ENGINE PERFORMANCE – Dodge Sprinter 3500 2004 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.7L

2.7L, Engine Performance Wiring Diagram (1 of 5) for Dodge Sprinter 3500 2004

List of elements for 2.7L, Engine Performance Wiring Diagram (1 of 5) for Dodge Sprinter 3500 2004:

• (16-19 not used)
• (41-48 not used)
• (63-71 not used)
• (in air intake duct) intake air pressure sensor
• (in engine compt) fuel temperature sensor
• (left side of engine compt)
• (on engine)
• 5 volt
• Boost press servo ctrl
• Boost pressure servomotor
• Cps ground
• Cps sig
• Cps sig 1
• Cps sig 2
• Crankcase heater (in engine compt)
• Crankshaft position sensor
• Crnkcase htr ground
• Crnkcase htr sig
• Ctrl
• Ecm c1 cav 15/62 o2 sen 1/5
• Ecm c1 cav 39 o2 sen cav 6
• Ecm c1 cav 40 o2 sen cav 2
• Ecm c1 cav 72 os sen cav 3
• Ect sens ground
• Ect sens sig
• Egr valve (on engine)
• Egr vlv ctrl
• Engine control module (left end of dash)
• Fps ground
• Fps sig
• Fuel inj 1 high side ctrl
• Fuel inj 1 low side ctrl
• Fuel inj 2 high side ctrl
• Fuel inj 2 low side ctrl
• Fuel inj 3 high side ctrl
• Fuel inj 3 low side ctrl
• Fuel inj 4 high side ctrl
• Fuel inj 4 low side ctrl
• Fuel inj 5 high side ctrl
• Fuel inj 5 low side ctrl
• Fuel qlty ctrl vlv ctrl
• Fuel shutdwn sol ctrl
• Fuel temp sens ground
• Fuel temp sens sig
• Gnd
• Ign
• Intake press sens ground
• Intake press sens signal
• Maf sens ground
• Maf sens sig
• Mass air flow sensor (in air intake duct)
• S106
• S107
• S175
• Sig
• Sig 1
• Sig 2
• Water in fuel sen gnd
• Water in fuel sen sig

2.7L, Engine Performance Wiring Diagram (2 of 5) for Dodge Sprinter 3500 2004

List of elements for 2.7L, Engine Performance Wiring Diagram (2 of 5) for Dodge Sprinter 3500 2004:

• (in engine compt) fuel pressure sensor
• (in engine compt) water in fuel sensor
• (rear of engine compt) fuel quality control valve
• 12 volt
• 5 volt
• 87a
• Camshaft position sensor (on front left side of engine)
• Ecm c1 cav 15/62 o2 sen cav 1/5
• Ecm c1 cav o2 sen cav
• Engine control relay
• Engine coolant temperature sensor (on front of engine)
• Fuel injectors
• Fuel shutdown solenoid
• Fuse 15a
• Fuse block 1 (under steering column)
• Gnd
• Hot at all times
• Hot in run or start
• Nca
• Not used
• Oxygen sensor
• S107 common circuit
• S206
• S217
• Sig
• To wiper/turn signal engine start control module (diagram 5 of 5)

2.7L, Engine Performance Wiring Diagram (3 of 5) for Dodge Sprinter 3500 2004

List of elements for 2.7L, Engine Performance Wiring Diagram (3 of 5) for Dodge Sprinter 3500 2004:

• (top of accelerator pedal) accelerator pedal position sensor
• 87a
• Fuel pump
• Fuel pump relay
• Fuse 125a
• Fuse 15a
• Fuse block 1 (under steering column
• G100 (left front of engine compt)
• G202 (under driver's seat)
• Glow plug control module (left front of engine compt)
• Glow plug module control
• Glow plugs
• Gnd
• Gnd 1
• Hot at all times
• Nca
• Power distribution center (left side of engine compt)
• Red
• S108
• Sig 1
• Sig 2
• Starter motor relay

2.7L, Engine Performance Wiring Diagram (4 of 5) for Dodge Sprinter 3500 2004

List of elements for 2.7L, Engine Performance Wiring Diagram (4 of 5) for Dodge Sprinter 3500 2004:

• (front of engine compt) engine coolant level switch
• (in air intake duct) intake air temperature sensor
• (top of fuel tank) fuel level sensor
• (under dash) kickdown switch
• Can c bus (+)
• Can c bus (-)
• Daytime running lights relay (in relay block)
• Eng coolant level sw sig
• Fuel lev sens sig (+)
• Fuel lev sens sig rtn
• Fuse 15a
• Fuse block 3
• G100 (left front of engine compt)
• G200 (left rear of engine compt)
• G203 (behind left side of dash)
• High idle switch
• Hot in run and start
• Instrument cluster
• Nca
• S107
• S306

2.7L, Engine Performance Wiring Diagram (5 of 5) for Dodge Sprinter 3500 2004

List of elements for 2.7L, Engine Performance Wiring Diagram (5 of 5) for Dodge Sprinter 3500 2004:

• (in air intake duct) boost pressure sensor
• 5 volt
• Accel/set sig
• Apps ground 1
• Apps ground 2
• Apps sig 1
• Apps sig 2
• Boost press sen sig
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Cruise control system
• Data link connector (under dash)
• Decel/set sig
• Driver enhncd accdnt report
• Eng ctrl rly ctrl
• Eng ctrl rly sig
• Engine control module (left end of dash)
• Engine rpm
• From engine control relay (diagram 2 of 5)
• Fuel pump rly ctrl
• Fuse 15a
• Fuse block 1 (under steering column)
• Fused eng ctrl rly output
• Fused ign sw output (run/start)
• G200 (left rear of engine compt)
• Glw plug mod ctrl
• Gnd
• Ground
• High idle on sig
• Hot in run and start
• Hot in start
• Iat sens ground
• Iat sens sig
• Ign sw output (start)
• K-ecm
• Kickdwn sw sig
• Off sig
• Red
• Resume sig
• S200
• S219
• S231
• S232
• S259
• S260
• Sensor ground
• Sig
• Starter mtr rly ctrl
• Starting/charging system
• Transmission control module (under driver's seat)
• Verification sig
• Wiper/turn signal/ engine start control module