TRANSMISSION – Ford F550 Super Duty 2007 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

4WD Wiring Diagram for Ford F550 Super Duty 2007

List of elements for 4WD Wiring Diagram for Ford F550 Super Duty 2007:

• (in engine control harness, near breakout to g100) s124
• (in main harness, in breakout to instrument cluster)
• (in main harness, in breakout to instrument cluster) s254
• (in main harness, near breakout to brake pedal position switch)
• (in main harness, near breakout to brake pedal position switch) s205
• (in main harness, near breakout to instrument cluster) s271
• (in main harness, near breakout to restraints control module) s230
• (left side of engine compt) powertrain control module
• (not used)
• 4wd hi
• 4wd hi ind
• 4wd lo
• 4wd lo ind
• 4wd sw
• 87a
• Anti-lock brakes system
• Auxiliary relay box 3 (gasoline: left rear side of engine compt)
• Battery
• Battery junction box (bjb) (left rear of engine compt)
• Bpp sw
• Brake pedal position switch (behind left side of dash, above brake pedal)
• C1381a
• C175b
• C220b
• C270a
• C270h
• C281a
• C281b
• C350a
• C350b
• Central junction box (cjb) (behind lower left side of dash)
• Computer data lines system
• Data link connector (behind left side of dash)
• Diesel
• Electronic shift on the fly (esof) solenoid (right side of engine compt)
• Enc gnd rtn
• Esof sol
• Exterior lights system
• Four-wheel drive control module (behind right side of dash)
• Four-wheel drive switch
• Fuse 10a
• Fuse 15a
• Fuse 30a
• G100 (left rear of engine compt)
• G201 (behind left side of dash)
• G300 (behind left kick panel)
• Gasoline
• Ground
• Hi to lo
• Hot at all times
• Hot in run
• Hot in run or acc
• Hot in run or start
• Illum
• Instrument cluster
• Interior lights system
• Iso bus
• Lo to hi
• Mtr pos 2
• Mtr pos 3
• Mtr pos 4
• Mtr pos 5
• Neut sens
• Off
• Powertrain control module (left side of firewall)
• Pwr to enc
• Red
• Run/acc
• S111 (in engine control sensor harness, near grommet in dash panel)
• S163 (in back up lamp switch harness, near breakout to auxiliary relay box 3)
• S201 (in main harness, near breakout to instrument cluster)
• S208 (in main harness, near breakout to instrument cluster)
• S225 (in main harness, near breakout to instrument cluster)
• S250 (in back-up light switch to rear light feed harness, near breakout to auxiliary relay box 3)
• S257 (in main harness, near breakout to temperature blend door actuator)
• S259
• S268
• Sig rtn
• Transfer case assembly
• Transfer case high to low relay
• Transfer case low to high relay
• Vpwr
• Vss

6.0L DIESEL

6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford F550 Super Duty 2007

List of elements for 6.0L Diesel, A/T Wiring Diagram (1 of 2) for Ford F550 Super Duty 2007:

• (in engine control harness, in breakout to powertrain control module) s117
• (in engine control sensor & fuel charge harness, near breakout to engine coolant temperature sensor) s192
• (in engine control sensor harness, in breakout to abs control module)
• (in engine control sensor harness, in breakout to powertrain control module) s106
• (in engine control sensor harness, near breakout to brake fluid level switch) s115
• (in main harness, near breakout to brake pedal position switch) s258
• (left rear of engine compt)
• (left rear of engine compt) g100
• (left side of engine compt) g101
• Abs control module (left side of engine compt)
• Acc
• Accel pdl sens
• Accelerator pedal position sensor (on accelerator pedal support)
• Anti-lock brakes system
• Aps2
• Aps3
• Battery junction box (bjb) (left rear of engine compt)
• Brake pedal position switch (behind left side of dash, above brake pedal)
• Brake pedal position switch)
• C135
• C1381a
• C1381c
• C220a
• C270a
• C270c
• C270f
• C270h
• Can h
• Can l
• Central junction box (cjb) (behind lower left side of dash)
• Computer data lines system
• Control module) s106
• Coolant temp
• Data link connector (behind left side of dash)
• Engine controls system
• Engine coolant temperature sensor (front of engine)
• Fuse 10a
• Fuse 15a
• Fuse 20a
• G100
• G101 (left side of engine compt)
• Ground
• Hot at all times
• Iat sensor
• Ignition
• Ignition switch
• Instrument cluster
• Lock
• Maf sensor
• Mass airflow (maf) sensor (in air intake tube)
• Near breakout to instrument cluster)
• Off
• Pcm power diode
• Pcm power relay
• Powertrain control module (pcm) (left side of engine compt)
• Prog sig
• Red
• Ref voltage
• Run
• S114
• S123 (in engine control sensor harness, near breakout to c1298)
• S140
• S142 (in engine control sensor harness, in breakout to abs control module)
• S170 (in engine control sensor harness, under battery junction box)
• S213 (in main harness, in breakout to data link connector)
• S221 (in main harness, near breakout to c2186)
• S223 (in main harness, near breakout to air bag sliding contact)
• Signal return
• Start
• Stoplamp sw
• Tan
• Tow/haul sw
• Vbatt
• Vss

6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford F550 Super Duty 2007

List of elements for 6.0L Diesel, A/T Wiring Diagram (2 of 2) for Ford F550 Super Duty 2007:

• (in back-up light switch to rear light feed harness, near breakout to output shaft speed sensor)
• (in back-up light switch to rear light feed harness, near breakout to torqshift transmission)
• (not used)
• C1381b
• C270a
• C270f
• Central junction box (cjb) (behind lower left side of dash)
• Fuse 15a
• Hot in run
• Intermediate shaft speed sensor
• Iss sig
• Lights switch)
• Nca
• Oss sig
• Output shaft speed (oss) sensor (top of transmission) extention housing)
• Pc sol pwr
• Pc-a sol
• Powertrain control module (left side of engine compt)
• Pressure control (pc-a) solenoid
• Ref volt
• Rev lmp ctrl
• Reversing lamp relay
• S127
• S128
• S129
• S235 (in main harness, near breakout to auxiliary relay box 1)
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Sig trn
• Speed sensor assembly (top left side of transmission)
• Sspc-a crl
• Sspc-b ctrl
• Sspc-c crl
• Sspc-d ctrl
• Sspc-e ctrl
• Tcc sol ctrl
• Tft sens sig
• Torqshift transmission
• Torque converter clutch solenoid
• Tow/haul switch
• Tr-p gnd
• Tr-p sig
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Tro
• Tss sig
• Turbine shaft speed sensor

6.8L

6.8L, A/T Wiring Diagram (1 of 2) for Ford F550 Super Duty 2007

List of elements for 6.8L, A/T Wiring Diagram (1 of 2) for Ford F550 Super Duty 2007:

• (4x4: in back-up lamp switch to rear lamp feed harness, near breakout to output shaft speed sensor) (m/t: in back-up lamp switch to rear lamp feed harness, near breakout to reversing lights switch)
• (6.8l: top center of engine)
• (in back-up light switch to rear light feed harness, near breakout to torqshift transmission)
• (in main harness, in breakout to data link connector)
• (top of transmission extension housing) output shaft speed (oss) sensor
• C175a
• C175b
• C175c
• C220b
• Computer data lines system
• Control module)
• Cyl head temp
• Cylinder head temperature sensor (6.8l: on left cylinder head) (5.4l: rear of block, under intake)
• Data link connector (behind left side of dash)
• Electronic throttle control motor (on throttle body)
• Engine controls system
• Etc cntrl
• Etc return
• G102 (right rear of engine compt)
• Hs can +
• Hs can -
• Iat sensor
• Instrument cluster
• Intermediate shaft speed sensor
• Iss sensor
• Maf sensor
• Mass air flow (maf) sensor (left front of engine compt)
• Oss sensor
• Pc sol
• Powertrain control module (left side of firewall)
• Pressure control (pc-a) solenoid
• Prog sig
• Red
• Ref voltage
• S109 (in engine control sensor harness, in breakout to abs control module)
• S127
• S128 (in back-up light switch to rear light feed harness, near breakout to output shaft speed sensor)
• S129
• S143 (in engine control sensor and fuel charge harness, near breakout to mass air flow sensor)
• S146
• S213 (in main harness, in breakout to data link connector)
• S220
• Shift sol
• Shift sol a
• Shift sol b
• Shift sol c
• Shift sol d
• Shift sol e
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Signal return
• Speed sensor assembly (top left side of transmission)
• Tcc sol
• Tft sensor
• Throttle position sensor (5.4l: on throttle body)
• Torqshift transmission
• Torque converter clutch solenoid
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Trs assembly
• Trs sensor
• Tss sensor
• Turbine shaft speed sensor

6.8L, A/T Wiring Diagram (2 of 2) for Ford F550 Super Duty 2007

List of elements for 6.8L, A/T Wiring Diagram (2 of 2) for Ford F550 Super Duty 2007:

• (in engine control sensor and fuel charge harness, near breakout to fuel injector 8) s137
• (in engine control sensor harness, in breakout to power- train control module) s106
• (in engine control sensor harness, near breakout to brake fluid level switch) s115
• (in engine control sensor harness, near breakout to c1756) s123
• (in main harness, near breakout to air bag sliding contact)
• (in main harness, near breakout to c2186)
• (not used)
• 5.4l
• 6.8l
• Abs control module (left rear of engine compt)
• Acc
• Accelerator pedal position (app) sensor (on accelerator pedal support)
• Anti-lock brakes system
• App sensor 1 sig
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (bjb) (left rear of engine compt)
• Bpp sw
• Brake pedal position switch (behind left side of dash, above brake pedal)
• C135
• C175b
• C2256
• C270a
• C270c
• C270f
• C270h
• Central junction box (cjb) (behind lower left side of dash)
• Engine controls system
• Fuse 10a
• Fuse 15a
• Fuse 20a
• G100 (left rear of engine compt)
• G102 (right rear of engine compt)
• G102 (rightt rear of engine compt)
• Ground
• Hot at all times
• Ignition (st/run)
• Ignition switch
• Lock
• Near breakout to brake pedal position switch)
• Near breakout to instrument cluster)
• Off
• Pcm power diode
• Pcm power relay
• Pedal position switch)
• Powertrain control module (left side of firewall)
• Red
• Run
• S106 (in engine control sensor harness, in breakout to powertrain control module)
• S127 (4x4: in back-up lamp switch to rear lamp feed harness, near breakout to output shaft speed sensor) (m/t: in back-up lamp switch to rear lamp feed harness, near breakout to reversing lights switch)
• S164 (in engine control sensor harness, in breakout to c140)
• S221
• S223
• Signal return
• Start
• Tan
• Vbatt
• Voltage reference
• Vss sig