ENGINE PERFORMANCE – Dodge Cab & Chassis R3500 1995 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

3.9L

3.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 3.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995:

• (located in exhaust pipe)
• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of intake)
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G125
• G125 (below a/c compressor)
• G14
• G21
• Generator
• Heated oxygen sensor
• Hot at all times
• Htd oxygen sensor
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (rear of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Link connector (right side cowl)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

3.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 3.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995:

• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor (in distributor)
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c (behind knee bolster)
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of transmission)

5.2L

5.2L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.2L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995:

• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Inj driver 7
• Inj driver 8
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side of dash panel)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

5.2L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.2L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995:

• (behind knee bolster)
• (in distributor)
• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c
• Joint connector c (behind knee bolster)
• Maintenance required lamp
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)

5.9L

5.9L Diesel, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.9L Diesel, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995:

• (front of cylinder head)
• (fuel gauge)
• (left fender side shield)
• (right side of dash panel)
• (tach)
• A/c comp cl rly gnd
• A/c damped press sw
• A/t only
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Battery
• Brake sense
• C13
• C20
• Center
• Cluster system
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Engine data link connector (right side
• F18
• Fuel heater (near fuel filter)
• Fuel heater relay
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (front of cylinder head)
• G14
• G21
• G85
• G86
• Generator
• Generator field
• Heated intake air system (on intake manifold)
• Heated intake air system relay #1 (left fender side shield)
• Heated intake air system relay #2 (left fender side shield)
• Hot at all times
• Htd intake rly #1
• Htd intake rly #2
• Ign feed
• Ignition switch
• Instrument
• Instrument cluster system
• Instrument cluster system (message center)
• Intake air temp
• K20
• K21
• K22
• K24
• K51
• K54
• Knock sensor gnd
• M/t only
• Mil
• Of dash panel)
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Red/
• Red/ tan
• Run
• S21
• S22
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans overheat lamp
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Wait to start
• Water in fuel sensor
• Z12

5.9L Diesel, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.9L Diesel, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995:

• (front of cylinder head)
• (in pwr dist ctr)
• (on transmission)
• (top of injection pump)
• A/t
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Check engine lamp
• Cylinder head)
• Engine
• Engine speed sensor (front of engine)
• Fuel shut down relay (left side shield)
• Fuel shutdown solenoid (mounted on injection pump)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• Fuse link 2 40a
• G125
• G206 (i/p left center support)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (rear of intake)
• Joint connector c (behind knee bolster)
• M/t
• Pnk
• Power distribution center
• Red/
• Relay
• Speedo- meter
• Starter motor)
• Starting system (engine
• Starting system (hot in start)
• Stop lamp & vehicle speed control switch
• Tan
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)
• Warnings system
• Water-in fuel sensor (left side of engine)

5.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.9L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995:

• (right side of dash panel)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr dist ctr)
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Cluster system (fuel gauge)
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Evap/purge solenoid
• Evap/purge solenoid (left rear of engine)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G100 (below horns)
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil driver
• Ign feed
• Ignition coil (right front of engine)
• Ignition switch
• Inj driver 1
• Inj driver 2
• Inj driver 3
• Inj driver 4
• Inj driver 5
• Inj driver 6
• Inj driver 7
• Inj driver 8
• Injectors
• Instrument
• Instrument cluster system (message center)
• Instrument cluster system (tach)
• K11
• K12
• K13
• K14
• K141
• K17
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K38
• K39
• K40
• K41
• K44
• K51
• K52
• K54
• K58
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side of dash panel)
• Map sensor
• Mil
• Nca
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• Starter rly
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

5.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 5.9L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995:

• (behind knee bolster)
• (in distributor)
• (on throttle body)
• (on transmission)
• A/t only
• Anti-lock brakes system (abs controller)
• B/h conn
• C215
• C216
• Camshaft position sensor
• Check engine lamp
• Crankshaft position sensor (right rear of engine)
• Engine coolant temperature sensor (front of engine)
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G206 (i/p left center support)
• Hot in run or start
• Instrument cluster
• Intake air temperature sensor (right front of intake)
• Joint connector c
• Joint connector c (behind knee bolster)
• Maintenance required lamp
• Map sensor (mounted on throttle body)
• Pnk
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle speed control switch
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (rear of trans- mission)

8.0L

8.0L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 8.0L, Engine Performance Wiring Diagrams (1 of 2) for Dodge Cab & Chassis R3500 1995:

• #10
• (below a/c compressor)
• (below horns)
• (right side of dash panel)
• (tach)
• A/c comp cl rly gnd
• A/c damped press sw
• A14
• A142
• Acc
• Air conditioning system
• Auto shutdown feed
• Auto shutdown relay
• Automatic shut down relay (in pwr
• B/h conn
• Brake sense
• C13
• C20
• Camshaft pos sensor
• Center
• Charge air temp
• Control module
• Cruise control system
• D20
• D21
• Data link receive
• Data link transmit
• Direct battery
• Dist ctr)
• Dist ign sensor (b+)
• Distribution
• Ect sensor
• Egr solenoid
• Egr solenoid (right rear of engine)
• Emrl
• Engine data
• Engine starter rly
• Evap/purge solenoid
• Evap/purge solenoid (rear of intake)
• F18
• Fuel
• Fuel pump relay (in pwr dist ctr)
• Fuel tank level gauge sending unit (top of fuel tank)
• Fuse 3 ign/acc 40a
• Fuse 4 eng 30a
• Fuse 8 fuel 20a
• Fuse 9 10a
• Fuse block: i/p
• G125
• G125 (below a/c compressor)
• G14
• G21
• G24
• Generator
• Hot at all times
• Htd oxygen sensor-lt
• Htd oxygen sensor-rt
• Iac motor
• Idle air control motor (on throttle body)
• Ign coil (4 pack)
• Ign coil (6 pack)
• Ign feed
• Ignition module
• Ignition switch
• Inj driver 1 & 10
• Inj driver 2 & 7
• Inj driver 3 & 6
• Inj driver 4 & 9
• Inj driver 5 & 8
• Injectors
• Instrument cluster system
• Instrument cluster system (fuel gauge)
• Instrument cluster system (message center)
• K113
• K114
• K115
• K116
• K137
• K138
• K141
• K158
• K18
• K19
• K20
• K21
• K22
• K24
• K35
• K39
• K40
• K41
• K43
• K44
• K51
• K52
• K54
• K59
• K60
• Left heated oxygen sensor
• Link connector (right side
• M/t
• Map sensor
• Mil
• Nca
• Of dash panel)
• Off
• Pnk
• Power
• Power ground
• Powertrain
• Red
• Right heated oxygen sensor
• Run
• Signal ref (b-)
• Start
• T18
• T41
• T54
• T60
• Tach output
• Tan
• Tan/red
• Throttle position
• Trans ctrl
• Trans lamp
• Trans od solenoid
• Trans od sw feed
• Trans temp lamp
• Trans temp sensor
• V31
• V32
• V33
• V35
• V36
• V40
• Voltage reg
• Vs ctrl-ign
• Vs ctrl-resume/accel
• Vs ctrl-set/coast
• Vs ctrl-vacuum
• Vs ctrl-vent
• Vss
• Z12

8.0L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995

List of elements for 8.0L, Engine Performance Wiring Diagrams (2 of 2) for Dodge Cab & Chassis R3500 1995:

• (on throttle body)
• (on transmission)
• (right fender side shield)
• A/t only
• B/h
• B/h conn
• C215
• C216
• Camshaft position sensor (on timing cover)
• Check engine lamp
• Conn
• Control
• Crankshaft position sensor (right side of engine, near motor mount)
• Engine coolant temperature sensor (front of engine)
• F18
• Fuse 11 10a
• Fuse 12 15a
• Fuse block: i/p
• G125 (below a/c compressor)
• G206 (i/p left center support)
• Hot in run or start
• Ignition coil 4-pack (rear of cylinder head)
• Ignition coil 6-pack (rear of cylinder head)
• Ignition module
• Instrument cluster
• Intake air temperature sensor (on intake manifold)
• Joint connector c (behind knee bolster)
• K137
• K138
• K17
• K32
• Maintenance required lamp
• Map sensor (on throttle body)
• Pnk
• Red/
• Speed
• Speedo- meter
• Starter relay)
• Starting system (engine
• Stop lamp & vehicle
• Switch
• Tan
• Throttle position sensor
• Transmission overdrive solenoid (mounted on transmission)
• Transmission overdrive switch
• Transmission range switch
• Transmission temperature sensor (in transmission cooler line)
• Upshift lamp
• Vehicle speed sensor (left side of trans- mission)
• Z12