Diagram sections — 27 (77 total)
AIR CONDITIONING ANTI-LOCK BRAKES ANTI-THEFT BODY CONTROL MODULES COMPUTER DATA LINES COOLING FAN CRUISE CONTROL DEFOGGERS ENGINE PERFORMANCE EXTERIOR LIGHTS GROUND DISTRIBUTION HEADLIGHTS HORN INSTRUMENT CLUSTER INTERIOR LIGHTS POWER DISTRIBUTION POWER DOOR LOCKS POWER MIRRORS POWER SEATS POWER TOP/SUNROOF POWER WINDOWS RADIO STARTING/CHARGING SUPPLEMENTAL RESTRAINTS TRANSMISSION WARNING SYSTEMS WIPER/WASHER
AIR CONDITIONING Automatic A/C Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for Automatic A/C Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 71 (2.4l, 3.5l) (2.7l) (behind right front kick panel) g08 A/c compressor (2.4l, 3.5l: at left front of engine) (2.7l: at lower left front of engine) A/c control module (behind center of dash) A/c diode A/c fuse 10a A/c out A/c relay A/c select Acttr ctrl Amb sens Ambient temperature sensor (near center of radiator) B/l Blower motor (below right side of dash, on bottom of hvac assembly) Blower relay Blwr fdbck Def E/r-b E/r-c E/r-d E/r-f Engine compartment junction block (on left side of engine compt) Engine control relay Evap sens Floor Fre Fuse 10a Fuse 15a Fusible link (blr) 40a Fusible link (ecu) 40a G05 (at left front of engine compt, on inner fender panel) G08 (behind right front kick panel) Ground Hi bl rly High blower relay Hot at all times Hot in on I/p-j I/p-l Illu (+) Illu (-) In car sens Intake actuator Interior lights system Joint connector m04 (behind lower left end of dash) Joint connector m05 (behind lower left end of dash) M32-1 M32-2 Mem power Mix Mode actuator (behind left center of dash, on hvac assembly) Nca Not used On input On/start in Passenger compartment junction block (behind lower left end of dash) Photo sensor (on top center of dash) Pnk Power transistor (behind upper right side of dash, on hvac assembly) Powr trans Rec Red Sensor + Sensor gnd Tan Temp acttr Temp feedbck Temperature actuator (below right side of dash, on hvac assembly) Thermostatic switch (behind right center of dash, on hvac assembly) Vent Automatic A/C Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for Automatic A/C Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 63 (or pnk) (w/ immobilizer) (w/o immobilizer) 2.4l 2.4l w/ a/t 2.4l w/ m/t 2.7l 3.5l A/c relay control C121-a C121-b C121-c C21-a C21-b C21-c C22-a C22-b C22-d C23-f C23-m C23-p Condenser fan motor (at front of engine compt, on right side of radiator support) Condenser fan relay 1 Condenser fan relay 2 Control (high) Control (low) E/r-b E/r-c E/r-e E/r-h Ecm/pcm (below center of dash) Ect sensor Engine Engine compartment junction block (on left side of engine compt) Engine controls system Engine coolant temperature sensor & sender (2.4l: on rear of cylinder head) (2.7l: on rear of left cylinder head) (3.5l: at rear of engine) Except 2.4l Except 3.5l Fan relay Fuse 10a Fusible link (c/ fan) 20a Fusible link (rad fan) 40a G05 (at left front of engine compt, on inner fender panel) G06 (at right front of engine compt, near power steering fluid reservoir) High Hot at all times Hot in on I/p-b Input Joint connector c134 (under center console) Joint connector c34 (below center of dash) Low Mid Nca Passenger compartment junction block (behind lower left end of dash) Pnk Radiator fan motor (at front of engine compt, on left side of radiator support) Radiator fan relay Relay control Signal a/c Signal cooling Switch a/c Triple switch (at right front of engine compt, below washer fluid reservoir) Manual A/C Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for Manual A/C Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 63 "on" input (2.4l, 3.5l) (2.7l) A/c compressor (2.4l, 3.5l: at left front of engine) (2.7l: at lower left front of engine) A/c diode A/c fuse 10a A/c relay A/c switch B/l Bl rly ctrl Blower motor Blower relay Blower resistor Blower switch Cool Def E/r-b E/r-c E/r-d E/r-f Engine compartment junction block (on left side of engine compt) Engine control relay Floor Flr Fresh Fuse 10a Fusible link (blr) 40a Fusible link (ecu) 40a G05 (at left front of engine compt, on inner fender panel) G08 (behind right front kick panel) Ground Hot at all times Hot in on I/p-l I/p-p Iii Iiii Ill (+) Ill (-) Intake actuator Interior lights system Joint connector m04 (behind lower left end of dash) Manual a/c control module (behind center of dash) Memory pwr Mix Mode actuator (behind left center of dash, on hvac assembly) Nca Off On input Passenger compartment junction block (behind lower left end of dash) Pbr Pnk Power connector Recirc Red Sens gnd Temp act Temperature switch Thermistor Thermostatic switch (behind right center of dash, on hvac assembly) Vcc Vent Warm Manual A/C Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for Manual A/C Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 61 (or pnk) (w/ immobilizer) (w/o immobilizer) 2.4l 2.4l w/ a/t 2.4l w/ m/t 2.7l 3.5l A/c relay control A/c switch C121-a C121-b C121-c C21-a C21-b C21-c C22-a C22-b C22-d C23-f C23-m C23-p Condenser fan motor (at front of engine compt, on right side of radiator support) Condenser fan relay 1 Condenser fan relay 2 E/r-b E/r-c E/r-e E/r-h Ecm/pcm (below center of dash) Ect sensor Engine compartment junction block (on left side of engine compt) Engine controls system Engine coolant temperature sensor & sender (2.4l: on rear of cylinder head) (2.7l: on rear of left cylinder head) (3.5l: at rear of engine) Engine relay control Except 2.4l Except 3.5l Fan relay control (high) Fan relay control (low) Fuse 10a Fusible link (c/ fan) 20a Fusible link (rad fan) 40a G05 (at left front of engine compt, on inner fender panel) G06 (at right front of engine compt, near power steering fluid reservoir) High Hot at all times Hot in on I/p-b Input Joint connector c134 (under center console) Joint connector c34 (below center of dash) Low Mid Nca Passenger compartment junction block (behind lower left end of dash) Pnk Radiator fan motor (at front of engine compt, on left side of radiator support) Radiator fan relay Signal a/c Signal cooling Triple switch (at right front of engine compt, below washer fluid reservoir)
ANTI-LOCK BRAKES
2.4L 2.4L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 2.4L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004: 50 "g" sensor (4wd) (below parking brake lever) 2.7l Abs control module (left rear of engine compartment, below brake master cylinder) Abs ind Abs pump motor Abs/ebd ind ctrl Abs/tcs solenoids Air bleeding connector (on left front strut tower) Brake ind C23-f Data link connector (behind lower left end of dash) Diagnosis E/r-b Engine compartment junction block (on left side of engine compt) Engine control module (below center of dash) Fuse 10a Fusible link (abs 1) 30a Fusible link (abs 2) 30a G sensor G05 (at left front of engine compt, on inner fender panel) G07 (behind left front kick panel) Ground Hot at all times Hot in on or start I/p-b I/p-f I/p-l I/p-m Instrument cluster J/c m05 (behind lower left end of dash) J/c m06 (behind lower left end of dash) Left front wheel sensor (on left front wheel hub assembly) Left rear wheel sensor (at left rear wheelwell) M15-6 Nca Note: abs control module contains: abs solenoids, tcs solenoids & abs pump motor On/start input Passenger compartment junction block (behind lower left end of dash) Pnk Red Right front wheel sensor (on right front wheel hub assembly) Right rear wheel sensor (on right rear wheelwell) Stop lamp sw input Stop lamp switch (above brake pedal, on bracket) Tcs ind Tcs ind ctrl Vss W/ cruise control W/o cruise control Wheel speed input
2.7L 2.7L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 2.7L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004: 50 "g" sensor (4wd) (below parking brake lever) 2.7l Abs control module (left rear of engine compartment, below brake master cylinder) Abs ind Abs pump motor Abs/ebd ind ctrl Abs/tcs solenoids Air bleeding connector (on left front strut tower) Brake ind C23-f Data link connector (behind lower left end of dash) Diagnosis E/r-b Engine compartment junction block (on left side of engine compt) Engine control module (below center of dash) Fuse 10a Fusible link (abs 1) 30a Fusible link (abs 2) 30a G sensor G05 (at left front of engine compt, on inner fender panel) G07 (behind left front kick panel) Ground Hot at all times Hot in on or start I/p-b I/p-f I/p-l I/p-m Instrument cluster J/c m05 (behind lower left end of dash) J/c m06 (behind lower left end of dash) Left front wheel sensor (on left front wheel hub assembly) Left rear wheel sensor (at left rear wheelwell) M15-6 Nca Note: abs control module contains: abs solenoids, tcs solenoids & abs pump motor On/start input Passenger compartment junction block (behind lower left end of dash) Pnk Red Right front wheel sensor (on right front wheel hub assembly) Right rear wheel sensor (on right rear wheelwell) Stop lamp sw input Stop lamp switch (above brake pedal, on bracket) Tcs ind Tcs ind ctrl Vss W/ cruise control W/o cruise control Wheel speed input
3.5L 3.5L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 3.5L, Anti-lock Brakes Wiring Diagram for Hyundai Santa Fe 2004: 57 (not used) 4wd control module (under left side of rear seat) Abs control module (at left side of engine compt) Abs ind Abs pump motor Abs/ebd ind ctrl Abs/tcs solenoids Air bleeding connector (on left front strut tower) Brake ind C121-c Communication area network Data link connector (behind lower left end of dash) Diagnosis E/r-b Engine compartment junction block (on left side of engine compt) Fuse 10a Fusible link (abs 1) 30a Fusible link (abs 2) 30a G sensor G-sensor (4wd) (below parking brake lever) G05 (at left front of engine compt, on inner fender panel) G07 g07 (behind left (behind left front kick front kick panel) Ground Hot at all times Hot in on or start I/p-b I/p-f I/p-l I/p-m Illum Instrument cluster Interior lights system J/c m05 (behind lower left end of dash) J/c m06 (behind lower left end of dash) Left front wheel sensor (on left front wheel hub assembly) Left rear wheel sensor (at left rear wheelwell) M15-6 Nca Note: abs control module contains: abs solenoids, tcs solenoids & abs pump motor On/start input Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Red Right front wheel sensor (on right front wheel hub assembly) Right rear wheel sensor (on right rear wheelwell) Stop lamp sw input Stop lamp switch (above brake pedal, on bracket) Tcs ind Tcs ind ctrl Tcs off Tcs off ind ctrl Tcs switch Tcs switch input Vss W/ cruise Wheel speed sensor
ANTI-THEFT Forced Entry Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Forced Entry Wiring Diagram for Hyundai Santa Fe 2004: 45 (at left center of floor) (at right front (behind lower left end of dash) multipurpose check connector (or 15) Burglar alarm relay Corner of Door locks system E/r-e Engine compartment junction block (on left side of engine compt) Engine compt) Etacm Exterior lights system Fuse 10a Fuse 15a G09 (on inner rocker panel, under driver seat) G10 (on inner rocker panel, under passenger seat) G13 (under tail gate trim, below rear wiper control module) Ground distribution system Hazard relay (behind left kick panel) Hood switch (behind right headlight, on radiator support) Hot at all times I/p-j I/p-p J/c m05 (behind lower left end of dash) Joint connector m46 Left front door lock actuator (at rear of left front door) Left front lock/ unlock switch Left rear door lock actuator (at rear of left rear door) Lock M13-1 M13-2 M13-3 Nca Passenger compartment junction block (behind lower left end of dash) Pnk Red Right front door lock actuator (at rear of right front door) Right front unlock switch Right rear door lock actuator (at rear of right rear door) Siren Starting/ charging system Starting/charging system Tail gate lock actuator (inside lower center of tail gate) Tail gate unlock switch (at center of tail gate) Unlock Immobilizer Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Immobilizer Wiring Diagram for Hyundai Santa Fe 2004: 32 (2.4l w/ a/t) (2.4l w/ m/t) (2.7l) (3.5l) 2.7l Antenna (+) Antenna (-) Antenna coil C21-c c22-c c23-v c121-c C24-3 Data link connector (behind lower left end of dash) Ecm & tcm Fuse 10a G07 (behind left front kick panel) Ground Hot at all times Hot in on or start I/p-j I/p-p Ignition key illumination & door warning switch Immo ind Immobilizer control module (behind center of dash) Immobilizer indicator Instrument cluster K-line M15-5 M15-6 Memory power Multipurpose check connector (behind lower left end of dash) Nca On/start Passenger compartment junction block (behind lower left end of dash) Powertrain control module (or) engine control module (below center of dash) Red Transmission control module (below center of dash)
BODY CONTROL MODULES Body Control Modules Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Body Control Modules Wiring Diagram for Hyundai Santa Fe 2004: 79 (not used) Anti-theft system B/alarm relay control Chime bell control Code save Cruise control system Defogger relay control Defogger switch on input Defogger system Door ajar ind control Door lock system Door locks system Door switch input Door warning switch input Dr lock/unlock relay cntrl Drl Engine running input Etacm Exterior lights system Fuse 12 15a Fuse 19 10a Fuse 9 10a G07 (behind left front kick panel) Ground Hazard relay control Hood switch Hot at all times Hot in on Hot in on or start I/p-d I/p-e I/p-f I/p-j I/p-k I/p-l I/p-m I/p-p Illumination control Impact signal input Indicator control Instrument cluster system Int Int (time) Interior lights system Junction block ground Key lock/unlock relay control Key on input Key start/on input Left front dr lock/unlock in Left front lock/unlock switch M13-1 M13-2 M13-3 Memory power Nca Passenger compartment junction block (behind lower left end of dash) Pnk Power connector Power window relay control Power windows system Pre- excitation resistor Right front dr lock/unlock in Right front unlock switch Room lamp control Rr dr lock/unlock input Seat belt indicator Seat belt switch Siren Starting/ charging system Starting/charging system Tail gate unlock switch Tail lamp relay auto cut Tail lamp relay auto cut cntrl Tailgate switch Vehicle speed sensor Warning system Washer input Wiper relay control Wiper/washer system
COMPUTER DATA LINES
2.4L 2.4L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 2.4L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004: 48 (behind center of dash) (behind left front kick panel) g07 (below front of center console) srs control module A/t Abs control module (at left rear of engine compt, below brake master cylinder) Air bleeding connector (on left front strut tower) C21-a C21-c C21-d C22-c C22-d Data link connector (behind lower left end of dash) Diag Diode z07 (behind left rear quarterpanel) E/r-d Ecm (below center of dash) Engine compartment junction block (on left side of engine compt) Etacm (on rear of passenger compt junction block) Flash source Fuel cut sensor Fuel pump check connector Fuel pump relay Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat) Fuse 10a G03 (under center console, near G11 (behind left rear quarterpanel trim, near speaker) Hot at all times I/p-j I/p-k I/p-l I/p-m Immobilizer control module Joint connector m04 (behind lower left end of dash) Joint connector m06 (behind lower left end of dash) K-line M/t M13-2 Multipurpose check connector (behind lower left end of dash) Nca Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Red Spark timing Srs control module) Vehicle speed sensor (on right side of transaxle) W/ immobilizer W/o immobilizer
2.7L 2.7L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 2.7L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004: 41 (behind left front kick panel) g07 (behind lower left end of dash) (below front of center console) srs control module Abs control module (at left rear of engine compt, below brake master cylinder) Air bleeding connector (on left front strut tower) C23-v C24-1 C24-3 Data link connector (behind lower left end of dash) Diag Diode z07 (behind left rear quarterpanel) E/r-d Ecm/pcm (below center of dash) Engine compartment junction block (on left side of engine compt) Etacm (on rear of passenger compt junction block) Flash source Fuel cut sensor Fuel pump check connector Fuel pump relay Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat) Fuse 10a G02 (under center console, near srs control module) G11 (behind left rear quarterpanel trim, near speaker) Hot at all times I/p-j I/p-k I/p-l I/p-m Immobilizer control module (behind center of dash) Joint connector m04 (behind lower left end of dash) Joint connector m06 (behind lower left end of dash) K-line M13-2 Multipurpose check connector (behind lower left end of dash) Nca Passenger compartment junction block Red Tcm (below center of dash) Vehicle speed sensor (on right side of transaxle) W/ immobilizer W/o immobilizer
3.5L 3.5L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 3.5L, Computer Data Lines Wiring Diagram for Hyundai Santa Fe 2004: 37 (behind left front kick panel) g07 (below front of center console) srs control module Abs control module (at left side of engine compt) Air bleeding connector (on left front strut tower) C121-a C121-c C121-d Data link connector (behind lower left end of dash) Diode z07 (behind left rear quarterpanel) E/r-d Engine compartment junction block (on left side of engine compt) Etacm (on rear of passenger compt junction block) Fuel cut sensor Fuel pump check connector Fuel pump relay Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat) Fuse 10a G103 (under center console) G11 (behind left rear quarterpanel trim, near speaker) Hot at all times I/p-j I/p-k I/p-l I/p-m Immobilizer control module (behind center of dash) Joint connector m04 (behind lower left end of dash) Joint connector m06 (behind lower left end of dash) M13-2 Multipurpose check connector (behind lower left end of dash) Nca Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Red Vehicle speed sensor (on right side of transaxle) W/ immobilizer W/o immobilizer
COOLING FAN Cooling Fan Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Cooling Fan Wiring Diagram for Hyundai Santa Fe 2004: 46 (or pnk) 2.4l 2.4l w/ a/t 2.4l w/ m/t 2.7l 3.5l C121-a C121-b C121-c C21-a C21-b C22-a C22-d C23-f C23-m Condenser fan motor (at front of engine compt, on right side of radiator support) Condenser fan relay 1 Condenser fan relay 2 E/r-b E/r-c E/r-e E/r-h Ecm/pcm (below center of dash) Ect sensor Engine compartment junction block (on left side of engine compt) Engine controls system Engine coolant temperature sensor & sender (2.4l: on rear of cylinder head) (2.7l: on rear of left cylinder head) (3.5l: at rear of engine) Except 2.4l Except 3.5l Fan relay ctrl (high) Fan relay ctrl (low) Fuse 10a Fusible link (c/ fan) 20a Fusible link (rad fan) 40a G05 (at left front of engine compt, on inner fender panel) G06 (at right front of engine compt, near power steering fluid reservoir) Hot at all times Hot in on I/p-b Joint connector c134 (under center console) Joint connector c34 (below center of dash) Nca Passenger compartment junction block (behind lower left end of dash) Pnk Radiator fan motor (at front of engine compt, on left side of radiator support) Radiator fan relay
CRUISE CONTROL Cruise Control Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Cruise Control Wiring Diagram for Hyundai Santa Fe 2004: 85 (2.4l w/ a/t) (2.4l w/ m/t) (3.5l) (above brake pedal, on bracket) stop lamp switch (at left front of engine compt) joint connector c33 c133 (behind lower left end of dash) j/c m05 (or red) 3.5l A/t Acc Actuator clutch C121-c C133 C21 C21-c C22-d C24-1 C33 Cancel Clock spring Clutch pedal position switch (above clutch pedal, on bracket) Connector (behind lower left end of dash) Cruise control module (on right side of engine compartment) Cruise ind Cruise on/off Cruise remote control switch Cruise sw ind on Data link E/r-d E/r-e E/r-g Ecu 3 fuse 10a Engine compartment junction block (on left side of engine compartment) Etacm Except 3.5l Fuse 14 10a Fuse 19 10a Fuse 25 10a Fuse 4 10a G03 (2.4l) g02 (2.7l) g103 (3.5l) (2.4l, 2.7l: under center console, near srs control module) (3.5l: under center console) G06 (at right front of engine compartment, near power steering fluid reservoir) G07 (behind left front kick panel) Ground Hall ic Hot at all times Hot in on Hot in on or start Hot with engine control relay energized I/p-b I/p-j I/p-l I/p-m Ignition switch Instrument cluster J/c m06 (behind lower left end of dash) Left side Lock M/t M13-3 M15-5 M15-6 Multi- function switch Nca O/d control Off Park/neutral input Passenger compartment junction block (behind lower left end of dash) Pcm/ecm (below center of dash) Pnk Power source Powertrain control module (2.4l) Red Remote ground Resume/ accel Right side Set/ coast Start Starting/ charging Steering wheel Stoplamp sw input Sw input System Tcm (2.7l) (below center of dash) Vehicle speed input Vehicle speed sensor (on right side of transaxle)
DEFOGGERS Defoggers Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Defoggers Wiring Diagram for Hyundai Santa Fe 2004: 35 (behind lower left end of dash) passenger compartment junction block Def Defogger relay Defogger relay control Defogger switch input Engine running input Etacm Fuse 10a Fuse 30a Fuse 8 10a G08 (under right front kick panel) G09 (on inner rocker panel, under driver seat) G10 (on inner rocker panel, under passenger seat) G11 (under left rear quarterpanel trim, near speaker) Hot in on or start I/p-f I/p-j I/p-l I/p-p Illumi- nation Ind Interior lights system Left power outside mirror motor & defogger M13-3 Nca Off On/start input Power outside mirror switch Pre- excitation resistor R02 R04 Rear window defogger Rear window defogger switch Red Right power outside mirror motor & defogger
ENGINE PERFORMANCE
2.4L 2.4L, Engine Performance Wiring Diagram, A/T (1 of 4) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, A/T (1 of 4) for Hyundai Santa Fe 2004: 89 (ecu) (under left rear quarterpanel trim, near speaker) g11 A/c rly ctrl A/c sig in Air conditioning system Air temp sens Atm rly ctrl Battery C21-a C21-b Ccv ctrl Check engine Ckp sens sig Closing Cmp sens sig Cooling fans system Cooling sig in Diode z07 (behind left rear quarterpanel) E/r-d E/r-f E/r-g E/r-h Ect sens Ecu (b+) fuse 15a Ecu 2 fuse 20a Egr sol ctrl Egr solenoid valve (on right side of intake manifold) Eng ctrl rly Eng rly on Engine compartment junction block (on left side of engine compt) Engine control relay Fan rly (hi) Fan rly (lo) Frt o2s heat Fuel cut sensor Fuel injectors Fuel pmp ctrl Fuel pump check connector Fuel pump relay Fuel sender Fuel sender & fuel pump motor (inside fuel tank) Fuel temperature sensor (inside fuel tank, beneath left rear seat) Fuel tmp sens Fuse 19 10a Fusible link 40a G01 (on body, near right front of engine) G03 (under center console) G11 (behind left rear quarterpanel trim, near speaker) Gnd Hot at all times Hot in on or start I/p-m Idle speed control actuator (below throttle body, on bracket) Ign coil 1, 4 Ign coil 2, 3 Ign det sig Ign timing adj Ignition coil 1 Ignition coil 2 Inj 1 Inj 2 Inj 3 Inj 4 Instrument cluster Instrument cluster system Joint connector m04 (behind lower left end of dash) Joint connector m05 (behind lower left end of dash) M15-5 Maf sens sig Memory pwr Mil (check engine ind) Nca Opening P/n input Passenger compartment junction block (behind lower left end of dash) Pcv vlv ctrl Pnk Power steering switch (on left front of engine, on pump) Powertrain control module (pcm) (below center of dash) Ps sw in Purge control solenoid valve (on right front of engine) Red Rr o2s heat Sens gnd Sens pwr (5v) Start sig Starting/ charging system To ecu 3 fuse (diagram 2 of 4) To spark plugs 2.4L, Engine Performance Wiring Diagram, A/T (2 of 4) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, A/T (2 of 4) for Hyundai Santa Fe 2004: 24 (at left front of engine compt) joint connector c33 Atm fuse 20a Canister close valve (beneath center of vehicle, above drive shaft) E/r-f E/r-g E/r-h Ecu 1 fuse 20a Ecu 3 fuse 10a Engine compartment junction block (on left side of engine compt) Engine coolant temperature sensor & sender (on rear of cylinder head) From engine control relay a (diagram 1 of 4) Front oxygen sensor (on exhaust manifold, on left side of engine) G03 (under center console, near srs control module) Hot at all times Ignition failure sensor (on rear of cylinder head) Instrument cluster system Joint connector c34 (below center of dash) Map sensor (on right side of engine) Nca Pnk Rear oxygen sensor (on exhaust pipe, beneath vehicle) Red Sender Sensor 2.4L, Engine Performance Wiring Diagram, A/T (3 of 4) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, A/T (3 of 4) for Hyundai Santa Fe 2004: 31 (behind lower left end of dash) data link connector (behind lower left end of dash) multipurpose check connector (on right side of engine compt) cruise control module (on right side of transaxle) vehicle speed sensor Camshaft position sensor (on left rear of cylinder head) Crankshaft position sensor (on right of engine) E/r-d Engine compartment junction block (on left side of e/r-g engine compt) Etacs control module Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle) Fuse 10a G03 (under center console) Hot in on or start I/p-b I/p-l I/p-m Immobilizer control module (behind center of dash) Instrument cluster system Joint connector c33 (at left front of engine compt) Joint connector c35 (below center of dash) Joint connector mo6 (behind left side of dash) Knock sensor (on rear of cylinder head) M13-3 Mass air flow sensor (on left rear of engine compt, in air intake duct) Nca Passenger compartment junction block (behind lower left end of dash) Pnk Red Throttle position sensor (on right side of throttle body) W/ immobilizer W/o immobilizer 2.4L, Engine Performance Wiring Diagram, A/T (4 of 4) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, A/T (4 of 4) for Hyundai Santa Fe 2004: 58 "1" "2" "3" "4" (behind left front kick panel) g07 (under center console) g04 2nd A/c sw on A/t pulse generator "a" (on left front of transaxle) A/t pulse generator "b" (on top front of transaxle) Air conditioning system Atm control relay (under center console) Atm solenoid valve (on top rear of transaxle) Battery C21-c C21-d Cruise control system Cruise ctrl D input Dcc Down shift Ecm Exterior lights system Exterior lights system (stop lamp switch) Flash source Frt o2s sig Ftp sens sig G04 (under center console) Gnd Instrument cluster Joint connector c35 (below center of dash) K-line Ks sig M15-7 Map sens sig N input Normal O/t Oil temp sensor On/start in P input Pnk Powertrain control module (pcm) (below center of dash) Pulse gen a Pulse gen b R input Red Rr o2s sig Select Select sw Select switch Sport mode switch Starting/ charging system Stop lmp sw Tp sens sig Transaxle range switch (on top rear of transaxle) Up shift Vss in 2.4L, Engine Performance Wiring Diagram, M/T (1 of 3) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, M/T (1 of 3) for Hyundai Santa Fe 2004: 68 (ecu) A/c rly ctrl A/c sig in A/c sw on in Air conditioning system Battery C22-a C22-b Check engine Closing Cooling fans system air conditioning system Cooling sig in Diode z07 (behind left rear quarterpanel) E/r-d E/r-f E/r-g E/r-h Ecu (b+) fuse 15a Ecu 2 fuse 20a Egr solenoid valve (on right side of intake manifold) Egr vlv ctrl Eng ctrl rly Eng rly on Engine compartment junction block (on left side of engine compt) Engine control module (ecm) (below center of dash) Engine control relay Fan rly (hi) Fan rly (lo) Fuel cut sensor Fuel injectors Fuel pmp ctrl Fuel pump check connector Fuel pump relay Fuel sender & fuel pump motor (inside fuel tank) Fuse 19 10a Fusible link 40a G01 (on body, near right front of engine) G03 (under center console, near srs control module) G11 (behind left rear quarterpanel trim, near speaker) Gnd Hot at all times Hot in on or start I/p-m Idle speed control actuator (below throttle body, on bracket) Ign coil 1, 4 Ign coil 2, 3 Ignition coil 1 (at top of engine) Ignition coil 2 (at top of engine) Inj 1 Inj 2 Inj 3 Inj 4 Instrument cluster Joint connector m04 (behind lower left end of dash Joint connector m05 (behind lower left end of dash) M15-5 Mil (check engine ind) Nca Opening Passenger compartment junction block (behind lower left end of dash) Pcs vlv ctrl Pnk Power steering switch (on left front of engine, on pump) Ps sw in Purge control solenoid valve (on right front of engine) Red To ecu 3 fuse (diagram 2 of 3) To spark plugs 2.4L, Engine Performance Wiring Diagram, M/T (2 of 3) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, M/T (2 of 3) for Hyundai Santa Fe 2004: 22 (at left front of engine compt) joint connector c33 Canister close valve (beneath center of vehicle, above drive shaft) E/r-g E/r-h Ecu 1 fuse 20a Ecu 3 fuse 10a Engine compartment junction block (on left side of engine compt) Engine coolant temperature sensor & sender (on rear of cylinder head) From engine control relay a (diagram 1 of 3) Front oxygen sensor (on exhaust manifold, on left side of engine) Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle) G03 (under center console) Ignition failure sensor (on rear of cylinder head) Instrument cluster system Joint connector c34 (below center of dash) Map sensor (on right side of engine) Nca Pnk Rear oxygen sensor (on exhaust pipe, beneath vehicle) Red Sender Sensor 2.4L, Engine Performance Wiring Diagram, M/T (3 of 3) for Hyundai Santa Fe 2004 List of elements for 2.4L, Engine Performance Wiring Diagram, M/T (3 of 3) for Hyundai Santa Fe 2004: 64 (behind lower left end of dash) data link connector (behind lower left end of dash) multipurpose check connector (on right side of engine compt) cruise control module (on right side of transaxle) vehicle speed sensor Afs sig Air temp C22-c C22-d Camshaft position sensor (on left rear of cylinder head) Ccv ctrl Ckp sens sig Cmp sens sig Crankshaft position sensor (on right side of engine) E/r-d Ect sens Engine compartment junction block (on left side of e/r-g engine compt) Engine control module (ecm) (below center of dash) Etacs control module Frt o2s heat Frt o2s sig Ftp sens sig Fuel sender Fuel temp Fuel temperature sensor (inside fuel tank, beneath left rear seat) Fuse 10a G03 (under center console) G03 (under center console, near srs control module) G11 (behind left rear quarterpanel trim, near speaker) Gnd Hot in on or start I/p-b I/p-l I/p-m Ign det sig Ign timing adj Immobilizer control module (behind center of dash) Instrument cluster system Instrument cluster system (tachometer) Joint connector c33 (at left front of engine compt) Joint connector mo6 (behind lower left end of dash) K-line Knock sensor (on rear of cylinder head) Ks sig M13-3 Map sens sig Mass air flow sensor (on left rear of engine compt, in air intake duct) Memory pwr Nca On/start in Passenger compartment junction block (behind lower left end of dash) Pnk Red Rr o2s heat Rr o2s sig Sens gnd Sens pwr Start sig Starting/ charging system Tcm Throttle position sensor (on right side of throttle body) Tp sens sig Vss input W/ immobilizer W/o immobilizer
2.7L 2.7L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Santa Fe 2004 List of elements for 2.7L, Engine Performance Wiring Diagram (1 of 4) for Hyundai Santa Fe 2004: 76 (ecu) (pins 11-16) (pins 2-6) (pins 2-7) (pins 27-28) (pins 39-41) (pins 43-45) (pins 49-52) (pins 8-12) 02s heating Air temp gnd Air temp in Air temperature sensor (on right front of intake manifold) Battery C23-m C23-p C23-v Close Cmp sens gnd Cmp sig Diode z07 (behind left rear quarter- panel) E/r-d E/r-f E/r-g Ect sens gnd Ect sens in Ecu (b+) fuse 15a Eng ctrl rly Engine compartment junction block (on left side of engine compt) Engine control module (ecm) (below center of dash) Engine control relay Engine coolant temperature sensor & sender (on rear of (left cylinder head) Fuel cut sensor Fuel inj 1 Fuel inj 2 Fuel inj 3 Fuel inj 4 Fuel inj 5 Fuel inj 6 Fuel injectors Fuel pump check connector Fuel pump relay Fuel sender & fuel pump motor (inside fuel tank) Fuse 10a Fusible link 40a G02 (under center console) G11 (behind left rear quarterpanel trim, near speaker) Gnd Hot at all times Hot in on or start I/p-l I/p-m Instrument cluster system Joint connector m04 (behind lower left end of dash) K-line Ks1 sig in Ks2 sig in Map sens gnd Map sig Memory pwr Nca O2s O2s ground O2s heating On/start in Open Passenger compartment junction block (behind lower left end of dash) Pcs vlv ctrl Pnk Ps sw in Purge control solenoid valve (on right side of intake manifold) Red Sens gnd To ecu 3 fuse (diagram 2 of 4) Tp sens pwr Tp sens sig 2.7L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Santa Fe 2004 List of elements for 2.7L, Engine Performance Wiring Diagram (2 of 4) for Hyundai Santa Fe 2004: 23 (behind lower left end of dash) data link connector (behind lower left end of dash) joint connector mo5 (behind lower left end of dash) multipurpose check connector E/r-g E/r-h Ecu 1 fuse 20a Ecu 2 fuse 20a Ecu 3 fuse 10a Engine compartment junction block (on left side of engine compt) From engine a control relay (diagram 1 of 4) Immobilizer control module (behind center of dash) Knock sensor 1 (on top right rear of engine, below intake manifold) Knock sensor 2 (on top right rear of engine, below intake manifold) Nca Oxygen sensor (b1/s1) (on right exhaust manifold) Oxygen sensor (b1/s2) (on lower right side of engine) Oxygen sensor (b2/s1) (on left exhaust manifold) Oxygen sensor (b2/s2) (on lower left side of engine) Pnk Power steering switch (on top of power steering pump, on front of engine) Red W/ immobilizer W/o immobilizer 2.7L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Santa Fe 2004 List of elements for 2.7L, Engine Performance Wiring Diagram (3 of 4) for Hyundai Santa Fe 2004: 27 (not used) (on right side of engine compt) cruise control module (on right side of transaxle) vehicle speed sensor (or red) Camshaft position sensor (on rear of left cyl head) Canister close valve (beneath center of vehicle, above drive shaft) Crankshaft position sensor (on left rear of engine) E/r-d Engine compartment junction e/r-g block (on left side of engine compt) Etacm Fuse 10a G02 (under center console, near srs control module) Hot in on or start I/p-b I/p-l I/p-m Idle speed control actuator (on left side of throttle body, on bracket) Instrument cluster system Joint connector c33 (at left front of engine compt) Joint connector m06 (behind lower left end of dash) M13-3 Map sensor (on right side of engine) Nca Passenger compartment junction block (behind lower left end of dash) Pnk Red Throttle position sensor (on left side of throttle body) 2.7L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Santa Fe 2004 List of elements for 2.7L, Engine Performance Wiring Diagram (4 of 4) for Hyundai Santa Fe 2004: 41 (at left rear of engine compt, below brake master cylinder) abs control module (below center of dash) tcm A/c on in A/c rly ctrl A/c sig in Air conditioning system C23-f C23-z C24-1 C24-3 Ccv Chck eng ind Ckp sens gnd Ckp sig Cond fan rly Cooling fans system Cooling sig Engine control module (ecm) (below center of dash) Engine rpm Ftp sens sig Fuel pmp rly Fuel sender Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle) G02 (under center console) Gnd Ign coil ctrl Ignition coil (on left rear of engine) Instrument cluster Instrument cluster system M15-5 Mil (check engine ind) Nca Rad fan rly Red Right front wheel sensor (w/o abs) (on right front wheel hub assembly) Sens ground Sens pwr Spark plugs Tcm Vss Whl spd in
3.5L 3.5L, Engine Performance Wiring Diagram (1 of 5) for Hyundai Santa Fe 2004 List of elements for 3.5L, Engine Performance Wiring Diagram (1 of 5) for Hyundai Santa Fe 2004: 86 (ecu) (under center console) g103 A/c rly ctrl A/c sig in Afs sig Air conditioning system Ats sig Battery C121-a C121-b Can Ccv ctrl Ckp sens sig Close Cmp sens sig Cooling fans system Cooling sig in Cruise control system Cruise ctrl Diode z07 (behind left rear quarter- panel) E/r-d E/r-f E/r-g E/r-h Ect sens Ecu (b+) fuse 15a Ecu 3 fuse 10a Egr sol ctrl Egr solenoid (at right side of engine) Eng ctrl rly Eng lamp ctrl Engine compartment junction block (on left side of engine compt) Engine control relay Fan rly (hi) Fan rly (lo) Fuel cut sensor Fuel injectors Fuel pmp ctrl Fuel pump check connector Fuel pump relay Fuel sender Fuel sender & fuel pump motor (inside fuel tank) Fusible link 40a G103 (under center console) G11 (behind left rear quarterpanel trim) Gnd Hot at all times Htr Ign coil 1.4 Ign coil 2.5 Ign coil 3.6 Ign det sig Ign timing adj Ignition coil 1 (at top left of engine) Ignition coil 2 (at top left of engine) Ignition coil 3 (at top left of engine) Inj 1 Inj 2 Inj 3 Inj 4 Inj 5 Inj 6 Instrument cluster system Joint connector m04 (behind lower left side of dash) Memory power Memory pwr Nca Open P/n sig Pnk Power steering switch (on left front of engine, on pump) Powertrain control module (pcm) (below center of dash) Ps sw in Pur sol ctrl Purge control solenoid valve (at right rear of engine) Red Rly ctrl Sens gnd Sens pwr Starting/ charging system To ecu fuse 2 (diagram 2 of 4) To spark plugs Valve ctrl Variable intake sensor (at right front of engine) W/ immobilizer W/o immobilizer 3.5L, Engine Performance Wiring Diagram (2 of 5) for Hyundai Santa Fe 2004 List of elements for 3.5L, Engine Performance Wiring Diagram (2 of 5) for Hyundai Santa Fe 2004: 30 (at right rear of engine) limp home valve (diagram 1 of 4) Atm fuse 20a Canister close valve (beneath center of vehicle, above drive shaft) Close E/r-f E/r-g E/r-h Ecu 1 fuse 20a Ecu 2 fuse 20a Engine compartment junction block (on left side of engine compt) From engine control relay a From fuel injectors b G103 (under center console) Ground Hot at all times Ignition failure sensor (at rear of engine) Joint connector c133 (at left front of engine compt) Joint connector c168 (under center of dash) Map sensor (on right side of engine) Nca Open Oxygen sensor (b1/s1) (at right rear of engine) Oxygen sensor (b1/s2) (at right rear of engine) Oxygen sensor (b2/s1) (at right rear of engine) Oxygen sensor (b2/s2) (at right rear of engine) Pnk Power Red Variable intake motor (at right front of engine) 3.5L, Engine Performance Wiring Diagram (3 of 5) for Hyundai Santa Fe 2004 List of elements for 3.5L, Engine Performance Wiring Diagram (3 of 5) for Hyundai Santa Fe 2004: 48 (above brake pedal, on bracket) stop lamp switch Can Cancel Clock spring Cruise on/off Cruise remote control switch Engine coolant temperature sensor & sender (at rear of engine) Engine rly Ets control module (under center of dash) Ets motor (at right rear of engine) Fail safety relay Fuse 10a Fuse 15a G07 (behind left front kick panel) G103 (under center console) Gnd Hot at all times Hot in on I/p-j I/p-l I/p-m Instrument cluster system Joint connector c134 (under center console) Joint connector m06 (behind lower left end of dash) Left M20-3 Memory Motor Multi- function switch Nca On/start P/n pos in Passenger compartment junction block (behind lower left end of dash) Pnk Red Relay box Resume/ accel Right Sender Sens gnd Sens pwr Sens sig Sensor Set/ coast Starting/ charging system Steering wheel Stop sw Sw in 3.5L, Engine Performance Wiring Diagram (4 of 5) for Hyundai Santa Fe 2004 List of elements for 3.5L, Engine Performance Wiring Diagram (4 of 5) for Hyundai Santa Fe 2004: 35 (behind lower left end of dash) data link connector (behind lower left end of dash) multipurpose check connector (on right side of transaxle) vehicle speed sensor Accel position sensor (at rear of engine) Camshaft position sensor (at left front of engine) Crankshaft position sensor (at left front of engine) Cruise control module (on right side of engine compt) E/r-d Engine compartment junction block (on left side of e/r-g engine compt) Etacm Fuel tank pressure sensor (above left rear of fuel tank, beneath vehicle) Fuse 10a G103 (under center console) Hot in on or start I/p-b I/p-l I/p-m Idle switch Immobilizer control module (behind center of dash) Instrument cluster system Joint connector c133 (at left front of engine compt) Joint connector c135 (under center console) Joint connector m05 (behind lower left end of dash) Joint connector mo6 (behind lower left end of dash) Knock sensor (at left rear of engine) M13-3 Maf sensor Nca Passenger compartment junction block (behind lower left end of dash) Pnk Red Red red Throttle position sensor (on right side of throttle body) W/ immobilizer W/o immobilizer 3.5L, Engine Performance Wiring Diagram (5 of 5) for Hyundai Santa Fe 2004 List of elements for 3.5L, Engine Performance Wiring Diagram (5 of 5) for Hyundai Santa Fe 2004: 63 "1" "2" "3" "4" "5" (behind left front kick panel) g07 (on top rear of transaxle) transaxle range switch 2nd A/c sw on A/t pulse generator "a" (on left front of transaxle) A/t pulse generator "b" (on top front of transaxle) Air conditioning system Anti-lock brakes system Atm control relay (under center console) Atm solenoid valve (at top of transaxle) Battery C121-c C121-d Can D input Dcc Down shift Ecm flash Ftps sig Fuel sens Fuel temperature sensor (above left rear of fuel tank, beneath vehicle) G104 (under center console) G11 (under center console) Gnd Idle sw Instrument cluster Joint connector c135 (under center console) K-line Ks sig M15-5 M15-7 Map sens sig Mil ind N input Normal O/t Oil temp sensor On/start in P input Pnk Powertrain control module (pcm) (below center of dash) Pulse gen a Pulse gen b R input Red Red red Select Select sw Select switch Sens gnd Sens pwr 5v Sens sig Sig Sport mode switch Starting/ charging system Stop lmp sw Up shift Vss in
EXTERIOR LIGHTS Back-up Lamps Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Back-up Lamps Wiring Diagram for Hyundai Santa Fe 2004: 26 (behind left rear quarter- panel trim, near speaker) g11 (behind right rear quarter- panel trim, near speaker) g12 (except 3.5l) (3.5l) (or red) A/t Back-up lamp switch (on top center of transaxle) E/r-d E/r-g Engine compartment junction block (on left side of engine compartment) Fuse 25 10a Hot in on or start I/p-b I/p-f I/p-p J/c c33 (except 3.5l) j/c c133 (3.5l) (at left front of engine compartment) J/c c35 j/c c135 (c33: below center of dash) (c135: under center console) J/c m46 (at left center of floor) Left back up lamp Left rear combination lamp M/t Nca Passenger compartment junction block (behind lower left end of dash) Pnk Right back up lamp Right rear combination lamp Transaxle range switch (on top rear of transaxle) Exterior Lamps Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for Exterior Lamps Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 49 (at left front of engine compt, on inner fender panel) g05 (at right front of engine compt, near power steering fluid reservoir) g06 (behind left front kick panel) g07 (behind lower left end of dash) passenger compartment junction block (under tail gate trim, below rear wiper control module) g13 Anti-lock brakes, cruise control, engine controls & transmissions systems E/r-a Engine compartment junction block (on left side of engine compartment) Etacm Fuse 14 10a Fuse 27 10a Fuse 28 10a Fusible link (b+) 50a G11 (behind left rear quarterpanel trim, near speaker) G13 (under tail gate trim, below rear wiper control module) High- mounted stoplamp Hot at all times I/p-a I/p-c I/p-f I/p-l Joint connector m05 (behind lower left end of dash) Joint connector m46 (at left center of floor) Joint connector m47 (at left center of floor) Left license lamp Left rear combination lamp Left side marker lamp Light switch Luggage room lamp M13-1 M13-3 M20-2 Multi- function switch Nca Nca nca Off Park head Pnk Right license lamp Right rear combination lamp Right side marker lamp S/m Stop Stop lamp switch (above brake pedal, on bracket) Tail Taillamp relay Turn W/ cruise W/o cruise Exterior Lamps Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for Exterior Lamps Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 39 (at left front of engine compt, on inner fender panel) g05 (at right front of engine compt, near power steering fluid reservoir) g06 (behind left front kick panel) g07 Coil control Etacm (on rear of passenger compartment junction block) Flasher unit (beside passenger compartment junction block, on bracket) Fuse 15 10a Fuse 24 10a Ground Hazard relay (with b/ alarm) (behind left kick panel) Hazard relay ctrl Hazard switch Hot at all times Hot in on or start I/p-a I/p-f I/p-j I/p-l Illumination Instrument cluster Interior lights system Left Left turn indicator Left turn signal lamp (park/turn) M13-2 M15-5 M15-6 M20-2 Multi- function switch Nca Off Passenger compartment junction block (behind lower left end of dash) Pnk Power Red Right Right turn indicator Right turn signal lamp (park/turn) Turn signal switch
GROUND DISTRIBUTION Ground Distribution Wiring Diagram (1 of 3) for Hyundai Santa Fe 2004 List of elements for Ground Distribution Wiring Diagram (1 of 3) for Hyundai Santa Fe 2004: 72 (2.4l w/ a/t) (2.7l) transmission control module (3.5l) (a/t) (a/t) powertrain control module (a/t) vehicle speed sensor (delphi) amplifier speaker 1 (except 3.5l) (except 3.5l) (under center console, near srs control module) (m/t) (m/t) engine control module 2.4l 2.7l 3.5l A/t Atm control relay Brake fluid level sensor C116 C121-b C121-c C136 C16 C21-b C21-c C22-a C22-d C23-v C23-z C24-1 C24-3 C36 C46 C46-1 Camshaft position sensor Crankshaft position sensor Data link connector Engine control module Ets control module Except 3.5l Front oxygen sensor shield Front wiper motor G01 (on body, near right front of engine) G02 (2.7l) (under center console, near srs control module) G03 (under center console, near srs control module) G04 g104 (3.5l) (under center console) G10 (on inner rocker panel, under passenger seat) G103 (under center console) G12 (under right rear quarterpanel trim, near speaker) Ignition coil 1 Ignition coil 2 Ignition coil 3 Ignition coil shield Ignition failure sensor Knock sensor Knock sensor shield Nca Pcm Pcm shield Powertrain control module Rear oxygen sensor shield Right front amplifier speaker Right front door lock actuator Right front power window switch Right front unlock switch Right power outside mirror motor & defogger Right rear amplifier speaker Right rear amplifier speaker shield Right rear combination lamp Right rear door lock actuator Right rear power window switch Sport mode switch illumination Vehicle speed sensor Ground Distribution Wiring Diagram (2 of 3) for Hyundai Santa Fe 2004 List of elements for Ground Distribution Wiring Diagram (2 of 3) for Hyundai Santa Fe 2004: 68 (on left side of engine compt) engine compartment junction block 2.4l, 3.5l 2.7l A/c compressor A/c diode A/c relay A/t Abs control module Air bleeding connector Auto light sensor Clutch pedal position switch Condenser fan motor Condenser fan relay 2 Cruise control module Data link connector Drl control module E/r-c E/r-d E/r-e E/r-f E/r-g Electrical chrome mirror Engine compartment junction block (on left side of engine compt) Etacm Flasher unit G05 (at left front of engine compt, on inner fender panel) G06 (at right front of engine compt, near power steering fluid reservoir) G07 (partial) (behind left front kick panel) Head lamp relay Home link controller I/p-d I/p-h I/p-l Immobilizer control system Instrument cluster Junction block ground Key lock/ unlock relay Left fog lamp Left horn Left side marker lamp Left turn signal lamp Left vanity lamp M/t M13-3 M15-5 M15-6 M15-7 M20-1 M20-2 Map lamp Multi-function switch Multipurpose check connector Nca Overhead console Passenger compartment junction block (behind lower left end of dash) Pnk Rheostat Right fog lamp Right horn Right side marker lamp Right turn signal lamp Right vanity lamp Room lamp Start relay Stop lamp switch W/ sun roof W/o sun roof Wiper relay Ground Distribution Wiring Diagram (3 of 3) for Hyundai Santa Fe 2004 List of elements for Ground Distribution Wiring Diagram (3 of 3) for Hyundai Santa Fe 2004: 64 (3.5l) 4wd control module (delphi) audio head unit 2.7l A/c control module A11 A21 Audio Blower relay Blower switch C23-f Cigarette lighter & power outlet Digital clock Diode z07 (behind left rear quarterpanel) Engine control module Engine controls system Fuel sender & fuel pump motor Fuel temperature sensor Full auto a/c G08 (behind right front kick panel) G09 (on inner rocker panel, under driver seat) G11 (behind left rear quarterpanel trim, near speaker) G13 (under tail gate trim, below rear wiper control module) G14 (under center console, near srs control module) G15 (under center of dash, on left center support bracket) Glove box lamp High blower relay High- mounted stop lamp Left front amplifier speaker Left front door lock actuator Left front lock/ unlock switch Left front seat warmer Left front seat warmer switch Left license lamp Left power outside mirror motor & defogger Left rear amplifier speaker Left rear amplifier speaker shield Left rear combination lamp Left rear door lock actuator Left rear power window switch Luggage room lamp M32-1 M94-1 M94-2 Manual a/c Mode actuator Nca Power outside mirror switch Power seat adjuster switch Power transistor Power window main switch Rear power outlet Rear window defogger (-) Rear window defogger switch Rear window switch Rear wiper motor control module Red Right front seat warmer Right front seat warmer switch Right license lamp Seat belt switch Srs control module Tailgate lock actuator Tailgate unlock switch Thermostatic switch
HEADLIGHTS Headlights Wiring Diagram, with Autolamps for Hyundai Santa Fe 2004 List of elements for Headlights Wiring Diagram, with Autolamps for Hyundai Santa Fe 2004: 61 (behind left front kick panel) g07 (behind lower left side of dash) diode z01 (on left side of engine compartment) engine compartment junction block Auto Auto light sensor (on top center of dash) Cpu/sensor Dimmer/ passing switch Diode z02 (behind lower left side of dash) E/r-a E/r-c E/r-d E/r-e Engine compartment junction block (on left side of engine compt) Etacm Flash Foglamp relay Front fog fuse 15a Front foglamp switch Fuse 10a Fusible link (b+) 50a G05 (at left front of engine compt, on inner fender panel) G07 (behind left front kick panel) Head Headlamp fuse (left) 10a Headlamp fuse (right) 10a Headlamp relay High High beam ind Hot at all times Hot in on Hot in on or start I/p-b I/p-c I/p-h I/p-l I/p-m Illumination Indicator Instrument cluster Interior lights system J/c m04 (behind lower left end of dash) Joint connector m05 (behind lower left end of dash) Left fog lamp Left headlamp Light switch Low M13-1 M13-3 M15-5 M20-2 Multi-function switch Nca Off Park Park head Passenger compartment junction block (behind lower left end of dash) Pnk Red Right fog lamp Right headlamp Taillamp relay Headlights Wiring Diagram, with DRL (1 of 2) for Hyundai Santa Fe 2004 List of elements for Headlights Wiring Diagram, with DRL (1 of 2) for Hyundai Santa Fe 2004: 43 (behind left front kick panel) g07 (not used) Daytime running lights control module (at left front corner of engine compt) Dimmer/ passing switch Drl resistor Engine running input Etacm Flash Fuse 10a G05 (at left front of engine compt, on inner fender panel) G07 (behind left front kick panel) Ground Head Headlamp relay Headlamp relay control High Hot in on Hot in on or start I/p-b I/p-c I/p-h I/p-l Ind (power) Ind control Joint connector m05 (behind lower left end of dash) Joint connector m06 (behind lower left end of dash) Light switch Low M13-1 M13-3 M20-2 Memory power Multi-function switch Nca Off Park Parking brake Parking brake switch (on base of parking brake lever) Passenger compartment junction block (behind lower left end of dash) Pnk Pre- excitation resistor Red Taillamp relay Headlights Wiring Diagram, with DRL (2 of 2) for Hyundai Santa Fe 2004 List of elements for Headlights Wiring Diagram, with DRL (2 of 2) for Hyundai Santa Fe 2004: 30 (behind lower left side of dash) diode z01 Daytime running lamps resistor (at left front corner of engine compt) Diode z02 (behind lower left side of dash) E/r-a E/r-c E/r-d E/r-e Engine compartment junction block (on left side of engine compartment) Foglamp relay Front fog fuse 15a Front foglamp switch Fusible link (b+) 50a G05 (at left front of engine compt, on inner fender panel) Headlamp fuse (left) 10a Headlamp fuse (right) 10a High beam ind Hot at all times Illumination Indicator Instru- ment cluster Interior lights system Joint connector m04 (behind lower left end of dash) Left fog lamp Left headlamp M15-5 Nca Pnk Red Right fog lamp Right headlamp Headlights Wiring Diagram, without DRL for Hyundai Santa Fe 2004 List of elements for Headlights Wiring Diagram, without DRL for Hyundai Santa Fe 2004: 54 (behind left front kick panel) g07 (behind lower left side of dash) diode z01 (on left side of engine compartment) engine compartment junction block Dimmer/ passing switch Diode z02 (behind lower left side of dash) E/r-a E/r-c E/r-d E/r-e Engine compartment junction block (on left side of engine compt) Etacm Flash Foglamp relay Front fog fuse 15a Front foglamp switch Fuse 10a Fusible link (b+) 50a G05 (at left front of engine compt, on inner fender panel) G07 (behind left front kick panel) Head Headlamp fuse (left) 10a Headlamp fuse (right) 10a Headlamp relay High High beam ind Hot at all times Hot in on I/p-b I/p-c I/p-h I/p-l Illumination Indicator Instrument cluster Interior lights system J/c m04 (behind lower left end of dash) Joint connector m05 (behind lower left end of dash) Left fog lamp Left headlamp Light switch Low M13-1 M13-3 M15-5 M20-2 Multi-function switch Off Park Passenger compartment junction block (behind lower left end of dash) Pnk Red Right fog lamp Right headlamp Taillamp relay
HORN Horn Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Horn Wiring Diagram for Hyundai Santa Fe 2004: 16 Clock spring E/r-c E/r-d Engine compartment junction block (on left side of engine compt) G05 (at left front of engine compt, on inner fender panel) G06 (at right front of engine compt, near power steering fluid reservoir) Horn fuse 10a Horn relay Horn switch Hot at all times Left horn (left of left radiator support) M20-3 Multifunction switch Nca Right horn (right of right radiator support) Steering wheel
INSTRUMENT CLUSTER Instrument Cluster Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for Instrument Cluster Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 67 (2.4l) (2.7l) (3.5l) (4 bulbs) illumination (at center of tail gate) rear window switch (or pnk) A/t Abs indicator Anti-lock brakes system Anti-theft system Brake indicator C121-d C21-d C24-1 Charge indicator Cruise control system Cruise indicator Diode z03 (below driver seat) Door ajar indicator Engine controls system Engine coolant temperature gauge Engine coolant temperature sensor & sender (2.4l: on rear of cylinder head) (3.5l: at left front of engine) (2.7l: on rear of left cylinder head) Exterior lights system Fuel gauge Fuse 10a G07 (behind left front kick panel) Headlights system Hot at all times Hot in on or start I/p-l I/p-m I/p-p Immobilizer indicator Indicator high beam Indicator srs Instrument cluster Interior lights system J/c m05 (behind lower left end of dash) Joint connector m47 (at left center of floor) Left turn indicator Low fuel ind M/t M15-5 M15-6 M15-7 Malfunction indicator lamp (mil) "check engine" Micom Nca Odo/trip Oil pressure indicator Oil pressure switch Oil pressure switch (2.4l: at right rear of engine) (2.7l: on lower left front of engine, near oil filter) (3.5l: at left front of engine) Passenger compartment junction block (behind lower left end of dash) Pcm (2.4l & 3.5l) tcm (2.7l) (below center of dash) Pnk Right turn indicator Seat belt indicator Solid state Speedometer Starting/charging system Tachometer Tail gate ajar indicator Tail gate switch (at lower center of tail gate) Tcs indicator Tcs off ind (3.5l) Vehicle speed sensor (on right side of transaxle) Warning system Instrument Cluster Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for Instrument Cluster Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 85 (2.4l) (3.5l) (at left ``b" pillar) (except 3.5l) (3.5l) (forward of left rear wheelwell) (inside fuel tank, beneath left rear seat) fuel sender (on body, near right front of engine) g01 (on inner rocker panel, under driver seat) g09 (or pnk) (or red) (w/ sunroof) (w/o sunroof) 2.4l w/ a/t 2.4l w/ m/t 2.7l 3.5l A/t Acc/on in Brake fluid level sensor (on right side of brake master cylinder) C121-b C21-b C21-b c121-b C22-c C22-d C23-f Digital clock/ calendar Dim input Diode z05 (below left kick panel) Door ajar ind control Drl control module (at left front corner of engine compt) E/r-d E/r-g Ecm (below center of dash) Ecm/pcm (below center of dash) Empty Engine compartment junction block (on left side of engine compartment) Etacm Except 2.7l Fuel level float Fuel sender Fuel sender & fuel pump motor (inside fuel tank, beneath left rear seat) Full Fuse 11 10a fuse 12 15a Fuse 25 10a Fuse 3 15a G07 (behind left front kick panel) G08 (behind right front kick panel) Gauge sender Ground Hot at all times Hot in acc or on Hot in on or start I/p-b I/p-d I/p-e I/p-j I/p-l Indicator control Interior lights system J/c c33 (except 3.5l) j/c c133 (3.5l) (at left front of engine compt) J/c c35 j/c c135 (except 3.5l: below center of dash) (3.5l: under center console) J/c m06 (behind lower left end of dash) J/c m47 (at left center of floor) Left front door switch Left rear door switch M/t M13-1 M13-3 Memory pwr Nca Normal Overhead console lamp Parking brake Parking brake switch (on base of parking brake lever) Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Right front door switch (at right ``b" pillar) Right rear door switch (forward of right rear wheelwell) Select Select switch Sport mode switch Transaxle range switch (on top rear of transaxle) Transmissions system W/ sunroof W/o sunroof
INTERIOR LIGHTS Courtesy Lamps Wiring Diagram, with Sunroof for Hyundai Santa Fe 2004 List of elements for Courtesy Lamps Wiring Diagram, with Sunroof for Hyundai Santa Fe 2004: 51 (at left ``b" pillar) (at right ``b" pillar) Diode z03 (below driver seat) Door Door ajar ind control Door switch Etacm Fuse 11 10a Fuse 28 10a G07 (behind left front kick panel) G11 (under left rear quarterpanel trim, near speaker) G13 (under tailgate trim, below rear wiper control module) Ground Hot at all times Hot with taillamp I/p-d I/p-e I/p-f I/p-j I/p-l I/p-p Instrument cluster Joint connector m47 (at left center of floor) Junction block ground Left front door lamp Left front door switch Left rear door switch (forward of left rear wheelwell) Left vanity lamp Luggage room lamp M13-3 M15-5 Map lamp Mirrors system Nca Off Overhead console lamp Passenger compartment junction block (behind lower left end of dash) Pnk Rear window switch (at center of tail gate) Red Relay energized Right front door lamp Right front door switch Right rear door switch (forward of right rear wheelwell) Right vanity lamp Room lamp Room lamp control Tail gate ajar ind Tail gate switch (at lower center of tail gate) Tailgate sw Warning system Courtesy Lamps Wiring Diagram, without Sunroof for Hyundai Santa Fe 2004 List of elements for Courtesy Lamps Wiring Diagram, without Sunroof for Hyundai Santa Fe 2004: 48 (at right ``b" pillar) 10a Diode z03 (below driver seat) Door Door ajar ind control Door switch Etacm Fuse 11 Fuse 28 G07 (behind left front kick panel) G11 (under left rear quarterpanel trim, near speaker) G13 (under tailgate trim, below rear wiper control module) Ground Hot at all times Hot with taillamp relay energized I/p-d I/p-e I/p-f I/p-j I/p-l I/p-p Instrument cluster Joint connector m47 (at left center of floor) Junction block ground Left front door lamp Left front door switch (at left ``b" pillar) Left rear door switch (forward of left rear wheelwell) Left vanity lamp Luggage room lamp M13-3 M15-5 Map lamp Nca Off Passenger compartment junction block (behind lower left end of dash) Pnk Rear window switch (at center of tail gate) Red Right front door lamp Right front door switch Right rear door switch (forward of right rear wheelwell) Right vanity lamp Room lamp Room lamp control Tail gate ajar ind Tail gate switch (at lower center of tail gate) Tailgate sw Warning system Instrument Illumination Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Instrument Illumination Wiring Diagram for Hyundai Santa Fe 2004: 67 (+) (-) (behind center of dash) (except 3.5l) (3.5l) A/c control module (full auto: behind center of dash) Ashtray illum Audio Audio head unit Automatic a/c Cigarette lighter & power outlet Compartment) Control Digital calendar Digital clock Dimmer E/r-a Engine compartment junction block (on left side of engine Etacm Front fog lamp switch Fuse 10a Fusible link (b+) 50a G04 g104 (except 3.5l: under center console, near srs control module) (3.5l: under center console) G07 (behind left front kick panel) G08 (behind right front kick panel) G09 (on inner rocker panel, under driver seat) G10 (on inner rocker panel, under passenger seat) Glove box lamp Gnd Hazard switch Head Hot at all times I/p-b I/p-c I/p-d I/p-l Illumination Instrument cluster Joint connector m05 (behind lower left end of dash) Joint connector m39 (at left rear of engine compt, under cowl) Joint connector m40 (at left rear of engine compt, under cowl) Left front seat warmer switch Left rear power window switch Light switch M13-1 M13-3 M15-6 M20-2 M32-1 Manual a/c control module Multifunction switch Nca Off Overhead console lamp Park Passenger compartment junction block (behind lower left end of dash) Pnk Power window maim switch Rear window defogger switch Rheostat Right front power window switch Right front seat warmer switch Right rear power window switch Sport mode switch illumination Taillamp relay Tcs switch (3.5l) W/ sunroof W/o sunroof
POWER DISTRIBUTION Power Distribution Wiring Diagram (1 of 5) for Hyundai Santa Fe 2004 List of elements for Power Distribution Wiring Diagram (1 of 5) for Hyundai Santa Fe 2004: 71 (not used) (on left side of engine compartment) engine compartment junction block A/c fuse 10a A/c relay A/t Abs control module Acc Air bleeding connector Ashtray illumination Audio Audio head unit (delphi) Battery Blower relay Body ground C21-b Cigarette lighter & power outlet Digital clock E/r-a E/r-b E/r-d E/r-e Engine ground Ets control module Fuse 1 20a Fuse 2 10a Fuse 3 15a Fusible link (abs 1) 30a Fusible link (abs 2) 30a Fusible link (alt) 120a Fusible link (b+) 50a Fusible link (blr) 40a Fusible link (ign) 50a G08 (behind right front kick panel) G11 (behind left rear quarterpanel trim, near speaker) Generator I/p-d I/p-f I/p-h I/p-j I/p-l I/p-p Ignition lock switch Ignition switch Illumi- nation Interior lights system J/c m46 (at left center of floor) Lock M/t Nca Off Overhead console lamp Passenger compartment junction block (behind lower left end of dash) Pcm Pnk Power outlet Power outside mirror switch Rear power outlet Red St sig fuse 10a Start Start motor Start relay Start solenoid To fusible link (p/w) 30a (diagram 2 of 5) To headlamp fuse (right) 10a (diagram 2 of 5) To passenger compartment junction block (fuse 18, 30a) (diagram 4 of 5) To passenger compartment junction block (fuse 5, 10a) (diagram 3 of 5) To passenger compartment junction block (power connector) (diagram 5 of 5) Transaxle range switch W/ sun roof W/o sun roof Power Distribution Wiring Diagram (2 of 5) for Hyundai Santa Fe 2004 List of elements for Power Distribution Wiring Diagram (2 of 5) for Hyundai Santa Fe 2004: 79 (2.4l) (2.4l, a/t) (2.7l) (3.5l) (on left side of engine compartment) engine compartment junction block (or red) 2.4l 2.4l, 3.5l 2.7l 2.7l, 3.5l 3.5l 4wd control module (3.5l) A/c relay A/t A/t, 3.5l Atm control relay Atm fuse 20a C121-b C21-b C22-b C22-d C23-p C23-v C24-2 Condenser fan relay 1 Door lock relay Door unlock relay Drl control module E/r-b E/r-d E/r-e E/r-f E/r-g E/r-h E/r-j Ecu (b+) fuse 15a Ecu 2 fuse 20a Engine control module Engine control module (2.7l) Engine control relay Fog lamp relay From ecu (b+) fuse, f 15a (diagram 2 of 5) From fusible b link (b+) 50a (diagram 1 of 5) From fusible link a (alt) 120a (diagram 1 of 5) Front fog lamp fuse 15a Fuel pump relay Fuse 20a Fusible link (condenser fan) 20a Fusible link (ecu) 40a Fusible link (p/w) 30a Fusible link (radiator fan) 40a Generator Headlamp fuse (left) 10a Headlamp fuse (right) 10a Horn fuse 10a Horn relay I/p-a I/p-m Injector Instrument cluster Key lock/unlock relay Left headlamp M/t M15-5 Nca Oxygen sensor (bank 1/ sensor 2) Oxygen sensor (bank 2/ sensor 2) Passenger compartment junction block (behind lower left end of dash) Pnk Power window relay Powertrain control module Radiator fan relay Red Right headlamp To engine compartment junction block (ecu 1 fuse, 20a) (diagram 3 of 5) To fusible link (ecu) 40a (diagram 2 of 5) Transmission control module (2.7l) W/ drl W/o drl Power Distribution Wiring Diagram (3 of 5) for Hyundai Santa Fe 2004 List of elements for Power Distribution Wiring Diagram (3 of 5) for Hyundai Santa Fe 2004: 99 (2.7l) (3.5l) (3.5l) ets control module (3.5l) limp home valve (3.5l, (3.5l, 2.4l) (except (not used) (on left side of engine compt) engine compartment junction block 2.4l 2.4l) (2.7l) 2.4l, 3.5l 2.7l 3.5l 3.5l) 3.5l, 2.4l A/c control module (automatic) A/t Auto- matic a/c Blower relay Blower relay (automatic) C121-b C21-b C22-a C23-v Camshaft position sensor Canister close valve Clock spring Condenser fan relay 1 Condenser fan relay 2 Crankshaft position sensor Cruise control module Cruise remote control switch E/r-c E/r-e E/r-f E/r-g E/r-h Ecu 1 fuse 20a Ecu 3 fuse 10a Egr solenoid Egr solenoid valve Electrical chrome mirror Engine compartment junction block (on left side of engine compt) Engine control module Etacm Except 3.5l Fail safety relay From engine compartment g junction block (a/c relay) (diagram 2 of 5) From ignition switch (diagram 1 of 5) Front oxygen sensor (2.4l) oxygen sensor (bank 2/ sensor 1) (3.5l) Front wiper motor Fuse 10a Fuse 20a Fuse 25a Headlamp relay Home link controller I/p-a I/p-b I/p-d I/p-e I/p-h I/p-j I/p-l Idle speed control actuator Ignition coil Ignition failure sensor J/c c33 (except 3.5l) j/c c133 (3.5l) (at left front of engine compt) J/c m04 (behind lower left end of dash) Left front seat warmer switch M/t M13-3 M20-3 M32-1 M87-2 Manual a/c Manual a/c control module Mass air flow sensor Mode actuator Mode actuator (automatic) Multi- function switch Nca Oxygen sensor (bank 1/ sensor 1) Oxygen sensor (bank 1/ sensor 2) (3.5l) Oxygen sensor (bank 2/ sensor 1) Passenger compartment junction block (behind lower left end of dash) Pnk Powertrain control module Purge control solenoid valve Radiator fan relay Rear oxygen sensor (2.4l) Rear wiper motor control module Red Relay box Right front seat warmer switch Stop lamp switch (w/ cruise control) Sunroof controller Washer motor Wiper relay Power Distribution Wiring Diagram (4 of 5) for Hyundai Santa Fe 2004 List of elements for Power Distribution Wiring Diagram (4 of 5) for Hyundai Santa Fe 2004: 65 (3.5l) ets control module (diagram 1 of 5) 2.4l 2.7l 3.5l 4wd control module A/t A/t pulse generator a A/t pulse generator b Abs control module Air bleeding connector Auto light sensor Back-up lamp switch C121-c C21-c C22-d C23-v C24-1 Defogger relay E/r-d E/r-g Engine compartment junction block (on left side of engine compartment) Engine control module Etacm Except 3.5l From h fuse 21, 10a (diagram 4 of 5) From ignition switch d Fuse 10a Fuse 15a Fuse 30a G-sensor (4wd) Hazard switch I/p-b I/p-f I/p-h I/p-j I/p-k I/p-l I/p-m I/p-p Ignition failure sensor Immobilizer control module Instrument cluster J/c c33 (except 3.5l) j/c c133 (3.5l) (at left front of engine compartment) J/c m05 (behind lower left end of dash) Left power outside mirror motor & defogger M/t M13-3 M15-5 M15-6 Nca Passenger compartment junction block (behind lower left end of dash) Pcm Powertrain control module Pre- excitation resistor Rear window defogger (+) Rear window defogger switch Red Right power outside mirror motor & defogger Srs control module Tcs switch To fuse 22, 10a (diagram 4 of 5) Transaxle range switch Transmission control module Vehicle speed sensor Power Distribution Wiring Diagram (5 of 5) for Hyundai Santa Fe 2004 List of elements for Power Distribution Wiring Diagram (5 of 5) for Hyundai Santa Fe 2004: 91 (at left center of floor) j/c m46 (behind lower left end of dash) j/c m05 (behind lower left end of dash) passenger compartment junction block (w/ cruise) (w/o cruise) A/c control module (automatic) Amplifier speaker 1 Audio Audio head unit (delphi) Cigarette lighter & power outlet Data link connector Digital clock E/r-e Electrical chrome mirror Engine compartment junction block (on left side of engine compt) Etacm Fog lamp relay From fuse 13, 20a (diagram 5 of 5) From fusible link (b+), 50a (diagram 1 of 5) Front fog lamp switch Fuse 10a Fuse 15a Fuse 20a Fuse 25a Glove box lamp Hazard relay Hazard switch I/p-a I/p-b I/p-c I/p-d I/p-e I/p-f I/p-j I/p-l I/p-p Ignition key illumination & door warning switch Immobilizer control module Instrument cluster J/c m40 (at left rear of engine compt, under cowl) J/c m46 (at left center of floor) Left front amplifier speaker Left front door lamp Left front seat warmer switch Left license lamp Left rear amplifier speaker Left rear combination lamp Left rear power window switch Left side marker lamp Left turn signal lamp Left vanity lamp Luggage room lamp M13-3 M15-5 M15-6 M32-1 Manual a/c control module Map lamp Multi- purpose check connector Nca Overhead console lamp Passenger compartment junction block (behind lower left end of dash) Pnk Power connector Power seat adjuster switch Power window main switch R07-1 Rear window defogger switch Rear wiper motor control module Red Rheostat Right front amplifier speaker Right front door lamp Right front power window switch Right front seat warmer switch Right license lamp Right rear amplifier speaker Right rear combination lamp Right rear power window switch Right side marker lamp Right turn signal lamp Right vanity lamp Room lamp Siren Sport mode switch illumination Stoplamp switch Sunroof controller Tail- lamp relay To fuse 14, 10a (diagram 5 of 5) W/ sunroof W/o sunroof
POWER DOOR LOCKS Power Door Locks Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Power Door Locks Wiring Diagram for Hyundai Santa Fe 2004: 34 (at left center of floor) j/c m46 (at left center of floor) j/c m47 (on inner rocker panel, under driver seat) g09 87a Door lock relay Door lock/ unlock switch Door unlock relay Etacm (on rear of passenger compt junction block) Fuse 20a G07 (behind left front kick panel) G09 (on inner rocker panel, under driver seat) G10 (on inner rocker panel, under passenger seat) G13 (under tail gate trim, below rear wiper control module) Ground distribution system Hot at all times I/p-e I/p-j I/p-m I/p-p J/c m46 (at left center of floor) Junction block ground Key lock/ unlock relay (behind right kick panel) Left front door lock actuator (at rear of left front door) Left rear door lock actuator (at rear of left rear door) Lock M13-1 M13-2 M13-3 Passenger compartment junction block (behind lower left end of dash) Power outside mirror switch Right front door lock actuator (at rear of right front door) Right rear door lock actuator (at rear of right rear door) Tail gate lock actuator (inside lower center of tail gate) Unlock
POWER MIRRORS Electrochromic Mirror Wiring Diagram, with Home Link for Hyundai Santa Fe 2004 List of elements for Electrochromic Mirror Wiring Diagram, with Home Link for Hyundai Santa Fe 2004: 43 (except 3.5l) (3.5l) (not used) A/t Back-up lamp switch (on top center of transaxle) E/r-d E/r-g Ec mirror control Electronic chrome mirror Engine compartment junction block (on left side of engine compartment) Fuse 11 10a Fuse 25 10a Fuse 9 10a G07 (behind left front kick panel) Gnd Hl 1 Hl 2 Hl 3 Home link Hot at all times Hot in on Hot in on or start I/p-b I/p-d I/p-l I/p-p Interior lights system Joint connector c33 c133 (at left front of engine compartment) Joint connector c35 c135 (c35: below center of dash) (c135: under center console) M/t Map lamp Memory power Nca Off On in Passenger compartment junction block (behind lower left end of dash) Pnk Power connector Red Reverse Room lamp Transaxle range switch (3.5l) (at top rear of transaxle) W/ sunroof W/o sunroof Electrochromic Mirror Wiring Diagram, without Home Link for Hyundai Santa Fe 2004 List of elements for Electrochromic Mirror Wiring Diagram, without Home Link for Hyundai Santa Fe 2004: 30 (except 3.5l) (3.5l) A/t Back-up lamp switch (on top center of transaxle) E/r-d E/r-g Electrical chrome mirror Engine compartment junction block (on left side of engine compartment) Fuse 25 10a Fuse 9 10a G07 (behind left front kick panel) Ground Hot in on Hot in on or start I/p-b I/p-d I/p-l I/p-p Joint connector c33 c133 (at left front of engine compartment) Joint connector c35 c135 (c35: below center of dash) (c135: under center console) M/t Map lamp Nca On input Passenger compartment junction block (behind lower left end of dash) Pnk Reverse input Room lamp Transaxle range switch (top rear of transaxle) W/ sunroof W/o sunroof Power Mirrors Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Power Mirrors Wiring Diagram for Hyundai Santa Fe 2004: 20 Defogger Defogger system Down Fuse 2 10a G09 (on inner rocker panel, under driver seat) Hot in acc or on I/p-j Left Left power outside mirror motor & defogger (at mirror) Left/right switch M down up/ Nca Passenger compartment junction block (behind lower left end of dash) Power outside mirror switch Red Right Right left/ Right power outside mirror motor & defogger (at mirror) Selector switch Up/down switch
POWER SEATS Heated Seats Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Heated Seats Wiring Diagram for Hyundai Santa Fe 2004: 18 (under driver's seat) (under front passenger's seat) Fuse 6 25a G09 (on inner rocker panel, under driver seat) Hot in on I/p-e Illum Ind Interior lights system Left front seat warmer Left front seat warmer switch Nca Passenger compartment junction block (behind lower left end of dash) Red Right front seat warmer Right front seat warmer switch Thermostat Warmer Power Seat Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Power Seat Wiring Diagram for Hyundai Santa Fe 2004: 22 (on inner rocker panel, under driver seat) g09 Back Down Forward Front height Front height adjuster (under driver's seat) Fuse 25a Fwd Hot at all times I/p-f M94-1 M94-2 Nca Passenger compartment junction block (behind lower left end of dash) Power seat adjuster switch Rear height Rear height adjuster (under driver's seat) Reclining Reclining adjuster Red Slide Slide adjuster
POWER TOP/SUNROOF Power Top/Sunroof Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Power Top/Sunroof Wiring Diagram for Hyundai Santa Fe 2004: 45 B+ (s/roof) Ccw(-) Cf-12v relay Close Cpu Cw(+) Digital clock acc/on input Dimmer Door switch signal (room lamp) Etacm Exterior lights system Fuse 10a Fuse 20a G07 (behind left front kick panel) Ground Hot at all times Hot in on I/p-d I/p-l Ig2 Instrument cluster system Interior lights system Limit switch M13-3 M87-1 M87-2 M88-1 Memory power Memory systems Motor N c N o Nca Open Overhead console lamp Passenger compartment junction block (behind lower left end of dash) Pnk S/close S/open Signal Sunroof controller (at front center of roof) Sunroof motor Switch T/down T/up
POWER WINDOWS Power Windows Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Power Windows Wiring Diagram for Hyundai Santa Fe 2004: 39 Auto down/up control unit Down E/r-b Engine compartment junction block (on left side of engine compt) Etacm Express down Fusible link (p/w) 30a G09 (on inner rocker panel, under driver seat) Hot at all times I/p-a I/p-h I/p-j Illum Interior lights system Joint connector m45 (at left center of floor) Left front power window motor (in left front door) Left front window switch Left rear power window motor (in left rear door) Left rear power window switch Left rear window switch Lock Lock switch M13-3 Nca Off Off dn Passenger compartment junction block (behind lower left end of dash) Pnk Power outside mirror switch Power window main switch Power window relay Red Right front power window motor (in right front door) Right front power window switch Right front window switch Right rear power window motor (in right rear door) Right rear power window switch Right rear window switch Unlk
RADIO Radio Wiring Diagram, Delphi for Hyundai Santa Fe 2004 List of elements for Radio Wiring Diagram, Delphi for Hyundai Santa Fe 2004: 47 (under center of dash, on left center support bracket) g15 Acc/on in Amp Amp on Amp sensor Amplifier speaker 1 Amplifier speaker 2 Audio head unit Fuse 12 15a Fuse 13 20a Fuse 2 10a G10 (on inner rocker panel, under passenger seat) Ground Hot at all times Hot in acc or on I/p-j I/p-l Ill Interior lights system J/c mo5 (behind lower left end of dash) Left front Left front speaker Left front tweeter speaker Left rear Left rear speaker Lf speaker Lr speaker Mem power Mem pwr Mid (+) Mid (-) Nca Passenger compartment junction block (behind lower left end of dash) Pnk Power connector Red Rf speaker Right front Right front speaker Right front tweeter speaker Right rear Right rear speaker Rr speaker Speaker Sub (+) Sub (-) Tweeter speaker Radio Wiring Diagram, with Amplifier for Hyundai Santa Fe 2004 List of elements for Radio Wiring Diagram, with Amplifier for Hyundai Santa Fe 2004: 50 (behind left rear quarterpanel trim, near speaker) g11 (behind right rear quarterpanel trim, near speaker) g12 (on inner rocker panel, under passenger seat) g10 (under center of dash, on left center support bracket) g15 Acc/on in Antenna Audio Circuit F/cable Fuse 12 15a Fuse 13 20a Fuse 2 10a G09 (on inner rocker panel, under driver seat) Glass antenna module Ground Ground distribution system Hot at all times Hot in acc or on I/p-e I/p-j I/p-j red I/p-l Ill (+) Ill (-) Interior lights system J/c m45 (at left center of floor) J/c m46 (at left center of floor) J/c mo5 (behind lower left end of dash) Left front amplifier speaker Left front tweeter speaker Left rear amplifier speaker (at left rear quarterpanel) Left rear tweeter speaker Lf speaker Lr speaker M78 Mem pwr Nca Nca rem ctrl nca gnd nca tweeter spkr nca sig in nca mem pwr Nca tweeter spkr nca sig in nca Passenger compartment junction block (behind lower left end of dash) Pnk Qtr glass Red Remote ctrl Rf speaker Right front amplifier speaker Right front tweeter speaker Right rear amplifier speaker (at right rear quarterpanel) Right rear tweeter speaker Rr speaker Radio Wiring Diagram, without Amplifier for Hyundai Santa Fe 2004 List of elements for Radio Wiring Diagram, without Amplifier for Hyundai Santa Fe 2004: 34 (under center of dash, on left center support bracket) g15 Acc/on Antenna Audio Circuit F/cable Fuse 10a Fuse 15a Glass antenna module Ground Hot at all times Hot in acc or on I/p-j I/p-l Ill (+) Ill (-) Interior lights system J/c m05 (behind lower left end of dash) Left front door speaker Left front tweeter speaker Left rear speaker Lf spkr Lr spkr M78 Mem pwr Nca Passenger compartment junction block (behind lower left end of dash) Qtr glass Red Rf spkr Right front door speaker Right front tweeter speaker Right rear speaker Rr spkr
STARTING/CHARGING Charging Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Charging Wiring Diagram for Hyundai Santa Fe 2004: 27 (behind lower left end of dash) (behind lower left end of dash) joint connector m05 (on left side of engine compt) engine compartment junction block 2.7l Battery Body ground Charge indicator E/r-e E/r-j Ecu (b+) fuse 15a Engine ground Etacm Except 2.7l Fuse 10a Fusible link (alt) 120a Generator Hot in start or on I/p-b I/p-l I/p-m Instrument cluster M13-3 M15-5 M15-6 Passenger compartment junction block Pre- excitation resistor Red Starting Wiring Diagram, A/T for Hyundai Santa Fe 2004 List of elements for Starting Wiring Diagram, A/T for Hyundai Santa Fe 2004: 37 (below center of dash) powertrain control module 2.4l 2.7l 3.5l Acc Battery Body ground Burglar alarm relay C121-b C21-b E/r-b E/r-d E/r-e E/r-g E/r-j Engine compartment junction block (on left side of engine compt) Engine ground Etacm (on rear of passenger compt junction block) Ets control module (under center of dash) Except 2.7l Fusible link (alt) 120a Fusible link (ign) 50a G07 (behind left front kick panel) Ignition switch Lock M13-2 Nca Off Red St sig fuse 10a Start Start motor Start relay Start solenoid Transaxle range switch (2.4l & 2.7l: on top rear of transaxle) (3.5l: at top rear of transaxle) W/ burglar alarm W/o burglar alarm Starting Wiring Diagram, M/T for Hyundai Santa Fe 2004 List of elements for Starting Wiring Diagram, M/T for Hyundai Santa Fe 2004: 32 2.4l Acc Battery Body ground Burglar alarm relay C22-d E/r-b E/r-d E/r-e E/r-g E/r-j Engine compartment junction block (on left side of engine compt) Engine control module (below center of dash) Engine ground Etacm (on rear of passenger compt junction block) Fusible link (alt) 120a Fusible link (ign) 50a G07 (behind left front kick panel) Ignition lock switch (under left side of dash) Ignition switch Lock M13-2 Nca Off Red St sig fuse 10a Start Start motor Start relay Start solenoid W/ burglar alarm W/o burglar alarm
SUPPLEMENTAL RESTRAINTS Supplemental Restraints Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Supplemental Restraints Wiring Diagram for Hyundai Santa Fe 2004: 39 Air bag indicator (srs) Clock- spring Data link connector (partial) (behind lower left end of dash) Diagnosis Driver air bag Driver satellite sensor (near base of left "b" pillar) Driver seat belt pretensioner (at base of left ``b" pillar) Driver side air bag (under driver seat) Etacm Fuse 10a Fuse 15a G14 (under center console, near srs control module) Ground High High side Hot in on or start I/p-j I/p-k I/p-l Impact signal input Impact signal out Instrument cluster Low Low side M13-3 M15-5 Multi- function switch Nca On/start input Passenger air bag (behind right side of dash) Passenger compartment junction block (behind lower left end of dash) Passenger satellite sensor (near base of right "b" pillar) Passenger seat belt pretensioner (at base of right ``b" pillar) Passenger side air bag (under front passenger seat) Pnk Red Srs control module (below front of center console) Srs indicator ctrl Steering wheel
TRANSMISSION
2.4L 2.4L, A/T Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for 2.4L, A/T Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 43 Atm control relay (under center console) Atm fuse 20a Atm rly Battery C21-a C21-b C21-c Data link connector (behind lower left end of dash) E/r-f E/r-h Ect sens Ecu 3 fuse 10a Eng rly on Engine compartment junction block (on left side of engine compt) Engine coolant temperature sensor & sender (on rear of cylinder head) Fuse 10a G03 (under center console, near srs control module) G04 (under center console, near srs control module) Gnd Ground Hot at all times Hot in on or start Hot w/ engine control relay energized I/p-l Ign time adj Ignition Instrument cluster system J/c c33 (at left front of engine compt) J/c c34 (below center of dash) J/c c35 (below center of dash) K-line Multipurpose check connector (behind lower left end of dash) Nca Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Red Sender Sens gnd Sens pwr Sensor Throttle position sensor (on right side of throttle body) Tps sig 2.4L, A/T Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for 2.4L, A/T Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 50 "1" "2" "3" "4" 2nd A/t pulse generator "a" (on left front of transaxle) A/t pulse generator "b" (on top front of transaxle) Atm solenoid valve (on top rear of transaxle) C21-d D input Dcc Down shift E/r-d Ecm flash Engine compartment junction block e/r-g (on left side of engine compt) Exterior lights system Fuse 10a G07 (behind left front kick panel) Hot at all times Hot in on or start I/p-b I/p-l Instrument cluster J/c c33 (at left front of engine compt) J/c c35 (below center of dash) J/c m06 (behind lower left end of dash) M15-7 N input Normal O/t Oil temp sensor P input Passenger compartment junction block (behind lower left end of dash) Pnk Powertrain control module (below center of dash) Pulse a Pulse b R input Red Select Select sw Select switch Sport mode switch Starting/ charging system Stop sw Stoplamp switch (above brake pedal, on bracket) Transaxle range switch (on top rear of transaxle) Up shift W/ cruise W/o cruise
2.7L 2.7L, A/T Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 2.7L, A/T Wiring Diagram for Hyundai Santa Fe 2004: 81 (behind left front kick panel) (behind lower left end of dash) (behind lower left end of dash) j/c m06 (below center of dash) ecm (below center of dash) j/c c35 1 input 2 input 2nd 3 input 4 input A/t pulse generator "a" (on left front of transaxle) A/t pulse generator "b" (on top front of transaxle) Atm control relay (under center console) Atm fuse 20a Atm relay Atm solenoid valve (on top rear of transaxle) Auto cruise Battery C23-f C24-1 C24-2 C24-3 Charging system Comm Control module) Cruise control system D input Data link connector Dcc Dlc Dn shift Down shift E/r-d E/r-f E/r-g Ecm comm Ecu fuse 15a Engine compartment junction block (on left side of engine compt) Engine compartment junction block e/r-g (on left side of engine compt) Exterior lights system Fuse 10a G04 (under center console) (near srs control module) G04 (under center console, near srs G07 Gen a Gen b Ground Hot at all times Hot in on or start I/p-b I/p-l Ignition Instrument cluster J/c c33 (at left front of engine compt) J/c c35 (below ceneter of dash) J/c c35 (below center of dash) K-line M15-7 Memory Multipurpose check connector N input Normal Oil temp Oil temp sensor P input Passenger compartment junction block (behind lower left end of dash) Pnk R input Red Select Select sw Select switch Sport mode switch Starting/ Stop sw Stoplamp switch (above brake pedal, on bracket) Transaxle range switch (on rear top of transaxle) Transmission control module (tcm) (below center of dash) Up shift W/ cruise W/o cruise
3.5L 3.5L, 4WD Wiring Diagram for Hyundai Santa Fe 2004 List of elements for 3.5L, 4WD Wiring Diagram for Hyundai Santa Fe 2004: 43 4wd control module (under left side of rear seat) 4wd ind Atm fuse 20a C121-c Can Computer data lines system Dlc E/r-g Electronic magnetic valve clutch (under rear of vehicle) Emc Engine compartment junction block (on left side of engine compt) Flss gnd Flss input Frss gnd Frss input Fuse 10a G09 (on inner rocker panel, under driver seat) Gnd Ground Hot at all times Hot in on or start I/p-g I/p-m Instrument cluster J/c m05 (behind lower left end of dash) Left front wheel sensor (on left front wheel hub assembly) Left rear wheel sensor (at left rear wheelwell) M15-5 Memory power Nca On/start input Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Red Ref Right front wheel sensor (on right front wheel hub assembly) Right rear wheel sensor (at right rear wheelwell) Rlss gnd Rlss input Rrss gnd Rrss input Steering angle sensor W/o abs 3.5L, A/T Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004 List of elements for 3.5L, A/T Wiring Diagram (1 of 2) for Hyundai Santa Fe 2004: 48 (at left front of engine compt) j/c c133 Atm control relay (under center console) Atm fuse 20a Atm rly Battery C121-a C121-b C121-c Data link connector (behind lower left end of dash) E/r-d E/r-f E/r-g E/r-h Ect sens Ecu 3 fuse 10a Engine compartment junction block (on left side of engine compt) Engine controls system Engine coolant temperature sensor & sender (at rear of engine) Engine ctrl relay on in Ets control module (under center of dash) Fuse 10a G04 (under center console, near srs control module) G103 (under center console) G104 (under center console) Gnd Ground Hot at all times Hot in on or start Hot w/ engine control relay energized I/p-b Ign time adj Instrument cluster system J/c c134 (under center console) J/c c135 (under center console) K-line Memory power Multipurpose check connector (behind lower left end of dash) On/start in Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Red Sender Sens gnd Sens pwr Sens sig Sensor Throttle position sensor (on left side of throttle body) 3.5L, A/T Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004 List of elements for 3.5L, A/T Wiring Diagram (2 of 2) for Hyundai Santa Fe 2004: 46 "1" "2" "3" "4" "5" (behind lower left end of dash) j/c m06 2nd A/t pulse generator "a" (on left front of transaxle) A/t pulse generator "b" (on top front of transaxle) Atm solenoid valve (on top rear of transaxle) C121-d D input Dcc Down shift Exterior lights system Fuse 10a G07 (behind left front kick panel) Hot at all times I/p-l Instrument cluster J/c c135 (under center console) M15-7 N input Normal O/t Oil temp sensor P input Passenger compartment junction block (behind lower left end of dash) Pcm (below center of dash) Pnk Pulse a Pulse b R input Red Select Select sw Select switch Sport mode switch Starting/ charging system Stop sw Stoplamp switch (above brake pedal, on bracket) Tcm Transaxle range switch (on top rear of transaxle) Up shift W/ cruise W/o cruise
WARNING SYSTEMS Warning Systems Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Warning Systems Wiring Diagram for Hyundai Santa Fe 2004: 52 (at left center of floor) j/c m47 Chime bell Chime bell (on left kick panel) Door ajar ind Door ajar sw Door sw in Door warn sw Etacm Fuse 11 10a Fuse 12 15a Fuse 19 10a Fuse 9 10a G07 (behind left front kick panel) G09 (on inner rocker panel, under driver seat) Ground Head Hot at all times Hot in on Hot in on or start I/p-e I/p-f I/p-j I/p-l I/p-m I/p-p Ignition key illumination & door warning switch Illum ctrl Instrument cluster Instrument cluster system Interior lights system J/c m05 (behind lower left end of dash) Junction block ground Left front door switch Light switch M13-1 M13-3 M15-5 M20-2 Memory pwr Multifunction switch Nca Off On input Park Passenger compartment junction block (behind lower left end of dash) Pnk Power connector Red Seat belt ind Seat belt switch Seat belt switch (in driver seat belt buckle) Start/on in
WIPER/WASHER Front Wiper/Washer Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Front Wiper/Washer Wiring Diagram for Hyundai Santa Fe 2004: 33 (behind left front kick panel) g07 (on body, near right front of engine) g01 Auto parking switch (shown with wipers at rest) Delay control E/r-c E/r-e E/r-f E/r-g Engine compartment junction block (on left side of engine compt) Etacm (on rear of passenger compt junction block) Front wiper motor (below left side of windshield) Fuse 31 20a G05 (at left front of engine compt, on inner fender panel) Hot in on I/p-a Int Int (time) M13-1 M20-1 Mist switch Multifunction switch Nca Off Passenger compartment junction block (behind lower left end of dash) Pnk Rear wiper/ washer circuit Red Washer input Washer motor (behind right front corner of bumper cover) Washer switch Wiper relay Wiper relay cntrl Wiper switch Rear Wiper/Washer Wiring Diagram for Hyundai Santa Fe 2004 List of elements for Rear Wiper/Washer Wiring Diagram for Hyundai Santa Fe 2004: 36 (below driver seat) diode z03 E/r-c E/r-e Engine compartment junction block (on left side of engine compt) Etacm Front wiper/ washer circuit Fuse 10a Fuse 20a Fuse 25a G07 (behind left front kick panel) G13 (under tailgate trim, below rear wiper control module) Hot at all times Hot in on I/p-a I/p-e I/p-f Int Joint connector m47 (at left center of floor) M13-3 M20-1 Multifunction switch Nca Off Passenger compartment junction block (behind lower left end of dash) Pnk R07 R07-1 Rear washer switch Rear window switch (at center of tail gate) Rear wiper motor (inside tailgate) Rear wiper motor control module (inside lower center of tailgate, behind trim panel) Rear wiper switch Red Tailgate switch Washer Washer motor (behind right front corner of bumper cover)
