ENGINE PERFORMANCE – Ford Bronco 1996 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

5.0L

5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (1 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (1 of 4) for Ford Bronco 1996:

• (49 state only)
• (not used)
• A/c clutch sig
• Air conditioning system
• Aird solenoid
• Case gnd
• Ckp sensor
• Coil
• Data link (+)
• Data link (-)
• Data link connector
• Data link feps
• Distributor (top front of engine)
• Distributor ignition shield
• Ect sens
• Egr solnd ctrl
• Engine compartment fuse box (left side of engine compartment)
• Fuel pump mon
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front radiator support)
• G203 (right kick panel)
• Hot at all times
• Hot in start or run
• Iat sens
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left rear of engine, near intake manifold)
• Ignition control module (left rear side of engine compartment, on fender apron)
• Low rnge 4x4
• Maf sig rtn
• Mil
• Misfire sens
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Power
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Pwr grd
• Radio capacitor (left side of engine, near coil)
• Red
• Red/
• Rr ho2s sig
• Spark output check connector (left rear of engine compartment, near icm)
• Spout
• Trans ctrl sw
• Trans temp
• Trans- missions system (4x4 hi/low indicator switch)
• Tss 1
• Tss 2
• Vss (-)

5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (2 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (2 of 4) for Ford Bronco 1996:

• C250
• C251
• C252
• Delta pressure feedback egr sensor (top right front of engine)
• Engine compartment fuse box (left side of engine compartment)
• Engine coolant temperature sensor (top left front of engine)
• Fuel pump relay
• Fuse 20a
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (top center front of engine, near intake runner #6)
• Malfunction indicator input
• Misfire sensor (center front of engine, on timing chain cover)
• Nca
• Output shaft speed sensor (left rear of transmission)
• Psom vehicle speed output
• Red
• Rpm input
• Throttle position sensor (top right front of engine, on throttle body)

5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (3 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (3 of 4) for Ford Bronco 1996:

• (49 state only)
• 4r70w transmission
• Egr vacuum regulator solenoid (top left of engine on coil support bracket)
• Electronic pressure control solenoid
• Fuel pump/ fuel gauge sender (top right of tank)
• G108 (left front radiator support)
• Idle air control valve (top right front of engine)
• Inertia fuel shutoff switch (right kick panel)
• Injectors fuel
• Nca
• Power
• Red
• Secondary air injection bypass (airb) solenoid (top left rear of engine)
• Secondary air injection diverter (aird) solenoid (top left rear of engine)
• Shift solnd #1
• Shift solnd #2
• Signal return
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (rear center of engine compartment)

5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (4 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with 4R70W Transmission (4 of 4) for Ford Bronco 1996:

• (not used)
• Airb solenoid
• Batt
• Brake on/off
• Brake on/off (boo) switch (under left side of i/p)
• Dpfe sens
• Epc sol
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 10a
• Fuse 15a
• Fuse panel (left side of i/p)
• G101 (right fender apron, right side of battery)
• H02s heater ctrl
• Hot at all times
• Hot in run or start
• Iac sol
• Left heated oxygen sensor (lower left rear of engine)
• Lf ho2s sig
• Maf sens in
• Mass air flow sensor (right front side of engine compartment)
• Misfire in
• Nca
• Power
• Power gnd
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Rear heated oxygen sensor (near catalytic converter)
• Red
• Ref volt
• Rf ho2s sig
• Right heated oxygen sensor (lower right rear of engine)
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens in
• Trans ctrl ind
• Trans shft spd
• Trans- mission control switch (top of steering column)
• Transmission range sensor (lower left side of transmission)
• Vapor valve
• Vss (+)

5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (1 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (1 of 4) for Ford Bronco 1996:

• (49 state only)
• (not used)
• A/c clutch sig
• Air conditioning system
• Aird solenoid
• Case gnd
• Ckp sensor
• Coil
• Data link (+)
• Data link (-)
• Data link connector
• Data link feps
• Distributor (top front of engine)
• Distributor ignition shield
• Ect sens
• Egr solnd ctrl
• Engine compartment fuse box (left side of engine compartment)
• Fuel pump mon
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front radiator support)
• G203 (right kick panel)
• Hot at all times
• Hot in start or run
• Iat sens
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left rear of engine, near intake manifold)
• Ignition control module (left rear side of engine compartment, on fender apron)
• Low rnge 4x4
• Maf sig rtn
• Mil
• Misfire sens
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Power
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Pwr grd
• Radio capacitor (left side of engine, near coil)
• Red
• Red/
• Rr ho2s sig
• Spark output check connector (left rear of engine compartment, near icm)
• Spout
• Trans ctrl sw
• Trans temp
• Trans- missions system (4x4 hi/low indicator switch)
• Tss 1
• Tss 2
• Vss (-)

5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (2 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (2 of 4) for Ford Bronco 1996:

• (not used)
• C250
• C251
• C252
• Delta pressure feedback egr sensor (top right front of engine)
• Engine compartment fuse box (left side of engine compartment)
• Engine coolant temperature sensor (top left front of engine)
• Fuel pump relay
• Fuse 20a
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (top center front of engine, near intake runner #6)
• Malfunction indicator input
• Misfire sensor (center front of engine, on timing chain cover)
• Nca
• Psom vehicle speed output
• Red
• Rpm input
• Throttle position sensor (top right front of engine, on throttle body)

5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (3 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (3 of 4) for Ford Bronco 1996:

• (49 state only)
• Coast clutch solenoid
• E4od transmission
• Egr vacuum regulator solenoid (top left of engine on coil support bracket)
• Electronic pressure control solenoid
• Fuel pump/ fuel gauge sender (top right of tank)
• G108 (left front radiator support)
• Idle air control valve (top right front of engine)
• Inertia fuel shutoff switch (right kick panel)
• Injectors fuel
• Nca
• Red
• Secondary air injection bypass (airb) solenoid (top left rear of engine)
• Secondary air injection diverter (aird) solenoid (top left rear of engine)
• Shift solenoids
• Ss1
• Ss2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (rear center of engine compartment)

5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (4 of 4) for Ford Bronco 1996

List of elements for 5.0L, Engine Performance Wiring Diagrams, with E4OD Transmission (4 of 4) for Ford Bronco 1996:

• (not used)
• Airb solenoid
• Batt
• Brake on/off
• Brake on/off (boo) switch (under left side of i/p)
• Coast clutch
• Dpfe sens
• Epc sol
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 10a
• Fuse 15a
• Fuse panel (left side of i/p)
• G101 (right fender apron, right side of battery)
• H02s heater ctrl
• Hot at all times
• Hot in run or start
• Iac sol
• Left heated oxygen sensor (lower left rear of engine)
• Lf ho2s sig
• Maf sens in
• Mass air flow sensor (right front side of engine compartment)
• Misfire in
• Nca
• Power
• Power gnd
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Rear heated oxygen sensor (near catalytic converter)
• Red
• Ref volt
• Rf ho2s sig
• Right heated oxygen sensor (lower right rear of engine)
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens in
• Trans ctrl ind
• Trans- mission control switch (top of steering column)
• Transmission range sensor (lower left side of transmission)
• Vapor valve
• Vss (+)

5.8L

5.8L, Engine Performance Wiring Diagrams (1 of 4) for Ford Bronco 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams (1 of 4) for Ford Bronco 1996:

• (not used)
• A/c clutch sig
• Air conditioning system
• Case gnd
• Ckp sensor
• Coil
• Data link (+)
• Data link (-)
• Data link connector
• Data link feps
• Distributor (top front of engine)
• Distributor ignition shield
• Ect sens
• Egr solnd ctrl
• Engine compartment fuse box (left side of engine compartment)
• Fuel pump mon
• Fuse 20a
• Fuse 30a
• G104 (rear of left fender apron)
• G108 (left front radiator support)
• G203 (right kick panel)
• Hot at all times
• Hot in start or run
• Iat sens
• Idm
• Idm (fto)
• Ign gnd
• Ignition coil (left rear of engine, near intake manifold)
• Ignition control module (left rear side of engine compartment, on fender apron)
• Low rnge 4x4
• Maf sig rtn
• Mil
• Misfire sens
• Nca
• Pcm power diode
• Pcm power relay
• Pip
• Pnk
• Power
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Pwr grd
• Radio capacitor (left side of engine, near coil)
• Red
• Red/
• Rr ho2s sig
• Spark output check connector (left rear of engine compartment, near icm)
• Spout
• Trans ctrl sw
• Trans temp
• Trans- missions system (4x4 hi/low indicator switch)
• Tss 1
• Tss 2
• Vss (-)

5.8L, Engine Performance Wiring Diagrams (2 of 4) for Ford Bronco 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams (2 of 4) for Ford Bronco 1996:

• (not used)
• C250
• C251
• C252
• Delta pressure feedback egr sensor (top right front of engine)
• Engine compartment fuse box (left side of engine compartment)
• Engine coolant temperature sensor (top left front of engine)
• Fuel pump relay
• Fuse 20a
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (top center front of engine, near intake runner #6)
• Malfunction indicator input
• Misfire sensor (center front of engine, on timing chain cover)
• Nca
• Psom vehicle speed output
• Red
• Rpm input
• Throttle position sensor (top right front of engine, on throttle body)

5.8L, Engine Performance Wiring Diagrams (3 of 4) for Ford Bronco 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams (3 of 4) for Ford Bronco 1996:

• Coast clutch solenoid
• E4od transmission
• Egr vacuum regulator solenoid (top left of engine on coil support bracket)
• Electronic pressure control solenoid
• Fuel injectors
• Fuel pump/ fuel gauge sender (top right of tank)
• G108 (left front radiator support)
• Idle air control valve (top right front of engine)
• Inertia fuel shutoff switch (right kick panel)
• Nca
• Red
• Shift solenoids
• Ss1
• Ss2
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve (rear center of engine compartment)

5.8L, Engine Performance Wiring Diagrams (4 of 4) for Ford Bronco 1996

List of elements for 5.8L, Engine Performance Wiring Diagrams (4 of 4) for Ford Bronco 1996:

• (not used)
• Batt
• Brake on/off
• Brake on/off (boo) switch (under left side of i/p)
• Coast clutch
• Dpfe sens
• Epc sol
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuse 10a
• Fuse 15a
• Fuse panel (left side of i/p)
• G101 (right fender apron, right side of battery)
• H02s heater ctrl
• Hot at all times
• Hot in run or start
• Iac sol
• Left heated oxygen sensor (lower left rear of engine)
• Lf ho2s sig
• Maf sens in
• Mass air flow sensor (right front side of engine compartment)
• Misfire in
• Nca
• Power
• Power gnd
• Powertrain control module (top left side of safety wall)
• Pwr gnd
• Rear heated oxygen sensor (near catalytic converter)
• Red
• Ref volt
• Rf ho2s sig
• Right heated oxygen sensor (lower right rear of engine)
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Tr sens in
• Trans ctrl ind
• Trans- mission control switch (top of steering column)
• Transmission range sensor (lower left side of transmission)
• Vapor valve
• Vss (+)