TRANSMISSION – Ford Ranger 2006 – SYSTEM WIRING DIAGRAMS

TRANSMISSION

4WD Wiring Diagram for Ford Ranger 2006

List of elements for 4WD Wiring Diagram for Ford Ranger 2006:

• (2.3l: on top of engine)
• (4.0l: in engine control sensor & fuel charge harness, at breakout for powertrain control module) (3.0l: in pcm harness)
• (at left front of vehicle floor) g205
• (in main harness, at left side of dash) s236
• (in main harness, behind center of dash)
• (in main harness, behind center of dash) s220
• (in main harness, near breakout for instrument cluster) s213
• (left side of engine compartment)
• 2.3l
• 4wd hi
• 4wd hi ind
• 4wd lo
• 4wd lo ind
• 4wd switch
• A/t
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp switch
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C2280a
• C2280b
• C2280c
• C281a
• C281b
• Clutch pedal position switch (behind left side of dash, top of brake pedal support)
• Computer data lines system
• Cruise control system
• Data link connector (dlc) (at bottom of steering column)
• Digital transmission range (dtr) sensor (left side of transmission)
• Door ajar
• Except 2.3l
• Four-wheel drive control module (behind left center of dash)
• Four-wheel drive switch
• Fuse 10a
• Fuse 15a
• Fuse 20a
• Fuse 5a
• G106 (at top rear of engine compt)
• G204 (under front of center console)
• G205 (at left front of vehicle floor)
• Gearmotor encoder assembly (on transfer case)
• Ground
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start
• Ign (run)
• Ign (st/run)
• Illum
• Instrument cluster
• Instrument cluster system
• Interior lights system
• Interior lights system (dimmer)
• Iso bus
• Left side of dash)
• Low current board
• M/t
• Main light switch
• Micro- processor
• Motor 1
• Motor 2
• Motor 3
• Motor 4
• Motor 5
• Neutral ind
• Neutral sens
• Neutral tow indicator
• Off
• Park
• Pnk
• Powertrain control module (pcm) (right rear of engine compt)
• S116
• S145
• S200 (in main harness, near breakout for center of dash)
• S203
• S208 (in main harness, near breakout for audio unit)
• S209
• S216 (in main harness, behind center of dash)
• S223 (in main harness, near breakout for left side of dash)
• S227
• S258 (in main harness, at left side of dash)
• Sig return
• Smart junction box (sjb) (behind right side of dash)
• Starter relay
• Tan/ red
• Tan/red
• Transfer case
• Vss input

2.3L

2.3L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006

List of elements for 2.3L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006:

• (left side of engine compt)
• (dlc) (at bottom of steering column)
• (in engine control sensor & fuel charge harness)
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 4)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (on top of engine)
• 5r44e transmission control solenoids (at left side of transmission)
• A/t
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Cht
• Data link connector
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Feps
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Harness, at left side of dash)
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left side of transmission)
• Iss
• Junction harness, near breakout to abs control module)
• M/t
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (a/t: on left rear of transmission) (m/t: at left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compt)
• Prndl
• Processor
• Ptc 1a
• Red
• S107 (on top of engine)
• S113
• S143
• S148
• S149
• S150 (on top of engine)
• S153
• S154
• S236 (in main harness, at left side of dash)
• Scp +
• Scp -
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

2.3L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006

List of elements for 2.3L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006:

• (at top rear of engine)
• (in engine control sensor & fuel charge harness, near breakout for idle air valve)
• (left side of engine compartment) s118
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (left rear side of engine compt)
• Cylinder head temperature (cht) sensor (on right side of cylinder head)
• Engine controls system
• G104 (at left front of engine compt)
• Pcm power relay
• R p
• Red
• S137
• S151
• S152 (in engine control sensor & fuel charge harness, near breakout for transmission)
• Throttle position (tp) sensor (top right side of engine, on throttle body)

3.0L

3.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006

List of elements for 3.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006:

• (dlc) (at bottom of steering column)
• (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• (in engine control sensor & fuel charge harness, near breakout for camshaft position sensor)
• (in engine control sensor & fuel charge harness, near breakout for heated oxygen sensor 21)
• (left side of engine compartment)
• (on top of transmission)
• 5r44e transmission control solenoids (at left side of transmission)
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Data link connector
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Feps
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Harness, at left side of dash)
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left side of transmission)
• Iss
• Junction harness, near breakout to abs control module)
• M/t a/t
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (a/t: on left rear of transmission) (m/t: at left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compt)
• Prndl
• Processor
• Ptc 1a
• Red
• S100
• S104
• S106
• S107 (in pcm harness)
• S113
• S129 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S143
• S236 (main harness,
• Scp +
• Scp -
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

3.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006

List of elements for 3.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006:

• (in engine control sensor & fuel charge harness, near breakout for fuel injector 5)
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 6)
• (left side of engine compartment) s118
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (at left rear side of engine compt)
• Engine controls system
• Engine coolant temperature (ect) sensor (on top front of engine, near thermostat housing)
• G104 (at left front of engine compt)
• Pcm power relay
• R p
• Red
• S137
• S139
• Throttle position (tp) sensor (top left front of engine, on throttle body)

4.0L

4.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006

List of elements for 4.0L, A/T Wiring Diagram (1 of 2) for Ford Ranger 2006:

• (dlc) (at bottom of steering column)
• (in engine control sensor & fuel charge harness, near breakout for ignition coil)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (in engine control sensor & fuel charge harness, near breakout to heated oxygen sensor 11)
• (in pcm harness)
• (left side of engine compt) s113
• (on top of transmission)
• 5r55e transmission control solenoids (at left side of transmission)
• Anti-lock brakes system
• Battery junction box (bjb) (at left rear side of engine compt)
• Bpp
• Brake pedal position switch (behind left side of dash, on brake pedal support)
• C220a
• C220b
• C2280a
• C2280b
• C2280c
• Check engine ind
• Data link connector
• Dlc
• Dlc (+)
• Dlc (-)
• Ect
• Electronic pressure control (epc) solenoid
• Engine controls system
• Epc
• Exterior lights system
• Fuse 10a
• Fuse 15a
• Fuse 30a
• Fuse 5a
• G104 (at left front of engine compt)
• G205 (at left front of vehicle floor)
• Ground
• Harness, at left side of dash)
• Head
• Hot at all times
• Hot in run
• Hot in run or start
• Hot in start or run
• Instrument cluster
• Interior lights system
• Intermediate shaft speed (iss) sensor (on left rear of transmission)
• Iss
• Junction harness, near breakout to abs control module)
• Main light switch
• Micro-
• Mil
• Nca
• O/d off ind
• Off
• Oss
• Output shaft speed (oss) sensor (a/t: on left rear of transmission) (m/t: at left rear of transmission)
• Park
• Pcm power diode
• Power
• Powertrain control module (pcm) (right rear of engine compt)
• Prndl
• Processor
• Ptc 1a
• Red
• S104
• S107 (in engine control sensor & fuel charge harness, at breakout for powertrain control module)
• S129
• S140
• S141
• S143 (in pcm harness)
• S144
• S236 (in main harness, at left side of dash)
• Shift solenoids
• Sig rtn
• Smart junction box (sjb) (behind right side of dash)
• Ss a
• Ss b
• Ss c
• Ss d
• Tcc
• Tcil
• Tcs
• Tft
• Torque converter clutch (tcc) solenoid
• Tr1
• Tr2
• Tr3a
• Tr4
• Transmission control switch (tcs) (on steering column)
• Transmission fluid temperature (tft) sensor
• Tss
• Turbine shaft speed (tss) sensor
• Vbatt
• Vref

4.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006

List of elements for 4.0L, A/T Wiring Diagram (2 of 2) for Ford Ranger 2006:

• (in engine control sensor & fuel charge harness, near breakout for engine coolant temperature sender) s133
• (in engine control sensor & fuel charge harness, near breakout for fuel injector 4)
• (in engine control sensor & fuel charge harness, near breakout for transmission)
• (left side of transmission) digital transmission range (dtr) sensor
• Battery junction box (bjb) (at left rear side of engine compt)
• Engine controls system
• Engine coolant temperature (ect) sensor (on top right front of engine)
• G104 (at left front of engine compt)
• Left side of engine compt s118
• Pcm power relay
• R p
• Red
• S135
• S137
• Throttle position (tp) sensor (top front of engine, on throttle body)