AIR CONDITIONING – Jeep Wrangler Unlimited Rubicon 2005 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Heater Wiring Diagram for Jeep Wrangler Unlimited Rubicon 2005

List of elements for Heater Wiring Diagram for Jeep Wrangler Unlimited Rubicon 2005:

• (behind left end of dash) g200
• (behind right end of dash) g202
• Blend door actuator (near hvac harness)
• Blower motor (near hvac harness)
• Blower motor relay (on hvac) (near hvac harness)
• Blower motor resistor block (near hvac harness)
• Defrost
• Fuse 10a
• Fuse 40a
• Fuse block (under right center of dash)
• G202 (behind right end of dash)
• Heat
• Heater control
• High
• Hot at all times
• Hot in on
• Interior lights system
• Low
• Mix
• Off
• Power distribution center (on right side of engine compartment)
• S207
• S208 (near breakout to blower motor)
• Tan
• Vent

Manual A/C Wiring Diagram for Jeep Wrangler Unlimited Rubicon 2005

List of elements for Manual A/C Wiring Diagram for Jeep Wrangler Unlimited Rubicon 2005:

• (2.4l)
• (behind left end of dash) g200
• (behind right end of dash) g202
• (behind right end of dash) g203
• (in power distribution center) (2.4l) high speed radiator fan relay
• (left rear of engine) (4.0l) s130 s176 (2.4l) (in fuel injector harness)
• (left side of engine compt) daytime running lamp module
• (near breakout to blower motor) s208
• (near breakout to g101) s103
• (near compressor) (2.4l) a/c pressure transducer
• 2.4l
• 4.0l
• A/c comp relay ctrl
• A/c compressor clutch (2.4l: right front of engine) (4.0l: lower left front of engine)
• A/c compressor clutch relay (in power distribution center)
• A/c high pressure switch (near left side of engine)
• A/c low pressure switch (2.4l: on a/c accumulator) (4.0l: near powertrain control module)
• A/c pressure signal
• A/c request signal
• A/c select input
• A/c- heater control
• A10
• Blend door actuator (near hvac harness)
• Blower motor (near hvac harness)
• Blower motor relay (on hvac) (near hvac harness)
• Blower motor resistor block (near hvac harness)
• C13
• C18
• C20
• C221
• D10
• D11
• D13
• D14
• Defrost
• Ect sensor
• Engine coolant temperature sensor (on thermostat housing)
• F856
• Fuse 10a
• Fuse 40a
• Fuse block (under right center of dash)
• G105 (2.4l: near left engine mount) (4.0l: right rear of engine block)
• G200 (behind left end of dash)
• G203 (behind right end of dash)
• Heat
• High
• High speed radiator
• Hot at all times
• Hot in on
• Hot in on or start
• Interior lights system
• K900
• Low
• Low speed radiator
• Low speed radiator fan relay (in power distribution center)
• Max
• Mix
• N112
• N201
• Nca
• Norm
• Off
• Power distribution center (on right side of engine compt)
• Powertrain control module (right rear of engine compt)
• Radiator fan motor (on right side of radiator fan shroud)
• Radiator fan motor circuit breaker (on right radiator fan shroud)
• Red
• S102 (4.0l)
• S129 (rear of engine)
• S132
• S147 (near breakout to underhood lamp)
• S180
• S207
• Sensor ground
• Tan
• Vacuum/ electric mode switch
• Vent