TRANSMISSION
5.2L
5.2L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO List of elements for 5.2L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997:
- (eng harn, in branch to controller anti-lock brakes)
- (front of engine) g125
- (i/p right center support, near radio) g206
- (left bottom of dash)
- (left fender side shield) g100
- 4wd ind
- 4wd sense
- 4wd switch (on front axle tube)
- A/c compressor relay, fuel pump relay
- A14
- A16
- A17
- A22
- A23
- A31
- A32
- Abs
- Air bag system control module & message center
- B11
- B21
- B25
- B27
- B28
- B29
- B30
- B31
- Brake sw sense
- C13
- C17
- C24
- C25
- C27
- C29
- Connector
- Controller anti-lock brake (abs)
- Controller anti-lock brake (behind (center of dash)
- D20
- D21
- Data link connector (partial)
- Ect sens sig
- Engine controls system
- Engine diagnostic
- F18
- Fog lamp switch
- Fuse 10a
- Fuse 15a
- Fuse 5a
- Fuse block
- Fused b(+)
- Fused ign (st/run)
- G107
- G206 (i/p right center support, near radio)
- Generator output
- Gnd
- Gov press sig
- Hot at all times
- Hot in run or start
- Hot w/headlamp switch in park or head position (rheostat controlled)
- If equipped
- Illum
- Ind
- Instrument cluster
- Joint connector c (behind knee bolster)
- Joint connector c (pin 5) (interior light system)
- K125
- K22
- K30
- K54
- K88
- Mil driversense
- Mil ind
- Od lamp driver
- Od sol ctrl
- Ou shft spd sig
- Out shaft spd gnd
- Overdrive switch
- Pnk
- Pnp sw sense
- Powertrain control module (in eng compt, on right side of dash panel)
- Rwal
- S103
- S105 (eng harn, in branch for horn breakout)
- S111
- S114
- S132
- S139
- S208
- S209
- S215
- Sc1 receive
- Sci transmit
- Sensor gnd
- Stop lamp switch (top of brake pedal bracket)
- T13
- T14
- T18
- T25
- T41
- T54
- T60
- Tcc sol ctrl
- Tp sens sig
- Trans od sw sense
- Trans rly ctrl
- Trans temp sens
- Transmission output shaft speed sensor (on left side of transmission)
- V40
- Var sol ctrl
- Vss signal
- Z12
5.2L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 5.2L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997:
- (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
- (eng harn, near branch to fuel inj 2,4,6,8 or 10) s129
- (eng harn, near branch to fuel injectors 2,4,6,8 or 10)
- Engine controls system
- Engine coolant temperature sensor (between generator & a/c compressor)
- Engine starter motor relay
- Fuel pump relay
- Fuse 20a
- Generator
- Governor pressure signal
- Hot at all times
- Instrument cluster (speedometer)
- Overdrive solenoid control
- Park/ neutral position switch (on left side of transmission)
- Pnk
- Power distribution center
- Power distribution center
- Red
- S130
- S136 (eng harn, 3.9l, 5.2l & 5.9l: near crankshaft position sensor breakout, 8.0l: between fuel inj 5 & 7 breakout)
- S137 (eng harn, 3.9l, 5.2l, & 5.9l: near distributor breakout; 8.0l: near breakout to idle air control motor)
- S141 (eng harn, 3.9l 5.2l & 5.9l: in branch to trans wiring harn; 8.0l: before branch to oxygen & vehicle speed sensor)
- S154 (eng harn, before branch to fuel inj 1,3,5,7 or 9)
- S163
- Sensor ground
- Throttle position sensor (on throttle body)
- Torque converter clutch solenoid control
- Trans ctrl rly output
- Transmission control relay
- Transmission solenoid assembly (transmission)
- Transmission temperature sensor signal
- Variable force solenoid control
- Vehicle speed sensor (2wd: on left side of transmission extension housing, 4wd: on left side of transfer case)
5.9L
5.9L Turbo Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 5.9L Turbo Diesel, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997:
- (eng harn, in branch to controller anti-lock brakes)
- (front of engine) g125
- (i/p right center support, near radio) g206
- (left bottom of dash)
- (left fender side shield) g100
- (on left side of transmission) transmission output shaft speed sensor
- 4wd ind
- 4wd sense
- 4wd switch (on front axle tube)
- A/c compressor relay, fuel pump relay
- A14
- A16
- A17
- A22
- A23
- A31
- A32
- Abs
- Air bag system control module & message center
- B11
- B21
- B25
- B27
- B28
- B29
- B30
- B31
- Brake sw sense
- C13
- C17
- C24
- C25
- C27
- C29
- Connector
- Controller anti-lock brake (abs)
- Controller anti-lock brake (behind (center of dash)
- D20
- D21
- Data link connector (partial)
- Ect sens sig
- Eng speed sens sig
- Engine controls system
- Engine diagnostic
- F18
- Fog lamp switch
- Fuse 10a
- Fuse 15a
- Fuse 5a
- Fuse block
- Fused b(+)
- Fused ign (st/run)
- G107
- G206 (i/p right center support, near radio)
- Generator output
- Gnd
- Gov press sig
- Hot at all times
- Hot in run or start
- Hot w/headlamp switch in park or head position (rheostat controlled)
- If equipped
- Illum
- Ind
- Instrument cluster
- Joint connector c (behind knee bolster)
- Joint connector c (pin 5) (interior light system)
- K125
- K22
- K24
- K30
- K54
- K88
- Mil ind
- Mil ind driver
- Od lamp driver
- Od sol ctrl
- Ou shft spd sig
- Out shaft spd gnd
- Overdrive switch
- Pnk
- Pnp sw sense
- Powertrain control module (in eng compt, on right side of dash panel)
- Rwal
- S103
- S105 (eng harn, in branch for horn breakout)
- S111
- S114
- S132
- S139
- S208
- S209
- S215
- Sc1 receive
- Sci transmit
- Sensor gnd
- Stop lamp switch (top of brake pedal bracket)
- T13
- T14
- T18
- T25
- T41
- T54
- T60
- Tcc sol ctrl
- Tp sens sig
- Trans od sw sense
- Trans rly ctrl
- Trans temp sens
- V40
- Var sol ctrl
- Vss signal
- Z12
5.9L Turbo Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 5.9L Turbo Diesel, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997:
- (eng harn, after engine coolant temp sending unit
- (eng harn, before pcm) s131
- (eng harn, near distributor)
- Breakout) s130
- Egr control module
- Engine controls system
- Engine coolant temperature sensor (between generator & a/c compressor)
- Engine speed sensor (on front of eng, in timing chain case/cover)
- Engine starter motor relay
- Fuel pump relay
- Fuse 20a
- Generator
- Governor pressure signal
- Hot at all times
- Instrument cluster (speedometer)
- Overdrive solenoid control
- Park/ neutral position switch (on left side of transmission)
- Pnk
- Power distribution center
- Power distribution center
- Red
- S137
- S141 (eng harn, before pcm)
- S157 (eng harn, between intake air heater & fuel heater breakout)
- S159 (eng harn, before pcm)
- S161
- S162
- Sensor ground
- Throttle position sensor (on top of injector pump)
- Torque converter clutch solenoid control
- Trans ctrl rly output
- Transmission control relay
- Transmission solenoid assembly (transmission)
- Transmission temperature sensor signal
- Variable force solenoid control
- Vehicle speed sensor (2wd: on left side of transmission extension housing, 4wd: on left side of transfer case)
- W/ egr cotrol module
- W/o egr cotrol module
5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 5.9L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997:
- (eng harn, in branch to controller anti-lock brakes)
- (front of engine) g125
- (i/p right center support, near radio) g206
- (left bottom of dash)
- (left fender side shield) g100
- 4wd ind
- 4wd sense
- 4wd switch (on front axle tube)
- A/c compressor relay, fuel pump relay
- A14
- A16
- A17
- A22
- A23
- A31
- A32
- Abs
- Air bag system control module & message center
- B11
- B21
- B25
- B27
- B28
- B29
- B30
- B31
- Brake sw sense
- C13
- C17
- C24
- C25
- C27
- C29
- Connector
- Controller anti-lock brake (abs)
- Controller anti-lock brake (behind (center of dash)
- D20
- D21
- Data link connector (partial)
- Ect sens sig
- Engine controls system
- Engine diagnostic
- F18
- Fog lamp switch
- Fuse 10a
- Fuse 15a
- Fuse 5a
- Fuse block
- Fused b(+)
- Fused ign (st/run)
- G107
- G206 (i/p right center support, near radio)
- Generator output
- Gnd
- Gov press sig
- Hot at all times
- Hot in run or start
- Hot w/headlamp switch in park or head position (rheostat controlled)
- If equipped
- Illum
- Ind
- Instrument cluster
- Joint connector c (behind knee bolster)
- Joint connector c (pin 5) (interior light system)
- K125
- K22
- K30
- K54
- K88
- Mil driversense
- Mil ind
- Od lamp driver
- Od sol ctrl
- Ou shft spd sig
- Out shaft spd gnd
- Overdrive switch
- Pnk
- Pnp sw sense
- Powertrain control module (in eng compt, on right side of dash panel)
- Rwal
- S103
- S105 (eng harn, in branch for horn breakout)
- S111
- S114
- S132
- S139
- S208
- S209
- S215
- Sc1 receive
- Sci transmit
- Sensor gnd
- Stop lamp switch (top of brake pedal bracket)
- T13
- T14
- T18
- T25
- T41
- T54
- T60
- Tcc sol ctrl
- Tp sens sig
- Trans od sw sense
- Trans rly ctrl
- Trans temp sens
- Transmission output shaft speed sensor (on left side of transmission)
- V40
- Var sol ctrl
- Vss signal
- Z12
5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 5.9L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997:
- (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
- (eng harn, near branch to fuel inj 2,4,6,8 or 10) s129
- (eng harn, near branch to fuel injectors 2,4,6,8 or 10)
- Engine controls system
- Engine coolant temperature sensor (between generator & a/c compressor)
- Engine starter motor relay
- Fuel pump relay
- Fuse 20a
- Generator
- Governor pressure signal
- Hot at all times
- Instrument cluster (speedometer)
- Overdrive solenoid control
- Park/ neutral position switch (on left side of transmission)
- Pnk
- Power distribution center
- Power distribution center
- Red
- S130
- S136 (eng harn, 3.9l, 5.2l & 5.9l: near crankshaft position sensor breakout, 8.0l: between fuel inj 5 & 7 breakout)
- S137 (eng harn, 3.9l, 5.2l, & 5.9l: near distributor breakout; 8.0l: near breakout to idle air control motor)
- S141 (eng harn, 3.9l 5.2l & 5.9l: in branch to trans wiring harn; 8.0l: before branch to oxygen & vehicle speed sensor)
- S154 (eng harn, before branch to fuel inj 1,3,5,7 or 9)
- S163
- Sensor ground
- Throttle position sensor (on throttle body)
- Torque converter clutch solenoid control
- Trans ctrl rly output
- Transmission control relay
- Transmission solenoid assembly (transmission)
- Transmission temperature sensor signal
- Variable force solenoid control
- Vehicle speed sensor (2wd: on left side of transmission extension housing, 4wd: on left side of transfer case)
8.0L
8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 8.0L, Transmission Wiring Diagram (1 of 2) for Dodge Cab & Chassis R3500 1997:
- (eng harn, in branch to controller anti-lock brakes)
- (front of engine) g125
- (i/p right center support, near radio) g206
- (left bottom of dash)
- (left fender side shield) g100
- 4wd ind
- 4wd sense
- 4wd switch (on front axle tube)
- A/c compressor relay, fuel pump relay
- A14
- A16
- A17
- A22
- A23
- A31
- A32
- Abs
- Air bag system control module & message center
- B11
- B21
- B25
- B27
- B28
- B29
- B30
- B31
- Brake sw sense
- C13
- C17
- C24
- C25
- C27
- C29
- Connector
- Controller anti-lock brake (abs)
- Controller anti-lock brake (behind (center of dash)
- D20
- D21
- Data link connector (partial)
- Ect sens sig
- Engine controls system
- Engine diagnostic
- F18
- Fog lamp switch
- Fuse 10a
- Fuse 15a
- Fuse 5a
- Fuse block
- Fused b(+)
- Fused ign (st/run)
- G107
- G206 (i/p right center support, near radio)
- Generator output
- Gnd
- Gov press sig
- Hot at all times
- Hot in run or start
- Hot w/headlamp switch in park or head position (rheostat controlled)
- If equipped
- Illum
- Ind
- Instrument cluster
- Joint connector c (behind knee bolster)
- Joint connector c (pin 5) (interior light system)
- K125
- K22
- K30
- K54
- K88
- Mil driversense
- Mil ind
- Od lamp driver
- Od sol ctrl
- Ou shft spd sig
- Out shaft spd gnd
- Overdrive switch
- Pnk
- Pnp sw sense
- Powertrain control module (in eng compt, on right side of dash panel)
- Rwal
- S103
- S105 (eng harn, in branch for horn breakout)
- S111
- S114
- S132
- S139
- S208
- S209
- S215
- Sc1 receive
- Sci transmit
- Sensor gnd
- Stop lamp switch (top of brake pedal bracket)
- T13
- T14
- T18
- T25
- T41
- T54
- T60
- Tcc sol ctrl
- Tp sens sig
- Trans od sw sense
- Trans rly ctrl
- Trans temp sens
- Transmission output shaft speed sensor (on left side of transmission)
- V40
- Var sol ctrl
- Vss signal
- Z12
8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997
List of elements for 8.0L, Transmission Wiring Diagram (2 of 2) for Dodge Cab & Chassis R3500 1997:
- (after branch to fuel injectors 2,4,6,8 & (10)) (3.9l, 5.2l, 5.2l cng, 5.9l & 8.0l engines) s131
- (eng harn, near branch to fuel inj 2,4,6,8 or 10) s129
- (eng harn, near branch to fuel injectors 2,4,6,8 or 10)
- Engine controls system
- Engine coolant temperature sensor (between generator & a/c compressor)
- Engine starter motor relay
- Fuel pump relay
- Fuse 20a
- Generator
- Governor pressure signal
- Hot at all times
- Instrument cluster (speedometer)
- Overdrive solenoid control
- Park/ neutral position switch (on left side of transmission)
- Pnk
- Power distribution center
- Power distribution center
- Red
- S130
- S136 (eng harn, 3.9l, 5.2l & 5.9l: near crankshaft position sensor breakout, 8.0l: between fuel inj 5 & 7 breakout)
- S137 (eng harn, 3.9l, 5.2l, & 5.9l: near distributor breakout; 8.0l: near breakout to idle air control motor)
- S141 (eng harn, 3.9l 5.2l & 5.9l: in branch to trans wiring harn; 8.0l: before branch to oxygen & vehicle speed sensor)
- S154 (eng harn, before branch to fuel inj 1,3,5,7 or 9)
- S163
- Sensor ground
- Throttle position sensor (on throttle body)
- Torque converter clutch solenoid control
- Trans ctrl rly output
- Transmission control relay
- Transmission solenoid assembly (transmission)
- Transmission temperature sensor signal
- Variable force solenoid control
- Vehicle speed sensor (2wd: on left side of transmission extension housing, 4wd: on left side of transfer case)