Dodge Ram Van B1500 1996 - 1996 CHRYSLER Ram Van & Ram Wagon

Dodge Ram Van B1500 1996 - BUZZERS, RELAYS & TIMERS

Dodge Ram Van B1500 1996 BUZZERS, RELAYS & TIMERS

Component	Component Location
ABS Lamp Relay	In power distribution center, radiator front support.
ABS Power Relay	In power distribution center, radiator front support.
A/C Compressor Clutch Relay	In power distribution center, radiator front support.
Automatic Shutdown Relay	In power distribution center, radiator front support.
Automatic Shutdown (ASD) Relay (CNG)	In power distribution center, radiator front support. See Fig. 11 .
Auxiliary A/C-Heater Relay	Behind center of dash. See Fig. 9 .
Electronic Transmission Relay	Dash panel, near brake master cylinder. See Fig. 5 .
Engine Starter Motor Relay	In power distribution center, radiator front support.
Fuel Pump Relay	In power distribution center, radiator front support.
Hazard Flasher	Behind glove box bin, on right cowl inner panel.
High Pressure Fuel Shut-Off Solenoid Relay (CNG)	In power distribution center, radiator front support. See Fig. 11 .
Horn Relay	In power distribution center, radiator front support.
Rear Window Defogger Timer	In rear window defogger switch.
Time Delay Relay	Behind right side of dash, on relay block.
Turn Signal Flasher	Behind glove box bin, on right cowl inner panel.
Van Conversion Accessory Relay	Near rear of headlamp switch.

Dodge Ram Van B1500 1996 - CIRCUIT PROTECTION DEVICES

Dodge Ram Van B1500 1996 CIRCUIT PROTECTION DEVICES

Component	Component Location
Circuit Breaker (Headlamp)	In headlamp switch.
Circuit Breaker (Power Door Lock)	In cavity No. 16 of fuse block.
Circuit Breaker (Power Window)	In cavity No. 8 of fuse block.
Circuit Breaker (Windshield Wiper)	In windshield wiper motor.
Fuse Block	Behind center of dash, to left of glove box.
Fusible Link (Accessories & Rear Window Defogger) (Gray)	On left side of dash panel.
Fusible Link (Charging System) (Dark Green)	On left side of dash panel.
Fusible Link (Hazard Flasher) (White)	On left side of dash panel.
Fusible Link (Headlamps) (Gray)	On left side of dash panel.
Fusible Link (Ignition Switch) (Orange)	On left side of dash panel (2 fusible links).
Power Distribution Center	Front of engine compartment, next to radiator.
Relay Bank	Behind right side of dash, to right of glove box. See Fig. 7 .

Dodge Ram Van B1500 1996 - CONTROL UNITS

Dodge Ram Van B1500 1996 CONTROL UNITS

Component	Component Location
Air Bag Control Module	Below driver's seat.
Buzzer Module	Left rear of instrument panel.
Controller Anti-Lock Brake	Left inner fender panel, under battery tray.
Daytime Running Lamps (DRL) Module	Top center of dash panel. See Fig. 3 .
Intermittent Wiper Control Module	Behind top of glove box. See Fig. 10 .
Power Door Lock Module	Behind center of instrument panel.
Powertrain Control Module (CNG)	Center of firewall. See Fig. 11 .
Powertrain Control Module (PCM)	Center of firewall. See Fig. 3 .
RWAL Module	Behind right side of dash. See Fig. 7 .

Dodge Ram Van B1500 1996 - MOTORS

Dodge Ram Van B1500 1996 MOTORS

Component	Component Location
ABS Front Hydraulic Valve	Left inner fender panel, under battery tray.
ABS Rear Hydraulic Valve	Left side of engine compartment. See Fig. 6 .
Blower Motor	On bottom of evaporator/heater housing, in engine compartment.
Idle Air Control Motor (3.9L)	On left side of throttle body assembly. See Fig. 1 .
Idle Air Control Motor (5.2L)	On left side of throttle body assembly. See Fig. 2 .
Idle Air Control Motor (5.9L)	On left side of throttle body assembly. See Fig. 2 .
Rear Blower Motor	Inside blower housing, on floor behind driver's seat.
Vehicle Speed Control Servo	Front of right fender side shield. See Fig. 4 .
Windshield Washer Motor	On bottom of windshield washer fluid reservoir.
Windshield Wiper Motor	On center of dash panel.

Dodge Ram Van B1500 1996 - SENDING UNITS & SENSORS

Dodge Ram Van B1500 1996 SENDING UNITS & SENSORS

Component	Component Location
ABS Left Front Wheel Speed Sensor	Left front steering knuckle.
ABS Right Front Wheel Speed Sensor	Right front steering knuckle. See Fig. 4 .
Camshaft Position Sensor	In distributor.
Crankshaft Position Sensor	Top of transmission bellhousing.
Engine Coolant Temperature Sending Unit (3.9L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 1 .
Engine Coolant Temperature Sending Unit (5.2L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 2 .
Engine Coolant Temperature Sending Unit (5.9L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 2 .
Engine Coolant Temperature Sensor (3.9L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 1 .
Engine Coolant Temperature Sensor (5.2L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 2 .
Engine Coolant Temperature Sensor (5.9L)	At front of engine, in intake manifold, near thermostat housing. See Fig. 2 .
Fuel Gauge Pressure Sensor (CNG)	Below left side of vehicle, on rear of left side mounted fuel cylinder. See Fig. 11 .
Fuel Pressure Sensor (CNG)	Top of engine, at end of fuel rail. See Fig. 11 .
Fuel Temperature Sensor (CNG)	Top of engine, at beginning of fuel rail. See Fig. 11 .
Intake Air Temperature Sensor (5.2L)	On right side of engine, in intake manifold. See Fig. 2 .
Intake Air Temperature Sensor (5.9L)	On right side of engine, in intake manifold. See Fig. 2 .
MAP Sensor (3.9L)	On right side of throttle body assembly. See Fig. 1 .
MAP Sensor (5.2L)	On right side of throttle body assembly. See Fig. 2 .
MAP Sensor (5.9L)	On right side of throttle body assembly. See Fig. 2 .
Oil Pressure Sending Unit (3.9L)	On rear of engine, to right of distributor. See Fig. 1 .
Oil Pressure Sending Unit (5.2L)	On rear of engine, to right of distributor. See Fig. 2 .
Oil Pressure Sending Unit (5.9L)	On rear of engine, to right of distributor. See Fig. 2 .
Rear Wheel Speed Sensor	On differential housing.
Throttle Position (TP) Sensor (3.9L)	On front of throttle body assembly. See Fig. 1 .
Throttle Position (TP) Sensor (5.2L)	On front of throttle body assembly. See Fig. 2 .
Throttle Position (TP) Sensor (5.9L)	On front of throttle body assembly. See Fig. 2 .
Vehicle Speed Sensor (VSS)	On left rear of transmission.
Windshield Washer Low Fluid Sensor	On top of windshield washer fluid reservoir.

Dodge Ram Van B1500 1996 - SOLENOIDS & SOLENOID VALVES

Dodge Ram Van B1500 1996 SOLENOIDS & SOLENOID VALVES

Component	Component Location
ABS Front Hydraulic Valve	Left inner fender panel, under battery tray.
ABS Rear Hydraulic Valve	Left side of engine compartment. See Fig. 6 .
Duty Cycle EVAP/Purge Solenoid (3.9L)	On left rear of intake manifold.
Duty Cycle EVAP/Purge Solenoid (5.2L)	On left rear of intake manifold. See Fig. 2 .
Duty Cycle EVAP/Purge Solenoid (5.9L)	On left rear of intake manifold. See Fig. 2 .
EGR Solenoid/Transducer	On right rear of engine.
High Pressure Fuel Shut-Off Solenoid (CNG)	Under center right side of vehicle, part of fuel pressure regulator. See Fig. 11 .
Low Pressure Fuel Shut-Off Solenoid (CNG)	Top of engine, mounted on side of fuel injector rail inlet. See Fig. 11 .
TCC Solenoid (A/T W/O Overdrive)	On left side of transmission, above park/neutral position switch.
Transmission Solenoid Assembly	On left side of transmission, above park/neutral position switch.

Dodge Ram Van B1500 1996 - SWITCHES

Dodge Ram Van B1500 1996 SWITCHES

Component	Component Location
A/C Clutch Cycling Switch	Right side of engine compartment.
A/C Low Pressure Cut-Off Switch	On suction line.
Brake/Stop Lamp Switch	On brake pedal bracket.
Brake Warning Switch	Lower front of engine compartment. See Fig. 6 .
Park/Neutral Position Switch	On left lower side of transmission.
Parking Brake Switch	On parking brake pedal bracket.

Dodge Ram Van B1500 1996 - MISCELLANEOUS

Dodge Ram Van B1500 1996 MISCELLANEOUS

Component	Component Location
Blower Motor Resistor Block (W/Heater Only)	In A/C-heater duct, under right side of dash. See Fig. 7 .
Blower Motor Resistor Block (W/A/C & Heater)	In A/C-heater duct, under right side of dash. See Fig. 8 .
Rear Blower Motor Resistor Block	At rear A/C-heater unit.
Test Connector Data Link (DLC)	Below steering column.

Dodge Ram Van B1500 1996 - CONNECTORS

Dodge Ram Van B1500 1996 CONNECTORS LOCATION

Component	Location
C107 (Black, 2 Pin)	At right fender side shield. See Fig. 3 .
C109 (Black, 14 Pin)	At center of firewall.
C110 (Light Gray, 10 Pin)	At center of firewall.
C115 (Black, 6 Pin)	At right side of firewall.
C118 (Black, 50 Pin)	Between battery & brake booster.
C133 (Black, 14 Pin)	Below starter motor relay.
C137 (Black, 8 Pin)	On front of driver's seat riser.
C157 (Black, 14 Pin)	Near brake booster. See Fig. 5 .
C206 (Black, 4 Pin)	Behind top left side of dash.
C210 (Black, 4 Pin)	Behind left side of dash.
C213 (Black, 3 Pin)	Behind instrument cluster.
C221 (Natural, 4 Pin)	Behind left side of dash.
C234 (Black, 8 Pin)	Behind right side of dash.
C302 (Black, 2 Pin)	Forward of right rear shock absorber.
C303 (Black, 6 Pin)	At center rear of frame.
C304 (Black, 6 Pin)	At left rear of vehicle.
C305 (Black, 2 Pin)	At center rear of frame.
C307 (Black, 6 Pin)	At right rear of vehicle.
C308 (Green, 3 Pin)	Behind left kick panel.
C309 (Red, 2 Pin)	At top of driver's side "B" pillar.
C310 (Black, 3 Pin)	At top of driver's side "B" pillar.
C311 (Black, 4 Pin)	Above driver's side middle & rear windows.
C312 (Black, 4 Pin)	Above driver's side middle & rear windows.
C313 (Red, 2 Pin)	Above driver's side rear window.
C322 (Black, 16 Pin)	Behind left side of dash, near brake pedal.
C400 (Red, 2 Pin)	At front of driver's seat riser.
C411 (Black, 3 Pin)	In front of rear heater.
C412 (Gray/Black, 3 Pin)	Right of left kick panel.

Dodge Ram Van B1500 1996 - GROUNDS

Dodge Ram Van B1500 1996 GROUNDS LOCATION

Component	Location
G100	On right fender side shield.
G103	At left side of firewall. See Fig. 5 .
G104	Near bottom of brake booster.
G105	At brake combination valve bracket.
G106	Behind left side of dash.
G107	At rear of engine.
G108	At rear of engine.
G109 (3.9L)	At A/C compressor. See Fig. 1 .
G109 (5.2L)	At A/C compressor. See Fig. 2 .
G109 (5.9L)	At A/C compressor. See Fig. 2 .
G200	Above headlight switch.
G201	Above headlight switch.
G204	At radio.
G300	At right rear of vehicle.
G301	Behind left kick panel.
G400	Behind rear door panel.
G401	On firewall, at rear of battery.
G402	On front left of engine.
G403	At lower right of dash panel.
G404	Below power seat.
G405	Rear of rear dome/reading light.

Dodge Ram Van B1500 1996 - SPLICES

Dodge Ram Van B1500 1996 SPLICES LOCATION

Component	Location
S100	At right fender side shield.
S101	After breakout to PCM. See Fig. 3 .
S102	Above brake booster. See Fig. 5 .
S103	Above brake booster. See Fig. 5 .
S104	In breakout to bulkhead connector. See Fig. 5 .
S105	In breakout to power distribution center. See Fig. 5 .
S106	Before breakout to left front wheel speed sensor.
S107	After breakout to left front wheel speed sensor.
S108	After breakout to left front wheel speed sensor.
S109	Before breakout to washer pump motor.
S110	In breakout to left headlight.
S111	Near breakout to vehicle speed sensor.
S112	Near breakout to upstream heated oxygen sensor.
S113 (5.2L)	Near breakout to fuel injector No. 7. See Fig. 2 .
S113 (5.9L)	Near breakout to fuel injector No. 7. See Fig. 2 .
S114 (3.9L)	Near breakout to fuel injector No. 4.
S114 (5.2L)	Near breakout to fuel injector No. 4. See Fig. 2 .
S114 (5.9L)	Near breakout to fuel injector No. 4. See Fig. 2 .
S115 (3.9L)	Near breakout to fuel injector No. 3.
S115 (5.2L)	Near breakout to fuel injector No. 3. See Fig. 2 .
S115 (5.9L)	Near breakout to fuel injector No. 3. See Fig. 2 .
S116 (3.9L)	After breakout to fuel injector No. 3.
S116 (5.2L)	After breakout to fuel injector No. 3. See Fig. 2 .
S116 (5.9L)	After breakout to fuel injector No. 3. See Fig. 2 .
S117	After breakout to A/C compressor clutch.
S118	After breakout to A/C compressor clutch.
S119	Before breakout to transmission control relay. See Fig. 5 .
S120	In branch to PCM. See Fig. 5 .
S121	In branch to PCM. See Fig. 5 .
S122	Near breakout to camshaft position sensor.
S123	In breakout to power distribution center. See Fig. 5 .
S125	In power distribution center.
S126	In power distribution center.
S127	In power distribution center.
S128	Near breakout to PCM. See Fig. 3 .
S200	In breakout to stoplight switch.
S201	Before bulkhead connector.
S203	Before bulkhead connector.
S204	Near breakout to headlight switch.
S205	Near breakout to headlight switch.
S206	Near breakout to instrument cluster.
S207	Near breakout to instrument cluster.
S208	Near breakout to instrument cluster.
S209	Near breakout to instrument cluster.
S210	Near breakout to instrument cluster.
S211	Near breakout to instrument cluster.
S213	Near breakout to instrument cluster.
S214	Near breakout to instrument cluster.
S215	In breakout to HVAC switch.
S216	Near breakout to radio.
S217	Before breakout to fuse block.
S218	Before breakout to fuse block.
S219	Before breakout to fuse block.
S220	Before breakout to fuse block.
S221	After breakout to fuse block.
S222	Near breakout to relay bank.
S223	Near breakout to relay bank.
S300	In breakout to dash wiring.
S301	In breakout to dash wiring.
S302	Before breakout to left rear speakers.
S303	After breakout to right rear speakers.
S304	Near breakout to fuel pump module.
S305	Near trailer tow connector.
S306	Near trailer tow connector.
S307	In breakout for right taillight.
S308	Behind left door panel, near door lock motor.
S309	Before grommet in left door.
S310	Before breakout to power mirror switch.
S311	Before breakout to power mirror switch.
S312	Before breakout to door lock.
S313	Before breakout to door lock.
S314	Before breakout to door lock.
S315	After breakout to power door lock module.
S316	In harness, near resistor block.
S317	In harness, near resistor block.
S318	Behind left door panel, near breakout to power mirror.
S401	In breakout to right taillight.
S402	In breakout to right taillight.
S403	In breakout to left taillight.
S404	In breakout to left taillight.
S405	Near power seat.
S407	In jumper for dome lights.
S408	In jumper for dome lights.
S409	In breakout to license plate lights.
S410	In breakout to license plate lights.
S411	In jumper for dome lights.