ENGINE PERFORMANCE – BMW 528i 2013 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.0L TURBO

2.0L Turbo, Engine Performance Wiring Diagram (1 of 5) for BMW 528i 2013

List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (1 of 5) for BMW 528i 2013:

• (front left side of engine) knock sensor cylinder 1 & 2
• (rear left side of engine) knock sensor cylinder 3 & 4
• (rear of intake manifold) intake-manifold pressure sensor
• Activation elec throttle vlv act
• Activation oil press ctrl valv
• Activation throttle vlv act
• Activation vol ctrl vlv
• Crankshaft sens gnd
• Crankshaft sens sig
• Crankshaft sens sply
• Crankshaft sensor (lower left rear of crankcase)
• Digital motor electronics (dme) control module (top rear of engine)
• Elec throttle vlv act gnd
• Elec throttle vlv act sig
• Int air temp pres gnd
• Int air temp pres sens
• Int pipe pres sens gnd
• Int pipe pres sens sply
• Knock sens sig
• Lin bus sig
• Nca
• Oil lvl sens gnd
• Oil lvl sens sig
• Oil lvl sens sply
• Oil press ctrl vlv sply
• Oxy sens aft cat conv sply
• Oxygen sens aft cat conv gnd
• Oxygen sens bef cat conv gnd
• Oxygen sens bef cat conv sply
• Oxygen sens sig
• Oxygen sensor after catalytic converter
• Press sens gnd
• Press sens sig
• Press sens sply
• Quantity control valve
• Rail press sens gnd
• Rail press sens sply
• Rail pressure sensor (on right cylinder head fuel rail)
• Red
• Starting/charging system
• Temp sens sig
• Venturi nozzle pressure sensor
• Vol ctrl vlv sply
• Wastegate valve pressure converter
• Wastegate vlv activation press conv
• Wastegate vlv press conv sply

2.0L Turbo, Engine Performance Wiring Diagram (2 of 5) for BMW 528i 2013

List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (2 of 5) for BMW 528i 2013:

• (bottom of oil pan) oil level sensor
• (right side of engine) intake air temperature pressure sensor
• Bypass blow-off valve
• Electric coolant pump (left side of engine)
• Electromotive throttle actuator
• Engine ventilation heating
• Exhaust vanos solenoid actuator
• Fuse 50a
• Hot at all times
• Intake camshaft sensor (left front of cylinder head)
• Intake vanos solenoid actuator
• Nca
• Oil pressure control valve
• Oxygen sensor before catalytic converter
• Power distribution box (in engine compt)
• Red
• Tank vent valve
• X664 2b
• Z6000 3b

2.0L Turbo, Engine Performance Wiring Diagram (3 of 5) for BMW 528i 2013

List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (3 of 5) for BMW 528i 2013:

• Activation
• Activation blow-off vlv
• Activation characteristic map hermostat
• Activation charcoal filter vlv
• Activation elect coolant pump
• Activation vlvelct rly
• Blow-off valve sply
• Characteristic map
• Charcoal filter vlv sply
• Digital motor electronics (dme) control module (top rear of engine)
• Dme main relay
• Engine coolant temp sens gnd
• Engine oil press/temp sens gnd
• Engine oil press/temp sens sig
• Engine oil press/temp sens sply
• Engine vent heating gnd
• Engine vent heating sply
• Exhaust activation vanos solenoid vlv
• Exhaust camshaft sens gnd
• Exhaust camshaft sens sig
• Exhaust camshaft sens sply
• Exhaust vanos sol valv sply
• Fuel injectors sply
• Fuse 100a
• Fuse 15a
• Fuse 20a
• Fuse 40a
• Fuse box (under spare tire)
• Gnd
• Hot at all times
• Hot-film air mass meter gnd
• Hot-film air mass meter sig
• Hot-film air mass meter sply
• Ignition & fuel injection relay
• Inlet activation vanos sol vlv
• Intake camshaft sens gnd
• Intake camshaft sens sig
• Intake camshaft sens sply
• Intake vanos sol vlv sply
• Lin bus sig
• Motor position sensor
• Mtr activation
• Mtr position snse gnd
• Mtr position snse sig
• Mtr position snse sply
• Power distribution box (in engine compt)
• Red
• Sply ign
• Sply valvetronic
• Temp sens sig
• Terminal 15 sply
• Thermostat supy
• Valvetronic actuator motor
• Valvetronic relay
• X60189
• Z10 3b (lower right front of engine compt)
• Z6000 4b

2.0L Turbo, Engine Performance Wiring Diagram (4 of 5) for BMW 528i 2013

List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (4 of 5) for BMW 528i 2013:

• (forward of rear power distribution box) dc/dc converter
• Car access system (lower left center of dash)
• Characteristic map thermostat
• Computer data lines system
• Electric fuel pump (below right rear seat)
• Engine coolant temperature sensor (top front of engine)
• Engine oil pressure/ temperature sensor (left side of engine)
• Exhaust camshaft sensor (left front of cylinder head)
• Exhaust flap electric changeover valve (left side of rear compt)
• Exterior lights system
• Fuel pump
• Fuel pump control (ekps)
• Fuse 10a
• Fuse 20a
• Fuse 5a
• Gnd
• Hot film air mass meter (in engine air intake duct)
• Hot w/ terminal 15n relay energized
• Hot w/ terminal 30b relay energized
• Junction box (right side of dash)
• Nca
• Pt can
• Pwr sply
• Rear fuse holder (right side of rear compt)
• Red
• Wake up
• Z10 16b (under spare tire)

2.0L Turbo, Engine Performance Wiring Diagram (5 of 5) for BMW 528i 2013

List of elements for 2.0L Turbo, Engine Performance Wiring Diagram (5 of 5) for BMW 528i 2013:

• (above 1 cylinders) ignition coil cylinder 1
• (above 2 cylinders) ignition coil cylinder 2
• (above 3 cylinders) ignition coil cylinder 3
• (above 4 cylinders) ignition coil cylinder 4
• (top of engine) fuel injectors
• 11b
• Accelerator pedal module (part of acceleration pedal assembly)
• Anti-theft system
• Brake light switch (left side of dash)
• Cas sub-bus
• Computer data lines system
• Cooling fans system
• Digital motor electronics (dme) control module (top rear of engine)
• Electric fan activation
• Engine start sig
• Engine start sig electric fan activation cut-out rly
• Flexray bus sig
• Fuel inj 1 activation
• Fuel inj 1 sply
• Fuel inj 2 activation
• Fuel inj 2 sply
• Fuel inj 3 activation
• Fuel inj 3 sply
• Fuel inj 4 activation
• Fuel inj 4 sply
• Fuse 5a
• Hall sens gnd
• Hall sens sig
• Hall sens sply
• Hall sensor sig
• Hot at all times
• Ign coil 1 activation
• Ign coil 1 sply
• Ign coil 2 activation
• Ign coil 2 sply
• Ign coil 3 activation
• Ign coil 3 sply
• Ign coil 4 activation
• Ign coil 4 sply
• Lin bus sig
• Natural vacuum leak detection
• Natural vacuum leak detection electric changeover vlv
• Nca
• Plug spark
• Pnk
• Pressure switch
• Pt-can bus sig
• Rear fuse holder (right side of rear compt)
• Red
• Spark plug
• Speed sig
• Term 30b pwr sply
• Terminal 15 sply
• Terminal 15 wake-up sig
• Z10 13b (right "c" pillar)
• Z10 9b (left kick panel)
• Z6000 1b
• Z6000 2b