ENGINE PERFORMANCE – Dodge Sprinter 2500 2009 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

3.0L DIESEL

3.0L Diesel, Engine Performance Wiring Diagram (1 of 4) for Dodge Sprinter 2500 2009

List of elements for 3.0L Diesel, Engine Performance Wiring Diagram (1 of 4) for Dodge Sprinter 2500 2009:

• (not used)
• 5v sply
• 87a
• Apps sig 1
• Apps sig 2
• Asd rly ctrl
• Asd rly out
• Body control frb module (fuse/ relay block)
• Can bus (+)
• Can bus (-)
• Clutch pedal sw
• Computer data lines system
• Ecm
• Egr switchover valve (on engine)
• Engine control module (in engine compt)
• Engine control relay
• Fuel pump module (under center of vehicle)
• Fuel pump rly
• Fuse 10a
• Fuse 20a
• Fuse 5a
• Fuse/relay block (left kick panel)
• Fused ignition sw out
• G103 (left rear of engine compt)
• G301 (lower left side of vehicle)
• Gnd
• Ground
• Hot at all times
• Hot w/ terminal 15 relay energized
• Lvl sig
• Rly ctrl
• Rly out
• Rtn
• S302
• Sens
• Sens 1 gnd
• Sens 2 gnd
• Sens gnd
• Sens sig
• Starting/charging system
• To fuel pump relay (diagram 3 of 4)
• U777
• Valve ctrl
• Vlv ctrl

3.0L Diesel, Engine Performance Wiring Diagram (2 of 4) for Dodge Sprinter 2500 2009

List of elements for 3.0L Diesel, Engine Performance Wiring Diagram (2 of 4) for Dodge Sprinter 2500 2009:

• (in air intake duct) boost pressure sensor
• (in engine compt) crankcase vent heater
• (in engine compt) exhaust differential pressure sensor
• (in exhaust) exhaust pressure sensor
• (on engine) egr valve
• (top of accelerator pedal) accelerator pedal position sensor
• (top of clutch pedal assembly) clutch pedal switch
• 5 volt
• Asd rly out
• Boost pressure actuator
• Computer data lines system
• Ctrl
• Exhaust temperature 1/2 sensor (in exhaust)
• Exhaust temperature 1/3 sensor (in exhaust)
• Fuel pressure sensor (in engine compt)
• Fused b(+)
• G103 (left rear of engine compt)
• G109 (left front of engine compt)
• G302 (left rear of engine compt)
• Glow plug 1 (top of cylinder 1)
• Glow plug 1 ctrl
• Glow plug 2 (top of cylinder 2)
• Glow plug 2 ctrl
• Glow plug 3 (top of cylinder 3)
• Glow plug 3 ctrl
• Glow plug 4 (top of cylinder 4)
• Glow plug 4 ctrl
• Glow plug 5 (top of cylinder 5)
• Glow plug 5 ctrl
• Glow plug 6 (top of cylinder 6)
• Glow plug 6 ctrl
• Glow plug module (in engine compartment)
• Gnd
• Gnd 2
• Ground
• Htr ctrl
• Intake swirl servo motor
• Lin bus
• Motor (+)
• Motor (-)
• Mtr ctrl
• Pnk
• Red
• Rly out
• S101
• S102 (left side engine compt)
• Sens gnd
• Sens sig
• Sig
• Sol ctrl
• Starting/ charging system
• Throttle body (on engine)
• U2032
• U748

3.0L Diesel, Engine Performance Wiring Diagram (3 of 4) for Dodge Sprinter 2500 2009

List of elements for 3.0L Diesel, Engine Performance Wiring Diagram (3 of 4) for Dodge Sprinter 2500 2009:

• (on engine) egr position sensor
• (on engine) fuel pressure solenoid
• (top of cylinder 1) fuel injector 1
• (top of cylinder 2) fuel injector 2
• (top of cylinder 3) fuel injector 3
• (top of cylinder 4) fuel injector 4
• (top of cylinder 5) fuel injector 5
• (top of cylinder 6) fuel injector 6
• 02 1/2 pump
• 12v
• 5v sply
• 87a
• Actr ctrl
• Computer data lines system
• Engine control module (in engine compt)
• Etc motor(+)
• Etc motor(-)
• Exhaust temperature 1/1 sensor (in exhaust)
• From fuse (diagram 1 of 4)
• Fuel inj 2 lo ctrl
• Fuel inj 3 lo ctrl
• Fuel inj 4 lo ctrl
• Fuel pump relay
• Fuel temperature sensor (in engine compt)
• Fuse 15a
• Fuse/relay block (left kick panel)
• Gnd
• Hi ctrl
• Hot at all times
• Left swirl sensor (on engine)
• Lin bus
• Lo ctrl
• Pnk
• Red
• Right swirl sensor (on engine)
• Sens gnd
• Sens sig
• Sens sig 1
• Sig
• Sol ctrl
• Swirl sig
• U2032

3.0L Diesel, Engine Performance Wiring Diagram (4 of 4) for Dodge Sprinter 2500 2009

List of elements for 3.0L Diesel, Engine Performance Wiring Diagram (4 of 4) for Dodge Sprinter 2500 2009:

• (front of engine) camshaft position sensor
• (in air intake duct) mass air flow sensor
• (in engine compt) inlet air pressure sensor
• (on engine) crankshaft position sensor
• 12v sply
• 5v sply
• A/c heater control
• Automatic a/c
• Common rail pump (top of engine)
• Ctrl rtn
• Current
• Df sig
• Egr tempe- rature sensor (on engine)
• Engine control module (in engine compt)
• Engine coolant temperature sensor (on engine)
• Fuel inj 1 hi ctrl
• Fuel inj 1 lo ctrl
• Fuel inj 2 hi ctrl
• Fuel inj 3 hi ctrl
• Fuel inj 4 hi ctrl
• Fuel inj 5 hi ctrl
• Fuel inj 5 lo ctrl
• Fuel inj 6 hi ctrl
• Fuel inj 6 lo ctrl
• Gnd
• Htr ctrl
• Intake air temperature sensor (in air intake duct)
• Intake swirl mtr ctrl
• Manual ac
• O2 1/2 pump
• O2 1/2 rtn
• O2 1/2 sig
• Oil tempe- rature sensor (on engine)
• Oxygen sensor
• Pump
• Right swirl sig
• Rtn
• S103 (left side engine compt)
• S120 (on diesel engine)
• S327 (on main body (hls) harness)
• Sens gnd
• Sens sig
• Sens sig 2
• Sig
• Sig 1
• Sig 2
• Sply
• Tp sig
• U760
• Water in fuel sensor