ENGINE PERFORMANCE – Chevrolet SSR 2004 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

5.3L VIN T

5.3L VIN T, Engine Performance Wiring Diagram (1 of 5) for Chevrolet SSR 2004

List of elements for 5.3L VIN T, Engine Performance Wiring Diagram (1 of 5) for Chevrolet SSR 2004:

• (engine harn, near breakout to fuel injs)
• (engine harn, near breakout to map sensor)
• (lower right rear side of engine) crankshaft position (ckp) sensor
• +5v
• 3-2 ss ctrl
• A/c press +5v
• A/c system
• Abs system
• Batt volt
• C12
• Ckp 12v ref
• Ckp sig
• Cls 2 data
• Cmp low ref
• Cmp sig
• Computer data lines system
• Cooling fans system
• D12
• Ect sig
• Engine coolant temperature sensor (left front of engine block, near generator)
• Ftp +5v
• G101 (lower left front of engine)
• Gnd
• Ho2s hi 1,1
• Ho2s hi 1,2
• Ho2s hi 2,1
• Ho2s hi 2,2
• Ho2s lo 1,1
• Ho2s lo 1,2
• Ho2s lo 2,1
• Ho2s lo 2,2
• Hot at all times
• Hot in accy, run & start
• Hot in run & start
• Ign 0 fuse 47 10a
• Ign 0 volt
• Ign 1 volt
• Inj 1 ctrl
• Inj 2 ctrl
• Inj 3 ctrl
• Inj 4 ctrl
• Inj 5 ctrl
• Inj 6 ctrl
• Inj 7 ctrl
• Inj 8 ctrl
• Inj a fuse 23 15a
• Inj b fuse 24 15a
• Injectors
• Ks 1 signal
• Ks 2 signal
• Lo spd cool
• Low ref
• Map +5v
• Map low ref
• O2a fuse 25 15a
• O2b fuse 26 15a
• Pcm b fuse 20a
• Pnk
• Powertrain control module (left front side of engine compt)
• Prnd a sig
• Prnd b sig
• Prnd p sig
• Range b
• Range c
• Rear fuse block
• Red
• Req torq sig
• S100
• S101
• S102
• S200
• Serial data
• Start relay
• Starting/ charging system
• Tan
• Tcc/brk sig
• Tft low ref
• Underhood fuse block (left side of eng compt)

5.3L VIN T, Engine Performance Wiring Diagram (2 of 5) for Chevrolet SSR 2004

List of elements for 5.3L VIN T, Engine Performance Wiring Diagram (2 of 5) for Chevrolet SSR 2004:

• (chassis harn, near breakout to fuel pump & sender assembly) s403
• Camshaft position sensor (top center rear of engine)
• F/pmp relay
• Fuel pump & sender assembly (inside fuel tank)
• G100 (lower left front of engine)
• G101 (lower left front of engine)
• G401 (on left middle frame body mount)
• Heated oxygen sensor (bank 1 sensor 1) (left exhaust pipe, ahead of converter)
• Heated oxygen sensor (bank 1 sensor 2) (left exhaust pipe, behind converter)
• Heated oxygen sensor (bank 2 sensor 1) (right exhaust pipe, ahead of converter)
• Heated oxygen sensor (bank 2 sensor 2) (right exhaust pipe, behind converter)
• Hot at all times
• Knock sensor 1 (top front center of engine)
• Knock sensor 2 (top rear center of engine)
• Nca
• Park/neutral position switch (on lower left side of transmission)
• Pcm b fuse 29 20a
• Pnk
• Red
• S101
• Tan
• Underhood fuse block (left side of engine compt)

5.3L VIN T, Engine Performance Wiring Diagram (3 of 5) for Chevrolet SSR 2004

List of elements for 5.3L VIN T, Engine Performance Wiring Diagram (3 of 5) for Chevrolet SSR 2004:

• 1-2 sol
• 2-3 sol
• 3-2 sol
• A/t fluid pressure manual valve position switch
• Automatic transaxle
• Engine oil pressure (eop) sensor (top center rear of engine)
• Evaporative emission (evap) canister purge solenoid (top front center of engine)
• Evaporative emission canister vent solenoid (front right side of fuel tank)
• Fluid temp sensor
• Fuel tank pressure sensor (top rear of fuel tank)
• Manifold absolute pressure sensor (top rear center of engine)
• Pnk
• Pressure control solenoid
• Red
• Rev
• Tan
• Tcc pwm sol
• Tcc sol
• Vehicle speed sensor (right rear of transmission)

5.3L VIN T, Engine Performance Wiring Diagram (4 of 5) for Chevrolet SSR 2004

List of elements for 5.3L VIN T, Engine Performance Wiring Diagram (4 of 5) for Chevrolet SSR 2004:

• (above accelerator pedal) accelerator pedal position sensor
• App sens 1
• App sens 2
• B10
• Canister fuse 3 10a
• Cruise control
• Cruise control system
• Cruise on
• Data
• E12
• Etc fuse 15a
• Exterior lights system
• G101 (lower left front of engine)
• Ground
• Hot at all times
• Hot in run or start
• Iat
• Ign 1 volt
• Intake air temperature (iat)/ mass airflow (maf) sensor (between air cleaner assembly & throttle body)
• Low ref
• Maf
• Pnk
• R/a input
• Rear fuse block (rear center of passenger compartment)
• Red
• Ref low
• S/c input
• S101
• St/lp fuse 12 15a
• Stop- lamp switch (top of brake pedal bracket)
• Stp lp in
• Tac cntrl
• Tac ctrl
• Tan
• Throttle actuator control module (left rear of engine compt)
• Throttle body
• Tp sens 1
• Tp sens 2
• Underhood fuse block (left side of engine compt)
• Veh stop fuse 34 15a

5.3L VIN T, Engine Performance Wiring Diagram (5 of 5) for Chevrolet SSR 2004

List of elements for 5.3L VIN T, Engine Performance Wiring Diagram (5 of 5) for Chevrolet SSR 2004:

• (ignition coil harness)
• (lower left rear of engine) g102
• 1-2 ss ctrl
• 2-3 ss ctrl
• A/c clu rly
• A/c press sens
• A/c system
• A12
• Air conditioning system
• Anti-lock brakes system
• Cmp 12v ref
• Cooling fans system
• Crank fuse 10a
• Crank volt
• Css sig
• Ctrl
• Delivered torq
• Eng 1 fuse 6 10a
• Engine speed
• Engine speed signal
• Evap purge
• Evap vent ctrl
• Fuel lev sig
• Fuel press sig
• G101 (lower left front of engine)
• Gen field
• Gen on sig
• Gnd
• Hi spd cool
• Ho2s htr 1,1
• Ho2s low 1,2
• Ho2s low 2,1
• Ho2s low 2,2
• Hot in run & start
• Hot in start
• Iat low ref
• Iat sig
• Ign
• Ign ctrl 1
• Ign ctrl 2
• Ign ctrl 3
• Ign ctrl 4
• Ign ctrl 5
• Ign ctrl 6
• Ign ctrl 7
• Ign ctrl 8
• Ign e fuse 9 10a
• Ignition coils
• Instrument cluster system
• Instrument panel cluster
• Low ref
• Low ref bank 1
• Low ref bank 2
• Maf sig
• Malfunction indicator lamp
• Map sig
• Mil ctrl
• Nca
• Nca nca
• Pc sol hi ctrl
• Pc sol lo ctrl
• Pcm 1 fuse 13 10a
• Pmp rly ctrl
• Pnk
• Powertrain control module (left front side of engine compt)
• Press sens sig
• Prnd c sig
• Red
• Ref lo
• S101
• S107
• S108
• S109
• S110
• S118
• S119
• S203
• Spark plug
• Starting/charging system
• Tan
• Tcc pwm ctrl
• Tcc sol ctrl
• Tft sens sig
• Underhood fuse block (left side of engine compt)
• Vss high sig
• Vss low sig
• Vss out