ENGINE PERFORMANCE – Ford Econoline E150 2005 – SYSTEM WIRING DIAGRAMS

ENGINE PERFORMANCE

4.6L

4.6L, Engine Performance Wiring Diagram (1 of 5) for Ford Econoline E150 2005

List of elements for 4.6L, Engine Performance Wiring Diagram (1 of 5) for Ford Econoline E150 2005:

• (engine control sensor harn, near breakout to left rear of engine)
• A/c clutch rly
• A/c press sw
• A/c system
• Brake pressure sw
• C175b
• Ckp sensor +
• Ckp sensor -
• Cmp sensor sig
• Coil on plug
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Coil on plug 5
• Coil on plug 6
• Coil on plug 7
• Coil on plug 8
• Crankshaft position sensor (lower right front of engine)
• Cyl head temp
• Egr system (esm) module (top of left cylinder bank cover)
• Egr valve
• Egv cntrl
• Electronic throttle control (etc) motor (top right front of engine)
• Etc return
• Etc wot cntrl
• Evap purge valve
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Ho2s 11 htr
• Ho2s 11 input
• Ho2s 21 htr
• Ho2s 21 input
• Iat sensor
• Ignition transformer capacitor 1 (right front of engine)
• Ignition transformer capacitor 2 (left front of engine)
• Inj press regulator
• Injection pressure sensor (top left side of engine)
• Knock sensor (top right rear side of engine)
• Knock sensor +
• Knock sensor -
• Maf sensor
• Nca
• Pcv heat
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• Red/pnk
• Reference voltage
• S136
• S156
• S158
• S161
• Shield drain
• Signal return
• Tan
• Tan/red
• Throttle position sensor (top of engine, near air intake)
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return

4.6L, Engine Performance Wiring Diagram (2 of 5) for Ford Econoline E150 2005

List of elements for 4.6L, Engine Performance Wiring Diagram (2 of 5) for Ford Econoline E150 2005:

• (at center of engine compt) mass air flow (maf) sensor
• (engine control sensor harn, near breakout to left side of engine compt) s155
• (engine control sensor harn, right side of engine)
• (engine ctrl sensor harn, near break- out to left rear of engine compt)
• (in center rear of engine) evap canister purge valve
• (left side of engine compt) brake pressure switch
• Battery junction box (left side of engine compt)
• Camshaft position sensor (front of left cyl head)
• Cylinder head temperature sensor (top front of left cyl head)
• Fuel injectors
• Fuse 2a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Heated oxygen sensor (ho2s) 11 (right rear of engine)
• Heated oxygen sensor (ho2s) 21 (left rear of engine)
• Heated positive crankcase ventilation (pcv) element (top of right cylinder bank)
• Nca
• Red
• S159
• S160
• Tan
• Tan/red

4.6L, Engine Performance Wiring Diagram (3 of 5) for Ford Econoline E150 2005

List of elements for 4.6L, Engine Performance Wiring Diagram (3 of 5) for Ford Econoline E150 2005:

• (at left side of transmission) digital transmission range (dtr) sensor
• (at rear of transmission) output shaft speed (oss) sensor
• (left side of transmission) turbine shaft speed (tss) sensor
• (near breakout to center rear of transmission)
• 4r70e/4r75e transmission
• C175c
• Dtr tr1
• Dtr tr2
• Dtr tr3a
• Dtr tr4
• Electronic pressure control solenoid
• Epc sol
• Ho2s 12 htr
• Ho2s 12 input
• Ho2s 22 htr
• Ho2s 22 input
• Oss sig
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Press ctrl sol
• Red
• S198
• Shift sol a
• Shift sol b
• Shift solenoids
• Tft sensor sig
• Torque converter clutch solenoid
• Tr-p ground
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission fluid temperature sensor
• Tss sensor

4.6L, Engine Performance Wiring Diagram (4 of 5) for Ford Econoline E150 2005

List of elements for 4.6L, Engine Performance Wiring Diagram (4 of 5) for Ford Econoline E150 2005:

• (except stripped chassis: at right kick panel) (stripped chassis: behind left side of dash) inertia fuel shut- off switch
• (transmission harn, near breakout to c192) s102
• (transmission harn, near breakout to center rear of transmission)
• (under rear of vehicle, near tank) fuel pump driver module
• (window regulator relay harn, near breakout to steering column)
• Battery junction box (left side of engine compt)
• Brake pedal position switch (above brake pedal)
• Bus +
• Bus -
• Central junction box (behind left side of dash)
• Data link connector (below left side of dash)
• Fuel lvl
• Fuel pump
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• G302 (left rear under- body of vehicle)
• Heated oxygen sensor (ho2s) 12 (left of transmission)
• Heated oxygen sensor (ho2s) 22 (right of transmission)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Malfunction indicator lamp
• Nca
• O/d off
• Overdrive cancel switch
• Red
• S100
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• S228 (main harn, near breakout to left side of dash)
• S269
• Vref

4.6L, Engine Performance Wiring Diagram (5 of 5) for Ford Econoline E150 2005

List of elements for 4.6L, Engine Performance Wiring Diagram (5 of 5) for Ford Econoline E150 2005:

• (behind left side of dash, above accelerator pedal) accelerator pedal position (app) sensor
• (ends in harness)
• (if equipped) overhead console
• (left side of engine compt)
• (not used)
• (stripped chassis) s127
• A/c system, exterior lights system
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• C175a
• Can +
• Can -
• Canister vent
• Central junction box (behind left side of dash)
• Cluster pwr
• Cruise control system
• Evap canister vent valve (left rear of vehicle, near fuel tank)
• Ftp sensor
• Fuel pump rly
• Fuel tank pressure transducer sensor (in tank)
• Fuse 10a
• Fuse 30a
• G100
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Od cancel sw
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Programming sig
• Red
• Red/pnk
• Ref voltage
• S1021
• S1033
• S1065 (except stripped chassis)
• S135 (engine control harn, near breakout to left rear of engine compt)
• S142 (engine control sensor harn, near breakout to left rear of engine compt)
• S172
• Signal return
• Speed control sw
• Tach sig
• Tan
• Tcil ctrl
• Vem system in
• Vss +

5.4L

5.4L, Engine Performance Wiring Diagram, with Torqshift (1 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, with Torqshift (1 of 5) for Ford Econoline E150 2005:

• (engine control sensor harn, near breakout to left rear of engine)
• A/c clutch rly
• A/c press sw
• A/c system
• Brake pressure sw
• C175b
• Ckp sensor +
• Ckp sensor -
• Cmp sensor sig
• Coil on plug
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Coil on plug 5
• Coil on plug 6
• Coil on plug 7
• Coil on plug 8
• Crankshaft position sensor (lower center front of engine)
• Cyl head temp
• Differential pressure feedback egr sensor (top left side of engine)
• Dpfe sensor
• Egr vacuum regulator solenoid (above left rear of engine
• Egv cntrl
• Electronic throttle control (etc) motor (top right front of engine)
• Etc return
• Etc wot cntrl
• Evap purge valve
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel rail temp sens
• Ho2s 11 htr
• Ho2s 11 input
• Ho2s 21 htr
• Ho2s 21 input
• Iat sensor
• Ignition transformer capacitor 1 (right front of engine)
• Ignition transformer capacitor 2 (left front of engine)
• Inj press regulator
• Injection pressure & temperature sensor (front of left cylinder bank)
• Knock sensor (top right rear side of engine)
• Knock sensor +
• Knock sensor -
• Maf sensor
• Nca
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• Red/pnk
• Reference voltage
• S136
• S156
• S158
• S161
• Shield drain
• Signal return
• Tan
• Tan/red
• Throttle position sensor (top of engine, near air intake)
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return

5.4L, Engine Performance Wiring Diagram, with Torqshift (2 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, with Torqshift (2 of 5) for Ford Econoline E150 2005:

• (at center of engine compt) mass air flow (maf) sensor
• (engine control sensor harn, near breakout to left side of engine compt) s155
• (engine control sensor harn, right side of engine)
• (engine ctrl sensor harn, near break- out to left rear of engine compt)
• (left rear of engine) evap canister purge valve
• (left side of engine compt) brake pressure switch
• Battery junction box (left side of engine compt)
• Camshaft position sensor (front of left cyl head)
• Cylinder head temperature sensor (top front of left cyl head)
• Fuel injectors
• Fuse 2a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Heated oxygen sensor (ho2s) 11 (right rear of engine)
• Heated oxygen sensor (ho2s) 21 (left rear of engine)
• Nca
• Red
• S159
• S160
• Tan
• Tan/red

5.4L, Engine Performance Wiring Diagram, with Torqshift (3 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, with Torqshift (3 of 5) for Ford Econoline E150 2005:

• (transmission harn, in breakout to right side of transmission)
• (transmission harn, near breakout to center rear of transmission) s198
• C175c
• Ho2s 12 htr
• Ho2s 12 input
• Ho2s 22 htr
• Ho2s 22 input
• Intermediate shaft speed sensor
• Iss sensor
• Oss sensor
• Output shaft speed sensor (at rear of transmission)
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Pressure control (pc-a) solenoid
• Red
• Ref voltage
• S1037 (transmission harn, near breakout to top center transmission)
• S123
• Shift sol a
• Shift sol b
• Shift sol c
• Shift sol d
• Shift sol e
• Shift solenoid pressure control a (sspc-a)
• Shift solenoid pressure control b (sspc-b)
• Shift solenoid pressure control c (sspc-c)
• Shift solenoid pressure control d (sspc-d)
• Shift solenoid pressure control e (sspc-e)
• Signal return
• Speed sensor assembly (left side of transmission)
• Tcc sol
• Tft sensor
• Torqshift transmission
• Torque converter clutch solenoid
• Transmission fluid temperature sensor
• Transmission range sensor assembly (tr-p)
• Trs sensor
• Tss sensor
• Turbine shaft speed sensor

5.4L, Engine Performance Wiring Diagram, with Torqshift (4 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, with Torqshift (4 of 5) for Ford Econoline E150 2005:

• (except stripped chassis: at right kick panel) (stripped chassis: behind left side of dash) inertia fuel shut- off switch
• (transmission harn, near breakout to c192) s102
• (transmission harn, near breakout to center rear of transmission)
• (under rear of vehicle, near tank) fuel pump driver module
• (window regulator relay harn, near breakout to steering column)
• Battery junction box (left side of engine compt)
• Brake pedal position switch (above brake pedal)
• Bus +
• Bus -
• Central junction box (behind left side of dash)
• Data link connector (below left side of dash)
• Fuel lvl
• Fuel pump
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• G302 (left rear under- body of vehicle)
• Heated oxygen sensor (ho2s) 12 (left of transmission)
• Heated oxygen sensor (ho2s) 22 (right of transmission)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Malfunction indicator lamp
• Nca
• Red
• S100
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• S228 (main harn, near breakout to left side of dash)
• S269
• Tow/ haul switch
• Vref

5.4L, Engine Performance Wiring Diagram, with Torqshift (5 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, with Torqshift (5 of 5) for Ford Econoline E150 2005:

• (ends in harness)
• (engine control harn, at left center of engine)
• (engine control harn, near breakout to left rear of engine compt) s135
• (engine control sensor harn, near breakout to left rear of engine compt) s142
• (left side of engine compt)
• (not used)
• (stripped chassis) s127
• (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• 4x4 lo
• A/c system, exterior lights system
• Accelerator pedal position (app) sensor (behind left side of dash, above accel pedal)
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• C175a
• Can +
• Can -
• Canister vent
• Central junction box (behind left side of dash)
• Cluster pwr
• Cruise control system
• Cto
• Evap canister vent valve (left rear of vehicle, near fuel tank)
• Exterior lights system
• Ftp sensor
• Fuel pump rly
• Fuel tank pressure transducer sensor (in tank)
• Fuse 10a
• Fuse 30a
• G100
• G104
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Heated oxygen sensor (ho2s) 23 (right rear of vehicle)
• Ho2s 23 htr
• Ho2s 23 input
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Nca
• Overhead console (if equipped)
• P/n
• Park out
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Programming sig
• Pto engage
• Pto ind
• Pto mode
• Pto rpm
• Red
• Red/pnk
• Ref voltage
• Reverse lmp relay
• S1021
• S1033
• S1065 (except stripped chassis)
• S157
• S172
• Signal return
• Speed control sw
• Starter relay
• Starting system
• Tan
• Tcil ctrl
• Tow/haul sw
• Vem system in
• Vss +

5.4L, Engine Performance Wiring Diagram, without Torqshift (1 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, without Torqshift (1 of 5) for Ford Econoline E150 2005:

• (engine control sensor harn, near breakout to left rear of engine)
• A/c clutch rly
• A/c press sw
• A/c system
• Brake pressure sw
• C175b
• Ckp sensor +
• Ckp sensor -
• Cmp sensor sig
• Coil on plug
• Coil on plug 1
• Coil on plug 2
• Coil on plug 3
• Coil on plug 4
• Coil on plug 5
• Coil on plug 6
• Coil on plug 7
• Coil on plug 8
• Crankshaft position sensor (lower center front of engine)
• Cyl head temp
• Differential pressure feedback egr sensor (top left side of engine)
• Dpfe sensor
• Egr vacuum regulator solenoid (above left rear of engine
• Egv cntrl
• Electronic throttle control (etc) motor (top right front of engine)
• Etc return
• Etc wot cntrl
• Evap purge valve
• Fuel inj 1
• Fuel inj 2
• Fuel inj 3
• Fuel inj 4
• Fuel inj 5
• Fuel inj 6
• Fuel inj 7
• Fuel inj 8
• Fuel rail temp sens
• Ho2s 11 htr
• Ho2s 11 input
• Ho2s 21 htr
• Ho2s 21 input
• Iat sensor
• Ignition transformer capacitor 1 (right front of engine)
• Ignition transformer capacitor 2 (left front of engine)
• Inj press regulator
• Injection pressure & temperature sensor (front of left cylinder bank)
• Knock sensor (top right rear side of engine)
• Knock sensor +
• Knock sensor -
• Maf sensor
• Nca
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Red
• Red/pnk
• Reference voltage
• S136
• S156
• S158
• S161
• Shield drain
• Signal return
• Tan
• Tan/red
• Throttle position sensor (top of engine, near air intake)
• Tps 2 sig
• Tps output
• Tps sig
• Tps sig return

5.4L, Engine Performance Wiring Diagram, without Torqshift (2 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, without Torqshift (2 of 5) for Ford Econoline E150 2005:

• (at center of engine compt) mass air flow (maf) sensor
• (engine control sensor harn, near breakout to left side of engine compt) s155
• (engine control sensor harn, right side of engine)
• (engine ctrl sensor harn, near break- out to left rear of engine compt)
• (left rear of engine) evap canister purge valve
• (left side of engine compt) brake pressure switch
• Battery junction box (left side of engine compt)
• Camshaft position sensor (front of left cyl head)
• Cylinder head temperature sensor (top front of left cyl head)
• Fuel injectors
• Fuse 2a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Heated oxygen sensor (ho2s) 11 (right rear of engine)
• Heated oxygen sensor (ho2s) 21 (left rear of engine)
• Nca
• Red
• S159
• S160
• Tan
• Tan/red

5.4L, Engine Performance Wiring Diagram, without Torqshift (3 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, without Torqshift (3 of 5) for Ford Econoline E150 2005:

• (at left side of transmission) digital transmission range (dtr) sensor
• (at rear of transmission) output shaft speed (oss) sensor
• (left side of transmission) turbine shaft speed (tss) sensor
• (near breakout to center rear of transmission)
• 4r70e/4r75e transmission
• C175c
• Dtr tr1
• Dtr tr2
• Dtr tr3a
• Dtr tr4
• Electronic pressure control solenoid
• Epc sol
• Ho2s 12 htr
• Ho2s 12 input
• Ho2s 22 htr
• Ho2s 22 input
• Oss sig
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Press ctrl sol
• Red
• S198
• Shift sol a
• Shift sol b
• Shift solenoids
• Tft sensor sig
• Torque converter clutch solenoid
• Tr-p ground
• Tr1
• Tr2
• Tr3
• Tr4
• Transmission fluid temperature sensor
• Tss sensor

5.4L, Engine Performance Wiring Diagram, without Torqshift (4 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, without Torqshift (4 of 5) for Ford Econoline E150 2005:

• (except stripped chassis: at right kick panel) (stripped chassis: behind left side of dash) inertia fuel shut- off switch
• (transmission harn, near breakout to c192) s102
• (transmission harn, near breakout to center rear of transmission)
• (under rear of vehicle, near tank) fuel pump driver module
• (window regulator relay harn, near breakout to steering column)
• Battery junction box (left side of engine compt)
• Brake pedal position switch (above brake pedal)
• Bus +
• Bus -
• Central junction box (behind left side of dash)
• Data link connector (below left side of dash)
• Fuel lvl
• Fuel pump
• Fuel pump relay
• Fuse 10a
• Fuse 15a
• Fuse 20a
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• G302 (left rear under- body of vehicle)
• Heated oxygen sensor (ho2s) 12 (left of transmission)
• Heated oxygen sensor (ho2s) 22 (right of transmission)
• Hot at all times
• Hot in run or start
• Instrument cluster
• Malfunction indicator lamp
• Nca
• O/d off
• Overdrive cancel switch
• Red
• S100
• S172
• S174 (engine control harn, in breakout to c110)
• S216
• S228 (main harn, near breakout to left side of dash)
• S269
• Vref

5.4L, Engine Performance Wiring Diagram, without Torqshift (5 of 5) for Ford Econoline E150 2005

List of elements for 5.4L, Engine Performance Wiring Diagram, without Torqshift (5 of 5) for Ford Econoline E150 2005:

• (behind left side of dash, above accelerator pedal) accelerator pedal position (app) sensor
• (ends in harness)
• (left side of engine compt)
• (not used)
• (stripped chassis) s127
• A/c system, exterior lights system
• App sensor 2 pwr
• App sensor 2 rtn
• App sensor 2 sig
• App sensor 3 pwr
• App sensor 3 rtn
• App sensor 3 sig
• Battery junction box (left side of engine compt)
• Bpp sw
• C175a
• C237
• Can +
• Can -
• Canister vent
• Central junction box (behind left side of dash)
• Cluster pwr
• Cruise control system
• Evap canister vent valve (left rear of vehicle, near fuel tank)
• Ftp sensor
• Fuel pump rly
• Fuel tank pressure transducer sensor (in tank)
• Fuse 10a
• Fuse 30a
• G100
• G104 (stripped chassis: right side of engine compt) (except stripped chassis: left side of engine compt)
• Ground
• Hot at all times
• Hot in run or start
• Ignition (st/run)
• Od cancel sw
• Pcm ap sensor
• Pcm power diode
• Pcm power relay
• Powertrain control module (left rear of engine compt, near brake master cylinder)
• Programming sig
• Red
• Red/pnk
• Ref voltage
• S1021
• S1033
• S1065 (except stripped chassis)
• S135 (engine control harn, near breakout to left rear of engine compt)
• S142 (engine control sensor harn, near breakout to left rear of engine compt)
• S172
• Signal return
• Speed control sw
• Tach sig
• Tan
• Tcil ctrl
• Vem system in
• Vss +