ENGINE PERFORMANCE – Dodge Sprinter 3500 2006 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

2.7L

2.7L, Engine Performance Wiring Diagram, Except OBD II (1 of 4) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, Except OBD II (1 of 4) for Dodge Sprinter 3500 2006:

• (in air intake duct) boost pressure sensor
• (in air intake duct) intake air temperature sensor
• (under dash) kickdown switch
• 12v supp
• 5 volt
• Accel/set sw
• Accelerator pedal position sensor (top of accelerator pedal)
• App +5v sup
• App sig 1
• App sig 2
• Boost pressure solenoid
• Bpp +5v
• Bpp 12v supp
• Bpp sol ctrl
• Can c bus +
• Can c bus -
• Computer data lines system
• Cruise control system
• Data link connector (under dash)
• Decel/set sig
• Ear drv
• Ene ctrl rly
• Eng ctrl rly sig
• Eng rpm
• Engine control module (left end of dash)
• Fuse 15a
• Fuse block 1 (under steering column)
• Glow plg mod
• Gnd
• Gnd 1
• Gnd 2
• High idle sw
• Hot in run or start
• Hot in start
• Iat sns sig
• Ign
• Ign sw
• Ign sw out
• K-ecm
• Kic dn sw
• Maf +5v
• Maf 12v supp
• Maf sig
• Mass air flow sensor (in air intake duct)
• Off sig
• Pres sig
• Red
• Resume sig
• Rly ctrl
• S200
• S219
• Sig
• Sig 1
• Sig 2
• Sns gnd
• Starting/charging system
• Ver sig
• Wiper/turn signal/ engine start control module

2.7L, Engine Performance Wiring Diagram, Except OBD II (2 of 4) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, Except OBD II (2 of 4) for Dodge Sprinter 3500 2006:

• (front of engine compt) engine coolant level switch
• (left rear of engine compt) g200
• (top of fuel tank) fuel level sensor
• (under driver's seat) s262
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Eng coolant level sw sig
• Eng ctrl rly ctrl
• Engine control module (left end of dash)
• Engine control relay
• Fuel lev sens sig (+)
• Fuel lev sens sig rtn
• Fuse 15a
• Fuse block 1 (under steering column)
• Fuse block 3 (under driver's seat)
• G100 (left front of engine compt)
• G203 (behind left side of dash)
• Ground
• High idle switch
• Hot at all times
• Instrument cluster
• Interior lights system
• Nca
• Rly ctrl out
• S107
• S217 (near ecm)
• S306
• Wiper/turn signal/ engine start control module

2.7L, Engine Performance Wiring Diagram, Except OBD II (3 of 4) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, Except OBD II (3 of 4) for Dodge Sprinter 3500 2006:

• (in engine compt) fuel temperature sensor
• 12v
• Camshaft position sensor (on front left side of engine)
• Engine coolant temperature sensor (on front of engine)
• Fuse 125a
• G100 (left front of engine compt)
• Glow plug control module (left front of engine compt)
• Glow plug module control
• Glow plugs
• Gnd
• Hot at all times
• Power distribution center (left side of engine compt)
• Red
• Sig

2.7L, Engine Performance Wiring Diagram, Except OBD II (4 of 4) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, Except OBD II (4 of 4) for Dodge Sprinter 3500 2006:

• (in engine compt) fuel pressure sensor
• (in engine compt) water in fuel sensor
• (left side
• (left side of engine compt)
• (on engine)
• (rear of engine compt) fuel pressure solenoid
• (top left side of engine) low fuel pressure sensor
• +5v sup
• +5v supp
• 12 volt
• 5 volt
• Ckp sig
• Cmp 12v sup
• Cmp sig
• Crankcase heater (in engine compt)
• Crankshaft position sensor
• Ect sig
• Egr ctrl
• Egr valve (on engine)
• Engine control module (left end of dash)
• Engine oil sensor (on engine)
• F pres sig
• F tmp sig
• Fp sns 5v
• Fp sns sig
• Fp sol ctrl
• Fs sol ctrl
• Fuel injectors
• Fuel shutdown solenoid
• G103
• Gnd
• Ground
• Inj 1 ctrl
• Inj 1 drv
• Inj 2 ctrl
• Inj 2 drv
• Inj 3 ctrl
• Inj 4 ctrl
• Inj 5 ctrl
• Of engine compt)
• Oil sig
• S175 (left side of engine compt)
• S176
• S177
• S178 (left side of engine compt)
• Sig
• Sns gnd
• Sol 12v sup
• Wif 12v sup
• Wif sig

2.7L, Engine Performance Wiring Diagram, OBD II (1 of 5) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, OBD II (1 of 5) for Dodge Sprinter 3500 2006:

• (41-48: not used)
• (63-71 not used)
• (on engine)
• 5 volt
• Boost press servo ctrl
• Boost pressure servomotor
• Cps ground
• Cps sig
• Cps sig 1
• Cps sig 2
• Crankcase heater (in engine compt)
• Crankshaft position sensor
• Crnkcase htr ground
• Crnkcase htr sig
• Ctrl
• Ect sens ground
• Ect sens sig
• Egr valve (on engine)
• Egr vlv ctrl
• Engine control module (left end of dash)
• Fps ground
• Fps sig
• Fuel inj 1 high side ctrl
• Fuel inj 1 low side ctrl
• Fuel inj 2 high side ctrl
• Fuel inj 2 low side ctrl
• Fuel inj 3 high side ctrl
• Fuel inj 3 low side ctrl
• Fuel inj 4 high side ctrl
• Fuel inj 4 low side ctrl
• Fuel inj 5 high side ctrl
• Fuel inj 5 low side ctrl
• Fuel press sol ctrl
• Fuel qlty ctrl vlv ctrl
• Fuel temp sens ground
• Fuel temp sens sig
• Fuel temperature sensor (in engine compt)
• Gnd
• Ign
• Intake air pressure sensor (left side of engine compartment)
• Intake press sens ground
• Intake press sens signal
• Maf sens ground
• Maf sens sig
• Mass air flow sensor (in air intake duct)
• O2 sens 1/1 cell sig
• O2 sens 1/1 pump cell ctrl
• O2 sens 1/1 pump cell sig
• O2 sens 1/1 virtual ground
• S106
• S107
• S175 (left side of engine compt)
• Sig
• Sig 1
• Sig 2
• Water in fuel sen gnd
• Water in fuel sen sig

2.7L, Engine Performance Wiring Diagram, OBD II (2 of 5) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, OBD II (2 of 5) for Dodge Sprinter 3500 2006:

• (in engine compt) fuel pressure sensor
• (in engine compt) water in fuel sensor
• (rear of engine compt) fuel quantity control valve
• 12 volt
• 5 volt
• Camshaft position sensor (on front left side of engine)
• Common circuit
• Eng ctrl rly ctrl
• Engine control relay
• Engine coolant temperature sensor (on front of engine)
• Fuel injectors
• Fuel pressure solenoid
• Fuse 15a
• Fuse block 1 (under steering column)
• Gnd
• Hot at all times
• Hot in run or start
• Nca
• O2 1/1 cell sig
• O2 1/1 gnd
• O2 1/1 htr ctrl
• O2 1/1 pump sig
• Oxygen sensor
• S206
• S217
• Sig
• Wiper/turn signal/ engine start control module

2.7L, Engine Performance Wiring Diagram, OBD II (3 of 5) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, OBD II (3 of 5) for Dodge Sprinter 3500 2006:

• (top of accelerator pedal) accelerator pedal position sensor
• 87a
• Fuel pump
• Fuel pump relay
• Fuse 125a
• Fuse 15a
• Fuse block 1 (under steering column)
• G100 (left front of engine compt)
• G202 (under driver's seat)
• Glow plug control module (left front of engine compt)
• Glow plug module control
• Glow plugs
• Gnd
• Gnd 1
• Hot at all times
• Nca
• Power distribution center (left side of engine compt)
• Red
• S108
• Sig 1
• Sig 2
• Starter motor relay

2.7L, Engine Performance Wiring Diagram, OBD II (4 of 5) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, OBD II (4 of 5) for Dodge Sprinter 3500 2006:

• (front of engine compt) engine coolant level switch
• (in air intake duct) intake air temperature sensor
• (top of fuel tank) fuel level sensor
• (under dash) kickdown switch
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Eng coolant level sw sig
• Fuel lev sens sig (+)
• Fuel lev sens sig rtn
• Fuse 15a
• Fuse block 3 (under driver's seat)
• G100 (left front of engine compt)
• G200 (left rear of engine compt)
• G203 (behind left side of dash)
• High idle switch
• Hot at all times
• Instrument cluster
• Interior lights system
• Nca
• S107
• S306

2.7L, Engine Performance Wiring Diagram, OBD II (5 of 5) for Dodge Sprinter 3500 2006

List of elements for 2.7L, Engine Performance Wiring Diagram, OBD II (5 of 5) for Dodge Sprinter 3500 2006:

• (in air intake duct) boost pressure sensor
• (under driver's seat) s260
• 5 volt
• Accel/set sig
• Apps ground 1
• Apps ground 2
• Apps sig 1
• Apps sig 2
• Boost press sen sig
• Can c bus (+)
• Can c bus (-)
• Computer data lines system
• Cruise control system
• Data link connector (under dash)
• Decel/set sig
• Driver enhncd accdnt report
• Eng ctrl rly sig
• Engine control module (left end of dash)
• Engine rpm
• Fuel pump rly ctrl
• Fuse 15a
• Fuse block 1 (under steering column)
• Fused eng ctrl rly output
• Fused ign sw (run/start)
• G200 (left rear of engine compt)
• Glw plug mod ctrl
• Gnd
• Ground
• High idle on sig
• Hot in run or start
• Hot in start
• Iat sens ground
• Iat sens sig
• Ign sw output (start)
• K-ecm
• Kickdwn sw sig
• Off sig
• Red
• Resume sig
• S200
• S219
• S259 (under driver's seat)
• Sensor ground
• Sig
• Starter mtr rly ctrl
• Starting/ charging system
• Transmission control module (in engine compartment)
• Verification sig
• Wiper/turn signal/ engine start control module