Wiring Diagram VW GOLF 2009 - Control unit with display for radio and navigation - Radio - Connection for external audio sources - Interface for external multimedia unit
https://portal-diagnostov.com/license.html
https://portal-diagnostov.com/license.html
Automotive Electricians Portal FZCO
Automotive Electricians Portal FZCO J503 | Control unit with display for radio and navigation |
J533 | Data bus diagnostic interface |
R | Radio |
R199 | Connection for external audio sources |
R215 | Interface for external multimedia unit, under centre armrest, front |
T3at | 3-pin connector |
T4bj | 4-pin connector, in front centre armrest, USB connection |
T12 | 12-pin connector |
T12t | 12-pin connector |
T16b | 16-pin connector |
T20 | 20-pin connector |
T30 | 30-pin connector |
45 | Earth point, centre behind dash panel |
370 | Earth connection 5, in main wiring harness |
371 | Earth connection 6, in main wiring harness |
A178 | Connection (infotainment CAN bus, high), in dash panel wiring harness |
A179 | Connection (infotainment CAN bus, low), in dash panel wiring harness |
A225 | Connection 2 (infotainment CAN bus, high) in dash panel wiring harness |
A226 | Connection 2 (infotainment CAN bus, low) in dash panel wiring harness |
VW GOLF 2009 Overview of control units
Overview of control units | q | Fitting locations / connector assignment Golf blue-e-motion: -V141- , -J842- , -JX1- , -Z115- , -V469- , -AX4- , -AX5- , -AX6- , -R68- , -R69- |
Control unit for headlight range control -J431- , cornering light and headlight range control unit -J745- |
q | Camera control unit -J852- |
q | Fitting location, near interior mirror |
12 - | Driver door control unit -J386- |
Dash panel insert -K- , dash panel insert control unit -J285- |
27 - | Gas mode control unit -J659- (from November 2010) |
On bulkhead, on right in engine compartment -arrow- | | | |
A - | ABS control unit -J104- |
B - | 47-pin connector -T47- , on wiring harness |
VW GOLF 2009 Auxiliary heater control unit J364
Auxiliary heater control unit -J364- |
1 - | Auxiliary heater control unit -J364- |
q | -A-8-pin connector -T8f- |
q | -B-2-pin connector -T2g- |
VW GOLF 2009 Airbag control unit J234
Airbag control unit -J234- |
- | Under centre console, front -1- |
q | Connector assignment 50-pin connector -T50- |
q | Connector assignment 75-pin connector -T75- |
q | Connector assignment 100-pin connector -T100- |
Connector assignment 50-pin connector -T50- : |
1 - | Airbag control unit -J234- |
2 - | 50-pin connector -T50- , on wiring harness |
Connector assignment 75-pin connector -T75- : |
A - | Airbag control unit -J234- |
B - | 75-pin connector -T75-, on wiring harness |
Connector assignment 100-pin connector -T100- : |
1 - | Airbag control unit -J234- |
A - | 100-pin connector -T100- , on wiring harness |
VW GOLF 2009 Control unit for headlight range control -J431- , control unit for bend lighting and headlight range control -J745- | On right of glove compartment -arrow- | | | |
A - | Control unit for headlight range control -J431- , control unit for bend lighting and headlight range control -J745- |
B - | Connector, 26-pin connector -T26b- , 26-pin connector -T26h- on wiring harness |
VW GOLF 2009 Fresh air blower control unit J126
Fresh air blower control unit -J126- |
1 - | Fresh air blower control unit -J126- |
q | on heater and air conditioner unit, front passenger footwell |
q | -A-2-pin connector -T2- |
q | -B-6-pin connector -T6- |
Note: The illustration shows left-hand drive model. The view of the front passenger side for a RHD model is basically a mirror image. | | | |
VW GOLF 2009 Voltage stabiliser J532
Voltage stabiliser -J532- |
1 - | Voltage stabiliser -J532- |
q | on heater and air conditioner unit, front passenger footwell |
q | -A-10-pin connector -T10ah- |
VW GOLF 2009 Front passenger door control unit J387Front passenger door control unit -J387- | Inside front right door -arrow- | Note: Only the left side is shown. The right side is similar. | | | |
A - | Front passenger door control unit -J387- |
B - | 32-pin connector -T32b- |
C - | 16-pin connector -T16g- |
D - | 20-pin connector -T20b- |
VW GOLF 2009
Automatic anti-dazzle interior mirror -Y7- /front camera for driver assist systems -R242- |
1 - | Automatic anti-dazzle interior mirror -Y7- /front camera for driver assist systems -R242- |
q | -A-8-pin connector -T8- |
VW GOLF 2009 Entry and start authorisation control unit J518
Entry and start authorisation control unit -J518- |
1 - | Entry and start authorisation control unit -J518- |
next to steering column, near centre console |
q | -A-32-pin connector -T32b- |
VW GOLF 2009 Multifunction steering wheel control unit J453
Multifunction steering wheel control unit -J453- |
1 - | Multifunction steering wheel control unit -J453- |
in operating unit of the multifunction buttons on left of steering wheel -E440- |
q | -A-6-pin connector -T6bo- |
q | -B-12-pin connector -T12k- |
VW GOLF 2009 Data bus diagnostic interface J533Data bus diagnostic interface -J533- | Left-hand drive model: in driver's footwell, near centre console -arrow- | Right-hand drive model: in driver's footwell near onboard supply control unit -J519- , behind relay carrier | | | |
1 - | Data bus diagnostic interface -J533- |
2 - | 20-pin connector -T20- |
VW GOLF 2009 Driver door control unit J386Driver door control unit -J386- | Inside front left door -arrow- | | | |
A - | Driver door control unit -J386- |
B - | 32-pin connector -T32b- |
C - | 16-pin connector -T16a- |
D - | 20-pin connector -T20a- |
VW GOLF 2009 Steering column electronics control unit -J527- , to model year 2010 | under steering column, near steering column switch -arrow- | | | |
Steering column electronics control unit -J527- , from model year 2010 |
1 - | Steering column electronics control unit -J527- |
q | Near steering column switch |
q | -A-16-pin connector -T16r- |
q | -B-4-pin connector -T4k- |
Connector assignment -T16r--A- : |
1 - | Positive connection 8 (30a), in interior wiring harness -B504- |
2 - | Earth connection 2, in main wiring harness -367- |
3 - | Connection 1 (convenience CAN bus, low), in main wiring harness -B406- |
4 - | Connection 1 (convenience CAN bus, high), in main wiring harness -B397- |
5 - | Connection (CCS) in main wiring harness -B441- |
6 - | Positive connection (50) in the main wiring harness -B276- (not for Kessy) |
7 - | Terminal S, (Radio Ultra Low) |
11 - | Connection (shift lock), in the main wiring harness -B454- (not for Kessy) |
12 - | Connection 1 (powertrain CAN bus, low), in main wiring harness -B390- |
13 - | Connection 6 (powertrain CAN bus, high), in main wiring harness -B388- |
14 - | Connection 1 in main wiring harness -B465- , terminal 15 (not for Kessy) |
Connector assignment -T4k--B- : |
1 - | Airbag control unit -J234- + |
2 - | Airbag control unit -J234- - |
VW GOLF 2009 Electronic steering column lock control unit J764
Electronic steering column lock control unit -J764- |
1 - | Electronic steering column lock control unit -J764- |
Behind steering column trim |
q | -A-16-pin connector -T16s- |
VW GOLF 2009
Dash panel insert -K- , dash panel insert control unit -J285- |
1 - | Dash panel insert -K- / Dash panel insert control unit -J285- |
-1-Fuel gauge sender -G- (full), fuel pump control unit -J538- |
-A-32-pin connector -T32- |
2 - | Fuel gauge sender -G- (empty) |
7 - | Immobiliser reader coil -D2- |
8 - | Immobilizer reader coil 2 -D3- |
9 - | Sliding sunroof adjustment control unit -J245- , speed signal, output |
11 - | Oil level and oil temperature sender -G266- |
15 - | Front left brake pad wear sender -G34- |
16 - | Earth connection 22, in main wiring harness -367- |
17 - | Washer fluid level warning lamp -K37- |
18 - | Coolant temperature and coolant shortage warning lamp -K28- |
19 - | Ambient temperature sensor -G17- |
20 - | Earth connection 1 (sender earth), in main wiring harness -410- |
25 - | Parking brake warning lamp -K139- |
26 - | Brake fluid level warning lamp -K33- |
27 - | Oil pressure warning lamp -K3- |
28 - | Data bus diagnostic interface -J533- |
29 - | Data bus diagnostic interface -J533- |
31 - | Fuse 6 on fuse holder B -SB6- |
32 - | Positive connection 8 (30a) in dash panel wiring harness -B504- |
VW GOLF 2009 Traffic data aerial R173Traffic data aerial -R173- | Behind dash panel insert -K--arrow- | | | |
VW GOLF 2009 Onboard supply control unit J519Onboard supply control unit -J519- | under dash panel on driver side, under relay carrier | Connector assignment 52-pin connector -T52B--white- | Connector assignment 52-pin connector -T52C--brown- | Connector assignment for Blue-E-Motion with engine code EAAA 52-pin connector -T52 A--black- | Connector assignment for Blue-E-Motion with engine code EAAA 52-pin connector -T52 B--white- | Connector assignment for Blue-E-Motion with engine code EAAA 52-pin connector -T52 C--brown- | | | |
52-pin connector -T52 A- black -A- |
1 - | Fuse 26 on fuse holder B -SB26- |
3 - | Luggage compartment light -W3-(1 |
4 - | Left washer jet heater element -Z20- , right washer jet heater element -Z21- |
5 - | Left headlight main beam bulb -M30- |
6 - | Left daytime running light bulb -L174- |
9 - | Rear right turn signal bulb -M8- |
10 - | Front left turn signal bulb -M5- |
11 - | Left headlight dipped beam bulb -M29- |
12 - | Rear lid lock unit -F256-Luggage compartment light -W3- |
13 - | Rear lid handle release button -E234- |
14 - | Bonnet contact switch -F266- |
16 - | Reversing light switch -F4- |
17 - | Rear fog light switch -E18- |
18 - | Light switch -E1- , zero position |
19 - | Light switch -E1- , side lights |
20 - | Light switch -E1- , driving light assist |
21 - | Fog light switch -E7- |
22 - | Light switch -E1- , dip beam |
23 - | Earth connection 2, in main wiring harness-367- |
24 - | Fuse 3 on fuse holder B -SB3- , terminal 30 |
25 - | Left fog light bulb -L22- |
26 - | Right brake and tail light bulb -M22- |
27 - | Left tail light bulb -M4- , rear left tail light |
28 - | Right daytime running light bulb -L175- |
29 - | Rear lid lock unit -F256- |
30 - | Rear right door contact switch -F11- |
35 - | Heater/heat output switch -E16- |
36 - | Interior monitoring deactivation switch -E267- |
42 - | Earth connection 21, in main wiring harness -386- |
43 - | Rear window wiper motor -V12- , windscreen and rear window washer pump -V59- |
44 - | Right side light bulb -M3- |
45 - | Additional brake light bulb -M25- |
46 - | Tank filler flap locking motor -V155- |
48 - | Rear left central locking lock unit -F222- |
49 - | Rear right door central locking motor, lock -V215- |
52-pin connector -T52 B- white-B- |
1 - | Fuse 45 on fuse holder C -SC45- , central locking |
2 - | Rear window wiper motor -V12-Windscreen and rear window washer pump -V59- |
11 - | Rear lid release motor -V139- |
12 - | Terminal 15 voltage supply relay -J329- |
14 - | Heater/heat output switch -E16-Heated rear window warning lamp -K10- |
15 - | Switch and instrument illumination regulator -E20- |
16 - | Sliding sunroof control unit -J245- |
17 - | Sliding sunroof adjustment control unit -J245- , convenience closing |
21 - | Heated front seats control unit -J774- heated seat switched off |
22 - | Heated rear window relay -J9- |
24 - | Hazard warning lights button -E229- , indicator lamp for hazard warning light -K6- |
28 - | X-contact relief relay -J59- |
29 - | Terminal 50 voltage supply relay -J682- |
30 - | Switch and instrument illumination regulator -E20- |
33 - | Wiper motor control unit -J400- , rain and light detector sensor -G397- LIN bus |
36 - | Alarm horn -H12-interior monitoring sensor -G273- vehicle Inclination sensor -G384- , LIN bus |
37 - | Interior monitoring deactivation switch -E267- , interior monitoring off warning lamp -K162- , fuel supply relay -J643- , fuel pump control unit -J538- |
38 - | Fuel supply relay -J643- |
40 - | Headlight washer system relay -J39- |
41 - | Dual tone horn relay -J4- |
42 - | Fuse 46 on fuse holder C -SC46- |
43 - | Positive connection 1 (30 g), in main wiring harness -B559- |
50 - | Left footwell lamp -W9- , right footwell lamp -W10- |
51 - | Connection 1 (58d), in main wiring harness -B340- |
52 - | Earth connection 1, in main wiring harness -366- |
52-pin connector -T52 C- brown-C- |
3 - | Right tail light bulb -M2- |
4 - | Left brake and tail light bulb -M21- |
5 - | Earth connection 21, in main wiring harness -386- |
7 - | Hazard warning lights button -E229- |
10 - | Connection 1 (TK), in interior wiring harness -B154- , front interior light -W1- |
13 - | Steering column electronics control unit -J527- , ignition/starter switch -D- , terminal S |
14 - | Positive connection 1 (50), in main wiring harness -B239- , Steering column electronics control unit -J527- |
15 - | Data bus diagnostic interface -J533- , connection 2 (convenience CAN bus, high), in main wiring harness -B398- |
16 - | Data bus diagnostic interface -J533- , connection 2 (convenience CAN bus, low), in main wiring harness -B407- |
17 - | Brake light switch -F- |
25 - | Right fog light bulb -L23- |
26 - | Left side light bulb -M1- |
27 - | Number plate light -X- |
28 - | Rear right fog light bulb -L47-Right reversing light bulb -M17- |
30 - | Mechatronic unit for dual clutch gearbox -J743- , clutch position sender -G476- |
31 - | Steering column electronics control unit -J527- |
32 - | Converter with socket, 12 V-230 V -U13- terminal L |
35 - | Switch and instrument illumination regulator -E20- |
40 - | Central locking and anti-theft alarm system aerial -R47- , aerial screening |
41 - | Central locking and anti-theft alarm system aerial -R47- |
42 - | Fuse 16 on fuse holder B -SB16- |
46 - | Right headlight main beam bulb -M32- |
47 - | Left rear fog light bulb -L46- , left reversing light bulb -M16- |
50 - | Front right turn signal bulb -M7- |
51 - | Rear left turn signal bulb -M6- |
52 - | Right headlight dipped beam bulb -M31- |
VW GOLF 2009 Onboard supply control unit -J519- Blue-E-Motion | | | |
Blue-E-Motion 52-pin connector -T52 A- black-A- |
1 - | Fuse 26 on fuse holder B -SB26- |
5 - | Left headlight main beam bulb -M30- |
6 - | Left daytime running light bulb -L174- |
9 - | Rear right turn signal bulb -M8- |
10 - | Front left turn signal bulb -M5- |
11 - | Left headlight dipped beam bulb -M29- |
12 - | Rear lid lock unit -F256-Luggage compartment light -W3- |
13 - | Rear lid handle release button -E234- |
14 - | Bonnet contact switch -F266- |
16 - | Reversing light switch -F4- |
17 - | Rear fog light switch -E18- |
18 - | Light switch -E1- , zero position |
19 - | Light switch -E1- , side lights |
20 - | Light switch -E1- , driving light assist |
21 - | Fog light switch -E7- |
22 - | Light switch -E1- , dip beam |
23 - | Earth point, in front right footwell-47- |
24 - | Battery monitor control unit -J367- , fuse 3 on fuse panel B -SB3- terminal 30 |
25 - | Left fog light bulb -L22- |
26 - | Right brake and tail light bulb -M22- |
27 - | Left tail light bulb -M4- , rear left tail light |
28 - | Right daytime running light bulb -L175- |
29 - | Rear lid lock unit -F256- |
30 - | Rear right door contact switch -F11- |
36 - | Interior monitoring deactivation switch -E267- |
42 - | Earth connection 21, in main wiring harness -386- |
43 - | Rear window wiper motor -V12- , windscreen and rear window washer pump -V59- |
44 - | Right side light bulb -M3- |
45 - | Additional brake light bulb -M25- |
46 - | Actuator for high-voltage charging flap lock 1 -F496- , Actuator for high-voltage charging flap lock 2 -F497- |
48 - | Rear left central locking lock unit -F222- |
49 - | Rear right door central locking motor, lock -V215- |
Blue-E-Motion 52-pin connector -T52 B- white -B- |
1 - | Fuse 45 on fuse holder C -SC45- , central locking |
2 - | Rear window wiper motor -V12-Windscreen and rear window washer pump -V59- |
5 - | Actuator for high-voltage charging flap lock 1 -F496- , Actuator for high-voltage charging flap lock 2 -F497- |
11 - | Rear lid release motor -V139- |
12 - | Terminal 15 voltage supply relay -J329- |
14 - | Heater/heat output switch -E16-Heated rear window warning lamp -K10- |
15 - | Switch and instrument illumination regulator -E20- |
21 - | Heated front seats control unit -J774- heated seat switched off |
22 - | Heated rear window relay -J9- |
23 - | Heated windscreen relay -J47- |
24 - | Hazard warning lights button -E229- , indicator lamp for hazard warning light -K6- |
28 - | X-contact relief relay -J59- |
29 - | Terminal 50 voltage supply relay -J682- |
30 - | Switch and instrument illumination regulator -E20- |
33 - | Wiper motor control unit -J400- , rain and light detector sensor -G397- LIN bus |
36 - | Alarm horn -H12- , Interior monitoring sensor -G273- , LIN bus |
37 - | Interior monitoring deactivation switch -E267- , interior monitoring off warning lamp -K162- , fuel supply relay -J643- , fuel pump control unit -J538- |
38 - | Fuel supply relay -J643- |
40 - | Headlight washer system relay -J39- |
41 - | Dual tone horn relay -J4- |
42 - | Fuse 46 on fuse holder C -SC46- |
43 - | Positive connection 1 (30 g), in main wiring harness -B559- |
50 - | Left footwell lamp -W9- , right footwell lamp -W10- |
51 - | Connection 1 (58d) in main wiring harness -B340- , switch illumination bulb -L156- , driving program button -E598- , immediate charge button -E766- , selector lever -E313- |
52 - | Earth connection on A-pillar, lower left -44- , earth connection on upper steering column -605- |
Blue-E-Motion 52-pin connector -T52 C- brown-C- |
3 - | Right tail light bulb -M2- |
4 - | Left brake and tail light bulb -M21- |
5 - | Earth connection on A-pillar, lower left -44- , earth connection on upper steering column -605- |
7 - | Hazard warning lights button -E229- |
10 - | Connection 1 (TK), in interior wiring harness -B154- , front interior light -W1- |
13 - | Steering column electronics control unit -J527- , ignition/starter switch -D- , terminal S |
14 - | Connection 1 in the main wiring harness -B465- , steering column electronics control unit -J527- , |
15 - | Data bus diagnostic interface -J533- , connection 2 (convenience CAN bus, high), in main wiring harness -B398- |
16 - | Data bus diagnostic interface -J533- , connection 2 (convenience CAN bus, low), in main wiring harness -B407- |
17 - | Brake light switch -F- , Engine control unit -J623- |
25 - | Right fog light bulb -L23- |
26 - | Left side light bulb -M1- |
27 - | Number plate light -X- |
28 - | Right reversing light bulb -M17- |
31 - | Steering column electronics control unit -J527- |
35 - | Switch and instrument illumination regulator -E20- |
40 - | Central locking and anti-theft alarm system aerial -R47- , aerial screening |
41 - | Central locking and anti-theft alarm system aerial -R47- |
42 - | Fuse 16 on fuse holder B -SB16- |
46 - | Right headlight main beam bulb -M32- |
47 - | Rear left fog light bulb -L46- |
50 - | Front right turn signal bulb -M7- |
51 - | Rear left turn signal bulb -M6- |
52 - | Right headlight dipped beam bulb -M31- |
Parking aid control unit -J446- | On left under dash panel, behind relay carrier above onboard supply control unit -2- | Connector on parking aid control unit 446 -1- | | | |
1 - | Parking aid control unit -J446- |
A - | 16-pin connector -T16j- |
B - | 12-pin connector -T12v- |
C - | 12-pin connector -T12n- |
A - | 16-pin connector -T16j- |
2 - | Rear parking aid warning buzzer -H15- |
4 - | Parking aid button -E266- |
6 - | Data bus diagnostic interface -J533- , connection 1 (powertrain CAN bus, high), in main wiring harness -B383- |
8 - | Earth connection 10, in main wiring harness -375- |
10 - | Rear parking aid warning buzzer -H15- 1 |
13 - | Parking aid warning lamp -K136- |
15 - | Data bus diagnostic interface -J533- , connection 1 (powertrain CAN bus, low), in main wiring harness -B390- |
B - | 12-pin connector -T12v- |
1 - | Front left sender for park assist steering on left side of vehicle -G568- 3 |
2 - | Front left sender for park assist steering on left side of vehicle -G568- 1 |
3 - | Front parking aid warning buzzer -H22- 2 |
4 - | Front parking aid warning buzzer -H22- 1 |
5 - | Front left parking aid sender -G255- 2 |
6 - | Front centre left parking aid sender -G254- 2 |
7 - | Front centre right parking aid sender -G253- 2 |
8 - | Front right parking aid sender -G252- 2 |
C - | 12-pin connector -T12n- |
2 - | Rear centre right parking aid sender -G205- 2 |
3 - | Rear centre left parking aid sender -G204- 2 |
4 - | Rear right parking aid sender -G206- 2 |
5 - | Rear left parking aid sender -G203- 2 |
8 - | Rear left parking aid sender -G203- 3 |
11 - | Rear left parking aid sender -G203- 1 |
VW GOLF 2009 Park assist steering control unit J791Park assist steering control unit -J791- | On left under dash panel, behind relay carrier above onboard supply control unit -2- | Connector on parking aid control unit J791-1- | | | |
1 - | Park assist steering control unit -J791- |
A - | 16-pin connector -T16j- |
B - | 12-pin connector -T12v- |
C - | 12-pin connector -T12n- |
A - | 16-pin connector -T16j- |
1 - | Positive connection 1 (15), in interior wiring harness -A217- |
2 - | Rear parking aid warning buzzer -H15- |
4 - | Parking aid button -E266- |
6 - | Data bus diagnostic interface -J533- , connection 1 (powertrain CAN bus, high), in main wiring harness -B383- |
8 - | Earth connection 10, in main wiring harness -375- |
9 - | Warning light for park assist steering -K241- 2 |
10 - | Rear parking aid warning buzzer -H15- 1 |
13 - | Parking aid warning lamp -K136- |
15 - | Data bus diagnostic interface -J533- , connection 1 (powertrain CAN bus, low), in main wiring harness -B390- |
16 - | Park assist steering button -E581- |
B - | 12-pin connector -T12v- |
1 - | Front left sender for park assist steering on left side of vehicle -G568- 3 |
2 - | Front left sender for park assist steering on left side of vehicle -G568- 1 |
3 - | Front parking aid warning buzzer -H22- 2 |
4 - | Front parking aid warning buzzer -H22- 1 |
5 - | Front left parking aid sender -G255- 2 |
6 - | Front centre left parking aid sender -G254- 2 |
7 - | Front centre right parking aid sender -G253- 2 |
8 - | Front right parking aid sender -G252- 2 |
9 - | Front left sender for park assist steering on left side of vehicle -G568- 2 |
10 - | Front right sender for park assist steering on right side of vehicle -G569- 2 |
C - | 12-pin connector -T12n- |
2 - | Rear centre right parking aid sender -G205- 2 |
3 - | Rear centre left parking aid sender -G204- 2 |
4 - | Rear right parking aid sender -G206- 2 |
5 - | Rear left parking aid sender -G203- 2 |
8 - | Rear left parking aid sender -G203- 3 |
11 - | Rear left parking aid sender -G203- 1 |
VW GOLF 2009 Automatic gearbox control unit J217Automatic gearbox control unit -J217- | In front left wheel housing -arrow- | | | |
- | Automatic gearbox control unit -J217--arrow- |
VW GOLF 2009 Battery monitor control unit J367Battery monitor control unit -J367- | On earth cable battery terminal clamp | Note: Models with start/stop system or Golf blue-e-motion only. | | | |
VW GOLF 2009 Gas mode control unit -J659- (from November 2010) | on front of left longitudinal member -arrow- | Note: Only for engine code CHGA | | | |
Note:
Warning, special pin on connector! |
A - | Gas mode control unit -J659- |
B - | 48-pin connector -T48b- |
C - | 32-pin connector -T32c- |
VW GOLF 2009 Mechatronic unit for dual clutch gearbox J743
Mechatronic unit for dual clutch gearbox -J743- |
1 - | Mechatronic unit for dual clutch gearbox -J743- |
Pin connector on gearbox: |
q | -A-20-pin connector -T20e- , on wiring harness |
q | Illustration is valid for dual clutch gearbox 02E |
q | Dual clutch gearbox 0AM 25-pin connector -T25- , on wiring harness |
VW GOLF 2009 Power steering control unit J500Power steering control unit -J500- | On steering on centre of assembly carrier -arrow- | | | |
A - | Power steering control unit -J500- |
B - | 5-pin connector -T5g- |
C - | 5-pin connector -T5h- |
D - | 2-pin connector -T2a- |
VW GOLF 2009 Radiator fan control unit J293
Radiator fan control unit -J293- |
1 - | Radiator fan control unit -J293- |
q | -A/B-4-pin connector -T4x- , on wiring harness |
VW GOLF 2009 Engine control unit J623Engine control unit -J623- | under plenum chamber cover -arrow- | | | |
154-pin connector assignment: |
A - | Engine control unit -J623- |
B - | 94-pin connector -T94- |
C - | 60-pin connector -T60- |
Note:
-T154- is made up of items B and C. |
VW GOLF 2009 Gas mode control unit -J659- (to November 2010) | under plenum chamber cover -arrow- | Note: | | |
A - | Gas mode control unit -J659- |
B - | 56-pin connector -T56-, on wiring harness |
VW GOLF 2009 Fitting locations for Golf blue-e-motionFitting locations for Golf blue-e-motion | DANGER! High voltage may be deadly! | | Note: Read the information before beginning work on the high-voltage (HV) system → Rep.-Gr. 93 | Fitting locations/connector assignment: | Installed location electric drive motor -V141- | Installed location control unit for air conditioning compressor -J842- | Installed location electrical air conditioner compressor -V470- | Pin assignment control unit for air conditioning compressor -J842- | Installed location electric drive power and control electronics -JX1- | Pin assignment power and control electronics for electric drive -JX1- | Installed location high-voltage heater (PTC) -Z115- | Pin assignment high-voltage heater (PTC) -Z115- | Installed location Brake servo vacuum pump -V469- | Pin assignment brake servo vacuum pump -V469- | Installed location charger 1 for high-voltage battery -AX4- | Installed location charger 2 for high-voltage battery -AX5- | Installed location charger 3 for high-voltage battery -AX6- | Installed location exterior speaker -R68- / exterior speaker 2 -R69- | Pin assignmentexterior speaker -R68- | Pin assignment exterior speaker 2 -R69- | | | |
Installed location three-phase current drive -VX54- , electric drive motor -V141- |
1 - | Electric drive motor -V141- |
2 - | 14-pin connector -T14h- |
3 - | 8-pin connector -T8 an- , (electrical air conditioner compressor -V470- ) |
Installed location control unit for air conditioner compressor -J842- |
1 - | Connection and distribution box 1 -SX1- |
2 - | 5-pin connector -T5ah- , high-voltage wire for electrical air conditioner compressor -P3- , sheathed line, orange |
3 - | Control unit for air conditioner compressor -J842- |
Installed location electrical air conditioner compressor -V470- |
1 - | Electric air-conditioner compressor -V470- |
Pin assignment control unit for air conditioner compressor -J842- |
1 - | 8-pin connector -T8an- |
2 - | Control unit for air conditioner compressor -J842- / 5-pin connector -T5ai- , electrical A/C compressor high-voltage cable -P3- , sheathed line, orange |
Installed location electric drive power and control electronics -JX1- |
1 - | High-voltage charge current distributor -SX4- |
Pin assignment power and control electronics for electric drive -JX1- |
1 - | Power and control electronics for electric drive -JX1- |
2 - | High-voltage cable for the power and control electronics, negative -P10- |
3 - | High-voltage cable for the power and control electronics, positive -P9- |
4 - | 80-pin connector -T80a- |
5 - | High-voltage wiring harness for drive motor -PX2- , High-voltage wire 1 for drive motor -P4- |
6 - | High-voltage wiring harness for drive motor -PX2- , High-voltage wire 2 for drive motor -P5- |
7 - | High-voltage wiring harness for drive motor -PX2- , High-voltage wire 3 for drive motor -P6- |
High-voltage heater (PTC) -Z115- |
1 - | High-voltage heater (PTC) -Z115- |
Pin assignment high-voltage heating system (PTC) -Z115- |
1 - | High-voltage heater (PTC) -Z115- |
2 - | 4-pin connector -T4cv- |
3 - | 5-pin connector -T5aj- , high-voltage wire for high-voltage heating (PTC) -P11- , sheathed line, orange |
Installed location Brake servo vacuum pump -V469- |
1 - | Brake servo vacuum pump -V469- |
3 - | Charge pressure sender -G31- |
Pin assignment brake servo vacuum pump -V469- |
1 - | Brake servo vacuum pump -V469- |
2 - | 2-pin connector -T2cg- |
Charging unit 1 for high-voltage battery -AX4- |
1 - | 23-pin connector -T23a- |
2 - | Charging unit 1 for high-voltage battery -AX4- |
3 - | 6-pin connector -T6bv- , high-voltage wire for charging unit 1/high-voltage charge current distributor -P15- , sheathed line, orange |
4 - | 6-pin connector -T6bs- , high-voltage wire for charging unit 1/wiring junction -P12- , sheathed line, orange |
Charging unit 2 for high-voltage battery -AX5- |
1 - | 6-pin connector -T6bw- , charger 2/high-voltage charge network distributor high-voltage cable -P16- , sheathed line, orange |
2 - | 6-pin connector -T6bt- , high-voltage wire for charging unit 2/wiring junction -P13- , sheathed line, orange |
3 - | Charging unit 2 for high-voltage battery -AX5- |
4 - | 23-pin connector -T23b- |
Charging unit 3 for high-voltage battery -AX6- |
1 - | Charging unit 3 for high-voltage battery -AX6- |
2 - | 23-pin connector -T23c- |
3 - | 6-pin connector -T6bx- , high-voltage wire for charging unit 3/high-voltage charge current distributor -P17- , sheathed line, orange |
4 - | 6-pin connector -T6bu- , high-voltage wire for charging unit 3/wiring junction -P14- , sheathed line, orange |
Installed location exterior speaker -R68- / exterior speaker 2 -R69- |
1 - | External loudspeaker 2 -R69- |
2 - | External loudspeaker -R68- |
Pin assignmentexterior speaker -R68- | 1 - | External loudspeaker -R68- | 2 - | 2-pin connector -T2- | | | |
Pin assignmentexterior speaker 2 -R69- | 1 - | External loudspeaker 2 -R69- | 2 - | 2-pin connector -T2- | | | |