ENGINE PERFORMANCE – Ford Club Wagon E150 1997 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

4.2L

4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997

List of elements for 4.2L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997:

• (ends in harness)
• (engine control harn, near breakout to fuel octane sensor)
• (engine control harn, near breakout to mass air flow sensor)
• (front of right front fender) g101
• (upper left side of i/p) g202
• A/c on sig
• Air conditioning system
• Air ctrl sens
• Data link (+)
• Data link (-)
• Data link connector (partial) (left side of i/p)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dtr-tr1
• Dtr-tr2a
• Dtr-tr4
• Ect
• Engine compartment fuse box (left front of engine compt)
• Engine coolant temperature sensor (top front of engine, on heater outlet elbow)
• Evr sol
• Feps (eprom)
• Fp sending unit
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• Gnd
• Hot at all times
• Hot in run or start
• I/p fuse panel (below left side of i/p)
• Iat
• Ign coil 1
• Ign coil 2
• Ignition coils
• Imrc
• Imrp 1
• Imrp 2
• Instrument cluster system
• Maf
• Mil
• Misfire sens (+)
• Misfire sens (-)
• Nca
• Not used
• O/d off
• Octane sensor
• Overdrive cancel switch
• Pcm power diode
• Pcm power relay
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• R n
• Radio noise capacitor
• Red
• Rr ho2s sig (12)
• S110
• S127
• S140
• S142
• S147
• S205
• Shift sol 1
• Shift sol 2
• Spark plugs
• Tcs
• Tft
• To dtr sensor (diagram 4 of 4)
• Transmission control indicator lamp
• Vss (-)

4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997

List of elements for 4.2L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997:

• (behind upper left side of i/p)
• (engine control harn, near breakout to 76-pin conn in left rear of engine compt on cowl) s126
• (fuel charge harn, near breakout to throttle position sensor)
• (speedometer/ odometer) vehicle speed input
• C224
• C225
• Delta pressure feedback egr sensor (top left rear of engine)
• Engine compartment fuse box (left front of engine compt)
• Engine coolant temperature gauge
• Fuel octane sensor (near brake master cylinder)
• Fuel pump relay
• Fuel tank pressure transducer (near fuel tank)
• Fuse 30a
• G100 (front of left front fender)
• G101 (front of right front fender)
• G202
• Hot at all times
• Instrument cluster
• Instrumentation engine coolant temperature sensor (top front center of engine)
• Intake air temperature sensor (part of intake clean air tube)
• Intake manifold runner control (right rear top of engine)
• Intake manifold runner position sensor 1 (left rear of intake)
• Intake manifold runner position sensor 2 (right rear of intake)
• Malfunction indicator
• Misfire sensor (lower right front of engine)
• Misfire sensor shield
• Nca
• Red
• Red/pnk
• S103
• S104 (fuel charge harn, near breakout to 16-pin conn near a/c pressure cut-out switch)
• S107
• S138 (engine control harn, near breakout to fuel octane sensor)
• S139
• S167
• S205
• Throttle position sensor (attached to throttle body)

4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997

List of elements for 4.2L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997:

• (center rear of engine compt)
• (cutaways) in transit fuel pump module
• (engine control harn, in breakout to pcm)
• (engine control harn, near breakout to fuel octane sensor)
• (fuel charge harn, near breakout to fuel injector 2)
• (fuel charge harn, near breakout to fuel injector 3)
• (fuel tank harn, below left center of vehicle)
• (not used)
• (right side of i/p) inertia fuel shut-off switch
• (transmission control harn, near breakout to dtr sensor) s100
• (transmission control harn, near breakout to transmission)
• 4r70w transmission
• C116
• Egr solenoid (above left valve cover)
• Electronic pressure control solenoid
• Fuel injectors
• Fuel pump module
• G100 (front of left front fender)
• Idle air control valve (rear of engine on intake)
• Nca
• Output shaft speed sensor (left side of transmission)
• Red
• Red/pnk
• S102
• S105
• S106
• S136
• S137
• S307
• S309
• Shift solenoids
• Tan
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve

4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997

List of elements for 4.2L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997:

• (engine control harn, near breakout to fuel octane sensor)
• (left rear of engine compt) speed control servo/amplifier assembly
• (left side of transmission) vehicle speed sensor
• (not used)
• (right side of engine) knock sensor
• (under left rear of vehicle) evaporative emissions canister purge valve
• 240 ohms
• 5v ref
• Brake on/off
• Brake on/off switch
• C116
• Cylinder id
• Cylinder identification sensor (front center of engine)
• Cylinder identification sensor shield
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Dtr-tr3a
• Epc sol
• Evap sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel pump ctrl
• Fuel tank press
• Fuse 15a
• G100 (front of left front fender)
• G101 (front of right front fender)
• G202 (upper left side of i/p)
• Heater ctrl
• Hot at all times
• I/p fuse panel (below left side of i/p)
• Iac sol
• Ign coil 3
• Kap b(+)
• Knock sensor
• Left front heated oxygen sensor (ho2s 21) (lower left rear of engine)
• Left rear heated oxygen sensor (ho2s 22) (left rear of transmission)
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• Maf sens in
• Mass air flow sensor (center of engine compt, in air cleaner assembly)
• Nca
• Not used
• Oss (+)
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Right front heated oxygen sensor (ho2s 11) (lower right rear of engine)
• Right rear heated oxygen sensor (ho2s 12) (right rear of transmission)
• Rr ho2s
• S135
• S139
• S140
• S167
• S205
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Trans ctrl ind
• Vapor valve
• Vpwr
• Vss (+)
• Vss input

4.6L

4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997

List of elements for 4.6L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997:

• (ends in harness)
• (engine control harn, near breakout to fuel octane sensor)
• (engine control harn, near breakout to mass air flow sensor)
• (front of right front fender) g101
• (not used)
• (upper left side of i/p) g202
• A/c on sig
• Air conditioning system
• Air ctrl sens
• C116
• Data link (+)
• Data link (-)
• Data link connector (partial) (left side of i/p)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dtr-tr1
• Dtr-tr2a
• Dtr-tr4
• Ect
• Engine compartment fuse box (left front of engine compt)
• Evr sol
• Feps (eprom)
• Fp sending unit
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• Gnd
• Hot at all times
• Hot in run or start
• I/p fuse panel (below left side of i/p)
• Iat
• Ign coil 1
• Ign coil 2
• Ignition coils 1 & 2
• Ignition coils 3 & 4
• Imrc
• Instrument cluster system
• Maf
• Mil
• Misfire sens (+)
• Misfire sens (-)
• Nca
• Not used
• O/d off
• Octane sensor
• Overdrive cancel switch
• Pcm power diode
• Pcm power relay
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• R n
• Radio noise capacitor 1
• Radio noise capacitor 2
• Red
• Rr ho2s sig (12)
• S110
• S127
• S140
• S142
• S147
• S150
• S205
• Shift sol 1
• Shift sol 2
• Spark plugs
• Tcs
• Tft
• To dtr sensor (diagram 4 of 4)
• Transmission control indicator lamp
• Vss (-)

4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997

List of elements for 4.6L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997:

• (engine control harn, near breakout to 76-pin conn in left rear of engine compt on cowl) s126
• (engine control harn, near breakout to fuel injector 7)
• (engine ctrl harn, near breakout to fuel octane sensor)
• (fuel charge harn, near breakout to throttle position sensor)
• (speedometer/ odometer) vehicle speed input
• (top front center of engine) instrumentation engine coolant temperature sensor
• C224
• C225
• Delta pressure feedback egr sensor (top left rear of engine)
• Engine compartment fuse box (left front of engine compt)
• Engine coolant temperature gauge
• Fuel octane sensor (near brake master cylinder)
• Fuel pump relay
• Fuel tank pressure transducer (near fuel tank)
• Fuse 30a
• G100 (front of left front fender)
• G202 (upper left side of i/p)
• Hot at all times
• Inlet air control sensor (top front of engine)
• Instrument cluster
• Intake air temperature sensor (part of intake clean air tube)
• Malfunction indicator
• Misfire sensor (lower right front of engine)
• Misfire sensor shield
• Nca
• Red
• Red/pnk
• S103
• S104 (fuel charge harn, near breakout to 16-pin conn near a/c pressure cut-out switch)
• S133
• S138 (engine control harn, near breakout to fuel octane sensor)
• S139
• S154
• S167
• S205
• Throttle position sensor (attached to throttle body)

4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997

List of elements for 4.6L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997:

• (center rear of engine compt)
• (cutaways) in transit fuel pump module
• (engine control harn, in breakout to pcm)
• (engine control harn, near breakout to fuel injector 4)
• (engine control harn, near breakout to fuel injector 8)
• (engine control harn, near breakout to fuel octane sensor)
• (fuel tank harn, below left center of vehicle)
• (right side of i/p) inertia fuel shut-off switch
• (transmission control harn, near breakout to dtr sensor) s100
• (transmission control harn, near breakout to transmission)
• 4r70w transmission
• Egr solenoid (above left valve cover)
• Electronic pressure control solenoid
• Fuel injectors
• Fuel pump module
• G100 (front of left front fender)
• Idle air control valve (rear of engine on intake)
• Nca
• Output shaft speed sensor (left side of transmission)
• Red
• Red/pnk
• S102
• S136
• S137
• S151
• S152
• S307
• S309
• Shift solenoids
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve

4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997

List of elements for 4.6L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997:

• (engine control harn, near breakout to fuel octane sensor)
• (front of left head) cylinder head temperature sensor
• (left rear of engine compt) speed control servo/amplifier assembly
• (left side of transmission) vehicle speed sensor
• (right side of engine) knock sensor
• (under left rear of vehicle) evaporative emissions canister purge valve
• 240 ohms
• 5v ref
• Brake on/off
• Brake on/off switch
• Cyl head temp
• Cylinder id
• Cylinder identification sensor (front of left cylinder head)
• Cylinder identification sensor shield
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Dtr-tr3a
• Epc sol
• Evap sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 15a
• G100 (front of left front fender)
• G101 (front of right front fender)
• G202 (upper left side of i/p)
• Heater ctrl
• Hot at all times
• I/p fuse panel (below left side of i/p)
• Iac sol
• Ign coil 3
• Ign coil 4
• Kap b(+)
• Knock sensor
• Left front heated oxygen sensor (ho2s 21) (lower left rear of engine)
• Left rear heated oxygen sensor (ho2s 22) (left rear of transmission)
• Lf ho2s
• Lf ho2s sig (21)
• Lr ho2s
• Lr ho2s sig (22)
• Maf sens in
• Mass air flow sensor (center of engine compt, in air cleaner assembly)
• Nca
• Oss (+)
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Right front heated oxygen sensor (ho2s 11) (lower right rear of engine)
• Right rear heated oxygen sensor (ho2s 12) (right rear of transmission)
• Rr ho2s
• S135
• S139
• S140
• S167
• S205
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Trans ctrl ind
• Vapor valve
• Vpwr
• Vss (+)
• Vss input

5.4L

5.4L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997

List of elements for 5.4L, Engine Performance Wiring Diagrams (1 of 4) for Ford Club Wagon E150 1997:

• (ends in harness)
• (engine control harn, near breakout to coil per plug 6)
• (engine control harn, near breakout to fuel injector 1)
• (engine control harn, near breakout to mass air flow sensor)
• (front of right front fender) g101
• (upper left side of i/p)
• A/c on sig
• Air conditioning system
• Data link (+)
• Data link (-)
• Data link connector (partial) (left side of i/p)
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dtr-tr1
• Dtr-tr2
• Dtr-tr4
• E4od ccs
• E4od ss1
• E4od ss2
• Ect
• Engine compartment fuse box (left front of engine compt)
• Evr sol
• Feps (eprom)
• Fp sending unit
• Fuel pump mon
• Fuse 30a
• Fuse 5a
• G100 (front of left front fender)
• G202
• Gnd
• Hot at all times
• Hot in run or start
• I/p fuse panel (below left side of i/p)
• Iat
• Ign coil 1
• Ign coil 3
• Ign coil 5
• Ign coil 6
• Ignition coils
• Inlet air ctrl
• Instrument cluster system
• Maf
• Mil
• Misfire sens (+)
• Misfire sens (-)
• Nca
• Not used
• O/d off
• Octane sensor
• Od off ind
• Overdrive cancel switch
• Pcm power diode
• Pcm power relay
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• R n
• Radio noise capacitor
• Rear ho2s (22)
• Red
• S110
• S127
• S140
• S142
• S156
• S161
• S169
• S205
• Tcs
• Tft
• To dtr sensor (diagram 4 of 4)
• Transmission control indicator lamp
• Vss (-)

5.4L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997

List of elements for 5.4L, Engine Performance Wiring Diagrams (2 of 4) for Ford Club Wagon E150 1997:

• (engine control harn, near breakout to 76-pin conn in left rear of engine compt on cowl) s126
• (engine control harn, near breakout to coil per plug 9)
• (engine control harn, near breakout to fuel octane sensor) s136
• (engine control harn, near breakout to pcm)
• (speedometer/ odometer) vehicle speed input
• (top left front of engine) instrumentation engine coolant temperature sensor
• C224
• C225
• Delta pressure feedback egr sensor (top left rear of engine)
• Engine compartment fuse box (left front of engine compt)
• Engine coolant temperature gauge
• Fuel octane sensor (near brake master cylinder)
• Fuel pump relay
• Fuel tank pressure transducer (near fuel tank)
• Fuse 30a
• G100 (front of left front fender)
• G202 (upper left side of i/p)
• Hot at all times
• Instrument cluster
• Intake air temperature sensor (part of intake clean air tube)
• Knock sensor (top right rear side of engine)
• Malfunction indicator
• Misfire sensor (lower right front of engine)
• Misfire sensor shield
• Nca
• Red
• Red/pnk
• S137
• S138 (engine control harn, near breakout to fuel octane sensor)
• S157
• S158 (engine control harn, near breakout to radio noise capacitor 1)
• S169
• S170
• S171
• S205
• Throttle position sensor (attached to throttle body)

5.4L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997

List of elements for 5.4L, Engine Performance Wiring Diagrams (3 of 4) for Ford Club Wagon E150 1997:

• (center rear of engine compt)
• (cutaways) in transit fuel pump module
• (engine control harn, near breakout to coil per plug 2)
• (engine control harn, near breakout to fuel injector 6)
• (engine control, harn, near breakout to e4od transmission)
• (fuel tank harn, below left center of vehicle)
• (left front of engine)
• (right side of i/p) inertia fuel shut-off switch
• (transmission control harn, near breakout to dtr sensor)
• (transmission control harn, near breakout to transmission)
• Coast clutch solenoid
• E4od transmission
• Egr solenoid (top left rear of engine)
• Electronic pressure control solenoid
• Fuel injectors
• Fuel pump module
• G100 (front of left front fender)
• Idle air control valve (rear of engine on intake)
• Inlet air control sensor
• Nca
• Red
• Red/pnk
• S100
• S102
• S155
• S159
• S160
• S307
• S309
• Shift solenoid
• Tan
• Tan/ red
• Tan/red
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Vapor management valve

5.4L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997

List of elements for 5.4L, Engine Performance Wiring Diagrams (4 of 4) for Ford Club Wagon E150 1997:

• (engine control harn, near breakout to fuel octane sensor)
• (front of left head) cylinder head temperature sensor
• (left rear of engine compt) speed control servo/amplifier assembly
• (left side of transmission) vehicle speed sensor
• (under left rear of vehicle) evaporative emissions canister purge valve
• 270 ohms
• 5v ref
• Brake on/off
• Brake on/off switch
• Cyl head temp
• Cylinder id
• Cylinder identification sensor (front of left cylinder head)
• Cylinder identification sensor shield
• Digital transmission range sensor (dtr sensor) (left side of transmission)
• Dpfe sens
• Dtr-tr3a
• Epc sol
• Evap sol
• From dtr sensor (diagram 1 of 4)
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel pump ctrl
• Fuel tank press
• Fuse 15a
• G100 (front of left front fender)
• G101 (front of right front fender)
• G202 (upper left side of i/p)
• Heater ctrl
• Hot at all times
• I/p fuse panel (below left side of i/p)
• Idle air ctrl
• Ign coil 2
• Ign coil 4
• Ign coil 7
• Ign coil 8
• Kap b(+)
• Knock sensor
• Left front heated oxygen sensor (ho2s 21) (lower left rear of engine)
• Lf ho2s
• Lf ho2s sig (21)
• Maf sens in
• Mass air flow sensor (center of engine compt, in air cleaner assembly)
• Nca
• Powertrain control module (near brake master cylinder)
• Pwr gnd
• R ho2s
• Rear heated oxygen sensor (ho2s 22) (under center of vehicle)
• Red
• Red/pnk
• Rf ho2s
• Rf ho2s sig (11)
• Right front heated oxygen sensor (ho2s 11) (lower right rear of engine)
• S135
• S139
• S140
• S169
• S170
• S171
• S205
• Sig rtn
• Tan
• Tan/red
• Tcc sol
• Tp sens in
• Vapor valve
• Vpwr
• Vss (+)
• Vss input