AIR CONDITIONING – Toyota RAV4 2004 – SYSTEM WIRING DIAGRAMS

AIR CONDITIONING

Manual A/C Wiring Diagram (1 of 2) for Toyota RAV4 2004

List of elements for Manual A/C Wiring Diagram (1 of 2) for Toyota RAV4 2004:

• (at front of left front fender) ed
• (at right kick panel) ii
• (in dash harness, behind right side of dash) i1
• A/c
• A/c amplifier (behind center of dash)
• A/c control switch
• A/c fuse 5a
• A/c magnetic clutch & lock sensor (at left front of engine compt)
• A/c thermistor (behind center of dash)
• Ac1
• Acc
• Acc fuse 7.5a
• Acin
• Air inlet control servo motor (behind right side of dash)
• Blower motor (behind right side of dash)
• Blower resistor (behind lower right side of dash)
• Blower switch
• Driver side j/b (behind left side of dash)
• Ecu ig fuse 10a
• Engine room j/b (at left side of engine compartment)
• F10
• Frs
• G10
• Gauge fuse 10a
• Gnd1
• Gnd2
• Ground
• Hot at all times
• Hot in acc or on
• Hot in on or start
• Htr fuse 40a
• Htr relay
• If (below center of dash, at left dash brace)
• Ig (below center of dash, at right dash brace)
• Ig+
• Ign
• Ill+
• Interior lights system
• J28
• Junction connector 4 (behind center of dash)
• Junction connector 5 (behind center of dash)
• Led
• Lock
• Mgc
• Mgp
• Off
• Passenger side j/b (behind right side of dash)
• Passenger side j/b ecu
• Pnk
• Prs
• Rec
• Red
• To fan 3 relay (diagram 2 of 2)

Manual A/C Wiring Diagram (2 of 2) for Toyota RAV4 2004

List of elements for Manual A/C Wiring Diagram (2 of 2) for Toyota RAV4 2004:

• (at front of right front fender) ea
• (in dash harness, behind right side of dash) i2
• A/c condenser fan motor (behind left side of radiator)
• A/c triple pressure switch (at right front corner of engine compartment)
• Ac1
• Acmg
• Cds fuse 30a
• Diode (fan) (behind right side of dash)
• Dual pressure switch
• E5 (in engine compt harness, at left side of engine compt)
• Ed (at front of left front fender)
• Engine control module (behind right side of dash)
• Engine controls system
• Engine coolant temperature sensor (on rear of engine)
• Engine room j/b (at left side of engine compartment)
• F10
• F11
• Fan
• Fan 1 relay
• Fan 2 relay
• Fan 3 relay
• From htr relay (diagram 1 of 2)
• Hot at all times
• I1 (in dash harness, behind right side of dash)
• Radiator fan motor (behind left side of radiator)
• Rdi fuse 30a
• Red
• Single pressure switch
• Tach
• Thw