See Fig. 11.
Camshaft Position Sensor (3.8L)	On front of engine. See Fig. 11.
Crankshaft Position Sensor (2.4L)	Right side of engine, below exhaust manifold. See Fig. 4.
Crankshaft Position Sensor (3.0L)	On transmission bellhousing. See Fig. 7.
Crankshaft Position Sensor (3.3L)	On transmission bellhousing. See Fig. 12.
Crankshaft Position Sensor (3.8L)	On transmission bellhousing. See Fig. 12.
Downstream Heated Oxygen Sensor	Front center of floor pan, in exhaust pipe.
Engine Coolant Temperature Sensor (2.4L)	On thermostat housing.
Engine Coolant Temperature Sensor (3.0L)	Near distributor. See Fig. 5.
Engine Coolant Temperature Sensor (3.3L)	Next to thermostat housing.
Engine Coolant Temperature Sensor (3.8L)	Next to thermostat housing.
Evaporator Temperature Sensor	Between coils of evaporator.
Input Speed Sensor (3.0L)	On transmission.
Input Speed Sensor (3.3L)	On transmission. See Fig. 10.
Input Speed Sensor (3.8L)	On transmission. See Fig. 10.
Intake Air Temperature Sensor (2.4L)	On intake manifold. See Fig. 3.
Knock Sensor (2.4L)	Left side of engine, below intake manifold. See Fig. 3.
Knock Sensor (3.3L)	Left side of engine, next to oil filter.
Knock Sensor (3.8L)	Left side of engine, next to oil filter.
Manifold Absolute Pressure (MAP) Sensor (2.4L)	On front of intake manifold.
Manifold Absolute Pressure (MAP) Sensor (3.0L)	On front of intake manifold. See Fig. 5.
Manifold Absolute Pressure (MAP) Sensor (3.3L)	On rear of intake manifold. See Fig. 10.
Manifold Absolute Pressure (MAP) Sensor (3.8L)	On rear of intake manifold. See Fig. 10.
Output Speed Sensor (3.0L)	On transmission.
Output Speed Sensor (3.3L)	On transmission. See Fig. 10.
Output Speed Sensor (3.8L)	On transmission. See Fig. 10.
Throttle Position Sensor (2.4L)	On throttle body. See Fig. 3.
Throttle Position Sensor (3.0L)	On throttle body. See Fig. 8.
Throttle Position Sensor (3.3L)	On throttle body. See Fig. 10.
Throttle Position Sensor (3.8L)	On throttle body. See Fig. 10.
Transmission Range Sensor (3.0L)	On transmission. See Fig. 6.
Transmission Range Sensor (3.3L)	On transmission. See Fig. 10.
Transmission Range Sensor (3.8L)	On transmission. See Fig. 10.
Upstream Heated Oxygen Sensor (2.4L)	On exhaust manifold. See Fig. 4.
Upstream Heated Oxygen Sensor (3.0L)	On exhaust manifold. See Fig. 8.
Upstream Heated Oxygen Sensor (3.3L)	On exhaust manifold. See Fig. 12.
Upstream Heated Oxygen Sensor (3.8L)	On exhaust manifold. See Fig. 12.
Vehicle Speed Sensor (2.4L)	On right side of transmission. See Fig. 4.
Wheel Speed Sensors	At respective wheel assemblies.

Dodge Grand Caravan Sport 2000 - SOLENOIDS & SOLENOID VALVES

Dodge Grand Caravan Sport 2000 SOLENOIDS & SOLENOID VALVES LOCATION

Component	Location
All Wheel Drive Solenoid	Near fuel tank.
EGR Solenoid (3.0L)	On right rear of engine. See Fig. 8.
EGR Solenoid (3.3L)	On right rear of engine. See Fig. 10.
EGR Solenoid (3.8L)	On right rear of engine. See Fig. 10.
EVAP/Purge Solenoid	On right side of engine compartment. See Fig. 1.
Torque Converter Clutch (TCC) Solenoid (2.4L)	On transmission. See Fig. 3.
Transmission Control Solenoids (3.0L)	On transmission. See Fig. 6.
Transmission Control Solenoids (3.3L)	On transmission.
Transmission Control Solenoids (3.8L)	On transmission.
Vehicle Speed Control Servo (2.4L)	Left rear of engine compartment. See Fig. 3.
Vehicle Speed Control Servo (3.0L)	Left rear of engine compartment. See Fig. 8.
Vehicle Speed Control Servo (3.3L)	Left rear of engine compartment. See Fig. 10.
Vehicle Speed Control Servo (3.8L)	Left rear of engine compartment. See Fig. 10.

Dodge Grand Caravan Sport 2000 - SWITCHES

Dodge Grand Caravan Sport 2000 SWITCHES LOCATION

Component	Location
Brake Pressure Switch	On brake master cylinder. See Fig. 2.
Engine Oil Pressure Switch (2.4L)	On right side of engine block. See Fig. 4.
Engine Oil Pressure Switch (3.0L)	Near starter. See Fig. 9.
Engine Oil Pressure Switch (3.3L)	Below A/C compressor. See Fig. 10.
Engine Oil Pressure Switch (3.8L)	Below A/C compressor. See Fig. 10.
Low Washer Fluid Level Switch	At bottom of washer fluid reservoir.
Park Brake Switch	At top of park brake.
Park/Neutral Position Switch (2.4L)	On transmission. See Fig. 3.
Seat Belt Switch	At base of left "B" pillar; integral to driver's seat belt retractor.
Stoplight Switch	Left side of brake pedal bracket.

Dodge Grand Caravan Sport 2000 - MISCELLANEOUS

Dodge Grand Caravan Sport 2000 MISCELLANEOUS LOCATION

Component	Location
A/C Compressor Clutch (2.4L)	On left front of engine. See Fig. 3.
A/C Compressor Clutch (3.0L)	On left front of engine. See Fig. 5.
A/C Compressor Clutch (3.3L)	On left front of engine. See Fig. 11.
A/C Compressor Clutch (3.8L)	On left front of engine. See Fig. 11.
Data Link Connector (DLC)	Below left side of dash.
Electric Wiper De-Icer	At base of windshield.
Front Blower Motor Resistor Block	Right rear of engine compartment. See Fig. 1.
Generator (2.4L)	On left front of engine. See Fig. 3.
Generator (3.0L)	On right front of engine. See Fig. 8.
Generator (3.3L)	On right front of engine. See Fig. 12.
Generator (3.8L)	On right front of engine. See Fig. 12.
Ignition Coil (3.0L)	Top of right valve cover. See Fig. 8.
Ignition Coil Pack (2.4L)	Top of valve cover. See Fig. 3.
Ignition Coil Pack (3.3L)	Front of engine, near generator.
Ignition Coil Pack (3.8L)	Front of engine, near generator.
Radio Choke	Behind radio.
Trailer Tow Connector	Left quarterpanel.

Dodge Grand Caravan Sport 2000 - CONNECTORS

Dodge Grand Caravan Sport 2000 CONNECTORS LOCATION

Component	Location
AW4 (Gray, 4 Pin)	At side of fuel tank.
B01 (Black, 10 Pin)	At left kick panel.
B02 (Black, 14 Pin)	At left kick panel.
B03 (Black, 14 Pin)	At right kick panel.
B09 (Black, 4 Pin)	Under left front seat.
B13 (Gray, 4 Pin)	At side of fuel tank.
B17 (Black, 14 Pin)	At left quarterpanel.
B23 (74 Pin)	Right of steering column.
B33 (Black, 10 Pin)	On left frame rail.
B56 (Black, 4 Pin)	Under right front seat.
B70 (Light Gray, 10 Pin)	On left frame rail.
B98 (Black, 6 Pin)	Rear of right taillight.
B99 (Black, 6 Pin)	Rear of left taillight.
B120 (Black, 10 Pin)	At right kick panel.
C20 (Gray, 20 Pin)	At bottom of right "B" pillar.
D02 (Black, 10 Pin)	At left kick panel.
E05 (Light Gray, 4 Pin)	At left kick panel.
E36 (Black, 10 Pin)	On left frame rail.
E40 (Black, 2 Pin)	At radiator fan module.
E43 (Light Gray, 10 Pin)	On left frame rail.
E69 (2.4L) (Black, 14 Pin)	At left side of intake. See Fig. 3.
E78 (3.3L) (Black, 14 Pin)	Near throttle body. See Fig. 10.
E78 (3.8L) (Black, 14 Pin)	Near throttle body. See Fig. 10.
F02 (3.3L) (Black, 14 Pin)	Near throttle body. See Fig. 10.
F02 (3.8L) (Black, 14 Pin)	Near throttle body. See Fig. 10.
F09 (2.4L) (Black, 14 Pin)	At left side of intake. See Fig. 3.
F09 (3.0L) (Black, 8 Pin)	At left side of intake.
HS5D (Black, 4 Pin)	At heated seat.
HS5P (Black, 4 Pin)	At heated seat.
HS6D (Black, 4 Pin)	At heated seat.
HS6P (Black, 4 Pin)	At heated seat.
J01D (Black, 14 Pin)	At right side of HVAC.
J02A (Black, 6 Pin)	At top of liftgate.
J03A (Black, 6 Pin)	At top of liftgate.
L15 (Black, 6 Pin)	At top of liftgate.
L16 (Black, 6 Pin)	At top of liftgate.
LD02 (Light Gray, 4 Pin)	At side of transmission.
LJ01 (Black, 14 Pin)	At left quarterpanel.
P30 (Black, 14 Pin)	At right side of HVAC.
P52 (74 Pin)	Behind center of dash.
S02 (Black, 4 Pin)	Under rear seat.
T05 (Black, 6 Pin)	At left quarterpanel.
T08 (Black, 6 Pin)	At left quarterpanel.

Dodge Grand Caravan Sport 2000 - GROUNDS

Dodge Grand Caravan Sport 2000 GROUNDS LOCATION

Component	Location
G100	At left frame rail.
G101 (2.4L)	At rear of cylinder head. See Fig. 3.
G101 (3.0L)	At rear of cylinder block. See Fig. 8.
G101 (3.3L)	At rear of cylinder block. See Fig. 10.
G101 (3.8L)	At rear of cylinder block. See Fig. 10.
G102	At left frame rail.
G103 (2.4L)	At rear of cylinder head. See Fig. 3.
G103 (3.0L)	At rear of cylinder block. See Fig. 8.
G103 (3.3L)	At rear of cylinder block. See Fig. 10.
G103 (3.8L)	At rear of cylinder block. See Fig. 10.
G200	Behind center of dash.
G201	Behind center of dash.
G202	Behind center of dash.
G203	Behind center of dash.
G204	Behind center of dash.
G300	At left kick panel ground block.
G301	At right kick panel ground block.
G302	At left rear quarterpanel ground block.
G400	At liftgate ground block.

Dodge Grand Caravan Sport 2000 - SPLICES

Dodge Grand Caravan Sport 2000 SPLICES LOCATION

Component	Location
BS01	Near breakout for taillights.
BS02	Near breakout for fuel tank.
BS03	Near breakout for connector B23.
BS05	In trough for radio choke.
BS06	In trough for radio choke.
BS08	Near breakout for connector B23.
BS09	Near breakout for right kick panel ground.
BS10	Near breakout for right kick panel ground.
BS14	Near breakout for left kick panel ground.
BS15	In breakout for connector B23.
BS16	Near breakout for right park light.
BS17 (LWB)	Near breakout for B75.
BS19	Near breakout for horn.
BS20	Near breakout for horn.
BS30 (SWB)	Near breakout for radio choke.
CS01	Above right rear door.
CS02	Near right "B" pillar.
CS03	Above right front door.
DS01	Near breakout for memory set switch.
ES01	Near breakout for transmission control module. See Fig. 1.
ES02 (2.4L)	Near breakout for throttle position sensor. See Fig. 3.
ES02 (3.0L)	Near breakout for generator. See Fig. 8.
ES02 (3.3L)	Near body ground. See Fig. 12.
ES02 (3.8L)	Near body ground. See Fig. 12.
ES03 (2.4L)	Near breakout for powertrain control module. See Fig. 2.
ES03 (3.0L)	Near breakout for throttle position sensor. See Fig. 8.
ES03 (3.3L)	Near breakout for body ground. See Fig. 2.
ES03 (3.8L)	Near breakout for body ground. See Fig. 2.
ES04 (2.4L)	Near breakout for engine grounds.
ES04 (3.3L)	Near breakout for E36. See Fig. 2.
ES04 (3.8L)	Near breakout for E36. See Fig. 2.
ES05 (3.0L)	Near breakout for body ground.
ES05 (3.3L)	Near breakout for body ground. See Fig. 10.
ES05 (3.8L)	Near breakout for body ground. See Fig. 10.
ES07 (2.4L)	Near breakout for E43. See Fig. 2.
ES07 (3.0L)	Near breakout for battery negative terminal. See Fig. 2.
ES07 (3.3L)	Near breakout for radiator fan. See Fig. 2.
ES07 (3.8L)	Near breakout for radiator fan. See Fig. 2.
ES08 (3.0L)	Near breakout for VSCS.
ES08 (3.3L)	Near breakout for TRS. See Fig. 10.
ES08 (3.8L)	Near breakout for TRS. See Fig. 10.
ES09	Near battery positive terminal. See Fig. 2.
ES10 (3.0L)	Near breakout for TRS.
ES10 (3.3L)	Near breakout for TRS.
ES10 (3.8L)	Near breakout for TRS.
ES11 (2.4L)	Near breakout for battery negative terminal. See Fig. 2.
ES11 (3.0L)	In breakout for battery negative terminal. See Fig. 2.
ES11 (3.3L)	In breakout for battery negative terminal. See Fig. 2.
ES11 (3.8L)	In breakout for battery negative terminal. See Fig. 2.
ES12 (2.4L)	Near breakout for throttle position sensor. See Fig. 3.
ES12 (3.0L)	Near breakout for throttle position sensor. See Fig. 8.
ES12 (3.3L)	Near breakout for power distribution center C7. See Fig. 2.
ES12 (3.8L)	Near breakout for power distribution center C7. See Fig. 2.
ES13 (3.0L)	Near breakout for VSCS.
ES13 (3.3L)	Near breakout for power distribution center. See Fig. 2.
ES13 (3.8L)	Near breakout for power distribution center. See Fig. 2.
ES14	Near breakout for negative battery cable. See Fig. 2.
ES17 (2.4L)	Near breakout for leak detection pump. See Fig. 4.
ES17 (3.0L)	At breakout for crank position sensor. See Fig. 6.
ES17 (3.3L)	Near breakout for negative battery cable. See Fig. 2.
ES17 (3.8L)	Near breakout for negative battery cable. See Fig. 2.
ES18 (2.4L)	Near breakout for engine grounds. See Fig. 3.
ES18 (3.0L)	Near breakout for EGR solenoid. See Fig. 6.
ES18 (3.3L)	Near breakout for throttle position sensor.
ES18 (3.8L)	Near breakout for throttle position sensor.
ES21 (3.0L)	Near breakout for engine ground. See Fig. 8.
ES21 (3.3L)	Near breakout for A/C clutch. See Fig. 11.
ES21 (3.8L)	Near breakout for A/C clutch. See Fig. 11.
ES23	At breakout for radiator fan. See Fig. 2.
ES24 (2.4L)	At breakout for powertrain control module C2. See Fig. 2.
ES24 (3.0L)	Near breakout for VSCS.
ES24 (3.3L)	Near breakout for TRS. See Fig. 10.
ES24 (3.8L)	Near breakout for TRS. See Fig. 10.
ES25 (2.4L)	Near breakout for powertrain control module. See Fig. 2.
ES25 (3.0L)	Near breakout for VSCS.
ES26 (2.4L)	At breakout for E36. See Fig. 2.
ES27 (2.4L)	At breakout for E36. See Fig. 2.
FS01 (2.4L)	Near breakout for ECT sensor.
FS01 (3.0L)	Near breakout for MAP sensor.
FS01 (3.3L)	Near breakout for MAP sensor.
FS01 (3.8L)	Near breakout for MAP sensor.
FS02 (2.4L)	Near breakout for injector No. 2.
FS02 (3.0L)	Between breakout for injector No. 4 & No. 6.
FS02 (3.3L)	Between breakout for injector No. 4 & No. 6.
FS02 (3.8L)	Between breakout for injector No. 4 & No. 6.
FS03 (2.4L)	Between breakout for injector No. 2 & No. 3.
JS01	At radiator fan module.
JS01	Near breakout for recirculation motor.
JS01 (W/AWD)	Near fuel tank grommet.
JS02	At radiator fan module.
JS03	Near breakout for mode door motor.
PS01	Near connector P52.
PS02	Near breakout for front cigar lighter/power outlet.
SS01	Near breakout for horizontal motor.
SS02	Near breakout for horizontal motor.