VW GOLF 2009 – Radiator fan, variable for one speed/two speed radiator fan . Wiring diagrams, Pin Connector, Location – Wiring diagrams for cars
AUTOMOTIVE ELECTRICIANS PORTAL
VW GOLF 2009 – Radiator fan, variable for one speed/two speed radiator fan . Wiring diagrams, Pin Connector, Location
Wiring Diagram VW GOLF 2009 - Terminal 30 voltage supply relay - battery https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO Wiring Diagram VW GOLF 2009 - Radiator fan control unit - radiator fan J293 Radiator fan control unit J519 Onboard supply control unit J623 Engine control unit, in centre of plenum chamber T2v 2-pin connector, on radiator fan T4x 4-pin connector, on lower left of radiator fan T80 80-pin connector T94 94-pin connector T121 121-pin connector V7 Radiator fan V177 Radiator fan 2 D111 Connection 9, in engine compartment wiring harness D180 Connection (87a), in engine compartment wiring harness * from November 2005 (not for engine codes BSE, BSF) ** up to October 2005 (not for engine codes BSE, BSF) --- engine code BSE, BSF only -●- only for models with increased blower output G83 - Radiator outlet coolant temperature sender ⇒ Engine Current Flow Diagram
VW GOLF 2009 Overview of relay carrier Overview of relay carrier q Relay assignment for E-box high, to May 2005
q Relay assignment for E-box high, from May 2005
q Relay assignment for E-box high, from November 2005
Relay carrier on onboard supply control unit
Relay carrier on left under dash panel
q Relay assignment for E-box low
q Relay assignment for E-box high, to May 2005
q Relay assignment for E-box high, from May 2005
Golf Fitting Locations No. 804 / 2
- Terminal 50 voltage supply relay -J682- (449)
q Relay assignment for E-box high, to May 2005
q Relay assignment for E-box low
q Relay assignment for E-box high, from May 2005
Relay locations on E-box low
1 - Terminal 30 voltage supply relay -J317- (458)
1 - Terminal 30 voltage supply relay -J317- (100)
1 - Terminal 30 voltage supply relay -J317- (370)
2 - Secondary air pump relay -J299- (100)
2 - Sensor for current measurement -G582- (488)
q Only models with diesel engine
t Relay code number 100 is replaced by relay code number 370 depending on production.
VW GOLF 2009 Relay assignment on E-box, to May 2005 Relay assignment on E-box, to May 2005 1 - Terminal 15 voltage supply relay -J329- (433)
2 - Terminal 50 voltage supply relay -J682- (433)
3 - Current supply relay for engine components -J757- (167)
q Engine codes BCA, BGU, AXX
4 - Terminal 30 voltage supply relay -J317- (458)
VW GOLF 2009 Relay assignment on E-box high, from May 2005 Relay assignment on E-box high, from May 2005 1 - Motronic current supply relay -J271- (100)
2 - Additional coolant pump relay -J496- (100)
4 - Engine components current supply relay -J757- (167)
VW GOLF 2009 Relay assignment on E-box high, from November 2005 Relay assignment on E-box high, from November 2005 1 - Engine components current supply relay -J757- (167)
2 - Additional coolant pump relay -J496- (100)
4 - Motronic current supply relay -J271- (100)
VW GOLF 2009 Relay assignment on relay carrier on onboard supply control unit Relay assignment on relay carrier on onboard supply control unit
Golf Fitting Locations No. 804 / 8
7 - Double washer pump relay 1 -J729- (404)
9 - Terminal 30 voltage supply relay 2 -J689- (449)
VW GOLF 2009 Relay carrier on left under dash panel, E-box low Relay carrier on left under dash panel, E-box low
1 - Low heat output relay -J359- (373)
2 - Auxiliary heater operation relay -J485- (449)
2 - High heat output relay -J360- (370)
3 - Headlight washer system relay -J39- (53)
4 - Additional coolant pump relay -J496- (449)
4 - Fuel supply relay -J643- (449)
4 - Fuel pump relay -J17- (449)
5 - Terminal 50 voltage supply relay -J682- (433)
q From May 2006 identification number (53)
t Relay socket attachment 2 and 3 with crossover winding.
VW GOLF 2009 Relay assignment for E-box high, to May 2005 Relay assignment for E-box high, to May 2005 1 - Fresh air blower relay -J13- (53)
q Only with auxiliary heater
4 - Headlight washer system relay -J39- (53)
5 - Fuel pump relay -J17- (449)
5 - Auxiliary heater operation relay -J485- (449)
t -J17- and -J485- are mini-relays and can be found on a relay slot
VW GOLF 2009 Relay assignment for E-box high, to May 2005 Relay assignment for E-box high, to May 2005 1 - Fresh air blower relay -J13- (53)
q Only with auxiliary heater
2 - Secondary air pump relay -J299- (100)
3 - Terminal 50 voltage supply relay -J682- (449)
q From May 2006 identification number (53)
4 - Headlight washer system relay -J39- (53)
5 - Fuel pump relay -J17- (449)
5 - Auxiliary heater operation relay -J485- (449)
t -J17- and -J485- are mini-relays and can be found on a relay slot
VW GOLF 2009 Relay assignment on additional relay carrier under E-box low Relay assignment on additional relay carrier under E-box low Automatic glow period control unit -J179-
1 - Additional relay carrier, under E-box on left in engine compartment
2 - Automatic glow period control unit -J179- (461), from August 2006 identification number (457)
VW GOLF 2009 Overview of fuses (SA), (SB) Overview of fuses (SA), (SB) q Fuse assignment for E-box low, from May 2005
q Fuse assignment for E-box low, from May 2006
q Fuse assignment for E-box low, from May 2007
q Installation position of E-box high
q Fuse assignment for E-box high, to May 2005
q Fuse assignment for E-box high, from May 2005
q Fuse assignment for E-box high, from November 2005
q Fuse assignment for E-box high, from May 2007
Golf Fitting Locations No. 802 / 2
q Fuse assignment for E-box low, from May 2005
q Fuse assignment for E-box low, from May 2006
q Fuse assignment for E-box low, from May 2007
q Installation position of E-box high
q Fuse assignment for E-box high, to May 2005
q Fuse assignment for E-box high, from May 2005
q Fuse assignment for E-box high, from November 2005
q Fuse assignment for E-box high, from May 2007
Installation position of fuses (SA) on E-box low
⇒ Electrical system, Repair Group 97, Removing and installing fuse holders
VW GOLF 2009 Fuse assignment for E-box low, from May 2005 Fuse assignment for E-box low, from May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (140A) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 30a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 30a 4 - SA4 - Fuse 4 on fuse holder A 40A - Special equipment 30a 5 - SA5 - Fuse 5 on fuse holder A 100A 100A - - Fuses on fuse holder C, on left under dash panel SC43-SC45, SC28, SC22, SC18, SC19, SC12, (to November 2005) J604 - Auxiliary air heater control unit (to November 2005) Z35 - Auxiliary air heater element (to November 2005) 30a 6 - SA6 - Fuse 6 on fuse holder A 80A 100A - - Fuses on fuse holder C, on left under dash panel SC43-SC45, SC28, SC22, SC18, SC19, SC12 J604 - Auxiliary air heater control unit (from November 2005) Z35 - Auxiliary air heater element (from November 2005) - Optional equipment 30a 7 - SA7 - Fuse 7 on fuse holder A 50A 40A 30A - - - - Trailer operation - Special equipment, disabled persons - Special equipment, criminal investigation department 30a
VW GOLF 2009 Fuse assignment for E-box low, from May 2006 Fuse assignment for E-box low, from May 2006 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (140A) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 30a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 (500 Watt) 30a 4 - SA4 - Fuse 4 on fuse holder A 40A - J359 - Low heat output relay (1st stage), (from December 2006) Z35 - Auxiliary air heater element (from December 2006) 30a 5 - SA5 - Fuse 5 on fuse holder A 100A 100A - - Fuses on fuse holder C, on left under dash panel SC43-SC45, SC28, SC22, SC15-SC20, SC 12, SC22-SC27, SC19, SC38, (from November 2005) -Optional equipment (from November 2005) 30a 6 - SA6 - Fuse 6 on fuse holder A 100A 80A - J604 - Auxiliary air heater control unit (from November 2005) Z35 - Auxiliary air heater element (from November 2005) J360 - High heat output relay (1st and 3rd stages), (from December 2006) Z35 - Auxiliary air heater element (from November 2006) 30a 7 - SA7 - Fuse 7 on fuse holder A 40A 30A - - - Special equipment, disabled persons - Special equipment, criminal investigation department 30a
VW GOLF 2009 Fuse assignment for E-box low, from May 2007 Fuse assignment for E-box low, from May 2007 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (140A) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 30a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 (500 Watt) 30a 4 - SA4 - Fuse 4 on fuse holder A 40A - J359 - Low heat output relay (1st stage), (from December 2006) Z35 - Auxiliary air heater element (from December 2006) 30a 5 - SA5 - Fuse 5 on fuse holder A 100A 100A - - Fuses on fuse holder C, on left under dash panel SC43-SC45, SC28, SC22, SC15-SC20, SC 12, SC22-SC27, SC19, SC38, (from November 2005) -Optional equipment (from November 2005) 30a 6 - SA6 - Fuse 6 on fuse holder A 100A 80A - J604 - Control unit for auxiliary air heater (from November 2005) Z35 - Heater element for auxiliary air heater (from November 2005) J360 - Relay for high heater output (1st and 3rd stages) (from December 2006) 30a 7 - SA7 - Fuse 7 on fuse holder A 40A 30A - - - Special equipment, disabled persons - Special equipment, criminal investigation department 30a
VW GOLF 2009 Fuses (SA) on fuse holder A, on E-box high Fuses (SA) on fuse holder A, on E-box high ⇒ Electrical system, Repair Group 97, Removing and installing fuse holders
VW GOLF 2009 Fuse assignment for E-box low, to May 2005 Fuse assignment for E-box low, to May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (1401A) TV2 - Terminal 30 wiring junction (rear battery) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 29a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 (500 W) 29a 4 - SA4 - Fuse 4 on fuse holder A - - - Not assigned 29a 5 - SA5 - Fuse 5 on fuse holder A 50A 80A - - Fuses on fuse holder C, on left under dash panel SC12-SC17, SC19, SC22-SC27, SC32-SC38, SC43-SC45 30a 6 - SA6 - Fuse 6 on fuse holder A 125A - SF1 - Fuse 1 on fuse holder F (rear battery) 30a 7 - SA7 - Fuse 7 on fuse holder A - - - Not assigned 30a
VW GOLF 2009 Fuse assignment for E-box high, from May 2005 Fuse assignment for E-box high, from May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (1401A) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 30a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 30a 4 - SA4 - Fuse 4 on fuse holder A 80A - Fuses on fuse holder C, on left under dash panel: SC32-SC 37, Driver seat adjustment thermal fuse 1 - 30A 29a 5 - SA5 - Fuse 5 on fuse holder A 100A - J604 - Auxiliary air heater control unit Z35 - Auxiliary air heater element 30a 6 - SA6 - Fuse 6 on fuse holder A 80A 100A - - Fuses on fuse holder C, on left under dash panel: SC18-SC20, SC22-SC28, SC43-SC45 optional equipment 30a 30a 7 - SA7 - Fuse 7 on fuse holder A 50A - Fuses on fuse holder C, on left under dash panel: SC22-SC27 30a
VW GOLF 2009 Fuse assignment for E-box high, from November 2005 Fuse assignment for E-box high, from November 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (1401A) TV2 - Terminal 30 wiring junction (rear battery) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 29a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 (500 W) 29a 4 - SA4 - Fuse 4 on fuse holder A - - - Not assigned 29a 5 - SA5 - Fuse 5 on fuse holder A 50A - Fuses on fuse holder C, on left under dash panel SC12-SC17, SC19, SC22-SC27, SC32-SC38, SC43-SC45 30a 6 - SA6 - Fuse 6 on fuse holder A 125A - SF1 - Fuse 1 on fuse holder F (rear battery) 30a 7 - SA7 - Fuse 7 on fuse holder A - - - Not assigned 30a
VW GOLF 2009 Fuse assignment for E-box high, from May 2007 Fuse assignment for E-box high, from May 2007 No. Current Flow Diagram designation Nominal value Function/component Terminal 1 - SA1 - Fuse 1 on fuse holder A 150A 200A - C - Alternator (90A/120A) C - Alternator (1401A) TV2 - Terminal 30 wiring junction (rear battery) 30a 2 - SA2 - Fuse 2 on fuse holder A 80A - J500 - Power steering control unit V187 - Electromechanical power steering motor 29a 3 - SA3 - Fuse 3 on fuse holder A 50A - J293 - Radiator fan control unit V7 - Radiator fan V177 - Radiator fan 2 (500 W) 29a 4 - SA4 - Fuse 4 on fuse holder A - - - Not assigned 29a 5 - SA5 - Fuse 5 on fuse holder A 50A 80A - - Fuses on fuse holder C, on left under dash panel SC12-SC17, SC19, SC22-SC27, SC32-SC38, SC43-SC45 30a 6 - SA6 - Fuse 6 on fuse holder A 125A - SF1 - Fuse 1 on fuse holder F (rear battery) 30a 7 - SA7 - Fuse 7 on fuse holder A - - - Not assigned 30a
VW GOLF 2009 Fuses (SB) on E-box low, on left of engine compartment Fuses (SB) on E-box low, on left of engine compartment VW GOLF 2009 Fuse assignment for E-box low, from May 2005 Fuse assignment for E-box low, from May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B 20A - J393 - Convenience system central control unit 30a F2 - SB2 - Fuse 2 on fuse holder B 5A - J527 - Steering column electronics control unit 30a F3 - SB3 - Fuse 3 on fuse holder B 5A - J519 - Onboard supply control unit 30a F4 - SB4 - Fuse 4 on fuse holder B 30A - J104 - ABS control unit 30a F5 - SB5 - Fuse 5 on fuse holder B 15A - J743 - Mechatronic control unit 30a F6 - SB6 - Fuse 6 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a F7 - SB7 - Fuse 7 on fuse holder B 15A - J608 - Special vehicle control unit 30a F8 - SB8 - Fuse 8 on fuse holder B 15A - J503 - Control unit with display for radio and navigation R - Radio 30a F9 - SB9 - Fuse 9 on fuse holder B 5A - J412 - Mobile telephone operating electronics control unit 30a F10 - SB10 - Fuse 10 on fuse holder B 5A 10A - - J317 - Terminal 30 voltage supply relay (models with petrol engine, not for engine codes BSE, BSF) J623 - Engine control unit (models with petrol engine, not for engine codes BSE, BSF) 30a 30a F11 - SB11 - Fuse 11 on fuse holder B 20A - J364 - Auxiliary heater control unit 30a F12 - SB12 - Fuse 12 on fuse holder B 5A - J533 - Data bus diagnostic interface 30a F13 - SB13 - Fuse 13 on fuse holder B 30A 25A - - J623 - Engine control unit (only models with diesel engine) J623 - Petrol engine control unit (only models with petrol engine) 87a
Golf Fitting Locations No. 802 / 15
No. Current Flow Diagram designation Nominal value Function/component Terminal F22 - SB22 - Fuse 22 on fuse holder B 5A - F47 - Brake pedal switch (to November 2005) G476 - Clutch position sender 87a F23 - SB23 - Fuse 23 on fuse holder B 5A 10A 15A - - - J299 - Secondary air pump relay (BSF) N18 - Exhaust gas recirculation valve N75 - Charge pressure control solenoid valve N345 - Exhaust gas recirculation cooler changeover valve N381 - Exhaust gas recirculation cooler changeover valve 2 N276 - Fuel pressure regulating valve 87a F24 - SB24 - Fuse 24 on fuse holder B 10A - F265 - Map-controlled engine cooling system thermostat J293 - Radiator fan control unit N18 - Exhaust gas recirculation valve N80 - Activated charcoal filter solenoid valve 1 N156 - Variable intake manifold changeover valve N205 - Inlet camshaft control valve 1 N316 - Intake manifold flap valve V157 - Intake manifold flap motor 87a F25 - SB25 - Fuse 25 on fuse holder B 40A - J519 - Onboard supply control unit 30a F26 - SB26 - Fuse 26 on fuse holder B 40A - J519 - Onboard supply control unit 30a F27 - SB27 - Fuse 27 on fuse holder B 50A - J179 - Automatic glow period control unit 30a F28 - SB28 - Fuse 28 on fuse holder B 40A - J681 - Terminal 15 voltage supply relay 2 30a F29 - SB29 - Fuse 29 on fuse holder B 50A - S44 - Driver seat adjustment thermal fuse 1 SC - Fuses 32-37 on fuse holder C 29a F30 - SB30 - Fuse 30 on fuse holder B - - - Not assigned 30a
VW GOLF 2009 Fuse assignment for E-box low, from May 2006 Fuse assignment for E-box low, from May 2006 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B - - - Not assigned 30a F2 - SB2 - Fuse 2 on fuse holder B 5A - J527 - Steering column electronics control unit 30a F3 - SB3 - Fuse 3 on fuse holder B 5A - J519 - Onboard supply control unit (measuring wire), for front battery 30a F4 - SB4 - Fuse 4 on fuse holder B 30A - J104 - ABS control unit 30a F5 - SB5 - Fuse 5 on fuse holder B 30A - J743 - Mechatronic control unit J285 - Control unit in dash panel insert 30a F6 - SB6 - Fuse 6 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a F7 - SB7 - Fuse 7 on fuse holder B 25A - J608 - Special vehicle control unit 30a F8 - SB8 - Fuse 8 on fuse holder B 15A 15A 25A - - - J503 - Control unit with display for radio and navigation system R - Radio R - Preparation for radio and navigation system with TV (models for Japan) 30a 30a F9 - SB9 - Fuse 9 on fuse holder B 5A - J412 - Mobile telephone operating electronics control unit 30a F10 - SB10 - Fuse 10 on fuse holder B 5A 10A 5A - - J317 -Terminal 30 voltage supply relay J623 - Engine control unit J359 - Low heat output relay 30a F11 - SB11 - Fuse 11 on fuse holder B 20A - J364 - Auxiliary heater control unit 30a F12 - SB12 - Fuse 12 on fuse holder B 5A - J533 - Data bus diagnostic interface 30a F13 SB13 - Fuse 13 on fuse holder B 30A 25A J623 - Engine control unit (diesel) J623 - Engine control unit (petrol) 87a F14 SB14 - Fuse 14 on fuse holder B 20A N152 - Ignition transformer N70-N323 - Ignition coils with output stage 87a
Golf Fitting Locations No. 802 / 18
No. Current Flow Diagram designation Nominal value Function/component Terminal F23 - SB23 - Fuse 23 on fuse holder B 5A 15A 10A - - - J299 - Secondary air pump relay N218 - Secondary air inlet valve N18 - Exhaust gas recirculation valve N80 - Activated charcoal filter system solenoid valve 1 V144 - Fuel system diagnostic pump (BGQ,BGP) N345 - Exhaust gas recirculation cooler changeover valve N276 - Fuel pressure regulating valve J623 - Engine control unit N156 - Variable intake manifold changeover valve 87a F24 - SB24 - Fuse 24 on fuse holder B 10A - F265 - Map-controlled engine cooling system thermostat J293 - Radiator fan control unit N18 - Exhaust gas recirculation valve N75 - Charge pressure control solenoid valve N205 - Inlet camshaft control valve 1 N316 - Intake manifold flap valve N381 - Exhaust gas recirculation cooler changeover valves 2 V157 - Intake manifold flap motor 30a F25 - SB25 - Fuse 25 on fuse holder B 30A - J519 - Onboard supply control unit (A/1) 30a F26 - SB26 - Fuse 26 on fuse holder B 30A - J519 - Onboard supply control unit (D/1) 30a F27 - SB27 - Fuse 27 on fuse holder B 40A 50A - J299 - Secondary air pump relay J179 - Automatic glow period control unit 30a F28 - SB28 - Fuse 28 on fuse holder B 40A - J681 - Terminal 15 voltage supply relay 2 30a F29 - SB29 - Fuse 29 on fuse holder B 50A - J496 - Additional coolant pump relay S44 - Seat adjustment thermal fuse 1 - SC33, SC34, SC37 30a F30 - SB30 - Fuse 30 on fuse holder B 50A - J59 - X-contact relief relay (SC7, SC8, SC28-SC35) 30a
VW GOLF 2009 Fuse assignment for E-box low, from May 2007 Fuse assignment for E-box low, from May 2007 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B - - - Not assigned 30a F2 - SB2 - Fuse 2 on fuse holder B 5A - J527 - Steering column electronics control unit 30a F3 - SB3 - Fuse 3 on fuse holder B 5A - J519 - Onboard supply control unit (measuring wire), for front battery 30a F4 - SB4 - Fuse 4 on fuse holder B 30A - J104 - ABS control unit 30a F5 - SB5 - Fuse 5 on fuse holder B 15A - J743 - Mechatronic control unit 30a F6 - SB6 - Fuse 6 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a F7 - SB7 - Fuse 7 on fuse holder B 25A 30A - J608 - Special vehicle control unit J743 - Mechatronics control unit (0AM) 30a F8 - SB8 - Fuse 8 on fuse holder B 15A 15A 25A - - - J503 - Control unit with display for radio and navigation system R - Radio R - Preparation for radio and navigation system with TV (models for Japan) 30a 30a F9 - SB9 - Fuse 9 on fuse holder B 5A - J412 - Mobile telephone operating electronics control unit 30a F10 - SB10 - Fuse 10 on fuse holder B 5A 10A 5A - - J317 -Terminal 30 voltage supply relay J623 - Engine control unit J359 - Low heat output relay 30a F11 - SB11 - Fuse 11 on fuse holder B 20A - J364 - Auxiliary heater control unit 30a F12 - SB12 - Fuse 12 on fuse holder B 5A - J533 - Data bus diagnostic interface 30a F13 - SB13 - Fuse 13 on fuse holder B 30A J623 - Engine control unit (diesel) J623 - Engine control unit (petrol) 87a F14 - SB14 - Fuse 14 on fuse holder B 20A N152 - Ignition transformer N70-N323 - Ignition coils with output stage 87a
Golf Fitting Locations No. 802 / 21
No. Current Flow Diagram designation Nominal value Function/component Terminal F23 - SB23 - Fuse 23 on fuse holder B 5A 15A 10A 15A - - - - J299 - Secondary air pump relay N218 - Secondary air inlet valve N18 - Exhaust gas recirculation valve N80 - Activated charcoal filter system solenoid valve 1 V144 - Fuel system diagnostic pump (BGQ,BGP) N345 - Exhaust gas recirculation cooler changeover valve N276 - Fuel pressure regulating valve J623 - Engine control unit N156 - Variable intake manifold changeover valve 87a F24 - SB24 - Fuse 24 on fuse holder B 10A - F265 - Map-controlled engine cooling system thermostat J293 - Radiator fan control unit N18 - Exhaust gas recirculation valve N75 - Charge pressure control solenoid valve N205 - Inlet camshaft control valve 1 N316 - Intake manifold flap valve N381 - Exhaust gas recirculation cooler changeover valves 2 V157 - Intake manifold flap motor 30a F25 - SB25 - Fuse 25 on fuse holder B 30A - J519 - Onboard supply control unit (A/1) 30a F26 - SB26 - Fuse 26 on fuse holder B 30A - J519 - Onboard supply control unit (D/1) 30a F27 - SB27 - Fuse 27 on fuse holder B 40A 50A - J299 - Secondary air pump relay J179 - Automatic glow period control unit 30a F28 - SB28 - Fuse 28 on fuse holder B 40A - J681 - Terminal 15 voltage supply relay 2 30a F29 - SB29 - Fuse 29 on fuse holder B 50A - J496 - Additional coolant pump relay S44 - Seat adjustment thermal fuse 1 - SC33, SC34, SC37 30a F30 - SB30 - Fuse 30 on fuse holder B 50A 40A - J59 - Relief relay for X - contact (SC7, SC8, SC28 - SC35) J519 - Onboard supply control unit (I/1) 30a
VW GOLF 2009 Fuses (SB) on E-box high, on left of engine compartment Fuses (SB) on E-box high, on left of engine compartment VW GOLF 2009 Fuse assignment for E-box low, to May 2005 Fuse assignment for E-box low, to May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B 30A - J104 - ABS with EDL control unit 30a F2 - SB2 - Fuse 2 on fuse holder B 30A - J104 - ABS with EDL control unit 30a F3 - SB3 - Fuse 3 on fuse holder B 20A - J393 - Convenience system central control unit 30a F4 - SB4 - Fuse 4 on fuse holder B 5A - J519 - Onboard supply control unit 30a F5 - SB5 - Fuse 5 on fuse holder B 20A - H2 - Treble tone horn H7 - Bass tone horn 30a F6 - SB6 - Fuse 6 on fuse holder B 5A 20A 20A - N276 - Fuel pressure regulating valve N152 - Ignition transformer N... - Ignition coils 1-4 with output stage 87a F7 - SB7 - Fuse 7 on fuse holder B 5A - F47 - Cruise control system brake pedal switch G476 - Clutch position sender 87a F8 - SB8 - Fuse 8 on fuse holder B 10A - F265 - Map-controlled engine cooling system thermostat N205 - Inlet camshaft control valve 1 N80 - Activated charcoal filter solenoid valve 1 (pulsed) N18 - Exhaust gas recirculation valve N316 - Intake manifold flap air control valve V157 - Intake manifold flap motor N79 - Crankcase breather heater element N156 - Variable intake manifold changeover valve J293 - Radiator fan control unit 87a
Golf Fitting Locations No. 802 / 25
No. Current Flow Diagram designation Nominal value Function/component Terminal F18 - SB18 - Fuse 18 on fuse holder B 30A - J608 - Special vehicle control unit 30a F19 - SB19 - Fuse 19 on fuse holder B 15A - R - Radio J503 - Control unit with display for radio and navigation system 30a F20 - SB20 - Fuse 20 on fuse holder B 10A - J412 - Mobile telephone operating electronics control unit (telephone /preparation for telephone) 30a F21 - SB21 - Fuse 21 on fuse holder B - - - Not assigned - F22 - SB22 - Fuse 22 on fuse holder B - - - Not assigned - F23 - SB23 - Fuse 23 on fuse holder B - - - Not assigned 15a F24 - SB24 - Fuse 24 on fuse holder B 10A - J533 - Data bus diagnostic interface 30a F25 - SB25 - Fuse 25 on fuse holder B - - - Not assigned - F26 - SB26 - Fuse 26 on fuse holder B 10A 5A - J220 - Motronic control unit J248 - Diesel direct injection system control unit J317 - Terminal 30 voltage supply relay 30a F27 - SB27 - Fuse 27 on fuse holder B 10A - N79 - Heater element for crankcase breather 15a F28 - SB28 - Fuse 28 on fuse holder B 20A - J217 - Automatic gearbox control unit F125 - Multifunction switch 15a F29 - SB29 - Fuse 29 on fuse holder B 20A - N... - Ignition coils 1-4 with output stage N... - Injectors cylinders 1-4 15a
Golf Fitting Locations No. 802 / 27
No. Current Flow Diagram designation Nominal value Function/component Terminal F44 - SB44 - Fuse 44 on fuse holder B - - - Not assigned - F45 - SB45 - Fuse 45 on fuse holder B - - - Not assigned - F46 - SB46 - Fuse 46 on fuse holder B - - - Not assigned - F47 - SB47 - Fuse 47 on fuse holder B 40A - J519 - Onboard supply control unit 30a F48 - SB48 - Fuse 48 on fuse holder B 40A - J519 - Onboard supply control unit 30a F49 - SB49 - Fuse 49 on fuse holder B - - - Not assigned 30a F50 - SB50 - Fuse 50 on fuse holder B - - - Not assigned 30a F51 - SB51 - Fuse 51 on fuse holder B 50A - Q10 - Glow plug 1 Q11 - Glow plug 2 Q12 - Glow plug 3 Q13 - Glow plug 4 30a F52 - SB52 - Fuse 52 on fuse holder B 50A - J519 - Onboard supply control unit SC40-SC42, SC46, SC47, SC49 30a F53 - SB53 - Fuse 53 on fuse holder B 50A - Safety cutout for seat adjustment 30a F54 - SB54 - Fuse 54 on fuse holder B 50A - J293 - Radiator fan control unit 30a
VW GOLF 2009 Fuse assignment for E-box high, from May 2005 Fuse assignment for E-box high, from May 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B 30A - J104 - ABS control unit (pump) 30a F2 - SB2 - Fuse 2 on fuse holder B 30A - J104 - ABS control unit (valves) 30a F3 - SB3 - Fuse 3 on fuse holder B 20A - J393 - Convenience system central control unit V217 - Front passenger side wiper motor 30a F4 - SB4 - Fuse 4 on fuse holder B 5A - J519 - Onboard supply control unit (measuring wire) 30a F5 - SB5 - Fuse 5 on fuse holder B 15A - J519 - Onboard supply control unit (horn) 30a F6 - SB6 - Fuse 6 on fuse holder B 15A - N276 - Fuel pressure regulating valve 87a F7 - SB7 - Fuse 7 on fuse holder B 15A - - Not assigned F8 - SB8 - Fuse 8 on fuse holder B - - - Not assigned F9 - SB9 - Fuse 9 on fuse holder B 10A - N249 - Turbocharger air recirculation valve N80 - Activated charcoal filter solenoid valve 1 N75 - Charge pressure control solenoid valve 87a F10 - SB10 - Fuse 10 on fuse holder B - - - Not assigned F11 - SB11 - Fuse 11 on fuse holder B 10A - Z19 - Lambda probe heater 87a F12 - SB12 - Fuse 12 on fuse holder B 10A - Z29 - Lambda probe 1 heater after catalytic converter 87a F13 - SB12 - Fuse 12 on fuse holder B 15A - J743 - Mechatronic control unit 30a F14 - SB14 - Fuse 14 on fuse holder B - - - Not assigned F15 - SB15 - Fuse 15 on fuse holder B 10A - V50 - Coolant circulation pump 30a F16 - SB16 - Fuse 16 on fuse holder B 5A - J104 - Steering column control unit 30a F17 - SB17 - Fuse 17 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a F18 - SB18 - Fuse 18 on fuse holder B 30A - R12 - Amplifier 30a F19 - SB19 - Fuse 19 on fuse holder B 15A - R - Radio 30a
Golf Fitting Locations No. 802 / 30
No. Current Flow Diagram designation Nominal value Function/component Terminal F38 - SB38 - Fuse 38 on fuse holder B 10A - J293 - Radiator fan control unit 87a F39 - SB39 - Fuse 39 on fuse holder B 5A - F - Brake light switch (to November 2005) 87a F40 - SB40 - Fuse 40 on fuse holder B 20A - N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage 87a F41 - SB41 - Fuse 41 on fuse holder B - - - Not assigned F42 - SB42 - Fuse 42 on fuse holder B 5A - J271 - Motronic current supply relay (to November 2005) 87a F43 - SB43 - Fuse 43 on fuse holder B 30A - N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage N323 - Ignition coil 5 with output stage N324 - Ignition coil 6 with output stage 87a F44 - SB44 - Fuse 44 on fuse holder B - - - Not assigned - F45 - SB45 - Fuse 45 on fuse holder B - - - Not assigned - F46 - SB46 - Fuse 46 on fuse holder B - - - Not assigned - F47 - SB47 - Fuse 47 on fuse holder B 40A - J519 - Onboard supply control unit 30a F48 - SB48 - Fuse 48 on fuse holder B 40A - J519 - Onboard supply control unit 30a F49 - SB49 - Fuse 49 on fuse holder B 40A - J681 - Terminal 15 voltage supply relay 2 30a F50 - SB50 - Fuse 50 on fuse holder B - - - Not assigned 30a F51 - SB51 - Fuse 51 on fuse holder B 40A - J299 - Secondary air pump relay 30a F52 - SB52 - Fuse 52 on fuse holder B 40A - J59 - X-contact relief relay 30a F53 - SB53 - Fuse 53 on fuse holder B 50A - - Optional equipment 30a F54 - SB54 - Fuse 54 on fuse holder B - - - Not assigned 30a
VW GOLF 2009 Fuse assignment for E-box high, from November 2005 Fuse assignment for E-box high, from November 2005 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B 30A - J104 - ABS control unit (pump) 30a F2 - SB2 - Fuse 2 on fuse holder B 30A - J104 - ABS control unit (valves) 30a F3 - SB3 - Fuse 3 on fuse holder B - - Not assigned 30a F4 - SB4 - Fuse 4 on fuse holder B 5A - J519 - Onboard supply control unit (measuring wire) 30a F5 - SB5 - Fuse 5 on fuse holder B 15A - J519 - Onboard supply control unit (horn) 30a F6 - SB6 - Fuse 6 on fuse holder B 15A - N276 - Fuel pressure regulating valve 87a F7 - SB7 - Fuse 7 on fuse holder B - - Not assigned F8 - SB8 - Fuse 8 on fuse holder B - - Not assigned F9 - SB9 - Fuse 9 on fuse holder B 10A - N249 - Turbocharger air recirculation valve N80 - Activated charcoal filter solenoid valve 1 N75 - Charge pressure control solenoid valve 87a F10 - SB10 - Fuse 10 on fuse holder B 10A - V144 - Fuel system diagnostic pump (USA/Canada) 87a F11 - SB11 - Fuse 11 on fuse holder B 10A - Z19 - Lambda probe heater 87a F12 - SB12 - Fuse 12 on fuse holder B 10A - Z29 - Lambda probe 1 heater after catalytic converter 87a F13 - SB12 - Fuse 12 on fuse holder B 30A - J743 - Mechatronic control unit 30a F14 - SB14 - Fuse 14 on fuse holder B - - Not assigned F15 - SB15 - Fuse 15 on fuse holder B 10A - V50 - Coolant circulation pump 30a F16 - SB16 - Fuse 16 on fuse holder B 5A - J527 - Steering column electronics control unit 30a F17 - SB17 - Fuse 17 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a F18 - SB18 - Fuse 18 on fuse holder B 30A - R12 - Amplifier (not USA/Canada) 30a F19 - SB19 - Fuse 19 on fuse holder B 15A - J503 - Control unit with display for radio and navigation system 30a
Golf Fitting Locations No. 802 / 33
No. Current Flow Diagram designation Nominal value Function/component Terminal F40 - SB40 - Fuse 40 on fuse holder B 20A - N70 - Ignition coil 1 with output stage (AXX, BWA, BPY) N127 - Ignition coil 2 with output stage (AXX, BWA, BPY) N291 - Ignition coil 3 with output stage (AXX, BWA, BPY) N292 - Ignition coil 4 with output stage (AXX, BWA, BPY) 87a F41 - SB41 - Fuse 41 on fuse holder B - - - Not assigned 87a F42 - SB42 - Fuse 42 on fuse holder B 10A - J757 - Engine component current supply relay 87a F43 - SB43 - Fuse 43 on fuse holder B 30A - N70 - Ignition coil 1 with output stage (BUB) N127 - Ignition coil 2 with output stage (BUB) N291 - Ignition coil 3 with output stage (BUB) N292 - Ignition coil 4 with output stage (BUB) N323 - Ignition coil 5 with output stage (BUB) N324 - Ignition coil 6 with output stage (BUB) 87a F44 - SB44 - Fuse 44 on fuse holder B - - - Not assigned - F45 - SB45 - Fuse 45 on fuse holder B - - - Not assigned - F46 - SB46 - Fuse 46 on fuse holder B - - - Not assigned - F47 - SB47 - Fuse 47 on fuse holder B 30A - J519 - Onboard supply control unit (D/1 left) 30a F48 - SB48 - Fuse 48 on fuse holder B 30A - J519 - Onboard supply control unit (A/1 right) 30a F49 - SB49 - Fuse 49 on fuse holder B 40A - J681 - Terminal 15 voltage supply relay 2 SF2 - Fuse in fuse holder F (rear battery) J519 - Onboard supply control unit (L1) 30a F50 - SB50 - Fuse 50 on fuse holder B - - - Not assigned 30a F51 - SB51 - Fuse 51 on fuse holder B 40A - J299 - Secondary air pump relay (BUB) 29a F52 - SB52 - Fuse 52 on fuse holder B 40A - J59 - X-contact relief relay 29a F53 - SB53 - Fuse 53 on fuse holder B 50A - S44 - Seat adjustment thermal fuse 1, SB111 - Positive connection 1 (30a) 29a F54 - SB54 - Fuse 54 on fuse holder B - - - Not assigned 29a
VW GOLF 2009 Fuse assignment for E-box high, from May 2007 Fuse assignment for E-box high, from May 2007 No. Current Flow Diagram designation Nominal value Function/component Terminal F1 - SB1 - Fuse 1 on fuse holder B 30A - J104 - ABS control unit (pump) 30a F2 - SB2 - Fuse 2 on fuse holder B 30A - J104 - ABS control unit (valves) 30a F3 - SB3 - Fuse 3 on fuse holder B - - Not assigned 30a F4 - SB4 - Fuse 4 on fuse holder B 5A - J519 - Onboard supply control unit (measuring wire) 30a F5 - SB5 - Fuse 5 on fuse holder B 15A - J519 - Onboard supply control unit (horn) 30a F6 - SB6 - Fuse 6 on fuse holder B 15A - N276 - Fuel pressure regulating valve J17 - Fuel pump 87a F7 - SB7 - Fuse 7 on fuse holder B 40A - SF2 - Fuse 2 on fuse holder F (rear battery) 29a F8 - SB8 - Fuse 8 on fuse holder B 15A - R190 - Digital radio satellite receiver 30a F9 - SB9 - Fuse 9 on fuse holder B 10A - N249 - Turbocharger air recirculation valve N80 - Activated charcoal filter solenoid valve 1 N75 - Charge pressure control solenoid valve 87a F10 - SB10 - Fuse 10 on fuse holder B 10A - V144 - Diagnosis pump for fuel system (USA/Canada) G42 - Intake air temperature sender G70 - Air mass meter 87a F11 - SB11 - Fuse 11 on fuse holder B 10A - Z19 - Lambda probe heater Z28 - Lambda probe 2 heater 2 87a F12 - SB12 - Fuse 12 on fuse holder B 10A - Z29 - Lambda probe 1 heater after catalytic converter Z30 - Lambda probe 2 heater after catalytic converter 87a F13 - SB12 - Fuse 12 on fuse holder B 30A - J743 - Mechatronic control unit 30a F14 - SB14 - Fuse 14 on fuse holder B - - Not assigned F15 - SB15 - Fuse 15 on fuse holder B 10A - V50 - Coolant circulation pump 30a F16 - SB16 - Fuse 16 on fuse holder B 5A - J527 - Steering column electronics control unit 30a F17 - SB17 - Fuse 17 on fuse holder B 5A - J285 - Control unit in dash panel insert 30a
Golf Fitting Locations No. 802 / 36
No. Current Flow Diagram designation Nominal value Function/component Terminal F36 - SB36 - Fuse 36 on fuse holder B 30A - - Not assigned 29a F37 - SB37 - Fuse 37 on fuse holder B 30A - - Not assigned 29a F38 - SB38 - Fuse 38 on fuse holder B 10A - J293 - Radiator fan control unit N205 - Camshaft adjustment valve 1 N112 - Secondary air inlet valve N321 - Exhaust flap 1 valve N320 - Secondary air inlet valve 2 V144 - Diagnosis pump for fuel system N80 - Activated charcoal filter solenoid valve 1 N156 - Secondary air inlet valve N318 - Exhaust camshaft control valve 1 87a F39 - SB39 - Fuse 39 on fuse holder B 5A - F47 - Brake pedal switch G476 - Clutch position sender 87a F40 - SB40 - Fuse 40 on fuse holder B 20A - N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage 87a F41 - SB41 - Fuse 41 on fuse holder B - - Not assigned 87a F42 - SB42 - Fuse 42 on fuse holder B 10A - J757 - Engine component current supply relay 87a F43 - SB43 - Fuse 43 on fuse holder B 30A - N70 - Ignition coil 1 with output stage N127 - Ignition coil 2 with output stage N291 - Ignition coil 3 with output stage N292 - Ignition coil 4 with output stage N323 - Ignition coil 5 with output stage N324 - Ignition coil 6 with output stage 87a F44 - SB44 - Fuse 44 on fuse holder B - - - Not assigned - F45 - SB45 - Fuse 45 on fuse holder B - - - Not assigned -
VW GOLF 2009 VW GOLF 2009 Overview of earth points in engine compartment Overview of earth points in engine compartment
Golf Fitting Locations No. 801 / 2
656 Earth point, on right headlight -arrow-
- Torque setting: M6 9+/-1 Nm
607 Earth point, on left in plenum chamber -arrow-
- Torque setting: M6 9+/-1 Nm
609 Earth point, on right in plenum chamber -arrow-
- Torque setting: M6 9+/-1 Nm
t Discontinued from May 2006
640 Earth point, on left in engine compartment -arrow A-
- Torque setting: M6 9+/-1 Nm
642 Earth point, electronically controlled fan -arrow C-
- Torque setting: M6 9+/-1 Nm
652 Earth point, engine and gearbox earth -arrow D-
- Torque setting: M8 20+/-3 Nm
t Additionally with earth point for electromechanical power steering
655 Earth point, on left headlight -arrow B-
- Torque setting: M6 9+/-1 Nm
t Discontinued from May 2006
Overview of earth points in vehicle interior
Golf Fitting Locations No. 801 / 7
638 Earth point, right A-pillar -arrow A-
- Torque setting: M6 9+/-1 Nm
43 Earth point, lower part of right A-pillar -arrow C-
- Torque setting: M6 9+/-1 Nm
44 Earth point, lower part of left A-pillar -arrow B-
- Torque setting: M6 9+/-1 Nm
45 Earth point, centre behind dash panel -arrow-
- Torque setting: M6 9+/-1 Nm
605 Earth point, on top end of steering column -arrow-
- Torque setting: M6 9+/-1 Nm
78 Earth point, lower part of right B-pillar -arrow-
- Torque setting: M6 9+/-1 Nm
t Discontinued from May 2006
77 Earth point, lower part of left B-pillar -arrow-
- Torque setting: M6 9+/-1 Nm
t Discontinued from May 2006
Overview of earth points in luggage compartment
662 Earth point, on rear left side panel -arrow A-
- Torque setting: M6 9+/-1 Nm
679 Earth point 2, in rear left side panel -arrow B-
- Torque setting: M6 9+/-1 Nm
t Discontinued from May 2006
681 Earth point 1, in rear right side panel -arrow A-
- Torque setting: M6 9+/-1 Nm
663 Earth point, in rear right side panel -arrow C-
- Torque setting: M6 9+/-1 Nm
53 Earth point, on right in rear lid -arrow-
- Torque setting: M6 9+/-1 Nm
VW GOLF 2009 VW GOLF 2009 Overview of control units Overview of control units
q 80-pin connector assignment
q 121-pin connector assignment
q 154-pin connector assignment
q 26-pin connector assignment (no ESP)
q 47-pin connector assignment (with ESP)
Golf Fitting Locations No. 805 / 2
6 - Control unit for headlight range control -J431-
7 - Convenience system central control unit -J393-
8 - Front passenger door control unit -J387-
9 - Steering column electronics control unit -J527-
10 - Dash panel insert -K-
11 - Driver door control unit -J386-
Golf Fitting Locations No. 805 / 3
12 - Onboard supply control unit -J519-
13 - Data bus diagnostic interface -J533-
14 - Automatic gearbox control unit -J217-
15 - W-box coupling point
Automatic gearbox control unit -J217-
In front left wheel housing -arrow-
Connector assignment:
A - Automatic gearbox control unit -J217-
B - 52-pin connector -T52-, on wiring harness
ABS with EDL control unit -J104-
On right of bulkhead in engine compartment -arrow-
26-pin connector assignment:
A - ABS with EDL control unit -J104-
B - 26-pin connector -T26a-, on wiring harness
47-pin connector assignment:
A - ABS with EDL control unit -J104-
B - 47-pin connector -T47a-, on wiring harness
Motronic control unit -J220-, engine control unit -J623-
Central under plenum chamber cover -arrow-
80-pin connector assignment:
A - Motronic control unit -J220-
B - 28-pin connector -T80-, on wiring harness
C - 52-pin connector -T80-, on wiring harness
Note:
-T80- is comprised of items B and C.
121-pin connector assignment:
A - Engine control unit -J623-
B - 81-pin connector -T121-, on wiring harness
C - 40-pin connector -T121-, on wiring harness
Note:
-T121- is comprised of items B and C.
154-pin connector assignment:
A - Engine control unit -J623-
B - 94-pin connector -T94-, on wiring harness
C - 60-pin connector -T60-, on wiring harness
Convenience system central control unit -J393-
Under dash panel, behind glove compartment -arrow-
Connector assignment:
A - Convenience system central control unit -J393-
B - 6-pin connector -T6m-, on wiring harness
C - 18-pin connector -T18-, on wiring harness
D - 8-pin connector -T8n-, on wiring harness
E - 6-pin connector -T6-, on wiring harness
F - 18-pin connector -T18a-, on wiring harness
Note:
Connector T18a is not used on vehicles with 2-doors.
Airbag control unit -J234-
Under centre console -arrow-
Connector assignment:
A - Airbag control unit -J234-
B - 50-pin connector -T50-, on wiring harness
Onboard supply control unit -J519-
On left under dash panel, below relay carrier -arrow-
Connector assignment:
2 - Right dipped beam bulb
5 - Right gas discharge (xenon) bulb
6 - Front right turn signal bulb
8 - Left side repeater turn signal (NAR)
10 - Electric fuel pump relay
11 - Terminal 50 voltage supply relay 2
1 - Right reversing light bulb
Golf Fitting Locations No. 805 / 19
3 - Rear left fog light bulb
4 - Right brake and tail light bulb
7 - Front left entry light, front right entry light
9 - Right tail light bulb
10 - Rear right turn signal bulb
11 - Front interior light
1 - Left brake light bulb
2 - Heated driver seat control unit, heated front passenger seat control unit
3 - Rear right fog light bulb
Golf Fitting Locations No. 805 / 20
4 - Sliding/tilting sunroof enabled
6 - High level brake light bulb
8 - Rear left turn signal bulb
4 - Left dipped beam bulb
6 - Left gas discharge (xenon) bulb
7 - Terminal 15 voltage supply relay
8 - Headlight washer system relay
Golf Fitting Locations No. 805 / 21
9 - Right side repeater turn signal (USA/Canada)
10 - Right side light bulb
11 - Front left turn signal bulb
1 - Light switch, terminal 58
3 - Coming Home / Leaving Home earth
4 - Coming Home / Leaving Home terminal 30
7 - Earth (only for manual gearbox), mechatronics for dual clutch gearbox (only for dual clutch gearbox), multifunction switch (only for automatic gearbox)
8 - Light switch, terminal 56
12 - Coming Home / Leaving Home signal
Golf Fitting Locations No. 805 / 22
1 - Light switch (rear fog light)
2 - Light switch (driving light assist)
4 - Light switch (day driving light)
1 - Terminal 50 voltage supply relay
2 - Terminal 15 voltage supply relay
3 - Windscreen wiper motor, rain and light detector sensor (LIN bus)
5 - Bonnet contact switch
6 - Reversing light switch
1 - Steering column electronics control unit terminal 50
Golf Fitting Locations No. 805 / 23
2 - Hazard warning light system warning lamp
4 - Illumination regulators, switches, instruments
6 - Heated rear window button
7 - Convenience CAN bus, low
8 - Convenience CAN bus, high
9 - Hazard warning light switch
10 - Illumination regulators, switches, instruments
11 - Steering column electronics control unit terminal 15
12 - Illumination regulators, switches, instruments
Golf Fitting Locations No. 805 / 24
1 - Windscreen and rear window washer pump fuse
2 - Rear window wiper motor, windscreen and rear window washer pump
4 - Rear window wiper motor, windscreen and rear window washer pump
5 - Double washer pump terminal 31
6 - Treble tone horn, bass tone horn
Golf Fitting Locations No. 805 / 25
6 - Heated rear window fuse
1 - Interior terminal 15 fuse
Data bus diagnostic interface -J533-
In left footwell near centre console -arrow-
Connector assignment:
A - Data bus diagnostic interface -J533-
B - 20-pin connector -T20-, on wiring harness
Vehicle inclination sender -G384-
Below the dash panel on right, behind the front passenger airbag -arrow-
Control unit for headlight range control -J431-
On right of glove compartment -arrow-
Connector assignment:
A - Control unit for headlight range control -J431-
B - 26-pin connector -T26b-, on wiring harness
Dash panel insert -K-
4 - Rear fog light warning lamp
5 - Brake fluid level warning lamp
6 - Handbrake warning lamp
7 - Immobilizer reader coil 1
8 - Immobilizer reader coil 2
12 - Diagnostic interface for dash panel CAN data bus, low
13 - Diagnostic interface for dash panel CAN data bus, high
14 - Dash panel CAN, screening
Golf Fitting Locations No. 805 / 32
15 - Data bus diagnostic interface for dash panel CAN wake-up wire
16 - Fuel gauge sender (4 Motion)
17 - Fuel gauge sender (full)
18 - Fuel gauge sender (empty)
22 - Front left brake pad wear sender
24 - Fuel tank flap lock warning lamp
25 - Oil pressure warning lamp
26 - Oil level and oil temperature sender
28 - Speed signal, sliding sunroof control unit output, control unit with display for radio and navigation system
Golf Fitting Locations No. 805 / 33
33 - Terminal 31, sensor earth
34 - Washer fluid level warning lamp
35 - Coolant temperature and coolant shortage warning lamp
36 - Ambient temperature sensor
Power steering control unit -J500-
Central on steering assembly carrier -arrow-
Connector assignment:
A - Power steering control unit -J500-
B - 5-pin connector -T5g-, on wiring harness
C - 5-pin connector -T5h-, on wiring harness
D - 2-pin connector -T2a-, on wiring harness
Steering column electronics control unit -J527-
Under steering column, near steering column switch -arrow-
Connector assignment:
A - Steering column electronics control unit -J527-
B = Mounting for airbag control unit:
C = Mounting for turn signals and cruise control system:
1 - Cruise control system terminal 15 voltage supply
5 - Cruise control system earth
6 - Cruise control system illumination terminal 58
Golf Fitting Locations No. 805 / 38
10 - Powertrain CAN screening
11 - Diagnostic interface for powertrain CAN data bus, low
12 - Diagnostic interface for powertrain CAN data bus, high
13 - Cruise control system, output
Golf Fitting Locations No. 805 / 39
14 - Diagnostic interface for convenience CAN data bus, low
15 - Diagnostic interface for convenience CAN data bus, high
16 - Multifunction switch (only automatic or dual clutch gearbox)
17 - Auxiliary output, terminal 15
18 - Auxiliary output, terminal 50
19 - Terminal 30 voltage supply
20 - Terminal 31 voltage supply
Golf Fitting Locations No. 805 / 40
F = Mounting for ignition/starter switch and ignition key withdrawal lock:
3 - Ignition key withdrawal lock on, terminal 30
4 - Ignition key withdrawal lock earth
7 - Ignition/starter switch output terminal 50
8 - Ignition/starter switch, terminal 30
9 - Ignition/starter switch output terminal S
10 - Ignition/starter switch output terminal X
11 - Ignition/starter switch output terminal P
12 - Ignition/starter switch output terminal 15
Golf Fitting Locations No. 805 / 41
G = Mounting for wiper, interval potentiometer and multifunction system:
3 - Rear wash/wipe signal
6 - MFI interval potentiometer earth
7 - Intermittent speeds signal
H= Mounting for steering angle sensor:
4 - Steering angle sender, 12 Volt voltage supply
5 - Steering angle sender, 5 Volt voltage supply
Golf Fitting Locations No. 805 / 42
10 - Photoelectric beam 7
I = Mounting for coil connector:
7 - Earth for coil connector, multifunction steering wheel and horn
8 - CCS detent off or horn
9 - LIN bus or heated steering wheel temperature sensor
10 - Multifunction steering wheel voltage supply terminal 15
Front passenger door control unit -J387-
On inner part of front right door -arrow-
Note:
The illustration shows the left side. The right side is similar.
Connector assignment:
A - Front passenger door control unit -J387-
B - 32-pin connector -T32b-, on wiring harness
C - 16-pin connector -T16g-, on wiring harness
D - 20-pin connector -T20b-, on wiring harness
Driver door control unit -J386-
On inner part of front left door -arrow-
Connector assignment:
A - Driver door control unit -J386-
B - 32-pin connector -T32a-, on wiring harness
C - 16-pin connector -T16a-, on wiring harness
D - 20-pin connector -T20a-, on wiring harness
W-box coupling point
The W-box coupling point is located on bulkhead on left in plenum chamber -arrow-
Note:
For a clearer illustration the wiper system is not shown.
Note:
The W-box has been discontinued as of model year 2006.
Connectors:
A - 12-pin connector -T12b-, blue, on wiring harness
B - 11-pin connector -T11a-, white, on wiring harness
C - 12-pin connector -T12c-, green, on wiring harness
D - 11-pin connector -T11-, red, on wiring harness
Note:
The W-box has been discontinued as of model year 2006.
We use cookies on our website to give you the most relevant experience by remembering your preferences and repeat visits. By clicking “Accept All”, you consent to the use of ALL the cookies. However, you may visit "Cookie Settings" to provide a controlled consent.
Manage consent